2001 Ford Explorer
Problems, recalls and owner-reported issues
Power train is the leading concern among 730 owner complaints filed for this model year. This is the 14th highest complaint count among 26 Explorer model years with reports.
Of the 2001 reports, 97 involved a crash and 41 involved a fire. 96 people were injured and 10 people died.
What owners report most often
Recalls and investigations
Vehicle speed controlOct 13, 2009
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Campaign 09V399000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Vehicle speed controlAug 3, 2007
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
THIS COULD RESULT IN AN UNDERHOOD FIRE.
DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Campaign 07V336000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Seats, front assembly, reclinerAug 5, 2003
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH HIGH BACK SEATS, THE UPPER BOLT ON THE DRIVER'S SIDE HIGH BACK SEAT, THAT ATTACHES THE SEAT RECLINER MECHANISM TO THE SEAT BACK FRAME, COULD FRACTURE. IF THE BOLT FRACTURES AND DOES NOT JAM IN THE SEAT BACK FRAME, THE SEAT BACK MAY RECLINE UNTIL IT MAKES CONTACT WITH AN OBJECT BEHIND THE SEAT, SUCH AS THE SECOND ROW SEAT CUSHION.
THE DRIVER COULD POTENTIALLY LOSE CONTACT WITH THE STEERING WHEEL OR FOOT PEDALS DURING SUCH AN EVENT, INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE DRIVER SEAT UPPER BOLT WITH A METAL SPACER AND BOLT. IN ADDITION, SEATS WITH TUBULAR BACK FRAMES WILL HAVE THE FULLY THREADED LOWER RECLINER BOLT REPLACED WITH A PARTIALLY THREADED BOLT. OWNER NOTIFICATION BEGAN ON AUGUST 29, 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 03V281000 on NHTSA.gov
Vehicle speed control, cablesAug 5, 2003
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL AND 4.0L SOHC ENGINES, IF THE STRAND COVER ON THE SPEED CONTROL CABLE BECOMES FLARED AT THE END, THE SPEED CONTROL CABLE MAY BIND WHEN THE SPEED CONTROL IS ACTIVATED.
THE THROTTLE RETURN SPRING FORCE MAY NOT BE SUFFICIENT TO OVERCOME THE BINDING CONDITION WHEN THE SPEED CONTROL IS DISENGAGED. BRAKING FUNCTION WOULD BE MAINTAINED THOUGH STOPPING DISTANCES MAY BE INCREASED.
DEALERS WILL INSPECT THE SPEED CONTROL CABLE AND, IF NECESSARY, REPLACE IT. OWNER NOTIFICATION BEGAN AUGUST 29, 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 03V280000 on NHTSA.gov
StructureMar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
Campaign 03V094000 on NHTSA.gov
Tires, tread/beltMay 22, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. EQUIPMENT DESCRIPTION: FORD IS REPLACING ALL FIRESTONE WILDERNESS AT 15, 16, AND 17 INCH TIRES MOUNTED ON FORD TRUCKS AND SUVS. FORD REPORTS TREAD SEPARATION CAN OCCUR DUE TO A COMBINATION OF THE SENSITIVITY OF THE TIRE DESIGN TO STRESS, AGING, AND MANUFACTURING DIFFERENCES BETWEEN PLANTS. FORD IS REPLACING THESE TIRES TO PREVENT POSSIBLE PREMATURE TIRE FAILURE. VEHICLE DESCRIPTION: THE VEHICLES LISTED BELOW MAY HAVE BEEN ORIGINALLY EQUIPPED WITH FIRESTONE WILDERNESS AT TIRES OR MAY HAVE HAD WILDERNESS AT TIRES INSTALLED DURING THE FIRESTONE RECALL LAUNCHED IN AUGUST 2000. CERTAIN 1991 THROUGHT 2002 FORD EXPLORER CERTAIN 2001 THROUGHT 2002 EXPLORER SPORT, AND SPORT TRAC CERTAIN 1997 THROUGH 2002 MERCURY MOUNTAINEER CERTAIN 1991 THROUGH 2001 RANGER CERTAIN 1999 THROUGH 2001 EXPEDITION CERTAIN 1991 THROUGH 1994, AND 1997 MODEL YEAR F-SERIES CERTAIN 1991 THROUGH 1994 BRONCO NOTE: BOTH ORIGINAL EQUIPMENT AND REPLACEMENT TIRES ARE AFFECTED.
