2002 Ford Explorer
Problems, recalls and owner-reported issues
Power train is the leading concern among 3,613 owner complaints filed for this model year. This is the highest complaint count among 26 Explorer model years with reports.
Of the 2002 reports, 163 involved a crash and 71 involved a fire. 213 people were injured and 6 people died.
What owners report most often
Recalls and investigations
Vehicle speed controlOct 13, 2009
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Campaign 09V399000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Visibility, glass, side/rearDec 11, 2007
CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.
SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER'S GLASS. WHOLESALE CUSTOMERS CAN CONTACT SAFELITE'S WHOLESALE DIVISION, SERVICE AUTOGLASS TOLL FREE AT 1-888-246-6298. THE RECALL BEGAN ON JANUARY 15, 2008.
Campaign 07E104000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Structure, body, hatchback/liftgate, hinge and attachmentsSep 13, 2004
ON CERTAIN SPORT UTILITY VEHICLES, THE LIFTGATE GLASS STRUT MAY BECOME DISENGAGED OR THE HINGE MAY FRACTURE ALLOWING THE GLASS TO FALL AND POSSIBLY BREAK.
IF THE HINGE SHOULD FRACTURE, THERE IS A POTENTIAL FOR THE GLASS TO FALL AND ULTIMATELY BREAK AND PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE THE LIFTGATE GLASS STRUT BRACKETS AND GLASS HINGES REPLACED. FOR THE VEHICLES BUILT FROM AUGUST 1, 2000 THROUGH MARCH 3, 2002, THE DEALERS WILL REPLACE THE HINGES AND LIFTGATE STRUT BRACKET. ON VEHICLES BUILT FROM MARCH 3, 2002 THROUGH JUNE 23, 2003, THE DEALERS WILL ONLY REPLACE THE HINGES. THE RECALL BEGAN ON SEPTEMBER 30, 2004. A POSTCARD WAS SENT TO OWNERS ON DECEMBER 27, 2004, ADVISING THEM THAT PARTS ARE NOW AVAILABLE. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V442000 on NHTSA.gov
StructureMar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
Campaign 03V094000 on NHTSA.gov
Tires, sidewallMay 24, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE RIGHT SIDE TIRES MAY HAVE HORIZONTAL CUTS ON THE EDGE OF THE TREAD THAT COULD HAVE OCCURRED DURING VEHICLE ASSEMBLY.
OVER TIME, THE TIRE COULD FAIL, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE TIRES AND, IF ANY SLICES ARE FOUND, THE CUT TIRES WILL BE REPLACED. OWNER NOTIFICATION BEGAN JUNE 7, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 01V171000 on NHTSA.gov
Visibility, glass, side/rearApr 10, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2002 FORD EXPLORER AND MERCURY MONTAINEER SPORT UTILITY VEHICLES. THE BRACKETS CONNECTING THE LEFT CYLINDERS TO EACH SIDE OF THE LIFTGATE GLASS COULD ROTATE OUT OF POSITION IF EITHER THE URETHANE BOND OR TORQUE ARE NOT SUFFICIENT.
ROTATION OF THE BRACKETS COULD POTENTIALLY CAUSE THE LIFT CYLINDERS TO DETACH FROM THE GLASS OR, IN SOME CASES, COULD POTENTIALLY CAUSE THE LIFTGATE GLASS TO BREAK. EITHER CONDITION IS MOST LIKELY TO OCCUR WHEN THE GLASS IS BEING CLOSED.
FORD DEALERS WILL INSPECT THE VEHICLES FOR THE POSITION OF BOTH THE LEFT AND RIGHT LIFTGATGE GLASS LIFT CYLINDER BRACKETS. IF THE BRACKETS ARE IN THE PROPER POSITION, THE BRACKET RETAINERS WILL BE TIGHTENED TO A HIGHER TORQUE. IN CASES WHERE THE BRACKET IS NOT PROPERLY POSITION, THE BRACKET MUST BE RE-ALIGNED.
Campaign 01I010000 on NHTSA.gov
Representative owner complaints
3,613 reports, newest first.
Suspension, Apr 13, 2010
TL*THE CONTACT OWNS A 2002 FORD EXPLORER. THE REAR COIL SPRINGS ON THE VEHICLE BROKE WHICH THE CONTACT WAS INFORMED OF DURING A BRAKE INSPECTION. THE DEALER STATED THAT THE COIL SPRINGS WERE THE SAME USED ON THE FORD TAURUS MODEL AND THAT THEY WERE AWARE OF THE FAILURES WITH THE SPRINGS. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 250,000.
Power train, Apr 13, 2010
2002 EXPLORER SHIFTED FUNNY FROM THE DAY I PURCHASED IT NEW. I FIGURED NATURE OF THE BEAST AS A 4X4. LITTLE DID I KNOW, THESE TRANSMISSIONS WERE JUNK FROM THE BEGINNING, AND NOW THEY ARE ALL FALLING APART. MINE SELF DESTRUCTED AT 61,000 MILES. AFTER THE REPAIR, IT STILL SHIFTED AS CRAPPY AS IT DID THE DAY I PURCHASED IT. NOW ONLY 10,000 MILES LATER, IT IS SHOWING SIGNS THAT FAILURE IS NEAR AGAIN. IF THESE TRANSMISSIONS ARE NOT RECALLED, I WILL NEVER PURCHASE ANOTHER FORD. *TR
Power train, Apr 10, 2010
SEALED TRANSMISSION IN 02 FORD EXPLORER. TANNY SHIFTS HARD THEN OVER DRIVE LIGHT FLASHES, STARTS SHIFTING INTO OD HARD THEN NOT AT ALL, THEN HARD THEN BACK AND FORTH ALOT. NO WAY TO CHECK FLUID. ALL FORD OFFERS IS A REBUILT AT 3000.00 DOLLARS. *TR
Visibility, Structure, Apr 9, 2010
THIS IS AN ACCIDENT WAITING O HAPPEN. MY PANEL BELOW THE REAR WINDOW IN 2002 EXPLORER MAY SOON FLY AND HIT ANOTHER CAR ON THE FREEWAY AND CAUSE A BIG ACCIDENT. THIS IS A PROBLEM FROM HUNDREDS OF OTHER FORD EXPLORERS. A RECALL SHOULD BE MADE BEFORE MAJOR ACCIDENTS HAPPEN BECAUSE OF THIS PROBLEM. *TR
Tires, Apr 7, 2010
TL*THE CONTACT OWNS A 2002 FORD EXPLORER. THE VEHICLE WAS EQUIPPED WITH GOODYEAR WRANGLER SRA TIRES. THE CONTACT WAS DRIVING APPROXIMATELY 50 MPH AND THE FRONT PASSENGER TIRE EXPLODED. THE VEHICLE WAS DRIVEN TO THE SIDE OF THE ROAD. THE FRONT PASSENGER TIRE WAS REPLACED WITH A SPARE TIRE. THE FAILURE AND CURRENT MILEAGES WERE 100,000.
Power train, Apr 7, 2010
1. O/D LIGHT STARTED FLASHING, CAR WAS JERKING WHEN SLOWING AND ACCELERATING. 2. ALMOST EVERY TIME STARTING AND STOPPING VEHICLE JERKS. 3. REMOVE AND REBUILD THE TRANSMISSION, FM68 TORQUE CONVERTER, TRANSMISSION OVERHAUL KIT, OVERDRIVE BAND ASSEMBLY, INTER BAND ASSEMBLY, SERVO BUSHING KIT, BUSHING KIT. AS OF APRIL 5TH 2010 O/D LIGHT FLASHING AGAIN AND VEHICLE JERKS WHEN SLOWING AND ACCELERATING. *TR
Power train, Apr 6, 2010
THE TRANSMISSION ON MY FORD EXPLORER WENT OUT AFTER THE OD LIGHT HAS BEEN BLINKING... FORD THE TO RECALL THE TRANSMISSION ON THIS EXPLORER IT IS REALLY A PROBLEM. *TR
Engine and engine cooling, Apr 6, 2010, fire
MY 2002 FORD EXPLORER BURST INTO FLAMES WHILE WE WERE MOVING, IN IT WERE SOME BELONGINGS. *TR
Structure, Apr 5, 2010
2002 FORD EXPLORER -- A CRACK APPEARS IN THE PANEL BELOW THE REAR TAILGATE WINDOW GLASS. *TR
Power train, Apr 5, 2010, crash
SHIFTER HANGS-UP WHEN TRYING TO PUT CAR IN PARK. WHEN CAR WAS NEW THE DEALER SAID THEY WOULD HAVE TO PULL THE TRANS. APART TO FIX IT BUT IN A FEW MONTHS THE BURR WOULD WEAR AND IT WOULD WORK FINE.(ANOTHER DEALER LIE). I THINK IT IS GETTING WORSE. THE CAR NOW HAS ONLY 28,000 MILES ON IT. *TR
Power train, Apr 5, 2010
O/D LIGHT BLINKING AND ENGINE REVVING LIKE THE CAR WAS IN PARK. WILL NOT GO INTO REVERSE. *TR
Power train, Apr 5, 2010
