2021 Chevrolet Tahoe
Problems, recalls and owner-reported issues
Engine is the leading concern among 453 owner complaints filed for this model year. This is the 9th highest complaint count among 26 Tahoe model years with reports.
Of the 2021 reports, 9 involved a crash and 3 involved a fire. 9 people were injured.
What owners report most often
Recalls and investigations
Fuel system, diesel, storage, tank assemblySep 18, 2025
General Motors, LLC (GM) is recalling certain 2021 Cadillac Escalade, 2021, 2023-2024 Chevrolet Tahoe, and 2022 and 2024 GMC Yukon vehicles equipped with a 6-cylinder diesel engine. The original fuel tank may have been replaced with an incorrect fuel tank, which can allow fuel to leak in a rollover crash.
A fuel leak in the presence of an ignition source increases the risk of a vehicle fire.
Dealers will inspect for the correct fuel tank and replace it, if necessary, free of charge. Owner notification letters were mailed November 5, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252512770. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on September 18, 2025.
Campaign 25V619000 on NHTSA.gov
Engine and engine cooling, engine, hard parts internal/mechanicalApr 24, 2025
General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.
Engine failure increases the risk of a crash.
Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.
Campaign 25V274000 on NHTSA.gov
Power train, automatic transmission, control module, softwareOct 24, 2024
General Motors, LLC (GM) is recalling certain 2020-2022 Chevrolet Silverado 1500, 2500, 3500, GMC Sierra 1500, 2500, 3500, 2021 Cadillac Escalade, Escalade ESV, Chevrolet Tahoe, Suburban, GMC Yukon, and Yukon XL vehicles equipped with diesel engines. The transmission control valve may fail and cause the rear wheels to lock-up.
Rear wheel lock-up can increase the risk of a crash.
Dealers will install new transmission control module software, free of charge. GM will provide a special coverage program to cover the repair of transmissions that are identified by the remedy software as containing a defective control valve. Owner notification letters were mailed December 12, 2024. Owners may contact GM customer service at 1-888-988-7267, Cadillac customer service at 1-800-458-8006, GMC customer service at GMC 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N242454440.
Campaign 24V797000 on NHTSA.gov
Exterior lighting, lighting control module, softwareNov 3, 2022
General Motors, LLC (GM) is recalling certain 2021 Yukon, Yukon XL, Chevrolet Tahoe, Chevrolet Suburban, Cadillac Escalade, and Cadillac Escalade ESV vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Daytime Running Lights that do not deactivate as intended may cause a glare, reducing visibility and increasing the risk of a crash.
Dealers will provide an over-the-air (OTA) update for the Body Control Module software, free of charge. Owner notification letters were mailed December 15, 2022. Owners may contact GM customer service at 1-888-988-7267, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N222382220.
Campaign 22V827000 on NHTSA.gov
Seat belts, critical fastenersAug 11, 2022
General Motors, LLC (M) is recalling certain 2021-2022 Cadillac Escalade, Escalade ESV, Chevrolet Suburban, Tahoe, GMC Yukon, and Yukon XL vehicles equipped with third-row seats. The rivet that retains the buckle to the mounting bracket in the left or right side third-row seat belt buckle assembly may have been improperly formed.
A seat belt with a deformed rivet may not properly restrain an occupant, increasing the risk of injury during a crash.
Dealers will inspect the rivet head formation on both the left and right side third-row seat belt buckle assemblies and replace seat belt buckle assemblies, as necessary, free of charge. Interim owner notification letters informing owners of the safety risk were mailed September 28, 2022. Owner notification letters were mailed on November 1, 2022. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N222372380.
Campaign 22V617000 on NHTSA.gov
Power train, driveline, driveshaftJan 27, 2022
General Motors, LLC (GM) is recalling certain 2021 GMC Yukon, Yukon XL, Cadillac Escalade, Escalade ESV, Chevrolet Suburban, and Chevrolet Tahoe vehicles. The rear wheel driveshaft assemblies may have internal components that were not heat-treated properly, possibly resulting in driveshaft failure.
Driveshaft failure can cause a sudden loss of drive power, increasing the risk of a crash.
