2000 Ford Explorer
Problems, recalls and owner-reported issues
Tires is the leading concern among 1,078 owner complaints filed for this model year. This is the 11th highest complaint count among 26 Explorer model years with reports.
Of the 2000 reports, 112 involved a crash and 83 involved a fire. 118 people were injured and 4 people died.
What owners report most often
Recalls and investigations
Vehicle speed controlOct 13, 2009
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Campaign 09V399000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Vehicle speed controlAug 3, 2007
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
THIS COULD RESULT IN AN UNDERHOOD FIRE.
DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Campaign 07V336000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Seats, front assembly, reclinerAug 5, 2003
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH HIGH BACK SEATS, THE UPPER BOLT ON THE DRIVER'S SIDE HIGH BACK SEAT, THAT ATTACHES THE SEAT RECLINER MECHANISM TO THE SEAT BACK FRAME, COULD FRACTURE. IF THE BOLT FRACTURES AND DOES NOT JAM IN THE SEAT BACK FRAME, THE SEAT BACK MAY RECLINE UNTIL IT MAKES CONTACT WITH AN OBJECT BEHIND THE SEAT, SUCH AS THE SECOND ROW SEAT CUSHION.
THE DRIVER COULD POTENTIALLY LOSE CONTACT WITH THE STEERING WHEEL OR FOOT PEDALS DURING SUCH AN EVENT, INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE DRIVER SEAT UPPER BOLT WITH A METAL SPACER AND BOLT. IN ADDITION, SEATS WITH TUBULAR BACK FRAMES WILL HAVE THE FULLY THREADED LOWER RECLINER BOLT REPLACED WITH A PARTIALLY THREADED BOLT. OWNER NOTIFICATION BEGAN ON AUGUST 29, 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 03V281000 on NHTSA.gov
Vehicle speed control, cablesAug 5, 2003
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL AND 4.0L SOHC ENGINES, IF THE STRAND COVER ON THE SPEED CONTROL CABLE BECOMES FLARED AT THE END, THE SPEED CONTROL CABLE MAY BIND WHEN THE SPEED CONTROL IS ACTIVATED.
THE THROTTLE RETURN SPRING FORCE MAY NOT BE SUFFICIENT TO OVERCOME THE BINDING CONDITION WHEN THE SPEED CONTROL IS DISENGAGED. BRAKING FUNCTION WOULD BE MAINTAINED THOUGH STOPPING DISTANCES MAY BE INCREASED.
DEALERS WILL INSPECT THE SPEED CONTROL CABLE AND, IF NECESSARY, REPLACE IT. OWNER NOTIFICATION BEGAN AUGUST 29, 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 03V280000 on NHTSA.gov
StructureMar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
Campaign 03V094000 on NHTSA.gov
Tires, tread/beltMay 22, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. EQUIPMENT DESCRIPTION: FORD IS REPLACING ALL FIRESTONE WILDERNESS AT 15, 16, AND 17 INCH TIRES MOUNTED ON FORD TRUCKS AND SUVS. FORD REPORTS TREAD SEPARATION CAN OCCUR DUE TO A COMBINATION OF THE SENSITIVITY OF THE TIRE DESIGN TO STRESS, AGING, AND MANUFACTURING DIFFERENCES BETWEEN PLANTS. FORD IS REPLACING THESE TIRES TO PREVENT POSSIBLE PREMATURE TIRE FAILURE. VEHICLE DESCRIPTION: THE VEHICLES LISTED BELOW MAY HAVE BEEN ORIGINALLY EQUIPPED WITH FIRESTONE WILDERNESS AT TIRES OR MAY HAVE HAD WILDERNESS AT TIRES INSTALLED DURING THE FIRESTONE RECALL LAUNCHED IN AUGUST 2000. CERTAIN 1991 THROUGHT 2002 FORD EXPLORER CERTAIN 2001 THROUGHT 2002 EXPLORER SPORT, AND SPORT TRAC CERTAIN 1997 THROUGH 2002 MERCURY MOUNTAINEER CERTAIN 1991 THROUGH 2001 RANGER CERTAIN 1999 THROUGH 2001 EXPEDITION CERTAIN 1991 THROUGH 1994, AND 1997 MODEL YEAR F-SERIES CERTAIN 1991 THROUGH 1994 BRONCO NOTE: BOTH ORIGINAL EQUIPMENT AND REPLACEMENT TIRES ARE AFFECTED.
SHOULD THE TREAD SEPARATE AT HIGHWAY SPEEDS, A VEHICLE CRASH COULD OCCUR, POSSIBLY RESULTING IN PERSONAL INJURY OR DEATH.