FORD 2002 6 CYLINDER EXPLORER XLT O/D OFF LIGHT FLASHING ON DASHBOARD. TRANSMISSION PROBLEM STARTED WITH 100,800 MILE. HAD REBUILT TRANSMISSION DONE AT 100,800 MILES. NOW VEHICLE HAS 109,900 MILES AND OD/OFF LIGHT FLASHING AGAIN. WAS TOLD THAT TRANSMISSION IS FALLING APART. BACK IN TRANSMISSION SHOP AGAIN. THERE ARE THOUSANDS OF SAME COMPLAINTS FOR THE SAME PROBLEM ON 2002 FORD EXPLORERS. FORD WILL NOT HELP AT ALL! FORD NEEDS TO RECALL TRANSMISSION. *TR
Engine and engine cooling, Apr 5, 2010, fire
A FIRE BURNING MY ENTIRE 2002 FORD EXPLORER SPORT IN THE EARLY MORNINGS WHEN THE SUV WASN'T EVEN STARTED. *TR
Power train, Apr 5, 2010
2002 FORD EXPLORER XLT (4.0L 5R55W) TRANSMISSION SLIPPAGE CAUSING NEAR ACCIDENT AS UNABLE TO PASS THROUGH INTERSECTION IN A TIMELY MANNER. WHEN SHIFTING BETWEEN 1ST AND 2ND GEAR, TRANSMISSION WOULD WIND BEFORE VIOLENTLY ENGAGING. REMEDY WAS TO TAKE FOOT OF ACCELERATOR AND ALLOW RPMS TO DECREASE. INCREASED ACCELERATION TIME IN LOWER GEARS A DANGER WHEN TRYING TO CROSS LANES OF TRAFFIC. *TR
Power train, Apr 5, 2010
TL* THE CONTACT OWNS A 2002 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING AT SPEEDS OF 20 MPH THE TRANSMISSION BEGAN TO SLIP. THE CONTACT BELIEVED THE FAILURE TO BE INTERMITTENT; HOWEVER, THE FAILURE BECAME PROGRESSIVELY WORSE AND THE OVERDRIVE WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE TRANSMISSION WAS REPLACED. THE DEALER AND MANUFACTURER WERE CONTACTED BUT WOULD PROVIDE NO ASSISTANCE BECAUSE THE VEHICLE WAS OUTSIDE OF THE FACTORY WARRANTY. THERE WERE NO RECALLS ON THE VEHICLE. THE FAILURE MILEAGE WAS APPROXIMATELY 130,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 150,000. UPDATED 5/24/10 *CN UPDATED 07/07/10.*JB
Power train, Apr 5, 2010
WHILE DRIVING MY VEHICLE WHEN IT SHIFTED GEARS THE CAR SLOWED DOWN AND THE RPMS WENT UP TO 4000 - 5000. AFTER A MINUTE THE CAR SHIFTED INTO THE NEXT GEAR AND IT SEEMED TO DRIVE FINE. THEN THE O/D OFF LIGHT BEGAN TO FLASH ON THE DASH. THIS PROBLEM HAS OCCURRED MULTIPLE TIMES TODAY. I HAVE SEEN MANY INSTANCES OF THE PROBLEM LISTED ON THE INTERNET FOR MY MAKE, MODEL AND YEAR. *TR
Power train, Apr 3, 2010
TRANSMISSION SHIFTS HARD AND THE O/D LIGHT IS STARTING TO BLINK AND BY READING UP ON THIS SEVERAL COMPLAINTS ARE BEING MADE AND FORD SHOULD ADDRESS THIS.
Equipment, Apr 3, 2010
I WOULD LIKE TO MAKE A COMPLAINT REGARDING THE FORD WINDOW REGULATOR. I KNOW THAT THE F150 I BELIEVE HAS HAD THE SAME COMPLAINTS. HOWEVER, I CURRENTLY OWN A 2002 FORD EXPLORER. BOTH WINDOW REGULATORS HAVE BROKE ON MY VEHICLE A WEEK APART. I BELIEVE THAT SINCE SO MANY PEOPLE ARE HAVING A PROBLEM WITH THEIR FORD VEHICLE WINDOW REGULATORS THAT THIS SHOULD BE A RECALL. I KNOW THAT AFTER A CERTAIN YEAR FORD HAD CHANGED THE WAY POWER WINDOWS WORKED. WELL, NOW THE WINDOW CABLE ON BOTH BACK WINDOWS HAS SNAPED. I WOULD LIKE TO CONTACT FORD TO MAKE A COMPLAINT AND TO SUGGEST A RECALL FOR THE WINDOW REGULATORS ON THE 2002 FORD EXPLORERS. THANK YOU.
