2004 Ford Explorer
Problems, recalls and owner-reported issues
Power train is the leading concern among 1,408 owner complaints filed for this model year. This is the 7th highest complaint count among 26 Explorer model years with reports.
Of the 2004 reports, 75 involved a crash and 16 involved a fire. 105 people were injured.
What owners report most often
Recalls and investigations
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Visibility, glass, side/rearDec 11, 2007
CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.
SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER'S GLASS. WHOLESALE CUSTOMERS CAN CONTACT SAFELITE'S WHOLESALE DIVISION, SERVICE AUTOGLASS TOLL FREE AT 1-888-246-6298. THE RECALL BEGAN ON JANUARY 15, 2008.
Campaign 07E104000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Representative owner complaints
1,408 reports, newest first.
Air bags, Seat belts, Jan 31, 2007, crash
THE CONSUMER WAS INVOLVED IN A SINGLE VEHICLE ROLLOVER ACCIDENT IN HIS 2004 FORD EXPLORER LIMITED IN WHICH THE SEAT BELTS FAILED TO PROPERLY RESTRAIN HIM. THE AIR BAGS ALSO DID NOT DEPLOY. *CC THE SEAT BELTS HAD BEEN RECALLED AND FIXED PRIOR TO THE ACCIDENT. THE CONSUMER WAS NOT SERIOUSLY INJURED AND ONLY SUSTAINED MINOR SCRAPES. *NM
Power train, Jan 29, 2007
WHINING NOISE IN REAR END OF 2004 FORD EXPLORER, DEALER SAID THERE'S NOTHING THEY CAN DO ABOUT IT, SAID DON'T WORRY ABOUT IT , IT DOESN'T HURT ANYTHING, 36,000 MILES. *JB
Power train, Jan 17, 2007
ON CHRISTMAS EVE 2006 I WAS SHOPPING FOR PRESENTS... WENT TO MAY BE 5 STORES. AFTER LAST STORE, I STARTED CAR AND WHEN I WENT TO PUT IT IN GEAR, THE GEAR STICK BROKE OFF INTO MY HANDS. TRANSMISSION WAS STUCK BETWEEN PARK AND REVERSE! THERE WAS NO WAY TO PUT IT BACK TOGETHER AS IT BROKE OFF AT THE BASE. DEALER REPLACED $1000 WORTH OF PARTS. I FEEL THIS COULD HAVE HAPPENED AT ANY TIME AND WAS LUCKY VEHICLE WAS IN PARK RATHER THAN IN DRIVE WHEN IT HAPPENED. *JB
Visibility, Other or unspecified, Jan 17, 2007
AUTOMATIC WINDOWS - REAR WINDOWS - MOTOR WENT OUT - REPLACED ONCE - DOING IT AGAIN, HAVE TO TAKE IT BACK IN. REAR AIR SYSTEM DOES NOT BLOW OUT HEAT. AGAIN, NEEDING TO TAKE IT IN AGAIN. HAD I NOT GOTTEN THE EXTENDED WARRANTY ON MY VEHICLE I WOULD BE WITHOUT REAR HEAT. *JB
Service brakes, Hydraulic, Electrical system, Structure, Latches/locks/linkages, Jan 16, 2007
