2010 Toyota RAV4
Problems, recalls and owner-reported issues
Suspension is the leading concern among 400 owner complaints filed for this model year. This is the 7th highest complaint count among 26 RAV4 model years with reports.
Of the 2010 reports, 57 involved a crash and 3 involved a fire. 27 people were injured.
What owners report most often
Recalls and investigations
Suspension, rearAug 12, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2011 Toyota RAV4 vehicles manufactured October 31, 2005, to September 7, 2010, and 2010 Lexus HS250h vehicles manufactured July 6, 2009, to August 26, 2010. The affected vehicles have rear suspension arms (rear tie rods) with adjusting lock nuts that may have been improperly tightened after servicing. As a result of being loose, the arm may have thread damage and may rust, possibly leading to the failure of the arm and an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners and dealers will replace both rear suspension arms and encapsulate the locknuts, free of charge. The recall began on September 30, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are G0V for Toyota vehicles and GLK for Lexus vehicles. Note: This recall supersedes recall 13V-383, in which some vehicles were only inspected, sealed, and did not have both arms replaced. The affected vehicles were previously recalled under 13V-383, but did not have both rear suspension arms replaced at that time. Those vehicles need to have both arms replaced as part of this recall remedy.
Campaign 16V596000 on NHTSA.gov
Seats, front assembly, seat heater/coolerJun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Campaign 16V396000 on NHTSA.gov
Seat belts, rear/otherFeb 19, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2012 RAV4 vehicles manufactured July 28, 2005, to December 19, 2012, and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the event of a frontal collision, the rear seat belts for the outboard seats may be cut by the seat cushion frame.
A cut seat belt may not properly restrain the seat occupant, increasing their risk of injury in a crash.
Toyota will notify owners, and dealers will install a protector over both rear seat cushion frames, free of charge. The recall began on June 24, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G0F.
Campaign 16V096000 on NHTSA.gov
Visibility, power window devices and controlsOct 22, 2015
Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.
If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.
Campaign 15V689000 on NHTSA.gov
Visibility/wiperSep 18, 2015
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2009-2012 RAV4 vehicles manufactured October 27, 2008, to December 19, 2012 and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the affected vehicles, water may drip onto the joint that connects the wiper linkage to the wiper motor.
Over time, the dripping water may cause corrosion and wear at the joint, potentially resulting in the separation of the wiper linkage. Once this occurs, the wipers would not function, reducing driver visibility and increasing the risk of a crash.
Toyota will notify owners, and dealers will replace the water diverter channel. In addition, a new wiper linkage with a wiper motor crank arm will be installed. The wiper linkage will have a protective cover over the wiper linkage joint to minimize water splash and a retainer ring to prevent the wiper arm from separating from the wiper motor. The recall began on November 7, 2016. Owners may contact Toyota's customer service number at 1-800-331-4331.
Campaign 15V577000 on NHTSA.gov
Seats, front assembly, seat heater/coolerNov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Campaign 14V743000 on NHTSA.gov
Suspension, rearAug 28, 2013
Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners, and dealers will inspect the tie rods and replace any that have rust or corrosion on the alignment adjustment threads. All of the rear tie rods will then be encased in an epoxy to prevent future environmental damage. Due to limitations in parts, the recall remedy will be launched in phases from September 2013 through mid-April 2014. All owners will receive notification of the recall, with most receiving second notifications when parts are available in their area. IMPORTANT: This recall supersedes Toyota and Lexus recall 12V-373. All vehicles that have been inspected and remedied under the previous recall need to be re-inspected and have the appropriate remedy applied.
Campaign 13V383000 on NHTSA.gov
Equipment, other, labelsApr 9, 2013
Southeast Toyota is recalling certain model year 2008 and 2010-2013 Toyota Tundra, 2010-2012 Rav4, 2012 Toyota Sequoia, 2010-2011 Toyota Corolla, 2010-2011 Toyota Camry and Camry Hybrid, 2010-2013 Toyota Highlander and Highlander Hybrid, 2010-2013 Toyota FJ Cruiser, 2011 Toyota Land Cruiser, 2010-2013 Toyota Venza, 2010-2011 Toyota 4Runner, 2010-2013 Toyota Tacoma, 2011-2012 Toyota Sienna, 2012 Toyota Prius, 2013 Scion FR-S, 2011 Scion XD, 2011 Scion XB, and 2012 Scion TC vehicles. These vehicles were sold with labels that were outside the allowable one percent of accuracy of actual weight added. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) Number 110, "Tire Selection and Rims."
An inaccurate label could lead to owners overloading their vehicles and tires. An overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.
Southeast Toyota will notify owners and provide a corrected label with instructions concerning its installation. A small group of the affected vehicles will need additonal remedies which are still being developed. The recall began on May 28, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Campaign 13V123000 on NHTSA.gov
Air bags, frontal, sensor/control module-inactiveJan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Campaign 13V014000 on NHTSA.gov
Suspension, rearAug 2, 2012
Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust, leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners, and dealers will inspect the rear tie-rod nut for looseness and replace any suspect tie-rod found loose. Dealers will also affix instructions in multiple places to prevent improper servicing in the future. The recall began on November 30, 2012. Owners may contact Toyota at 1-800-331-4331 or Lexus at 1-800-255-3987.
Campaign 12V373000 on NHTSA.gov
Vehicle speed control, accelerator pedalFeb 24, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 LEXUS LX570, 2003 THROUGH 2009 TOYOTA 4RUNNER, AND 2006 THROUGH 2010 RAV4 VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
THE REMEDY IS NOW AVAILABLE. THE SAFETY RECALL BEGAN EARLY APRIL 2011. THE REMEDY WILL INVOLVE MODIFICATION OR REPLACEMENT OF THE ACCELERATOR PEDAL AND REPLACEMENT OF ANY TOYOTA ALL-WEATHER FLOOR MAT. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.
Campaign 11V113000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Campaign 10V036000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Campaign 10V035000 on NHTSA.gov
Vehicle speed control, accelerator pedalJan 21, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 AVALON, MODEL YEAR 2007-2010 CAMRY, MODEL YEAR 2009-2010 COROLLA, COROLLA MATRIX, RAV4, MODEL YEAR 2010 HIGHLANDER, MODEL YEAR 2008-2010 SEQUOIA, AND MODEL YEAR 2007-2010 TUNDRA VEHICLES. DUE TO THE MANNER IN WHICH THE FRICTION LEVER INTERACTS WITH THE SLIDING SURFACE OF THE ACCELERATOR PEDAL INSIDE THE PEDAL SENSOR ASSEMBLY, THE SLIDING SURFACE OF THE LEVER MAY BECOME SMOOTH DURING VEHICLE OPERATION. IN THIS CONDITION, IF CONDENSATION OCCURS ON THE SURFACE, AS MAY OCCUR FROM HEATER OPERATION (WITHOUT A/C) WHEN THE PEDAL ASSEMBLY IS COLD, THE FRICTION WHEN THE ACCELERATOR PEDAL IS OPERATED MAY INCREASE, WHICH MAY RESULT IN THE ACCELERATOR PEDAL BECOMING HARDER TO DEPRESS, SLOWER TO RETURN, OR, IN THE WORST CASE, MECHANICALLY STUCK IN A PARTIALLY DEPRESSED POSITION.
THE ACCELERATOR PEDAL MAY BECOME HARD TO DEPRESS, SLOW TO RETURN TO IDLE, OR, IN THE WORST CASE, MECHANICALLY STUCK IN A PARTIALLY DEPRESSED POSITION, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSTALL A REINFORCEMENT BAR IN THE ACCELERATOR PEDAL WHICH WILL ALLOW THE PEDAL TO OPERATE SMOOTHLY. GM WILL NOTIFY OWNERS FOR THE PONTIAC VIBE PLEASE SEE 10V-018. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON FEBRUARY 5, 2010 AND WILL BE COMPLETED ON MARCH 15, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 10V017000 on NHTSA.gov
Representative owner complaints
400 reports, newest first.
