2000 Ford F-150
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 1,204 owner complaints filed for this model year. This is the 3rd highest complaint count among 26 F-150 model years with reports.
Of the 2000 reports, 92 involved a crash and 361 involved a fire. 79 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lighting, headlightsAug 1, 2006
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 28, 2006. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.
Campaign 06E067000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Campaign 06E065000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Vehicle speed controlSep 7, 2005
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
A FIRE AT THE SWITCH COULD OCCUR.
BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)
Campaign 05V388000 on NHTSA.gov
Vehicle speed control, cruise controlJan 27, 2005
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
THIS CONDITION COULD LEAD TO A FIRE. FIRES HAVE OCCURRED WHILE THE VEHICLES WERE PARKED WITH THE IGNITION 'OFF.'
AS AN INTERIM REPAIR, OWNERS WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. AS SOON AS REPLACEMENT PARTS ARE AVAILABLE (EARLY APRIL 2005), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A NEW SWITCH FREE OF CHARGE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V388 AND 06V286)
Campaign 05V017000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Equipment, other, labelsSep 21, 2000
VEHICLE DESCRIPTION: BI-FUEL CNG PICKUP TRUCKS AND BI-FUEL CNG VANS, MODIFIED BY CFI CONTROL SYSTEMS, INC., FAIL TO CONFORM TO THE REQUIREMENTS OF FMVSS NO. 303, "FUEL SYSTEM INTEGRITY OF COMPRESSED NATURAL GAS VEHICLES." THE LABEL AFFIXED TO THE FUEL FILLER DOOR BY THE VEHICLE MODIFIER CONTAINS THE INSPECTION DATE AND EXPIRATION DATE OF THE CNG TANK. HOWEVER, IT DOES NOT CONTAIN THE STATEMENT "SEE INSTRUCTIONS ON THE FUEL CONTAINER FOR INSPECTION AND SERVICE LIFE."
THESE VEHICLES DO NOT COMPLY WITH THE REQUIREMENTS.
OWNERS WILL BE PROVIDED A LABEL WITH THE REQUIRED STATEMENT, ALONG WITH INSTRUCTIONS FOR AFFIXING THE LABEL AT THE FUEL FILLER DOOR. OWNER NOTIFICATION BEGAN NOVEMBER 2, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V284000 on NHTSA.gov
Seat beltsAug 18, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
DEALERS WILL INSPECT THE DATE CODE ON CERTAIN SEAT BELT BUCKLES OF YOUR VEHICLE AND REPLACE ALL SEAT BELT BUCKLES THAT FALL WITHIN THE SUSPECT DATE CODE RANGE. OWNER NOTIFICATION BEGAN OCTOBER 26, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V228001 on NHTSA.gov
Representative owner complaints: electrical system
210 reports, newest first. Show all
Electrical system, Dec 13, 2004, fire
CONSUMER PARKED VEHICLE IN DRIVEWAY AT 2:30 PM. AT 5:30 PM CONSUMER WAS AWAKENED BY A POPPING SOUND OUTSIDE. WHEN CONSUMER GOT OUTSIDE THE FRONT END OF THE VEHICLE WAS ON FIRE. CONSUMER PUT THE VEHICLE IN NEUTRAL AND ROLLED IT BACK FROM THE HOUSE. FIRE DEPARTMENT ARRIVED, BUT THE FIRE EVENTUALLY CONSUMED THE VEHICLE. CONSUMER FELT THAT AN ELECTRICAL PROBLEM CAUSED THE FIRE. *AK THE CONUSMER STATED THAT THE FIRE WAS AN ELECTRICAL FIRE THAT STARTED UNDER THE HOOD. *TC
Electrical system, Dec 8, 2004, fire
CONSUMER WAS NOTIFIED THAT HIS VEHICLE WAS ON FIRE. CONSUMER NOTICED FLAMES COMING FROM UNDER THE HOOD. CONSUMER TRIED TO PUT THE FIRE. OUT, BUT COULDN'T DO SO. THE FIRE DEPARTMENT ARRIVED AND EXTINGUISHED THE FIRE. VEHICLE WAS NOT TOWED.*AK
Electrical system, Dec 7, 2004, fire
DROVE VEHILCE ALL DAY. IN TOWN-VARIOUS JOB SITES. PARKED VEHICLE IN FRONT OF OFFICE . APPROXIMATELY 45 MINUTES LATER HEARD LOUD POPPING. FOUND VEHICLE'S FRONT END COMPLETELY ENGULFED IN FLAMES. FIRE DEPARTMENT SAID MOST LIKELY DUE TO WIRING.*AK CRUISE CONTROL HAD STOPPED WORKING MONTH PRIOR.
