2000 Ford F-150
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 1,204 owner complaints filed for this model year. This is the 3rd highest complaint count among 26 F-150 model years with reports.
Of the 2000 reports, 92 involved a crash and 361 involved a fire. 79 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lighting, headlightsAug 1, 2006
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 28, 2006. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.
Campaign 06E067000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Campaign 06E065000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Vehicle speed controlSep 7, 2005
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
A FIRE AT THE SWITCH COULD OCCUR.
BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)
Campaign 05V388000 on NHTSA.gov
Vehicle speed control, cruise controlJan 27, 2005
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
THIS CONDITION COULD LEAD TO A FIRE. FIRES HAVE OCCURRED WHILE THE VEHICLES WERE PARKED WITH THE IGNITION 'OFF.'
AS AN INTERIM REPAIR, OWNERS WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. AS SOON AS REPLACEMENT PARTS ARE AVAILABLE (EARLY APRIL 2005), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A NEW SWITCH FREE OF CHARGE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V388 AND 06V286)
Campaign 05V017000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Equipment, other, labelsSep 21, 2000
VEHICLE DESCRIPTION: BI-FUEL CNG PICKUP TRUCKS AND BI-FUEL CNG VANS, MODIFIED BY CFI CONTROL SYSTEMS, INC., FAIL TO CONFORM TO THE REQUIREMENTS OF FMVSS NO. 303, "FUEL SYSTEM INTEGRITY OF COMPRESSED NATURAL GAS VEHICLES." THE LABEL AFFIXED TO THE FUEL FILLER DOOR BY THE VEHICLE MODIFIER CONTAINS THE INSPECTION DATE AND EXPIRATION DATE OF THE CNG TANK. HOWEVER, IT DOES NOT CONTAIN THE STATEMENT "SEE INSTRUCTIONS ON THE FUEL CONTAINER FOR INSPECTION AND SERVICE LIFE."
THESE VEHICLES DO NOT COMPLY WITH THE REQUIREMENTS.
OWNERS WILL BE PROVIDED A LABEL WITH THE REQUIRED STATEMENT, ALONG WITH INSTRUCTIONS FOR AFFIXING THE LABEL AT THE FUEL FILLER DOOR. OWNER NOTIFICATION BEGAN NOVEMBER 2, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V284000 on NHTSA.gov
Seat beltsAug 18, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
DEALERS WILL INSPECT THE DATE CODE ON CERTAIN SEAT BELT BUCKLES OF YOUR VEHICLE AND REPLACE ALL SEAT BELT BUCKLES THAT FALL WITHIN THE SUSPECT DATE CODE RANGE. OWNER NOTIFICATION BEGAN OCTOBER 26, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V228001 on NHTSA.gov
Representative owner complaints: engine and engine cooling
158 reports, newest first. Show all
Engine and engine cooling, Feb 10, 2010, fire
THE FACTORY SPARK PLUG BLEW OUT OF THE CYLINDER HEAD ON MY FORD F-150. MY WIFE WAS DRIVING THE VEHICLE HOME AFTER PICKING MY SON UP FROM DAYCARE. A FIRE STARTED UNDER THE HOOD AND PASSER BY WAS KIND ENOUGH TO STOP AND HELP PUT IT OUT. I HAD A MACHINIST FIX THE HEAD AND I AM ABLE TO DRIVE THE TRUCK AGAIN. IT SCARES ME TO THINK THAT A MANUFACTURER IS ALLOWED TO PRODUCE A VEHICLE THAT COULD HAVE KILLED MY FAMILY. I HAVE LEARNED THAT I WILL NEVER OWN ANOTHER FORD VEHICLE WITH THIS TYPE OF ENGINE AND I WILL ENCOURAGE OTHERS TO THE SAME. *TR
Engine and engine cooling, Dec 29, 2009, fire
TL* THE CONTACT OWNS A 2000 FORD F-150. WHILE PARKED HE NOTICED FLAMES FROM UNDERNEATH THE HOOD OF THE VEHICLE. THE FIRE DEPARTMENT EXTINGUISHED THE FLAMES. THE VEHICLE WAS COMPLETELY DESTROYED. A FIRE REPORT WAS AVAILABLE. THE CAUSE OF THE FAILURE HAS NOT BEEN DETERMINED. A TECHNICIAN FROM THE DEALER STATED THAT HIS COMPLAINT WOULD BE FORWARDED TO THE OFFICE OF GENERAL COUNCIL AND THAT THEY WILL GIVE HIM A CALL BACK. THE VEHICLE WAS TOWED TO A FORD COLLISION CENTER FOR INSPECTION. THE FAILURE AND CURRENT MILEAGES WERE 125000.
