2021 Chevrolet Tahoe
Problems, recalls and owner-reported issues
Engine is the leading concern among 453 owner complaints filed for this model year. This is the 9th highest complaint count among 26 Tahoe model years with reports.
Of the 2021 reports, 9 involved a crash and 3 involved a fire. 9 people were injured.
What owners report most often
Recalls and investigations
Fuel system, diesel, storage, tank assemblySep 18, 2025
General Motors, LLC (GM) is recalling certain 2021 Cadillac Escalade, 2021, 2023-2024 Chevrolet Tahoe, and 2022 and 2024 GMC Yukon vehicles equipped with a 6-cylinder diesel engine. The original fuel tank may have been replaced with an incorrect fuel tank, which can allow fuel to leak in a rollover crash.
A fuel leak in the presence of an ignition source increases the risk of a vehicle fire.
Dealers will inspect for the correct fuel tank and replace it, if necessary, free of charge. Owner notification letters were mailed November 5, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252512770. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on September 18, 2025.
Campaign 25V619000 on NHTSA.gov
Engine and engine cooling, engine, hard parts internal/mechanicalApr 24, 2025
General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.
Engine failure increases the risk of a crash.
Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.
Campaign 25V274000 on NHTSA.gov
Power train, automatic transmission, control module, softwareOct 24, 2024
General Motors, LLC (GM) is recalling certain 2020-2022 Chevrolet Silverado 1500, 2500, 3500, GMC Sierra 1500, 2500, 3500, 2021 Cadillac Escalade, Escalade ESV, Chevrolet Tahoe, Suburban, GMC Yukon, and Yukon XL vehicles equipped with diesel engines. The transmission control valve may fail and cause the rear wheels to lock-up.
Rear wheel lock-up can increase the risk of a crash.
Dealers will install new transmission control module software, free of charge. GM will provide a special coverage program to cover the repair of transmissions that are identified by the remedy software as containing a defective control valve. Owner notification letters were mailed December 12, 2024. Owners may contact GM customer service at 1-888-988-7267, Cadillac customer service at 1-800-458-8006, GMC customer service at GMC 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N242454440.
Campaign 24V797000 on NHTSA.gov
Exterior lighting, lighting control module, softwareNov 3, 2022
General Motors, LLC (GM) is recalling certain 2021 Yukon, Yukon XL, Chevrolet Tahoe, Chevrolet Suburban, Cadillac Escalade, and Cadillac Escalade ESV vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Daytime Running Lights that do not deactivate as intended may cause a glare, reducing visibility and increasing the risk of a crash.
Dealers will provide an over-the-air (OTA) update for the Body Control Module software, free of charge. Owner notification letters were mailed December 15, 2022. Owners may contact GM customer service at 1-888-988-7267, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N222382220.
Campaign 22V827000 on NHTSA.gov
Seat belts, critical fastenersAug 11, 2022
General Motors, LLC (M) is recalling certain 2021-2022 Cadillac Escalade, Escalade ESV, Chevrolet Suburban, Tahoe, GMC Yukon, and Yukon XL vehicles equipped with third-row seats. The rivet that retains the buckle to the mounting bracket in the left or right side third-row seat belt buckle assembly may have been improperly formed.
A seat belt with a deformed rivet may not properly restrain an occupant, increasing the risk of injury during a crash.
Dealers will inspect the rivet head formation on both the left and right side third-row seat belt buckle assemblies and replace seat belt buckle assemblies, as necessary, free of charge. Interim owner notification letters informing owners of the safety risk were mailed September 28, 2022. Owner notification letters were mailed on November 1, 2022. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N222372380.
Campaign 22V617000 on NHTSA.gov
Power train, driveline, driveshaftJan 27, 2022
General Motors, LLC (GM) is recalling certain 2021 GMC Yukon, Yukon XL, Cadillac Escalade, Escalade ESV, Chevrolet Suburban, and Chevrolet Tahoe vehicles. The rear wheel driveshaft assemblies may have internal components that were not heat-treated properly, possibly resulting in driveshaft failure.
Driveshaft failure can cause a sudden loss of drive power, increasing the risk of a crash.
Dealers will replace the left and/or right rear driveshaft assemblies, free of charge. Owner notification letters were mailed on March 14, 2022. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006 or GMC customer service at 1-800-462-8782. GM's number for this recall is N212351030.
Campaign 22V036000 on NHTSA.gov
Fuel system, gasoline, delivery, fuel pump, control/drive moduleSep 23, 2021
General Motors, LLC (GM) is recalling certain 2021 Cadillac Escalade, Escalade ESV, Chevrolet Suburban, Tahoe, GMC Yukon, and Yukon XL vehicles. The fuel pump power control module may cause the fuel pump to fail or operate intermittently, which can interrupt fuel flow to the engine, and cause an unexpected engine stall.
An engine stall increases the risk of a crash.
Dealers will replace the fuel pump power control module, free of charge. Owner notification letters were mailed on October 14, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; or GMC customer service at 1-800-462-8782. GM's number for this recall is N212332040.
Campaign 21V739000 on NHTSA.gov
Service brakes, hydraulic, power assist, electric, control module, softwareJul 29, 2021
General Motors, LLC (GM) is recalling certain 2021 Chevrolet Tahoe and GMC Yukon vehicles. Dealer service technicians may have calibrated the brake system incorrectly, affecting Electronic Stability Control (ESC) , traction control, Anti-Lock Brake System (ABS), and braking while towing a trailer.
Overall braking performance may be compromised, increasing the risk of a crash.
Dealers will recalibrate the brake system control module, free of charge. Owner notification letters were mailed on August 27, 2021. Owners may contact Chevrolet customer service at 1-800-222-1202; GMC customer service at 1-800-462-8782. GM's number for this recall is N212340970.
Campaign 21V579000 on NHTSA.gov
Steering, steering control moduleJun 17, 2021
General Motors, LLC (GM) is recalling certain 2021 Cadillac Escalade, Escalade ESV, Chevrolet Suburban, Chevrolet Tahoe, GMC Yukon, and Yukon XL vehicles. A software issue may cause a loss of power steering assist at startup or while driving.
Increased steering effort, particularly at lower speeds, increases the risk of a crash.
The power steering module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed July 13, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; or GMC customer service at 1-800-462-8782. GM's number for this recall is N212333900.
Campaign 21V455000 on NHTSA.gov
Air bags, srs malfunction warning lamp/lightJun 10, 2021
General Motors, LLC (GM) is recalling certain 2021 Buick Envision, Cadillac CT4, CT5, Escalade, Escalade ESV, Chevrolet Tahoe, Corvette, Suburban, GMC Yukon, Yukon XL vehicles. The communications gateway module incorrectly processes a loss of communication with the sensing diagnostic module (SDM), causing the air bag malfunction indicator light to inconsistently illuminate.
The air bag malfunction indicator light may fail to warn the driver of a problem with the air bag, increasing the risk of injury.
The communications gateway module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed on July 1, 2021. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N212338110.
Campaign 21V421000 on NHTSA.gov
Seat belts, rear/otherMar 25, 2021
General Motors, LLC (GM) is recalling certain 2021 Chevrolet Tahoe vehicles. The second-row center seat belt latch may be trapped beneath the trim bezel and therefore inaccessible. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208. "Occupant Crash Protection."
A passenger in the second-row center will be unable to wear a seat belt, increasing the risk of injury in the event of a crash.
GM will notify owners, and dealers will remove the trim bezel, correctly position the seat belt latch plate, and reinstall the trim bezel, free of charge. The recall began April 14, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N212329320.
