2002 Ford Explorer
Problems, recalls and owner-reported issues
Power train is the leading concern among 3,613 owner complaints filed for this model year. This is the highest complaint count among 26 Explorer model years with reports.
Of the 2002 reports, 163 involved a crash and 71 involved a fire. 213 people were injured and 6 people died.
What owners report most often
Recalls and investigations
Vehicle speed controlOct 13, 2009
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Campaign 09V399000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Visibility, glass, side/rearDec 11, 2007
CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.
SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER'S GLASS. WHOLESALE CUSTOMERS CAN CONTACT SAFELITE'S WHOLESALE DIVISION, SERVICE AUTOGLASS TOLL FREE AT 1-888-246-6298. THE RECALL BEGAN ON JANUARY 15, 2008.
Campaign 07E104000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Structure, body, hatchback/liftgate, hinge and attachmentsSep 13, 2004
ON CERTAIN SPORT UTILITY VEHICLES, THE LIFTGATE GLASS STRUT MAY BECOME DISENGAGED OR THE HINGE MAY FRACTURE ALLOWING THE GLASS TO FALL AND POSSIBLY BREAK.
IF THE HINGE SHOULD FRACTURE, THERE IS A POTENTIAL FOR THE GLASS TO FALL AND ULTIMATELY BREAK AND PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE THE LIFTGATE GLASS STRUT BRACKETS AND GLASS HINGES REPLACED. FOR THE VEHICLES BUILT FROM AUGUST 1, 2000 THROUGH MARCH 3, 2002, THE DEALERS WILL REPLACE THE HINGES AND LIFTGATE STRUT BRACKET. ON VEHICLES BUILT FROM MARCH 3, 2002 THROUGH JUNE 23, 2003, THE DEALERS WILL ONLY REPLACE THE HINGES. THE RECALL BEGAN ON SEPTEMBER 30, 2004. A POSTCARD WAS SENT TO OWNERS ON DECEMBER 27, 2004, ADVISING THEM THAT PARTS ARE NOW AVAILABLE. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V442000 on NHTSA.gov
StructureMar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
Campaign 03V094000 on NHTSA.gov
Tires, sidewallMay 24, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE RIGHT SIDE TIRES MAY HAVE HORIZONTAL CUTS ON THE EDGE OF THE TREAD THAT COULD HAVE OCCURRED DURING VEHICLE ASSEMBLY.
OVER TIME, THE TIRE COULD FAIL, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE TIRES AND, IF ANY SLICES ARE FOUND, THE CUT TIRES WILL BE REPLACED. OWNER NOTIFICATION BEGAN JUNE 7, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 01V171000 on NHTSA.gov
Visibility, glass, side/rearApr 10, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2002 FORD EXPLORER AND MERCURY MONTAINEER SPORT UTILITY VEHICLES. THE BRACKETS CONNECTING THE LEFT CYLINDERS TO EACH SIDE OF THE LIFTGATE GLASS COULD ROTATE OUT OF POSITION IF EITHER THE URETHANE BOND OR TORQUE ARE NOT SUFFICIENT.
ROTATION OF THE BRACKETS COULD POTENTIALLY CAUSE THE LIFT CYLINDERS TO DETACH FROM THE GLASS OR, IN SOME CASES, COULD POTENTIALLY CAUSE THE LIFTGATE GLASS TO BREAK. EITHER CONDITION IS MOST LIKELY TO OCCUR WHEN THE GLASS IS BEING CLOSED.
FORD DEALERS WILL INSPECT THE VEHICLES FOR THE POSITION OF BOTH THE LEFT AND RIGHT LIFTGATGE GLASS LIFT CYLINDER BRACKETS. IF THE BRACKETS ARE IN THE PROPER POSITION, THE BRACKET RETAINERS WILL BE TIGHTENED TO A HIGHER TORQUE. IN CASES WHERE THE BRACKET IS NOT PROPERLY POSITION, THE BRACKET MUST BE RE-ALIGNED.
Campaign 01I010000 on NHTSA.gov
Representative owner complaints
3,613 reports, newest first.
Power train, Dec 17, 2014
TL* THE CONTACT OWNS A 2002 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 5 MPH, THE GEAR SHIFT FRACTURED AND ONLY OPERATED IN REVERSE. THE VEHICLE WAS TOWED TO THE DEALER BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 250,000.
