2011 Ford Explorer
Problems, recalls and owner-reported issues
Steering is the leading concern among 1,196 owner complaints filed for this model year. This is the 10th highest complaint count among 26 Explorer model years with reports.
Of the 2011 reports, 30 involved a crash and 4 involved a fire. 15 people were injured.
What owners report most often
Recalls and investigations
Structure, body, roof and pillarsJan 19, 2024
Ford Motor Company (Ford) is recalling certain 2011-2019 Explorer vehicles. The A-pillar trim retention clips may not be properly engaged, allowing the trim to detach.
A detached trim piece can fall off the vehicle, becoming a road hazard and increasing the risk of a crash.
Dealers will inspect and replace the A-pillar trim as necessary, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model years. Owner notification letters were mailed between July 18, 2024 and December 16, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S02.
Campaign 24V031000 on NHTSA.gov
Suspension, rearSep 22, 2021
Ford Motor Company (Ford) is recalling certain 2011-2013 Explorer vehicles originally sold, or currently registered in Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, and Wisconsin. These vehicles may be equipped with a cross-axis ball joint (CABJ) replacement part that could seize, and result in a fracture of the outboard section of the rear suspension toe link.
A rear toe link fracture can result in a loss of steering control, increasing the risk of a crash.
Dealer will inspect for the presence of a CABJ. If a CABJ of any design is found, the dealer will inspect the tightness of the CABJ, and replace the CABJ, knuckle, and/or toe link as necessary, free of charge. Interim notification letters were mailed November 10, 2021. Owner notification letters were mailed on March 17, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S43.
Campaign 21V746000 on NHTSA.gov
Suspension, rearJun 10, 2019
Ford Motor Company (Ford) is recalling certain 2011-2017 Explorer vehicles. The rear suspension toe links may fracture due to stress on the rear suspension.
A fractured rear toe link will cause a sudden change in vehicle handling and increase the risk of a crash.
Ford will notify owners, and dealers will replace the rear suspension toe links, and inspect both rear toe link ball joints, replacing the rear wheel knuckle(s), if necessary, free of charge. The recall began June 26, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S17.
Campaign 19V435000 on NHTSA.gov
Wheels, hubAug 28, 2017
Ford Motor Company (Ford) is recalling certain Wheel Hub Bearing assemblies, part number HB5Z-1104-C, incorrectly listed as being for installation on the rear axles of 2011-2017 Ford Explorer 4X2 vehicles. These bearings assemblies were manufactured without a self retention feature, possibly resulting in the separation of the wheel or wheel end.
A loss of the wheel or wheel end can increase the risk of a crash.
Ford will notify the distributors of the hubs specifying that they are to only be used on drive axles. It is believed that none of the hubs were purchased from Ford dealers for the incorrect application. Owners may contact Ford customer service at 1-866-436-7332.
Campaign 17E048000 on NHTSA.gov
Structure, body, doorMar 24, 2015
Ford Motor Company (Ford) is recalling certain model year 2011-2013 Explorer vehicles. In the affected vehicles, the interior door handle return spring may unseat, resulting in interior door handle that does not return to the fully stowed position after actuation.
If the interior door handle return spring is unseated, the door may unlatch in the event of a side impact crash, increasing the risk of personal injury.
Ford will notify owners, and dealers will inspect all four of the interior door handles and either repair or replace them, free of charge. The recall began on July 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S11.
Campaign 15V171000 on NHTSA.gov
Steering, electric power assist systemMay 29, 2014
Ford Motor Company (Ford) is recalling certain model year 2011-2013 Ford Explorer vehicles manufactured May 17, 2010, through February 28, 2012. The affected vehicles may experience an intermittent connection in the electric power steering gear, which can cause a loss of the motor position sensor signal resulting in a shut down of the power steering assist.
If the vehicle experiences a loss of power steering assist it will require extra steering effort at lower speeds, increasing the risk of a vehicle crash.
Ford will notify owners, and dealers will update the Power Steering Control Module (PSCM) software, free of charge. If a vehicle shows a history of a loss of motor position sensor signal when the vehicle is brought in for the recall remedy, its steering rack assembly will be replaced, free of charge. The recall began on July 23, 2014. Owners may contact Ford customer service at 1-800-392-3673. Ford's number for this recall is 14S06.
Campaign 14V286000 on NHTSA.gov
SteeringJan 6, 2014
Ford Motor Company (Ford) is recalling certain replacement steering gears installed on model year 2011-2012 Explorers as service parts in September 2013 and January 2014. The affected gears may lock, preventing the driver from being able to steer the vehicle.
The inability to steer the vehicle increases the risk of a crash.
Ford will notify owners and dealers will replace the suspect steering gears with new steering gears, free of charge. The recall began on January 29, 2014. Customers may contact Ford at 1-800-392-3673. Ford's number for this recall is 13S14.
Campaign 14E001000 on NHTSA.gov
SeatsFeb 2, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2011 EXPLORER VEHICLES MANUFACTURED FROM JULY 15, 2010, THROUGH DECEMBER 13, 2010, EQUIPPED WITH SECOND ROW 60% SEATS WITH MANUAL RECLINER MECHANISMS THAT MAY HAVE COMPONENTS THAT ARE OUT OF DIMENSIONAL SPECIFICATION. THESE SEATS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207, "SEATING SYSTEMS."
IN THE EVENT OF A CRASH, THE SEAT BACK MAY NOT PROVIDE THE REQUIRED STRENGTH, INCREASING THE RISK OF INJURY.
FORD WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE SEATS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Campaign 11V063000 on NHTSA.gov
Representative owner complaints: structure
110 reports, newest first. Show all
Structure, Jun 3, 2025
The contact owns a 2011 Ford Explorer. The contact stated that while driving at an undisclosed speed, the driver’s and passenger’s side a-pillar trim pieces became disconnected. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 24V031000 (Structure); the VIN was included, but the vehicle had already been repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 240,000.
Structure, May 29, 2025
Recall 24S02.EXTERIOR A-PILLAR APPLIQUE TRIM CLIP on Ford Explorer 2011 -Dealership: Pearson Ford, 10650 N Michigan Road, Zionsville IN 46077 -August 2024: I notified the Ford dealership that the rubbery part around the A-frame on drivers side windshield was coming off and there has been a recall on this part. They looked at it and said the part was on back order. -Over the next few months the rubbery part that attaches to window came completely off. -I continued to notify Ford dealership throughout the next several months, and they continue to say the part is on back order. -April 2025: After filing a google complaint, Tyler with customer service called back and said he will contact me when the A-frame is ordered and in the shop. [XXX]: I was on the highway and the right side A-frame (part of the body) completely flew off and hit the car behind me. May 26-29th, 2025: I have attempted several times to get ahold of someone at this dealership (text, phone messages), and no response. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Structure, Apr 11, 2025
The contact owns a 2011 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated both the driver's side and passenger's side windshield exterior trims had detached from the vehicle. The vehicle was taken to the dealer, where the trims were removed from the vehicle to prevent a road safety hazard. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 109,000. Parts distribution disconnect.
Structure, Mar 28, 2025
The contact owns a 2011 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer and a second dealer, Serra Ford Kalkaska (408 W Mile Rd, Kalkaska, MI 49646), were made aware of the issue and confirmed that parts were not yet available. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Structure, Mar 26, 2025
The contact owns a 2011 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Air bags, Structure, Mar 25, 2025
The contact owns a 2011 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the air bag warning light was illuminated. The vehicle was taken to the dealer for the air bag warning light being illuminated and the dealer diagnosed that the front passenger’s side air bag sensor had failed and needed to be replaced. The dealer informed the contact that the part was ordered; however, the vehicle was not repaired. The dealer was contacted regarding NHTSA Campaign Number: 24V031000 (Structure); in February 2024 and the contact was informed there were no parts available for the recall repair. In July 2024 the contact received a letter stating that parts were available, and an appointment was scheduled for October 2024. At the time of the appointment, the dealer informed the contact that the recall repair could not be performed due to parts not being available. The manufacturer was made aware of the issue, and a case was opened. The failure mileage was approximately 30,000. Parts distribution disconnect.
Structure, Mar 3, 2025
The contact owns a 2011 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated while driving at various speeds, the rubber gaskets underneath the front driver's side and passenger's side of the windshield A-Pillar trims were flapping against the windshield. The vehicle was taken to the dealer, where it was determined that both trims needed to be replaced; however, the parts were not yet available. The vehicle was not repaired. The contact used tape to secure the trims. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 100,000. Parts distribution disconnect.
Structure, Feb 20, 2025
The contact owns a 2011 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Structure, Feb 14, 2025
The contact owns a 2011 Ford Explorer. The contact stated that the front windshield A-pillar trim had become loosened. The contact glued the trim back in place. There were no warning lights illuminated. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 140,000. Parts distribution disconnect.
Structure, Feb 4, 2025
The contact owns a 2011 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that while driving at an undisclosed speed, a piece of the front driver’s side A-pilar trim detached and blew off onto the highway. The contact stated that a piece of the driver’s side A-pilar trim remained attached; however, the vehicle was temporarily repaired with tape. The local dealer was contacted; however, parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The approximate failure mileage was 140,000. Parts distribution disconnect.
Structure, Feb 4, 2025
The contact owns a 2011 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Structure, Jan 31, 2025
The contact owns a 2011 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Structure, Jan 21, 2025
The contact owns a 2011 Ford Explorer. The contact stated while driving on several occasions at various speeds, there was a sound of air coming from the driver’s and passenger’s side of the windshield. The vehicle was taken to a dealer on several occasions where it was determined that the upper A-pillar trims and clips needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 143,000.
Structure, Jan 7, 2025
The contact owns a 2011 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact stated that while she was washing the vehicle with a garden hose, the driver's side of the A-pillar detached and separated from the vehicle. The contact was unable to reinstall the trim piece. The contact stated that recently the passenger’s side A-pillar trim became loosened. The failure mileage was 58,519. Parts distribution disconnect.
Structure, Jan 5, 2025
Referencing Recall 24V031: A and B Pillar trim clips fail and cause cover to fly off while driving. * Puts driver and others at risk by part releasing from clips and flying off while driving. * I just lost my 4th one and have been waiting for parts at Corning Ford (530-824-5434) to fix this issue since August of 2024 when we originally took the vehicle in for repair. * After viewing my other cover, it is also near detaching and flying off without warning. * I feel the lack of attention and available parts for this recall is causing unnecessary risk to drivers and others on the road. PLEASE TAKE ACTION IN THAT FORD MOTOR COMPANY COMPLETES THIS RECALL AND FIXES OUR VEHICLE.
Structure, Dec 30, 2024
The contact owns a 2011 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated while driving at an undisclosed speed, the exterior A-pillar Trim detached. No warning light was illuminated. The local dealer was contacted and confirmed that the parts were not yet available. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was unknown. Parts distribution disconnect.
Structure, Dec 30, 2024
In the 2021 Ford Explorer there are multiple leaks due to rain / water damage. The back of the trunk has a leak that has water running down the side into the third row seat it causes rust on to the spare tire, it’s causes fog to be on the inside of the car causing issues to see. There is also leaking in the front of the car that comes out through the light unit above all electric panel. This leaking is causing the ceiling lights to have issues, drips into the dashboard with all the electrical items causing the unit to short, which is where the rear camera display occurs.
Structure, Dec 27, 2024
The contact owns a 2011 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000(Structure); however, the part to do the recall repair was not yet available. The contact stated while driving 70-72 MPH, the contact heard an abnormal popping sound, and the driver's side windshield exterior A-Pillar trim separated and flew off. Additionally, the contact stated that the passenger's side windshield exterior A-Pillar trim had detached. The local dealer was contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 110,000. Parts distribution disconnect.
Structure, Dec 27, 2024
The contact owns a 2011 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The local dealer was contacted. The vehilce was taken to the local dealer where the exterior A-pillar trim was removed. The vehilce was not repaired due to parts being backordered. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Structure, Dec 12, 2024
The contact owns a 2011 Ford Explorer. The contact stated while driving at an undisclosed speed, the driver's side windshield trim detached and flew off the vehicle. The contact stated that shortly afterwards, the passenger's side windshield trim fractured. The vehicle was taken to an independent mechanic and the passenger's side trim was reattached. The contact stated that due to the wind, the failure reoccurred. The contact applied tape to the area to hold the windshield trim in place. In addition, the vehicle was taken to the dealer however, the contact was informed that parts were not yet available. The contact received notification of NHTSA Campaign Number: 24V31000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was unknown. Parts distribution disconnect.
Structure, Oct 30, 2024
The contact owns a 2011 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact stated while driving approximately 60 MPH, the driver’s and passenger’s side A-pillar trims had detached and flew off the vehicle. The contact stated that the failure had occurred prior to receiving the recall repair. The contact had taken the vehicle to a local dealer who replaced both trim pieces. The failure mileage was 146,682. Parts distribution disconnect.
Structure, Oct 25, 2024
The contact owns a 2011 Ford Explorer. The contact stated while driving at an undisclosed speed, the front windshield trim on the driver’s and the passenger’s side trims detached. The contact stated that due to the failure when it rained, the water filled up in the floorboard of the vehicle. The dealer was made aware of the failure; however, the contact was informed that the parts were not yet available. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was 100,000. Parts distribution disconnect.
Structure, Oct 22, 2024
The contact owns a 2011 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Structure, Oct 3, 2024
The contact owns a 2011 Ford Explorer. The contact stated while driving at an undisclosed speed, the driver’s and passenger’s side front windshield exterior A-pillar trims detached and flew off the vehicle. In addition, the contact stated that the failure had started two years ago, and the vehicle was taken to the dealer several times; however, the vehicle was not repaired. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was 96,000. Parts distribution disconnect.
Structure, Sep 26, 2024
The contact owns a 2011 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was not yet available. The local dealer was contacted and confirmed that the parts would not be available until 2025. The contact stated while driving 65 MPH, the exterior A-Pillar applique trim detached. The contact was not able to retrieve the part. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The approximate failure mileage was 230,000. Parts distribution disconnect.