Wheels, Jan 24, 2019
THEY DID A RECALL ON MY VEHICLE AND IT WAS ABOUT A BOLT RUSTING ON THE BACKEND NEAR THE REAR TIRE SO THE FIX WAS TO PROTECT A BOLT. THEY PUT SOME BAR ON THE BACK SIDE NEAR THE REAR TIRE THAT MADE IT WHERE I HAVE NOT BEEN ABLE TO GET MY BACK END OF THE CAR ALIGNED SINCE. CAUSING MY TIRES TO KEEP GETTING BUBBLES IN THEM. THIS HAPPENS TO EVERY SET I GET AND I HAVE BEEN TOLD THAT THEY CANNOT FIX THE REAR ALIGNMENT BECAUSE OF THE RECALL. THIS FIGHT HAS GONE ON FOR YEARS. ALL TOYOTA SAYS IS THEY WERE ONLY REQUIRED TO FIX THE RECALL ....IN OTHER WORDS THEY DO NOT CARE ABOUT THE ALIGNMENT ISSUE. PLEASE HELP ME. I HAVE THE REPORT FROM THE LAST ATTEMPTED ALIGNMENT SHOWING HOW OUT OF ALIGNMENT THE VEHICLE IS.
Fuel/propulsion system, Dec 20, 2018
IN THE PAST 4 YEARS THE CHARCOAL CANISTER AND PURGE VALVE HAS GONE BAD. WHY DOES THE HAVE TO BE REPLACED SO OFTEN? I'M ON A FIXED INCOME AND CAN'T AFFORD TO REPLACE THIS EVERY FOUR YEARS, THEN I BOUGHT THIS VEHICLE GOOD FAITH.
Suspension, Dec 17, 2018
TL* THE CONTACT OWNS A 2010 TOYOTA RAV4. THE CONTACT STATED THAT THE VEHICLE WAS SERVICED PER NHTSA CAMPAIGN NUMBER: 16V596000 (SUSPENSION). THE MECHANIC FOUND THAT THE VEHICLE WAS NOT AFFECTED BY THIS RECALL, BUT IT WAS REPAIRED ANYWAY AT TOYOTA OF PORTLAND (55 NE BROADWAY ST, PORTLAND, OR 97232, (503) 284-1105). AT NO COST. TOYOTA?S PRESCRIBED RECALL REPAIR INVOLVES APPLYING AN EPOXY TO THE ADJUSTMENT NUTS ON THE REAR LOWER SUSPENSION ARMS (TOYOTA PART # 4871042020), PER THE INSTRUCTIONS SPECIFIED BY TOYOTA (SAFETY RECALL ?CSJ?). IN DECEMBER 2018, A TIRE SERVICE CENTER NOTED THE CONTACT?S REAR WHEELS WHERE OUT OF ALIGNMENT BUT THAT THEY COULD NOT PERFORM AN ALIGNMENT DUE TO THE APPLICATION OF THE EPOXY ? WHICH SEIZED THE ADJUSTMENT NUTS IN PLACE. THE CONTACT IS NOW UNABLE TO HAVE A REAR ALIGNMENT PERFORMED. CONTACT RETURNED THE VEHICLE TO THE DEALER, WHO STATED THAT THE SUSPENSION ARMS MUST BE ENTIRELY REPLACED IN ORDER TO REALIGN THE REAR WHEELS ? WITH TOYOTA INSISTING THE RECALL WORK (APPLYING EPOXY) IS PERFORMED AGAIN AT CONTACT?S EXPENSE. CONTACT WAS QUOTED $1050 BY TOYOTA DEALERSHIP TO PERFORM THE WORK. PRIOR TO THE RECALL, A REAR ALIGNMENT COULD BE PERFORMED AT THE SAME DEALERSHIP (OR ANY INDEPENDENT MECHANIC) ? UTILIZING THE ADJUSTMENT NUTS ? FOR APPROXIMATELY $85. IN SUMMARY, THE CONTACT BELIEVES TOYOTA?S PRESCRIBED RECALL REPAIR HAS INTRODUCED A SAFETY ISSUE DUE TO REMOVING THE ABILITY TO HAVE INDEPENDENT MECHANIC PERFORM A REAR ALIGNMENT.*DT *JB *TR
Vehicle speed control, Service brakes, Dec 3, 2018
TL* THE CONTACT OWNS A 2010 TOYOTA RAV 4. WHILE DRIVING 70 MPH WITH THE CRUISE CONTROL ACTIVATED, THE CONTACT ATTEMPTED TO STOP THE VEHICLE, BUT IT KEPT GOING. THE CONTACT DEPRESSED THE BRAKE PEDAL WITH FORCE AND WAS FINALLY ABLE TO STOP AFTER A FEW ATTEMPTS. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO BRIAN EASLEY TOYOTA (409 SPARTANBURG HWY, HENDERSONVILLE, NC 28792, (828) 693-7261) WHERE IT WAS DIAGNOSED THAT THE CRUISE CONTROL WAS DAMAGED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 74,000. THE VIN WAS INVALID.
