2002 Ford Explorer
Problems, recalls and owner-reported issues
Power train is the leading concern among 3,613 owner complaints filed for this model year. This is the highest complaint count among 26 Explorer model years with reports.
Of the 2002 reports, 163 involved a crash and 71 involved a fire. 213 people were injured and 6 people died.
What owners report most often
Recalls and investigations
Vehicle speed controlOct 13, 2009
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Campaign 09V399000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Visibility, glass, side/rearDec 11, 2007
CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.
SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER'S GLASS. WHOLESALE CUSTOMERS CAN CONTACT SAFELITE'S WHOLESALE DIVISION, SERVICE AUTOGLASS TOLL FREE AT 1-888-246-6298. THE RECALL BEGAN ON JANUARY 15, 2008.
Campaign 07E104000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Structure, body, hatchback/liftgate, hinge and attachmentsSep 13, 2004
ON CERTAIN SPORT UTILITY VEHICLES, THE LIFTGATE GLASS STRUT MAY BECOME DISENGAGED OR THE HINGE MAY FRACTURE ALLOWING THE GLASS TO FALL AND POSSIBLY BREAK.
IF THE HINGE SHOULD FRACTURE, THERE IS A POTENTIAL FOR THE GLASS TO FALL AND ULTIMATELY BREAK AND PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE THE LIFTGATE GLASS STRUT BRACKETS AND GLASS HINGES REPLACED. FOR THE VEHICLES BUILT FROM AUGUST 1, 2000 THROUGH MARCH 3, 2002, THE DEALERS WILL REPLACE THE HINGES AND LIFTGATE STRUT BRACKET. ON VEHICLES BUILT FROM MARCH 3, 2002 THROUGH JUNE 23, 2003, THE DEALERS WILL ONLY REPLACE THE HINGES. THE RECALL BEGAN ON SEPTEMBER 30, 2004. A POSTCARD WAS SENT TO OWNERS ON DECEMBER 27, 2004, ADVISING THEM THAT PARTS ARE NOW AVAILABLE. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V442000 on NHTSA.gov
StructureMar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
Campaign 03V094000 on NHTSA.gov
Tires, sidewallMay 24, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE RIGHT SIDE TIRES MAY HAVE HORIZONTAL CUTS ON THE EDGE OF THE TREAD THAT COULD HAVE OCCURRED DURING VEHICLE ASSEMBLY.
OVER TIME, THE TIRE COULD FAIL, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE TIRES AND, IF ANY SLICES ARE FOUND, THE CUT TIRES WILL BE REPLACED. OWNER NOTIFICATION BEGAN JUNE 7, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 01V171000 on NHTSA.gov
Visibility, glass, side/rearApr 10, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2002 FORD EXPLORER AND MERCURY MONTAINEER SPORT UTILITY VEHICLES. THE BRACKETS CONNECTING THE LEFT CYLINDERS TO EACH SIDE OF THE LIFTGATE GLASS COULD ROTATE OUT OF POSITION IF EITHER THE URETHANE BOND OR TORQUE ARE NOT SUFFICIENT.
ROTATION OF THE BRACKETS COULD POTENTIALLY CAUSE THE LIFT CYLINDERS TO DETACH FROM THE GLASS OR, IN SOME CASES, COULD POTENTIALLY CAUSE THE LIFTGATE GLASS TO BREAK. EITHER CONDITION IS MOST LIKELY TO OCCUR WHEN THE GLASS IS BEING CLOSED.
FORD DEALERS WILL INSPECT THE VEHICLES FOR THE POSITION OF BOTH THE LEFT AND RIGHT LIFTGATGE GLASS LIFT CYLINDER BRACKETS. IF THE BRACKETS ARE IN THE PROPER POSITION, THE BRACKET RETAINERS WILL BE TIGHTENED TO A HIGHER TORQUE. IN CASES WHERE THE BRACKET IS NOT PROPERLY POSITION, THE BRACKET MUST BE RE-ALIGNED.
Campaign 01I010000 on NHTSA.gov
Representative owner complaints
3,613 reports, newest first.
Structure, Aug 27, 2014
REAR LIFT GATE PLASTIC PANEL CRACKED, ALLOWING WATER TO ENTER. I HAVE NOTICED MANY FORD EXPLORERS WITH THE SAME ISSUE. WHY HAS FORD IGNORED THIS DEFECT, I SEE MANY COMPLANTS ON-LINE WITH THE SAME FLAW BY OTHER EXPLORER OWNERS.. *TR
Power train, Aug 21, 2014
I WAS DRIVING MY 02 EXPLORER ON THE THRUWAY FOR 2 AN 1/2 HOURS AND WHEN I GOT TO MY DESTINATION THE TRANSMISSION BUCKED AND SHUDDERED AND REVVED UP WHILE I WAS TRYING TO STOP AT A STOP LIGHT I ALMOST HIT THE PERSON IN FRONT OF ME BECAUSE OF THE TRANSMISSION FAILING WHEN I LOOKED AT MY INSTRUMENT PANEL ON THE DASH THE OVERDRIVE LIGHT WAS FLASHING SO AFTER I GOT HOME I CHECKED THE INTERNET AND WOULD YOU KNOW THERE ARE THOUSANDS OF PEOPLE THAT ARE EXPERIENCING THE SAME PROBLEM... FORD SHOULD HAVE A RECALL FOR THIS TRANSMISSION BECAUSE WHAT HAPPENED TO ME MIGHT HAPPEN TO SOMEONE ELSE WITH DEADLY RESULTS... I TALKED TO MY TRANSMISSION SPECIALIST AND HE SAID IT NEEDS A NEW TRANSMISSION THE TRUCK DOESN'T EVEN HAVE 150,000 ON IT SO I CONTACTED FORD AND THEY CAN'T HELP ME BECAUSE THERE IS NO RECALL FOR THIS TRUCK... FORD NEEDS TO FIX THEIR MANUFACTURE ERROR HERE BECAUSE WHAT THEY ARE DOING IS FRAUD THEY CLAIM THAT THEIR TRANSMISSIONS ARE GOOD BUT LIKE WITH A LOT OF THE COMPLAINTS I HAVE READ THEIR TRANNYS DIED BEFORE 100,000 MILES SO FOR THEM TO SELL DEFECTED SUVS IS FRAUDULENT IN ITS SELF BECAUSE NOT ONLY DO WE THE CUSTOMERS HAVE TO PAY ALL THIS MONEY FOR THE VEHICLE BUT WE ALSO HAVE TO PUT A NEW TRANSMISSION IN THEM BEFORE 100,000 MILES AT THE COST OF 3500 TO 4000 DOLLARS... *TR
Power train, Structure, Aug 21, 2014
I PURCHASED THIS TO USE AS A SECOND VEHICLE FOR CAMPING TRIPS SO THE MILEAGE ON IT IS VERY LOW FOR ITS AGE. SUDDENLY ONE DAY OF NORMAL LOCAL DRIVING, THE O/D LIGHT STARTED FLASHING AND THE VEHICLE STARTED TO RUN VERY ROUGH. IT COULDN'T SEEM TO ACCELERATE AND RPMS WERE HIGH. I HAD TO DRIVE HOME WITH EMERGENCY FLASHERS ON SINCE THE CAR FELT LIKE IT WAS GOING TO DIE ANY MOMENT. SINCE O/D FLASHING MEANS SOMETHING WITH TRANSMISSION, I TOOK IT TO TWO DIFFERENT TRANSMISSION REPAIR SHOPS WHO BOTH DIAGNOSED A BAD TRANSMISSION THAT WOULD NEED TO BE REPLACED AT ABOUT $3,500. I WAS SHOCKED THAT I WOULD NEED A NEW TRANSMISSION WITH ONLY 43000 MILES ON VEHICLE DESPITE ITS AGE. BOTH SHOPS INFORMED ME THAT THE 2002 FORD EXPLORERS ARE NOTORIOUS FOR BAD TRANSMISSIONS. I CALLED FORD MOTOR COMPANY TO REQUEST ASSISTANCE WITH THIS REPAIR. THEY WOULD NOT HELP ME IN ANY WAY. THE VEHICLE IS NOT DRIVABLE AND I AM NOT IN A FINANCIAL POSITION TO TAKE ON SUCH AN EXPENSIVE REPAIR FOR A SECOND VEHICLE. RIGHT NOW IT IS SITTING UNUSED IN MY DRIVEWAY WHILE COSTING ME TO KEEP IT INSURED. CAN'T BELIEVE THIS HAS HAPPENED TO ME SINCE I THOUGHT I WAS BUYING A REPUTABLE PRODUCT. FORD ABANDONED ME WHEN THEIR PRODUCT FAILED. I WILL NEVER BUY ANOTHER FORD PRODUCT AGAIN. THE LEAST FORD COULD HAVE DONE WAS ASSUME RESPONSIBILITY FOR THEIR MISTAKES AND NOT CHEAT THE PUBLIC. OTHER ISSUES I AM HAVING IS FLAKING PEELING PAINT AND A CRACK THROUGH THE FORD EMBLEM ON THE REAR DOOR PANEL. *TR
Power train, Aug 18, 2014
TRANSMISSION PROBLEM. O/D LIGHT BLINKING. TRANSMISSION INSTANTLY STARTED TO SLIP IN 3RD GEAR UNDER ACCELERATION. OVER 8,000 COMPLAINTS LISTED BUT FORD SAYS THAT IS NOT ENOUGH FOR RECALL. THIS TRANSMISSION HAS A HISTORY OF PROBLEMS, THAT CAN CAUSE MAJOR PROBLEMS WHILE DRIVING. BIGGEST ONE IS LOSE OF ACCELERATION IN TRAFFIC. THIS TRANSMISSION HAS A LENGTHY BAD HISTORY. IT IS THE 5R55 SERIES TRANSMISSION, STARTING WITH THE FAULTY SOLENOID PACK. IF YOU LOOK AT THIS TRANSMISSIONS HISTORY, YOU WILL FIND THE SAME COMPLAINTS ABOUT IT OVER AND OVER AGAIN, SLIPPING WHILE IN GEAR FAILURE TO SHIFT, O/D LIGHT BLINKS THEN GOES OUT, TRANS FAILING AT 50,000M, 60,000M. I AM ON MY SECOND PAIR OF TIRES AND THE TRANSMISSION IS FAILING. I DRIVE LESS THAN 8700 MILES PER YEAR AND MAINTAIN MY VEHICLE VERY WELL. THIS TYPE OF FAILURE SHOULD NOT HAVE OCCURRED. I THINK FORD IS AWARE OF THE PROBLEM BUT REFUSES TO DO ANYTHING ABOUT IT TILL THEY WILL BE FORCED TO DO SOMETHING. *TR
Wheels, Aug 11, 2014
TL* THE CONTACT OWNS A 2002 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 10 MPH, THE CONTACT NOTICED THAT THE REAR PASSENGER SIDE TIRE RODE ROUGHLY. THE CONTACT NOTICED THAT THREE OF THE WHEEL STUDS WERE SHEARED OFF. THE FAILURE OCCURRED FOUR TIMES WITH THE REMAINING WHEEL STUDS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 140,000. UPDATED 10/02/14*LJ THE CONSUMER STATED WITHIN 7 MONTHS THE THE REAR WHEEL STUDS SUDDENLY SHEARED OFF WHILE DRIVING. THE LAST TIME THE DRIVER WAS ON THE FREEWAY WITH 5 CHILDREN IN THE CAR. UPDATED 3/30/2015 *JS
Power train, Wheels, Aug 10, 2014, fire