Power train, Engine, Dec 17, 2014
OVERDRIVE LIGHT CAME ON. CHECK TRANSMISSION LIGHT CAME ON. THE TRUCK SUDDENLY STARTED SCREECHING LOUDLY, NEARLY CAUSED AN ACCIDENT WHILE GOING TO THE AIRPORT ON AN EXPRESSWAY. *TR
Power train, Dec 17, 2014
I GOT IN IT AFTER 15 MINUTES OF IT WARMING UP, PULLED OUT OF THE DRIVE AND THE RPM WENT TO 3000RPM BEFORE IT SHIFTED IN SECOND GEAR. THEN THE O/D LIGHT STARTED FLASHING ON AND OFF, NEXT THE CHECK TRANSMISSION INDICATOR LIGHT CAME ON. WENT HOME AND CALLED A MECHANIC, TOOK IT TO HIM AND THEN BAD NEWS. IT HAS WORKED PERFECTLY UP TO THIS POINT. *TR
Steering, Air bags, Vehicle speed control, Service brakes, Dec 16, 2014, crash, fire
TL* THE CONTACT OWNS A 2002 FORD EXPLORER. THE CONTACT STATED THAT WHILE IN REVERSE, THE VEHICLE ACCELERATED INDEPENDENTLY. ADDITIONALLY, THE BRAKE PEDAL WAS DEPRESSED BUT FAILED TO RESPOND AND THE STEERING WHEEL SEIZED. AS A RESULT, THE VEHICLE CRASHED INTO TREES THEN WENT FORWARD INDEPENDENTLY CRASHING INTO SHRUBS, A FENCE, AND A BUILDING. IN ADDITION, THE AIR BAGS FAILED TO DEPLOY AND SMOKE STARTED TO EMIT FROM THE FRONT OF THE VEHICLE. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED BRUISE AND NECK AND HEAD INJURIES THAT DID NOT REQUIRE MEDICAL ATTENTION. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
Power train, Dec 14, 2014
AFTER MAKING ABRUPT STOP HALF MILE BEFORE INCIDENT TO AVOID ACCIDENT, I CAME TO A STOP AT A STOP SIGN. WHEN I WENT TO ENTER A MAIN HIGHWAY, MY TRANSMISSION SLIPPED AND LEFT ME NON MOBILE IN THE INTERSECTION, ALMOST CAUSING ME TO GET HIT BROADSIDE. HAD TO GET OUT IN TRAFFIC TO PUSH MY VEHICLE OFF HIGHWAY. MANY EXACT TRANSMISSION PROBLEMS FOR THIS VEHICLE ALREADY POSTED ON INTERNET I SEE. VERY DANGEROUS. *TR
Vehicle speed control, Dec 12, 2014, crash
DROVE CAR TO TIRE DEALER FOR WHEEL ALIGNMENT. PARKED AND LEFT FOR THEM TO WORK ON. THE NEXT DAY,DEC 10,2014, THE SERVICE TECH DROVE THE CAR FOR A TEST RIDE TO CHECK THE ALIGNMENT BEFORE HE ADJUSTED. HE THEN DROVE INTO THE BAY AND APPLIED FOOT PRESSURE TO THE GAS PEDDLE TO GET ONTO THE ALIGNMENT RAMP. THE PEDDLE STUCK AT HIGH RPMS , 4000+, . AS SUCH THE CAR RAN OFF OF THE RAMP , HE APPLIED BRAKES, TO NO AVAIL, SHUT CAR OFF AT SAME TIME. WHICH STOPPED THE CAR, BUT NOT BEFORE IT CRASHED INTO THE ALIGNMENT MACHINE AND TIRES. CAR WAS HUNG UP ON PART OF THE RAMP HAD TO BE JACKED OFF OF RAMP. FRONT BUMPER DAMAGED, CROSS MEMBER UNDER TRANS PAN BENT, LEFT RARE LOWER CONTROL ARM BENT..TIRE DEALER HAS SENT THE CAR TO FORD DEALER, ON DEC 11,2014 I SPOKE WITH FORD DEALER AND THE HAVE NEVER HAD A PROBLEM LIKE THIS BEFORE. TOLD HIM OF YOUR REPORT PE 05037 AND YOUR LETTER TO FORD. . SINCE YOUR LETTER TO FORD THE INTERNET HAS AT LEAST 25 REPORTS OF THIS SAME PROBLEM MOST WITH ACCIDENTS. THERE MAY ONLY BE 240,000 OF THIS CARS ,AS YOUR REPORT NOTES, BUT THIS PROBLEM CAN CAUSE A DEATH .THIS CAR WAS MADE WITH IN THE TIME PERIOD STATED IN YOU REPORT. THE FIX IS TO REPLACE THE CABLE. I TOLD FORD THAT I WOULD NOT ACCEPT THE CAR UNLESS THE CABLE WAS REPLACED. ON THE OTHER HAND I WOULD EXPECT YOU TO FOLLOW UP ON THIS DEADLY PROBLEM. *TR
