2021 Chevrolet Tahoe
Problems, recalls and owner-reported issues
Engine is the leading concern among 453 owner complaints filed for this model year. This is the 9th highest complaint count among 26 Tahoe model years with reports.
Of the 2021 reports, 9 involved a crash and 3 involved a fire. 9 people were injured.
What owners report most often
Recalls and investigations
Fuel system, diesel, storage, tank assemblySep 18, 2025
General Motors, LLC (GM) is recalling certain 2021 Cadillac Escalade, 2021, 2023-2024 Chevrolet Tahoe, and 2022 and 2024 GMC Yukon vehicles equipped with a 6-cylinder diesel engine. The original fuel tank may have been replaced with an incorrect fuel tank, which can allow fuel to leak in a rollover crash.
A fuel leak in the presence of an ignition source increases the risk of a vehicle fire.
Dealers will inspect for the correct fuel tank and replace it, if necessary, free of charge. Owner notification letters were mailed November 5, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252512770. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on September 18, 2025.
Campaign 25V619000 on NHTSA.gov
Engine and engine cooling, engine, hard parts internal/mechanicalApr 24, 2025
General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.
Engine failure increases the risk of a crash.
Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.
Campaign 25V274000 on NHTSA.gov
Power train, automatic transmission, control module, softwareOct 24, 2024
General Motors, LLC (GM) is recalling certain 2020-2022 Chevrolet Silverado 1500, 2500, 3500, GMC Sierra 1500, 2500, 3500, 2021 Cadillac Escalade, Escalade ESV, Chevrolet Tahoe, Suburban, GMC Yukon, and Yukon XL vehicles equipped with diesel engines. The transmission control valve may fail and cause the rear wheels to lock-up.
Rear wheel lock-up can increase the risk of a crash.
Dealers will install new transmission control module software, free of charge. GM will provide a special coverage program to cover the repair of transmissions that are identified by the remedy software as containing a defective control valve. Owner notification letters were mailed December 12, 2024. Owners may contact GM customer service at 1-888-988-7267, Cadillac customer service at 1-800-458-8006, GMC customer service at GMC 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N242454440.
Campaign 24V797000 on NHTSA.gov
Exterior lighting, lighting control module, softwareNov 3, 2022
General Motors, LLC (GM) is recalling certain 2021 Yukon, Yukon XL, Chevrolet Tahoe, Chevrolet Suburban, Cadillac Escalade, and Cadillac Escalade ESV vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Daytime Running Lights that do not deactivate as intended may cause a glare, reducing visibility and increasing the risk of a crash.
Dealers will provide an over-the-air (OTA) update for the Body Control Module software, free of charge. Owner notification letters were mailed December 15, 2022. Owners may contact GM customer service at 1-888-988-7267, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N222382220.
Campaign 22V827000 on NHTSA.gov
Seat belts, critical fastenersAug 11, 2022
General Motors, LLC (M) is recalling certain 2021-2022 Cadillac Escalade, Escalade ESV, Chevrolet Suburban, Tahoe, GMC Yukon, and Yukon XL vehicles equipped with third-row seats. The rivet that retains the buckle to the mounting bracket in the left or right side third-row seat belt buckle assembly may have been improperly formed.
A seat belt with a deformed rivet may not properly restrain an occupant, increasing the risk of injury during a crash.
Dealers will inspect the rivet head formation on both the left and right side third-row seat belt buckle assemblies and replace seat belt buckle assemblies, as necessary, free of charge. Interim owner notification letters informing owners of the safety risk were mailed September 28, 2022. Owner notification letters were mailed on November 1, 2022. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N222372380.
Campaign 22V617000 on NHTSA.gov
Power train, driveline, driveshaftJan 27, 2022
General Motors, LLC (GM) is recalling certain 2021 GMC Yukon, Yukon XL, Cadillac Escalade, Escalade ESV, Chevrolet Suburban, and Chevrolet Tahoe vehicles. The rear wheel driveshaft assemblies may have internal components that were not heat-treated properly, possibly resulting in driveshaft failure.
Driveshaft failure can cause a sudden loss of drive power, increasing the risk of a crash.
Dealers will replace the left and/or right rear driveshaft assemblies, free of charge. Owner notification letters were mailed on March 14, 2022. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006 or GMC customer service at 1-800-462-8782. GM's number for this recall is N212351030.
