2006 Toyota Tacoma
Problems, recalls and owner-reported issues
Structure is the leading concern among 782 owner complaints filed for this model year. This is the highest complaint count among 26 Tacoma model years with reports.
Of the 2006 reports, 66 involved a crash and 7 involved a fire. 31 people were injured.
What owners report most often
Recalls and investigations
Seats, front assembly, seat heater/coolerJun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Campaign 16V396000 on NHTSA.gov
Seats, front assembly, seat heater/coolerNov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Campaign 14V743000 on NHTSA.gov
Suspension, rear, springs, leaf spring assembly, leafSep 29, 2014
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2005-2011 Toyota Tacoma Pre-Runner and 4x4 vehicles manufactured September 14, 2009, to October 11, 2010. In the affected vehicles, one of the leaf springs may fracture due to stress or corrosion. While being driven, the broken leaf could move out of position and contact surrounding components including the fuel tank, possibly puncturing the tank and causing a fuel leak.
If the fuel tank leaks fuel from being punctured, there is an increased risk of a fire.
Toyota will notify owners and dealers will install new rear leaf spring assemblies. The recall began on January 29, 2016. Owners may contact Toyota customer service at 1-800-331-4331.
Campaign 14V604000 on NHTSA.gov
Seat beltsAug 7, 2013
Toyota is recalling certain model year 2005-2010 Tacoma Access Cab vehicles manufactured September 14, 2004, through March 29, 2010; and model year 2011 Tacoma Access Cab vehicles manufactured July 1, 2010, through September 7, 2011. If the access doors are repeatedly and forcefully closed, the screws that attach the seat belt pre-tensioner to the seat belt retractor can loosen over time. If the screws loosen completely, the seat belt pre-tensioner and the retractor spring cover could detach from the seat belt retractor.
If the seat belt pre-tensioner detaches from the seat belt assembly, the seat belt pre-tensioner will not perform as designed, increasing the risk of injury in a severe crash.
Toyota will notify owners, and dealers will inspect the seat belt assemblies. Based on the inspection, the seat belt assembly will be replaced or new pre-tensioner screws will be installed with thread-locking sealant and a retractor spring cover with stopper ribs to prevent loosening of the screws. These services will be provided at no cost to the owner. The recall began during February 2014. Owners may contact Toyota at 1-800-331-4331.
Campaign 13V337000 on NHTSA.gov
Air bags, frontalMar 7, 2012
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2009 TACOMA VEHICLES, MANUFACTURED FROM SEPTEMBER 14, 2004, THROUGH AUGUST 29, 2008. OVER TIME, STEERING WHEEL VIBRATION MAY DAMAGE THE SPIRAL CABLE ASSEMBLY (CLOCKSPRING) THAT POWERS THE DRIVERS AIR BAG MODULE. IF DAMAGE OCCURS, THE AIR BAG WARNING LAMP WILL ILLUMINATE AND THE AIR BAG MAY BECOME DEACTIVATED.
IN THE EVENT OF A CRASH, THE DRIVERS SIDE AIR BAG MAY NOT DEPLOY, INCREASING THE RISK OF PERSONAL INJURY.
TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE SPIRAL CABLE ASSEMBLY, FREE OF CHARGE. AN INTERIM LETTER IS EXPECTED TO BE MAILED TO OWNERS DURING APRIL 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 12V092000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Campaign 10V036000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Campaign 10V035000 on NHTSA.gov
Vehicle speed control, accelerator pedalOct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Campaign 09V388000 on NHTSA.gov
Equipment, other, labelsJun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Campaign 09V223000 on NHTSA.gov
Air bagsApr 3, 2006
ON CERTAIN VEHICLES, DUE TO IMPROPER ASSEMBLY OF THE AIR BAG INFLATOR, WHICH IS USED IN THE SIDE AIR BAG, THE CURTAIN SHIELD AIR BAG, AND THE KNEE AIR BAG ASSEMBLY, SOME INFLATORS WERE PRODUCED WITH AN INSUFFICIENT AMOUNT OF THE HEATING AGENTS NECESSARY FOR PROPER AIR BAG DEPLOYMENT. IN THIS CONDITION, THE EXPANSION FORCE OF THE GAS MAY BE INSUFFICIENT TO PROPERLY INFLATE THE AIR BAG WHEN THE SRS SYSTEM IS ACTIVATED DURING A CRASH.