Power train, Nov 18, 2018
YESTERDAY MY CAR DROVE PERFECTLY FINE. TODAY, I AM PULLING OUT OF MY DRIVEWAY TRYING TO ACCELERATE, THERE WAS A DELAYED REACTION, THEN A THUD AND THE CAR JUMPED FORWARD AT THE TIME OF THE THUD. IT DID IT AGAIN WHEN I PULLED INTO A PARKING SPACE, PROPELLING THE VEHICLE FORWARD SUDDENTLY AFTER THE THUD WAS HEARD AGAIN. WHEN I PUT IT IN REVERSE, THE THUD WAS HEARD AGAIN, NOT AS LOUD. ALL OF MY DRIVING WAS ON CITY STREETS, BUT DUE TO THE SUDDEN LERCHING FORWARD AFTER THE THUD SOUND, I KEPT A VERY WISE DISTANCE FROM VEHICLES IN FRONT OF ME. THIS HAPPENED BOTH IN STATIONARY AND ALSO WHILE IN MOTION. IT FEELS LIKE A TRANSMISSION PROBLEM, ALTHOUGH I HAVE READ ABOUT ISSUES WITH ECM SOLENOIDS. THIS CAR HAS RECORD OF BEING SERVICED ON A VERY REGULAR BASIS. IT HAS ABOUT 148K MILES ON IT.
Engine, Nov 4, 2018
SUV ACCELERATED WHEN I USED THE BRAKE! I WAS STOPPING AT RED LIGHT!
Suspension, Oct 31, 2018
TOYOTA ISSUED A SAFETY RECALL G0V A FEW YEARS AGO THAT SEALED THE REAR SUSPENSION ARMS WITH AN EPOXY. MY REAR ALIGNMENT IS OUT, AND I CANNOT NO LONGER ADJUST MY REAR SUSPENSION UNLESS I REPLACED BOTH REAR SUSPENSION ARMS. TOYOTA SAYS THIS IS MY OWN PROBLEM, AND ANY REPAIR ASSOCIATED WITH THIS SAFETY RECALL HAS TO COME FROM MY POCKET. HOW CAN THE SAFETY RECALL LEAD TO ANOTHER PROBLEM? I AM PROBABLY NOT THE ONLY ONE WHO HAS EXPERIENCED THIS ISSUE AS I READ SEVERAL OTHER FOLKS WHO VOICED THEIR CONCERNS ONLINE. IS THERE ANYTHING THAT NHTSA CAN DO?
Suspension, Sep 24, 2018
TL* THE CONTACT OWNS A 2010 TOYOTA RAV4. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC FOR A WHEEL ALIGNMENT. WHEN THE MECHANIC PLACED THE VEHICLE ON THE LIFT, IT WAS NOTICED THAT THE REAR PASSENGER SIDE CONTROL ARM WAS BOLTED AND EPOXIED. THE CONTACT STATED THAT THE REAR PASSENGER SIDE CONTROL ARM WAS REPAIRED ON DECEMBER 21, 2014 BY TOYOTA OF MORRISTOWN (169 RIDGEDALE AVENUE, MORRISTOWN, NJ 07960) PER NHTSA CAMPAIGN NUMBER: 16V383000 (SUSPENSION). IMMEDIATELY AFTER THE REPAIRS WERE PERFORMED, THE REAR PASSENGER TIRE STARTED TO WEAR UNEVENLY AND HAD TO BE REPLACED FIVE TIMES. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.
Air bags, Aug 21, 2018
SIDE CURTAIN AIRBAGS SPONTANEOUSLY DEPLOYED WHILE VEHICLE WAS BEING BACKED OUT OF A MECHANIC'S GARAGE AFTER ROUTINE BRAKE MAINTENANCE WAS PERFORMED. THERE WAS NO IMPACT PRIOR TO THE DEPLOYMENT. THANKFULLY NO ONE WAS INJURED, BUT IT WOULD HAVE BEEN A DIFFERENT STORY IF MY WIFE AND KIDS WERE IN THE CAR AND DRIVING WHILE THIS OCCURRED. AS OF THIS WRITING, I HAVE OPENED A CASE WITH TOYOTA (CORPORATE) AS INSURANCE HAS APPRAISED THE DAMAGE AT OVER $11,000 MAKING THIS A TOTAL LOSS. I HAVE YET TO HEAR ANYTHING FROM TOYOTA REGARDING THE CLAIM.