Campaign 22V036000 on NHTSA.gov
Fuel system, gasoline, delivery, fuel pump, control/drive moduleSep 23, 2021
General Motors, LLC (GM) is recalling certain 2021 Cadillac Escalade, Escalade ESV, Chevrolet Suburban, Tahoe, GMC Yukon, and Yukon XL vehicles. The fuel pump power control module may cause the fuel pump to fail or operate intermittently, which can interrupt fuel flow to the engine, and cause an unexpected engine stall.
An engine stall increases the risk of a crash.
Dealers will replace the fuel pump power control module, free of charge. Owner notification letters were mailed on October 14, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; or GMC customer service at 1-800-462-8782. GM's number for this recall is N212332040.
Campaign 21V739000 on NHTSA.gov
Service brakes, hydraulic, power assist, electric, control module, softwareJul 29, 2021
General Motors, LLC (GM) is recalling certain 2021 Chevrolet Tahoe and GMC Yukon vehicles. Dealer service technicians may have calibrated the brake system incorrectly, affecting Electronic Stability Control (ESC) , traction control, Anti-Lock Brake System (ABS), and braking while towing a trailer.
Overall braking performance may be compromised, increasing the risk of a crash.
Dealers will recalibrate the brake system control module, free of charge. Owner notification letters were mailed on August 27, 2021. Owners may contact Chevrolet customer service at 1-800-222-1202; GMC customer service at 1-800-462-8782. GM's number for this recall is N212340970.
Campaign 21V579000 on NHTSA.gov
Steering, steering control moduleJun 17, 2021
General Motors, LLC (GM) is recalling certain 2021 Cadillac Escalade, Escalade ESV, Chevrolet Suburban, Chevrolet Tahoe, GMC Yukon, and Yukon XL vehicles. A software issue may cause a loss of power steering assist at startup or while driving.
Increased steering effort, particularly at lower speeds, increases the risk of a crash.
The power steering module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed July 13, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; or GMC customer service at 1-800-462-8782. GM's number for this recall is N212333900.
Campaign 21V455000 on NHTSA.gov
Air bags, srs malfunction warning lamp/lightJun 10, 2021
General Motors, LLC (GM) is recalling certain 2021 Buick Envision, Cadillac CT4, CT5, Escalade, Escalade ESV, Chevrolet Tahoe, Corvette, Suburban, GMC Yukon, Yukon XL vehicles. The communications gateway module incorrectly processes a loss of communication with the sensing diagnostic module (SDM), causing the air bag malfunction indicator light to inconsistently illuminate.
The air bag malfunction indicator light may fail to warn the driver of a problem with the air bag, increasing the risk of injury.
The communications gateway module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed on July 1, 2021. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N212338110.
Campaign 21V421000 on NHTSA.gov
Seat belts, rear/otherMar 25, 2021
General Motors, LLC (GM) is recalling certain 2021 Chevrolet Tahoe vehicles. The second-row center seat belt latch may be trapped beneath the trim bezel and therefore inaccessible. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208. "Occupant Crash Protection."
A passenger in the second-row center will be unable to wear a seat belt, increasing the risk of injury in the event of a crash.
GM will notify owners, and dealers will remove the trim bezel, correctly position the seat belt latch plate, and reinstall the trim bezel, free of charge. The recall began April 14, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N212329320.
Campaign 21V210000 on NHTSA.gov
Seat beltsMar 18, 2021
General Motors, LLC (GM) is recalling certain 2021 Cadillac Escalade, Escalade ESV, GMC Yukon, Yukon XL, Chevrolet Suburban, and Tahoe vehicles with third-row seating. The third-row outboard seat belts may have been entrapped or misrouted behind the outboard seat-folding mechanism, which could result in damaged seat belts.
A damaged seat belt can break during a crash, increasing the risk of injury to the occupant.
GM will notify owners, and dealers will inspect the third-row outboard seat belts, replacing any damaged seat belts, and rerouting them if necessary, free of charge. The recall began on April 21, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Cadillac customer service at 1-800-458-8006. GM's number for this recall is N202313000.
