2001 Ford Explorer
Problems, recalls and owner-reported issues
Power train is the leading concern among 730 owner complaints filed for this model year. This is the 14th highest complaint count among 26 Explorer model years with reports.
Of the 2001 reports, 97 involved a crash and 41 involved a fire. 96 people were injured and 10 people died.
What owners report most often
Recalls and investigations
Vehicle speed controlOct 13, 2009
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Campaign 09V399000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Vehicle speed controlAug 3, 2007
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
THIS COULD RESULT IN AN UNDERHOOD FIRE.
DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Campaign 07V336000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Seats, front assembly, reclinerAug 5, 2003
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH HIGH BACK SEATS, THE UPPER BOLT ON THE DRIVER'S SIDE HIGH BACK SEAT, THAT ATTACHES THE SEAT RECLINER MECHANISM TO THE SEAT BACK FRAME, COULD FRACTURE. IF THE BOLT FRACTURES AND DOES NOT JAM IN THE SEAT BACK FRAME, THE SEAT BACK MAY RECLINE UNTIL IT MAKES CONTACT WITH AN OBJECT BEHIND THE SEAT, SUCH AS THE SECOND ROW SEAT CUSHION.
THE DRIVER COULD POTENTIALLY LOSE CONTACT WITH THE STEERING WHEEL OR FOOT PEDALS DURING SUCH AN EVENT, INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE DRIVER SEAT UPPER BOLT WITH A METAL SPACER AND BOLT. IN ADDITION, SEATS WITH TUBULAR BACK FRAMES WILL HAVE THE FULLY THREADED LOWER RECLINER BOLT REPLACED WITH A PARTIALLY THREADED BOLT. OWNER NOTIFICATION BEGAN ON AUGUST 29, 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 03V281000 on NHTSA.gov
Vehicle speed control, cablesAug 5, 2003
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL AND 4.0L SOHC ENGINES, IF THE STRAND COVER ON THE SPEED CONTROL CABLE BECOMES FLARED AT THE END, THE SPEED CONTROL CABLE MAY BIND WHEN THE SPEED CONTROL IS ACTIVATED.
THE THROTTLE RETURN SPRING FORCE MAY NOT BE SUFFICIENT TO OVERCOME THE BINDING CONDITION WHEN THE SPEED CONTROL IS DISENGAGED. BRAKING FUNCTION WOULD BE MAINTAINED THOUGH STOPPING DISTANCES MAY BE INCREASED.
DEALERS WILL INSPECT THE SPEED CONTROL CABLE AND, IF NECESSARY, REPLACE IT. OWNER NOTIFICATION BEGAN AUGUST 29, 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 03V280000 on NHTSA.gov
StructureMar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
Campaign 03V094000 on NHTSA.gov
Tires, tread/beltMay 22, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. EQUIPMENT DESCRIPTION: FORD IS REPLACING ALL FIRESTONE WILDERNESS AT 15, 16, AND 17 INCH TIRES MOUNTED ON FORD TRUCKS AND SUVS. FORD REPORTS TREAD SEPARATION CAN OCCUR DUE TO A COMBINATION OF THE SENSITIVITY OF THE TIRE DESIGN TO STRESS, AGING, AND MANUFACTURING DIFFERENCES BETWEEN PLANTS. FORD IS REPLACING THESE TIRES TO PREVENT POSSIBLE PREMATURE TIRE FAILURE. VEHICLE DESCRIPTION: THE VEHICLES LISTED BELOW MAY HAVE BEEN ORIGINALLY EQUIPPED WITH FIRESTONE WILDERNESS AT TIRES OR MAY HAVE HAD WILDERNESS AT TIRES INSTALLED DURING THE FIRESTONE RECALL LAUNCHED IN AUGUST 2000. CERTAIN 1991 THROUGHT 2002 FORD EXPLORER CERTAIN 2001 THROUGHT 2002 EXPLORER SPORT, AND SPORT TRAC CERTAIN 1997 THROUGH 2002 MERCURY MOUNTAINEER CERTAIN 1991 THROUGH 2001 RANGER CERTAIN 1999 THROUGH 2001 EXPEDITION CERTAIN 1991 THROUGH 1994, AND 1997 MODEL YEAR F-SERIES CERTAIN 1991 THROUGH 1994 BRONCO NOTE: BOTH ORIGINAL EQUIPMENT AND REPLACEMENT TIRES ARE AFFECTED.
SHOULD THE TREAD SEPARATE AT HIGHWAY SPEEDS, A VEHICLE CRASH COULD OCCUR, POSSIBLY RESULTING IN PERSONAL INJURY OR DEATH.
THE REPLACEMENT/REIMBURSEMENT PROGRAM FOR THIS CAMPAIGN EXPIRED ON MARCH 31, 2002. HOWEVER, CUSTOMERS CAN CONTACT FORD AT 1-877-917-3673 OR GO ON-LINE TO WWW.FORD.COM FOR POSSIBLE ASSISTANCE.
Campaign 01X001000 on NHTSA.gov
Equipment, other, labelsOct 17, 2000
VEHICLE DESCRIPTION: CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF PART 567.4, "CERTIFICATION." THESE VEHICLES WERE SHIPPED FROM THE ASSEMBLY PLANT WITHOUT SAFETY CERTIFICATION LABELS.
INCORRECT TIRE INFLATION PRESSURE COULD RESULT IN TIRE TREAD SEPARATION, INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE CERTIFICATION LABELS.
Campaign 00V313000 on NHTSA.gov
Representative owner complaints
730 reports, newest first.
Power train, Apr 8, 2010
FORD EXPLORER O/D LIGHT FLASHING, TRANSMISSION SLIPPING. *TR
Engine and engine cooling, Apr 5, 2010, crash
TL*THE CONTACT OWNS A 2001 FORD EXPLORER. WHILE DRIVING AT SPEED AT 15 MPH, THE VEHICLE LOST ELECTRICAL POWER AND THE ENGINE STALLED. THE STEERING BECAME VERY DIFFICULT TO MANEUVER AND THE CONTACT WAS UNABLE TO MAINTAIN CONTROL OF THE VEHICLE. THE VEHICLE ROLLED OVER AS A RESULT OF THE FAILURE. THE POLICE ARRIVED ON THE SCENE AND THE DRIVER SUSTAINED MINOR INJURIES. THE VEHICLE WAS TAKEN TO A LOCAL BODY SHOP TO BE SERVICED. THE FAILURE RECURRED INTERMITTENTLY AND WAS THEN TAKEN TO AN AUTHORIZED DEALER FOR SERVICE. THE FAILURE CONTINUED TO RECUR INTERMITTENTLY. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 1,500 AND THE CURRENT MILEAGE WAS 40,000. UPDATED 05/21/10.*LJ THE CONSUMER STATED THE FAILURE WOULD HAPPEN WHEN FIRST STARTING TO DRIVE. UPDATED 10/14/10*JB
Engine and engine cooling, Electrical system, Apr 4, 2010, fire
VEHICLE CAUGHT FIRE. VEHICLE WAS NOT RUNNING AT THE TIME. VEHICLE DESTROYED BY FIRE. *TR
Air bags, Mar 29, 2010
AIR BAG LIGHT KEEPS FLASHING OFF AND ON. DON'T KNOW IF AIR BAGS WILL DEPLOY OR NOT IN CASE OF AN ACCIDENT. FORD HAS A SAFEY MEMO OUT ON THIS PROBLEM, BUT WON'T RECALL BECAUSE THEY SAY IT ISN'T A SAFETY ISSUE. HOW CAN THIS NOT BE A SAFETY ISSUE IF YOU DON'T KNOW IF THE AIR BAGS WILL DEPLOY. *CN