Dealers will replace the left and/or right rear driveshaft assemblies, free of charge. Owner notification letters were mailed on March 14, 2022. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006 or GMC customer service at 1-800-462-8782. GM's number for this recall is N212351030.
Campaign 22V036000 on NHTSA.gov
Fuel system, gasoline, delivery, fuel pump, control/drive moduleSep 23, 2021
General Motors, LLC (GM) is recalling certain 2021 Cadillac Escalade, Escalade ESV, Chevrolet Suburban, Tahoe, GMC Yukon, and Yukon XL vehicles. The fuel pump power control module may cause the fuel pump to fail or operate intermittently, which can interrupt fuel flow to the engine, and cause an unexpected engine stall.
An engine stall increases the risk of a crash.
Dealers will replace the fuel pump power control module, free of charge. Owner notification letters were mailed on October 14, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; or GMC customer service at 1-800-462-8782. GM's number for this recall is N212332040.
Campaign 21V739000 on NHTSA.gov
Service brakes, hydraulic, power assist, electric, control module, softwareJul 29, 2021
General Motors, LLC (GM) is recalling certain 2021 Chevrolet Tahoe and GMC Yukon vehicles. Dealer service technicians may have calibrated the brake system incorrectly, affecting Electronic Stability Control (ESC) , traction control, Anti-Lock Brake System (ABS), and braking while towing a trailer.
Overall braking performance may be compromised, increasing the risk of a crash.
Dealers will recalibrate the brake system control module, free of charge. Owner notification letters were mailed on August 27, 2021. Owners may contact Chevrolet customer service at 1-800-222-1202; GMC customer service at 1-800-462-8782. GM's number for this recall is N212340970.
Campaign 21V579000 on NHTSA.gov
Steering, steering control moduleJun 17, 2021
General Motors, LLC (GM) is recalling certain 2021 Cadillac Escalade, Escalade ESV, Chevrolet Suburban, Chevrolet Tahoe, GMC Yukon, and Yukon XL vehicles. A software issue may cause a loss of power steering assist at startup or while driving.
Increased steering effort, particularly at lower speeds, increases the risk of a crash.
The power steering module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed July 13, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; or GMC customer service at 1-800-462-8782. GM's number for this recall is N212333900.
Campaign 21V455000 on NHTSA.gov
Air bags, srs malfunction warning lamp/lightJun 10, 2021
General Motors, LLC (GM) is recalling certain 2021 Buick Envision, Cadillac CT4, CT5, Escalade, Escalade ESV, Chevrolet Tahoe, Corvette, Suburban, GMC Yukon, Yukon XL vehicles. The communications gateway module incorrectly processes a loss of communication with the sensing diagnostic module (SDM), causing the air bag malfunction indicator light to inconsistently illuminate.
The air bag malfunction indicator light may fail to warn the driver of a problem with the air bag, increasing the risk of injury.
The communications gateway module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed on July 1, 2021. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N212338110.
Campaign 21V421000 on NHTSA.gov
Seat belts, rear/otherMar 25, 2021
General Motors, LLC (GM) is recalling certain 2021 Chevrolet Tahoe vehicles. The second-row center seat belt latch may be trapped beneath the trim bezel and therefore inaccessible. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208. "Occupant Crash Protection."
A passenger in the second-row center will be unable to wear a seat belt, increasing the risk of injury in the event of a crash.
GM will notify owners, and dealers will remove the trim bezel, correctly position the seat belt latch plate, and reinstall the trim bezel, free of charge. The recall began April 14, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N212329320.
Campaign 21V210000 on NHTSA.gov
Seat beltsMar 18, 2021
General Motors, LLC (GM) is recalling certain 2021 Cadillac Escalade, Escalade ESV, GMC Yukon, Yukon XL, Chevrolet Suburban, and Tahoe vehicles with third-row seating. The third-row outboard seat belts may have been entrapped or misrouted behind the outboard seat-folding mechanism, which could result in damaged seat belts.
A damaged seat belt can break during a crash, increasing the risk of injury to the occupant.
GM will notify owners, and dealers will inspect the third-row outboard seat belts, replacing any damaged seat belts, and rerouting them if necessary, free of charge. The recall began on April 21, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Cadillac customer service at 1-800-458-8006. GM's number for this recall is N202313000.