Engine, Nov 24, 2014
TL* THE CONTACT OWNS A 2002 FORD EXPLORER SPORT. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, THE ENGINE LIGHT ILLUMINATED AS THE VEHICLE STARTED TO OVERHEAT AND STALLED. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN DIAGNOSED THAT THE WATER PUMP AND HEATING CORE NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 183,000. UPDATED 1/16/15*CN UPDATED 9/7/2017*CN
Structure, Nov 24, 2014
HUGE CRACK ON BACK PANEL BELOW WINDOW!!!!!!!!!!!! *TR
Seats, Nov 19, 2014
SEAT BRACKET BROKE WHEN HITTING THE BRAKES WHEN A DEER JUMPED OUT IN FRONT OF ME. *TR
Structure, Nov 4, 2014
TL* THE CONTACT OWNS A 2002 FORD EXPLORER SPORT. THE CONTACT STATED THAT THE REAR GLASS HINGES WERE NOT ATTACHED TO THE TAILGATE PROPERLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 215,260.
Structure, Nov 4, 2014
THERE WAS A RECALL FOR FAULTY HINGES YEARS BACK, FORD REPLACED. I NOTICED FAULTY HINGE WHEN WAXING VEHICLE, HINGE IS ASKEW. CALLED FORD CUSTOMER SERVICE, VERIFIED IT WOULD NEED REPLACING OR GLASS WINDOW COULD FALL OFF, INFORMED I WOULD HAVE TO PAY FOR REPAIR. SINCE THE FAULTY HINGE IS THEIR PRODUCT, I THINK THEY ARE RESPONSIBLE, AND IT IS A SAFETY HAZARD. I HAVE HAD THIS CAR SERVICED EVERY 3 MONTHS SINCE I BOUGHT IT. IT IS WELL MAINTAINED, I HAVE SPENT A FORTUNE REPLACING FAULTY FORD PARTS. THE GLASS HINGE IS A FORD HAZARD THAT I BELIEVE FORD IS RESPONSIBLE FOR. *TR
Power train, Nov 3, 2014
A PART THAT SHOULD NEVER FAIL, THE SHIFTER HANDLE BROKE OFF. THIS APPEARS TO BE A COMMON AND EXPENSIVE FAILURE. *TR
Structure, Visibility/wiper, Nov 2, 2014
CRACK IN REAR LIFT GATE PANEL THAT LED TO SHATTERED REAR WINDOW UPON NORMAL CLOSING. *TR
Vehicle speed control, Oct 30, 2014
TL* THE CONTACT OWNS A 2002 FORD EXPLORER. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 09V399000 (VEHICLE SPEED CONTROL) AND THE CONTACT INDICATED THAT AN AUTHORIZED DEALER REPLACED THE WIRING HARNESS BUT DID NOT INSPECT THE ABS CONTROL MODULE CONNECTOR TO DETERMINE IF THE VEHICLE NEEDED TO BE REMEDIED FOR THE RECALL. THE CONTACT REPORTED THE SAFETY CONCERN TO THE MANUFACTURER AND THEY WOULD NOT COMPLY. THE VEHICLE WAS NOT FULLY REPAIRED UNDER THE RECALL REMEDY. THE MANUFACTURER WAS NOTIFIED OF THE SAFETY CONCERN AND PROVIDED NO REMEDY. THE APPROXIMATE FAILURE MILEAGE WAS NOT AVAILABLE.