THIS MAY INCREASE THE RISK OF INJURY TO THE OCCUPANT IN THE INVOLVED SEATING POSITION IN THE EVENT OF A CRASH.
DEALERS WILL REPLACE THE SPECIFIC SRS AIR BAG. THE RECALL BEGAN ON APRIL 6, 2006. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371, SCION AT 1-866-548-1851, OR LEXUS AT 1-800-255-3987.
Campaign 06V096000 on NHTSA.gov
Tires, beadMar 2, 2006
ON CERTAIN PICKUP TRUCKS, THE BEAD OF THE TIRE MAY BE DAMAGED DUE TO IMPROPER ASSEMBLY OF THE TIRES ONTO THE WHEELS.
IF THE VEHICLE IS OPERATED IN THIS CONDITION, THERE IS A POSSIBILITY THAT A BULGE MAY BE FORMED ON THE SIDEWALL AND AIR MAY LEAK FROM THE AREA OF THE DAMAGED BEAD AND A CRASH COULD OCCUR.
DEALERS WILL INSPECT THE TIRES AND REPLACE IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 27, 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 06V061000 on NHTSA.gov
Representative owner complaints: power train
56 reports, newest first. Show all
Power train, Apr 11, 2023
I was driving and all of the sudden I felt a vibration when I let off the gas...I checked under and saw that the drive shaft/yoke was separated a little, so I decided not to drive it anymore and to disassemble it and found out that the lock nut is missing and more likely it came off. I've noticed that no sign that the lock been staked to lock in position (picture attached)...this is a near miss and could possibly there are more like this on the road that could lead to a very serious accident if this comes off while running in high speed. I bought this car in 2005 brand new, and I know for sure that this never been work on...I am a mechanic myself so I does the Maintenace to all my cars...I just want to make the company aware to prevent any possible serious accident...I owe 5 Toyota cars and I know one of the best and safest vehicle.
Power train, Mar 30, 2021
REAR DIFFERENTIAL OIL LEAK. THERE HAD BEEN A RECALL IN THE 2016 TOYOTA TACOMA BUT MY 2006 HAS THE SAME PROBLEM STARTING YEARS AGO. I DID NOT KNOW IT WAS LEAKING UNTIL I TOOK IT TO THE DEALERSHIP.
Suspension, Power train, Service brakes, Jul 4, 2020
EXCESSIVE CORROSION AND RUSTED THROUGH FRAME THAT IS UNABLE TO SUPPORT WEIGHT OF VEHICLE. HAD A BRAKE LINE BUST DUE TO BEING RUSTED OR CORRODED OUT. ALSO SUSPENSION SHOWS EXCESSIVE RUST AND CORROSION. COOLING LINES CORRODED. POWER STEERING LINES CORRODED. TRANSMISSION LINES CORRODED. ANY METAL LINE IS THAT'S ATTACHED TO THIS VEHICLE ARE CORRODED. AND ALL BRACKETS AND HARDWARE ATTACHED TO FRAME AND EVEN THE METAL PULLEYS ALL EXCESSIVELY CORRODED.
Power train, Apr 25, 2019
WHEN THE VEHICLE HAD AROUND 112,000 MILES ON IT THE CHECK ENGINE LIGHT CAME ON AND IT EXPERIENCED IRREGULARITIES WITH REGARD TO SHIFTING. THE CODE WAS RAN AND THE SHIFT SOLENOID WAS THE ISSUE. A NEW TRANSMISSION WAS RECOMMENDED. WE WERE NOT INFORMED OF THIS WHEN WE PURCHASED THE VEHICLE SECOND HAND. APPROXIMATELY A YEAR LATER THE SAME THING HAPPENED WITH THE SHIFTING AND THE CHECK ENGINE LIGHT COMING ON. UNFORTUNATELY BY THE TIME WE TOOK IT TO A CERTIFIED TOYOTA DEALER THE LIGHT WAS OFF AND IT WAS RUNNING SMOOTHLY. THE INCONSISTENCY OF THE ISSUE IS FRUSTRATING BECAUSE WE DON'T KNOW THE ACTUAL ISSUE AND IF THE VEHICLE CAN BE TRUSTED. THE CERTIFIED DEALER RECOMMENDS A COSTLY TRANSMISSION REPLACEMENT WITHOUT BEING ABLE TO VERIFY THE ISSUE.
