2009 Toyota RAV4
Problems, recalls and owner-reported issues
Vehicle speed control is the leading concern among 327 owner complaints filed for this model year. This is the 10th highest complaint count among 26 RAV4 model years with reports.
Of the 2009 reports, 52 involved a crash and 3 involved a fire. 16 people were injured.
What owners report most often
Recalls and investigations
Suspension, rearAug 12, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2011 Toyota RAV4 vehicles manufactured October 31, 2005, to September 7, 2010, and 2010 Lexus HS250h vehicles manufactured July 6, 2009, to August 26, 2010. The affected vehicles have rear suspension arms (rear tie rods) with adjusting lock nuts that may have been improperly tightened after servicing. As a result of being loose, the arm may have thread damage and may rust, possibly leading to the failure of the arm and an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners and dealers will replace both rear suspension arms and encapsulate the locknuts, free of charge. The recall began on September 30, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are G0V for Toyota vehicles and GLK for Lexus vehicles. Note: This recall supersedes recall 13V-383, in which some vehicles were only inspected, sealed, and did not have both arms replaced. The affected vehicles were previously recalled under 13V-383, but did not have both rear suspension arms replaced at that time. Those vehicles need to have both arms replaced as part of this recall remedy.
Campaign 16V596000 on NHTSA.gov
Seats, front assembly, seat heater/coolerJun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Campaign 16V396000 on NHTSA.gov
Seat belts, rear/otherFeb 19, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2012 RAV4 vehicles manufactured July 28, 2005, to December 19, 2012, and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the event of a frontal collision, the rear seat belts for the outboard seats may be cut by the seat cushion frame.
A cut seat belt may not properly restrain the seat occupant, increasing their risk of injury in a crash.
Toyota will notify owners, and dealers will install a protector over both rear seat cushion frames, free of charge. The recall began on June 24, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G0F.
Campaign 16V096000 on NHTSA.gov
Visibility, power window devices and controlsOct 22, 2015
Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.
If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.
Campaign 15V689000 on NHTSA.gov
Visibility/wiperSep 18, 2015
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2009-2012 RAV4 vehicles manufactured October 27, 2008, to December 19, 2012 and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the affected vehicles, water may drip onto the joint that connects the wiper linkage to the wiper motor.
Over time, the dripping water may cause corrosion and wear at the joint, potentially resulting in the separation of the wiper linkage. Once this occurs, the wipers would not function, reducing driver visibility and increasing the risk of a crash.
Toyota will notify owners, and dealers will replace the water diverter channel. In addition, a new wiper linkage with a wiper motor crank arm will be installed. The wiper linkage will have a protective cover over the wiper linkage joint to minimize water splash and a retainer ring to prevent the wiper arm from separating from the wiper motor. The recall began on November 7, 2016. Owners may contact Toyota's customer service number at 1-800-331-4331.
Campaign 15V577000 on NHTSA.gov
Seats, front assembly, seat heater/coolerNov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Campaign 14V743000 on NHTSA.gov
Suspension, rearAug 28, 2013
Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners, and dealers will inspect the tie rods and replace any that have rust or corrosion on the alignment adjustment threads. All of the rear tie rods will then be encased in an epoxy to prevent future environmental damage. Due to limitations in parts, the recall remedy will be launched in phases from September 2013 through mid-April 2014. All owners will receive notification of the recall, with most receiving second notifications when parts are available in their area. IMPORTANT: This recall supersedes Toyota and Lexus recall 12V-373. All vehicles that have been inspected and remedied under the previous recall need to be re-inspected and have the appropriate remedy applied.
Campaign 13V383000 on NHTSA.gov
Air bags, frontal, sensor/control module-inactiveJan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Campaign 13V014000 on NHTSA.gov
Visibility, power window devices and controlsOct 10, 2012
Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. Irregularities in this lubrication process may cause the power window master switch assemblies to malfunction and overheat.
If the switch overheats, it may melt, possibly resulting in a fire.
Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. Toyota owners that experience a problem with a switch should not attempt to make repairs, but should contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331. General Motors will contact the Pontiac Vibe owners affected by this recall and GM dealers will inspect and repair switches as necessary. Those owners may contact Pontiac Customer Care at 1-800-762-2737.
Campaign 12V491000 on NHTSA.gov
Suspension, rearAug 2, 2012
Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust, leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners, and dealers will inspect the rear tie-rod nut for looseness and replace any suspect tie-rod found loose. Dealers will also affix instructions in multiple places to prevent improper servicing in the future. The recall began on November 30, 2012. Owners may contact Toyota at 1-800-331-4331 or Lexus at 1-800-255-3987.
Campaign 12V373000 on NHTSA.gov
Vehicle speed control, accelerator pedalFeb 24, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 LEXUS LX570, 2003 THROUGH 2009 TOYOTA 4RUNNER, AND 2006 THROUGH 2010 RAV4 VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
THE REMEDY IS NOW AVAILABLE. THE SAFETY RECALL BEGAN EARLY APRIL 2011. THE REMEDY WILL INVOLVE MODIFICATION OR REPLACEMENT OF THE ACCELERATOR PEDAL AND REPLACEMENT OF ANY TOYOTA ALL-WEATHER FLOOR MAT. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.
Campaign 11V113000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Campaign 10V036000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Campaign 10V035000 on NHTSA.gov
Vehicle speed control, accelerator pedalJan 21, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 AVALON, MODEL YEAR 2007-2010 CAMRY, MODEL YEAR 2009-2010 COROLLA, COROLLA MATRIX, RAV4, MODEL YEAR 2010 HIGHLANDER, MODEL YEAR 2008-2010 SEQUOIA, AND MODEL YEAR 2007-2010 TUNDRA VEHICLES. DUE TO THE MANNER IN WHICH THE FRICTION LEVER INTERACTS WITH THE SLIDING SURFACE OF THE ACCELERATOR PEDAL INSIDE THE PEDAL SENSOR ASSEMBLY, THE SLIDING SURFACE OF THE LEVER MAY BECOME SMOOTH DURING VEHICLE OPERATION. IN THIS CONDITION, IF CONDENSATION OCCURS ON THE SURFACE, AS MAY OCCUR FROM HEATER OPERATION (WITHOUT A/C) WHEN THE PEDAL ASSEMBLY IS COLD, THE FRICTION WHEN THE ACCELERATOR PEDAL IS OPERATED MAY INCREASE, WHICH MAY RESULT IN THE ACCELERATOR PEDAL BECOMING HARDER TO DEPRESS, SLOWER TO RETURN, OR, IN THE WORST CASE, MECHANICALLY STUCK IN A PARTIALLY DEPRESSED POSITION.
THE ACCELERATOR PEDAL MAY BECOME HARD TO DEPRESS, SLOW TO RETURN TO IDLE, OR, IN THE WORST CASE, MECHANICALLY STUCK IN A PARTIALLY DEPRESSED POSITION, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSTALL A REINFORCEMENT BAR IN THE ACCELERATOR PEDAL WHICH WILL ALLOW THE PEDAL TO OPERATE SMOOTHLY. GM WILL NOTIFY OWNERS FOR THE PONTIAC VIBE PLEASE SEE 10V-018. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON FEBRUARY 5, 2010 AND WILL BE COMPLETED ON MARCH 15, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 10V017000 on NHTSA.gov
Equipment, other, labelsJun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Campaign 09V223000 on NHTSA.gov
Representative owner complaints
327 reports, newest first.
Steering, Dec 6, 2016
TL* THE CONTACT OWNS A 2009 TOYOTA RAV4. WHILE DRIVING ON A BUMPY ROAD OR MAKING A LEFT OR RIGHT TURN, THE STEERING WHEEL MADE A KNOCKING NOISE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE STEERING RACK WAS LEAKING FLUID AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 108,192.