Power train, Oct 28, 2014
PARKED IN PARKING LOT ON LEVEL SURFACE. STARTED ENGINE WENT TO PUT IN REVERSE AND SHIFTING LEVER FELL OFF. CONTACTED FORD INSTEAD OF SELLING BROKEN PART WANTED TO SELL COMPLETE STEERING COLUMN. *TR
Steering, Power train, Oct 20, 2014
THE HANDLE TO SHIFT THE MANUAL TRANSMISSION FROM PARK TO REVERSE BROKE OFF AT THE METAL PART INSIDE THE STEERING COLUMN. THIS IS COULD HAVE BEEN VERY DANGEROUS IF I WAS DRIVING! FORD STATES THEY NO LONGER PRODUCE THE PART. *TR
Structure, Oct 18, 2014
MY DAUGHTER WENT TO OPEN MY REAR HATCH AND THE WINDOW FELL. THE HINGE COMPLETELY DETACHED FROM THE CAR. I WENT TO FORD TO HAVE THEM LOOK AT IT THEY STATED THAT IT WAS A RECALL ITEM BUT THAT IT HAD ALREADY BEEN FIXED IN 2005. I ASKED IF IT HAD BEEN FIXED WHY WOULD THE SAME PROBLEM OCCUR. THEY COULDN'T GIVE ME AN ANSWER. ALL THEY SAID WAS THAT THEY ONLY PAY FOR THE FIRST OCCURRENCE NOT AND SUBSEQUENT OCCURRENCES. MY ISSUE IS THAT IF AN ITEM CONTINUES TO BREAK THAT IS NO LONGER AND ISSUE WITH THAT ITEM ITS AND ISSUE WITH THE DESIGN OF THE ITEM. THIS IS A SAFETY CONCERN. WHAT IF THE GLASS FELL ON MY DAUGHTER OR SHATTERED ON HER. I DON'T SEE WHY I HAVE TO REPLACE A FAULTY FORD ISSUE. *TR
Power train, Oct 16, 2014
WENT TO PUT VEHICLE IN RESERVE AND GEAR SHIFT ON THE COLUMN FELL IN MY HAND, COMPLETELY SNAPPED. *TR
Vehicle speed control, Service brakes, Fuel/propulsion system, Oct 14, 2014
WHEN BRAKING VEHICLE ACCELERATES. COULD NOT STOP HAD TO PUT IN N AND IT STALLED BEFORE HITTING A STORE FRONT AND A SECOND TIME ON THE WAY HOME AT A RED LIGHT. *TR
Structure, Sep 25, 2014
TL* THE CONTACT OWNS A 2002 FORD EXPLORER. THE CONTACT STATED THAT THE VEHICLE WAS RECENTLY REPAIRED ACCORDING TO NHTSA CAMPAIGN NUMBER: 04V442000 (STRUCTURE), BUT THE FAILURE WAS NOT REMEDIED. THE LIFTGATE HINGE FRACTURED AND CAUSED THE GLASS TO SHIFT. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 100,000.