Power train, Nov 2, 2018
TRANSMISIN SLIPS OR NOT RUN IN REVERSE, EVEN ON FLAT SURFACES. RUNS NORMALLY IN FORWARD.
Power train, Sep 7, 2017
VIBRATION EVERYTIME THE VEHICLE IS TRAVELLING AT LOWER SPEED, 20 MPH.
Steering, Power train, Seats, Dec 20, 2016
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. WHILE DRIVING APPROXIMATELY 30 TO 70 MPH, THE DRIVE TRAIN VIBRATED UNCONTROLLABLY, AND THE SEAT AND STEERING WHEEL ALSO VIBRATED. THE MANUFACTURER WAS NOTIFIED. THE DEALER REPLACED THE TIRES, BUT THE FAILURE RECURRED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.
Power train, Structure, Engine, Dec 4, 2016
I TOOK MY 2006 TOYOTA TACOMA TO BOCH TOYOTA AS PART OF TOYOTA SERVICE CAMPAIGN REGARDING FRAME RECALL BACK IN DEC OF 2015. I WAITED 5 MONTHS TO GET MY TRUCK BACK TO GET IT BACK IN DEPLORABLE CONDITIONS. TRUCK WAS NOT REPAIRED SATISFACTORILY AND I AM STILL HAVING ISSUES WITH IT. I HAVE MADE SEVERAL COMPLAINTS TO TOYOTA AND BOTH TOYOTA TO NO AVAIL. TRUCK BARELY RUNNING. *TR
Suspension, Power train, Structure, Mar 9, 2016
I TOOK MY TRUCK TO MALLOY TOYOTA FOR FRAME INSPECTION REGARDING THE LIMITED SERVICE CAMPAIGN EOD- FRAME RUST RECALL. DEALER INFORMED ME THERE WAS RUST, BUT NO PERFORATIONS. THEY RECOMMENDED COATING THE FRAME WITH COMPOUNDS. I FEEL THAT MY TRUCK MAY NOT HAVE PERFORATIONS, BUT IT IS JUST A MATTER OF TIME BEFORE THE FRAME BECOMES PERFORATED, RESULTING IN A DANGEROUS / UNSAFE VEHICLE. PUTTING THE COMPUNDS ON THE FRAME IS A QUICK BAND-AID AND DOES NOT FIX THE PROBLEM. THIS FRAME WILL BECOME UNSAFE, IT IS JUST A MATTER OF TIME. THIS WILL NOT ONLY POTENTIALLY JEOPARDIZE THE SAFETY OF MY FAMILY / OCCUPANTS IN THE VEHICLE, BUT ALSO THE OTHERS THAT SHARE THE ROAD WITH MY TRUCK.
Power train, Service brakes, Dec 7, 2015
WE HAVE HAD SEVERAL ISSUES WITH OUR 2006 TOYOTA TACOMA WHICH HAS 125331 MILES. ON MAY 11, 2015, WE BROUGHT THE TRUCK INTO MOUNTAIN STATES TOYOTA, FOR THE REPAIR OF THE REAR DRIVE SHAFT WHICH HAD FAILED. I WAS EXPERIENCING A VIBRATION EVEN WHEN DRIVING AT VERY LOW SPEEDS THAT CONTINUED TO GET WORSE. I HAVE ENCLOSED THE PAPERWORK DESCRIBING THE REPAIR, WHICH I BELIEVE WAS TIED TO A RECALL, AND ANOTHER REPAIR. OCTOBER 19, 2012, THE RIGHT REAR LEAF SPRING CRACKED AND NEEDED REPAIR, MILEAGE WAS 92303. AT THE TIME WE DID NOT KNOW ANYTHING ABOUT THE RECALL FOR THE LEAF SPRINGS, AND THE REPAIR FOR THE RIGHT HAD COST US 1408.11. THE REPAIR SHOP ALSO NOTICED AT THE TIME THAT THE LEFT REAR LEAF SPRING WAS ALSO FAULTY AND NEEDED TO BE REPAIRED, THAT WAS REPAIRED A FEW DAYS LATER 10/23/2012 THE COST 1407.61. AT THE TIME WE HAD DRIVEN AROUND NOT KNOWING WHAT THE VIBRATION WAS ONLY THAT THE VEHICLE WAS VERY DIFFICULT TO DRIVE. THE FAULTY LEAF SPRINGS WE WERE TOLD AT A LATER DATE BY THE TOYOTA DEALER