Campaign 21V210000 on NHTSA.gov
Seat beltsMar 18, 2021
General Motors, LLC (GM) is recalling certain 2021 Cadillac Escalade, Escalade ESV, GMC Yukon, Yukon XL, Chevrolet Suburban, and Tahoe vehicles with third-row seating. The third-row outboard seat belts may have been entrapped or misrouted behind the outboard seat-folding mechanism, which could result in damaged seat belts.
A damaged seat belt can break during a crash, increasing the risk of injury to the occupant.
GM will notify owners, and dealers will inspect the third-row outboard seat belts, replacing any damaged seat belts, and rerouting them if necessary, free of charge. The recall began on April 21, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Cadillac customer service at 1-800-458-8006. GM's number for this recall is N202313000.
Campaign 21V190000 on NHTSA.gov
Fuel system, gasoline, storage, tank assemblyFeb 11, 2021
General Motors, LLC (GM) is recalling certain 2021 Chevrolet Tahoe and GMC Yukon vehicles. The fuel tank assemblies may be missing adhesive between two layers of the fuel tank shell which may result in a fuel leak.
A fuel leak in the presence of an ignition source increases the risk of a fire.
GM will notify owners, and dealers will replace the fuel tank, free of charge. The recall began March 6, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is N212327720.
Campaign 21V064000 on NHTSA.gov
Seat beltsDec 23, 2020
General Motors, LLC (GM) is recalling certain 2020 Chevrolet Bolt EV and 2021 GMC Canyon and Sierra 1500, 2500 and 3500, Yukon, Yukon XL, Cadillac Escalade and Escalade ESV and Chevrolet Blazer, Camaro, Colorado, Equinox, Silverado 1500, 2500 and 3500, Suburban and Tahoe vehicles. Incorrect bolts may have been used at one or more fastening locations to secure the seat belts to the vehicle. If an incorrect bolt was used, the seat belt may not be properly attached to the vehicle.
If a seat belt assembly is not properly attached to the vehicle, the seat belt may not properly restrain an occupant in the event of a crash, increasing the risk of injury.
GM will notify owners, and dealers will replace the suspect bolts, free of charge. The recall began January 29, 2021. Owners may contact GMC customer service at 1-800-462-8785, Cadillac customer service at 1-800-458-8006, or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N202322230.
Campaign 20V811000 on NHTSA.gov
Seat beltsDec 17, 2020
General Motors, LLC (GM) is recalling certain 2019-2021 Chevrolet Silverado 1500 and GMC Sierra 1500, 2021 Chevrolet Suburban and Tahoe and GMC Yukon XL and 2020-2021 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 vehicles. The seat belt brackets may not be secured to the seat frame in the front-row center seating position.
If a seat-belt bracket is not secured, the seat belt may not properly restrain an occupant in the front-row center seat position, increasing the risk of injury in a crash.
GM will notify owners, and dealers will inspect left-side and right-side front-row center seat-belt bracket attachments and reassemble it correctly as necessary, free of charge. The recall began January 26, 2021. Owners may contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N202314670.
Campaign 20V792000 on NHTSA.gov
SeatsNov 25, 2020
General Motors LLC (GM) is recalling certain 2021 Chevrolet Suburban and Tahoe and GMC Yukon and Yukon XL vehicles. During general assembly, a repair involved removal of one or both front seats. The attachment bolts for the front seats may not have been properly reinstalled after the repair was completed.
If an occupied front seat has loose or missing attachment bolts, it may move during a crash, increasing the risk of injury to the seated occupant.
GM will notify owners, and dealers will inspect the seat attachments for both front seats and install attachment bolts as needed, free of charge. The recall began December 21, 2020. Owners may contact Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-888-988-7267. GM's number for this recall is N202312720.