Campaign 21V190000 on NHTSA.gov
Fuel system, gasoline, storage, tank assemblyFeb 11, 2021
General Motors, LLC (GM) is recalling certain 2021 Chevrolet Tahoe and GMC Yukon vehicles. The fuel tank assemblies may be missing adhesive between two layers of the fuel tank shell which may result in a fuel leak.
A fuel leak in the presence of an ignition source increases the risk of a fire.
GM will notify owners, and dealers will replace the fuel tank, free of charge. The recall began March 6, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is N212327720.
Campaign 21V064000 on NHTSA.gov
Seat beltsDec 23, 2020
General Motors, LLC (GM) is recalling certain 2020 Chevrolet Bolt EV and 2021 GMC Canyon and Sierra 1500, 2500 and 3500, Yukon, Yukon XL, Cadillac Escalade and Escalade ESV and Chevrolet Blazer, Camaro, Colorado, Equinox, Silverado 1500, 2500 and 3500, Suburban and Tahoe vehicles. Incorrect bolts may have been used at one or more fastening locations to secure the seat belts to the vehicle. If an incorrect bolt was used, the seat belt may not be properly attached to the vehicle.
If a seat belt assembly is not properly attached to the vehicle, the seat belt may not properly restrain an occupant in the event of a crash, increasing the risk of injury.
GM will notify owners, and dealers will replace the suspect bolts, free of charge. The recall began January 29, 2021. Owners may contact GMC customer service at 1-800-462-8785, Cadillac customer service at 1-800-458-8006, or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N202322230.
Campaign 20V811000 on NHTSA.gov
Seat beltsDec 17, 2020
General Motors, LLC (GM) is recalling certain 2019-2021 Chevrolet Silverado 1500 and GMC Sierra 1500, 2021 Chevrolet Suburban and Tahoe and GMC Yukon XL and 2020-2021 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 vehicles. The seat belt brackets may not be secured to the seat frame in the front-row center seating position.
If a seat-belt bracket is not secured, the seat belt may not properly restrain an occupant in the front-row center seat position, increasing the risk of injury in a crash.
GM will notify owners, and dealers will inspect left-side and right-side front-row center seat-belt bracket attachments and reassemble it correctly as necessary, free of charge. The recall began January 26, 2021. Owners may contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N202314670.
Campaign 20V792000 on NHTSA.gov
SeatsNov 25, 2020
General Motors LLC (GM) is recalling certain 2021 Chevrolet Suburban and Tahoe and GMC Yukon and Yukon XL vehicles. During general assembly, a repair involved removal of one or both front seats. The attachment bolts for the front seats may not have been properly reinstalled after the repair was completed.
If an occupied front seat has loose or missing attachment bolts, it may move during a crash, increasing the risk of injury to the seated occupant.
GM will notify owners, and dealers will inspect the seat attachments for both front seats and install attachment bolts as needed, free of charge. The recall began December 21, 2020. Owners may contact Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-888-988-7267. GM's number for this recall is N202312720.
Campaign 20V735000 on NHTSA.gov
Representative owner complaints: engine
184 reports, newest first. Show all
Engine, May 12, 2026
On May 2nd 2026 I was driving my 2021 Tahoe high country with the 6.2 motor at 60 mph and started to slow down before my left hand turn. In the process of slowing down at about 40mph I heard a loud bang/thud noise. The car had completely shut down all motor related usage. I coasted into the shoulder on the side of the road the vehicle would not restart. I had my children and wife in the car. There were no check engine lights or any other warning signs on the dash prior to this happening. The Tahoe was running perfectly fine. Ended up needing the vehicle towed to the chevrolet dealership. It was confirmed upon dealership inspection by the mechanic that an intake valve spring broke and locked up the engine. We currently are being denied coverage through our extended warranty with endurance to replace the engine.
Service brakes, Hydraulic, Engine, Lane departure, May 11, 2026
The contact owns a 2021 Chevrolet Tahoe. The contact stated while driving at an undisclosed speed, the contact stated that several warning lights illuminated. The vehicle was towed to the dealer where it was diagnosed with a failed engine, lane departure modular and the brake master cylinder. The contact was informed that the engine, lane departure modular and the brake master cylinder needed to be replaced. The vehicle was not repaired. The contact was informed that the lane departure module was in back order. The manufacturer was made aware of the failure and a case was filed. The contact was advised to contact the NHTSA Hotline and report the failure. The failure mileage was approximately 78,026.
Engine, May 11, 2026
Engine has developed a miss and has check engine code P0300 random misfires. There are subcodes pending of P0011 and P0016 indicating Crank and Cam misalignment. This has all the classic signs for a failing engine. I am taking this truck in for the GM Picoscope test, the oil was changed to 0w40 mobile one supercar oil approx. 2,800 miles ago when the truck was under Powertrain warranty. I will preform a Blackstone oil test to determine if there is abnormal engine wear. My truck is not in the vin. recall range.
Other or unspecified, Engine, Fuel/propulsion system, Apr 30, 2026
Check engine light illuminated on my 2021 Chevrolet Tahoe. Upon diagnostic scan, the following emissions-related fault codes were present: P11D5 (NOx sensor), P14D9 (NOx sensor), P2383 (EGR pressure sensor), and P2C7A (NOx catalytic converter efficiency). All components are available for inspection upon request. The vehicle was taken to an authorized Chevrolet dealership for diagnosis. The dealer acknowledged the emissions codes but stated that unrelated components would need to be repaired at owner expense before the emissions system would be addressed, despite these codes falling within the federally mandated 8-year/80,000-mile emissions warranty. The fault codes were confirmed by the dealership. No safety incident has occurred to date, however degraded NOx and EGR function can result in increased harmful emissions output and potential engine performance issues. Warning lamps appeared without prior incident or symptom. The manufacturer has not offered to cover the emissions components under the federal emissions warranty without the owner first paying for additional repairs that may or may not be causally related to the emissions system failure. When the dealer was directly asked, "Are you saying the emissions system itself is functioning correctly, and something else caused these codes to appear?" — the dealer did not provide an answer. This question was asked in order to clarify whether the emissions components themselves are degraded or failed, which would confirm warranty coverage eligibility. The dealer's failure to answer this question directly is noted as part of this complaint.
Engine and engine cooling, Apr 30, 2026
The contact owns a 2021 Chevrolet Tahoe. The contact stated that while driving 65 MPH, there was an abnormal vibration coming from the engine compartment and felt in the steering wheel. The check oil warning light illuminated. The vehicle was taken to the residence and then to the dealer, where it was determined that the vehicle was functioning properly, and there was no oil leak; however, the oil level was low even though an oil change was not yet due. The dealer added oil to the vehicle, and an oil consumption test was ordered. The manufacturer was notified of the failure and a complaint was filed. The vehicle was not repaired. The failure mileage was approximately 48,000.
Engine, Apr 28, 2026
Urgent: Engine Failure Following Recent Service – 2021 Chevrolet Tahoe To Whom It May Concern, I am writing to formally request assistance and an investigation regarding a serious engine failure involving my 2021 Chevrolet Tahoe. In July 2025, I paid out of pocket to have the lifters and camshaft replaced on this vehicle. More recently, while traveling, the vehicle broke down and was taken to Uebelhor Chevrolet, where the valve body in the transmission was replaced. After picking the vehicle up from Uebelhor Chevrolet, the vehicle broke down again approximately one hour later while in Henderson, Kentucky. At that time, the engine began smoking, running rough, and misfiring. I checked the oil level during the incident and found it to be extremely low on the dipstick (I have photographic evidence of this condition). The vehicle had to be towed to Kate Faupel Chevrolet for further inspection. I was then informed that the engine has a dropped lifter on cylinder #8 and possible camshaft damage. Given the following factors: Recent out-of-pocket lifter and camshaft replacement (July 2025) Immediate failure shortly after leaving a Chevrolet dealership Extremely low oil level observed at the time of breakdown (with photo documentation) Diagnosis consistent with potential oil starvation and internal engine damage I am requesting that General Motors conduct a full review of this situation to determine responsibility. This raises serious concerns about a potential defect, improper prior repair, or a service-related issue that resulted in catastrophic engine damage. At this time, I am not authorizing repairs until liability is determined. I am requesting: A formal case review and investigation Assistance with repair or full engine replacement Guidance on how this situation will be resolved This incident created a significant safety concern, as the vehicle became disabled shortly after leaving a dealership during travel. Please contact me as soon as possible to discuss next steps
Engine, Apr 24, 2026
Vehicle is prompting a “decreased acceleration “ warning, will not shift past 3rd gear, and will not shift into reverse.
Suspension, Engine, Apr 13, 2026
Suspension system failed- had to replaced, Car difficult to control when operating. Repaired by dealer- Country Chevrolet, Benton KY- owner paid for repair. [XXX] Engine failure- knocking and difficult to drive on returning trip from Louisville KY to Benton, KY. Taken to dealer on 4.6.2026 - made it without being towed- extremely slow- traffic hazard- Tahoe has lots of road miles- always repaired and serviced by dealer. There were no warning lights, symbols or indicators that there was a problem. Dealer still determining the extent of the damage. [XXX] Benton KY INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Power train, Engine, Forward collision avoidance, Apr 12, 2026
The component at issue is the engine, which suffered a sudden and catastrophic failure due to unknown causes. At no time prior to this incident were there any warnings, symptoms, or indications of an underlying mechanical defect that would have allowed for preventative action. While operating the vehicle on the highway with my family present, multiple warning indicators activated simultaneously, including a blinking check engine light, traction control light, ESC warning, and a forward collision warning. Immediately thereafter, the vehicle experienced a rapid and significant loss of power accompanied by a loud and persistent engine knocking noise, rendering the vehicle unsafe to operate and placing the occupants at risk. It is important to emphasize that traction control and ESC systems are not causally related to an engine misfire condition, further supporting that this event was abrupt and not part of a progressive or diagnosable issue. A diagnostic scan performed at that time identified a misfire in cylinder 1. Upon delivery of the vehicle to the dealership for inspection, it was determined that the engine had suffered complete internal failure and was deemed “blown.” This finding confirms the occurrence of a catastrophic mechanical breakdown. Based on the sudden onset, absence of prior warning, and severity of the failure, there is no reasonable basis to attribute this condition to normal wear and tear, operator misuse, or neglect. Rather, the facts support the conclusion that this was the result of a latent defect or internal mechanical failure beyond the operator’s control. Accordingly, this matter should be addressed under applicable warranty coverage or consumer protection standards.
Electrical system, Engine, Apr 10, 2026
During highway driving, alert on dashboard stated “electrical system failing enter idle mode”. Tahoe slowed down and then engine began knocking right as it shut off resulting in needing to coast to the shoulder of the highway safely since engine was off. Towed to dealership and then they came back saying needed a new battery, new alternator belt, pulley and water compartment. After those installed, additional call was made indicating the engine needed a full replacement as it keeps overheating despite no sensor alerts and codes are being tripped. Here we are asked to pay 16K for new engine install and unable to fix.
Engine and engine cooling, Apr 7, 2026
The contact owns a 2021 Chevrolet Tahoe. The contact stated that while driving approximately 45 MPH, the check engine warning light illuminated, and the message “Reduced Acceleration - Drive Safely” was displayed. The vehicle then started shaking abnormally. The contact pulled into a nearby parking lot, turned off the vehicle, and waited for a while before restarting the vehicle. After restarting the vehicle, the warning lights remained illuminated, and the vehicle continued to shake abnormally. The vehicle was taken to Auto Zone, where a certified mechanic diagnosed the vehicle and determined that there was a bent rod inside the engine. The vehicle was not repaired. The vehicle was taken to the dealer, who confirmed the diagnostic result and that the failure was causing additional damage to the crankshaft. The dealer determined that there was a misfire in the engine and that the valve lifter was malfunctioning. The contact was informed that the lifter and the camshaft needed to be replaced, and the engine needed to be repaired. The vehicle was not repaired. The contact researched and became aware of NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling); however, the VIN was not included. The manufacturer was informed of the failure and confirmed that the VIN was not included in the recall. The contact was referred to the dealer to inquire about a Goodwill Repair for which the contact could be reimbursed if the VIN was later added to the recall. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 100,000.