Structure, Sep 20, 2014
PAINT JOB ON ENGINE HOOD IS BUBBLING UP. SUV HAS BEEN REGULARLY WASHED AND WAXED; SO ONE WOULD NOT EXPECT PROBLEMS WITH THE PAINT JOB. BASED UPON INTERNET RESEARCH, FORD HAS PAINT JOB ISSUES WITH VEHICLES SOLD FROM 2000-2005. *TR
Electrical system, Exterior lighting, Service brakes, Sep 18, 2014
BRAKE LIGHTS AND TURN SIGNALS STOPPED WORKING. PROBLEM TRACED TO TILT STEERING AND MULTI-FUNCTION SWITCH WIRING HARNESS. BROKEN RETAINER CLIP ALLOWS WIRES TO BE PULLED FROM CONNECTOR BREAKING CONNECTION FOR BRAKE LIGHT AND TURN SIGNAL. ONCE TILT STEERING IS ENGAGED CONNECTION IS BROKEN AND WIRES DO NOT STAY CONNECTED AND LOSS OF BRAKE LIGHTS AND TURN SIGNAL IS THE RESULT. THIS COULD LEAD TO ACCIDENT, INJURY AND OR LOSS OF LIFE DUE TO POOR DESIGN. THE BRAKE LIGHT PROBLEM HAD ELUDED ME UNTIL I DID A GOOGLE SEARCH ON THE INTERNET WHICH RESULTED IN HUNDREDS, IF NOT THOUSANDS, OF PEOPLE ALL EXPERIENCING THE SAME PROBLEM. CALLING THE FORD DEALER AND PROVIDING THE PART NUMBER (E6DB14489DA) ON THE CONNECTOR PROVED FUTILE IN HAVING THEM EVEN IDENTIFY THE PART YET I WAS ABLE TO FIND THE PART ON THE INTERNET JUST BE A GOOGLE SEARCH. AT THIS POINT, I AM UNABLE TO LOCATE A REPLACEMENT PART SO I AM FORCED TO HOT GLUE THE WIRES INTO THE BROKEN CONNECTOR IN ORDER TO DRIVE MY VEHICLE. *TR
Power train, Sep 12, 2014
WHEN IS THE NHTSA GOING TO ADDRESS THE CHRONIC ISSUES WITH THE 2002-2005 FORD EXPLORER AUTOMATIC TRANSMISSIONS? IT IS COMMON KNOWLEDGE ( INCLUDING BY FORD) THAT THESE TRANSMISSIONS ALL FAIL ANYWHERE FROM 50,000 MILES UP TO LESS THAN 150,000 MILES. TOWING WITH THIS VEHICLE HAS NOTHING TO DO WITH THE ISSUE.THE MARKET IS FLOODED WITH THESE BROKEN EXPLORERS AND THEY ARE THE REGULAR CUSTOMERS AT THE REPAIR SHOPS IF PEOPLE DON'T JUNK THEM AND CAN AFFORD TO HAVE THEM FIXED. THEY ARE A HAZARD ON THE ROAD WHEN THE VEHICLE SUDDENLY FAILS TO MOVE IN TRAFFIC OR FROM A STOP AT AN INTERSECTION. I WAS NEARLY REAR ENDED WHEN MY VEHICLE STARTED INTO A BUSY INTERSECTION AND THE TRANSMISSION FAILED LEAVING ME COASTING IN TRAFFIC. I AM SURE THAT MANY OTHER COMPLAINTS HAVE BEEN LODGED AGAINST THESE VEHICLES AND THAT SERIOUS INJURY HAS OCCURRED AS A RESULT OF THE TRANSMISSION FAILURES. THE INTERNET EVEN SELLS QUESTIONABLE REPAIR FIXES FOR THESE TRANSMISSIONS. *TR
Air bags, Equipment adaptive/mobility, Sep 8, 2014, crash
I WAS IN A ACCIDENT ON AUGUST 21, 2014. TWO OR MORE DEER'S RAN OUT IN FRONT OF MY 2002 FORD EXPLORER AND I RAN OFF THE ROAD HITTING A POLE. IT CRUSHED THE WHOLE FRONT END AND MY AIRBAG NEVER DEPLOYED. MY TRUCK IS A TOTAL LOSS AND I DID HAVE ON MY SEAT BELT BUT THE AIRBAG SHOULD OF DEPLOYED. *TR
Fuel/propulsion system, Sep 5, 2014
BROUGHT VEHICLE IN JAN 2014. EVERY SINCE FIRST DAY BROUGHT, HAD A PROBLEM WITH GETTING FUEL INTO VEHICLE WITHOUT FUEL PUMP CLICKING AS IF VEHICLE IS FULL. THIS HAPPENS AT ABOUT EVERY FUEL STATION I GO TO. THIS IS VERY FRUSTRATING. BROUGHT PLENTY OF FORDS, BUT THIS IS THE FIRST ONE THAT DOES THIS. BEFORE I GET A FEW OUNCES OF FUEL INTO THE VEHICLE IT WILL CLICK AND CONTINUE DOING THIS AS LONG AS IM TRYING TO PUT IN FUEL. LOVE VEHICLE BUT HATE IT BECAUSE OF THIS. I READ ON OTHERS HAVING SAME PROBLEM. CAN SOMEONE PLEASE HELP US ALL./ THIS IS DEFINITE A RECALL. [XXX] (RETIRED VET / RETIRED U. S. POSTAL SVC. ). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR