2001 Ford Explorer
Problems, recalls and owner-reported issues
Power train is the leading concern among 730 owner complaints filed for this model year. This is the 14th highest complaint count among 26 Explorer model years with reports.
Of the 2001 reports, 97 involved a crash and 41 involved a fire. 96 people were injured and 10 people died.
What owners report most often
Recalls and investigations
Vehicle speed controlOct 13, 2009
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Campaign 09V399000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Vehicle speed controlAug 3, 2007
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
THIS COULD RESULT IN AN UNDERHOOD FIRE.
DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Campaign 07V336000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Seats, front assembly, reclinerAug 5, 2003
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH HIGH BACK SEATS, THE UPPER BOLT ON THE DRIVER'S SIDE HIGH BACK SEAT, THAT ATTACHES THE SEAT RECLINER MECHANISM TO THE SEAT BACK FRAME, COULD FRACTURE. IF THE BOLT FRACTURES AND DOES NOT JAM IN THE SEAT BACK FRAME, THE SEAT BACK MAY RECLINE UNTIL IT MAKES CONTACT WITH AN OBJECT BEHIND THE SEAT, SUCH AS THE SECOND ROW SEAT CUSHION.
THE DRIVER COULD POTENTIALLY LOSE CONTACT WITH THE STEERING WHEEL OR FOOT PEDALS DURING SUCH AN EVENT, INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE DRIVER SEAT UPPER BOLT WITH A METAL SPACER AND BOLT. IN ADDITION, SEATS WITH TUBULAR BACK FRAMES WILL HAVE THE FULLY THREADED LOWER RECLINER BOLT REPLACED WITH A PARTIALLY THREADED BOLT. OWNER NOTIFICATION BEGAN ON AUGUST 29, 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 03V281000 on NHTSA.gov
Vehicle speed control, cablesAug 5, 2003
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL AND 4.0L SOHC ENGINES, IF THE STRAND COVER ON THE SPEED CONTROL CABLE BECOMES FLARED AT THE END, THE SPEED CONTROL CABLE MAY BIND WHEN THE SPEED CONTROL IS ACTIVATED.
THE THROTTLE RETURN SPRING FORCE MAY NOT BE SUFFICIENT TO OVERCOME THE BINDING CONDITION WHEN THE SPEED CONTROL IS DISENGAGED. BRAKING FUNCTION WOULD BE MAINTAINED THOUGH STOPPING DISTANCES MAY BE INCREASED.
DEALERS WILL INSPECT THE SPEED CONTROL CABLE AND, IF NECESSARY, REPLACE IT. OWNER NOTIFICATION BEGAN AUGUST 29, 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 03V280000 on NHTSA.gov
StructureMar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
Campaign 03V094000 on NHTSA.gov
Tires, tread/beltMay 22, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. EQUIPMENT DESCRIPTION: FORD IS REPLACING ALL FIRESTONE WILDERNESS AT 15, 16, AND 17 INCH TIRES MOUNTED ON FORD TRUCKS AND SUVS. FORD REPORTS TREAD SEPARATION CAN OCCUR DUE TO A COMBINATION OF THE SENSITIVITY OF THE TIRE DESIGN TO STRESS, AGING, AND MANUFACTURING DIFFERENCES BETWEEN PLANTS. FORD IS REPLACING THESE TIRES TO PREVENT POSSIBLE PREMATURE TIRE FAILURE. VEHICLE DESCRIPTION: THE VEHICLES LISTED BELOW MAY HAVE BEEN ORIGINALLY EQUIPPED WITH FIRESTONE WILDERNESS AT TIRES OR MAY HAVE HAD WILDERNESS AT TIRES INSTALLED DURING THE FIRESTONE RECALL LAUNCHED IN AUGUST 2000. CERTAIN 1991 THROUGHT 2002 FORD EXPLORER CERTAIN 2001 THROUGHT 2002 EXPLORER SPORT, AND SPORT TRAC CERTAIN 1997 THROUGH 2002 MERCURY MOUNTAINEER CERTAIN 1991 THROUGH 2001 RANGER CERTAIN 1999 THROUGH 2001 EXPEDITION CERTAIN 1991 THROUGH 1994, AND 1997 MODEL YEAR F-SERIES CERTAIN 1991 THROUGH 1994 BRONCO NOTE: BOTH ORIGINAL EQUIPMENT AND REPLACEMENT TIRES ARE AFFECTED.