Campaign 21V190000 on NHTSA.gov
Fuel system, gasoline, storage, tank assemblyFeb 11, 2021
General Motors, LLC (GM) is recalling certain 2021 Chevrolet Tahoe and GMC Yukon vehicles. The fuel tank assemblies may be missing adhesive between two layers of the fuel tank shell which may result in a fuel leak.
A fuel leak in the presence of an ignition source increases the risk of a fire.
GM will notify owners, and dealers will replace the fuel tank, free of charge. The recall began March 6, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is N212327720.
Campaign 21V064000 on NHTSA.gov
Seat beltsDec 23, 2020
General Motors, LLC (GM) is recalling certain 2020 Chevrolet Bolt EV and 2021 GMC Canyon and Sierra 1500, 2500 and 3500, Yukon, Yukon XL, Cadillac Escalade and Escalade ESV and Chevrolet Blazer, Camaro, Colorado, Equinox, Silverado 1500, 2500 and 3500, Suburban and Tahoe vehicles. Incorrect bolts may have been used at one or more fastening locations to secure the seat belts to the vehicle. If an incorrect bolt was used, the seat belt may not be properly attached to the vehicle.
If a seat belt assembly is not properly attached to the vehicle, the seat belt may not properly restrain an occupant in the event of a crash, increasing the risk of injury.
GM will notify owners, and dealers will replace the suspect bolts, free of charge. The recall began January 29, 2021. Owners may contact GMC customer service at 1-800-462-8785, Cadillac customer service at 1-800-458-8006, or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N202322230.
Campaign 20V811000 on NHTSA.gov
Seat beltsDec 17, 2020
General Motors, LLC (GM) is recalling certain 2019-2021 Chevrolet Silverado 1500 and GMC Sierra 1500, 2021 Chevrolet Suburban and Tahoe and GMC Yukon XL and 2020-2021 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 vehicles. The seat belt brackets may not be secured to the seat frame in the front-row center seating position.
If a seat-belt bracket is not secured, the seat belt may not properly restrain an occupant in the front-row center seat position, increasing the risk of injury in a crash.
GM will notify owners, and dealers will inspect left-side and right-side front-row center seat-belt bracket attachments and reassemble it correctly as necessary, free of charge. The recall began January 26, 2021. Owners may contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N202314670.
Campaign 20V792000 on NHTSA.gov
SeatsNov 25, 2020
General Motors LLC (GM) is recalling certain 2021 Chevrolet Suburban and Tahoe and GMC Yukon and Yukon XL vehicles. During general assembly, a repair involved removal of one or both front seats. The attachment bolts for the front seats may not have been properly reinstalled after the repair was completed.
If an occupied front seat has loose or missing attachment bolts, it may move during a crash, increasing the risk of injury to the seated occupant.
GM will notify owners, and dealers will inspect the seat attachments for both front seats and install attachment bolts as needed, free of charge. The recall began December 21, 2020. Owners may contact Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-888-988-7267. GM's number for this recall is N202312720.
Campaign 20V735000 on NHTSA.gov
Representative owner complaints: power train
88 reports, newest first. Show all
Power train, Feb 4, 2026
The contact owns a 2021 Chevrolet Tahoe. The contact stated that while driving at an undisclosed speed, there was a loud grinding sound coming from the rear of the vehicle. There was no warning light illuminated. The vehicle was taken to the dealer and was diagnosed with failure. The contact was informed that the rear differential assembly needed to be replaced. The vehicle was not repaired. The contact related the failure with NHTSA Campaign Number: 22V036000 (Power Train); however, the VIN was not included. The manufacturer was made aware of the failure. The approximate failure mileage was 95,000.
Power train, Engine, Jan 19, 2026
6.2l motor blew up set at dealership for 4 months no motor to fix it. finally got it back with in 10 days the torque converter need replaced in the transmission. out of service out f service for motor june 19 2025 got it back october 20 2025. transmission went out 10mdays later
Power train, Engine, Jan 15, 2026
* Sudden Catastrophic Engine Failure. * The car lost power in the middle of a high traffic, very dark country road, forcing her to stay in the middle of the (undivided) road in the dark hoping cars didn't slam into her. A Collin County Sheriff was dispatched to keep her safe until the tow truck arrived almost two hours later." * The vehicle was towed to a dealer where they confirmed that the torque converter, valves, lifters had failed. Dealer didn't disclose that there was any issues for these engines, which there is. It's a 6.2L V8 Tahoe High Country. * It has only been inspected by the dealer, not the manufacturer, police, insurance representatives, etc... * The vehicle indicated a traction control problem, then the engine light came on, and then the engine failed followed by loss of power. All happened in rapid succession WITH NO OPPORTUNITY FOR THE DRIVER TO GET TO A SAFE LOCATION. * There was no warning or other symptoms preceding this. The vehicle has always been faithfully serviced at Chevy dealerships consistent with the manufacturers recommendations.