Suspension, Jul 31, 2018
REAR TOE ALLINEMENNT ADJUSTERS RECALL. THE PART IS NOW BEING EPOXIED DUE TO A TOYOTA MANUFACTURING FLAW. NOW THE CUSTOMERS HAVE TO SUFFER THE COST AT $600.00 TO HAVE A SIMPLE ALLINEMENT DONE ON THE REAR OF THE CAR. THE ONLINE CAR REVIEWS FROM OTHER CUSTOMERS ARE REALLY PISSED FOR BEING PLAYED SUCKERS FROM TOYOTA. THERE IS A LOT OF LOYAL TOYOTA CUSTOMERS GOING TO DROP TOYOTA AND GO WITH HONDA. AND AFTER GETTING RID OF THESE FLAWED CARS TO THE OPEN MARKET AND OTHER PEOPLE GET TO OWN FLAWED JUNK 'TOYOTA'S', THEIR VIEW WILL BE THE SAME AS THE CURRENT TOYOTA OWNERS. THEN THE SNOWBALL EFFECT KICKS IN PLUS ALL THE NEWS ABOUT TOYOTA'S NOW BEING JUNK CARS I'M SURE WILL HURT THE COMPANY WHERE IT SHOULD, IN THEIR BANK ACCOUNTS. I WAS A BIG LOYAL TOYOTA OWNER FOR YEARS, TAKING A LOT OF HEAT FROM MY NASCAR FRIENDS FOR OWNING A TOYOTA, WAIT TILL THEY HEAR ABOUT THIS, THIS WILL MAKE THEIR DAY AND A I TOLD YOU SO WILL BE NEXT. TOYOTA HAS OR HAD A CHANCE TO DO IT RIGHT AND THEY ARE BLOWING IT BIG TIME. 2006-2011 YEARS HAVE BEEN RECALLED ON THE RAV4, OVER 200,000 CARS. AT THIS NUMBER TOYOTA WILL GO DOWN QUICK. I ALSO HAVE BEEN THROUGH 2 SETS OF EXPENSIVE TIRES DUE TO THIS PROBLEM TO FIND OUT IT'S A SHODDY WAY FOR TOYOTA TO DO BUSINESS LIKE THIS. WE, THE CUSTOMER HAVE BEEN PLAYED OFF AS STUPID, I DON'T SEE IT THAT WAY ALONG WITH A LOT OF OTHERS. I HEAR HONDA'S ARE STILL DOING IT RIGHT, IF SOMETHING DON'T HAPPEN SOON, I WILL BE FINDING IT OUT MYSELF. OH I ALMOST FORGOT, THE TIRES NOW GOING BAD WAY TO SOON IS A SAFETY ISSUE AND NOW VERY HARD TO AFFORD THE COST OF OPERATION FOR THIS VEHICLE, YOU THINK IT'S THE SHOCKS, THEY CHECK GOOD, SHAME ON YOU TOYOTA.