WE HAVE EXPERIENCED MULTIPLE PROBLEMS WITH THE ELECTRICAL SYSTEMS OF OUR 2004 FORD EXPLORER ALONG WITH OTHER MISCELLANEOUS PROBLEMS. THE ELECTRICAL PROBLEMS HAVE NOT BEEN CORRECTED TO DATE. IN NOVEMBER 2006, THE REAR WINDOW OF THE LIFTGATE BROKE OFF THE HINGE. WE WERE TOLD THERE WERE NO RECALLS FOR THIS PROBLEM AND HAD TO PAY FOR THIS REPAIR OUT OF OUR POCKET. TODAY, JANUARY 16, 2007 THE FRAME OF THE REAR LIFTGATE CRACKED IN THE MIDDLE. *NNM
Electrical system, Jan 16, 2007
I HAVE A 2004 FORD EXPLORER. LAST YEAR AT 38,000 MILES, THE KEY LOCKED IN THE IGNITION AND I HAVE BEEN UNABLE TO GET IT OUT. PORTSMOUTH FORD N.H. SAYS TOO BAD: IT IS OUT OF WARRANTY AND IT WILL COST ME $400 TO GET IT OUT. TODAY I HAVE 56,000 MILES ON MY EXPLORER AND THE KEY IS STILL IN THE IGNITION. IT IS A PAIN. I WAS HOPING FOR A RECALL. HAVE YOU HEARD OF THIS PROBLEM?*JB
Power train, Jan 15, 2007
PURCHASED THE 2004 FORD EXPLORER IN SYRACUSE, NY IN THE FALL OF 2004. WE RECEIVED THE RECALL NOTICE ABOUT THE TRANSMISSION AND HAD THE SERVICE PERFORMED. THE VEHICLE HAS BEEN IN TO THE DEALER TO FIX A CONTINUING PROBLEM ABOUT THE TRANSMISSION. THE TRANSMISSION HAS TROUBLE SHIFTING INTO REVERSE AND WHEN GOING UP HILL, ON OCCASION. THE VEHICLE'S TRANSMISSION ALSO CONTINUES TO MAKE A "CLUNKING" NOISE AND PHYSICALLY LURCHES ON OCCASION WHEN TRAVELING AT SPEEDS BETWEEN 40 - 60 MPH. THE VEHICLE IS WITHIN A COUPLE HUNDRED MILES OF THE FACTORY WARRANTY EXPIRATION AND FORD HAS STILL NOT REPAIRED THE PROBLEM. WE HAVE SPOKEN TO THE FORD MANUFACTURER DIRECTLY AND THEY HAVE ONLY OFFERED TO SELL US AN EXTENDED WARRANTY. THE LOCAL DEALER SERVICE MANAGER DID INDICATE THAT HE IS AUTHORIZED TO OFFER AN EXTENDED WARRANTY UP TO 75,000 MILES AT NO COST, BUT WE HAVE NOT RECEIVED THAT IN WRITING. WE FEEL THAT THIS WAS A PROBLEM CAUSED IN THE PRODUCTION OF THE VEHICLE AND ALL REPAIRS SHOULD BE COVERED BY FORD, BUT THEY ARE NOT TAKING CARE OF THE PROBLEM. *NM
Power train, Jan 15, 2007
WITHIN A WEEK OF BUYING MY 2004 EXPLORER I EXPERIENCED PROBLEMS WHEN SHIFTING OUT OF REVERSE. I ALSO EXPERIENCED A LOUD "CLANG" WHILE DOING STEADY INTERSTATE DRIVING (OVER 200 MILES). OVER TIME TRANSMISSION SHIFTING BECAME SLUGGISH, UNTIMELY, AND LOUD. A RECALL WAS RECEIVED AND A TRANSMISSION ADDITIVE WAS ADDED. PROBLEMS CONTINUED WITH THE TRANSMISSION (SAME AS NOTED ABOVE). IN JUNE '06- DEALERSHIP REPLACED SOME PARTS OF THE TRANSMISSION (UNDER WARRANTY). FIVE MONTHS LATER, I'M CONTINUING WITH PROBLEMS. LOUD "CLANG" DURING LONG ROAD TRIP. JERKY, HESITANT SHIFTING CONTINUES. TOOK CAR TO DEALERSHIP AND NO PROBLEMS WERE FOUND WITH THE TRANSMISSION AND DEALERSHIP WAS NOT ABLE TO DUPLICATE DURING 30 MILE TEST DRIVE. CAR STALLED IN PARKING LOT THIS WEEK, JERKY MOTION CONTINUES GOING UP STEEP INCLINE AND LOUD "CLANG" EXISTS ON LONG ROADTRIP. WARRANTY IS ABOUT TO RUN OUT IN ABOUT 400 MILES. I HAVE CONTACTED CUSTOMER CARE CENTER RESULTING IN NO HELP. ALSO HAVE REPEATED PROBLEMS WITH FUEL GAUGE NOT REGISTERING PROPERLY. *NM