Structure, Mar 22, 2010
BODY MOUNT BUSHINGS ARE DETERIORATING PREMATURELY. *DT
Power train, Mar 9, 2010
'O/D OFF' LIGHT IF BLINKING, ON AND OFF. WHILE LIGHT IS BLINKING THE CAR SEEMS TO BE SLUGGISH AND DOES NOT RESPOND TO THROTTLE PROPERLY. ROUGH SHIFTS WHILE DRIVING. *TR
Engine and engine cooling, Mar 8, 2010
AS WITH SO MANY EXPLORERS I HAVE READ ABOUT, MY O/D LIGHT COMES ON AND FLASHES. I LOSE ALL POWER DURING INITIAL ACCELERATION AND THEN THE TRUCK SHOOTS OFF LIKE A ROCKET. IF I TURN THE IGNITION OFF, THE LIGHT RESETS AND THE VEHICLE IS OK FOR A WHILE UNTIL THE LIGHT COMES ON AGAIN. I HAD THE CODES READ AND IT CAME UP A SOLENOID PROBLEM. I HAD THEM REPLACED AND TEN MILES FROM THE LOT, THE LIGHT CAME ON AGAIN. I HAVE READ THAT THIS IS A KNOWN ISSUE FROM FORD, BUT THEY HAVE YET TO ACT ON THIS ISSUE. *TR
Service brakes, Hydraulic, Equipment, Mar 3, 2010
I HAVE A 2001 FORD EXPLORER SPORT. AFTER DRIVING FOR ANY PERIOD OF TIME,(ESPECIALLY AT HIGHWAY SPEEDS) WHEN YOU APPLY THE BRAKES THEY SHUDDER VIOLENTLY. AS YOU TRY TO COME TO A STOP AT ANY TIME THE BRAKES GO IN ANTI- LOCK MODE AND THEN GIVE OUT!! YOU HAVE TO PUMP THE BRAKES TO GET THEM TO HOLD. IT IS VERY SCARY AND DANGEROUS SITUATION. I HAD THE BRAKES REPAIRED AT MY FORD DEALER (FETTE FORD, CLIFTON NJ) NOT THAT MANY MILES AGO. AND THEY TELL YOU THEY HAVE NEVER HEARD OF THIS PROBLEM BEFORE AND IT'S MY BAD DRIVING HABITS CAUSING THE PROBLEM. THERE IS A WEBSITE (FORDBRAKES.COM) WHERE HUNDREDS OF DRIVERS DESCRIBE THE SAME PROBLEMS AND SIMILAR LIES TOLD TO THEM BY FORD SERVICE DEPTS. WHEN THIS STORY FINALLY GETS OUT AND WE START REALIZING HOW MANY ACCIDENTS, INJURIES, AND MAYBE DEATHS HAVE OCCURRED OVER THE PAST DOZEN YEARS. IT WILL PROBABLY RIVAL THE TOYOTA COVER-UP. PLEASE TAKE ACTION AND INVESTIGATE NOW!!! *TR
Suspension, Structure, Feb 26, 2010
THE EMAILS BELOW CHRONICLE MY ATTEMPT TO HAVE THE FORD MOTOR COMPANY ADDRESS WHAT I FEEL TO BE A SAFETY ISSUE. PLEASE NOTE THAT THE COMPONENTS THAT ARE THE SUBJECT TO THE INQUIRY ARE PART OF THE STEERING. ANY FAILURE OF THESE COMPONENTS MAY RESULT IN LOSS OF CONTROL OF THE VEHICLE. THE RUBBER BODY MOUNT, STRUT AND CONTROL ARM BUSHINGS ON MY 2001 SPORT TRAC 4WD ARE CRUMBLING. PLEASE ADVISE WHAT CORRECTIVE ACTION THE FORD MOTOR COMPANY IS TAKING TO ADDRESS THIS PROBLEM. [XXX] THANK YOU FOR CONTACTING THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER REGARDING THE CONCERNS YOU HAVE WITH YOUR 2001 FORD EXPLORER SPORT TRAC. WE HAVE REVIEWED THE SITUATION, AND UNFORTUNATELY, THERE ARE NO WARRANTIES, FIELD SERVICE ACTIONS/CUSTOMER SATISFACTION PROGRAMS ON YOUR VEHICLE THAT WOULD PROVIDE ASSISTANCE FOR THIS REPAIR. HOWEVER, WE DO SUGGEST THAT THE REPAIR BE DONE BY A FORD/LINCOLN-MERCURY DEALERSHIP WHERE THE TECHNICIANS ARE TRAINED TO PUT YOUR VEHICLE BACK INTO FACTORY SPECIFICATIONS, AND ANY FORD PARTS REPLACED WILL COME WITH A 12 MONTHS/12,000 MILES WARRANTY. PLEASE BE ADVISED THAT A DIAGNOSTIC FEE MAY BE CHARGED. IF ADDITIONAL ASSISTANCE IS REQUIRED, WE SUGGEST THAT YOU CONTACT THE CUSTOMER RELATIONSHIP/SERVICE MANAGER. THEY WILL FURTHER ASSIST IN FACILITATING YOUR SERVICE/REPAIR NEEDS. YOUR NEXT STEPS ARE TO DISCUSS THIS REPAIR WITH THE SERVICE MANAGER AT YOUR DEALERSHIP. SHOULD YOU FEEL THAT WE HAVE NOT ADEQUATELY ADDRESSED YOUR QUESTIONS, PLEASE FEEL FREE TO CONTACT US VIA TELEPHONE AT (800)392-3673 BETWEEN THE HOURS OF 8AM AND 5PM, LOCAL TIME, MONDAY THROUGH FRIDAY. PLEASE PROVIDE YOUR 10 DIGIT REFERENCE NUMBER - [XXX] . SINCERELY, [XXX] CUSTOMER RELATIONSHIP CENTER FORD MOTOR COMPANY. *TR
Power train, Feb 26, 2010
TRANSMISSIONS IN EXPLORER SPORT TRACS 2001 ARE NOT VERY RELIABLE, I AM HAVING TO PUT A 2ND ONE IN WITH ONLY 126,000 MILES. FORD SHOULD ADDRESS THE ISSUE WITH ALL TRANSMISSIONS IN THE EXPLORER. I WILL NOT PURCHASE ANOTHER FORD, NOR WILL I TELL ANYBODY ELSE, MAYBE THEY SHOULD HAVE TAKEN A BAIL-OUT FROM THE GOVERNMENT TO FIX THERE CARS. *TR
Structure, Feb 6, 2010
2001 FORD SPORT TRAC BODY MOUNTS HAVE ALL DETERATED AND FALLEN OFF. VERY SERIOUS MATTER WHEN BODY MIGHT BREAK OFF. *CN
Seat belts, Feb 3, 2010
TL* THE CONTACT OWNS A 2001 FORD EXPLORER. SHE STATED THAT THE DRIVER SEAT BELT BUCKLE FAILED. SHE WAS NOT ABLE TO TAKE THE SEAT BELT OFF.THE CONTACT STATED SHE WILL TAKE THE VEHICLE TO THE DEALER OR A GARAGE FOR REPAIR. THE CONTACT STATED SHE WILL CONTACT THE MANUFACTURER .THE FAILURE AND THE CURRENT MILEAGE WAS 172,236.