Electrical system, Dec 1, 2004, fire
AT WORK CONSUMER PARKED VEHICLE AND ONE AND A HALF HOURS LATER SMOKE WAS SEEN COMING FROM UNDER THE HOOD. IT LOOKED LIKE FIRE WAS COMING FROM DRIVERS SIDE OF THE ENGINE COMPARTMENT. THE CRUISE CONTROL STOPPED WORKING ABOUT 3 MONTHS BEFORE THE FIRE. VEHICLE INSURED THROUGH ALLSTATE. *AK
Electrical system, Dec 1, 2004, fire
THE VEHICLE WAS PARKED INSIDE THE GARAGE AND IT CAUGHT ON FIRE. THE FIRE DEPARTMENT WAS CALLED TO EXTINGUISH THE FIRE. VEHICLE WAS TOWED AND TOTALED OUT BY THE INSURANCE COMPANY. *AK
Electrical system, Dec 1, 2004, fire
WHILE DRIVING FOR 1/2 HOUR AND PARKED FOR 1 HOUR AT STORE SMELLED SMOKE. OPENED HOOD SLIGHTLY CANDLE SIZED FLAME AT SCDS ATTACHED TO MASTER CYLINDER BROKE OUT. FIRE GREW AFTER HOOD OPENED. BRAKE FLUID RESEVOIUR WAS ON FIRE. SMOTHERED FIRE WITH TOWELS. HAD VEHICLE TOWED TO GAS STATION. DROVE AROUND HOME SLOWLY WITH BRAKES THAT STILL REMAINED ON. BOUGHT NEW MASTER CYLINDER FOM JUNK YARD.*AK....AKSO, CRUISE CONTROL WAS MELTED. *AK
Electrical system, Nov 29, 2004, fire
MY 2000 F-150 CAUGHT ON FIRE AND BURNED AFTER BEING PARKED FOR 7 HOURS. THE FIRE STARTED UNDER THE HOOD AND APPEARS TO HAVE STARTED ON OR AROUND THE MASTER CYLINDER. THE TRUCK WAS A TOTAL LOSS.*AK
Electrical system, Nov 11, 2004, fire
OUR 2000 FORD F-150 HAD NOT HAD ANY PREVIOUS PROBLEMS. ONE MORNING IT WAS DRIVEN FOR ABOUT 40 MINUTES, THEN PARKED IN A LOT. WHILE IN THE LOT, IT CAUGHT FIRE (WITH NOT EVEN A KEY IN THE IGNITION). WE THINK IT HAD MAYBE BEEN PARKED AN HOUR BEFORE IT CAUGHT FIRE, BUT NOBODY KNOWS FOR SURE BECAUSE SOMEONE ELSE SPOTTED IT BURNING. FIRE INSPECTORS DETERMINED THAT THE FIRE STARTED IN THE ENGINE COMPARTMENT, AND THAT THERE WAS NO FOUL PLAY. THE FIRE APPEARED TO START TOWARDS THE FRONT, AND ON THE BATTERY SIDE. BY THE TIME SOMEONE NOTICED IT AND CALLED THE FIRE DEPARTMENT, MOST OF THE ENGINE AND HOOD AREA HAD PRETTY MUCH BEEN TORCHED. IT WAS PUT OUT BY THE FIRE DEPARTMENT AND WE CONSIDERED IT A TOTAL LOSS. WE CONTACTED THE FORD DEALER WHERE THE CAR WAS PURCHASED, AND THE FORD MOTOR COMPANY. BOTH REPLIED THAT THEY WERE NOT RESPONSIBLE AND UNWILLING TO HELP IN ANY WAY. 8JB
Electrical system, Oct 26, 2004, fire
VEHICLE WAS PARKED AT 8:30 PM AND AT 2:30 AM NEIGHBOR HEARD LOUD BANG, SAW VEHICLE ON FIRE. CONSUMER STATED THAT CRUISE CONTROL STOPPED WORKING ABOUT A WEEK PRIOR TO THE FIRE. #2/13 AND 14 FUSES FOUND OPERATING.*AK
Electrical system, Vehicle speed control, Oct 26, 2004, fire
WHILE VEHICLE WAS PARKED FOR ABOUT 3 HOURS A NEIGHBOR ALERTED CONSUMER THAT VEHICLE WAS ON FIRE. BURNED FOR APPROXIMATELY 5 MINUTES. FUSES #2/13, AND 14 FOUND OPERATING. CONSUMER STATED THAT CRUISE CONTROL STOPPED WORKING IN THE WEEK BEFORE THE FIRE. *AK
Electrical system, Oct 21, 2004, fire
FIRE WAS MINOR AND IN LEFT REAR CORNER OF ENGINE COMPARTMENT. THE ONLY ITEM THAT ACTUALLY BURNED WAS THE CRUISE CONTROL DEACTIVATION SWITCH (CCDS). THE 15 AMP FUSE FOR THAT CIRCUIT WAS BLOWN. THE SWITCH HEAD WAS PHOTOGRAPHED INITIALLY BUT WAS DAMAGED AND LOST WHEN SOMEONE VANDALIZED THE TRUCK IN STORAGE. HOWEVER, THE CONNECTOR FOR THE CCDS REMAINED AND ONE OF THE BRASS CONTACTS WAS STILL INSERTED. IT WAS MELTED OFF FROM ELECTRICAL ARCING ACTIVITY.
Electrical system, Vehicle speed control, Oct 7, 2004, fire
FIRE IN ENGINE COMPARTMENT AFTER SITTING PARKED FOR 2.5 HOURS. FIRE STARTED NEAR THE MASTER CYLINDER. CRUISE CONTROL WAS NOT WORKING SINCE THE PURCHASE OF THE VEHICLE IN NOVEMBER 2003. PLEASE CONTACT FIRE INVESTIGATOR MIKE BERES 214-946-8989. *AK
Electrical system, Sep 14, 2004, fire
FIRE OCCURRED IN LR QUADRANT OF ENGINE COMPARTMENT WHILE VEHICLE WAS PARKED AND NOT RUNNING. ORIGIN IS AT MASTER BRAKE CYLINDER. OWNER RELATES THAT 30-45 DAYS PRIOR TO FIRE THE CRUISE CONTROL HAD FAILED INTERMITTANTLY SEVERAL TIMES AND THEN BECAME INOPERATIVE. HAS TWO COMPLAINTS ON DIFF VEH. SEE ODI #10090873
Electrical system, Air bags, Sep 14, 2004, crash
WHILE DRIVING 40 MPH, THE CONSUMER'S VEHICLE WAS INVOLVED IN FRONT END COLLISION. UPON IMPACT, FRONT AIR BAGS DID NOT DEPLOY. THE VEHICLE WAS TOWED. THE DEALERSHIP WAS NOTIFIED,BUT DID NOT RESOLVE THE PROBLEM. *AK THE INTERIOR LIGHTS GAVE NO PRIOR INDICATION THAT THE COMPONENTS WERE FAULTY. THE FUSES, RELAYS, AND BATTERY WERE INACCESSIBLE DURING DISMANTLING AND ONCE AGAIN, THE AIR BAGS FAILED TO DEPLOY. *SC
Electrical system, Sep 12, 2004, fire
FIRE ORIGINATED IN VEHICLE WHILE PARKED AND RUNNING. OWNER HAD PARKED VEHICLE AND EXITED IT TO OPEN A GATE. SMELLED SMOKE AND OBSERVED SMOKE ISSUING FROM UNDER LR HOOD. OBSERVED A SMALL FIRE AT THE LOCATION OF THE CRUISE CONTROL DE-ACTIVATION SWITCH. FIRE PROPOGATED RAPIDLY AND ULTIMATELY CAUSED HEAVY DAMAGE TO VEHICLE.*AK
Electrical system, Vehicle speed control, Aug 31, 2004, fire
2000 FORD F150 PICKUP TRUCK WITH APPROX. 126,000 MILES, CAUGHT FIRE IN THE ENGINE COMPARTMENT AFTER BEING PARKED ABOUT 5 HOURS. FIRE LOCATION WAS AT THE LEFT SIDE OF THE ENGINE COMPARTMENT. THE CAUSE OF THE FIRE IS BELIVED TO BE THE SCDS (SPEED CONTROL DISENGAGEMENT SWITCH). FIRE DAMAGED TRUCK AND EDGE OF CARPORT. *AK