Campaign 20V735000 on NHTSA.gov
Representative owner complaints: engine
184 reports, newest first. Show all
Engine, Mar 28, 2025
After I washed my 2021 Chevrolet Tahoe, I went to run some errands. As I pushed the start button, the car would try to start but did not. I tried several times without success. I had the truck towed to Ed Morse Chevrolet in Sunrise, Florida. My odometer is at approximately 43,000 miles. About 3-4 months ago, at 42,000 miles, I had the same situation. I had to have the truck towed to Ed Morse. At the time, the Service Writer told me it was probably the fuel cell module and that Chevy has been a problem with them. The Service Writer surprisingly admitted that this issue could cause the truck to stop in the middle of your commute! I told him that an issue this serious needs a recall. So, today, when AAA picked up my truck, he said that this happens frequently and he towed many Chevrolet Tahoes and pickup trucks with this issue. The AAA technician even reiterated that the fuel cell modular failure shuts down your vehicle while driving! This is insane and troubling. Within 1000 miles, I will need 2 fuel cell modules and there is no guarantee that this one will last. Thanks [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Other or unspecified, Engine, Mar 25, 2025
2 incidents of complete engine power loss while driving. Luckily was able to roll off road safely to curb. Dashboard glitch/flashing multiple/various message, including check engine, conditions not ideal to shift, etc. Would not re-start/shift when attempted. Tried disconnecting battery cable completely and re-connecting and that seemed to 're-set' the system and engine re-started. Incidents were about 30 days apart. "This battery reset" was tried because approx 1 year prior after leaving Tahoe parked at airport for a 7 day trip, it would not start, completely dead. Battery charge/jump would not work...watched youtube videos and someone said to try disconnect/reconnect cable and it worked to start it up at that time & did take it into Dealership after that incident and no-cost repairs were made for that issue. Called Chevy 3/25/25 on this power loss while driving issue to ask for information/assistance, they advised to take to dealership for diagnostic info/report and depending on result/cause might assist with costs to repairs. Appointment set for 3/28/2025 with Salem Oregon Chevrolet.
Engine, Mar 15, 2025
Driving on a highway to Dallas and vehicle loss power and locked up in the middle of the highway.Was stranded on the highway for 4 hours. Vehicle would not start up and had to get towed to local dealership. Dealership diagnose the problem and stated that the engine has failed. I got the vehicle towed back home to my local dealership and they confirmed that the engine has failed. The vehicle showed no signs of engine issues. GM needs to recall this vehicle.
Engine, Mar 5, 2025
Approximately 4/14/24 while I was driving home from being out of town with my child the check engine light came on with a message “Reduced acceleration drive with care.” The car was not shifting and I couldn’t go over 45 mph and the rpm’s were about 3000 at that speed. The light went off and the car seemed to be driving normally. While on the interstate traveling at approximately 70 mph the car did a hard shift and drastically slowed while the rpm’s spiked. I took it to the dealership who determined the valve body needed to be replaced. Approximately August 2024 it happened again but the light went off. December 2024 same issues with the check engine light, reduced acceleration and not shifting happened. Took the car back 12/9/24 where a wire was replaced. Picked the car up 12/12/24 and 12/18/24 while driving in the car rider line picking my child up the car had a hard shift, check engine light came on, reduced acceleration message and the car would not shift. Notified the dealership immediately and took it back 12/26/24 where they did a second valve body replacement. 1/28/25 on my way home from running errands and was stopped at a red light and the car shifted hard, check engine light came on, reduced acceleration message and engine would not shift causing me to drive slowly to get home (40 mph or less). Dealership was notified immediately and took in the following day. Dealership had a week and had me pick it up because they “couldn’t replicate the issue.” 2/15/25 after driving 2 hours we pulled in a parking lot and the car shifted hard hard, check engine light came on, reduced acceleration and would not go into reverse. The dealership picked the car up and have had it since trying to replicate it. It occurs without warning while driving and will drastically slows the car down putting us a risk of being rear ended due to the rapid and speed change. It also is a safety risk due to lack of warning that a power failure is about to occur while driving.