Engine and engine cooling, Dec 26, 2009
SPARK PLUG BLOW OUT ON 2000 F150 5.4 TRITON ENGINE. DAMAGING COIL AND HEAD. RELEASING FUEL MIXTURE INTO ENGINE COMPARTMENT CREATING AN ENVIRONMENT FOR POTENTIAL EXPLOSION. *TR
Engine and engine cooling, Nov 27, 2009
2000 FORD F-150 #3 SPARK PLUG BLOWS OUT OF CYLINDER HEAD. THIS INCIDENT HAS HAPPENED TWICE. *TR
Engine and engine cooling, Oct 20, 2009, fire
I PARKED MY 2000 FORD F 150 , ABOUT [2] HRS LATER I HEARD NOISES OUTSIDE, I WENT TO SEE WHAT THE NOISE WAS, AND MY TRUCK WAS IN FLAMES. *TR
Engine and engine cooling, Sep 27, 2009
2000 FORD F-150 BLEW OUT A SPARK PLUG WHILE DRIVING ON HIGHWAY. *TR
Engine and engine cooling, Sep 20, 2009, fire
2000 FORD F150. BLEW NO. 3 SPARK WHILE DRIVING. IT BLEW AT PARTIAL THROTTLE, 45 MPH. TRUCK HAS BEEN PROPERLY MAINTAINED, NEVER HAD THIS HAPPEN ON ANY OTHER CAR I EVER OWNED. COME TO FIND OUT THIS A COMMON PROBLEM ON TRITON V-8 ENGINES. I'VE OWNED CARS WITH ALUMINUM HEADS BEFORE SO FOR FORD TO CLAIM ITS A TORQUING PROBLEM AND THE FAULT OF THE OWNER IS DISGRACEFUL TO ALL THE PEOPLE THAT MAINTAIN THEIR OWN CARS. FORTUNATELY THE FIRE WAS ONLY TEMPORARY AND WENT OUT WHEN I STOPPED THE TRUCK AND KILLED THE ENGINE, BUT THERE OBVIOUSLY HAD BEEN A FIRE AT SOME POINT. THIS IS THE SAME TRUCK THAT HAS ALREADY BEEN RECALLED ONCE, STILL HAVE A BURN MARK ON THE MASTER CYLINDER RESERVOIR FROM WHERE IT ALMOST BURST INTO FLAMES IN MY DRIVEWAY ONE DAY, THANK GOD I JUST SO HAPPENED TO HAVE THE HOOD UP TO REPLACE MY COOLANT WHEN IT HAPPENED, OR THE WHOLE TRUCK WOULD HAVE BURNT DOWN, I MANAGED TO PULL THE FUSE BEFORE IT DID, BUT FOR THIS TO HAPPEN ON TOP OF THAT IS RIDICULOUS. *TR
Engine and engine cooling, Jul 23, 2009, fire
ON WEDNESDAY, JULY 22, 2009, I DROVE TO WORK AND ARRIVED AT 9:00AM WITHOUT INCIDENT. AT 11:00AM I WAS NOTIFIED THAT MY TRUCK (2000 FORD F150) WAS ON FIRE IN THE PARKING LOT. IT APPEARS THAT AN ELECTRICAL FIRE HAD STARTED IN THE ENGINE COMPARTMENT. I READ LATER (ONLINE) THAT THERE IS A RECALL ON NUMEROUS FORD VEHICLES REGARDING A DEFAULT WITH A CRUISE CONTROL SWITCH THAT HAS CONSTANT POWER THAT HAS LEAD TO NUMEROUS F150'S (AND OTHER FORD VEHICLES) TO UNEXPECTEDLY BURST INTO FLAMES. THIS APPEARS TO HAVE BEEN CAUSED BY THIS PROBLEMATIC SWITCH BECAUSE THE FIRE STARTED IN THE LOCATION WHERE THIS DEFECTIVE SWITCH IS LOCATED. FORTUNATELY NOBODY WAS INJURED AND THE VEHICLE WAS INSURED.*TR
Engine and engine cooling, May 23, 2009
I OWN A 2000 FORD F-150, TRITON 4.6 LITER. JULY 2007, BLOWN SPARK PLUG FROM CYLINDER HEAD; COST FOR REPAIR $636.00. MAY 2009, BLOWN SPARK PLUG (#3) FROM CYLINDER HEAD; COST FOR REPAIR $606.00 PLUS $81.00 FOR RENTAL VEHICLE. I UNDERSTAND FORD WILL NOT TAKE RESPONSIBILITY FOR REPAIRING AND OR REIMBURSING A CUSTOMER FOR THEIR EXPENSES. SIGNED, ANOTHER UNHAPPY FORD OWNER. *TR
Engine and engine cooling, May 19, 2009, fire
TL*THE CONTACT OWNS A 2000 FORD F-150. THE VEHICLE CAUGHT FIRE WHILE PARKED IN FRONT OF THE CONTACT'S RESIDENCE. THE CONTACT STATED THAT THE FIRE ORIGINATED UNDER THE HOOD AND THEN SPREAD TO THE FRONT SEAT AND REAR OF THE VEHICLE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE AND FILED A REPORT. THERE WERE NO INJURIES. THE FAILURE MILEAGE WAS 148,000.