Engine, Apr 6, 2026
Motor is not included in the 6.2 recall for some reason. It is consistently burning through 3 qts of oil every 2-3k miles. This is a major concern considering I travel a lot. I want to know why this specific motor isn’t covered in the recall considering it is having the same issues as the current recall. This has been an ongoing issue and I have been waiting for a recall notice. GM dealership says there is no recall and won’t ever be one.
Engine, Mar 26, 2026
On March 14,2026 I was driving 80 MPH on the interstate and the vehicle shifted to Neutral and shutoff. Shortly before that the vehicle revved to 4000 RPM and you could feel rhythmic vibrations. The vehicle was towed to a Chevy dealership and diagnosed as loss of propulsion needing a new engine. Tahoe had 104,000 miles at failure.
Engine, Mar 18, 2026
I was driving down I-5 at 75mph and the truck shut off while driving. Couldn’t get to start. Paid over $1k for a new battery cause dealership couldn’t replicate problem. Next day doing 75mph on freeway engine through a rod.
Electrical system, Engine, Fuel/propulsion system, Mar 15, 2026
Since March of 2025 I have identified a critical safety defect with my vehicle. When driving and without warning, the vehicle unexpectedly shifts to neutral, experiences a loss of propulsion, and the engine shuts off. This has occurred multiple times in which I narrowly escaped collisions with other vehicles or objects. If this would occur at a high rate of speed, it would certainly result in serious accident including possible fatality. I have experienced three near-accident scenarios when I had children in the vehicle. I have worked with Classic Chevrolet in Sugar Land, Texas who has made six attempts at repair. They have each time found a different component attribute to an error code and replaced that part. After each visit they tell me that the car is fixed and safe to drive. They have never been able to provide a clear explanation as to why I am experience this reoccurring issue, but attribute it to a different part each time. Within 5 days to 2 months, the incident repeats. I have recent video of the incident that I can share. Chevrolet Customer Care has been minimized my concern and informs me that their Service staff has found the vehicle to be fully operational and safe to operate. I have spent over $6,000 in failed repairs. I do not feel safe operating this vehicle. That list of repairs includes: March 7, 2025 - battery replacement March 28, 2025 - DC/DC power converter April 22, 2025 - ECM updates January 8, 2026 - •Throttle body replacement •Serpentine belt replacement •Engine air filter replacement •Transmission fluid flush •Coolant fluid flush •Fuel injection cleaning •Hydrogen carbon cleaning service January 23, 2026 - power control module (recall) January 30, 2026 - rear differential system replacement March 10, 2026 - • Replacement of the high-pressure fuel pump • Replacement of the DC power supply converter • Hydrogen carbon cleaning service I can share all invoices. Chevy is NOT TAKING THIS MATTER SERIOUSLY. Please support
Engine and engine cooling, Mar 11, 2026
The contact owns a 2021 Chevrolet Tahoe. The contact stated that the engine was consuming an excessive amount of oil, and there was an abnormal knocking sound coming from the engine. Additionally, the vehicle hesitated and failed to accelerate as needed, with blue smoke coming from the exhaust pipes. The check engine warning light was intermittently illuminated. The vehicle was taken to the dealer, who determined that there were metal shavings in the engine oil and that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 51,000.
Electrical system, Engine, Forward collision avoidance, Mar 7, 2026
My truck was driving perfect and I went to pull into a parking lot in Arkansas where I live in long story short it started acting funny trying to idle out and then I heard a knocking noise. It happened twice. Then my service ESV light come on next my motor light come on then my auto for a collision system failure light come on. It’s on the dash anyway my vehicle is not running around. It has hardly no power and I smell something under the hood from time to time burning it’s kinda like an electrical smell. I’m not sure. I’m not a mechanic. I’m a [XXX]. I’m a [XXX]!!! but I have to have a way back back-and-forth to work and I cannot drive this vehicle. I have been driving it to work and just straight to home and that’s only like a mile from the shop but I need a replacement vehicle I need to sell mine at wholesale value as you guys said you would that would be greatly appreciated. God bless you guys. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Engine and engine cooling, Mar 6, 2026
The contact owns a 2021 Chevrolet Tahoe. The contact stated that while driving at various speeds, the Forward Collision Avoidance message was intermittently displayed. The vehicle was taken to a dealer, where a computer module was replaced. While driving at various speeds, there was an intermittent knocking sound coming from the engine, with the check engine warning light illuminated. While driving at an undisclosed speed, the knocking sound became constant. The vehicle was driven to the dealer, and upon inspection, the mechanic discovered a bent engine rod inside the engine. The vehicle was diagnosed with engine failure, and the contact was provided an estimate for the repair. Upon investigation, the contact discovered the failure was associated with NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling). The manufacturer was initially notified of the failure through the dealer, and the contact was later informed that the manufacturer agreed to cover half the cost of an engine replacement. Upon calling the manufacturer directly, the contact was referred to the NHTSA Hotline to report the failure. The vehicle was not repaired and remained with the dealer. The failure mileage was approximately 72,000.