Power train, Engine, Feb 11, 2025
Engine failed while driving down the road. There was not prior warning signs to this issue. Vehicle was unable to accelerate. The safety of myself and husband were put a risk as we were traveling on an Interstate 12 in Baton Rouge, LA. The vehicle was inspected by Pine Belt Chevy and the cause identified as Camshaft and lifters failed in the engine causing a sudden deacceleration.
Engine, Feb 4, 2025
At 35,000 miles, my 2021 Chevrolet Tahoe started to misfire. When I pressed the accelerator, the truck started hesitating and the check engine light started flashing. I was able to get the truck to the dealer I purchased it at. The technician "claimed" it was a bad fuel injector. The dealer replaced the spark plug and injector. The vehicle was never test driven. I picked up the truck and drove it on the road. Within 1 mile, the truck started to misfire again with the check engine light started flashing. The dealer claimed that the lifter or lifters in one engine bank were bad. The dealer replaced the lifters on the one side of the engine.
Engine, Feb 4, 2025
Engine knocking while accelerating. Told by Chevy dealership that a thruster is broken. Car is only 4 years old with 60k miles. Unfortunately, not under warranty. Quoted $5,000 for fix. No errors on dash or visuals of the problem.
Engine, Jan 28, 2025
2021 Chevrolet Tahoe Engine began misfiring and check engine light and ESC warning indicators displayed as I was driving. I pulled over and shut off vehicle, read manual and restarted engine. Same problems occurred, so I drove to Chevrolet dealer which was a mile away. The advisors said I shouldn’t drive it on the expressway or any further since engine had known problems that GM was aware of and it would blow up. Scans showed P0300 & P0305 for Cylinder 5 misfire. Major Repair included replacement of all lifters and push rods on both banks and the camshaft taking 17 days. This engine should have a GM Recall due to its severity. I was told the engine usually blows up before the warranty period is over and GM would just fix it. Unfortunately for me, my engine failed after full warranty and while I was traveling out of state to a family wedding, costly me directly. GM did pay half of the cost of repair which indicates admitting fault. The major safety concern is when an engine blows up and the driver cannot control the vehicle causing accidents or fire (and being stranded). There were No previous indications or symptoms of engine failure prior to date the problem occurred. Police departments in Illinois have had the same problem with this engine and their entire Tahoe fleet needed a new / repaired engine. This is an unacceptable action by GM to just wait for the problem to occur instead of proactively recalling the engine for repair.
Engine, Jan 26, 2025
This is a fairly new vehicle, so to be told we need a new engine when we’ve had the car for only 4 years is ridiculous! We were driving one day and heard a knocking sound coming from the front of the car. We made it home, but when we tried to leave the next time, we only made it halfway down our driveway when we heard a loud knocking noise from the front and the car suddenly stopped. We were dead in the water and needed to get the car towed back to our house. The gear shift was also stuck in drive and we couldn’t turn the car on. The engine had completely seized up. The tow truck driver had to get underneath the vehicle in order to disengage the gear shift and allow us to shift into neutral so that we could get it back home. When we had it towed to our mechanic, they told us that it was a bearing failure and the connecting rod had caused our engine to seize up. I’m just glad we weren’t on a major highway or busy street at the time this took place. This is supposed to be our family vehicle and it has been out of commission for more than 6 months because we haven’t been able to afford to replace the engine. We’ve tried contacting GM directly, but they said we were beyond our warranty and there was nothing they could do to help us.
Engine, Jan 21, 2025
GM has a known issue with engine lifters on this model engine that fail around 60,000 miles. Customer service managers even stated so themselves and GM has a TSB related to this. Repair bill is $5K-$6K if it doesn’t bend the cam shaft and upwards of $10K if cam is bent. This is a huge safety issue because vehicle fails while in motion, shakes violently, and numerous safety features the driver relies on turn off.