Engine and engine cooling, Apr 13, 2009, fire
2000FORD F150 BURNED TO THE GROUND CAUSING DAMAGE TO HOUSE. *TR
Engine and engine cooling, Mar 6, 2009, fire
TL*THE CONTACT OWNS A 2000 FORD F150. WHILE DRIVING APPROXIMATELY 20 MPH, THE CONTACT NOTICED SMOKE COMING FROM THE FRONT END OF HIS VEHICLE. HE THEN NOTICED FLAMES COMING FROM THE FUEL INJECTOR CYLINDERS. THE CONTACT EXTINGUISHED THE FLAMES. PRIOR TO THE FAILURE, THE VEHICLE WAS REPAIRED ACCORDING TO NHTSA CAMPAIGN ID NUMBER 05V388000 (VEHICLE SPEED CONTROL). THE VEHICLE HAS NOT YET BEEN TAKEN TO THE DEALER TO DETERMINE THE CAUSE OF THE FAILURE. NO REPAIRS HAVE BEEN MADE. THE FAILURE AND CURRENT MILEAGES WERE 222,000.
Engine and engine cooling, Feb 6, 2009
MY FORD-150 PICK-UP STARTED MAKING A SMALL NOISE FOR A FEW DAYS. I WENT OUT TO START MY TRUCK AND IT NO LONGER WAS A SMALL NOISE BUT ONE BIG LOUD NOISE. I HAD MY OIL AND PLUGS CHANGED ON OCTOBER 15, 2008. UPON RAISING THE HOOD I FOUND THAT ONE OF THE SPARK PLUGS HAD BLOWN OUT FROM WHERE IT WAS SUPPOSE TO BE. THE PLUG LOOKED LIKE IT WAS THE OLD ONE AND THAT MADE ME THINK THAT THEY HAD NOT CHANGED MY PLUGS. THE TRUCK WAS TOWED TO THE DEALER AND HE INFORMED ME THAT THE PLUG WAS ONE OF THE NEW ONES BUT THAT THE HEAD HID BLOWN THE PLUG OUT. (I HOPE I AM SAYING THIS RIGHT). THE SERVICE MANAGER TOLD ME THAT THERE HAD BEEN A LOT OF PROBLEMS WITH THIS HAPPENING TO THE FORD TRUCKS BUT THAT NO RECALL HAD EVER BEEN ISSUED. IT SEAMS THAT THERE IS SOME WEAK SPOTS DUE TO THE METAL NOT BEING STRONG ENOUGH TO HOLD THE PLUGS IN. I HAVE BEEN RESEARCHING THIS PROBLEMS AND THERE ARE A LOT OF PEOPLE COMPLAINING ABOUT THIS SAME SITUATION. *TR
Engine and engine cooling, Jan 19, 2009
I WAS BACKING OUT OF MY DRIVEWAY AND ONE OF MY SPARKPLUGS BLEW OUT OF THE HOLE. I HAD TO BRING IT TO THE SHOP WHERE THEY RETAPPED THE HOLE AND INSTALLED A NEW SPARK PLUG FOR A TOTAL OF 275.00. *TR
Engine and engine cooling, Jan 10, 2009, fire
MY FORD F150 WAS PARKED IN MY DRIVEWAY FOR APPROXIMATELY 24 HOURS WITHOUT BEING USED. I WAN NOTIFIED THE TRUCK WAS ON FIRE IN MY DRIVEWAY, BURNING THE ENTIRE ENGINE COMPARTMENT AND THE WHOLE CAB OF MY TRUCK. I ALSO SUSTAINED DAMAGE TO MY FENCE AND MY NEIGHBORS FENCE. THE HEAT WAS SO INTENSE IT MELTED THE VINYL SIDING ON THE ENTIRE SIDE OF MY HOUSE WHERE VEHICLE WAS PARKED. THE VEHICLE WAS APPROXIMATELY 12 FEET FROM HOUSE. *TR
Engine and engine cooling, Dec 8, 2008