SHOULD THE TREAD SEPARATE AT HIGHWAY SPEEDS, A VEHICLE CRASH COULD OCCUR, POSSIBLY RESULTING IN PERSONAL INJURY OR DEATH.
THE REPLACEMENT/REIMBURSEMENT PROGRAM FOR THIS CAMPAIGN EXPIRED ON MARCH 31, 2002. HOWEVER, CUSTOMERS CAN CONTACT FORD AT 1-877-917-3673 OR GO ON-LINE TO WWW.FORD.COM FOR POSSIBLE ASSISTANCE.
Campaign 01X001000 on NHTSA.gov
Equipment, other, labelsOct 17, 2000
VEHICLE DESCRIPTION: CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF PART 567.4, "CERTIFICATION." THESE VEHICLES WERE SHIPPED FROM THE ASSEMBLY PLANT WITHOUT SAFETY CERTIFICATION LABELS.
INCORRECT TIRE INFLATION PRESSURE COULD RESULT IN TIRE TREAD SEPARATION, INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE CERTIFICATION LABELS.
Campaign 00V313000 on NHTSA.gov
Representative owner complaints
730 reports, newest first.
Power train, Jun 4, 2008
CHECK ENGINE LIGHT CAME ON, WITHIN HOURS THE TRANSMISSION STARTED NOT CATCHING...WOULD REV BETWEEN 2-3K RPM OR AROUND 30 MPH BUT NOT ACCELERATE. THEN O/D LIGHT STARTED BLINKING. ALL OUT OF THE BLUE.
Structure, Equipment adaptive/mobility, May 31, 2008
THERE'S NO FAILURE JUST RUDE AND LACK OF COMMUNICATION WITH WORKERS. ON 12/21/07 I TOOK MY LETTER OF THE RECALL FOR THE CRUISE CONTROL TO GRANDE TRUCK CENTER ON INTERSTATE 10 @ W.W.WHITE RD."GARY RANDALL AND FINALLY GOT THE REPLACE MENT ON 05/29/08. MR. RANDALL EXPLAINED WHAT WAS TO TAKE PLACE AFTER I ASKED HIM WHY DID THE WORKER TEAR MY CRUISE CONTROL BUTTON(THE PLASTIC) HE STATED 'NO HE SHOULD HAVE LOOKED INSIDE BUT UNDER THE HOOD-MY CRUISE CONTROL PLASTIC FELL OF AND I JUST ASSUME THAT IT WAS A PART OF THE REPLACEMENT OF THE RECALL SO I LEFT IT IN THE CAR UNTIL THE RECALL WAS DONE-TO FIND OUT THE PLASTIC WAS NOT REPLACEABLE BY THE ONE WHO BROKE/TORE/CUT IT. AFTER THE JOB WAS FINISHED THE RUDE WORKER JUST SLAMMED THE HOOD CLOSE AND WALKED AWAY-VERY RUDE. POOR REPRESENTATION OF THE FORD COMPANY-RACE HAS ALWAYS BEEN AN ISSUE WITH THESE TYPE PEOPLE THAT SHOULD NOT BE WORKING IN THE PUBLIC-NOW I WOULD LET THEM DO NOTHING ELSE TO MY VEHICLE AGAIN NOT EVEN RECALL. *TR
Engine and engine cooling, May 12, 2008
TL*THE CONTACT OWNS A 2001 FORD EXPLORER SPORT TRAC. THE CONTACT STATED THAT HIS CHECK ENGINE LIGHT ILLUMINATED. A DIAGNOSTIC WAS PERFORMED AND THE DEALER STATED THAT THE EGR SENSOR FAILED. THE DEALER AND MANUFACTURER STATED THAT THERE WERE NO OPEN RECALLS AVAILABLE PERTAINING TO HIS VIN; THEREFORE, IT WAS EXCLUDED FROM RECALL NUMBER 02M01S6. THE CONTACT IS RESPONSIBLE FOR THE REPAIR COSTS. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 70,000.