MAY HAVE PLAYED A FACTOR IN THE ABOVE REPAIR. THEY COULD NOT GUARANTEE THAT IT HAD NOT BEEN CAUSED BY THE FAULTY LEAF SPRING. ON OCTOBER 27, 2006 THE HEAD GASKET NEEDED TO BE REPAIRED, THE MILEAGE AT THIS TIME WAS 90102. THE COST OF THE REPAIR WAS 2866.18. WE ALSO HAD AN ISSUE WITH THE BRAKES JUST GOING ON THE VEHICLE WHILE MY SON WAS DRIVING THE VEHICLE, IN OCTOBER. HE LUCKILY WAS ABLE TO GEAR DOWN USING THE TRANSMISSION TO SLOW THE VEHICLE DOWN. WHEN IT WAS TOWED TO MOUNTAIN STATES TOYOTA, WHICH IS WHERE HE HAD HAD THE BRAKE FLUID REPLACED A FEW MONTHS PRIOR, PAID IN FULL FOR ALL REPAIRS AT THE TIME. SO I FEEL THIS ISSUE WAS PROBABLY THE FAULT OF MOUNTAIN STATES TOYOTA.
Power train, Structure, Jul 7, 2014
DUE TO THE RUSTED FRAME ISSUES THAT I REPORTED TO TOYOTA ON 04/16/2014 (MULLER TOYOTA AND TOYOTA CORPORATE) MY CLUTCH PEDAL STUCK TO THE FLOOR WHEN CROSSING AN INTERSECTION ALMOST CAUSING A CRASH WHEN THE RUSTED CLUTCH SLAVE CYLINDER STUCK . THERE ARE BIG RUST HOLES IN THE FRAME AND TOYOTA FREELY ADMITS THAT THEY ARE DEFECTIVE FRAMES , BUT WON'T HAVE A RECALL ON THOSE MODEL TACOMAS UNTIL ENOUGH PEOPLE COMPLAIN OR GET INJURED OR KILLED ! SOMETHING SHOULD BE DONE ABOUT THESE DEFECTIVE FRAMES THAT RUST FROM THE INSIDE OUT. *JS
Power train, Jun 5, 2014
6 SPEED TRANSMISSION LOCKED IN GEAR WHEN ATTEMPTING TO SHIFT INTO FIRST GEAR. APPEARS TO BE STUCK IN 4 TH GEAR ? WAS ABLE TO GET IN DRIVEWAY. *TR
Power train, Engine, Feb 6, 2014
I WAS SLOWLY ENTERING A PARKING SPACE. I PRESSED THE BRAKE PEDAL AND THE ENGINE SPEED INCREASED TO MAXIMUM RPM. I JAMMED THE EMERGENCY BRAKE AND THREW THE TRANSMISSION INTO "PARK." A GREAT CLOUD OF BLUE SMOKE ISSUED FORTH FROM THE SPINNING TIRES. THIS NEVER HAPPENED BEFORE AND IT'S DEFINITELY A PROBLEM WITH THE TRUCK AND NOT MY FOOT! SEVERAL YEARS AGO, AS A PEDESTRIAN, I SAW THE EXACT SAME THING HAPPEN TO A JEEP CHEROKEE AT A STOP SIGN. *TR
Power train, Vehicle speed control, Jan 29, 2013
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. THE CONTACT STATED THAT WHILE THE VEHICLE WAS COMING TO A STOP, AN ODD NOISE WAS HEARD COMING FROM THE DRIVESHAFT. THE CONTACT ALSO STATED THAT ACCELERATION SUDDENLY INCREASED UP TO 7 MPH HIGHER THAN WHAT THE SPEED CONTROL WAS SET TO. IN ADDITION, WHEN THE WIND SHIFTED THE VEHICLE, THE FRONT STABILIZER BAR RUBBED AGAINST THE TIRES AND CAUSED A LOUD NOISE. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THERE WAS NO FAILURE WITH THE VEHICLE. THE DEALER GAVE HIM ANOTHER VEHICLE TO TEST DRIVE AND STATED IF THAT VEHICLE HAS THE SAME ISSUE THEN THAT WAS THE DESIGN OF ALL OF THE VEHICLES. THE CONTACT TEST DROVE THE VEHICLE AND EXPERIENCED THE SAME FAILURE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 102,000. UPDATED 03/07/13*LJ THE CONSUMER THE DRIVESHAFT WAS REPLACED.. THE FAILURE FELT LIKE THE VEHICLE WAS REAR-ENDED BY ANOTHER VEHICLE. *JS
