2002 Ford Escape
Problems, recalls and owner-reported issues
Engine and engine cooling is the leading concern among 1,070 owner complaints filed for this model year. This is the 13th highest complaint count among 26 Escape model years with reports.
Of the 2002 reports, 68 involved a crash and 108 involved a fire. 45 people were injured and 2 people died.
What owners report most often
Recalls and investigations
Power train, automatic transmission, lever and linkage, floor shiftSep 29, 2015
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Campaign 15V606000 on NHTSA.gov
Suspension, front, wheel bearingJun 3, 2015
The Timken Company (Timken) is recalling certain aftermarket front wheel bearings, part number 510072, sold from January 22, 2015, to May 21, 2015, to be used as service parts on 2001-2012 Ford Escape, 2001-2011 Mazda Tribute, and 2005-2011 Mercury Mariner vehicles. The affected wheel bearings have incorrect dimensions of a 42mm bore, 76mm outer dimension, and 39mm width, instead of a 42mm bore, 78mm outer dimension and a 45mm width.
Use of an incorrectly sized wheel bearing can adversely affect the braking and steering of the vehicle, increasing the risk of a crash.
Timken has begun notifying distributors who will offer purchasers replacement wheel bearings, free of charge. The recall began on May 21, 2015. Owners may contact Timken customer service at 1-866-984-6536.
Campaign 15E045000 on NHTSA.gov
Structure, frame and membersApr 2, 2014
Ford Motor Company (Ford) is recalling certain model year 2001-2004 Escape vehicles manufactured October 22, 1999, through January 23, 2004, originally sold, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. These vehicles may experience excessive corrosion at the forward attachment of the lower control arm.
A separation of the lower control arm can result in a significant loss of steering control, increasing the risk of a crash.
Ford will notify owners, and dealers will install a newly designed reinforcement cross-brace, free of charge. The recall began on May 30, 2014. Owners may contact Ford at 1-800-392-3673. Ford's number for this recall is 14S02.
Campaign 14V165000 on NHTSA.gov
Engine and engine coolingJul 26, 2012
Ford Motor Company is recalling certain model year 2001 through 2004 Escape vehicles equipped with 3.0L V6 engines and speed control manufactured from October 22, 1999, through January 23, 2004. Inadequate clearance between the engine cover and the speed control cable connector could result in a stuck throttle when the accelerator pedal is fully or almost-fully depressed. This risk exists regardless of whether or not speed control (cruise control) is used.
A stuck throttle may result in very high vehicle speeds and make it difficult to stop or slow the vehicle, which could cause a crash, serious injury or death.
Ford will notify owners, and dealers will repair the vehicles by increasing the engine cover clearance, free of charge. The safety recall began August 3, 2012. Remedy parts are expected to be available in mid-August 2012. Until then dealers will disconnect the speed control cable as an interim remedy, if parts are not available at the time of an owner's service appointment. Owners may contact Ford at 1-866-436-7332.
Campaign 12V353000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/moduleJan 9, 2012
FORD IS RECALLING CERTAIN MODEL YEAR 2001-2002 ESCAPE VEHICLES MANUFACTURED FROM OCTOBER 22, 1999, THROUGH JULY 19, 2002, EQUIPPED WITH A BRAKE MASTER CYLINDER RESERVOIR CAP THAT COULD LEAK BRAKE FLUID. IF BRAKE FLUID LEAKS FROM THE CAP, IT COULD COME IN CONTACT WITH THE ANTILOCK BRAKE SYSTEM (ABS) MODULE WIRING HARNESS CONNECTOR.
CORROSION CAN DEVELOP IN THE ELECTRICAL CONNECTOR LEADING TO MELTING, SMOKE OR A FIRE.
DEALERS WILL REPLACE THE BRAKE MASTER CYLINDER RESERVOIR CAP AND THE ABS ELECTRICAL SYSTEM WILL BE MODIFIED. AN INTERIM LETTER WAS MAILED ON JANUARY 20, 2012. DUE TO A PARTS DELAY, HOWEVER, THE REMEDY MAY NOT BE AVAILABLE CURRENTLY. IF PARTS ARE NOT AVAILABLE, FORD WILL INSTRUCT OWNERS TO PARK THEIR VEHICLES OUTSIDE UNTIL SUCH TIME AS PARTS BECOME AVAILABLE. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. THIS RECALL CAMPAIGN IS RELATED TO 07V-156.
Campaign 12V005000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/moduleApr 10, 2007
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH ANTILOCK BRAKES (ABS), THE ABS MODULE CONNECTOR MAY HAVE MISSING OR DISLODGED WIRE SEALS. THIS CONDITION COULD ALLOW CONTAMINATION TO ENTER THE MODULE CONNECTOR, CREATING A POTENTIAL FOR AN ELECTRICAL SHORT.
AN ELECTRICAL SHORT MIGHT CAUSE AN ABS MALFUNCTION THAT WOULD ILLUMINATE THE ABS WARNING LIGHT, AND IN SOME CASES, THE MODULE MAY OVERHEAT RESULTING IN BURNING ODOR, SMOKE, AND/OR FIRE. THIS CONDITION COULD OCCUR EITHER WHEN THE VEHICLE IGNITION SWITCH IS IN THE OFF POSITION OR WHILE THE VEHICLE IS BEING OPERATED.
DEALERS WILL INSPECT THE WIRE HARNESS CONNECTOR TO THE ABS MODULE FOR MISSING OR DISLODGED WIRE SEALS, AND REPAIR OR REPLACE THE HARNESS CONNECTOR AS APPROPRIATE. THE DEALER WILL ALSO INSPECT THE CONNECTOR ON THE ABS MODULE AND REPLACE IT IF IT IS FOUND TO BE CORRODED OR DAMAGED. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 07V156000 on NHTSA.gov
Service brakes, hydraulic, foundation components, master cylinderMar 29, 2007
CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.
LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.
CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.
Campaign 07E023000 on NHTSA.gov
Latches/locks/linkages, doors, latchDec 20, 2004
CERTAIN 2004-2005 SPORT UTILITY VEHICLES AND CERTAIN 2001-2003 SPORT UTIITY VEHICLE HAVING REAR LIFTGATE COMPONENTS SERVICED WITH 2004 EQUIVALENT COMPONENTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, 'DOOR LOCKS AND DOOR RETENTION COMPONENTS.' THE REAR LIFTGATE LATCHING SYSTEM DOES NOT MEET THE INERTIA LOAD REQUIREMENT IN ONE DIRECTION.
IF THE LIFTGATE IS LEFT UNLOCKED, THERE IS THE POTENTIAL THAT IT MAY OPEN DURING A CRASH.
DEALERS WILL REPLACE THE REAR LIFTGATE LATCH RELEASE ROD, THE RELEASE ROD ATTACHMENT CLIP AND THE DOOR HANDLE RETURN SPRING. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V602000 on NHTSA.gov
Vehicle speed control, cablesDec 7, 2004
ON CERTAIN SPORT UTILITY VEHICLES BUILT WITH 3.0L V6 ENGINES, THE ACCELERATOR CABLE MAY PREVENT THE THROTTLE FROM RETURNING TO THE IDLE POSITION.
AN UNEXPECTED INCREASE IN ENGINE IDLE SPEED MAY INCREASE STOPPING DISTANCE AND MAY RESULT IN A VEHICLE CRASH.
DEALERS WILL REPLACE THE ACCELERATOR CABLE. THE RECALL BEGAN ON JANUARY 10, 2005. OWNERS SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 04V574000 on NHTSA.gov
Power train, automatic transmission, control module (tcm/pcm/tecm)Apr 6, 2004
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 3.0L V6 ENGINES, DURING DECELERATION, THE ENGINE CAN STALL.
SHOULD THE ENGINE STALL, A VEHICLE CRASH COULD OCCUR.
DEALERS WILL REPROGRAM THE POWER CONTROL MODULE (PCM) WITH THE APPROPRIATE CALIBRATION. OWNER NOTIFICATION BEGAN ON APRIL 21, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V165000 on NHTSA.gov
Representative owner complaints
1,070 reports, newest first.
Engine, Feb 14, 2019, fire
AS SHOWN IN ATTACHED PICTURE MY COOLANT CONTAINER IS BURNING AS IF IT IS TRYING TO CATCH FIRE. AS ALSO SEEN THE COOLANT LEVEL IS BACK AT MAX BUT AT ONE POINT WAS LOW. CONCERN IS 🔥 SAFETY. I WAS DRIVING DOWN THE HIGHWAY WHEN I FIRST SMELT BURNING I DID STOP DRIVING AND IT MADE IT MORE INTENSE. NO ACTUAL FIRE TOOK PLACE BUT INSIDE CONTAINER IT APPEARS TO HAVE HAD A SMALL FIRE OR BURN AS SHOWN BY IMAGE.
Suspension, Jan 3, 2019
TL* THE CONTACT OWNS A 2002 FORD ESCAPE. WHILE DRIVING VARIOUS SPEEDS, A KNOCKING SOUND WAS HEARD COMING FROM THE FRONT OF THE VEHICLE. THE VEHICLE WAS TAKEN TO LIBERTY MAZDA (91 WEST SERVICE RD, HARTFORD, CT) WHERE IT WAS DIAGNOSED THAT THE LOWER CONTROL ARM WAS RUSTED, CORRODED, AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 103,000. THE VIN WAS UNKNOWN.
Structure, Dec 4, 2018
TL* THE CONTACT OWNS A 2002 FORD ESCAPE. THE CONTACT STATED THAT THE FRAME OF THE VEHICLE WAS COMPLETELY RUSTED. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE SHOOK VIOLENTLY. THE VEHICLE WAS TAKEN TO BRIAN BEMIS FORD (1380 DEKALB AVE, SYCAMORE, IL 60178, (815) 895-4584) TO BE DIAGNOSED AND THEY REFUSED TO RELEASE THE VEHICLE BACK TO THE CONTACT DUE TO THE DANGEROUS CONDITION OF THE RUSTED FRAME. THE DEALER STATED THAT THEY WOULD NOT CHARGE THE CONTACT A STORAGE FEE. THE CONTACT PURCHASED THE VEHICLE IN MARCH OF 2018. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 125,000. *TT*JB
Structure, Dec 3, 2018
MY VEHICLE SHOULD BE COVERED UNDER FORD RECALL 14S02. SUB FRAME COMPLETELY RUSTED THROUGH WHILE DRIVING ENDANGERING MY FAMILY'S SAFETY. ILLINOIS, "SALT STATE". CURRENTLY AT FORD DEALERSHIP UNSAFE TO DRIVE.
Power train, Sep 13, 2018
ON 2002 FORD ESCAPE XLT, WHILE DRIVING CAR IN REVERSE GEAR BACKING OUT OF GARAGE DOWN HILL AND TURNING ON ROAD ALSO WITH STEEP DOWN HILL, TRANSMISSION SHIFTER CABLE DETACHED FROM TRANSMISSION. COULD NOT GET CAR OUT OF REVERSE GEAR. THIS CAUSED A VERY DANGEROUS SITUATION AS CAR ROLLED BACKWARDS DOWN HILL OUT OF CONTROL WHEN ENGINE SHUT OFF. USED EMERGENCY BRAKE TO STOP CAR AND BLOCKED WHEELS WITH ROCKS TO DIAGNOSE. BUSHING ON SHIFTER CABLE END CLOSEST TO TRANSMISSION DISENTEGRATED AND SHIFTER CABLE SLIPPED OFF LINK TO TRANSMISSION SUCH THAT THE COLUMN SHIFT WAS DETACHED FROM TRANSMISSION. HAD NO PRIOR WARNINGS TO INSPECT THIS. FOUND THROUGH RESEARCH THAT FORD HAD ISSUED RECALL NUMBER 18S20 FOR FORD ESCAPE MODEL YEARS 2013-2014 FOR EXACT SAME ISSUE ON JULY 18, 2018. CALLED FORD CUSTOMER SERVICE. FORD REFUSED TO ACKNOWLEDGE THIS ISSUE FOR MODEL YEAR 2002. TEMPORARILY FIXED ISSUE TO CONTINUE DRIVING CAR. VERY DANGEROUS SITUATION. I AM NO EXPERT, BUT SOMEONE WITH LESS EXPERTISE THAN ME COULD BE IN A LOT OF TROUBLE AS THIS CAN HAPPEN ON A HILL WHERE THE CAR CAN ROLL OUT OF CONTROL. RECOMMEND FORD ADD THIS MODEL YEAR TO RECALL LIST OR AT LEAST ISSUE WARNING TO OWNERS TO INSPECT SHIFTER CABLE BUSHING. DIFFICULT TO GET PHOTO SINCE TRANSMISSION CABLE BURIED DOWN IN ENGINE COMPARTMENT, BUT COULD ATTEMPT UPON REQUEST.
Fuel/propulsion system, Sep 6, 2018
FUEL GAS TANK STRAPS ROTTED OUT CAUSING THE FUEL TANK TO FALL
Steering, Structure, Electronic stability control (ESC), Jun 24, 2018
MY ENGINE COOLANT LIGHT STAYS ON EVEN AFTER TAKING STEPS TO FIX IT AS IT WAS A PROBLEM WITH THE 2002 FORD ESCAPES, AND THERE IS A PROBLEM WITH MY POWER STEERING AS FLUID AND ALL THAT IS FINE, WHICH I READ WAS A RECALL ALSO.
Latches/locks/linkages, Jun 19, 2018
TL* THE CONTACT OWNS A 2002 FORD ESCAPE. THE CONTACT STATED THAT THE LIFTGATE FAILED TO OPEN. THE VEHICLE WAS TAKEN TO THE DEALER (CURRIE MOTORS FORD OF VALPO, 2052 W MORTHLAND DR., VALPARAISO, IN 46385, (219) 464-3523), BUT THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 88,000.
Suspension, Jun 19, 2018
TL* THE CONTACT OWNS A 2002 FORD ESCAPE. WHILE DRIVING 10 MPH, THE LOWER CONTROL ARM FRACTURED AND THE FRONT DRIVER SIDE WHEEL SEPARATED FROM THE VEHICLE. THE CONTACT STATED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED PER NHTSA CAMPAIGN NUMBER: 14V165000 (STRUCTURE). THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC, BUT WAS NOT REPAIRED. THE CONTACT WAS CONCERNED THAT THE RECALL REMEDY WAS NOT SUFFICIENT TO PREVENT A FAILURE. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 96,000. *TT
Service brakes, Hydraulic, Engine and engine cooling, Vehicle speed control, Jun 18, 2018, fire
TL* THE CONTACT OWNED A 2002 FORD ESCAPE. THE CONTACT STATED THAT THE VEHICLE CAUGHT FIRE WHILE PARKED IN HER DRIVEWAY. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE AND FILED A REPORT. THE FIRE DEPARTMENT STATED THAT THE MASTER BRAKE CYLINDER AND THE CRUISE CONTROL CABLES WERE MELTED. THE VEHICLE WAS DEEMED A TOTAL LOSS, BUT WAS NOT TOWED FROM THE CONTACT'S RESIDENCE. THE DEALER (LITHIA FORD OF MISSOULA, 3943 BROOKS ST, MISSOULA, MT 59804) AND THE MANUFACTURER WERE CALLED AND THE CONTACT WAS AWAITING A CALL BACK. THE CONTACT STATED THAT SHE HAD NOT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 12V005000 (SERVICE BRAKES, HYDRAULIC) AND 12V353000 (ENGINE AND ENGINE COOLING, VEHICLE SPEED CONTROL). THE FAILURE MILEAGE WAS 145,000. .*BF *TR
Engine, May 30, 2018
FORD EXCURSION V10 ALUMINUM HEAD COMPLAINT SPARK PLUG BLEW OUT OF HEAD. THIS HAPPENED WHILE DRIVING ACROSS COUNTRY TO VISIT MY SON, NO WARNING JUST BLEW COMPLETELY OUT OF HEAD AND LEFT ME STRANDED ALONG THE ROADSIDE. THIS PROBLEM WHICH FORD IS AWARE IS NOT BEING FIXED OR RECALLED, TRUCK JUST TURNED 100,000 MILES BUT IF ONE SPARK PLUG BLEW WHEN WILL THE OTHERS LET GO AND EXPLODED OUT OF THE HEAD AND LEAVE ME STRANDED AGAIN ALONG A BUSY HIGHWAY ROUTE 70 IN A STATE WHICH I HAVE NEVER BEEN IN BEFORE AT 5 AM IN THE MORNING, WITHOUT A KNEW HEAD DESIGN THIS MAKES THIS VEHICLE VERY UNRELIABLE AND NOT SAFE TO DRIVE , ITS LIKE DRIVING A TIME BOMB JUST WAITING FOR THE NEXT PLUG TO BLOW, VEHICLE WAS 40,000 DOLLARS IN 2002 WHO HAS MONEY TO PURCHASE ANOTHER VEHICLE WHICH IS NOW ALMOST 60,000 FORD SHOULD BE REQUIRED TO MAKE REPLACEMENT HEADS FOR ALL TRITON ENGINES
Other or unspecified, May 23, 2018
THE GEARS WILL NOT SHIFT INTO DRIVE ONLY 2ND AND 1ST AND REVERSE HEARD A CLANK AND SOUNDED LIKE A SCREW OR SOME SORT DROPPED BUT CANNOT FIND IT. THE VEHICLE WAS PARKED I WENT TO PUT IT IN DRIVE AND THAT'S WHEN IT OCCURRED
Steering, Electrical system, Fuel/propulsion system, May 12, 2018
MY VEHICLE IDLES TO 4000RPM AND CONTROL THE SPEED BY ITSELF, THERE IS A LEAK IN THE BACK BREAK AREA THE STEERING WHEEL LOCKS WHERE I CAN'T PUT IT IN ANY GEAR SOMETIMES AND GETTING WORSE. HAD TO GET IT TOWED HOME LAST NIGHT BECAUSE WHILE DRIVING IT IDLED HIGH AND AS I BRAKE IT BARELY STOPPED AND WHEN RELEASING BREAK IT SPEEDS UP TO 50 OR MORE MPH AND I HAD TO KEEP MY FEET ON THE BREAK..I PULLED OVER AND TURNED THE SWITCH OFF AND WAITED A WHILE AND TURNED BACK ON AND IT IDLED TO 4000 RPM AGAIN. COULD NOT SHIFT THE GEAR FROM PARK AND BREAK PEDAL WAS HARD. WHEN ARRIVING HOME TO BACK CAR IN DRIVEWAY TOWE GUY HAD NO PROBLEM WITH IDLE. THE FOLLOWING MORNING CRANKED AND WAS AT 1000RPM AT FIRST START. ALSO AC PRESSURE. CAR RUNS HOT BUT NO SMOKE WATER BUBBLES IN COOLANT RESERVOIR. MY CHECK ENGINE LIGHT NEVER GAVE WARNING OF ANY OF THE PROBLEMS LISTED.
Suspension, Other or unspecified, May 9, 2018
HAD A RECALL FOR THE LOWER CONTROL ARM ON MAY 30 2014 AND TODAY HAD TO REPLACE THE SAME PART AND FORD ISN'T RECOGNIZING IT AS A PROBLEM , THE PART IS $2000 AND VECHICLE IS STILL WORTH MORE THAN THAT AMOUNT AND I HAD TO BUY THE PART AND PAY FOR THE INSTALLATION AND FORD REFUSE TO CLAIM RESPONSIBILITY FOR IT : THE RECALLED PART FAILED NOT SATISFYING THE RECALL ONLY LASTED 4 YEARS , CAUSING THE CECILE NOT TO PASS STATE INSPECTION
Electronic stability control (ESC), Service brakes, Engine, Apr 28, 2018
BOUGHT THIS CAR AND 2 MILES DOWN ROAD CHECK ENGINE, ABS, AND THE BRAKE AS WELL AS THE OVER DRIVE (ONLY ONE FLASHING) CAME ON. THE CAR GEAR SHIFT LEVER POPS OUT OF GEAR. THE VEHICLE HAS A NEW TRANNY. THE VEHICLE STALLS, AND IS BLOWING TRANNY FLUID. IT HAS HAD THE COMPUTE REPLACEE ON A RECALL. EVERY ISSUE I HAVE FOUND RELATES TO RECALLS, YET FORE TOLD ME NOPE ZERO RECALLS ON THIS EVEN AFTER I SHOWED HIM PROOF OF A RECALL ON THE ENGINE ITSELF. SO RECALLS; 07V156000, 15V606000, 12V005000, AND 04V165000 SOMEHOW DO NOT APPLY? SO I HAVE TO CRASH BEFORE FORD WILLL EVEN LOOK AT THE CAR. IT POPS OUT OF GEAR! CLEARLY AN ABS MALFUNCTION OR NOT? ALL HAZARDS.
Suspension, Structure, Apr 11, 2018
TL* THE CONTACT OWNS A 2002 FORD ESCAPE. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC TO BE SERVICED. WHILE THE MECHANIC WAS TEST DRIVING THE VEHICLE AT APPROXIMATELY 35 MPH, AN ABNORMAL NOISE WAS HEARD COMING FROM THE FRONT OF THE VEHICLE. THE CONTACT STATED THAT THE FRONT PASSENGER SIDE LOWER CONTROL ARM FRACTURED, WHICH CAUSED THE WHEEL TO SEPARATE FROM THE SUSPENSION. PRIOR TO THE TEST DRIVE, THE CONTACT WAS INFORMED BY THE MECHANIC OF SEVERE RUST ON THE LOWER CONTROL ARM. THE VEHICLE WAS TOWED BACK TO THE FACILITY. THE VEHICLE WAS NOT REPAIRED. THE DEALER (ELKHORN MOTORS FORD, 910 N WISCONSIN ST, ELKHORN, WI 53121, (262) 723-2131) WAS CONTACTED AND A SUBSEQUENT VIN SEARCH SHOWED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V165000 (STRUCTURE). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 106,000. THE CONSUMER STATED THE GAS TANK STRAPS WERE ALSO CORRODED AND NEEDED TO BE REPLACED.*JS
Structure, Engine, Apr 6, 2018
TL* THE CONTACT OWNS A 2002 FORD ESCAPE. WHILE THE VEHICLE WAS AT AN INDEPENDENT MECHANIC FOR EXHAUST REPAIRS, THE TECHNICIAN NOTICED THAT THE ENGINE CRADLE AND THE LOWER PART OF THE ENGINE FRAME WERE CORRODED AND NEEDED TO BE REPLACED. THE CONTACT CALLED SUBURBAN FORD OF STERLING HEIGHTS AT (586) 268-7500 (40333 VAN DYKE, STERLING HEIGHTS, MI 48313) AND WAS INFORMED THAT THE VIN WAS NOT INCLUDED IN A RECALL. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 180,000.
Steering, Feb 17, 2018
CROSS MEMBER BAR RUSTED OUT. PLEASE SEE ATTACHED.
Steering, Engine and engine cooling, Structure, Jan 30, 2018
TL* THE CONTACT OWNS A 2002 FORD ESCAPE. WHILE DRIVING 10 MPH, THE STEERING WHEEL SHOOK WITHOUT WARNING. THE VEHICLE WAS TOWED TO A LOCAL DEALER (BLACKWELL FORD, 41001 PLYMOUTH RD, PLYMOUTH, MI) WHERE IT WAS DIAGNOSED THAT THE CROSS FRAME, LOWER CONTROL ARM, AND EXHAUST NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 185,000.
Service brakes, Hydraulic, Vehicle speed control, Engine, Jan 17, 2018, fire
TL* THE CONTACT OWNED A 2002 FORD ESCAPE. AFTER EXITING THE VEHICLE, THERE WAS A FIRE THAT ERUPTED UNDER THE HOOD. THE FIRE WAS EXTINGUISHED BY A FIRE COMPANY. THE VEHICLE WAS DESTROYED AND TOWED. THE INSURANCE COMPANY WAS TO INVESTIGATE THE FAILURE. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBERS: 12V353000 (ENGINE AND ENGINE COOLING, VEHICLE SPEED CONTROL) AND 12V005000 (SERVICE BRAKES, HYDRAULIC). THE VEHICLE WAS NOT INSPECTED BY A DEALER. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE. PARTS DISTRIBUTION DISCONNECT. *TT *TR
Exterior lighting, Fuel/propulsion system, Oct 10, 2017
TL* THE CONTACT OWNS A 2002 FORD ESCAPE. WHILE DRIVING, AN ODOR OF FUEL EMITTED INTO THE VEHICLE AND IT STALLED WITHOUT WARNING, THE CONTACT ALSO STATED THAT THE HAZARD LIGHTS FAILED TO FUNCTION. THE VEHICLE WAS TAKEN TO WAYNE EKERS FORD (2000 10TH AVE N, LAKE WORTH, FL 33461, PHONE NUMBER: (800) 749-8875) AND WAS INFORMED THAT THE VEHICLE COULD NOT BE SERVICED BECAUSE THE FUEL LEAK WAS A SAFETY CONCERN FOR THE WORKERS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 108,325.
Suspension, Structure, Sep 20, 2017
TL* THE CONTACT OWNS A 2002 FORD ESCAPE. WHILE ATTEMPTING TO ACCELERATE FROM A TRAFFIC LIGHT, THE STEERING FAILED WITHOUT WARNING. THE CONTACT STATED THAT THE STEERING WHEEL WENT IN ONE DIRECTION AND THE WHEELS WENT IN A DIFFERENT DIRECTION. THE VEHICLE WAS TOWED TO REINEKE FORD LINCOLN OF LIMA (1360 GREELY CHAPEL RD, LIMA, OH 45804, (419)223-3673) TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE PASSENGER SIDE LOWER CONTROL ARM SUPPORT WAS SEVERELY RUSTED, WHICH CAUSED THE LOWER CONTROL ARM TO FRACTURE AND SEPARATE FROM THE VEHICLE. THE CONTACT WAS INFORMED THAT THE SUB FRAME, CROSS MEMBER, CONTROL ARM, AND STEERING ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V165000 (STRUCTURE). THE MANUFACTURER WAS CONTACTED AND NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.
Other or unspecified, Engine, Sep 14, 2017
WHEN I RUN MY AC OR HEATER EXHAUST COMES IN CANT USE EITHER NOT SURE WHATS GOING ON WITH CAR BUT I DO KNOW THAT MY CAR HAS BEEN RECALLED PRIOR TO ME OWNING THE VEHICLE IN 2015 OF AUGUST AND DO KNOW THAT IT HAS NOT BEEN FIXED. CURRENTLY MY CAR HAS 10 RECALLS AND CANT GET MY CAR FIXED BY FORD
Steering, Suspension, Air bags, Sep 14, 2017
AIRBAG LIGHT STAYS ON AND ALSO I HAVE A ISSUE WITH THE STEERING WHEEL AND SUSPENSION THERE ARE OTHER ISSUES WITH THE CAR AND NEVER WAS FIXED BY PREVIOUS OWNER NOW IM STUCK WITH A CAR THAT HAS PAST RECALLED ISSUES. IF YOU OWN A CAR AND JUST PURCHASED IT BY PREVIOUS OWNER MAKE SURE THAT RECALLS HAVE BEEN FIXED ON VEHICLE. NOW I DONT KNOW WHAT TO DO WITH MY VEHICLE.
Air bags, Sep 2, 2017
THE AIRBAG LIGHT CAME ON ON THE DASHBOARD. IT CONTINUES TO STAY ON AND BEEPS FIVE TIMES REPEATING FIVE TIMES. THIS OCCURS DURING START UP OF THE VEHICLE, AND IT ALSO OCCURS ABOUT 30 MINUTES AFTER CONTINUOUS DRIVING.