Electrical system, Aug 17, 2004, fire
FORD F150 4X4 SPORT EXTENDED CAB 5.4L V8 ELECTRICAL FAILURE CAUSED ENGINE TO SPONTANEOUSLY COMBUST INTO ROARING FLAMES. TRUCK WAS A TOTAL LOSS. TRUCK WAS NOT RUNNING NOR BEING ATTEMPTED TO START AT THE TIME. TRUCK HAD NOT BEEN DRIVEN FOR 8 HOURS PRIOR TO THE FIRE. FORD MOTOR CO WILL DO NOTHING TO CORRECT OR EVEN DISCUSS THIS PROBLEM. THEY CLAIM THEIR IS NOT A PROBLEM WITH THIS TRUCK DESPITE THE 179 TECHNICAL SERVICE BULLETINS ON THE TRUCK AND THE NUMEROUS TIMES SPONTANEOUS COMBUSTION OF THIS VEHICLE HAS BEEN REPORTED TO THE US DEPT OF TRANS. IF ANYONE CAN PROVIDE ANY INFORMATION OR NEEDS ANY INFORMATION PLEASE FEEL FREE TO CONTACT ME 513-225-1247 CATHERINE . *JB
Power train, Electrical system, Aug 14, 2004
ELECTRICAL PROBLEMS. MOST SIGNIFICANTLY THE TRUCK SHUT OFF WHILE I WAS DRIVING DOWN A ROAD AT ABOUT 50MPH. ZERO ELECTRICAL AND THE POWER STEARING WAS OUT AND I HAD TO MUSCLE THE TRUCK TO THE SIDE OF THE ROAD, MY WIFE WOULD NOT HAVE BEEN ABLE TO DO THIS.I WAITED ABOUT 15 MINUTES AND IT STARTED. HAD I BEEN IN A TURN I MAY NOT HAVE BEEN ABLE TO TURN THE TRUCK FAST ENOUGH AND HIT ONCOMMING CARS. I TOOK IT IN TO JOHN ELWAY FORD DEALERSHIP AND THEY SAID THEY COULDNT FIND ANYTHING WRONG WITH IT AND SAID THEY COULD DO NOTHING. THEY SAID THERE WAS NO ERROR CODE LOGGED IN THE COMPUTER SO NOTHING WAS DONE. TODAY, AUG 13, 2004 THE TRUCK STARTED BUT THE ODOMETER WAS NOT LIT BUT THEN LIT WHEN I BACKED OUT OF MY PARKING SPACE. MY WIFE LATER TOOK THE TRUCK TO THE STORE THEN TO A PLAYGROUND WHERE IT FAILED TO START AGAIN. THIS IS THE THIRD OCCURANCE OF THIS AND THE FORD DEALERSHIP SAID THEY COULD NOT FIND ANYTHING WRONG. WHEN I CALLED FORD THEY AGREED THAT THEY COULD NOT DO ANYTHING IF THEY COULD NOT RECREATE THE PROBLEM. I ALSO HAVE AN OCCASIONAL GRINDING FROM 2ND TO 3RD GEAR THAT I HAVE TAKEN IT IN FOR SEVERAL TIMES ONLY TO BE TOLD SORRY WE CANT RECREATE THE PROBLEM. MY MAIN CONCERN IS LOSING ELECTRICAL POWER WHILE DRIVING. IF THIS HAPPENS TO MY PREGNANTE WIFE I AM VERY CONCERNED THAT SHE COULD GET INTO A BAD ACCIDENT.*AK
Electrical system, Aug 12, 2004, fire
UNDERHOOD FIRE IN THE LEFT REAR ENGINE COMPARTMENT. VEHICLE WAS PARKED SEVERAL HOURS BEFORE FAILURE IN A PARKING LOT. OTHERS BROUGHT THE FIRE TO THE OWNERS ATTENTION WHO WAS AT WORK. NOT REPAIRABLE.*AK
Electrical system, Aug 11, 2004, fire
VEHICLE BEING DRIVEN. SMOKE OBSERVED COMING FROM ENGINE COMPARTMENT. *JB