Power train, Wheels, Service brakes, Dec 11, 2012
DECEMBER 2006 TRUCK PARKED WITH EMERGENCY BRAKE OFF AND WOULD NOT MOVE BELOW FREEZING TEMPERATURE. ALL FOUR WHEELS LOCKED UP. TOWED TO DEALER, AFTER NUMEROUS ATTEMPTS TO FIX HE STATED THE WHEEL BEARING WERE LEAKING GREASE AND FREEZING UP SO TRUCK WOULD NOT MOVE. TRUCK OPERATES GOOD ALL YEAR TILL IT GETS BELOW FREEZING AND WHEELS LOCK UP. DEALER DOES NOT KNOW THE PROBLEM, BUT ONLY HAPPENS WHEN PARKED AND BELOW FREEZING. DECEMBER 10 2012 REAR WHEELS LOCK UP WHILE DRIVING IN BELOW FREEZING CAUSING TRUCK TO SLIDE AND MISS TWO ON COMING CARS, TRUCK ENDS UP IN DITCH. WOULD SELL VEHICLE BUT AFRAID ANYONE DRIVING IT IN COLD WEATHER WOULD BE STRANDED OR IN A FATAL WRECK. ARE OTHER TRUCKS HAVING SAME ISSUE AS I HUNT AND GO BACK 30 MILES INTO THE WOODS AND IF FREEZES I WOULD BE STRANDED. *TR
Power train, Engine, Oct 14, 2012
FOR AT LEAST 2 MOS PREVIOUS I WOULD HEAR A CHIRPING NOISE FROM THE ENGINE COMPARTMENT. IT WOULD GET LOUDER AS YOU ACCELERATED & SEAMED MORE NOTICEABLE IN WARMER WEATHER. TOOK VEHICLE IN TO DHC TORRANCE TOYOTA & SAID IT WAS MY IDLER BEARINGS. I THOUGHT THAT WAS ODD SINCE THE TRUCK ONLY HAS 37400 MILES. IT COST ME OVER $800.00. *TR
Steering, Suspension, Power train, Nov 4, 2011
NOTICED RUST ON THE FRAME OF THE VEHICLE WITH HEAVIER AMOUNTS NEAR/ON WELD POINTS, & BOLT POINTS. RUST IS ACCUMULATING ON THE STEERING TIE RODS. HEAVY RUST ON REAR DIFFERENTIAL AND VARIOUS STEERING COMPONENT PARTS. I CONSIDER THE AMOUNT OF RUST ON THE FRAME AND THE ABOVE MENTIONED COMPONENTS A MANUFACTURER'S DEFECT. IF ANY OF THE COMPONENTS FAIL WHILE I AM DRIVING I COULD CRASH AND INJURE, OR KILL ANOTHER MOTORIST/MYSELF. I SPOKE WITH TOYOTA OF SD SERVICE REP WHO TOLD ME I SHOULD CONTACT TOYOTA. I HAVE A 100,000/10YR EXTENDED SERVICE PLAN AND WANT THIS RESOLVED PRIOR TO THE TIME FRAME RUNNING OUT. *TR
Power train, Dec 22, 2010
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. THE CONTACT STATED THE VEHICLE HAS HAD PROBLEMS WITH THE CRUISE CONTROL. THE FAILURE BEGAN AFTER THE CONTACT HAD THE TRANSMISSION SERVICED AND THE TRANSMISSION WAS NOT REFILLED PROPERLY. AFTER THE SERVICE, THE CONTACT STATED THAT THE CRUISE CONTROL STARTED TO ACCELERATE PASS THE SPEED THAT IT WAS SET WITH BEING RESET BY THE DRIVER. THE VEHICLE WAS TAKEN TO THE DEALER AGAIN AND REPAIRS WERE MADE TO THE ELECTRONIC CONTROL UNIT, WHICH HAS CAUSED THE RPMS TO IDLE EITHER EXCESSIVELY LOW OR EXCESSIVELY HIGH. THE CONTACT STATED THE VEHICLE WILL ALSO DOWNSHIFT FROM FIFTH GEAR TO SECOND GEAR WHEN DRIVING WITH THE CRUISE CONTROL SET TO 55 MPH AND ABOVE. THE FAILURE MILEAGE WAS 85,118 AND THE CURRENT MILEAGE WAS 85,557.