Steering, Power train, Engine, Mar 1, 2026
#1 ) el motor presento esta fallas en las 98mil millas, el motor empezó con un alto consumo de aceite de 5 cuartos de aceite cada 3 mil millas, en repetidas ocasiones estábamos de viaje junto a mi familia, mi esposa, [XXX]. Un dia Hicimos una para frente a un semáforo, y en seguida el vehículo empezo a tirar una gran cantidad de humo blanco por la salida de los escapes, mis hijas entraron en pánico una de ellas intento salir del vehículo en plena calle principal, ella sintió miedo y pensó que el vehículo se estaba incendiando. En ese momento le dije que es un problema de el vehículo pero que no era incendio. El humo que sale repentinamente es derivado de el excesivo consumo de de aceite en el motor. A mi punto de vista esto representa un alto riesgo en la carretera. Poniendo riesgo la vida de mi familia, la mía misma y la terceros en la carretera. El aceite que consume significa que esta llegando a las cámaras de combustión en el motor y esto puede deribar, que en un momento determinado el aceite sirva como combustible y el vehículo en marcha se acelere sin control y provocar graves danos a la integridad de mi familia y asta la muerte de terceras personasla carretera. #2) la transmisión en este vehículo tironea bruscamente cuando hace un cambio de velocidad esto representa un alto riesgo para mi familia, este vehículo representa un alto riesgo de que cuando haga un cambio de marcha rompa algunos componentes internos y esto lleve a una parada repentina y provocar un accidente mortal. #3) últimamente este vehículo a presentado inestabilidad en el volante, a la fecha de esta nota el problema tiene al rededor 5 días . El vehículo se llevo al consecionario Maik Chevrolet ubicado en 11711 Katy fresa y, houston tx 77079, ellos hicieron las respectivas pruebas en el vehículo y determinaron que el vehículo no era apto para estar en la carrtera debido a las fallas que presenta en la transmisión y el motor. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Engine, Feb 23, 2026
My 2021 Chevrolet Tahoe engine seized while I was driving on the highway. All I heard was a loud clunk then there was a sudden power loss while I was driving before I could even get to the side of the road. I had to pay, out of pocket, to get a tow because the vehicle failed to crank or start. I had the vehicle towed to the Chevy dealership in Paramus, NJ just to find that this is a known recalled issued with the 5.3L, V8 engines which is the engine my vehicle has. There seem to be problems specifically regarding defective connecting rods or the crankshaft but for some strange reason my vehicle's vin number is not included in this recall although it is the same year, same vehicle, same engine and same problem. My vehicle should be included in the recall so it can be repaired for free at the chevy dealership in Paramus, NJ as I use this vehicle to transport children and that is very unsafe to have this defect and not fix it for free when it is not the fault of the driver.
Engine, Feb 15, 2026
While driving home late at night, the vehicle experienced a sudden mechanical failure in the engine. I was traveling approximately 2 miles per hour while slowing to stop at a stop sign when there was a loud “clunk,” followed by an abrupt stop of the vehicle. Immediately after this occurred, multiple dashboard warning lights illuminated, and a knocking sound began coming from the engine. The vehicle is currently not operating normally and is available for inspection upon request. This incident occurred late at night while I was driving with my two young children in the vehicle. The sudden and unexpected stop put us at risk of being rear-ended or stranded in an unsafe location. The loss of normal vehicle operation created a dangerous situation, especially given the time of night, location, and the presence of my children. There were no warning lights, messages, or noticeable symptoms prior to the incident. All warning lights illuminated only after the loud clunk and abrupt stop occurred. The knocking sound from the engine began immediately following the failure. I now am in a rental car that costs $700 a week that my insurance doesn’t cover.