Latches/locks/linkages, Jan 25, 2010
2001 FORD EXPLORER SPORT: DOOR SUDDENLY STOPPED UNLOCKING WITH THE KEY. I HAVE SINCE DISCOVERED HUNDREDS OF OTHER EXPLORER OWNERS WITH THE SAME STORY. I FEEL THIS IS A SAFETY ISSUE BECAUSE I TRANSPORT MY 10 MONTH OLD DAUGHTER IN THIS CAR, AND I CAN'T AFFORD TO BE LOCKED OUT WITHOUT WARNING DURING THE WINTER. *TR
Visibility, Jan 11, 2010
TL*THE CONTACT OWNS A 2001 FORD EXPLORER SPORT. THE CONTACT STATED THAT THE DRIVER SIDE WINDOW FELL INSIDE THE DOOR. THE DEALER WAS CONTACTED AND ADVISED THE CONTACT THE HE WILL BE RESPONSIBLE FOR PAYING FOR THE REPAIRS. THERE WERE NO RELATED RECALLS OR WARRANTIES. THE FAILURE MILEAGE WAS 8,000. UPDATED 02/02/10 *BF UPDATED 02/05/10.*JB
Power train, Jan 8, 2010
MY 2001 FORD EXPLORERS TRANSMISSION IS HAVING SHIFTING PROBLEMS FOLLOWED BY IT'S OVERDRIVE LIGHT FLASHING. I TALKED TO SEVERAL FORD TRANSMISSION FRIENDS AND THEY ADVISED ME TO INSTALL A UPGRADE KIT IN THE VALVE BODY. THIS WAS DONE, FLUID AND FILTER CHANGED, TO NO AVAIL. THE LIGHT INTERMITTENTLY FLASHES AND THE TRANSMISSION SHIFTING WEIRD. AFTER READING SEVERAL POSTS ON SEVERAL SITES REGARDING THIS PROBLEM, I AM AT A LOSS AT WHAT TO DO. SEVERAL PEOPLE STATED THAT THEY WENT TO THE EXTENT OF REPLACING THE TRANSMISSIONS WITH NEW ONES AND THE LIGHT STILL FLASHING AND HAVING THE SAME PROBLEMS. MY EXPLORER HAS 60K MILES ON IT AND THIS PROBLEM STARTED AT ONLY 50K MILES, TO ME THIS IS A PROBLEM FORD SHOULD ACKNOWLEDGE, AND ALLOW SOME COMPENSATION TO IT'S LOYAL CUSTOMERS. *TR
Air bags, Jan 7, 2010, crash
TL*THE CONTACT OWNS A 2001 FORD EXPLORER SPORT. WHILE DRIVING 35 MPH DURING INCLEMENT WEATHER, THE CONTACT LOST CONTROL OF THE VEHICLE AND CRASHED INTO THE DIVIDER ON THE HIGHWAY. DURING THE CRASH NONE OF THE AIR BAGS IN THE VEHICLE DEPLOYED. THE VEHICLE WAS DESTROYED. THE CONTACT WAS TAKEN TO THE HOSPITAL FOR INJURIES TO THE NECK AND BACK. THE CONTACT CALLED THE MANUFACTURER TO FILE A COMPLAINT AND THE MANUFACTURER DISCONNECTED THE CALL. THE CONTACT STATED THAT THE MANUFACTURER SHOULD TAKE RESPONSIBILITY FOR THE REPAIRS TO THIS VEHICLE. THE FAILURE MILEAGE WAS 83,000.
Wheels, Dec 28, 2009
TL* THE CONTACT OWNS A 2001 FORD EXPLORER. THE CHROME STEEL WHEELS HAVE EXTERIOR CORROSION. THIS CONDITION HAS CAUSED THE TIRES TO LOSE AIR PRESSURE. THIS FAILURE HAS OCCURRED TWICE BEFORE. SHE WAS ADVISED BY A TECHNICIAN AT THE DEALER TO PAY $257.00. TO REPLACE BOTHER REAR TIRES. THE FAILURE MILEAGE WAS 105,000.