Suspension, Oct 24, 2016
TL* THE CONTACT OWNS A 2009 TOYOTA RAV4. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V596000 (SUSPENSION); HOWEVER, THE PART FOR THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE MANUFACTURER STATED THAT THE PARTS WERE ON BACK ORDER AND THERE WAS NO ESTIMATED TIME FRAME FOR THEIR AVAILABILITY. PARTS DISTRIBUTION DISCONNECT.
Suspension, Sep 24, 2016
WE HAVE TAKEN IT TO THE TOYOTA DEALER TWICE AND HAD THEM REPLACE THE TIE RODS TWICE AND IT WON'T STAY IN ALIGNMENT. I HAVE CALLED THE DEALER MULTIPLE TIMES TO SCHEDULE IT TO BE FIXED AND CALLED CORPORATE AND THEY WON'T DO MUCH AND IT WON'T STAY IN ALIGNMENT AND THEY WON'T FIX IT RIGHT. THE CAR IS VERY SCARY TO DRIVE WITH IT BEING OUT OF ALIGNMENT AND NO OTHER MECHANIC WILL TOUCH IT BECAUSE THEY HAVE A STICKER SAYING IT CAN ONLY BE ADJUSTED BY TOYOTA BECAUSE THEY GLUE THE TIE RODS IN PLACE. TOYOTA SAID IF WE HAVE REPLACED BY AN OUTSIDE SOURCE BECAUSE THE DEALER WON'T CALL US BACK THEY WILL NOT HELP COVER IT. THEY WON'T ALLOW US TO GO TO ANOTHER DEALER AS WELL.
Air bags, Sep 21, 2016, crash
TL* THE CONTACT OWNS A 2009 TOYOTA RAV4. WHILE DRIVING 45 MPH, THE CONTACT'S VEHICLE CRASHED INTO ANOTHER VEHICLE. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 105,040.
Engine, Sep 14, 2016
TL* THE CONTACT OWNS A 2009 TOYOTA RAV4. THE CONTACT STATED THAT WHEN THE VEHICLE WAS STARTED THERE WAS A LOUD NOISE COMING FROM THE ENGINE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE TIMING PINION NEEDED REPLACEMENT. THE CONTACT ALSO STATED THAT THE SAME FAILURE OCCURRED THREE OTHER TIMES. THE VEHICLE WAS REPAIRED UNDER WARRANTY. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 81,300.
Other or unspecified, Sep 8, 2016, crash
I PUT MY RAV 4 2009 IN PARK WHILE RUNNING AND GOT OUT OF THE CAR AND TALKED TO MY MAIL CARRIER, WENT AROUND MY CAR TO MY MAILBOX AND ALL OF A SUDDEN, MY CAR TOOK OFF ACCELERATING AND BACKED OUT OF THE DRIVEWAY, I TRIED TO GET THE CAR BUT IT WAS MOVING TOO FAST IT HIT A TREE. NOW I KEEP IT IN ER BRAKE WHEN I GET OUT. TOYOTA DEALERS CLAIM THEY CANNOT CHECK TO SEE WHAT HAPPENED. I AM SORRY AS TO WHAT TO DO, I HAD A WITNESS TO THIS INCIDENT I AM AFRAID OF MY OWN CAR, I DO NOT KNOW WHEN IT WILL DO IT AGAIN. WAS TOLD I SHOULD BE GLAD I DID NOT GET RUN OVER WHEN I WALKED BEHIND IT.
Wheels, Sep 1, 2016
STUDS THAT THE LUG NUTS ARE SCREWED ON TO HAVE DETERIORATED. I JUST HAD MY TIRES ROTATED AND MY MECHANIC TOLD ME THAT THE NEXT TIME I ROTATE THE TIRES, THE STUDS WILL BREAK OFF. I ROTATE MY TIRES EVERY 6000 MILES
Structure, Aug 30, 2016
PAINT PEELING ON ROOF OF 2009 RAV4 TOYOTA, MANUFACTURING DEFECT THAT TOYOTA WILL NOT REPAIR.