Power train, Engine, Jan 7, 2026
AFM lifter collapse on Cylinder 6 Written repair estimate or a Diagnostic report showing P0306 + lifter failure
Power train, Other or unspecified, Fuel/propulsion system, Jan 3, 2026
This vehicle has experienced multiple substantial defects, several of which directly endangered my family, including an infant, and rendered the vehicle unsafe and inoperable for extended periods despite warranty repairs. Summary of defects and failures: 1.Electronic door locking failure The vehicle experienced an electronic malfunction that caused the doors to randomly lock, resulting in my infant being locked inside the vehicle when we exited. This wiring defect was later repaired under warranty but represents a serious safety failure. 2.Fuel pump recall and highway breakdown While driving my family of six on a major highway over an hour from home, the recalled fuel pump failed while in motion, leaving us stranded on the side of the highway. We were forced to arrange an Uber for transportation. This incident placed my family in a dangerous situation and constitutes a major safety-related defect. 3.Transmission failure and extended inoperability The vehicle suffered a transmission failure that rendered it unsafe and inoperable. The dealership required over one week to schedule service and more than two additional weeks before the vehicle was inspected and repaired. The vehicle was out of safe driving condition for approximately one month. Upon return, the vehicle experienced additional failures, including a dead battery. 4.Known poor design defect – rear entertainment screens The rear entertainment system screens cracked due to a widely known poor design and placement issue, unrelated to misuse. 5.Rear headrest internal mechanism failure The internal mechanism of a rear headrest failed and requires replacement, further demonstrating ongoing quality and safety concerns. Due to the number, severity, and safety-related nature of these defects—combined with cumulative downtime exceeding 30 days—I have lost all confidence in this vehicle. I no longer consider it safe or reliable for transporting my family.
Power train, Dec 18, 2025
My Tahoe was making a loud noise, I took it to the dealer to look at it and they said I need to replace the rear driveshaft to the tune of $4000. I don't have $4000 to spend on this. This Tahoe is only 4 years old and was supposed to drive us to Minnesota next week for Christmas and now that is not possible. This is a known issue and a recall, but my VIN not included in that recall. How can this happen - you know it is a known issue in these cars! Power train Recall date 2022-01-27 Recall no. 22V036000 General Motors, LLC (GM) is recalling certain 2021 GMC Yukon, Yukon XL, Cadillac Escalade, Escalade ESV, Chevrolet Suburban, and Chevrolet Tahoe vehicles. The rear wheel driveshaft assemblies may have internal components that were not heat-treated properly, possibly resulting in driveshaft failure. Recall consequence Driveshaft failure can cause a sudden loss of drive power, increasing the risk of a crash. Recall action Dealers will replace the left and/or right rear driveshaft assemblies, free of charge. An owner notification letter mailing date has not been finalized. Owner notification letters are expected to be mailed April 15, 2022. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006 or GMC customer service at [XXX] . GM's number for this recall is XXX INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Power train, Dec 16, 2025
2021 Tahoe Z71 with 70000 miles making a roaring and whining noise on reverse and turning, especially when cold. Took to shop and they changed the rear differential fluid. Now its worse. Needs a whole new rear end. This veicle is 4 years old and does not tow or use four wheel drive. The shop said there has been so many complaints and services on the same issue. Why is there not a recall on this yet? We spend $70,000 and up and expect a more quality vehicle without having to spend $4000 dollars on repairs.
Power train, Dec 16, 2025
Issue related to the rear-differential fluid, TSB 21-NA-028. Its a known issue where the rear differential make moan/chatter noises on turning (including at low speeds). Dealers are instructed to service/replace the rear differential fluid and perform procedures to address clutch pack chatter. It is such an issue, the fluid to remedy this is on back order!
Power train, Dec 5, 2025
Based on dealer inspection, oil was found sitting on top of the #2 piston, and you’ve indicated the failure is originating from the bottom end of the engine—likely involving piston, ring, or cylinder wall damage. Combined with the stored P050D, P0300, and P0302 codes, this represents a clear internal mechanical failure. Vehicle is currently at the dealership. Mechanical failure while driving the vehicle. Sensor light for service ESC and service traction control both showed as the failure was occurring.
Steering, Power train, Dec 3, 2025
While driving and turning left and right, and while cold and turning It does a grinding/groan noice, and recently while driving it did that, and It started losing speed and the grinding worsening and I was losing control of the vehicle. Putting the vehicle in Auto makes the groan/grind worse.
Power train, Engine, Nov 20, 2025
I am writing to formally document serious engine defects I have experienced with my 2021 Chevrolet Tahoe equipped with the 5.3L L84 V8 engine. 1.Crankshaft Failure: My Tahoe suffered a catastrophic crankshaft failure that required major repair/replacement. I am aware that GM has recalled certain vehicles equipped with the 6.2L L87 engine for crankshaft and rod-bearing defects. Based on my experience, the same or a very similar defect has also occurred in my 5.3L engine, which is currently not included in that recall. 2.Valve Lifter Failure: In addition, my vehicle has suffered from valve lifter collapse—a well-documented problem in 2021–2022 GM trucks and SUVs with both the 5.3L and 6.2L engines. This caused severe misfiring, drivability issues, and expensive repair needs. Why this is a concern: •Both failures occurred well before what would be expected of a modern engine. •The crankshaft failure raises a safety risk: sudden loss of propulsion while driving could lead to accidents. •The lifter issue is widely reported by other owners and has been the subject of GM service bulletins. •Taken together, these problems suggest systemic defects in the 2021 Tahoe’s 5.3L engine that have not been adequately addressed by GM. Requested Action: •I ask GM to extend recall and warranty coverage to include the 5.3L L84 engine in addition to the 6.2L L87. •I ask NHTSA to consider investigating whether the scope of the current 6.2L recall should be broadened to include 5.3L engines, given failures like mine. •At minimum, I request assistance in covering repair/replacement costs for both the crankshaft and lifter defects, which are clearly not due to normal wear and tear. Vehicle details: •Year/Make/Model: 2021 Chevrolet Tahoe •Engine: 5.3L V8 L84
Steering, Power train, Engine, Nov 11, 2025
The rear differential makes a rubbing or humming noise when turning left/right at slow speed especially when it’s cold.
Power train, Oct 24, 2025
My 2021 Chevrolet Tahoe recently displayed a warning message that said “Service Transmission – May Not Be Able to Shift Soon.” The message appeared at approximately 132,754 miles. Since then, I’ve noticed delayed and rough shifting between gears. The vehicle still drives and shifts into gear, but the message and behavior are concerning. I have an appointment scheduled for a diagnostic inspection on Tuesday, which was the earliest available. I have not yet received a confirmed diagnosis, but I’ve seen that many other 2021 Tahoe's and similar GM vehicles have experienced the same transmission problem and were included in recalls. My vehicle’s symptoms match those reports, though my VIN was not included. This situation makes me nervous because I drive with my four children daily. Even though the vehicle hasn’t completely lost the ability to shift, a sudden failure while driving could put my family and others on the road at risk. The warning itself suggests a potential failure is coming soon. The vehicle has been properly maintained and has not had prior transmission work. I’m reporting this because it appears to be part of a larger pattern that should be investigated to determine if more vehicles need to be included in GM’s existing transmission recall.