WAS DRIVING ON THE HIGHWAY AND FELT A SHARP JERK/PULL TO THE RIGHT. AT FIRST THOUGHT IT WAS A FLAT TIRE SO GOT OFF ON NEXT EXIT. WASN'T A FLAT TIRE BUT COULD SMELL SOMETHING AWFUL. MADE GRINDING SOUND AND STILL HAD BAD SMELL, KNEW WE HAD TO DRIVE IT BACK TO THE PLACE WE ARE STAYING AT. HAD HAZARD LIGHTS ON AND ONLY DROVE 10-15 MPH BECAUSE OF THE SOUND AND BECAUSE OF HOW SCARY IT WAS. KNEW SOMETHING BAD WAS HAPPENING TO OUR CAR. BRAKES AT THIS POINT PRACTICALLY WENT OUT. WOULD NOT HAVE TO PRESS BRAKES TO STOP VEHICLE AT A RED LIGHT, THE CAR WOULD JUST STOP. STEERING WHEEL WAS NOT EVEN, BUT MORE OR LESS 90 DEGREES TO THE RIGHT. PULLED INTO THE NEIGHBORHOOD AND INTO THE DRIVEWAY AND A CAR LEAVING THE STREET SAW THAT OUR VEHICLE AT THIS POINT WAS ON FIRE! EXTINGUISH FIRE (SINCE IT WAS A GAS FIRE) AND LOOKED AT THE DAMAGE. LOOKS LIKE THE FRONT DRIVER SIDE WASN'T EVEN CONNECTED TO ANYTHING. DO NOT KNOW HOW OR WHEN FIRE STARTED BUT THE FLAMES WHEN WE NOTICED WERE ABOUT 1 FOOT TALL AND WIDE BY THE INTERNAL DRIVER SIDE WHEEL. *TR
Suspension, Seat belts, Structure, Aug 7, 2014
THE BODY MOUNT INSULATORS DETERIORATED AND THE BODY COULD COME LOOSE FROM THE CHASSIS. FORD WANTS OVER 3000 DOLLARS FOR THIS REPAIR WHICH IS AN OBVIOUS MATERIAL FLAW. *TR
Power train, Jul 31, 2014
TL* THE CONTACT OWNS A 2002 FORD EXPLORER. THE CONTACT STATED THAT WHILE PARKING, THE SHIFT SELECTOR FRACTURED WHILE ATTEMPTING TO SHIFT FROM DRIVE TO PARK. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 140,000.
Structure, Latches/locks/linkages, Jul 27, 2014
REAR DOOR GLASS HATCH HINGES CAME OFF.THIS WAS MY WIFES VEHICLE DRIVEN VERY LITTLE UNTIL SHE PASSED AWAY 2009.THEN IT WAS DRIVEN EVEN LESS. BACK HATCH GLASS WAS NEVER USED AS FAR AS I KNOW. SHE ALWAYS USED THE METAL DOOR. I DROVE IT TO GROCERY STORE,PUT GROCERIES IN BACK USING LARGE DOOR. WHEN I GOT HOME I JUST GRABBED GLASS HATCH HANDLE BY MISTAKE,IT CAME OFF IN MY HAND.BOTH HINGES WERE BROKEN. I DON'T KNOW FOR HOW LONG,THE LATCH WAS ALL THAT KEPT IT IN PLACE.WHEN THE LATCH OPENED IT EXPLODED OUTWARD ,RESULTING IN BADLY DAMAGED PAINT AND BOTH REAR DEFROSTER WIRES TO BE TORN OFF GLASS.LUCKILY IT WAS ME AND NOT MY WIFE,COULD HAVE BEEN A LOT WORSE.LIFT CYLINDERS WERE SO STRONG I COULD NOT PUT IT BACK IN PLACE,HAD TO YELL FOR NEIGHBORS FOR HELP!HAD IT REPAIRED LOCAL FORD DEALER.TOLD ME ABOUT RECALL FOR MODELS EXCEPT SPORT.NO RECALL FOR IT.$150.50(NOT INCLUDING PAINT) FOR REPAIRS & 10 DAYS @ DEALER.IT NOW HAS 71,800 MILES GLASS HATCH NEVER USED,IT HAS BROKEN DRIVERS SIDE HINGE AGAIN.07/28/2014.HAVE NOT CONTACTED DEALER AGAIN AS OF THIS TIME. BUT I PLAN TO EXPRESS MY CONCERNS FOR SUCH INADEQUATE REPLACEMENT PARTS. ANY HELP WOULD BE APPRECIATED.THIS VEHICLE WAS PURCHASED NEW, NEVER ABUSED AND WELL MAINTAINED. *JS
Visibility, Structure, Jul 24, 2014