Air bags, Apr 2, 2010
I HAVE A 2002 FORD EXPLORER. FOR THE LAST 2 YEARS THE AIR BAG LIGHT IS COMING ON AND OFF. FINALLY I TOOK IT FOR INSPECTION AND IT DIDN'T PASS BECAUSE THE LIGHT WAS ON AND IS A SAFETY ISSUE CONCERN. I CONTACTED FORD MOTOR COMPANY AND BECAUSE THERE IS NO A RECALL THEY WOULD NOT FIX THE PROBLEM, DESPIDE OF ALL HUNDREDS OF COMPLAINTS ABOUT THE SAME ISSUE. PROBABLY WAITING TILL SOMEONE DIE...TOYOTA IS THE BEST EXAMPLE OF IGNORING PROBLEMS LIKE THIS...
Power train, Apr 1, 2010
2002 FORD EXPLORER. O/D LIGHT FLASHING WITH SERVICE ENGINE SOON FLASHING. CAR JERKING BETWEEN 2ND AND 3RD GEAR. FORD SAYS TO REPLACE TRANSMISSION BUT AFTER READING SO MANY OF THE SAME COMPLAINTS I THOUGHT I SHOULD REPORT THIS INCIDENT.
Suspension, Apr 1, 2010
I HAVE A 2002 FORD EXPLORER AND BOTH REAR COIL SPRINGS ARE COMPLETLY RUSTED AND BROKE IN SEVERAL PLACES..I REALIZE THAT MY VECHILE IS NOW 8 YEARS OLD AND HAS 100,000 MILES BUT I'VE READ ONLINE THAT MANY PEOPLE HAVE HAD THIS SAME PROBLEM WITH THESE SPRINGS BREAKING AND BLOWING TIRES. NOW IM PAYING CLOSE TO 400 DOLLARS TO HAVE THIS REPLACED. I THINK FORD NEEDS TO TAKE ACTION AND STOP NEGLECTING THEM BUYING CHEAP MATERIAL AND PLAYING WITH PEOPLE LIVES AND SAFETY. THEY SHOULD REIMBURSE THOSE WHO HAVE HAD THIS PROBLEM AND FIX ALL VECHILES OF THIS YEAR...
Power train, Apr 1, 2010
I HAVE A 2002 FORD EXPLORER XLT 4X4 4.0L SOHC. TRANSMISSION BROKEN IN 3RD FEAR. OD LIGHT STARTING FLASHING WITH NO WARNING AND THEN TRANSMISSION BROKE. THE CAR HAS 120,000 MILES ON IT. I HAD A PROBLEM WITH THE TRANSMISSION AT AROUND 75,000 MILES. I TOOK IT TO THE FORD DEALER. IT WAS COVERED UNDER MY EXTENDED WARRANTY. NOW THE TRANSMISSION BROKE AGAIN. 2,400. - 3,000 TO FIX.
Vehicle speed control, Apr 1, 2010, fire
TL*THE CONTACT OWNS A 2002 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE SUDDENLY ACCELERATED. SHE APPLIED BOTH FEET TO THE BRAKE PEDAL BUT THE REAR TIRES WERE SMOKING AND THE VEHICLE BEGAN SPINNING OUT OF CONTROL UNTIL SHE TURNED OFF THE IGNITION TO REGAIN CONTROL OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING BUT THE FAILURE COULD NOT BE DUPLICATED. THE VIN WAS NOT AVAILABLE. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 63,000.
Power train, Mar 30, 2010
I HAVE A 2002 FORD EXPLORER EDDIE BOWER THAT I BOUGHT NEW. I HAVE 88000 MILES ON IT AND ROUGHLY 3WEEKS AGO THE O/D LIGHT STARTED BLINKING AND THE "CHECK TRANSMISSION" WARNING COMES UP. TOOK IT TO THE DEALER AND THEY TOLD ME THAT I NEED A NEW OR REBUILT TRANSMISSION COSTING BETWEEN $2,200-$3,500. THIS SEEMS TO BE A COMMON PROBLEM WITH THE 2002 EXPLORER.
Engine and engine cooling, Mar 30, 2010
ENGINE KNOCK IN ALL 4.6 FORD EXPLORER ENGINES-KNOW BY FORD, DUE TO FAULTY CYLINDER HEADS