2021 Chevrolet Tahoe
Problems, recalls and owner-reported issues
Engine is the leading concern among 453 owner complaints filed for this model year. This is the 9th highest complaint count among 26 Tahoe model years with reports.
Of the 2021 reports, 9 involved a crash and 3 involved a fire. 9 people were injured.
What owners report most often
Recalls and investigations
Fuel system, diesel, storage, tank assemblySep 18, 2025
General Motors, LLC (GM) is recalling certain 2021 Cadillac Escalade, 2021, 2023-2024 Chevrolet Tahoe, and 2022 and 2024 GMC Yukon vehicles equipped with a 6-cylinder diesel engine. The original fuel tank may have been replaced with an incorrect fuel tank, which can allow fuel to leak in a rollover crash.
A fuel leak in the presence of an ignition source increases the risk of a vehicle fire.
Dealers will inspect for the correct fuel tank and replace it, if necessary, free of charge. Owner notification letters were mailed November 5, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252512770. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on September 18, 2025.
Campaign 25V619000 on NHTSA.gov
Engine and engine cooling, engine, hard parts internal/mechanicalApr 24, 2025
General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.
Engine failure increases the risk of a crash.
Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.
Campaign 25V274000 on NHTSA.gov
Power train, automatic transmission, control module, softwareOct 24, 2024
General Motors, LLC (GM) is recalling certain 2020-2022 Chevrolet Silverado 1500, 2500, 3500, GMC Sierra 1500, 2500, 3500, 2021 Cadillac Escalade, Escalade ESV, Chevrolet Tahoe, Suburban, GMC Yukon, and Yukon XL vehicles equipped with diesel engines. The transmission control valve may fail and cause the rear wheels to lock-up.
Rear wheel lock-up can increase the risk of a crash.
Dealers will install new transmission control module software, free of charge. GM will provide a special coverage program to cover the repair of transmissions that are identified by the remedy software as containing a defective control valve. Owner notification letters were mailed December 12, 2024. Owners may contact GM customer service at 1-888-988-7267, Cadillac customer service at 1-800-458-8006, GMC customer service at GMC 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N242454440.
Campaign 24V797000 on NHTSA.gov
Exterior lighting, lighting control module, softwareNov 3, 2022
General Motors, LLC (GM) is recalling certain 2021 Yukon, Yukon XL, Chevrolet Tahoe, Chevrolet Suburban, Cadillac Escalade, and Cadillac Escalade ESV vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Daytime Running Lights that do not deactivate as intended may cause a glare, reducing visibility and increasing the risk of a crash.
Dealers will provide an over-the-air (OTA) update for the Body Control Module software, free of charge. Owner notification letters were mailed December 15, 2022. Owners may contact GM customer service at 1-888-988-7267, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N222382220.
Campaign 22V827000 on NHTSA.gov
Seat belts, critical fastenersAug 11, 2022
General Motors, LLC (M) is recalling certain 2021-2022 Cadillac Escalade, Escalade ESV, Chevrolet Suburban, Tahoe, GMC Yukon, and Yukon XL vehicles equipped with third-row seats. The rivet that retains the buckle to the mounting bracket in the left or right side third-row seat belt buckle assembly may have been improperly formed.
A seat belt with a deformed rivet may not properly restrain an occupant, increasing the risk of injury during a crash.
Dealers will inspect the rivet head formation on both the left and right side third-row seat belt buckle assemblies and replace seat belt buckle assemblies, as necessary, free of charge. Interim owner notification letters informing owners of the safety risk were mailed September 28, 2022. Owner notification letters were mailed on November 1, 2022. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N222372380.
Campaign 22V617000 on NHTSA.gov
Power train, driveline, driveshaftJan 27, 2022
General Motors, LLC (GM) is recalling certain 2021 GMC Yukon, Yukon XL, Cadillac Escalade, Escalade ESV, Chevrolet Suburban, and Chevrolet Tahoe vehicles. The rear wheel driveshaft assemblies may have internal components that were not heat-treated properly, possibly resulting in driveshaft failure.
Driveshaft failure can cause a sudden loss of drive power, increasing the risk of a crash.
Dealers will replace the left and/or right rear driveshaft assemblies, free of charge. Owner notification letters were mailed on March 14, 2022. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006 or GMC customer service at 1-800-462-8782. GM's number for this recall is N212351030.
Campaign 22V036000 on NHTSA.gov
Fuel system, gasoline, delivery, fuel pump, control/drive moduleSep 23, 2021
General Motors, LLC (GM) is recalling certain 2021 Cadillac Escalade, Escalade ESV, Chevrolet Suburban, Tahoe, GMC Yukon, and Yukon XL vehicles. The fuel pump power control module may cause the fuel pump to fail or operate intermittently, which can interrupt fuel flow to the engine, and cause an unexpected engine stall.
An engine stall increases the risk of a crash.
Dealers will replace the fuel pump power control module, free of charge. Owner notification letters were mailed on October 14, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; or GMC customer service at 1-800-462-8782. GM's number for this recall is N212332040.
Campaign 21V739000 on NHTSA.gov
Service brakes, hydraulic, power assist, electric, control module, softwareJul 29, 2021
General Motors, LLC (GM) is recalling certain 2021 Chevrolet Tahoe and GMC Yukon vehicles. Dealer service technicians may have calibrated the brake system incorrectly, affecting Electronic Stability Control (ESC) , traction control, Anti-Lock Brake System (ABS), and braking while towing a trailer.
Overall braking performance may be compromised, increasing the risk of a crash.
Dealers will recalibrate the brake system control module, free of charge. Owner notification letters were mailed on August 27, 2021. Owners may contact Chevrolet customer service at 1-800-222-1202; GMC customer service at 1-800-462-8782. GM's number for this recall is N212340970.
Campaign 21V579000 on NHTSA.gov
Steering, steering control moduleJun 17, 2021
General Motors, LLC (GM) is recalling certain 2021 Cadillac Escalade, Escalade ESV, Chevrolet Suburban, Chevrolet Tahoe, GMC Yukon, and Yukon XL vehicles. A software issue may cause a loss of power steering assist at startup or while driving.
Increased steering effort, particularly at lower speeds, increases the risk of a crash.
The power steering module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed July 13, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; or GMC customer service at 1-800-462-8782. GM's number for this recall is N212333900.
Campaign 21V455000 on NHTSA.gov
Air bags, srs malfunction warning lamp/lightJun 10, 2021
General Motors, LLC (GM) is recalling certain 2021 Buick Envision, Cadillac CT4, CT5, Escalade, Escalade ESV, Chevrolet Tahoe, Corvette, Suburban, GMC Yukon, Yukon XL vehicles. The communications gateway module incorrectly processes a loss of communication with the sensing diagnostic module (SDM), causing the air bag malfunction indicator light to inconsistently illuminate.
The air bag malfunction indicator light may fail to warn the driver of a problem with the air bag, increasing the risk of injury.
The communications gateway module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed on July 1, 2021. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N212338110.
Campaign 21V421000 on NHTSA.gov
Seat belts, rear/otherMar 25, 2021
General Motors, LLC (GM) is recalling certain 2021 Chevrolet Tahoe vehicles. The second-row center seat belt latch may be trapped beneath the trim bezel and therefore inaccessible. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208. "Occupant Crash Protection."
A passenger in the second-row center will be unable to wear a seat belt, increasing the risk of injury in the event of a crash.
GM will notify owners, and dealers will remove the trim bezel, correctly position the seat belt latch plate, and reinstall the trim bezel, free of charge. The recall began April 14, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N212329320.
Campaign 21V210000 on NHTSA.gov
Seat beltsMar 18, 2021
General Motors, LLC (GM) is recalling certain 2021 Cadillac Escalade, Escalade ESV, GMC Yukon, Yukon XL, Chevrolet Suburban, and Tahoe vehicles with third-row seating. The third-row outboard seat belts may have been entrapped or misrouted behind the outboard seat-folding mechanism, which could result in damaged seat belts.
A damaged seat belt can break during a crash, increasing the risk of injury to the occupant.
GM will notify owners, and dealers will inspect the third-row outboard seat belts, replacing any damaged seat belts, and rerouting them if necessary, free of charge. The recall began on April 21, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Cadillac customer service at 1-800-458-8006. GM's number for this recall is N202313000.
Campaign 21V190000 on NHTSA.gov
Fuel system, gasoline, storage, tank assemblyFeb 11, 2021
General Motors, LLC (GM) is recalling certain 2021 Chevrolet Tahoe and GMC Yukon vehicles. The fuel tank assemblies may be missing adhesive between two layers of the fuel tank shell which may result in a fuel leak.
A fuel leak in the presence of an ignition source increases the risk of a fire.
GM will notify owners, and dealers will replace the fuel tank, free of charge. The recall began March 6, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is N212327720.
Campaign 21V064000 on NHTSA.gov
Seat beltsDec 23, 2020
General Motors, LLC (GM) is recalling certain 2020 Chevrolet Bolt EV and 2021 GMC Canyon and Sierra 1500, 2500 and 3500, Yukon, Yukon XL, Cadillac Escalade and Escalade ESV and Chevrolet Blazer, Camaro, Colorado, Equinox, Silverado 1500, 2500 and 3500, Suburban and Tahoe vehicles. Incorrect bolts may have been used at one or more fastening locations to secure the seat belts to the vehicle. If an incorrect bolt was used, the seat belt may not be properly attached to the vehicle.
If a seat belt assembly is not properly attached to the vehicle, the seat belt may not properly restrain an occupant in the event of a crash, increasing the risk of injury.
GM will notify owners, and dealers will replace the suspect bolts, free of charge. The recall began January 29, 2021. Owners may contact GMC customer service at 1-800-462-8785, Cadillac customer service at 1-800-458-8006, or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N202322230.
Campaign 20V811000 on NHTSA.gov
Seat beltsDec 17, 2020
General Motors, LLC (GM) is recalling certain 2019-2021 Chevrolet Silverado 1500 and GMC Sierra 1500, 2021 Chevrolet Suburban and Tahoe and GMC Yukon XL and 2020-2021 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 vehicles. The seat belt brackets may not be secured to the seat frame in the front-row center seating position.
If a seat-belt bracket is not secured, the seat belt may not properly restrain an occupant in the front-row center seat position, increasing the risk of injury in a crash.
GM will notify owners, and dealers will inspect left-side and right-side front-row center seat-belt bracket attachments and reassemble it correctly as necessary, free of charge. The recall began January 26, 2021. Owners may contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N202314670.
Campaign 20V792000 on NHTSA.gov
SeatsNov 25, 2020
General Motors LLC (GM) is recalling certain 2021 Chevrolet Suburban and Tahoe and GMC Yukon and Yukon XL vehicles. During general assembly, a repair involved removal of one or both front seats. The attachment bolts for the front seats may not have been properly reinstalled after the repair was completed.
If an occupied front seat has loose or missing attachment bolts, it may move during a crash, increasing the risk of injury to the seated occupant.
GM will notify owners, and dealers will inspect the seat attachments for both front seats and install attachment bolts as needed, free of charge. The recall began December 21, 2020. Owners may contact Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-888-988-7267. GM's number for this recall is N202312720.
Campaign 20V735000 on NHTSA.gov
Representative owner complaints: engine
184 reports, newest first. Show all
Engine, Fuel/propulsion system, Jun 27, 2025
I was driving home from a long trip and heard a large pop. Several warning signs and messages began popping up and the vehicle was shaking and struggling to maintain speed. I was able to get home and get my family out of the vehicle and get it to a dealer down the road. They stated the Fuel injector and harness had failed.
Engine, Jun 25, 2025
[XXX] # [XXX] VIN = [XXX] MAKE ; Chevrolet Tahoe 2021 RE : I received a recall affects certain 2021-2024 models equipped with the 6.2L V8 L87 engine. The defect involves the connecting rod and/or crankshaft engine components, potentially leading to engine damage or failure. On March 2025, My Tohoe completely stopped while I was driving. My SUV was towed to Bomnin Chevrolet in Manassas Virginia. They diagnois was crank shaft damage leading to engine failure. My SUV was in the dealership for 2 weeks while the engine was replaced. I spent a total of $ 15,027.20 to fix my car for that problem. I called GM recall about this problem. I was informed that the recall was for only certain vehicles. Not my SUV. I am concerned that my SUV was affected by faulty crank chaft. I had to replace the engine. Thanks, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Engine, Fuel/propulsion system, Forward collision avoidance, Jun 19, 2025
several issues with certain popups regarding various indicators on dash and engine not getting enough psi
Engine, Fuel/propulsion system, Jun 18, 2025
Unknown - engine is driving hard and somethings wrong. No one will service my car because they say it’s on a recall, but then when they look up the VIN number it’s not on a recall however there are major issues going on.
Engine and engine cooling, Jun 17, 2025
The contact owned a 2021 Chevrolet Tahoe. The contact stated while driving approximately 60 MPH, the check engine warning light illuminated, and the vehicle started losing motive power. The contact stated there was an abnormal ticking sound coming from the engine compartment. The contact stated that the vehicle slowed to approximately 10 MPH with black smoke coming from the exhaust pipe. The contact was able to drive the vehicle to a dealer. The dealer diagnosed the vehicle and determined that the engine connecting rods had failed and needed to be replaced. The contact researched online and related the failure to NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling); however, the VIN was not included in the recall. The vehicle was repaired. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 85,000.
Engine, Jun 16, 2025
On April 25th, 2025 while traveling on Interstate 20 at 70+mph speeds with my children in my vehicle and 30 weeks pregnant, with no indication of an issue my 2021 Chevrolet Tahoe suffered catastrophic engine failure. There was zero warning from the vehicle including noises/electronic display warnings that this was fixing to occur. In the middle of going 70+mph surrounded by traffic on a busy interstate the vehicle just shut off completely. I was able to use what momentum I had from my speed to get on to the shoulder. However, the failure prevented me from being able to turn on my signal to alert other drivers of my merging and prevented the use of my emergency flashers to signal once on the shoulder immobile. The vehicle would not start up again after that, and I had to call a tow truck to take my vehicle to the nearest certified Chevrolet service center. When the tow truck arrived the vehicle would not even shift into neutral allowing them to load it without potentially causing more damage. It had to be drug with the wench in park onto the tow truck bed. Once at the nearest service center I was told it would be up to 3 weeks + before they could do a diagnostics. I was 14 hours from home when this happened, and now had to pay to have my Tahoe towed 14 hours back to the service center near my home. On May 8th the failure was determined to be caused by this recall, specifically the crankshaft. The dealership has lied and said they've ordered a new motor and it came in, then called to tell me they ordered the wrong motor. They said they ordered the correct one and it would be in within 14 days, and that was 25 days ago. They called today June 16, 2025 to tell me there is still no update on when my engine will ship to complete this repair. The dealership has also refused to assist me with any loaner vehicle or rental assistance even though GM has told me I am entitled to it under this recall. GM has moved my case to Parts Delay team and I still have not been contacted.
Engine, Jun 12, 2025
While starting from a stop the engine stuttered and resulted in a major loss of power. Luckily this occurred pulling out of our driveway on to a quiet neighborhood street. Several warning lights and messages went off including the engine and transmission system warning, “service ESC”, “Service Traction Control”, and the emission system warning. After driving it to the dealership at 30mph since the shaking and banging noise was so bad, the dealer diagnosed it as a cylinder 6 caused by a failed lifter and lifter rod. Resulting repair involved lifters and rods in that same bank at a $3500 repair. The vehicle was just over 4 years old with 79,250 miles.Repair invoice available upon request.
Vehicle speed control, Engine, Jun 9, 2025
The contact owns a 2021 Chevrolet Tahoe. The contact stated that upon coming to a complete stop, the vehicle suddenly jolted forward independently. The vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the valve body. The vehicle was not repaired due to part availability. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 57,000.
Engine, May 20, 2025
“Catastrophic engine failure” as stated by Chevrolet dealership service department. Loud rattling noise prompted service visit. Not 6.2 liter engine, but almost identical issue.
Power train, Engine, Fuel/propulsion system, May 17, 2025
Check Engine Light Came On. Upon Diagnosis', the engine is misfiring, lifters are not performing correctly and there are critical engine alerts and an estimate of 11,000 to fix. 2021 - 83,000 miles v8 - 5.3 NOT the 6.2 and no one will help me bc my power train expires. I am the only owner. Second brand new Tahoe ai bought from this dealership and they are doing nothing to help.
Engine and engine cooling, May 16, 2025
The contact owns a 2021 Chevrolet Tahoe. The contact stated that while her husband was driving 40 MPH, the "Service Stabili-trak Soon" message was displayed on the instrument panel. The contact stated that there was an abnormal knocking sound coming from the engine and the contact's husband pulled over and restarted the vehicle. The contact stated that after the vehicle was restarted, the failure persisted. The contact's husband pulled into a gas station and called an independent mechanic. The mechanic advised the contact's husband to safely drive the vehicle home and to then take the vehicle to his shop the next day for a diagnostic test. The vehicle was driven to the independent mechanic and was diagnosed, and the contact was informed that cylinders #1 and #7 were not functioning as needed. The contact was then informed that the engine lifters needed to be repaired. The manufacturer was notified of the failure and parts were ordered to repair the vehicle. The vehicle remained in the possession of the mechanic and was not yet repaired. The failure mileage was approximately 75,400.
Engine, Forward collision avoidance, May 15, 2025
On April 25th, 2025 we were taking our kids to their after school activities when the SUV started to shake, and accelerate very fast by barely pushing the gas pedal, the ETS light along with the forward collision warning also appeared on the dashboard along with the check engine light. This prompted my husband to get our vehicle towed to the nearest shop close to the street where our vehicle started having problems. After several days of diagnostics the shop let us know our vehicle needed the following repairs: Bank One lifters replacement, head gasket service, and a water pump replacement, we ok'd the repairs. Although these components were replaced, we were informed on May 15, 2025, that the vehicle continues to misfire and now requires a camshaft replacement as well. The total cost of the repair has now risen from $5,182.16 to $13,549.79, which is a significant financial burden as the vehicle is just outside of warranty coverage. We are aware that there is an active recall covering similar issues for 2021–2024 Chevrolet Tahoes equipped with 6.2L engines. However, our 5.3L engine model is experiencing the same mechanical failures, including misfires, knocking noises, low RPM idling, and performance degradation. There is growing evidence that the valve lifter issues are not limited to the 6.2L engine variant. Our experience—and the experiences of others reported online—suggests that the 5.3L L84 engine may also suffer from the same design or manufacturing flaws. We respectfully urge NHTSA to investigate whether this issue warrants expanding the scope of the existing recall to include the 5.3L engine models, and we ask that GMC/General Motors be encouraged to provide assistance. Given the severity and known pattern of these issues, we believe GMC should cover at least 75% of the repair costs, or ideally, offer to perform the repair at no charge. Thank you for your time and consideration.