Power train, Vehicle speed control, Engine, Feb 13, 2026
The contact owns a 2021 Chevrolet Tahoe. The contact stated that while driving and attempting to slow down to approximately 35 MPH, there was an abnormal clunking sound coming from the vehicle. The contact believed that the sound was caused by ice buildup on the mud flap, but shortly afterwards, the engine revved unexpectedly, with the check engine warning light illuminated, and the message “Reduce Acceleration - Drive with Care” was displayed. The vehicle started to coast unintendedly. The contact stated the vehicle returned to normal operation after a short while. The vehicle was taken to a local dealer to be diagnosed. The mechanics pushed the vehicle out of the parking spot before inspecting the vehicle. The vehicle was diagnosed with transmission valve body failure. The contact was informed that the transmission valve body needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline to report the failure. The approximate failure mileage was 88,342
Engine, Feb 11, 2026
The contact owns a 2021 Chevrolet Tahoe. The contact stated that while his wife was driving out of the driveway and driving approximately 20 MPH, the driver became aware of an abnormal flapping sound that became louder as the vehicle accelerated. Additionally, the contact stated while his wife was driving approximately 60-65 MPH on another occasion, the check engine warning light illuminated. The driver pulled over to the side of the road. The vehicle was towed to the residence, where a mobile independent mechanic diagnosed the vehicle with a misfire in cylinder #8. The mechanic determined that both sides of the engine lifters, the gaskets, and other unknown parts needed to be replaced. The vehicle was not repaired due to the cost. The dealer and the manufacturer were not contacted. The vehicle warranty company was contacted and informed the contact that the vehicle was not covered under warranty. The failure mileage was approximately 93,000.
Engine, Fuel/propulsion system, Feb 2, 2026
1ST ISSUE: 9/2025, after driving from another city to my home at 55-75 mph. As I pulled up home, the car just stalled and wouldn't start. I googled issue to find out it was a commonly known issue by GM. If fuel pump control module had happened while driving faster and not on my street to roll up to curb. I would have or could have been deadly. I find out what part # and local dealer knew there was a recall but told me he never heard about it and charged me for part. I installed in front of home on street and have been trying to get money back after reporting to GM I repaired my fuel pump control module and have been trying to get my money back from a repair done on 9/29/2025 by me. GM says it's looking into still after I keep calling them on status of this notice. I still have old part. I have filled out all reimbursement forms.1st the danger of it failing and now no money. By the time engine light comes on you have no power for any stopping or steering. #2 engine 2021 Tahoe High Country 6.2 L V8: NO RECALL HAS BEEN SENT. GM has known about an engine that has multiple failure issues that could GET YOU IN A SERIOUS ACCIDENT/death BY JUST STOP RUNNING, while just driving at any moment, INTERNAL FAILURES and main seal leaks, MORE! Mine just poured oil out on driveway after driving 6 miles to church and back. this will be the largest and most deadly auto issue in history. They even had dealers now with any on lot with this engine a stop sale order. aprox. 800,000 of these engines are out there, Local GM dealer says THERE IS NO RECALL. 2021 TO 2026 and they have only changed out aprox. 2800 engines and telling me mine sitting in driveway is not on recall. BS. these engines are in their high-end trucks, SUV's, Escalades. Someone needs to get Gm to do what's right and replace with new engines. That have been tested, all issues before someone has to die. Trying to keep silent on internet is sad. Yes its going to cost billions. But to keep customers safe and not scared.
Engine, Feb 1, 2026
The vehicle stalled while driving down the road and started making a loud ticking noise, the engine light went on. It was brough to the dealership where they did an engine rebuild. They replaced 16 lifters and camshaft, a pulley belt and gaskets. The vehicle was picked up, however, a month later the oil low add oil light came on and the oil tank was more than 2.5 quarts low indicating extreme burning of oil. The vehicle is shuttering on acceleration of low RPMs. Brought it back to the dealership and awaiting further instruction. It caused a major safety concern because it has the potential to stall due to a motor defect on a major highway, putting my family and possibly others at risk of harm or death.