Power train, Dec 6, 2010
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. THE CONTACT STATED WHILE DRIVING 30 MPH, HE NOTICED AN ABNORMAL CLAPPING SOUND COMING FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN STATED THAT THE DIFFERENTIAL UNIT WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 57,859.
Power train, Jun 12, 2010
2006 TOYOTA TACOMA WITH AUTOMATIC TRANSMISSION. SAME COMPLAINT AS OTHERS. LOW END RUMBLING SOUND AND VIBRATION IN FRONT END BETWEEN 55 AND 65 MPH. FRONT DIFFERENTIAL BEARINGS, WHERE FRONT AXLES ENTER THE DIFFERENTIAL CASE, HAVE EXCESSIVE PLAY (SLOP) IN THE BEARINGS. DEALER REFUSES TO REPAIR THE BEARINGS EVEN THOUGH IT IS STILL UNDER WARRANTY. I HAVE VIDEO TAPED THE CONDITION AS WELL AS THE MILEAGE AND WILL KEEP RECORDS OF MY MULTIPLE VISITS TO THE DEALER. I HAVE ALSO FOUND OTHER USED TACOMA TRUCKS ON DEALER LOTS WITH AS LITTLE AS 20,000 MILES THAT HAVE THIS SAME PROBLEM. I BELIEVE TOYOTA ENGINEERED THESE DIFFERENTIALS TO LAST ONLY 60,000 MI AND MOST OWNERS MAY NOT NOTICE THE PROBLEM UNTIL WARRANTY IS OVER. MY 1992 TOYOTA PICKUP 4X4 WITH 238,000 MILES HAS LESS BEARING SLOP IN IT THAN THE '06. *TR
Power train, May 12, 2010
A CHIRPING SOUND BEGAN BEING EMITTED FROM THE TRANSMISSION. THE CHIRP WAS PRESENT AT ALL TIMES EXCEPT WHEN THE CLUTCH WAS DEPRESSED. THE PROBLEM WAS DIAGNOSED AS A THROW OUT BEARING WIGGLING ON THE PILOT SHAFT. THE THROW OUT BEARING SCORED THE PILOT SHAFT. A NEW THROW OUT BEARING WAS INSTALLED AND THE PILOT SHAFT SMOOTHED WITH EMORY CLOTH. THIS SOLUTION SOLVED THE PROBLEM IMMEDIATELY, BUT WITHIN A YEAR, THE SAME CHIRP RETURNED. THE THROW OUT BEARING IS AGAIN VIBRATING ON THE PILOT SHAFT. *TR
Power train, Vehicle speed control, Mar 3, 2010
WHILE DRIVING ON I-95 SOUTH OF JACKSONVILLE FLORIDA IN MY 2006 TOYOTA TACOMA I WAS FORCED TO ACCELERATE RAPIDLY TO AVOID AN ACCIDENT. THE VEHICLE KEPT ACCELERATING UNTIL I DOING ALMOST A 100 MPH WEAVING THROUGH TRAFFIC UNTIL I COULD GET INTO THE RIGHT HAND LANE AND SHUT THE ENGINE OFF. ONCE STOPPED THE FIRST THING I CHECKED WAS THE FLOOR MAT AS I HAD A PROBLEM WITH PREVIOUS VEHICLE CAUSING THE ACCELERATOR TO STICK BUT THE FLOOR MAT WAS NO WHERE NEAR THE ACCELERATOR PEDAL. I RESTARTED THE VEHICLE BUT IT JUST REVVED WIDE OPEN SO I TURNED IT BACK OFF AND CALLED ARLINGTON TOYOTA. I WAS ADVISED TO CALL A WRECKER AS THEY SAID THEY HAD NOT EXPERIENCED THIS ISSUE BEFORE. THEY HAD IT FOR THREE DAYS BUT COULD NOT FIND ANY PROBLEMS AS IT RUN PERFECTLY WHEN OFF LOADED OFF THE WRECKER. I WAS ADVISED TO INSTALL MAT RETAINING PINS. THEN I RECEIVED A RECALL FOR THE FLOOR MATS AND WHEN I TOOK IT TO THE DEALER FOR RECALL I WAS ADVISED TO REMOVED THE DRIVERS SIDE FLOORMAT. I WAS TOLD NOTHING MORE THAT TOYOTA AS TO WHAT WAS BEING ATTEMPTED TO CORRECT THE ISSUE. IS THAT A VIABLE RECALL? I KNOW FOR A FACT IT WAS NOT THE FLOOR MAT THAT CAUSED THE ISSUE BUT WAS ADVISED BY TOYOTA THERE WAS NO DOCUMENTED INSTANCES OF UNEXPLAINED ACCELERATION WITH TACOMA'S. MY VEHICLE IS A 2006 TACOMA PRERUNNER ACCESS CAB, V6, AUTOMATIC TRANSMISSION WITH TOWING PACKAGE. I REALLY THOUGHT THAT TOYOTA WOULD RAPIDLY GET FIX IN PLACE BUT THAT HAS NOT BEEN THE CASE AND FOR THIS REASON I AM SUBMITTING THIS COMPLAINT. *TR
Power train, Vehicle speed control, Mar 3, 2010
TL*THE CONTACT OWNS A 2006 TOYOTA TACOMA. WHENEVER THE CONTACT ATTEMPTED TO SWITCH GEARS FROM 4TH TO 5TH HE NOTICED THAT THE RPM'S WOULD REMAIN CONSTANT OR RISE FOR A PERIOD OF 10 SECONDS. THE FAILURE OCCURRED AT VARIOUS SPEEDS. THE VEHICLE WAS TAKEN TO THE DEALERSHIP WHERE THE CONTACT WAS INFORMED THAT THE VEHICLE WAS WORKING PROPERLY. THE CONTACT HAS NOTICED THE FAILURE SINCE THE DAY THE VEHICLE WAS PURCHASED. THE FAILURE MILEAGE WAS 26,041 UPDATED 4/26/10 *CN THE CONSUMER STATED DURING 4TH AND 5TH SHIFTING, THE ACCELERATOR PEDAL WOULD STICK. HE ALSO EXPERIENCED ERRATIC IDLING WHILE IN 1ST GEAR. THE THROTTLE WOULD STICK FROM 8-14 SECONDS. UPDATED 08/24/10.