Engine, Jan 20, 2025
My wife was driving the vehicle when all of a sudden the engine started knocking and throwing a bunch of codes. The engine has a bottom end knock and it seems this is a known problem with these engines.
Engine, Jan 19, 2025
Vehicle has no warning of issues. Regular maintenance had been performed and had 80k miles. Driving down a 4 lane the engine locked up and lost power. We have been waiting on it to be repaired for 4 months now. The engine is back ordered from GM and no one can find used ones. We found a refurbished one but it also locked up within 30 minutes of being installed. I was warrantied so now we are having ours rebuilt but is costing us $14k.
Engine, Jan 18, 2025
I am getting heavy oil consumption and the dealer just keeps on wanting to run tests and not fix the actual issue
Engine, Forward collision avoidance, Dec 22, 2024
On [XXX] I was driving in the [XXX] in El Paso Texas at about [XXX] I was about to enter [XXX} and the vehicle suddenly stopped with no warning! I was able to pull to the side and put the blinkers because the traffic was heavy and could of had a vehicle crash into me if I had not maneuver the vehicle quickly(My two daughters where with me in the vehicle). The vehicle prompted to start the vehicle, which I did so and continued my way. As soon as I was able to get into the [XXX] the check engine light turned on, and the forward collision warning message on the display. I stopped to my nearest Autozone to get some help as the vehicle started to make a noise too. They connected their computer and told me that the vehicle was given a message of a faulty cylinder, they told me I should not move the vehicle until I had it inspected on a GM dealership. Which I did on Friday December 20, 2024, I am waiting for a full diagnostic to see what had happened to my vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Other or unspecified, Engine, Nov 26, 2024
I have taken this vehicle two times to the dealers that sell Chevrolet. The first time it was there for 5 hours and nothing was done and the second time the service agent said there was no recall on this vehicle when obviously there is one.
Engine, Fuel system, Gasoline, Nov 21, 2024
The contact owns a 2021 Chevrolet Tahoe. The contact stated while driving 5 MPH in the driveway, the vehicle stopped and stalled. The vehicle failed to restart. The vehicle was towed to an independent mechanic who determined that the fuel pump control module needed to be replaced. The vehicle was repaired. The contact called the local dealer and was informed that there were no associated recalls. The vehicle was not diagnosed or repaired. The manufacturer was contacted and confirmed that the vehicle was not included in NHTSA Campaign Number: 21V739000 (Fuel System, Gasoline). The failure mileage was approximately 30,000.
Engine, Fuel/propulsion system, Aug 8, 2024
Driving on the I-95 I abruptly lost power driving in the left lane, RPM dropped all the way down and speed was rapidly decreasing. I had to pull over on the shoulder in the most safe manner possible for myself and other drivers on the road; but it was not without any risk. The body of the car was rattling on my way to the shoulder and the car shut off before I could put the car in Park in a safe place. With my hazard lights on I tried restarting the car but the enging would not turnover, the starter would run and the car would rattle about all whilst creating a traffic jam. Once i noticed the engine light and yielded to the car's inabiltiy to start up, we got the attention of a FHP State trooper who called in a Tow truck for us. Getting te car onto the tow truck in traffic also increased the risk associated for everyone involved. Aftert succesfully oading the car, which was no smooth task as the car could not shift into Neutral; we took the car to my local Firestone. After a diagnostic test done the following morning, we were notified of a fuel pump issue that has been on the recall list for my vehicle, but NOT associated with my VIN.
Electrical system, Engine, Fuel/propulsion system, Aug 7, 2024
Stopped for gas, then proceeded to leave store, the check engine light came on, and car immediately shut off while on the highway going ~25mph. Car would not turn back on, and then lights for fuel machine error started coming on. Car sat there trying to turn on, lights off, and then would say push start button, but nothing happened. Car began to shake and continued to try to turn on, yet nothing happened. Car was towed to home, sat for an hour and then started again, check engine light remains on.