Suspension, Jul 1, 2018
MY COMPLAINT IS ABOUT THE REAR SUSPENSION RECALL ENACTED IN 2012. I HAD THE RECALL PERFORMED AT MY LOCAL TOYOTA DEALER IN 2014. RECENTLY I PURCHASED NEW TIRES AT A FIRESTONE DEALER AND PURCHASED A A LIFETIME ALIGNMENT. WHEN THEY PERFORMED THE ALIGNMENT FOR FRONT AND REAR, BOTH NEEDED A LITTLE ADJUSTMENT. I WAS INFORMED THAT IT COULD NOT BE DONE AND THEY CAN ONLY ADJUST THE FRONT AS THE REAR HAD A TAG THAT STATES "ONLY TO BE SERVICED BY AN AUTHORIZED TOYOTA DEALER." FURTHERMORE, WHEN TOYOTA SERVICED THE RECALL, THEY PAINTED EPOXY OVER THE ENTIRE ARM. NOW THIS LEAVES FOR A VERY EXPENSIVE FIX. THE RECALL SOLUTION MADE BY TOYOTA DISABLED THE ABILITY TO ADJUST THE TOE IN TOE OUT FUNCTION TO ALIGN THIS VEHICLE PROPERLY. I CALLED THE TOYOTA DEALERSHIP AND THEY TOLD ME THE WHOLE SUSPENSION NEEDS TO BE REDONE WITH NEW PARTS AND NEW KITS COSTING 200 DOLLARS PLUS LABOR. I BELIEVE THIS TO BE A ENGINEERING PROBLEM. THE RECALL FIX DID NOT ALLOW AN ADJUSTABLE ARM AND THIS WILL CAUSE AN UNEVEN WEAR ON MY BRAND NEW TIRES. THIS IS WRONG AND TOYOTA FEELS THEY HAVE NO RESPONSIBILITY ON THIS MATTER AND IS LAYING THIS BLAME ON THE NATIONAL HIGHWAY SAFETY RECALLS. IN MY OPINION ANOTHER RECALL SHOULD BE IN ORDER. PEOPLE THAT OWN THESE VEHICLES SHOULD NOT HAVE TO PAY EXPENSIVE REPLACEMENT CHARGES TO FIX AN ALREADY RECALLED REAR SUSPENSION PROBLEM. WITH ALL THE ROAD HAZARDS ALIGNMENT PROBLEMS HAPPENING ALL THE TIME OR ANYTIME, AN ALIGNMENT IS BOUND TO OCCUR. WHAT CAN BE DONE TO GET THE MANUFACTURES TO OWN UP TO THE INADEQUACY OF THE RECALL SOLUTION THEY PERFORMED. P.S. SOME OF US CONSUMERS KEEP OUR CARS FOR A LIFETIME OF THE VEHICLE. AND I KNOW TOYOTA LIKES TO BRAG ABOUT THE LONGEST LASTING MOST DEPENDABLE CAR ON THE ROAD. I AM ONE OF THOSE PEOPLE THAT KEEP MY CARS MAINTAINED AT I'S MAXIMUM DRIVING CAPACITY.
Power train, Jun 27, 2018
WHINING SOUND, POSSIBLY TRANSMISSION. THE SOUND HAPPENS WHEN I ACCELERATE OR MAINTAIN A CERTAIN SPEED (25-45 MPH). WHEN I REMOVE MY FOOT OFF THE PEDAL THE SOUND GOES AWAY SO IT'S ONLY TEMPORARY. I CAN'T REALLY HEAR IT ON THE HIGHWAY BUT WHEN I'M ON THE SMALL ROADS I SOMETIMES DO. THE VEHICLE IS ONLY 8 YEARS OLD WITH SLIGHTLY LESS OF 100, 000 MILES. THE VEHICLE SHOULD BE ABLE TO RUN A FEW MORE YEARS.
Suspension, Jun 11, 2018
TL* THE CONTACT OWNS A 2010 TOYOTA RAV4. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V596000 (SUSPENSION); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER (PARKWAY TOYOTA, 50 SYLVAN AVE, ENGLEWOOD CLIFFS, NJ 076320, (201) 944-3300) WAS CONTACTED AND CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND WAS UNABLE TO CONFIRM WHEN THE PARTS WERE TO BECOME AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
Suspension, May 25, 2018
I HAVE MY REAR TIRES WEARING UNEVEN. TOOK MY VEHICLE TO GET AN ALIGNMENT BUT TOYOTA HAS A STICKER ON IT SAYING NO ONE CAN ADJUST DUE TO RECALL. TOYOTA APPARENTLY PUT APOXY ON THEIR SUSPENSION RECALL AND NOW MY CAR NEEDS AN ALIGNMENT AND NO ONE CAN FIX IT. TOYOTA SAYS FOR 850.00 THEY WILL FIX IT. SERIOUSLY, IT ONLY NEEDS AN ALIGNMENT BUT BECAUSE THEY DID A HORRIBLE JOB IN THE FIRST PLACE I AM UNABLE TO MAINTAIN MY OWN CAR. THEY REFUSE TO FIX IT WITHOUT CHARGING ME. HOW CAN THEY GET AWAY WITH THIS. THIS IS THEIR FAULT
Visibility, Other or unspecified, Apr 16, 2018
WHILE DRIVING AT APPROXIMATELY 55 MPH ON A TWO LANE HIGHWAY, THE SUNROOF SUDDENLY CRACKED AND THEN SHATTERED FOR NO APPARENT REASON. THERE WAS NO DEBRIS (ROCK, BOLT) ETC FOUND IN THE GLASS ONCE WE WERE ABLE TO PULL OVER AND LOOK AT THE DAMAGE. THE GLASS APPEARS TO HAVE BOWED UPWARD AND AWAY FROM THE FRAME AND THEN SHATTERED.