Power train, Feb 24, 2010
THE INCIDENT OCCURRED IN A 2006 TOYOTA TACOMA DOUBLE CAB (AUTOMATIC TRANSMISSION) ON DRY PAVEMENT DURING CONGESTED EVENING RUSH-HOUR TRAFFIC IN REDMOND, WASHINGTON, USA. THE VEHICLE WAS COASTING (DECELERATING) UP A GENTLE RIGHT-BENDING GRADE TO A YIELD SIGN FROM SOUTHBOUND 148TH AVE NE TO WESTBOUND REDMOND WAY (RTE 908). AS THE VEHICLE COASTED TO THE YIELD SIGN SLOWING THROUGH A SPEED OF APPROXIMATELY 25-30 MPH, THE VEHICLE SUDDENLY AND UNEXPECTEDLY ACCELERATED AT FULL POWER WITH THE TACHOMETER NEEDLE INDICATING APPROXIMATELY 5000-6000 RPM. THE DRIVER STATES WITH UTMOST CERTAINTY THAT HIS FOOT WAS NOT IN CONTACT WITH THE ACCELERATOR PEDAL IMMEDIATELY PRIOR TO OR DURING THE ACCELERATION. THE VEHICLE'S CRUISE CONTROL WAS TURNED ON BUT THE DRIVER STATES WITH UTMOST CERTAINTY THAT THE CRUISE CONTROL WAS NOT SET/ENGAGED IMMEDIATELY PRIOR TO OR DURING THE INCIDENT. WITHIN APPROXIMATELY 2 SECONDS OF THE ONSET OF THE RAPID UNEXPECTED ACCELERATION, THE DRIVER APPLIED HEAVY BRAKING AND THE ACCELERATION CEASED. THE VEHICLE OPERATED NORMALLY IMMEDIATELY AFTER THE APPLICATION OF BRAKES. THE DRIVER STATES THAT NO SUBSEQUENT UNEXPECTED ACCELERATIONS HAVE OCCURRED SINCE THE REPORTED INCIDENT. *TR
Power train, Vehicle speed control, Feb 20, 2010
I OWN A 2006 TOYOTA TACOMA PRERUNNER DOUBLE CAB 4X2 V6. I BOUGHT THE TRUCK NEW FROM THE DEALERSHIP AND HAVE EXPERIENCED FOUR INSTANCES WHERE AFTER PRESSING THE GAS PEDAL HARD, THUS INTO OVERDRIVE, THE TRUCK EITHER KEPT SPEEDING UP OR DID NOT REV BACK DOWN. 1ST INSTANCE - ABOUT 6 MONTHS AFTER BUYING THE VEHICLE, I WAS ENTERING THE FREEWAY AND NEEDED TO SPEED UP TO ENTER INTO TRAFFIC AT SPEED. I PRESSED THE GAS PEDAL HARD ENOUGH TO BOOST SPEED. AS I ENTERED TRAFFIC, THE TRUCK JUST KEPT SPEEDING UP. AFTER APPLYING A LIGHT BRAKE, I PUMPED THE GAS PEDAL SEVERAL TIMES AND IT THE TRANSMISSION FINALLY ENGAGED AND GEARED BACK DOWN. 2ND INSTANCE - WHILE LEAVING THE FREEWAY @ 65 MPH I SLOWED TO 45 MPH AND SWITCHED LANES TO THE RIGHT. THEN I APPLIED GAS TO SPEED UP TO MERGE AND THE TRUCK DID NOT SLOW DOWN. AGAIN THE LINK BETWEEN THE THROTTLE AND THE TRANSMISSION DID NOT SEEM TO REACTION AS IN A NORMAL SITUATION. I HAD TO MERGE BACK BECAUSE THE WOULD NOT SLOW DOWN FAST ENOUGH. AFTER 4-5 SECONDS THE TRUCK SLOWED DOWN. 3RD INSTANCE - AGAIN ENTERING THE FREEWAY. I APPLIED PRESSURE TO THE GAS PEDAL TO SPEED UP ENOUGH TO ENTER THE TRAFFIC. THIS TIME THE THROTTLE OPENED FULL BORE. I PUT THE TRUCK IN NEUTRAL, LIGHTLY APPLIED THE BRAKE, AND PUMPED THE GAS PEDAL. AFTER 5 SECONDS THE TRUCK FINALLY REVVED BACK DOWN. I REACHED A SPEED OF OVER 90 MPH IN THIS INSTANCE. 4TH INSTANCE - DRIVING UPHILL THE CAR AUTOMATICALLY INCREASED THROTTLE WITH A SMALL AMOUNT OF ADDITIONAL PRESSURE TO THE PEDAL, THE TRUCK SURGED FORWARD, AGAIN FULL BORE. I USED THE SAME TECHNIQUE AND IT EVENTUALLY SLOWED. THIS PROBLEM IS DEFINITELY NOT A FLOOR MAT PROBLEM. I NOW DRIVE MY TRUCK VERY GINGERLY SO AS NOT TO REPLICATE THE ISSUE. I HAVE TAKEN THE TRUCK TO TWO DEALERSHIPS, BOTH HAVE NOT BEEN HELPFUL OR HAVE RECOGNIZED THE PROBLEM. SAYING THAT "YOUR TRUCK IS NOT ON THE RECALL LIST WE SEE HERE, CALL THIS TOYOTA NUMBER." I KNOW THAT OTHERS WITH THE SAME MODEL HAVE THIS PROBLEM. *TR