Visibility, Dec 6, 2009
2001 FORD EXPLORER SPORT 2 DOORS BLEND DOOR BROKEN NO HEAT. *TR
Seats, Dec 4, 2009
THE DRIVER'S SEAT IS LOOSE AND TILTS TO THE RIGHT. THERE IS CLEARLY SOMETHING WRONG WITH THE WAY IT IS AFFIXED TO THE VEHICLE. THE SEAT RECLINER MECHANISM HAS A DEFECT CAUSING THIS LOOSENESS. THE DEGREE OF LOOSENESS HAS INCREASED SINCE IT BECAME CLEARLY APPARENT IN FEBRUARY OF 2009; 5 MONTHS AFTER PURCHASING THE VEHICLE. IT IS NOW EVEN MORE LOOSE AND THERE IS CLEARLY A PROBLEM THAT COULD LEAD TO HAZARDOUS CONDITIONS IF NOT FIXED BY THE DEALER. I WAS LIED TO AT THE DEALER SEVERAL TIMES, I REQUESTED CARFAX REPEATEDLY, BUT WAS NEVER PROVIDED WITH ONE. I REQUESTED A CAR MANUAL REPEATEDLY, BUT WAS NEVER GIVEN ONE. I OBTAINED A CARFAX ON MY OWN THAT SHOWS THE DEALER LIED ABOUT THE NUMBER OF PREVIOUS OWNERS, THE SERVICE OF ONE FORD RECALL, AND THE EXISTENCE OF A SECOND FORD RECALL. THAT IS THE SEAT RECLINING MECHANISM. THERE IS A SAFETY RECALL 03S04, DATED AUGUST 2003. CERTAIN 2001-2002 MODEL YEAR 2-DOOR EXPLORER/EXPLORER SPORT* VEHICLES EQUIPPED WITH HIGH BACK SEATS, BUT AT THE LOUISVILLE ASSEMBLY PLANT FROM JOB #1, 2001 THROUGH JOB LAST 2002. IN 2001, THE EXPLORER 2-DOOR WAS RENAMED EXPLORER SPORT. AFFECTED VEHICLES ARE IDENTIFIED OASIS. IN ADDITION, FOR A LIST OF VEHICLES ASSIGNED TO YOUR DEALERSHIP, VISIT THE WEBSITE. THIS INFORMATION WAS MADE AVAILABLE ON APRIL 5, 2006. SOME OF THE VEHICLES AFFECTED BY THIS PROGRAM WILL RECEIVE ONE LETTER DESCRIBING BOTH PROGRAMS. FOR CUSTOMERS CONVENIENCE, PLEASE COMPLETE BOTH PROGRAMS 03S03 AND 03S04 DURING ONE CUSTOMER VISIT. THE REASON FOR THIS SAFETY RECALL IS IN SOME OF THE AFFECTED VEHICLES, A BOLT THAT ATTACHES THE SEAT RECLINER MECHANISM TO THE DRIVER SEAT BACK FRAME MAY FRACTURE. IF THIS CONDITION WERE TO OCCUR, THE CUSTOMER MAY EXPERIENCE LOOSENESS OR NOISE IN THE SEAT. IN EXTREME CASES THE SEAT BACK MAY RECLINE UNTIL IT MAKES CONTACT WITH AN OBJECT BEHIND THE SEAT OR THE SECOND ROW CUSHION. THE OCCUPANT COULD POTENTIALLY LOSE CONTACT WITH THE STEERING WHEEL OR FOOT PEDALS, POSSIBLY RESULTING IN A CRASH. *TR
Power train, Electrical system, Nov 16, 2009
I HAVE A 2001 FORD EXPLORER SPORT THAT THE 4X4 CONTROL MODULE CONSTANTLY MALFUNCTIONS. THIS IS A COMMON PROBLEM THAT IS WIDESPREAD AND COULD CAUSE MAJOR ACCIDENTS BY LOSING CONTROL OF THE VEHICLE DURING OPERATION IN THE WINTER MONTHS ON SNOW/ ICE. IF YOU RESEARCH THIS YOU'LL FIND THE PROBLEM EXISTED FROM WHEN THESE WERE NEW VEHICLES AND FORD HAS NO RESOLUTION TO FIX THIS PROBLEM OTHER THAN REPLACE IT WITH ANOTHER DEFECTIVE PART. FORD'S DIAGNOSTIC