Power train, Vehicle speed control, Engine, Oct 13, 2025
On the morning of 1 Oct, I had left the house here in Cedartown GA to head to a meeting in Atlanta with a customer. I had started the truck 15 minutes before departing just as we have always done to our vehicles over the years to allow them to warm up properly. I departed Doyle Rd onto Hwy 27 South heading towards interstate 20. About 15 miles from the house I was at a steady cruise speed of 45 MPH, no traffic, acceleration or deceleration and the stability control system light came on, one second later the engine light came on and the engine all of a sudden started making a loud grinding and clunking noise. I was on the inside lane so let the car pass next to me and started to pull over onto the shoulder of the road. I immediately shut off the truck, popped the hood and got out to inspect what might have happened. There was no smoke, I checked all the fluids and all were at the normal ranges. The engine oil was at its full mark as well. The oil was just changed a month early and still of the same color as it was new. After checking, I got back on the truck, attempted to start and it ran for a few seconds then I immediately shut it off after hearing again the loud noise. A Polk county police officer stopped to check on me and offer assistance as well as some tow companies to call. Eventually after about at hour a tow truck showed, we tried to momentarily start the vehicle so it could be put in neutral but the engine had locked up. I’m glad I got off the road when I did, otherwise I feel I could have been driving and experienced that sudden lock up and loss of control which could have been a serious accident with log trucks up and down that highway all day long. This vehicle is my wife’s primary vehicle and always has been maintained to a T just like all of our GM vehicles have. My daughter just graduated and drives our passed down 2005 Tahoe with over 300k miles that we bought in 2006. This has never happened to us and I feel it is a serious safety issue on the 6.2
Power train, Sep 9, 2025
I have a 2021 Tahoe that while circling a parking lot at my son's football practice. The Tahoe's emergency came on and the Tahoe abruptly stopped. A checked engine light came on. The Tahoe wouldn't release the emergency brakes. I was finally able to get it released. I took the vehicle to a transmission shop because I plugged OBD scan tool on it. It had two transmission codes. One generic and one for the vavle body. The transmission shop said they have had lots of Tahoes with the vavle body's going out. They told me about N242454441. I called Chevrolet and they advised me that wasn't for my Tahoe. I asked why and they said they don't know. If this is effecting the desiel only models then why is mine doing the same thing. Parts cant be ordered either. Please look into this matter.
Power train, Sep 5, 2025
This is an amendment to campaign 11684444 as there is some inaccurate info as it pertains to the diagnostic- 2021 Chevrolet Tahoe, Driving 25 MPH, in the neighborhood, my Tahoe kicked into neutral and abruptly stopped in the middle of the street. I immediately tried to restart it, however it would not start. After about 15 minutes, we tried again and it started enough to make it back to my in laws house, where it remains parked today. We did a diagnostic test and received the code for Fuel Pump Control Module failure. Contacted the Chevrolet dealership I bought my vehicle from and they indicated this is a common issue and the part is on back order. This is a very dangerous risk to safety and should be covered under a recall. I've seen where GMC issued a recall for the exact same issue, but only for Tahoes with 6.2L V8 engine; Mine is 5.3L. I am confused why that matters as it poses the same safety risk across the board. Very dangerous. Please consider this as a recall.
Power train, Sep 3, 2025
Rapid deceleration at 55mph on highway, followed by console message "reduced acceleration" with check engine light. Fortunately rolled into dealer within a mile. After analysis, they stated the transmission valve body and electronic control component needs replacement over $3,000. after tax. No warning signs prior. NTSB recall N24254441 covers only diesel engines not gas with same problem in 10 speed transmission.
Power train, Engine, Sep 2, 2025
I am writing to formally document serious engine defects I have experienced with my 2021 Chevrolet Tahoe equipped with the 5.3L L84 V8 engine. 1.Crankshaft Failure oMy Tahoe suffered a catastrophic crankshaft failure that required major repair/replacement. oI am aware that GM has recalled certain vehicles equipped with the 6.2L L87 engine for crankshaft and rod-bearing defects. oBased on my experience, the same or a very similar defect has also occurred in my 5.3L engine, which is currently not included in that recall. 2.Valve Lifter Failure oIn addition, my vehicle has suffered from valve lifter collapse—a well-documented problem in 2021–2022 GM trucks and SUVs with both the 5.3L and 6.2L engines. oThis caused severe misfiring, drivability issues, and expensive repair needs. Why this is a concern: •Both failures occurred well before what would be expected of a modern engine. •The crankshaft failure raises a safety risk: sudden loss of propulsion while driving could lead to accidents. •The lifter issue is widely reported by other owners and has been the subject of GM service bulletins. •Taken together, these problems suggest systemic defects in the 2021 Tahoe’s 5.3L engine that have not been adequately addressed by GM. Requested Action: •I ask GM to extend recall and warranty coverage to include the 5.3L L84 engine in addition to the 6.2L L87. •I ask NHTSA to consider investigating whether the scope of the current 6.2L recall should be broadened to include 5.3L engines, given failures like mine. •At minimum, I request assistance in covering repair/replacement costs for both the crankshaft and lifter defects, which are clearly not due to normal wear and tear. Vehicle details: •Year/Make/Model: 2021 Chevrolet Tahoe •Engine: 5.3L V8 L84
Power train, Electrical system, Engine, Aug 30, 2025
The affected systems are the power train, engine, and electrical. My 2021 Chevrolet Tahoe experienced failures consistent with GM Technical Service Bulletin 21-NA-149 (engine wiring harness chafing) and the conditions outlined in Recall N232404190 (valve body failure, November 2024). Beginning in March 2025, the vehicle displayed warning lights and messages including Check Engine, Traction Control, Service Transmission, and limp mode (Reduced Acceleration – Drive with Care). The vehicle shifted erratically, lost power, and occasionally failed to accelerate, creating a serious safety hazard at highway speeds. These problems were documented at AutoNation Chevrolet South Clearwater, where multiple diagnostic trouble codes (P0700, P0717, P2714, P2716, P0706, and U-codes) were recorded but not properly investigated. No test drive was performed despite being claimed by the service technician, and the applicable TSB was not referenced. By July 2025, the condition worsened into a complete transmission failure, with additional codes (P0700, P077C, P17F6, P17FB, P1872). The dealer’s estimate required a full transmission replacement at nearly $10,000. GM reviewed the case through its internal Policy Evaluation Tool and increased goodwill assistance from 15% to 40%, while AutoNation contributed only $500. GM’s partial contribution confirms the defect is recognized, yet this VIN remains excluded from the official recall. This issue placed my family and other motorists at significant risk, as sudden loss of power and shifting failures occurred during normal driving conditions. Dealer records, GM documentation, and photographs of warning messages are available. I request that NHTSA expand Recall N232404190 to include affected VINs such as mine, since the symptoms, diagnostic codes, and confirmed failures match exactly what GM has already identified as a known safety issue.
Power train, Electrical system, Engine, Aug 30, 2025
The affected components are the electrical system, engine, and power train. In March 2025, my 2021 Chevrolet Tahoe displayed multiple warning lamps across the dash, including traction control and check engine lights. The vehicle shifted erratically and sometimes entered limp mode. I brought the vehicle to AutoNation Chevrolet South Clearwater for inspection. The dealer replaced the battery, dismissed my concerns, and stated that a test drive was performed, but the mileage in and out on the invoice was identical, showing it never actually occurred. Diagnostic trouble codes (P0700, P0717, P2714, P2716, P0706, and multiple U-codes) were present but were not fully investigated. A GM Technical Service Bulletin (21-NA-149, December 2022) covers these exact symptoms (caused by engine wiring harness chafing), but it was never referenced or applied. Because the problem was not addressed, the condition worsened. By July 2025, the vehicle suffered a complete transmission failure. At that point, the dealer confirmed the issue, documenting transmission slipping, shuddering, noise, and additional codes (P0700, P077C, P17F6, P17FB, P1872). GM increased its goodwill contribution from 15% to 40% of the $9,925 repair cost, while AutoNation offered only $500 despite their role in the missed diagnosis. Safety Risk: My family and I were at risk each time the vehicle stalled, lost power, or shifted erratically while driving, including at highway speeds. These failures created a significant risk of collision. The drivability problem was not properly confirmed in March 2025 despite multiple codes being present. By July 2025, the dealer acknowledged and confirmed the transmission failure. The vehicle remains available for inspection, and I have retained all invoices, diagnostic reports, and communications with GM and the dealership.
Engine, Power train, Aug 5, 2025
I am submitting this complaint regarding my 2021 Chevrolet Tahoe (VIN: [XXX] ) which has developed a severe transmission shudder at both low and highway speeds. The issue has been confirmed by my Chevrolet dealer, who provided an estimate of $5,492.18 for torque converter and valve body replacement. This failure is identical to the torque converter shudder problem documented in GM service bulletins and special coverage adjustments for other GM vehicles of the same make, model, and model year. However, my VIN is not currently included in those programs, leaving me without coverage despite experiencing the exact same defect. I believe this condition poses a serious safety risk, as the shudder occurs while driving at highway speeds, causing vibration, hesitation, and potential loss of control. These symptoms could lead to accidents if the vehicle fails to respond properly during acceleration or lane changes. Given that this appears to be a widespread defect affecting multiple GM vehicles, I respectfully request that NHTSA investigate and consider expanding any related recall or special coverage programs to include affected VINs such as mine. Please let me know if further documentation, service records, or dealer estimates are needed to support my complaint. Thank you for your time and for working to ensure vehicle safety. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Power train, Jul 23, 2025
In May 2025, my 2021 Chevy Tahoe experienced transmission failure related to the valve body. The vehicle has now been at the dealership (Richard Chevrolet in Cheshire, CT) for over 2 months with no timeline for repair due to a national backorder on the part. This issue is widely reported among 2021 Tahoes and other GM vehicles, and appears to be a systemic transmission defect. I was never notified of any recall or service bulletin, and I’m still making monthly payments on a vehicle that is inoperable. The rental provided does not suit my family’s needs, and GM has been unable to offer a resolution or clear update. This type of critical drivability failure should be classified as a safety concern, especially considering the volume of similar complaints and the absence of repair parts. I am requesting NHTSA investigate this issue further and take action if warranted.
Power train, Electrical system, Engine, Jul 16, 2025
On 01/03/24, the vehicle stalled and smoked on the Suncoast Parkway. All dashboard warning lights and messages illuminated, and the vehicle entered emergency park mode. OnStar was contacted and the vehicle was towed to Jenkins Chevrolet in Homosassa, FL. The failure was linked to a broken pulley and belt system that damaged the ECM and wiring harness. No DTCs were pulled, and mileage in/out was 80042/80043—no test drive performed. On 08/06/24, the vehicle returned to Jenkins for a roaring noise. A pulley bearing was replaced, possibly related to the earlier failure. Again, no drivability evaluation or codes recorded. On 03/09/25, the same full system warning lights/messages appeared again. The vehicle experienced harsh shifting and delayed acceleration. It was taken to AutoNation Chevrolet South Clearwater on 03/10/25. DTCs (P0700, P0717, P2714, P2716, P0706, and U-codes) were found but dismissed. Only the battery was replaced. Mileage in/out was 99494—no test drive performed despite claims one occurred. On 07/08/25, the vehicle again showed full dashboard warnings. Brought back to AutoNation on 07/09/25. On 07/14/25, customer received a $9,177.85 estimate including full transmission replacement. Safety was at risk due to repeated stalling, loss of acceleration, and emergency parking mode while driving or merging. These failures could have led to accidents or left the vehicle disabled in traffic. Driver and children were present during each incident. The vehicle is enrolled in OnStar and the MyChevy app, which provide monthly health reports. Despite these incidents, no faults or warnings were ever shown in the reports. Vehicle remains available for inspection. A case is open with GM. Across 4 service visits, GM-certified dealerships failed to follow proper protocols, including code checks, drivability assessments, and test drives—contributing to delayed diagnosis of transmission failure.
Power train, Jul 9, 2025
The contact owns a 2021 Chevrolet Tahoe. The contact stated that while driving at an undisclosed speed, the transmission unexpectedly downshifted to a lower gear. There was no warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed that the transmission valve body had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 39,000.
Fuel system, Gasoline, Power train, Jul 9, 2025
The contact owns a 2021 Chevrolet Tahoe. The contact stated that the vehicle displayed "Reduced Power," and the rear wheels started to lock-up. The contact was able to keep control of the vehicle and continued driving. The vehicle was taken to the dealer, who completed the repair under NHTSA Campaign Number: 24V797000 (Power Train). The contact stated that after the recall repair, while leaving the dealer and driving approximately 10 MPH, the vehicle veered off to the right and ended up partially in the next lane. The contact stated that the vehicle unintendedly shifted into neutral, and the message to "Press Start Again" was displayed. The contact was able to restart the vehicle and parked the vehicle in a nearby parking lot. The contact restarted the vehicle and drove back to the dealer. The failure recurred twice while returning to the dealer. The dealer diagnosed that there was a fuel pump drive failure. The vehicle was not repaired. The manufacturer was informed of the failure and confirmed the VIN was no longer under NHTSA Campaign Number: 24V797000 (Power Train). The manufacturer opened a case. The failure mileage was approximately 69,000.