Power train, Engine, Aug 13, 2016
WHEN CAR IS AT 1500 RPM AT 40 MPH, THE TRANSMISSION VIBRATES AND THRUSTS. NOISE GOES AWAY IF ABOVE 2000 RPM OR ABOVE 40 MPH. IT'S TOYOTA OF MANCHESTER NH HAS BEEN ABLE TO REPRODUCE. WAITING TO SEE IF TOYOTA WILL DO ANYTHING.
Seat belts, Aug 9, 2016
THE SHOULDER SEATBELTS IN ONE OF THE SECOND-ROW OUTBOARD SEATS WAS TOTALLY BROKEN BY THE FRICTION OF A METAL ON THE SHOULDER RETRACTOR END. I RECEIVED A RECALL FOR REPAIR THE LAP SEATBELTS FOR THE SAME PROBLEM BUT NOT INCLUDE THE SHOULDER END. HE BROKE WHEN THE CAR WAS STOPPED AND THE PASSENGER TRIED TO BELT .
Seat belts, Aug 8, 2016
A RECALL WAS ISSUED ON FEBRUARY 17, 2016 FOR THE REAR, OUTBOARD SEAT BELTS. AS OF AUGUST 8, 2016 THE MANUFACTURE HAS YET TO ADDRESS THIS DEFECT.
Seats, Other or unspecified, Jul 28, 2016
MY RAV4 HAS RUST ALL OVER WHERE THE DRIVERS SEAT AS WELL AS THE PASSENGER SEATS ARE ATTACHED TO THE CAR AND SEEMS TO BE SO FRAGILE THAT WITH ANY SMALL IMPACT THE SEAT WILL DETACHED FROM CAR AND CAUSE A TRAGIC ACCIDENT. THE RUST APPEARED ALMOST IMMEDIATELY AFTER IT WAS PURCHASED AND WAS ADVISED BY DEALERSHIP THAT THERE WAS NOTHING THEY CAN DO ABOUT IT . IF THIS ISSUE IS NOT FIXED IN THE FUTURE IT CAN CAUSE INJURIES OR EVEN DEATH.
Seat belts, Jun 6, 2016
TL* THE CONTACT OWNS A 2009 TOYOTA RAV4. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V096000 (SEAT BELTS). THE PART NEEDED FOR THE REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PART NOT AVAILABLE.
Vehicle speed control, Jun 1, 2016, crash
TL* THE CONTACT OWNS A 2009 TOYOTA RAV4. THE CONTACT STATED THAT WHILE REVERSING AT APPROXIMATELY 5 MPH, THE VEHICLE INDEPENDENTLY ACCELERATED WITHOUT WARNING. THE VEHICLE WAS ABLE TO BE STOPPED. ON ANOTHER OCCASION, THE CONTACT STATED THAT AFTER SWITCHING INTO THE DRIVE POSITION, THE VEHICLE SUDDENLY ACCELERATED WITHOUT WARNING. AS A RESULT, THE CONTACT CRASHED INTO A TREE. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS NOT FILED. THE CONTACT SUSTAINED NECK AND BACK INJURIES THAT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS NOT DIAGNOSED HOWEVER, THE BODY DAMAGE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 47,000.
Steering, May 26, 2016
AT 47,500 MILES, STEERING STARTED MAKING A CLUNKING NOISE WHEN WHEEL TURNED ALL THE WAY TO ONE SIDE OR THE OTHER. USUALLY IT OCCURRED WHEN TURNING THE WHEEL BACK TO CENTER BUT NOT ALWAYS. TENDED T HAPPEN IN A PARKING LOT OR WHEN A SHARP TURN WAS REQUIRED. DEALER REPAIRED AT A COST OF ALMOST $700. CAR WAS UNSAFE TO DRIVE WITHOUT REPAIR. (COST OF REPAIR COVERED UNDER EXTENDED SERVICE PLAN WHICH WAS PURCHASED WHEN CAR WAS PURCHASED.) THIS TYPE OF SERIOUS SAFETY ISSUE SHOULD NOT HAPPEN AT UNDER 50,000 MILES OR EVEN EVER.