Engine, Jul 12, 2024
The contact owns a 2021 Chevrolet Tahoe. The contact stated while driving at various speeds on several occasions, there was a banging sound coming from the engine compartment. The vehicle was taken to a dealer where it was diagnosed and determined that the cam lifters needed to be replaced. The contact stated that the failure reoccurred two weeks later. The manufacturer was notified of the failure. The failure mileage was approximately 11,400.
Electrical system, Engine, Jun 10, 2024
I am experiencing loss of power just like the recall shows for campaign 22V036000 powertrain. Engine stall in the middle of the street just like it shows for the fuel system 21V73 9000. I have stalled in the middle of the street including today four times and a month. The dealership can’t seem to find what’s wrong. Nor other places. I don’t think they are looking hard enough at the dealership. I almost got killed by another car going at least 65 mph while I was stuck in the middle of the street at a stoplight. These are all different days. While working and people in my car.
Fuel system, Gasoline, Engine, Apr 3, 2024
The contact owns a 2021 Chevrolet Tahoe. The contact stated that while driving 35–40 MPH, the vehicle abruptly shut off. The contact continued to pump the brake pedal to alert oncoming traffic. There were no warning lights illuminated. The contact called the Police, and the vehicle was towed to an impound lot. The vehicle was towed to the local dealer, where it was diagnosed that the fuel pump control drive module needed to be replaced. The vehicle was repaired. The manufacturer was contacted, and a case was opened. The contact stated that the failure was related to NHTSA Campaign Number: 21V739000 (Fuel System, Gasoline). The failure mileage was approximately 38,000.
Power train, Engine, Fuel/propulsion system, Mar 11, 2024
As a traffic crash reconstructionist, the issue is a MAJOR SAFETY ISSUE. My wife was exiting a residential driveway when the vehicle started to stutter and immediately shut down with no power or any capability to get the vehicle off the road. The shutdown caused the blockage of a residential street on a Friday afternoon, until the correct tow truck arrived. This was due to the fact the vehicle could not be moved due to not being able to start the engine nor the ability to place the vehicle into neutral, without starting the engine or crawling un der it with tools. It was determined the fuel module went bad. There was no warning of the failure of the component. Luckily the shut down of all components of the vehicle did not occur on a high speed or highly traveled road since I did not have any control of the vehicle after the fuel module failed. This is not the first report of the issue to NHTSA. Hopefully something will happen to find a fix to put the vehicle in neutral without tools, for the safety of the motoring public.
Engine, Feb 5, 2024
Third time engine only cranks and will not start. I was forced to disconnect the battery and reconnect after a short while to get the vehicle to start.
Engine, Jan 26, 2024
The contact owns a 2021 Chevrolet Tahoe. The contact stated that while driving at an undisclosed speed and making a left turn, the vehicle lost motive power and stalled in the middle of the road. The contact was unable to restart the vehicle. The contact stated that the gear shifter had seized in park. The vehicle was towed to the dealer. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure. The failure mileage was approximately 16,000.
Power train, Electrical system, Engine, Jan 23, 2024
This is the second engine I’ve had replaced since I bought the vehicle in December 21, 2023. The first engine failed in August of 2022 while I was driving on the highway. The vehicle began to smoke and shut down while I was driving on the highway. The vehicle shut down and I had to use the current momentum of the vehicle to pull over to the shoulder. The vehicle would not come out of gear and would not restart. I complained of transmission problems ever since the engine was replaced. The service department escalated the concerns to the GM engineers who never gave directions to check the transmission fluid or physically check the transmission. January 24 of this year I was on the highway driving to work when the vehicle again shut down. The dash stated restart the vehicle. While in motion the vehicle was trying to shift to neutral. I informed the dealer of this message and they claim they took note of it. With the vehicle not being able to start or move out of gear the tow truck had to drag the vehicle onto the bed of the tow truck. This also occurred on the first engine failure as well.