SHOULD THE TREAD SEPARATE AT HIGHWAY SPEEDS, A VEHICLE CRASH COULD OCCUR, POSSIBLY RESULTING IN PERSONAL INJURY OR DEATH.
THE REPLACEMENT/REIMBURSEMENT PROGRAM FOR THIS CAMPAIGN EXPIRED ON MARCH 31, 2002. HOWEVER, CUSTOMERS CAN CONTACT FORD AT 1-877-917-3673 OR GO ON-LINE TO WWW.FORD.COM FOR POSSIBLE ASSISTANCE.
Campaign 01X001000 on NHTSA.gov
Equipment, other, labelsOct 17, 2000
VEHICLE DESCRIPTION: CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF PART 567.4, "CERTIFICATION." THESE VEHICLES WERE SHIPPED FROM THE ASSEMBLY PLANT WITHOUT SAFETY CERTIFICATION LABELS.
INCORRECT TIRE INFLATION PRESSURE COULD RESULT IN TIRE TREAD SEPARATION, INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE CERTIFICATION LABELS.
Campaign 00V313000 on NHTSA.gov
Representative owner complaints
730 reports, newest first.
Latches/locks/linkages, Jun 5, 2009
THE LOCKS AND DOOR LATCH ON MY 2001 FORD EXPLORER SPORT OBVIOUSLY DO NOT WORK! THE FIRST PROBLEM IS THAT WHILE I'M DRIVING, THE DRIVER'S SIDE DOOR WILL FLY OPEN IF I HIT A BUMP, DRIVE OVER RAILROAD TRACKS OR TURN TOO HARD. MY DOOR HAS OPENED ON THE INTERSTATE, IN ON-COMING TRAFFIC, AND HAS ALMOST HIT OTHER CARS OR OBJECTS. ANY TIME I CLOSE THE PASSENGER OR REAR DOORS, THE DRIVER DOOR WILL POP OPEN. THE SECOND PROBLEM IS THAT THE LOCKS DON'T KEEP THE DOORS SECURED. MY DOOR WILL STILL FLY OPEN EVEN IF THE LOCK IS DOWN. THIS PAST MONDAY, I LEFT MY CAR LOCKED (OR ATLEAST IT APPEARED TO BE LOCKED) IN FRONT OF MY HOUSE AND WITHIN 30 MINUTES SOMEONE HAD BROKEN IN AND STOLEN EVERYTHING. HE APPARENTLY JUST LIFTED THE DOOR HANDLE BECAUSE THERE WAS NO SIGN OF FORCED ENTRY. HE STOLE MY CD PLAYER, CHECKBOOKS, INSURANCE & REGISTRATION CARDS, CASH, AND EVERYTHING ELSE HE COULD CARRY. THE LOCKS AND DOORS ON MY CAR HAVE BEEN AN INCREDIBLE INCONVENIENCE AND SAFETY PROBLEM FOR ME FOR ALMOST 3 YEARS. THE ESTIMATES THAT HAVE BEEN OFFERED ARE TOO EXPENSIVE FOR ME TO AFFORD AS I AM A RECENT COLLEGE GRADUATE. *TR
Electrical system, Vehicle speed control, Jun 4, 2009
WHEN I HAVE USED MY SPEED CONTROL I HAVE HAD SMOKE COME OUT OF THE TOP OF MY STEERING COLUMN TWICE. THE SMOKE COMES THROUGH THE HOLE FOR MY EMERGENCY LIGHT BUTTON ON THE TOP OF MY STEERING COLUMN. THIS HAPPENED RECENTLY FOR THE THIRD TIME. THE FORD DEALER IS CHARGING $652.63 TO REPLACE THE WIRE HARNESS AND THE SWITCH THAT CONTROLS WIPERS, HAZARD LIGHTS, BLINKERS, ETC. THE RECALL WAS REPLACED, AND THEY SAY THE TWO ARE NOT RELATED. APPARENTLY THIS COULD CAUSE AN ELECTRICAL FIRE AS WOULD THE RECALL PART. THE SUV IS A FORD EXPLORER 2001 V8 XLT. *TR
Power train, May 13, 2009
TL*THE CONTACT OWNS A 2001 FORD EXPLORER SPORT TRAC. THE CONTACT STATED THAT THE OVERDRIVE LIGHT KEPT ILLUMINATING ON THE INSTRUMENT PANEL AND THE TRANSMISSION WAS SLIPPING. THE SHIFT SOLENOID WAS REPLACED, BUT BEGAN TO FAIL 4,000 MILES LATER. THE FORD MANUFACTURER WAS AWARE OF THE FAILURE, BUT COULD NOT ASSIST BECAUSE IT WAS NOT A SAFETY ISSUE. THE FAILURE MILEAGE WAS 58,000.
Air bags, Apr 24, 2009
TL*THE CONTACT OWNS A 2001 FORD EXPLORER. HE STATED THAT THE AIR BAG LIGHT REMAINED ILLUMINATED CONTINUOUSLY AND BLINKS WHEN THERE IS NO PASSENGER IN THE SEAT. THE DEALER WILL NOT DIAGNOSE THE FAILURE WITHOUT THE CONTACT PAYING A FEE. THE LIGHT HAS BEEN ILLUMINATED FOR APPROXIMATELY 2 WEEKS. THE DEALER ALSO STATED THAT THE WARRANTY EXPIRED AND THERE WERE NO RELATED RECALLS. THE FAILURE MILEAGE WAS 93000 AND THE CURRENT MILEAGE WAS 94144. UPDATED 05/11/09. *LJ UPDATED 05/12/09.*JB
Service brakes, Hydraulic, Apr 4, 2009
FRONT BRAKE ROTORS WARP AND BRAKES ARE BAD WITHIN 13,000 MILES. PROBLEM HAS RECURRED SEVERAL TIMES. APPARENTLY THE BRAKES FOR THE HEAVIER FORD SPORT TRAC MODEL ARE FROM THE LIGHTER FORD RANGER AND UNDERSIZED. BRAKES FAILING ON THIS SHORT INTERVAL COULD LEAD TO DRIVERS ON THE ROAD WITH TOTALLY INADEQUATE BRAKING CAPACITY. *TR
Engine and engine cooling, Mar 20, 2009
2001 FORD EXPLORER TIMING CHAIN RATTLE AND FAILURE. ON 4.0L SOHC. THERE ARE MANY PEOPLE WITH THIS PROBLEM ON FORUMS. FORD NEEDS TO HAVE A RECALL OF THIS POTENTIALLY DANGEROUS MOTOR ISSUE OR REIMBURSE PEOPLE THAT NEED TO HAVE THIS REPAIRED. *TR
Electrical system, Interior lighting, Mar 16, 2009
NO REAL EVENT LEADS TO THIS FAILURE. PROBLEM IS THE "DOOR AJAR" LIGHT ON THE DASH. IT DETECTS WHETHER A DOOR IS PARTIALLY OPEN. THE SWITCH IN ONE OF THE DOORS FAILS FOR NO REASON. WHEN IT SENSES THIS FALSELY, THE DASH WARNING LIGHT COMES ON & BEEPS A TONE & QUITE OFTEN THE INTERIOR DOME LIGHTS TURN ON. THE DEALER SAYS TO LUBRICATE THE DOOR LATCHES & WORK THEM SEVERAL TIMES. I'VE DONE THAT MANY TIMES & IT DOES NOT HELP. WHEN THE SWITCH FAILS & THE LIGHT COMES ON, IT MAY BE BRIEF BUT OTHER TIMES, I'LL PARK THE TRUCK & WALK AWAY & THE LIGHT REMAINS ON FOR QUITE A LONG TIME. I'M SURE I'LL COME OUT TO A DEAD BATTERY ONE DAY. PLEASE CHECK THIS OUT. I HAVE SEEN HUNDREDS OF OTHER REPORTS LIKE THIS ON THE INTERNET - FOR VARIOUS FORD MODEL CARS & TRUCKS. THE LIGHT COMING ON IS VERY DISTRACTING AND COULD BE DANGEROUS. *TR
Vehicle speed control, Feb 22, 2009, fire
1. LYING IN BED ONLY TO BE AWOKEN BY BOOM (TIRE BLOWING OUT) AT 5:00 A.M. 2. FAILURE WAS SPEED CONTROL DEACTIVATION SWITCH, ALSO KNOWN AS A "BRAKE PRESSURE SWITCH...IGNITED SETTING VEHICLE ON FIRE 3. NOTHING DONE...VEHICLE WAS TOTALED IN FIRE. *TR
Engine and engine cooling, Feb 9, 2009
TL*THE CONTACT OWNS A 2001 FORD EXPLORER. THE CONTACT HEARD RATTLING NOISES IN THE ENGINE AND THE VEHICLE SHUT OFF. THE VEHICLE WAS TAKEN TO A BODY SHOP AND THE MECHANIC STATED THAT SHE NEEDED A NEW TRANSMISSION. THE CONTACT GOT A SECOND OPINION AND WAS INFORMED THAT A NEW ENGINE WAS NEEDED. A THIRD REPAIR SHOP STATED THAT THE TIMING CHAIN AND CAMSHAFT WERE THE CAUSES OF THE FAILURE. THE CONTACT WAS INFORMED THAT THE PARTS WERE MODIFIED AND WERE DEFECTIVE; THEREFORE, ENTIRELY NEW PARTS WERE NEEDED. THE VEHICLE HAS NOT BEEN REPAIRED. THE DEALER DIAGNOSED THE ISSUE AS HAVING ENGINE FAILURE. THE FAILURE AND CURRENT MILEAGES WERE 135,000.
Suspension, Dec 18, 2008
2001 FORD SPORT TRAC 49,000 MILES HAVE HAD LOWER BALL JOINTS REPLACED TWO YRS AGO AND YESTERDAY 12-17-2008 HAD THE UPPERS REPLACED. ALL FOUR WERE PERM SEALED TYPE. I AM 64YRS OLD AND HAVE NEVER BEFORE HAD BALL JOINT PROBLEMS. PLEASE FORCE CAR COMPANIES TO GO BACK TO GREASE FITTINGS ON SUCH AN IMPORTANT PART OF A VEHICLE. *TR
Electrical system, Nov 22, 2008, fire
VEHICLE WAS PARKED IN THE GARAGE. AFTER 4 HOURS LATER THE CAR WAS BURNING. CALLED THE FIRE DEPARTMENT... *TR
Vehicle speed control, Nov 8, 2008
AFTER RESEARCHING THE PROBLEM WITH MY 2001 FORD EXPLORE I DISCOVERED THAT THERE WAS A RECALL ON THE 2001 FORD EXPLORER WITH THE SPEED CONTROL ACTIVATION SWITCH. MY SPEED CONTROL ACTIVATION SWITCH IS MALFUNCTIONING AND THEIR HAS BEEN A RECALL IN PLACE FOR QUITE SOMETIME AND I WAS NEVER NOTIFIED. THE RECALL # IS 07V336000. *TR
Structure, Nov 8, 2008
2001 FORD EXPLORER BODY MOUNTS. COMPLETELY DETERIORATED. *TR
Visibility, Nov 4, 2008
I WAS ON MIRAMAR RD. & MY BACK WINDOW IN MY 2001 FORD EXPLORER EXPLODED. NOT A TINY, LITTLE CRACK, BUT A LOUD, TERRIFYING EXPLOSION WITH FLYING GLASS. THANK GOD I WAS ON MY WAY TO PICK UP MY 9 YEAR OLD NIECE & 4 YR OLD NEPHEW AND THEY WERE NOT ALREADY IN MY BACK SEAT. GLASS WOULD HAVE FLEW INTO THEIR HEAD ON THE BACK SEAT OR I COULD HAVE GOTTEN INTO A POSSIBLE ACCIDENT. THE GLASS DID NOT REACH THE FRONT, BUT WAS ALL OVER THE CARGO AREA OF THE CAR, INSIDE AND OUTSIDE. (I TOOK SOME PICTURES) I PULLED OVER AND LUCKILY A MAN AT A LOCAL AUTO SHOP HELPED ME TAPE THE HANGING PARTS WITH GLASS TO THE CAR AND CLEAN UP THE GLASS SO I CAN GET THE VEHICLE HOME. I WAS IN COMPLETE SHOCK. AS I LOOKED ONLINE FOR WHAT TO DO AND FORD INFORMATION I FOUND SIMILAR INSTANCES. APPARENTLY, I WASN'T ALONE IN THIS SITUATION. THIS IS AN ONGOING PROBLEM WITH THE EXPLORERS AND IN ALL SITUATIONS FORD IS REFUSING THE RESPONSIBILITY. FIRST, I CONTACTED THE LOCAL POWAY PERRY FORD SERVICE DEPARTMENT AND WAS TOLD BY CHRISTINE THAT UNLESS I WANTED TO SPEND AROUND $450 THERE WAS NOTHING SHE OR ANYONE CAN DO. NEXT, I CONTACTED FORD CUSTOMER CARE CENTER WHERE PAT AND HER SUPERVISOR ROBERT (66360) GAVE ME THE WARRANTY SPEECH AND A FEW DIFFERENT WEBSITES TO RESEARCH FOR RECALLS ISSUES AS TO GET ME OFF OF THE PHONE. I LET THEM KNOW THAT THIS IS A VERY DANGEROUS SITUATION, FOR WHICH NEITHER REALLY CARED TO COMMENT ON AND KEPT RIVETING BACK TO THE MANUAL. I AM VERY DISAPPOINTED IN THE WAY I WAS SPOKEN TO AND THIS SITUATION IN GENERAL. THIS IS A VERY DANGEROUS SITUATION THAT CAN RESULT IN POSSIBLE ACCIDENTS INVOLVING DEATH. I WOULD LIKE FOR FORD TO NOT ONLY RESOLVE MY ISSUE BY FIXING MY BACK WINDOW WITHOUT ANY CHARGES, BUT ALSO DO SOME RESEARCH AND FIGURE OUT WHAT IT IS THAT IS CAUSING THIS IN ALL THE CASES THAT WERE PRESENTED. *TR
Structure, Oct 16, 2008
THE RIGHT REAR SIDE OF MY FORD THE CAB MOUNT HAS RIPPED APART THE STEEL MOUNT HAS FAILED. THE CAB IS IN DANGER OF LEAVING THE FRAME. THE BODY SHOP TOLD ME THAT THIS IS A FACTORY DEFECT AND IS VERY DANGEROUS. THE TRUCK HAS ONLY 74534 MIL. 2001. I'M THE ONLY OWNER, THE TRUCK IS GARAGE KEPT AND VERY WELL MAINTAINED. THIS TRUCK WAS BUILT IN OCT. 2000 AND I BOUGHT THE TRUCK IN NOV. 2000. *TR
Visibility, Oct 14, 2008
FORD EXPLORER 2001 BLEND DOOR NEEDS REPLACED. CAR IS IN GREAT CONDITION EXCEPT FOR THIS PROBLEM WHICH IS A SAFETY ISSUE I FOUND OUT EARLY ONE MORNING ON A COLD DAY WHEN THE WINDSHIELD WOULD NOT DEFROST AND I COULD NOT SEE THREW IT WHILE I WAS ON THE HIGHWAY. I KEPT PULLING OVER TO WIPE THE WINDOWS AND HEADED BACK HOME. I HAVE MADE AN APPOINTMENT WITH FORD SERVICE AND I KNOW IT'S GOING TO COST ALOT. AFTER RESEARCHING ON THE WEB I LEARNED THAT THIS IS A VERY COMMON PROBLEM. I FEEL THIS SHOULD BE A RECALL BECAUSE IT IS A REAL SAFETY ISSUE AND IT IS SO COMMON OF A PROBLEM. THANK YOU, CHRISTINE *TR
Power train, Equipment, Oct 14, 2008
FORD PART # 1L24-7H473-AG VENDOR # M799G MOTOROLA MODEL # 01MU152B06 DATE CODE 01211 SERIAL # 21396939
Suspension, Sep 22, 2008
TL*THE CONTACT OWNS A 2001 FORD EXPLORER SPORT. WHILE DRIVING OVER A BUMP IN THE ROAD AT ANY SPEED, IT FEELS AS IF THERE ARE NO SHOCK ABSORBERS ON THE VEHICLE. TWO DIFFERENT MECHANICS STATED THAT THE REAR PASSENGER SIDE BUSHINGS WERE THE CAUSE OF THE FAILURE. THE CURRENT MILEAGE WAS 70,000 AND FAILURE MILEAGE WAS 65,000. UPDATED 10/30/08. *LJ UPDATED 10/30/08.*JB
Vehicle speed control, Sep 18, 2008
MY FORD EXPLORER 2001 HAD A RECALL NOTICE LAST YEAR REGARDING CRUISE CONTROL. I TOOK MY VEHICLE INTO BREMEN FORD IN BREMEN, IN TO HAVE IT DISCONNECTED. I WAS TOLD IT WOULD GET THE PART IN SHORTLY. THIS WAS IN NOVEMBER OF 2007. IN APRIL I RECEIVED A LETTER FROM FORD STATING THE PROBLEM SHOULD HAVE BEEN FIXED OR WILL BE SHORTLY THROUGH THE SUMMER. AS YET, IT IS GOING ON A YEAR AND I HAVE HEARD ABSOLUTELY NOTHING ABOUT THE PARTS OR GETTING MY TRUCK FIXED. WHAT SEEMS TO BE THE PROBLEM. I HEARD THERE WERE NOT ENOUGH PARTS TO GO AROUND. WHAT DOES THIS SAFE FOR YOUR COMPANY? YOU SHOULD NOT SENT OUT A NOTICE UNLESS YOU INTEND TO REMEDY THE PROBLEM. HOW MUCH LONGER AM I SUPPOSED TO WAIT? *TR
Power train, Sep 2, 2008
TL*THE CONTACT OWNS A 2001 FORD EXPLORER. WHILE DRIVING 65 MPH, THE OVERDRIVE LIGHT BEGAN BLINKING ON AND OFF. THE CONTACT HAD TO STOP THE VEHICLE EVERYTIME THE BLINKING OCCURRED. THE TRANSMISSION SWITCHED FROM FIRST TO SECOND GEAR EACH TIME THE LIGHT ILLUMINATED. THE CURRENT MILEAGE WAS 96,491 AND FAILURE MILEAGE WAS 96,427.
Structure, Aug 30, 2008
I HAVE A 2001 EXPLORER AND THE PAINT HAS BEEN PEELING OFF FOR A COUPLE OF YEARS. IF I WASH IT WITH HIGH PRESSURE, THE PAINT WILL BLOW OFF THE HOOD. PAINT HAS BUBBLED AND COME OFF ON THE HOOD, TAILGATE AND BOTH QUARTER PANELS OVER THE REAR WHEELS. I HAND WASH IT AT THIS POINT TO MINIMIZE MORE PAINT LOSS. *TR
Seats, Aug 30, 2008
MY 4 DOOR EXPLORER IS EQUIPPED WITH RECLINER HIGH BACK SEATS. ABOUT A 2 MONTHS AGO I WAS DRIVING AND THE SEAT ON THE FRONT LEFT HAND (DRIVER SIDE) IT RECLINE WITH OUT WARNING UNTIL IS CAME IN CONTACTED WITH THE SECOND ROW SEAT CUSHION. I WENT TO A FORD DEALER SHIP AND WAS INFORMED THAT THERE WAS NO RECALL FOR SUCH PROBLEM. I HAVE SEND AND MADE CALLS AND SEND LETTERS TO FORD, BUT THEY HAVE FAIL TO ANSWER ANY OF MY LETTERS. *TR
Engine and engine cooling, Jul 28, 2008
THIS IS A 7 YEAR OLD VEHICLE AND IT SEEMS AS THOUGH RECALLS CONTINUE. THIS VEHICLE HAS A CHAIN GUIDE PROBLEM THAT SEEMS TO BE MAJOR. WE NOW EITHER NEED A NEW MOTOR OR WE HAVE TO HAVE IT REPLACED FOR 2,500.00 EVERYWHERE WE CHECK. MAJOR PROBLEM. NOT THAT OLD OF A VEHICLE. *TR
Engine and engine cooling, Jun 12, 2008, fire
WIFE PARKED EXPLORER IN GARAGE, 20 MIN LATER HEARD A LOUD NOISE THEN NOTICED THE VEHICLE WAS ENGULFED IN FLAMES. LUCKILY, WE WERE ABLE TO SAVE OUR HOME AND EVERYONE IS ALRIGHT. CAR IS COMPLETELY TOTALED AND OUR GARAGE IS A DISASTER. *TR
Vehicle speed control, Jun 12, 2008
TL*THE CONTACT OWNS A 2001 FORD EXPLORER. WHILE DRIVING 75 MPH, THE CONTACT ACTIVATED THE CRUISE CONTROL. SHE BEGAN HEARING A CLICKING NOISE AND SMELLED SOMETHING BURNING. HE DEACTIVATED THE CRUISE CONTROL, BUT THE BURNING SMELL PERSISTED. THE CONTACT DID NOT CONTINUE TO DRIVE THE VEHICLE. HE RECEIVED A SAFETY RECALL NOTICE THREE MONTHS AGO, BUT THE SWITCH WAS NEVER DISCONNECTED OR REPAIRED. NHTSA CAMPAIGN ID NUMBER 07V336000 (VEHICLE SPEED CONTROL) WAS REFERENCED. THE CURRENT AND FAILURE MILEAGES WERE 80,016.