Power train, Engine, Lane departure, May 6, 2025
While traveling on the highway one day, my 2021 Chevrolet Tahoe began warning lights on the dashboard. Shortly after, it running roughly,, and jerking, so I pulled over to investigate. There no visible smoke, so I drove to the nearest auto parts store, where they ran a diagnostic test that returned a code of P0306. I then took vehicle back to the dealership where have always received oil changes and repairs. I have never visited any other dealership, relying on certified GM/Chevrolet dealerships. After inspecting the vehicle, they informed me that the lifters needed replacement advised that it would be best to replace the engine entirely. Upon further research, I discovered that issue has been affecting many people in our area and across the United States. This needs to be addressed, as the vehicle is only three years old, purchased brand new with zero miles, and I have not done anything out of the ordinary to cause this problem. The vehicle being 70,000 and 12.000 for repairs is insane.
Engine, May 3, 2025
MY 2021 TAHOE ENGINE LIGHT CAME ON 4/26/2025 AS WELL AS IT BEGAN RIDING ROUGH. SCHEDULED SERVICE ON 5/01/2025 WHICH I WAS INFORMED COST OF FAILURE ENGINE DIAGNOSIS REPAIR WOULD COST ME $5,000 UP TO $15,000 TO REPAIR. MY VEHICLE IS BASICALLY NEW AND WHY IS MY VEHICLE NOT INCLUDED IN THE ENGINE FAILURE RECALL? HOPEFULLY IT IS AN OVERSIGHT. AS A VALUED CUSTOMER PLEASE ADVISE, THANKING YOU IN ADVANCE.
Engine and engine cooling, May 1, 2025
The contact owns a 2021 Chevrolet Tahoe. The contact stated while driving 70 MPH, the check engine warning light and other unknown warning lights illuminated. The message "Loss of Oil Pressure" was displayed, and the vehicle made an abnormally loud banging sound. The contact was able to continue driving at slow speeds with the hazard lights engaged. The contact drove to the dealer, where he was employed. The dealer diagnosed that the engine lifters had failed. The vehicle was then towed to the Chevrolet dealer, where it was diagnosed that the lifters had failed. The dealer provided an estimated fee for the repair. The vehicle was towed to Redline Performance LLC, where it was diagnosed that there were metal shavings in the oil pump, camshaft, and in other unknown parts, along with the lifters failure. The mechanic replaced the lifters, the connecting rod, the camshaft, the oil pump, and other unknown parts; however, the failure recurred after picking up and driving the vehicle to the residence. Additionally, there was smoke coming from the engine. The vehicle was towed to Stan McNabb Chevrolet Columbia (101 S James Campbell Blvd, Columbia, TN 38401), who informed the contact that the vehicle would not be diagnosed by the dealer. The contact became aware that the VIN was included in NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling), which the contact related to the failure; however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 66,000. VIN tool confirms parts not available.
Engine, Fuel/propulsion system, May 1, 2025
On May 14, 2023 I was on a trip driving the Tahoe (midnight blue Tahoe in the pictures) about 60 mph, on highway 41 (middle of nowhere, no cell reception) south of kettleman city, CA when, without any warning or symptoms of any problem whatsoever, the engine lost propulsion and died. I was able to coast onto the shoulder and tried starting it. It started again and I continued driving and about 35 minutes later I stopped at a red light on Highway 41 in Lemoore, CA. Again the Tahoe engine died without warning and would not restart. When I tried starting it I could smell a burning smell. The engine cranked but wouldn’t start, and then the check engine light came on. I was at a stoplight on a major highway and was unable to move the vehicle, and was scared to sit in it, so I put on the vehicle hazard lights, got out of the car and ran to the side of the road for safety. Luckily I did not have my children with me. I called 911 and a police officer came and parked behind my vehicle with his lights on so hopefully no other vehicles would hit it. A tow truck was immediately dispatched as high priority by the police. I had it towed to Hedricks Chevrolet dealership in Clovis, California, who informed me there was metal parts in the oil and that the engine was destroyed and had to be replaced. It took several months to get the engine replaced and in the meantime, I bought a new 2023 Cadillac Escalade so I would have a vehicle to drive. The Cadillac Escalade ended up having an extremely similar problem (and I will file a separate report for that vehicle). A few months later when the Tahoe replacement engine was installed I picked up the Tahoe from the dealership and sold it to Carmax.