Electrical system, Aug 5, 2004, fire
FIRE IN 2000 FORD F-150 PICKUP TRUCK. PARKED VEHICLE IN DRIVEWAY. FIVE MINUTES LATER TRUCK WAS SEEN ON FIRE. HAD 46000 MILES ON ODOMETER. FIRE ORIGIN AT BRAKE MASTER CYLINDER. SPEED CONTROL DEACTIVATION SWITCH STILL IN POSITION BUT FIRE DAMAGED. XRAYS OF PLASTIC SWITCH HEAD SHOW ONE CONTACT TOTALLY DESTROYED BY ELECTRICAL ARCING. FUSE FOR THE SCDS WAS BLOWN AFTER THE FIRE. *AK
Electrical system, Aug 4, 2004
MY FORD FOCUS IGNITION LOCKED UP ON MY CAR AND I HAD TO HAVE MY CAR TOWED TO FORD WEST DEALERSHIP AND WAS CHARGED $40.00 FOR TOWING. I THEN HAD TO PAY $398.00 TO HAVE MY IGNITION REPAIRED WHICH SEEMS TO BE A COMMON DEFECT WITH FORD FOCUS. I SAW ON THE INTERNET WHERE THIS IS A COMMON PROBLEM WITH THE FORD FOCUS. I FEEL THAT I SHOULD BE REIMBURSE BECAUSE IT'S NOT MY FAULT THAT THIS A DEFECT PROBLEM WITH FORD. *AK
Electrical system, Jul 31, 2004, fire
UPON RETURNING FROM LUNCH, I PARKED MY 2000 F-150 EXT CAB AND TURNED OFF THE MOTOR, PLACED MY KEYS IN MY POCKET AND RETRUNED TO MY DESK TO COMPLETE THE DAYS WORK. ABOUT TWO HOURS LATER, I RECEIVED A CALL FROM A CO-WORKER INFORMING ME THAT MY TRUCK WAS ON FIRE. I IMMEDIATELY WENT OUT TO WHERE I HAD PARKED AND A FIRE TRUCK WAS ALREADY ON THE SCENE GETTING READY TO PUT OUT THE FIRE. BY THIS TIME THE FLAMES WERE SHOOTING UP ABOUT 12 FEET HIGH, THE HOOD HAD ALREADY MELTED ALONG WITH ALL OTHER ALUMINUM ON THE ENGINE BLOCK, THE PLASTICS ON THE FRONT GRILL, THE WINDSHIELD HAD MELTED AND THE INTERIOR WAS SEVERLY DAMAGED. A POLICE REPORT WAS FILED ALONG WITH A CLAIM WITH MY INSURANCE COMPANY. *AK UPON FURTHER INVESTIGATION, AFTER THE FACT, I LATER LEARNED THAT THIS HAS BEEN A KNOWN PROBLEM WITH OTHER F-150 OWNERS WHERE THEIR PICKUPS ALSO HAD SPONTANEOUS COMBUSTION RESULTING IN TOTAL DAMAGE THEIR VEHICLE AND IN SOME CASES, LOSS OF THEIR HOMES.
Service brakes, Hydraulic, Electrical system, Jun 28, 2004
HAD ABS REPLACED NUMEROUS TIMES ON MY 2000 F-150 COME TO FIND OUT THE WIRING HARNESS HAS BEEN DEFECTIVE THE WHOLE TIME AND HAS JUST BEEN DISCOVERED TO BE THE CULPRIT. FORD HAS AGREED TO PAY 50% OF COST BUT I CAN'T BE THE ONLY ONE WITH A DEFECTIVE HARNESS, RIGHT?*AK
Electrical system, Jun 25, 2004, fire
WHILE IN THE STREET VEHICLE WAS IN PARK AND THE KEY WAS TAKEN OUT OF THE IGNITION SWITCH. THEN, VEHICLE CAUGHT ON FIRE UNDER THE HOOD, FOLLOWED BY BLACK SMOKE AND LARGE FLAMES. THE FIRE DEPARTMENT INDICATED THAT IGNITION SWITCH CAUSED THE FIRE. *AK