BACK TAILGATE PANEL WAS CRACKED (DEFECT) AND THE BACK WINDOW JUST EXPLODED WHEN THE TAILGATE WAS OPEN. *TR
Structure, Jul 23, 2014
WHILE OPENING MY REAR HATCH WINDOW TO LOAD GROCERIES I NOTICED THE TOP RIGHT HINGE HAD DETACHED FROM THE CAR, LEAVING THE GLASS HATCH HANGING BY A SINGLE HINGE. WHEN I GOT HOME I GOOGLED THE PROBLEM AND DISCOVERED RECALL #04S20 AND MENTIONED IT TO MY DEALER WHEN I TOOK MY CAR IN FOR SERVICING. THEY SAID MY CAR WAS NOT INCLUDED, SO I CALLED FORD AND THEY AGREED. EVEN THOUGH THE RECALL SPECIFIES "ALL FORD EXPLORER MODELS" THEY SAY MINE IS THE 2-DOOR "SPORT" EDITION AND SO ISN'T INCLUDED EVEN THOUGH THE HATCH IS IDENTICAL (I'VE OWNED BOTH). THIS IS AN EXPENSIVE REPAIR AND THIS IS THE 2ND TIME I'VE HAD THIS PROBLEM (THE OTHER HINGE BROKE 2 YEARS AGO). I'D APPRECIATE IT IF YOU COULD DETERMINE IF THE 2-DOOR MODELS ARE SUFFICIENTLY DIFFERENT THAT THEY CAN BE EXEMPTED FROM THIS RECALL, AND IF THEY SHOULD BE INCLUDED TELL ME HOW TO PROCEED. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Power train, Jul 14, 2014
PULLED INTO A PARKING SPACE (FLAT SURFACE) AND ATTEMPTED TO PUT THE CAR INTO PARK AND THE GEARSHIFT LEVER BROKE OFF INTO MY HAND. THE SAME THING HAPPEN ABOUT A YEAR AGO, AND OUR MECHANIC REPLACED THE DEFECTIVE PARTS. *TR
Power train, Electrical system, Jul 5, 2014
MY GEAR SHIFT BROKE AS I WAS PUTTING INTO GEAR AND IT JUST FELL INTO MY HANDS IT BROKE INTO TWO HALF A PIECE THAT SHOULD NOT BROKE AND AS I WAS GOING SOMEWHERE THE TRUCK JUST STARTING GOING CRAZY THE LIGHTS WAS FLASHING ON AND OFF THE ALARMS WAS GOING OF THE LIGHTS FLASHIN,SOMETIMES IN THE MIDDLE OF THE NIGHT THE ALARM JUST GOES OFF ON IT ON WE SEE ALL THIS HAPPEN AND NO ONE IS BY THE TRUCK NO CATS DOGS NOTHING. *TR
Steering, Jul 3, 2014
TL* THE CONTACT OWNS A 2002 FORD EXPLORER. THE CONTACT WAS ATTEMPTING TO EXIT THE DRIVEWAY WHEN THE STEERING WHEEL FRACTURED. THE DEALER REPLACED THE STEERING WHEEL. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 130,000. UPDATED 09/05/14*LJ UPDATED 09/11/2014 *JS
Power train, Jun 26, 2014
TL* THE CONTACT OWNS A 2002 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE WOULD SUDDENLY HESITATE AND THE SPEED WOULD DECELERATE. THE CONTACT INDICATED THAT THE CHECK TRANSMISSION SENSOR LIGHT AND OVER DRIVE LIGHT HAD ILUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE TRANSMISSION WAS FAULTY. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT BUT NO SOLUTION WAS OFFERED. THE FAILURE MILEAGE WAS 150,000.
Power train, Jun 24, 2014
DRIVING IN RUSH HOUR TRAFFIC, TRANSMISSION WOULD NOT SHIFT INTO HIGH. I WAS ALMOST HIT BY A SEMI TRUCK ON I-94 NEAR I-275. *TR
Steering, Jun 18, 2014
SHIFTER LEVER BROKE OFF. *TR
Electrical system, Jun 16, 2014
ALARM STARTED GOING OFF AND THE BACK GATE DOOR BECAME UNLOCKED WITHOUT ANYONE BEING IN OR NEAR THE SUV SATURDAY NIGHT JUNE 14,2014. IT CONTINUED OFF AND ON EVERY TWENTY MINUTES, THEN TEN MINUTES. THIS WAS AT NIGHT ABOUT SEVEN O'CLOCK. IT STOPPED. THE NEXT DAY ON SUNDAY AFTER COMING BACK FROM A RELIGIOUS MEETING IT STARTED GOING OFF AGAIN WITH AN ERROR MESSAGE STATING THAT THE REAR BACK DOOR WAS OPEN. IT WAS AND I DIDN'T OPEN IT. I OPENED AND CLOSED EVERY DOOR AFTER USING THE PANIC BUTTON TO STOP THE ALARM. IT STARTS WITH THE LIGHTS COMING ON IN THE FRONT OF THE SUV, THEN THE ALARM WILL START BEEPING VERY LOUDLY WITHOUT STOPPING. THIS GOES ON FOR ABOUT A GOOD HOUR EVERY DAY SINCE WITH YOU GOING OUT THERE TO TURN IT OFF WITH THE PANIC BUTTON. I DID SOME RESEARCH TO FIND OUT WHAT IS MAKING THIS HAPPEN AND I WAS AMAZED AND SHOCKED AT HOW MANY 2002 FORD EXPLORERS AND OTHER FORD CARS, TRUCKS, AND SUVS HAS THIS PROBLEM. IT IS A VERY DANGEROUS PROBLEM BECAUSE NO ONE KNOWS HOW TO STOP IT AND IT ENDS UP WITH YOU HAVING TO LEAVE YOUR DOORS UNLOCKED TO STOP THE ALARM FROM GOING OFF AND KILLING YOUR BATTERY. I HAVE LIMITED RESOURCES AND I WANT TO KNOW WHY FORD HAS NOT ADDRESSED THIS PROBLEM SINCE IT AFFECTS SO MANY PEOPLE. I DON'T WISH TO DIE BEFORE SOMETHING IS DONE ABOUT THIS DANGEROUS PROBLEM. I DON'T WANT MY FAMILY OR ME WORRYING ABOUT MY SAFETY BECAUSE IF ANYONE FINDS OUT MY SUV IS UNLOCKED, I COULD BE ACCOSTED, OR ROBBED OR KILLED AND NOTHING WILL BE DONE ABOUT IT BECAUSE THE AUTO INSURANCE PEOPLE SAY YOUR CAR HAS TO BE LOCKED. PLEASE ADDRESS THIS DANGEROUS PROBLEM WITH FORD SINCE NO ONE ELSE SEEMS TO CARE BECAUSE I KNOW FOR A FACT THE FORD PEOPLE DON'T. BY THE WAY IT GOING ON NOW! THANK YOU. *TR
Power train, Air bags, Jun 16, 2014
FIRST OF ALL THE TRANSMISSION IS STARTING TO SLIP. WHEN ACCELERATING THE CAR TRANSMISSION SLIPS WHEN SHIFTING INTO THIRD GEAR. TOOK TO DEALER AND THEY SAID THEY NEED TO REPAIR THE TRANSMISSION. THE SECOND PROBLEM IS THAT THE AIRBAG LIGHT CAME ON. I HAVE NOT BEEN IN A ACCIDENT OR ANYTHING. IT JUST CAME ON. I READ ONLINE THAT IF THE LIGHT IS ON AND I AM IN AN ACCIDENT THE AIRBAGS WONT DEPLOY. THIS SEEMS REALLY DANGEROUS AND SHOULD BE COVER UNDER WARRANTY. *TR
Electrical system, Air bags, Seat belts, Jun 16, 2014
I HAVE A 2002 FORD EXPLORER AND IT HAS NOT BEEN WRECKED AND I HAD THE LIGHT THAT COME ON IN MY DASH AND THEY SAID THAT MY SEAT BELT PRETENTIONER WAS GONE IN MY SEAT BELT. *TR
Power train, Engine, Jun 11, 2014
TIMING CHAIN PROBLEMS; BACK CHAIN 'PLASTIC' TENSOR BROKE AND AFFECTED CRITICALLY ENTIRE ENGINE. MANY PEOPLE WITH THE SAME PROBLEM. TRANSMISSION SOLENOID PROBLEMS; SHIFT ROUGH FROM 1ST TO 2ND. PUT NEW SOLENOID BLOCK, PROBLEM STILL THERE. FORD DOES NOT KNOW WHAT THE PROBLEM IS. MANY PEOPLE WITH THE SAME PROBLEM. *TR
Structure, Jun 9, 2014
THE REAR HATCH IS SPLITTING DOWN THE MIDDLE NEAR THE WINDSHIELD WIPERS. THE METAL IS COMING APART AND MAY FLY OFF DURING HIGH RATES OF SPEED CAUSING AN ACCIDENT. THIS EMAIL IS TO PREVENT AN ACCIDENT WHICH MAY OCCUR. I AM AWARE OF A PENDING LAWSUIT REGARDING COSMETIC DEFECTS BUT WOULD LIKE YOU TO KNOW THE POSSIBILITY OF AN ACCIDENT OCCURRING ONCE THE METAL SEPARATES AT HIGH RATES OF SPEED ON THE INTERSTATE. THIS IS ALSO A PAPER TRAIL IN CASE I AM THE TRUCK THE CAUSES THE ACCIDENT. *TR
Power train, Jun 8, 2014
I GOT MY EXPLORER NOT TOO LONG AGO. IT WAS RUNNING GREAT THEN OUT OF NO WHERE THE O/D LIGHT KEEPS FLASHING AND MY TRANSMISSION STARTS TO SLIP. A LOT OF PEOPLE ARE HAVING THIS PROBLEM AND I THINK FORD NEEDS TO STEP UP AND TAKE CARE OF THIS BECAUSE I HAVE KIDS AND THIS IS MY ONLY CAR AND I AM ON A FIXED INCOME. IF FORD DOES NOT WANT TO FIX THESE PROBLEMS OR RECALL THEM THEN NEVER WILL I BUY A FORD AGAIN. *TR
Structure, Jun 2, 2014
SHORTLY AFTER PURCHASING MY FORD EXPLORER FROM THE DEALERSHIP I NOTICED A SMALL CRACK IN THE REAR HATCH AROUND THE FORD EMBLEM. THIS PART OF THE HATCH IS ALSO CONNECTED TO THE REAR GLASS WINDOW THAT LIFTS OPEN. I TOOK MY VEHICLE BACK TO THE DEALERSHIP AND THEY TOLD ME IT WAS A MANUFACTURERS DEFECT AND WILL BE RECALLED EVENTUALLY SO I SHOULD KEEP CHECKING BACK. THE RECALL NEVER HAPPENED AND AFTER 10 PLUS YEARS THE CRACK GOT LARGER LETTING MOISTURE IN AND RUSTING. MEANWHILE I WAS NOTICING THE MAJORITY OF FORD EXPLORERS FROM THAT YEAR HAD THE SAME CRACK ON THE REAR HATCH IN THE SAME PLACE! ABOUT 2 WEEKS AGO I WENT TO SIMPLY OPEN THE REAR HATCH AND THE GLASS WINDOW BUCKLED AND SHATTERED WITH AN EXPLODING SOUND SIMILAR TO A GUNSHOT. GLASS WAS EVERYWHERE! THE PIECE WITH THE CRACK LITERALLY BROKE IN HALF. THANKFULLY NO ONE GOT HURT, BUT IF MY KIDS WERE IN THE CAR OR MY FACE WAS ANY CLOSER IT COULD HAVE BEEN A DISASTER. I TRULY BELIEVE FORD NEEDS TO TAKE RESPONSIBILITY FOR THEIR DEFECTIVE REAR HATCHES IN THESE MODELS TO PREVENT INJURIES. *TR
Power train, Equipment, May 28, 2014
I WAS AT THE SCHOOL TO PICK UP MY KIDS,I TURN ON MY FORD EXPLORER 2002 XLT V6 4.0 TO DRIVE AND THEN THE SHIFT LEVER BROKE ON NEUTRAL POSITION, THAT WAS DANGEROUS BECAUSE, HOW WILL I PARK MY CAR? IF IT HAPPENED ON A DOWNHILL, HOW ARE WE GOING TO PARK IT.IS THAT POSSIBLE TO MAKE A RECALL A FORD COMPANY TO FIX THE CAR. *TR