COMPUTER DOESN'T EVEN RECOGNIZE THERE IS A FAILURE IN THE SYSTEM CREATING AN EVEN LARGER DANGER SINCE HERE'S NO WAY TO TRACE THE PROBLEM WHEN TAKEN IN FOR SERVICE. THERE SHOULD BE A RECALL ISSUED IMMEDIATELY. FORD AND MOTOROLA HAVE DESIGNED AND INSTALLED A DEFECTIVE PART THAT CAN KILL PEOPLE IF NOT FIXED AND HAS PROBABLY CAUSED HUNDREDS OF ACCIDENTS ALREADY. THE FORD PART NUMBER IS 1L54-7H417-AC AND THE MOTOROLA MODEL NUMBER IS 01MP207C01 AND IT IS DESCRIBED AS THE 4X4 CONTROL MODULE. *TR
Structure, Oct 30, 2009
THE RUBBER BODY MOUNT,STRUT AND CONTROL ARM BUSHINGS ON MY 2001 SPORT TRAC 4WD ARE CRUMBLING. *TR
Suspension, Sep 21, 2009
I HAVE A 2001 FORD EXPLORER SPORT TRAC AND THE DRIVERS SIDE FRONT WHEEL BEARING HAS GONE OUT SEVERAL TIMES AND NO ONE KNOWS WHAT THE PROBLEM IS WHY DON'T THEY PUT SEALED BEARINGS SO YOU DON,T HAVE TO CHANGE THEM EVERY 6 MONTHS. *TR
Electrical system, Sep 3, 2009
WE BECAME THE OWNERS A 2001 FORD EXPLORER SPORT TRAC THROUGH A FAMILY MEMBER, AND FOUND THAT THE SIGNAL BLINKERS DO NOT WORK WHEN THE STEERING COLUMN IS ADJUSTED. THE FAMILY MEMBER NEVER KNEW SHE COULD ADJUST THE STEERING COLUMN (SHE IS 74 YEARS OLD). I CONTACTED FORD AND THEY DECLINED THIS WAS A SAFETY ISSUE. THE BLINKERS WORK FINE AS LONG AS THE STEERING COLUMN REMAINS IN THE TOP UPRIGHT UNADJUSTED POSITION. I RESEARCHED THIS PROBLEM ON THE INTERNET AND SEVERAL OWNERS HAVE COMPLAINED WITH THE SAME PROBLEM IN OTHER FORD TRUCKS AS WELL SUCH AS THE FORD 150 PICKUP TRUCK. YET, FORD CLAIMS THIS IS NOT A SAFETY ISSUE. OUR FORD DEALER HAS CLOSED LOCALLY. I AM INTERESTED IN FINDING OUT IF THIS PROBLEM HAS BEEN IDENTIFIED AS A SAFETY ISSUE. *TR
Structure, Aug 27, 2009
2001 FORD EXPLORER SPORT TRAC VEHICLES HAS BADLY DETERIORATING CAB MOUNT BUSHINGS. (THESE BUSHINGS CONNECT THE CAB TO THE FRAME.) ON MY VEHICLE THEY HAVE ALMOST TOTALLY FALLEN APART. THEY CRUMBLE WHEN TOUCHED AND SOME ARE TOTALLY MISSING. THIS CAN CAUSE A BODY SWAY OF UP TO 3-4 INCHES. THERE IS NO RECALL OR SERVICE BULLETIN ON THIS ISSUES ACCORDING TO FORD. I RESEARCHED THIS ON THE INTERNET AND HAVE FOUND THIS TO BE A COMMON PROBLEM WITH THIS VEHICLE. COST OF REPAIR IS ABOUT $600.00. *TR
Electrical system, Air bags, Jul 12, 2009
01 FORD EXP SPORT TRAC 4X4 WITH REAR RADIO/AC CONTROLS AIR BAG WARNING LIGHT DOES NOT GO OUT AND KEEPS POPPING FUSE (LOCATION FOR FAN BLOWER) AND BLOWER INOP EVEN WITH HIGHER AMP FUSES. HAPPENS CHANGE WEATHER COLD/HOT AND ROUGH ROADS. JIGGLE WIRE HARNESS UNDER DASH/CENTER CONSOLE AREA CORRECTS (TEMP). CAN NOT TROUBLE SHOOT AIRBAG MOD WHEN FUSE BLOWN. AC INOP WHEN FUSE BLOWN. *TR