Engine, Apr 30, 2025
The contact owns a 2021 Chevrolet Tahoe. The contact stated that while driving at an undisclosed speed, there was a loud revving and knocking sound coming from the engine compartment. The contact stated that later after starting the vehicle, the check engine warning light illuminated with the knocking sound coming from the engine. The vehicle was driven to the local dealer who diagnosed that the engine was faulty and needed to be replaced. The engine was replaced, and the vehicle was repaired. The manufacturer was notified of the failure. The contact was informed that the VIN was not included in NHTSA Campaign Number: 25V274000 (ENGINE AND ENGINE COOLING). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 70,000.
Engine and engine cooling, Power train, Apr 30, 2025
The contact owns a 2021 Chevrolet Tahoe. The contact stated that while her husband was driving at an undisclosed speed, several unknown warning lights illuminated, and the engine made knocking sounds. The message "Service Transmission" was displayed. The contact's husband pulled over and turned off the vehicle. The vehicle failed to restart immediately. The vehicle was taken to the dealer, who replaced the camshaft retainer, valve tensioner kit, gaskets, seals, lifters, engine bolts, rods, and pipes; however, the "Service Transmission" message displayed again while driving. The dealer was made aware of the failure, but the vehicle was not yet diagnosed or repaired. The manufacturer was made aware of the failure but informed the contact that there was no recall associated with the VIN. The failure mileage was approximately 89,678.
Engine, Apr 30, 2025
Sudden engine failure while driving. Was able to pull to the side of the road with a few hundred feet. Repair required full engine replacement. Have to other friends that drive similar gm products that also experience engine failure with 3 weeks of our incident.
Engine, Apr 27, 2025
Engine burning through oil excessively. Has been noted on multiple occasions and requires early changes and top off. Is also happening with 3 friends with the same make and model with the 6.2L. No warnings but was informed it is common at shop.
Engine, Forward collision avoidance, Apr 27, 2025
We had a failed lifter that caused bent rods which caused scratches on the crank shaft which caused us to have to replace the engine. After a simple internet search I have found the lifter failure is very common with gms 5.3 v8. We were told oil needs to be changed at least every 5000 miles although the vehicle prompts you around 7000.
Engine and engine cooling, Apr 25, 2025
The contact owns a 2021 Chevrolet Tahoe. The contact stated that while driving 15 MPH, the vehicle lost automotive power and stalled. The contact stated that several unknown warning lights were illuminated. The vehicle was towed to the dealer but was not diagnosed or repaired. The contact called the local dealer and was informed that there were no associated recalls. VIN tool search showed: NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling). The manufacturer was not notified of the failure. The failure mileage was approximately 10,440.
Engine, Apr 10, 2025
Traction control light came on and the vehicle felt like it was going to die/low idle. I took to dealership on 9/13/22 (5months after getting vehicle) and the codes P03000 00 which is an engine misfire, P050D 00 which is cold start rough idle and it was noted by service tech that engine making a clunk and ticking noise. There was a misfire on cylinder 6. They removed the valve cover and the intake valve rocker arm was not moving at all and when the rocker arm was removed they noticed the push rod was also bent. They verified the DFM lifter was collapsed.
Power train, Engine, Apr 3, 2025
I was driving along the highway at 11pm when I the vehicle started shaking and I heard strange sounds coming from outside the vehicle. I pulled over to inspect and realized it was coming from the engine bay. The engine was making knocking, rattling, and belt slipping noises and the entire vehicle was shaking and the engine also stuttering. I was able to drive the vehicle to a nearby plaza where I had it towed the following morning. There were no warning signs, the vehicle ran properly up until this occurred. The dealership inspected it and told me the engine needs to be replaced and it was likely that a rod bearing that went bad. This happened nearly 2 months ago and I am still waiting for a new engine.
Engine, Fuel/propulsion system, Apr 1, 2025
2nd glow plug failure