Visibility, Visibility/wiper, Apr 12, 2018
TL* THE CONTACT OWNS A 2010 TOYOTA RAV4. WHILE DRIVING 30 MPH, THE DRIVER'S SIDE SUN VISOR FELL DOWN INTO THE DRIVER'S LINE OF SIGHT. THE VEHICLE WAS TAKEN TO MULLER TOYOTA (2019 NJ-31, CLINTON, NJ 08809, (908) 638-4100) WHERE THE CONTACT WAS ADVISED THAT THERE WERE NO RECALLS ON THE VEHICLE. THE DEALER STATED THAT THE SUN VISOR WAS NOT A SAFETY HAZARD. THE MANUFACTURER ALSO STATED THAT THE FAILURE WAS NOT A SAFETY HAZARD AND THAT THE VISOR WOULD NOT BE REPAIRED BY THE MANUFACTURER. THE FAILURE MILEAGE WAS 75,000.
Air bags, Jan 16, 2018, crash
DECEMBER 8, 2017, IN 2010 RAV4, ABOUT 27 MPH HEADING FORWARD, HIT HEAD-ON, (CITY STREET) 12TH ST. NW, ALBUQUERQUE. OTHER DRIVER DUI (BLEW 2.6 ABOUT 1 HR LATER), WRONG-WAY IN MY LANE, DROVE SILVERADO, SEEMED TO SPEED UP UPON IMPACT, ATTEMPTED TO KEEP GOING BUT SILVERADO HOOKED INTO BRAKED RAV. MY CAR WAS PUSHED BACKWARD ABOUT 40 FT., ACCORDING TO POLICE OFFICERS. SHOCKING SOUND AND FEELING UPON IMPACT. MY AIR BAG DEPLOYED, BUT DID NOT DEFLATE--INSTEAD, IT EXPLODED. HAVE HAD BREATHING PROBLEMS SINCE, EXACERBATION OF ASTHMA, BURNING FEELING IN EARS, OTHER SYMPTOMS. I DID NOT KNOW THAT THE AIR BAG WAS SUPPOSED TO DEFLATE. ADJUSTER AGREES IT EXPLODED, BUT DOES NOT KNOW IF HE HAS A PHOTO OF THE EXPLODED AIR BAG. HE WILL LOOK THROUGH HIS PHOTOS.
Suspension, Seat belts, Jan 15, 2018
I AM FILING A COMPLAINT AGAINST BUTLER TOYOTA LOCATED AT 9419 ARONSON DR., INDIANAPOLIS, IN 46240. THIS IS THE ADDRESS OF THE SERVICE DEPARTMENT. WE HAVE BEEN CALLING THEM FOR TWO YEARS TO TRY AND GET THE RECALLS TAKEN CARE ON OUR CAR. EACH TIME WE HAVE CALLED THEY SAY THEY DO NOT HAVE THE PARTS IN STOCK. I JUST TRIED TO SCHEDULE AN APPOINTMENT WITH THE SERVICE DEPARTMENT AGAIN TODAY AND WAS GIVEN THE SAME STORY.
Visibility/wiper, Jan 14, 2018
THE DRIVER'S SUN VISOR WILL NOT STAY IN THE CLOSED POSITION & IS CONSTANTLY FALLING DOWN, WHICH OBSTRUCTS MY VIEW. THE ATTACHED PHOTO SHOWS THE VISOR AS CLOSED AT IT WILL STAY. I HAVE CONTACTED TOYOTA AND THEY REFUSE TO ACKNOWLEDGE THE PROBLEM, DESPITE THE FACT THAT ON SEVERAL MESSAGE BOARDS NUMEROUS OWNERS REPORT THAT THIS IS A DESIGN FLAW DATING BACK TO PRIOR RAV4 GENERATIONS.