Power train, Jan 13, 2007, crash
THE TRANSMISSION IN OUR 2004 FORD EXPLORER XLT AWD REQUIRED A SIGNIFICANT REPAIR IN 7/05 AT 11,311 MILES BECAUSE THE TRANSMISSION WOULD NOT ENGAGE AFTER SHIFTING INTO REVERSE. DEALER REPLACED SHIFT SOLENOID AND REFILLED FLUID. DEALER ESTIMATED THAT COST TO REPLACE SHIFT SOLENOID WAS $3,500 BUT IT WAS COVERED UNDER WARRANTY. PROBLEM RECURRED AND IN DECEMBER 2006 AT APPROXIMATELY 32,000 MILES, MY DAUGHTER WAS INVOLVED IN AN ACCIDENT WHEN SHE BACKED INTO A PARKED CAR BECAUSE THE TRANSMISSION FAILED TO ENGAGE. WE TOOK IT TO THE DEALERSHIP AND THEY REPLACED THE SHIFT SOLENOID A SECOND TIME. *JB
Power train, Jan 10, 2007
2004 FORD EXPLORER GEAR SHIFTER LEVER BROKE IN MY HAND WHILE VEHICLE WAS IN DRIVE. THE VEHICLE IS AN AUTOMATIC. THIS IS A HUGE SAFTEY ISSUE BECAUSE THE VEHICLE WAS ENGAGED IN DRIVE AT THE POINT OF THE LEVER BREAKING. THE LEVER WAS NOT A STEEL PIECE AND WAS DEFECTIVE. FORD IS UNRESPONSIVE TO THIS ISSUE. *JB
Engine and engine cooling, Jan 3, 2007
ON THREE SEPARATE OCCASIONS, MY EXPLORER WOULD TURN OVER BUT REFUSE TO START. THE THIRD TIME IT TOOK 2 DAYS FOR IT TO FINALLY START. ON THE WAY TO THE SERVICE APPOINTMENT AT THE DEALER, THE SUV STALLED IN THE MIDDLE OF A VERY BUSY INTERSECTION. THE DEALER SAID THAT THEY COULDN'T PIN-POINT ANY PARTICULAR CAUSE BUT THEY DID HAVE A SERVICE BULLETIN THAT CALLED FOR UPDATING OF SOME SOFTWARE. *NM
Power train, Jan 2, 2007
TRANSMISSION/DIFFERENTIAL/REAR-END PROBLEMS, PURCHASED 2004 FORD EXPLORER XLT IN MARCH OF 2006, FIRST COMPLAINT WAS THAT THE PRNDL INDICATOR WOULD NOT MOVE INTO THE RIGHT GEAR,REPORTED THE DEFECT IN MAY, PROBLEM STOPPED BUT THEN STARTED AGAIN. BROUGHT THE VEHICLE BACK TO THE DEALER AND HAD TO PAY TO GET THE PROBLEM REPAIRED. BUT ALSO FOUND THAT THE REAR-END IS SHOT THE DRIVE SHAFT KEEPS TURNING AND THE VEHICLE KEEPS ROLLING WHILE IN PARK. THE VEHICLE ALSO LURCHES WHEN BRAKE IS DEPRESSED. DEALER STATES THAT THE REAR-END AND DIFFERENTIAL IS BAD HOW CAN THIS BE ON A VEHICLE THAT HAS ONLY 49000 MILES ON IT . *JB
Power train, Equipment, Dec 29, 2006
WHEN THE EXPLORER IS PUT IN REVERSE IT TAKES UP TO 5 SECONDS TO ENGAGE AND THEN JERKS BACKWARDS AFTER MAKING A LARGE CLUNKING NOISE. U JOINTS AND WHEEL BEARINGS HAVE BEEN REPLACED, BUT PROBLEM STILL OCCURS.
Suspension, Dec 27, 2006
I HAVE EXPERIENCED ACCELERATED FRONT TIRE WEAR, AND ASSOCIATED NOISE AND VIBRATION ON THIS VEHICLE, WITH CURRENT MILEAGE AT 37000 MILES. I HAVE HAD THE WHEELS BALANCED RELIGIOUSLY EVERY 5000-6000 MILES SINCE I BOUGHT IT. I FIRST NOTICED THE WEAR AND VIBRATION AT ABOUT 25000 MILES. I TOOK THE VEHICLE IN TO HAVE THE WHEELS BALANCED AND WAS TOLD THAT THE BALL JOINTS WERE LOOSE AND OUT OF SPECIFICATION. I THEN RETURNED THE VEHICLE TO THE DEALER TO HAVE THE VIBRATION AND WEAR PROBLEM ADDRESSED UNDER WARRANTY. THE DEALER TOLD ME THAT THERE WAS NOTHING WRONG WITH THE VEHICLE, AND THAT THE NOISE WAS SIMPLY DUE TO TIRE WEAR. WHEN I INDICATED THAT A THIRD PARTY SHOP HAD FOUND LOOSE BALL JOINTS, THE DEALER STATED THAT THEY WERE IN SPEC, AND THEN RECOMMENDED FRONT END ALIGNMENT WHICH I HAD PERFORMED. THE VIBRATION AND NOISE FROM THE FRONT TIRES CONTINUED AFTER THE ALIGNMENT WAS DONE. AT THIS RATE, I WILL HAVE TO REPLACE THE TIRES AND LIKELY THE BALL JOINTS ON THIS VEHICLE PRIOR TO REACHING 40000 MILES. SEVERAL OTHER COMPLAINTS TO NHTSA ARE VERY SIMILAR TO MY EXPERIENCE WITH THIS VEHICLE. *JB
Power train, Nov 26, 2006, crash
WE HAVE A 2004 FORD EXPLORER WITH 41,000 MILES. IN THE PAST 3 MONTHS WE HAVE HAD TO HAVE THE TRANSMISSION OVERHAULED, UNIVERSAL BALL JOINT REPLACED, WHEEL BEARINGS REPLACED, PARKING BRAKE REPLACED. ALL WORK HAS BEEN DONE BY THE DEALER. ON THE EVENING OF 11/21/06, WE WERE LEAVING MY DAUGHTER'S SCHOOL AND I GOT IN THE VEHICLE TO BACK THE CAR UP A FEW FEET SO THAT MY WIFE WOULD NOT HAVE TO STEP IN THE MUD. I STARTED THE CAR, PUT THE CAR IN REVERSE (FOOT ON BRAKE), AND WHEN I TOOK MY FOOT OFF THE BRAKE TO MOVE THE CAR A FEW FEET, IT SURGED BACKWARDS, LIKE A CANNON BALL IN REVERSE; IT CRASHED INTO A NEON, WHICH WAS PARKED 6 FEET FROM OUR CAR, SENT THE NEON FLYING ABOUT 15 FEET INTO ANOTHER CAR; (THE NEON'S FRONT END WAS CRUSHED). I FELT I HAD NO CONTROL OVER THIS VEHICLE WHATSOEVER. WE ARE THANKFUL THAT IT HIT A PARKED CAR, RATHER THAN TRAFFIC COMING FROM BEHIND. WHAT WOULD HAVE CAUSED THIS? THE POLICEMEN THAT RESPONDED TO OUR CALL SUGGESTED THAT WE NOT ATTEMPT TO DRIVE THE VEHICLE, SO WE PUSHED IT TO THE SIDE OF THE ROAD AND HAD IT TOWED TO THE FORD DEALER. THE OTHER CAR IN THE INCIDENT WAS NOT DRIVABLE AND ALSO HAD TO BE TOWED. ONE OF THE POLICEMEN THAT RESPONDED TO OUR CALL SAID THAT THEY HAD A SIMILAR ACCIDENT HAPPEN WITH ONE OF THEIR POLICE CRUISERS (ANOTHER FORD PRODUCT); WHEN THE CAR WAS PUT INTO REVERSE IT SHOT BACKWARDS AND HIT ANOTHER POLICE CAR, BUT THEY DID NOT SUSTAIN DAMAGE BECAUSE THE CARS WERE PARKED SO CLOSE TO EACH OTHER. PLEASE HELP US FIGURE THIS OUT. WE ARE AFRAID TO GET BACK INTO THE VEHICLE. AS OF THIS DATE, FORD HAS NOT FIGURED OUT WHAT COULD HAVE HAPPENED TO THE VEHICLE. WE ALSO FOUND ON THIS WEBSITE SIMILAR INCIDENTS WITH THIS MODEL OF THE EXPLORER. WE ARE ALSO WAITING FOR OUR INSURANCE ADJUSTER'S REVIEW OF THE INCIDENT BEFORE THE COLLISION WORK TAKES PLACE. *NM
Structure, Nov 24, 2006
ON 11/23/2006, MY WIFE, PUT SOMETHING IN OUR 2004 FORD EXPLORER VIA THE REAR HATCH WHEN THE DRIVERS SIDE GLASS HINGE BROKE. THE GLASS REMAINED IN TACT, BUT TO BE ABLE TO CLOSE THE HATCH I HAD TO REMOVE THE TWO STRUTS. THIS APPEARS TO BE SIMILAR TO RECALL #04V442000 ON THE SAME MODEL VEHICLE IN 2002. *JB
Engine and engine cooling, Nov 21, 2006
DT*: THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS, THE ENGINE STALLED WITHOUT WARNING. AFTERWARDS, THE ENGINE WAS RESTARTED AFTER SEVERAL ATTEMPTS. THE VEHICLE WAS INSPECTED BY A DEALER WHO WAS UNABLE TO DUPLICATE THE PROBLEM. THE MANUFACTURER WAS NOT ALERTED.