THE REPLACEMENT/REIMBURSEMENT PROGRAM FOR THIS CAMPAIGN EXPIRED ON MARCH 31, 2002. HOWEVER, CUSTOMERS CAN CONTACT FORD AT 1-877-917-3673 OR GO ON-LINE TO WWW.FORD.COM FOR POSSIBLE ASSISTANCE.
Campaign 01X001000 on NHTSA.gov
Power train, automatic transmission, control module (tcm/pcm/tecm)Nov 28, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES EQUIPPED WITH THE 3.27 OR 3.55 AXLE RATION. THE SUBJECT VEHICLES HAVE A POWERTRAIN CONTROL MODULE THAT COULD ALLOW THE VEHICLE TO EXCEED THE DESIGN INTENT TOP SPEED. AT THESE EXTREME SPEEDS, THE VEHICLE COULD BE CAPABLE OF EXCEEDING THE SPEED RATING OF THE TIRE.
OPERATING THE VEHICLE ABOVE THE MAXIMUM SPEED RATING COULD LEAD TO A TIRE FAILURE WHICH AT THESE SPEEDS COULD RESULT IN A CRASH.
DEALERS WILL REPROGRAM THE POWERTRAIN CONTROL MODULE.
Campaign 00V395000 on NHTSA.gov
Tires, tread/beltAug 21, 2000
TIRE DESCRIPTION: FIRESTONE WILDERNESS AT, SIZE P235/75R15, PRODUCED AT THE DECATUR, ILLINOIS TIRE PLANT AND ALL FIRESTONE RADIAL ATX AND RADIAL ATX II TIRES, SIZE P235/75R15. OPERATION OF THESE TIRES AT LOW INFLATION PRESSURES, HIGH SPEED, AND IN HOT WEATHER, CAN CONTRIBUTE TO SEPARATION OF THE TIRE TREAD.
IF THE TREAD SEPARATES FROM THE TIRE, THE DRIVER CAN LOSE CONTROL OF THE VEHICLE, POSSIBLY RESULTING IN A CRASH CAUSING INJURY OR DEATH.
THE REPLACEMENT/REIMBURSEMENT PROGRAM FOR THIS CAMPAIGN EXPIRED ON AUGUST 29, 2001. HOWEVER, CUSTOMERS SHOULD CONTACT FIRESTONE CUSTOMER SERVICE AT 1-800-465-1904 FOR POSSIBLE ASSISTANCE.
Campaign 00T005000 on NHTSA.gov
Seat beltsAug 18, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
DEALERS WILL INSPECT THE DATE CODE ON CERTAIN SEAT BELT BUCKLES OF YOUR VEHICLE AND REPLACE ALL SEAT BELT BUCKLES THAT FALL WITHIN THE SUSPECT DATE CODE RANGE. OWNER NOTIFICATION BEGAN OCTOBER 26, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V228001 on NHTSA.gov
Air bags, side/windowJul 5, 2000
VEHICLE DESCRIPTION: 4-DOOR SPORT UTILITY VEHICLES EQUIPPED WITH SIDE AIR BAGS. THE SUBJECT VEHICLES HAVE A REVISED LEVEL SIDE CRASH SENSOR THAT COULD DEPLOY THE SIDE AIR BAG IF THE IGNITION KEY IS IN THE "RUN" POSITION AND THE SEATBELT WEBBING IS FORCIBLY EXTRACTED FROM A LOCKED RETRACTOR WITH A JERKING MOTION.
INADVERTENT SIDE AIR BAG DEPLOYMENT COULD CAUSE PERSONAL INJURY TO THE SEAT OCCUPANT.
DEALERS WILL REPLACE THE SIDE CRASH SENSORS WITH A REVISED DESIGN THAT WILL REDUCE THE LIKELIHOOD OF AN UNEXPECTED SIDE AIR BAG DEPLOYMENT.
Campaign 00V179000 on NHTSA.gov
Electrical system, wiring, fuses and circuit breakersMar 7, 2000
VEHICLE DESCRIPTION: MULTI-PURPOSE VEHICLES EQUIPPED WITH 4.0L ENGINES AND ALL-TIME 4-WHEEL DRIVE (A4WD) POWERTRAINS. THE GENERIC ELECTRONIC MODULE (GEM) COULD EXPERIENCE A CONDITION REFERRED TO AS "LOCK-UP" IN WHICH THE GEM CONTROLLED ELECTRONIC FUNCTIONS (E.G., FRONT WINDSHIELD WIPERS, INTERIOR LIGHTS, 4X4 SYSTEM, ETC.) COULD NOT BE TURNED ON OR, IN SOME CASES IF THE FUNCTION IS ON, COULD NOT BE TURNED OFF.
AN INOPERATIVE WINDSHIELD WIPER SYSTEM COULD AFFECT DRIVER VISIBILITY, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSTALL A RESISTOR IN THE GEM CIRCUIT.
Campaign 00V072000 on NHTSA.gov
Representative owner complaints
1,078 reports, newest first.
Structure, Mar 26, 2002
VIBRATION FROM CENTER OF THE OF THE EXPLORER, THE PROBLEM GETS WORSE EVERY DAY . MY CONSERN IS THAT I DRIVE A LOT AND NIGHT VISION AFTER WATCHING THE REAR VIEW, SIDE VIEW MIRRORS AFTER A WHILE CREATES A VISUAL ADJUSTMENT PERIOD WHEN LOOKING BACK AT THE ROAD AT NIGHT IT IS A VERY BIG PROBLEM, THE DEALER TO DATE HAS NOT TAKEN IT OUT AT NIGHT AND AT THIS POINT THE FACTORY REP SAID IT WAS NORMAL. I HAVE DRIVEN THREE OTHER EXPLORERS AND ONE OF THEM ARE HAVING THE SAME PROBLEM, BUT THEY DO NO DRIVE HIGHWAY , SO THEY ARE JUST LIVING WITH IT. THE DEALER SAID THAT THE SHORT FRAME VEHICLES ARE NOTED FOR THIS PROBLEM. THE FACTORY REP SAID IT IT JUST THE WAY IT IS. NLM
Power train, Mar 22, 2002
AT SPEEDS OVER 60 MPH VEHICLE INTERMITTENTLY BUCKS FOR A FEW SECONDS, FEELS LIKE IT'S NOT SHIFTING RIGHT. ALSO DIFFICULT TO STEER AT THAT TIME.*AK
Visibility, Mar 20, 2002
I PROCEEDED INTO A NO-TOUCH CAR WASH ON 16 MAR 02, TEMP. WAS APPROX. 36 DEGRESS ABOVE ZERO, WHEN THE FIRST COAT OF SOAP HIT THE REAR WINDOW, THE WHOLE WINDOW IMPLODED INSIDE OF MY EXPLORER. THE CAR WASH DID NOT HIT THE VEHICLE JUST THE SOAP . *AK ERO
Engine and engine cooling, Fuel system, Other, Visibility, Equipment, Mar 12, 2002
THIS EXLORER/EDDIE BAUER WAS LEASED BRAND NEW. I HAVE HAD NOTHING BUT PROBLEMS BEGINNING WITH THE FIRST WEEK OF HAVING IT (IE. STALLING, SHUTTING OFF, ENGINE FAILURE, EXCESSIVE WIND NOISE, WINDOW/RADIO REPLACEMENT, INACCURATE FUEL READINGS ETC..). I HAVE BEEN BOUNCED BACK AND FORTH BETWEEN THE SERVICE AND SALES DEPT. OF THE DEALSHIP. THEIR FAVORITE ANSWER TO A PROBLEM IS, "WE ARE UNABLE TO DUPLICATE CONSUMER CONCERN." HELLO!!!!, THIS IS WHY YOU GET PAID THE BIG BUCKS! I AM NOT AN ENGINEER OR SAVY WITH VEHICLE TERMINOLOGY. HOWEVER, I THINK I'M SMART ENOUGH TO KNOW THERE IS A MAJOR PROBLEM HERE. I AM A SINGLE PARENT WHO IS CONCERNED FOR MYSELF AND CHILD'S SAFETY. THIS HAS BEEN A NIGHTMARE FOR ME AND I AM REACHING OUT TO WHOMEVER WILL LISTEN TO MY CONCERNS. *AK
Engine and engine cooling, Mar 8, 2002
ENGINE IS MAKING A LOUD KNOCKING NOISE. DEALER HAS TRIED TWICE TO DIAGNOSE PROBLEM. DEALER WAS CONTACTED. *AL *YD
Structure, Mar 4, 2002
VEHICLE SWAYS TO LEFT AND RIGHT WHILE TRAVELING ON HIGHWAY. VEHICLE WAS TOP HEAVY. THE DEALERSHIP IS AWARE OF THE PROBLEM.
Suspension, Mar 4, 2002
WHILE TRAVELING ON HIGHWAY VEHICLE WILL SWAY TO LEFT AND RIGHT OF HIGHWAY. DEALERSHIP IS AWARE OF PROBLEM. *AK
Seats, Feb 27, 2002, crash
VEHICLE WAS INVOLVED IN A 5 MPH REAR END COLLISION, HITTING A TREE. DRIVER AND PASSENGER SEATS COLLAPSED BACKWARDS. *AKJG
Air bags, Feb 26, 2002, crash
VEHICLE WAS INVOLVED IN A FRONTAL COLLISION AT 40-45 MPH WITH A TREE, AND NEITHER AIR BAG DEPLOYED. *AK CONSUMER ADDS THAT THE AIRBAG SENSOR BRACKET WHICH IS 4 INCHES LONG FOLDED AROUND, THUS NOT DEPLOYING THE AIR BAGS, HAD THE SENSORS BEEN PLACED ON THE FRAME ON A SHORTER BRACKET THEY WOULD HAVE DEPLOYED, ONE PERSON WAS INJURED IN ACCIDENT. *TT
Air bags, Feb 20, 2002, crash
WHILE TRAVELING 50 MPH, CONSUMER WAS INVOLVED IN A HEAD-ON COLLISION, HITTING A TREE WITH FRONTAL DAMAGE, THE AIR BAGS DID NOT DEPLOY AT ANY TIME.*AK. CONSUMER WAS INFORMED BY MANUFACTURER THAT THEY WERE NOT LIABLE FOR AIR BAGS IN AN ANCCIDENT.*JB
Power train, Feb 14, 2002
WHEN TRIED TO PUT VEHICLE INTO REVERSE, MADE LOUD NOISE, AS STEPPING ON GAS, CAR WOULD NOT MOVE. HOWEVER VECHILE WILL GO INTO DRIVE. *AK
Exterior lighting, Feb 12, 2002, fire
DEALER HAD TO REPLACE MULTI-FUNCTION SWITCH FOR SECOND TIME BECAUSE OF SMOKE COMING FROM STEERING COLUMN. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK
Vehicle speed control, Feb 8, 2002
CONSUMER WAS DRIVING WITH CRUISE CONTROL ON AT 60 MPH AND VEHICLE STARTED TO ACCELERATE WITHOUT COMMAND FROM 60 TO 85 MPH. CONSUMER APPLIED BRAKES,AND VEHICLE WOULD NOT SLOW DOWN. APPLIED ON OFF BUTTON, BUT IT WOULD NOT WORK, HIT EMERGENCY BRAKE, AND VEHICLE SLOWED DOWN. *AK
Power train, Feb 8, 2002
TRANSMISSION SLIPS WHEN SHIFTING TO OVERDRIVE AT 50-55MPH. *AK
Tires, Feb 6, 2002
AFTER PURCHASE OF FIRESTONE 235/75R15 WILDERNESS AT TIRES (DOT # 8XHL), CONSUMER FOUND TREAD CAPS HAD A SAW TOOTH SHAPE MEASURING ABOUT 3/4 INCH CROSSWISE AND A DEEP CRACK IN THE TREAD CAP, CONSUMER REPLACED TIRES AFTER RECALL NOTICE AND WAS REIMBURSED. *TT
Other or unspecified, Jan 30, 2002
ENGINE CHECK LIGHT COMES ON FREQUENTLY. FORD SAYS IS NORMAL AND OVER 100 THINGS COULD CAUSE IT. SERVICE PEOPLE SAY LOOSE GAS CAP OR FILL WHILE RUNNING COULD CAUSE. CHARGED $86 TO RUN TEST TO DETERMINE NOTHING IS WRONG.GAS CAP MIGHT HAVE BEEN LEFT LOOSE AFTER FILL...FORD HAS A SIGNIFICANT, FREQUENT PROBLEM WITH ENGINE LIGHT AND SHOULD BE RESPONSIBLE TO TAKE CARE OF THESE NUISANCE INSTANCES WITHOUT CHARGE TO CUSTOMERS...ESPECIALLY WHILE UNDER WARRANTY. *AK
Equipment, Jan 23, 2002
CONSUMER HAS HAD A LENGTHY HISTORY OF SERVICE WORK PERFORMED ON THIS VEHICLE SINCE DAY OF PURCHASE, PROBLEMS ARE CENTERED AROUND THE STEREO UNIT. THE UNIT WOULD MAKE CD'S AND TAPES SO HOT THAT THEY BURN WHEN TOUCHING THEM TO REMOVE FROM STEREO SYSTEM. (ATTORNEY ON BEHLAF OF CLIENT. *JG
Suspension, Power train, Jan 18, 2002