Vehicle speed control, Apr 5, 2016, crash
TL* THE CONTACT OWNS A 2009 TOYOTA RAV4. WHILE COMING TO A STOP AND PLACING THE VEHICLE IN PARK, THE VEHICLE ACCELERATED INDEPENDENTLY ONCE THE BRAKE PEDAL WAS RELEASED. THE VEHICLE CRASHED INTO A BUILDING. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE CAUSE OF THE FAILURE WAS UNDETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 90,000.
Suspension, Mar 18, 2016
I HAVE HAD SEVERAL ISSUE WITH THE RV4, ALL RELATED TO THE REAR SUSPENSION. THE RECAL FOR TOYOA WITH PART OF THE SUSPENSION LEAKSUNBOLTED FROM THE CAR WHILE TRAVELING AT ABOUT 30 MPH. THE RIGHT REAR TIRE WENT UP IN TO THE WHEEL WELL. ONLY BECAUSE OF THE SLOW SPEED DID I NOT GET IN TO AN ACCIDENT. VEHICLE HAD TO BE TOWED TO THE DEALER. AT 65K MILES, I TOOK THE CAR IN AGAIN TO THE SHOP. BOTH REAR LINKAGES TO THE ANTI-SWAY BAR WERE BROKEN AND HAD TO BE REPLACED. AGAIN ANOTHER ISSUE WITH THE REAR SUSPENSION.
Other or unspecified, Feb 21, 2016
THE DRIVER'S SIDE SUN VISOR FLOPS DOWN AND WON'T STAY UP. THIS RESULTS IN IMPAIRED VISION AND CAN STARTLE A DRIVER INTO LOSING CONTROL OF THE VEHICLE.
Suspension, Feb 19, 2016
REAR SUSPENSION ARMS WERE REPLACED DUE TO A RECALL. IT WAS FOUND A YEAR LATER, THAT THE REAR TIRES WERE OUT OF ALIGNMENT. DURING THIS TIME, THE HANDLING OF THE CAR ON TURNS AND IN WET WEATHER WERE IMPAIRED. ALSO, THE TIRES WORE UNEVENLY AND WERE BALD ON THE INSIDE. I FOUND OUT, THAT THE RECALL FIX REPLACED THE ORIGINAL ADJUSTABLE ARMS WITH NON-ADJUSTABLE ARMS AND THE CAR COULD NOT BE ALIGNED. TOYOTA WANTED $830 TO REPLACE THE ARMS AGAIN IN ORDER TO ALIGN IT. THIS WOULD MEAN EVERY TIME THE CAR NEEDED AN ALIGNMENT OF THE REAR WHEELS, NEW REAR ARMS WOULD HAVE TO BE PURCHASED. THAT CAR HAS BEEN ALTERED FROM THE ORIGINAL DESIGN TO THE ADVANTAGE OF TOYOTA. ..UPDATED 03/10/16 *BF
Vehicle speed control, Feb 5, 2016, crash
TL* THE CONTACT OWNS A 2009 TOYOTA RAV4. WHILE EXITING A FUEL STATION AND ATTEMPTING TO DEPRESS THE BRAKE PEDAL, THE CONTACT'S FOOT BECAME TRAPPED BETWEEN THE RUG AND THE ACCELERATOR PEDAL. THE VEHICLE ACCELERATED AND CRASHED INTO ANOTHER VEHICLE. THERE WERE NO INJURIES AND A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE THE DAMAGE WAS REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 11V113000 (VEHICLE SPEED CONTROL). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 76,000.