Power train, Nov 21, 2006
DT*: THE CONTACT STATED WHILE SHIFTING THE TRANSMISSION INTO GEAR, THE VEHICLE JUMPED. THE PROBLEM PROGRESSIVELY WORSENED AND THE VEHICLE DID NOT RESPOND PROPERLY TO THE DEPRESSION OF THE ACCELERATOR PEDAL. THE VEHICLE WAS TAKEN TO THE DEALERSHIP, WHERE DIAGNOSTIC TESTS DETERMINED THE TRANSMISSION NEEDED TO BE REPLACED.
Structure, Nov 21, 2006
DT*: THE CONTACT STATED THE WINDOW HINGE IN THE REAR LIFT GATE FRACTURED, AND THEN THE WEIGHT OF THE WINDOW FRACTURED THE SECOND HINGE. THE VEHICLE WAS TAKEN TO A SERVICE DEALER AND THE MANUFACTURER WAS NOTIFIED. THE MANUFACTURER INFORMED THE CONTACT THE VEHICLE WAS NOT INCLUDED IN RECALL #04V442000 REGARDING THE STRUCTURE: BODY: HATCHBACK/LIFTGATE: HINGE AND ATTACHMENTS, ALTHOUGH THE FAILURE WAS THE SAME.
Power train, Nov 15, 2006, crash
2004 FORD EXPLORER. TRANSMISSION SHIFTS ROUGHLY INTO REVERSE AND THIRD GEAR. CAR WAS PUT INTO REVERSE IN JUNE, 2004 AND DID NOT MOVE UNTIL A FEW SECONDS LATER, AND THEN LUNGED BACKWARDS, HITTING MY WIFE AND BREAKING HER ARM. STILL SHIFTS ROUGHLY TO THIS DAY. *JB
Power train, Nov 7, 2006
SHIFTING FROM "DRIVE" TO "REVERSE" TRANSMISSION ENGAGES HARSHLY. *NM
Power train, Nov 3, 2006
DELAYED HARSH REVERSE ENGAGEMENTS
Steering, Service brakes, Hydraulic, Power train, Visibility, Latches/locks/linkages, Oct 30, 2006
2004 EXPLORER HAD PROBLEMS WITH BRAKES AND WINDOWS. *TS THREE MONTHS AFTER THE VEHICLE WAS PURCHASED THEE WAS A RECALL ON THE TRANSMISSION. THE ABS MALFUNCTIONED AND THE POWER WINDOWS WOULD NOT GO DOWN. THE REAR HATCH DOOR WOULD NOT OPEN. THE TRANSMISSION BEGAN TO SLAM INTO GEAR. THE ROTORS VIBRATED IN THE REAR. CONSUMER HEARD A HOWLING NOISE AT 40-55 MPH. THE DEALER REPLACED THE RING AND PINION. NM
Power train, Oct 30, 2006
WHEN MOVING GEAR SELECTOR FROM PARK TO REVERSE AND SOMETIMES DRIVE, THERE IS A LAG OF ABOUT 3 TO 5 SECONDS AND THEN A LOUD CLUNKING NOISE FOLLOWED BY A POWER SURGE OF VEHICLE GOING INTO GEAR. WORRIED TRANSMISSION IS FAILING AGAIN. TOOK IN FOR REPAIRS SAME ON SAME INCIDENT THEY SAID IT WAS FIXED. AND GUESS WHAT, I BELIEVED THEM. *JB
Power train, Oct 23, 2006
DURING THE ACCELERATION FROM A STOP LIGHT THE VEHICLE WOULD NOT SHIFT FROM 2ND TO 3RD. THE OVERDRIVE OFF LIGHT THEN BEGAN FLASHING. THIS CAUSED UNEXPECTED POOR ACCELERATION AND IN TRAFFIC COULD RESULT IN POSSIBLY BEING REAR ENDED BY TRAFFIC BEHIND YOU. *NM