Equipment, Apr 29, 2008
IN NOVEMBER 2007 I RECEIVED A RECALL NOTICE. I PROMPTLY CONTACTED MY LOCAL DEALER AND PLACED MY NAME ON THE "WAIT" LIST. I HAVE CALLED THREE TIME SINCE AUGUST AND HAVE BEEN ASSURED EACH TIME THAT I AM STILL ON THE LIST; HOWEVER, MANUFACTURER HAS NOT SHIPPED THE PART FOR MY 2001 FORD SPORT TRAC. *TR
Service brakes, Hydraulic, Apr 22, 2008
2001 FORD EXPLORER SPORT - INTERMITTENT LOCKING OF THE BRAKES WHICH CAUSES THE VEHICLE TO PULL HARD TO THE LEFT, CREATING AN UNCONTROLLABLE VEHICLE. THIS INTERMITTENT LOCKING CAN OCCUR AT ANY SPEED INCLUDING HIGHWAY SPEEDS, WHICH IS OBVIOUSLY VERY DANGEROUS. VEHICLE CAN NOT BE SOLD AS IT IS UNSAFE TO DRIVE, FORD MOTOR COMPANY DOES NOT KNOW HOW TO FIX THE VEHICLE. SEPTEMBER 2004 - 30,173 MILES. CUSTOMER STATES VEHICLE PULLS TO THE LEFT WHEN BRAKING. TECHNICIAN COULDN'T DUPLICATE PROBLEM. OCTOBER 2004 - 30,400 MILES. CUSTOMER STATES VEHICLE IS PULLING HARD TO LEFT WHEN BRAKING AT TIMES. TECHNICIAN COMMENTS "FOUND VEHICLE PULLING TO LEFT AND FELT POP IN PEDAL AND VEH STARTED BRAKING STRAIGHT, CHECKED BRAKES FOUND RIGHT INNER BRAKE PAD STUCK TRIED TO REPLACE BRAKE HARDWARE. REPLACED PADS TO GET HARDWARE KIT INSTALLED HARDWARE KIT AND NEW PADS AGAIN DROVE THE VEHICLE VEHICLE FOUND VEHICLE STOPS STRAIGHT." NOVEMBER 1, 2004 - CUSTOMER STATED THAT VEHICLE PULL HARD TO THE LEFT WHEN BRAKING AT TIMES SERVICE COMPLETED BRAKE SERVICE - CALIPER ASY - BRAKE - LESS PAD - FLUID BRAKE - HUB ASY - WHEEL NOVEMBER 8, 2004 - 31,311 MILES. - CUSTOMER STATED BRAKES PULL TO THE LEFT AND LOCK UP! NEW PARTS AND ITEMS WORKED ON: ANTI-LOCK BRAKING SYSTEM CONTROL AND MODULE, PIN POINT TEST, ANTI LOCK MODULE - REPLACE, SOLENOID VALVE BLOCK / HCU - REPLACE 5/9/2007 - 6/8/07, MILES 62,013 - FORD HAD THE VEHICLE FOR ONE MONTH, LISTED BELOW ARE THE ITEMS THAT WERE REPAIRED FOR THE SAME HARD PULLING TO THE LEFT INTERMITTENTLY. - REPLACED FRONT AND REAR ROTORS - REPLACED BOTH FRONT BALL JOINTS, ALIGNED FRONT END 6/14 - 6/20/07, MILES 62,326. - VEHICLE TAKEN HOME BY TECHNICIAN TO DUPLICATE PROBLEM - INSPECTED FRONT CALIPER PISTONS - BLED FRONT BRAKES FOR ANY AIR - INSPECTED FRONT WHEEL BEARING FOR LOOSENESS/ BINDING *WE HAVE A LETTER FROM FORD STATING THAT THEY CAN NOT FIX THE PROBLEM AND THAT THE VEHICLE IS NOT SAFE FOR DRIVING. *TR
Vehicle speed control, Apr 8, 2008
AS OF APRIL 2008, FORD STILL HAS NOT SHIPPED THE PARTS NEEDED FOR THE SPEED CONTROL DEACTIVATION SWITCH RECALL. THE RECALL WAS SENT OUT IN AUGUST 2008! FIRST, I WAS TOLD THAT THE PARTS WOULD ARRIVE IN DECEMBER OF 2007. THEN IN DECEMBER 2007, I WAS TOLD IT WOULD BE NEXT APRIL. NOW I AM TOLD IT WILL BE JUNE 2008. *TR
Vehicle speed control, Mar 29, 2008
FORD SENT ME A NOTICE IN THE JULY/AUGUST 2007 TIME FRAME ADVISING ME OF A RECALL ON MY FORD SPORT TRAC FOR A CRUISE CONTROL CABLE THAT COULD LEAD TO AN ENGINE FIRE. SEVEN (7) MONTHS LATER MY DEALER IN SPRINGFIELD, VA STILL DOES NOT HAVE THE REPLACEMENT PARTS. THIS IS TOTALLY UN-ACCEPTABLE. *TR
Vehicle speed control, Mar 26, 2008
RECEIVED RECALL NOTICE IN AUGUST 2007 FOR PROBLEMS WITH SPEED CONTROL ON 2001 FORD EXPLORER. CALLED LOCAL FORD DEALER, WAS TOLD NO PARTS SHIPPED FROM FORD YET, WILL BE DECEMBER BEFORE THEY GET THEM. CALLED IN JAN 08, STILL NO PARTS, WILL BE MARCH BEFORE THEY GET THEM, CALLED MARCH 26, 2008 WAS TOLD NO PART SHIPPED, WILL BE END OF MAY AT THE EARLIEST. FORD MOTOR COMPANY KNEW OF THE PROBLEM WAY BEFORE THE RECALL NOTICES WERE SENT OUT IN AUGUST 07. FORD WOULD HAVE SPENT MONTHS DENYING THERE WAS A PROBLEM AND THEN MORE TIME TRYING TO FIND A WORK AROUND BEFORE FINALLY ADMITTING THEY HAD NO CHOICE BUT TO FOLLOW GOV.'T GUIDELINES AND DO A RECALL - MONTHS IF NOT LONGER BEFORE THE LETTERS WERE SENT OUT. PLENTY OF TIME TO KNOW HOW MANY VEHICLES WERE EFFECTED AND GET THE PARTS ORDERED. IT WILL BE A MINIMUM OF 1 YEAR SINCE THE PROBLEM WAS NOTICED AND LETTERS SENT BEFORE THE PARTS ACTUALLY ARRIVE AT THE DEALERS FOR REPAIR OF PROBLEM. INEXCUSABLE! AND THE NHTSA SHOULD BE DOING MORE THAN IGNORING IT! *TR
Vehicle speed control, Mar 18, 2008
RECALL BY FORD ON SPEED CONTROL. SAFETY RECALL 05S28. OCT OF 2007 GOT SPEED CONTROL DEACTIVATED BY FORD. WAS TOLD PART WOULD BE IN NOV 07 AND AGAIN TOLD IT WILL BE DEC 07 IN DEC 07 WAS TOLD MARCH 07. TODAY MARCH 18TH CALLED FOR PART WAS TOLD PART IS NOT IN YET TO CALL AGAIN IN APRIL. (5 MONTHS) IS REALLY A LONG TIME TO GO WITH OUT SPEED CONTROL. *TR
Equipment, Mar 11, 2008
SAFETY RECALL L05S28 (SPEED CONTROL SYSTEM DEACTIVATION. RECALL WAS MADE IN AUGUST 2007. WE ARE STILL WAITING ON THE SERVICE PARTS TO MAKE THE REPAIR. FORD SENT NOTICE IN SEPTEMBER THAT THEY HAVE A SHORTAGE OF THESE PARTS AND WE COULD HAVE THE DEVICE DISCONNECTED. WE DON'T WANT THE DEVICE DISCONNECTED, WE WANT THE REPAIR TO BE MADE. IT HAS BEEN 7 MONTHS WAITING ON THIS REPAIR. ARE WE TO WAIT FOREVER FOR THIS REPAIR TO BE MADE? *TR
Suspension, Structure, Mar 7, 2008
2001 FORD EXPLORER SPORT DEFECTIVE BODY MOUNT INSULATORS. MECHANIC DETERMINED THAT THE BODY MOUNT INSULATORS DETERIORATED AND COULD CRUMBLE IN SOMEONE'S HAND. FORD DECLINED TAKING RESPONSIBILITY FOR REPLACING THE PARTS. *KB PARTS ATTACHED
Vehicle speed control, Mar 7, 2008
TL*THE CONTACT OWNS A 2001 FORD EXPLORER SPORT TRAC. THE CONTACT RECEIVED A RECALL NOTICE IN SEPTEMBER OF 2007 FOR THE VEHICLE SPEED CONTROL: CRUISE CONTROL. THE SPEED CONTROL WAS DISCONNECTED. THE CONTACT WOULD LIKE TO KNOW WHY THE DEALER DOES NOT HAVE THE PARTS AVAILABLE. THERE HAD BEEN NO FAILURE TO DATE. THE RECALL NUMBER WAS UNKNOWN. THE CURRENT MILEAGE WAS 104,600. UPDATED 5/20/08 *CN
Vehicle speed control, Mar 6, 2008
TL*THE CONTACT OWNS A 2001 FORD EXPLORER. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 07V336000 (VEHICLE SPEED CONTROL). THE PART WAS UNAVAILABLE. SHE HAS MADE THREE ATTEMPTS TO HAVE THE DEALER DISCONNECT THE SWITCH, BUT THEY CONTINUED TO STATE THAT THEY DID NOT HAVE THE TIME. THERE HAD BEEN NO FAILURE TO DATE. THE CURRENT MILEAGE WAS 106,000.
Vehicle speed control, Feb 28, 2008
FORDS RECALL ON THE DEFECTIVE CRUISE CONTROL SWITCH IS A SCAM IN MY OPINION. I RECEIVED A RECALL NOTICE IN, I BELIEVE IT WAS OCTOBER 2007. THE LOCAL DEALER UNPLUGGED THE CRUISE CONTROL AND SAID THAT THEY WOULD MAKE REPAIRS WHEN THE PARTS BECAME AVAILABLE. THE REPAIR IS TO PUT A FUSE IN LINE WITH THE SWITCH. THIS, IN NO WAY, REPAIRS THE DEFECTIVE PART. THE ADDITION OF A FUSE, AS RELATED TO ME BY THE DEALER, HAS NOW ALSO BEEN RECALLED. THAT IS A MUTE POINT BECAUSE FORD HAS NOT YET BEEN ABLE TO SUPPLY THE PART/FUSE. TODAY IS THE 28TH OF FEBRUARY 2008. I HAVE BEEN WAITING, AND UNABLE TO USE MY CRUISE CONTROL SINCE THE DEALER DISCONNECTED IT IN OCTOBER OF 2007. I HAVE LEARNED THAT THERE IS A REPLACEMENT PART AVAILABLE THAT FORD IS INSTALLING IN SOME VEHICLES. THE LOCAL DEALER TELLS ME THAT MY 2001 EXPLORER SPORTAC IS NOT INCLUDED. I WAS TOLD THAT I COULD REPLACE THE PART MYSELF BUT FORD WOULD NOT INSTALL IT UNDER THE RECALL FOR NO CHARGE EVEN IF I PAID FOR THE PART. THE PART # IS SW-6350 THE LOCAL DEALER HAS 21 OF THESE SWITCHES IN STOCK TODAY. BECAUSE FORD HAS NOT ALLOWED THE USE OF THIS PART IN ITS RECALL, WE THE CONSUMERS ARE LEFT IN A POSITION OF EITHER NOT USING SOMETHING WE PAID FOR OR RISKING A FIRE. I AM APPALLED BY THE LACK OF ACTION ON THIS MATTER. I BELIEVE THAT THE NHSTA NEEDS TO APPLY THE PRESSURE TO FORD TO RESOLVE THIS INACTION. THERE IS AN HOW TO ARTICLE AT MYSPORTAC.COM. IT INCLUDES INSTRUCTIONS AND PHOTO'S POSSIBLY YOU COULD ASK FORD TO CHECK IT OUT. THANK YOU DAVID M. CLARY *TR
Vehicle speed control, Feb 22, 2008
TL*THE CONTACT OWNS A 2001 FORD EXPLORER SPORT TRAC. THE CONTACT RECEIVED A FORD RECALL NOTICE FOR THE VEHICLE SPEED CONTROL IN AUGUST OF 2007. THE DEALER HAS STATED EVERY MONTH SINCE THEN THAT THE PART FOR THE REPAIR WOULD BE AVAILABLE THE FOLLOWING MONTH. THERE HAD BEEN NO FAILURE TO DATE. THE CURRENT MILEAGE WAS 111,000. UPDATED 04/03/08. *LJ
Vehicle speed control, Feb 14, 2008
I WAS NOTIFIED BY FORD THAT I HAD A PROBLEM WITH MY SPEED CONTROL ON MY 2001 FORD SPORT TRAC AND REQUESTED ME TO BRING MY CAR IN TO GET IT REPLACED. WHEN I TOOK MY TRUCK IN IN AUGUST I WAS TOLD THAT THE PART WAS NOT IN STOCK AND TO BRING IT BACK IN DECEMBER. I JUST CALLED THE DEALERSHIP AND THEY ARE NOW TELLING ME THE PART IS NOT IN AND THEY HAVE NO CLUE WHEN IT IS GOING TO BE IN. FRANKLY IT APPEARED TO ME THEY DIDN'T CARE. WHEN I ASKED WHO I COULD ESCALATE IT TO AT FORD THE GENTLEMAN DID GIVE ME THE NUMBER, BUT TOLD ME IT WOULDN'T DO ANY GOOD BECAUSE FORD COULDN'T DO ANYTHING ABOUT IT. *TR
Vehicle speed control, Feb 7, 2008
TL*THE CONTACT OWNS A 2001 FOR EXPLORER. THE CONTACT RECEIVED A RECALL NOTICE FOR THE VEHICLE SPEED CONTROL IN SEPTEMBER OF 2007. THE PARTS ARE STILL NOT AVAILABLE FOR THE RECALL REPAIR. THERE HAD BEEN NO FAILURE TO DATE. THE RECALL NUMBER WAS UNKNOWN. THE CURRENT MILEAGE WAS 195,000.
Vehicle speed control, Feb 6, 2008
TL*THE CONTACT OWNS A 2001 FORD EXPLORER SPORT TRAC. THE CONTACT STATED THAT THE PARTS FOR FORD RECALL NUMBER 05S28 (VEHICLE SPEED CONTROL: CRUISE CONTROL) ARE UNAVAILABLE. HE HAS BEEN GIVEN A LOT OF INCORRECT INFORMATION AS TO WHEN THE PARTS WILL BE AVAILABLE. THERE HAD BEEN NO FAILURE TO DATE. THE CURRENT MILEAGE WAS 86,000. UPDATED 03-04-08 *BF
Power train, Feb 5, 2008
2001 FORD EXPLORER SPORT WITH AUTOMATIC TRANSMISSION, 105,000 MILES. "O/D OFF" LIGHT BLINKING AFTER DRIVING FOR A FEW MINUTES. ENGINE ALWAYS REVS HIGH BETWEEN GEAR SHIFTS, ESPECIALLY BETWEEN FIRST AND SECOND, EVEN BEFORE THE LIGHT STARTS BLINKING. CHANGED TRANSMISSION FLUID AND FILTER, BUT THAT DIDN'T HELP. ONLY OCCASIONALLY TOWED SMALL TRAILER, BUT MOSTLY JUST DAILY DRIVING. NUMEROUS BLOGS ON THIS SUBJECT, SO THE PROBLEM APPEARS TO BE WIDESPREAD! *TR
Vehicle speed control, Feb 4, 2008
TL*THE CONTACT OWNS A 2001 FORD EXPLORER SPORT. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 07V336000 (VEHICLE SPEED CONTROL). THE PART FOR THE RECALL REPAIR WAS UNAVAILABLE. THE DEACTIVATION SWITCH WAS NOT DISCONNECTED B UPDATED 02-25-08 *BFECAUSE HE IS HANDICAPPED. THERE HAD BEEN NO FAILURE TO DATE. . THE CURRENT MILEAGE IS 105,000.
Power train, Vehicle speed control, Jan 25, 2008
TL*THE CONTACT OWNS A 2001 FORD EXPLORER SPORT TRAC. WHEN THE TRANSMISSION INDICATOR LEVER IS PULLED TO CHANGE GEARS, IT GOES ONE SPACE TOO FAR. WHEN THE GEAR IS PLACED INTO NEUTRAL, THE VEHICLE DRIVES IN REVERSE. WHEN THE GEAR IS PLACED INTO DRIVE, THE VEHICLE OPERATES IN NEUTRAL. WHEN THE GEAR IS PLACED INTO REVERSE, THE VEHICLE REMAINS IN PARK. THE CURRENT MILEAGE WAS 34,231 AND FAILURE MILEAGE WAS 34,175. UPDATED 02-19-08 *BF THE CONSUMER STATED DISCONNECTED SPEED DEACTIVATION SWITCH PERTAINING TO RECALL 05S28. UPDATED 02/14/08 *TR
Vehicle speed control, Jan 24, 2008, fire
2001 FORD EXPLORER SPORT SPONTANEOUSLY CAUGHT FIRE IN ENGINE COMPARTMENT WHILE PARKED IN GARAGE ATTACHED TO MY HOME. VEHICLE WAS MOVED TO DRIVEWAY AND FIRE EXTINGUISHED. FORD DEALER ADMITTED TO RECALL OF DEFECTIVE CRUISE CONTROL SWITCH WHICH WAS THE ORIGINATION POINT OF FIRE. WAS ADVISED TO FILE CLAIM WITH MY AUTO INSURANCE COMPANY TO SPEED UP REPAIRS AND ENSURE THAT CLAIM WAS SUBROGATION TO FORD FOR REIMBURSEMENT. VEHICLE REPAIRED, NOW FORD WILL NOT TAKE CLAIM WITHOUT PROOF OF CAUSE OF FIRE. THIS WOULD REQUIRE MY INSURANCE COMPANY TO HIRE AN ENGINEER. NOT COST EFFECTIVE FOR INSURANCE COMPANY, NOT TO MENTION THE FACT THAT THE VEHICLE WAS REPAIRED OVER 3 MONTHS AGO. I AM OUT MY DEDUCTIBLE AND MY INSURANCE COMPANY IS OUT THE REMAINDER OF THE REPAIRS, EVEN THOUGH FORD KNOWS THIS WAS A FAULTY PART. *TR
Vehicle speed control, Jan 20, 2008
DEFECT WITH THE CRUISE CONTROL. MY CRUISE CONTROL WAS DE-ACTIVATED ON 9/13/07, AND MY DEALERSHIP REPORTS THEY ARE STILL WAITING FOR THE REPAIR PART FROM FORD. I WOULD LIKE TO HAVE MY CRUISE CONTROL REPAIRED IMMEDIATELY - I HAVE BEEN DRIVING FOR 4 MONTHS WITHOUT CRUISE CONTROL. *TR
Vehicle speed control, Jan 14, 2008
2001 FORD EXPLORER WITH SPEED CONTROL SYSTEM RECALL. CONSUMER STATES THAT THE DEALER TO FIX THE RECALL STATED THAT THEY WERE UNABLE TO OBTAIN THE REPLACEMENT PARTS. DEALER FINALLY DISCONNECTED THE SPEED CONTROL UNTIL THE PARTS WERE AVAILABLE. *KB
Vehicle speed control, Jan 11, 2008
TL*THE CONTACT OWNS A 2001 FORD EXPLORER SPORT TRAC. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 07V336000 (VEHICLE SPEED CONTROL) IN AUGUST OF 2007. HE SCHEDULED AN APPOINTMENT TO HAVE THE CRUISE CONTROL SERVICED; HOWEVER, THE DEALER STATED THAT THE PARTS WERE UNAVAILABLE. THE DEALER OFFERED TO HAVE THE DEACTIVATION SWITCH DISCONNECTED, BUT THE CONTACT DECLINED AND STATED THAT HE PAID GOOD MONEY FOR THE VEHICLE. THE CONTACT NOTIFIED FORD MOTOR COMPANY AND THEY STATED THAT THEY DID NOT KNOW WHEN THE PART WOULD ARRIVE. THERE HAD BEEN NO FAILURE TO DATE. THE CURRENT MILEAGE IS 125,090. UPDATED 02-25-08 *BF UPDATED *JB