MY 2000 FORD F-150 W/ A TRITON 5.4 L ENGINE (: ) BLEW THE #3 SPARK PLUG. THERE WERE NO UNUSUAL EVENTS LEADING UP TO THE FAILURE. I TOOK THE TRUCK TO THE DEALER AND THEY WANTED TO CHARGE ME $3000 FOR A NEW HEAD OR $1000 FOR INSERTION OF A HELICOIL. I KNOW THAT THIS IS HAPPENING ON MANY TRUCKS LIKE MINE. WHY IS FORD NOT BEING FORCED TO TAKE RESPONSIBILITY FOR THIS FAILURE? IT IS OBVIOUS TO ME THAT IT IS NOT IMPROPER INSTALLATION OF A SPARK PLUG, A FEW TOO MANY COINCIDENCES FOR THAT I THINK. *TR
Engine and engine cooling, Tires, Aug 29, 2008, fire
THE TRUCK WAS DRIVEN TO 2MILES VERY CLOSE TO HOME. THIS IS THE FIRST TIME OCCURING. THE TRUCK CAUGHT ON FIRE AND WHAT I DID WAS CALL THE FIRE FIGHTERS TO COME. THEREFORE I GOT THE HOSE AND POINTED IT AT THE TRUCK AND IT TURNED OFF. *TR
Engine and engine cooling, Power train, Tires, Jun 16, 2008
I WAS JUST DRIVING AND FELT A VIBRATION AND HAVE SPENT A LOT OF MONEY TRYING TO FIGURE THE PROBLEM OUT AND NO ONE KNOWS WHY IT IS VIBRATING. I HAVE HAD MY TIRES ROAD FORCED AND CHECK. I HAVE HAD AN ALIGNMENT. I HAVE HAD MY CRANKSHAFT CHECKED. I HAVE HAD THE TIRES BALANCED. I SAW A BULLETIN ON VALVES AND THAT SEEMS TO BE THE CLOSEST TO MY SITUATION I HAVE THE INFORMATION ON THE VALVES AND WILL BE HAPPY TO SHARE THAT WITH YOU. I HAVE SPENT A LOT OF MONEY AT THE DEALER AND INDEPENDENT SHOPS EVEN A TRANSMISSION SHOP AND NO ONE CAN FIGURE IT OUT. I WOULD LIKE TO HAVE THIS 1-2 YEAR PROBLEM SOLVED. THE FRONT END HAS BEEN REPLACED AND CHECK AS WELL. *TR
Engine and engine cooling, May 15, 2008, fire
2000 FORD F-150 BURST INTO FLAMES WHILE PARKED IN MY DRIVEWAY ON MAY 15TH AT 3:30 PM. VEHICLE WAS NOT RUNNING, NO KEY IN THE IGNITION, HAD NOT BEEN STARTED OR DRIVEN ON SAID DATE. *TR
Engine and engine cooling, Equipment, Dec 29, 2007
OUR RV SEEMED SLUGGISH ON GOING UP ON HILLS, THEN SUDDEN ENGINE FAILURE WHILE GOING UPHILL ON HWY 77 IN WV. TOWED TO A LARGE AAA REPAIR CENTRE, WHERE THEY LOOKED INTO SOME SPARK PLUGS AND PULLED 5 OUT, ONE OF WHICH WAS SO BADLY DAMAGED, FLATTENED WITH TWISTED THREADS, THEY DETERMINED IT NEEDS A NEW ENGINE. HAD IT TOWED AGAIN DEC. 26 TO AN AUTHORIZED FORD DEALER. THEY INSPECTED THE ENGINE AND FOUND A HOLE IN ONE OF THE PISTONS. REPAIR WOULD BE NEW ENGINE ASSEBLY. NOT ONE THAT HAS SEEN THE SPARK PLUG AND KNOW THE MILES (29,500) ON THIS RV BELIEVE THAT THIS COULD OR SHOULD HAPPEN. IT NEEDS TO BE TOWED AGAIN TO A CAPABLE REPAIR SHOP, WHICH SEEMS TO BE EXTREMELY HARD TO FIND. FORDS MOTOR COMPANY ANSWER IS THAT WARRANTY TIME IS OVER, FIX IT AND PAY FOR IT. APPRX. ESTIMATES ARE $6000.00 - 7000.00. THIS JUST HAPPENING BEFORE CHRISTMAS INVOLVES SO MANY PERSONAL HARDSHIPS, INCLUDING 19 HOUR BUS TRIP GOING NORTH, CANCELLATIONS OF SO MANY RESERVATIONS, INCLUDING AIRLINE TICKETS. THIS IS FAR FROM BEING OVER, AND THE REPAIR COSTS ARE UNBELIEVABLE AND WE ARE NOT READY FOR AND WE HAVE NO IDEA WHERE IT IS GOING TO BE REPAIRED. EVERYONE SEEMS TO THINK THAT IT MUST BE AN ORIGINAL MANUFACTURING DEFECT THAT THERE IS NO OTHER ANSWER TO HAVE A HOLE IN AT LEAST ONE PISTON AND HAVE THAT LOSE METAL PIECE SOMEWHERE IN THE ENGINE MAYBE CAUSING MORE DAMAGE IF THE WHOLE ENGINE IS NOT CHANGED. WE ARE HELPLESS AND FAR AWAY FROM OUR RV. *TR
Engine and engine cooling, Dec 28, 2007
ENGINE EJECTED SPARK PLUG TWICE IN ONE MONTH (TWO DIFFERENT PLUGS) INCIDENTALLY THE SPARK PLUGS HAD NOT RECENTLY BEEN CHANGED SO IT WASN'T AN OVERTIGHTENING PROBLEM. I HAD CHECKED HE TORQUE ON THE SPARKS ABOUT A MONTH BEFORE THE INCIDENTS AND THEY WERE TORQUED TO THE FACTORY SPECS. *TR
Engine and engine cooling, Dec 14, 2007, fire
FRANKLIN (TN) FIRE DEPARTMENT RESPONDED TO A VEHICLE FIRE AT 108 CALVECADE CIR. UPON ARRIVAL WE FOUND ONE PICKUP TRUCK AT THE ENGINE COMPARTMENT FULLY INVOLVED. WE EXTINGUISHED THE FIRE WITH A 1 3/4 HOSE FROM THE FRONT BUMPER. VEHICLE DETAILS ARE AS FOLLOWS: MAKE: FORD SHIPPING DATE: 01/20/00 DEALER CODE: 23I050 INVOICE DATE: 01/18/00 INVOICE NUMBER: 2FYCA49209 MCO ISSUED: Y HORSEPOWER: 4030 NUMBER OF CYLINDERS: 8 SHIPPING WEIGHT: 4312 GROSS VEHICLE WEIGHT: 63000 COLOR UP: R1 COMPONENT PARTS COMPONENT TYPE: AIRBAG (DRIVER) COMPONENT ID: 2AJX355M30521 COMPONENT TYPE: AIRBAG (PASSENGER) COMPONENT ID: RA0131129 DEALER - 1 DEALER MAKE: FORD DEALER CODE: 23I050 DEALER: MURPHY-GRAHAM FORD DEALER ADDRESS: LA PLACE, LA 700681417 DEALER PHONE: 5046512881 SET UP DATE: 02/07/95 DEALER STATUS: ACTIVE *TR
Engine and engine cooling, Nov 24, 2007
BLOWN HEAD GASKET A KNOWN ISSUE WITH THIS ENGINE 2500. TO FIX. SO MUCH FOR BUILT FORD TOUGH. *TR
Engine and engine cooling, Oct 23, 2007
SPARK PLUGS THAT WERE SUPPOSED TO LAST 100,000 MILES ( MOTORCRAFT PLATINUM) LASTED UNDER 55,000 MILES. THE PLUG SEPARATED FROM THE INSULATOR, ONE EVEN DISINTEGRATED, CAUSING MISSES IN THE ENGINE AND ALL THE WIRES TO THE PLUGS TO MELT AND ADHERE TO WHAT WAS LEFT OF THE PLUGS. 6 PLUGS - 6 CYLINDERS. *TR
Engine and engine cooling, Sep 6, 2007
30,000 MILES MOTOR STARTED KNOCKING, SPUN A BEARING, HAD MOTOR REPAIRED NOW MOTOR IS KNOCKING AGAIN. FORD MOTOR AND DEALERSHIP DENIED ANY RESPONSABILITY