Steering, Jan 28, 2016
WHEN TURNING THE STEERING WHEEL EITHER DIRECTION AT LOW SPEEDS A CLUNKING NOISE WAS AUDIBLE. CAR HAS ONLY 50,000 MILES. LOOKED ON INTERNET AND FOUND HUNDREDS OF REPORTS OF THE PROBLEM IN MULTIPLE MODELS AND OVER MANY YEARS. THE CAUSE IS THE STEERING COLUMN SHAFT. TOOK IT TO DEALER AND THAT WAS EXACTLY THE PROBLEM! $600 TO REPAIR ! FURTHER RESEARCH INDICATES THAT JAPAN HAS RECALLED THESE CARS FOR THIS REASON ALREADY. RECALL THESE CARS NOW!! STEERING FAILURE CAN EVENTUALLY HAPPEN!!
Service brakes, Jan 17, 2016
PARKING/EMERGENCY BRAKE BECAME INOPERATIVE. INVESTIGATION REVEALED THAT BOTH BRAKE CABLES HAD CORRODED SUCH THAT THEY NO LONGER HAD FREEDOM OF MOVEMENT AT THE CABLE END WHERE THEY ENTERED THE BACKING PLATES. WHEN I PURCHASED REPLACEMENT CABLES TOYOTA SERVICE TECHNICIAN COMMENTED THAT THIS WAS A COMMON PROBLEM ON RAV 4, TACOMA, AND OTHER (DON'T REMEMBER) TOYOTA VEHICLES. WHEN I PURCHASED & EXAMINED REPLACEMENT CABLES DURING REPAIR IT WAS APPARENT THAT NEW CABLE DESIGN WAS SIGNIFICANTLY DIFFERENT IN EXACTLY THE PLACE WHERE OLD CABLES HAD FAILED. THIS WAS A SAFETY PROBLEM DURING TIME PERIOD WHEN BRAKES WERE INOPERATIVE AND CLEARLY A SIGNIFICANT DESIGN FLAW. IT WAS ~ $400 IN PARTS + MY LABOR TP REPLACE THE CABLES AS PART OF REPAIRING THE EMERGENCY/PARKING.
Other or unspecified, Nov 17, 2015
WAS DRIVING,SUDDEN LOST P/S, ALL LIGHTS ON DASH CAME ON, DETERMINED FUSE ECU-IG1, BLOWN, DETERMINED, WHEN REAR VIEW MIRROR DISCONN. THE FUSE DOESN'T BLOW.TSB:IG1 RELAY NEEDS 2B UPDATED $1,000+ VEHICLE WAS IN MOTION ON A COUNTY STREET.....UPDATED 12/03/15*BF *CN
Engine, Sep 18, 2015
WHENEVER WE ARE TRAVELING ABOUT 40 MPH AND 1500 RPM, THERE IS A RATTLE NOISE. THE VIBRATION HOLDS FOR AS LONG AS 1-2 SECONDS. AS SOON AS THE VIBRATION STARTS, YOU CAN LET OFF THE GAS OR STEP ON THE GAS TO CHANGE THE RPMS AND IT INSTANTLY STOPS. THE CAR HAS BEEN MAKING THIS SOUND SINCE SHORTLY AFTER WE BOUGHT IT BRAND NEW. NOW WE'RE BEING TOLD THAT IT'S A TRANSMISSION FAILURE. THE TORQUE CONVERTER IS THE ROUTE IF THE PROBLEM. AT 1500 RPM AND 38-40 MPH THE TORQUE CONVERTER IN THE TRANSFER CASE IS VIBRATING, CAUSING THE HEAT SHIELD TO RATTLE BECAUSE OF THE TRANSFER OF VIBRATIONS. IT JUST SEEMS LIKE WE'VE HAD A FAULTY TRANSMISSION ALL ALONG.
Electrical system, Sep 16, 2015
TL* THE CONTACT OWNS A 2009 TOYOTA RAV4. THE CONTACT STATED THAT THE WIRE HARNESS WIRING WAS BEING DAMAGED BY ANIMALS BITING THE WIRING. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING, BUT IT WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND PROVIDED NO REMEDY. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 7,000.