WHILE DRIVING AND MAKING A LEFT HAND TURN VEHICLE HESITATES AND VIBRATES IN FRONT END. DRIVER STATES IT FEELS LIKE GEARS ARE NOT ENGAGING PROPERLY. PLEASE PROVIDE ANY FURTHER INFORMATION. *AK
Air bags, Jan 17, 2002
WHEN STARTING UP VEHICLE AIRBAG LIGHT WOULD COME ON, LIGHT STAYS ON ALL THE TIME WHILE DRIVING. HAD LIGHT FIXED SIX TIMES AND PROBLEM STILL EXISTS. *AK *SLC
Electrical system, Jan 16, 2002
ELECTRICAL SYSTEM IS CAUSING INTERMITTENT OPERATION OF INTERIOR LIGHTS/ INSTRUMENT PANEL FUNCTIONS, AND WINDSHIELD WIPERS. DEALERSHIP EXAMINED VEHICLE, BUT COULD NOT DETERMINE CAUSE OF PROBLEM. VEHICLE WAS NOT AFFECTED BY RECALL CAMPAIGN 00V072000/ ELECTRONIC FUNCTIONS. PLEASE PROVIDE ANY ADDITIONAL INFORMATION / DOCUMENTATION.*AK
Steering, Engine and engine cooling, Exterior lighting, Air bags, Jan 9, 2002
WHEN STARTING UP VEHICLE AIR BAG LIGHT REMAINS ON UNTIL VEHICLE IS TURNED OFF. HAVE BEEN TO DEALER FOR REPAIRS SEVERAL TIMES.*AK CONSUMER ALSO STATRED THE TURN SIGNALS AND HAZARD LIGHTS WERE INOPERATIVE, DEALER REPLACED THE MULTI-FUNCTION SWITCH, ALSO THERE WAS AN UNUSUAL NOISE COMING FROM THE ENGINE COMPARTMENT,AND THERE WAS ALSO SMOKE COMING FROM THE UPPER STEEING COLUMN.*SLC
Engine and engine cooling, Power train, Jan 2, 2002
THERE WAS A VERY LOUD NOISE COMING FROM ENGINE. TOOK VEHICLE TO DEALER, AND THEY REPLACED THE ENGINE LIFTERS. 5 DAYS LATER, PROBLEM REOCCURRED. VEHICLE HAS HAD 4 ENGINES IN LAST TWO YEARS. *AK ON SEVERAL OCCASIONS, THE CHECK ENGINE SOON LIGHT CAME ON. DEALER REPLACED CAM SENSOR AND GAS CAP. HOWEVER LIGHT CAME ON AGAIN. OCCASIONALLY THERE IS A ROUGH IDLE AND VEHICLE FEELS AS IF IT IS ABOUT TO STALL. DEALER REPLACED CYLINER HEAD GASKET. TRANSMISSION SLIPPING. DEALER FOUND 2 3 SHIFT VALVES STICKING. *TT
Air bags, Dec 31, 2001, crash
WHILE TRAVELING APPROXIMATELY 40 TO 50 MPH A VEHICLE IN FRONT OF HIM CAME TO AN ABRUPT STOP. AS A RESULT, CONSUMER'S VEHICLE REAR ENDED THE STOPPED VEHICLE AND BOTH FRONTAL AIR BAGS FAILED TO DEPLOY. DRIVER RECEIVED HEAD, NECK, AND BACK INJURIES. VEHICLE HAS NOT BEEN EXAMINED BY DEALERSHIP OR INSURANCE COMPANY TO DETERMINE REASON FOR THE AIR BAG FAILURE. *AK ANOTHER AUTO SPECIALIST EXAMINED THE VEHICLE AND DETERMINED THAT THE FAILURE OF THE AIR BAGS TO DEPLOY WAS DUE TO THE COMPUTER FAILURE. *YH
Vehicle speed control, Dec 21, 2001
WHILE TRAVELING RPMS WENT WAY UP TO NUMBER SIX. APPLIED BRAKES AND VEHICLE WAS STILL GOING. SHE COULD STOP ITBY TURNING VEHICLE OFF. DEALERSHIP WAS AWARE OF PROBLEM.*AK
Suspension, Dec 14, 2001
VEHICLE WAS MAKING A SQUEALING NOISE. WHEN TURNING VEHICLE NOISE WOULD GET LOUDER. CONTACTED DEALER,AND DEALER STATED IT WAS UPPER CONTROL ARM. CONTACTED FORD, AND FORD DECIDED TO LEAVE IT AS AN OPEN CASE.*AK THE BALL JOINT AND UPPER CONTROL ARM ON THE DRIVER SIDE IS WHAT FAILED. *JB