Steering, Jan 10, 2018
MY CAR IS TOYOTA 2010 RV4 SPORT.THIS MORNING WHEN I START ENGINE, THE SYMBOLS OF "ELECTRIC POWER STEERING SYSTEM WARNING LIGHT , ABS, AIRBAG, BREAKER , SLIP INDICATOR WARNING LIGHT" ON DASHBOARD ALL LIGHTS ON. THAT'S NEVER HAPPEN BEFORE. AND WHEN I WAS DRIVING, THE STEERING WHEEL BECOME HEAVY. I WAS SO SHOCKED AND GO TO A LOCAL AUTO SERVICE STORE, THEY CHECK AND TOLD ME THIS IS ELECTRONIC STEERING MOTOR ISSUE. THEY ADJUSTED AND WHEEL BACK TO NORMAL NOW, BUT THEY ALSO MENTION THEY CAN NOT GUARANTEE THE SAME SITUATION WILL BE BACK OR NOT. AND THEY RECOMMEND ME TRY TO AVOID DRIVE ON FREEWAY ( BUT THIS IS IMPOSSIBLE IF YOU LIVE IN CALIFORNIA). I WAS TOLD THE SAME PROBLEM HAPPEN ON TOYOTA RECALL GROUP BUT NOT INCLUDING MY CAR'S MAKE YEAR.
Power train, Engine, Jan 5, 2018
TL* THE CONTACT OWNS A 2010 TOYOTA RAV4. WHILE DRIVING 40 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A LOCAL DEALER (COPELAND TOYOTA, 1554 MAIN ST, BROCKTON, MA 02301) WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 137,000.
Air bags, Dec 22, 2017
"TAKATA RECALL"
Structure, Dec 6, 2017
I PURCHASED NEW FROM TOYOTA OF WARRENTON, VA IN 2010. MY CAR DEVELOPED A PAINT PEELING PROBLEM LAST WINTER. I HAVE BEEN TOLD BY AN AUTO PAINT COMPANY THAT IT IS DUE TO MANUFACTURER MALFUNCTION. I HAVE ATTEMPTED TO CONTACT TOYOTA OF NORTH AMERICA; I FILED A COMPLAINT, MET WITH MY LOCAL DEALER AND DISCOVERED THAT CORPORATE GIVES THE DEALER THE POWER TO DELETE THE CLAIM, PREVENTING ME FROM DEALING DIRECTLY WITH THE MANUFACTURER. IN EFFECT, I HAVE NO RECOURSE.
Vehicle speed control, Dec 5, 2017, crash
TL* THE CONTACT OWNS A 2010 TOYOTA RAV4. THE CONTACT STATED THE VEHICLE SPEED ACCELERATED INDEPENDENTLY CAUSING THE CONTACT TO REAR END THE VEHICLE IN FRONT OF HER, WHILE SHE HAD THE BRAKE PEDAL DEPRESSED. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED. THERE WERE NO MEDICAL INJURIES THAT WERE SUSTAINED THAT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS NOT TOWED, THE CONTACT ABLE WAS TO DRIVE THE VEHICLE HOME. THE MANUFACTURER WAS CONTACTED AND MADE AWARE OF THE FAILURE AND OFFERED TO BUY BACK THE VEHICLE. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000. *TT UPDATED 9/18/18*JB
Suspension, Air bags, Dec 3, 2017, crash
TAKATA RECALL, MY REAR SWERVED AS I MOVED RIGHT TO AVOID A HEAD ON COLLISION, MY CHEST HIT THE STEERING WHEEL SO HARD THAT I BROKE 6 RIBS INCLUDING MY STERNUM BECAUSE THE AIRBAGS DIDN'T DEPLOY UNTIL AFTER THE IMPACT , I ALSO SAW ANOTHER RECALL THAT WAS ANNOUNCED 2 OR 3 DAYS AFTER MY ACCIDENT WHICH RESULTED IN A TOTAL LOSS WHICH WAS THE REAR SUSPENSION NEEDED TO BE REPLACED BECAUSE IT COULD CAUSE AN ACCIDENT I REPORTED THIS TO NHTSA AND WAS GIVEN A REFERENCE NUMBER10937800, PLEASE KEEP ME UPDATED THIS IS HORRIBLE THAT THESE PEOPLE KNOWINGLY PUT FAULTY PARTS ON A VEHICLE, I AM STILL AFRAID TO DRIVE I FELT MY CAR SHAKING AND BLAMED IT ON THE ROADS, THE WIND, ANYTHING BECAUSE I DIDN'T WANT TO BELIEVE SOMEONE WOULD SELL A VEHICLE KNOWING IT WAS NOT SAFE