2000 Ford F-150
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 1,204 owner complaints filed for this model year. This is the 3rd highest complaint count among 26 F-150 model years with reports.
Of the 2000 reports, 92 involved a crash and 361 involved a fire. 79 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lighting, headlightsAug 1, 2006
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 28, 2006. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.
Campaign 06E067000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Campaign 06E065000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Vehicle speed controlSep 7, 2005
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
A FIRE AT THE SWITCH COULD OCCUR.
BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)
Campaign 05V388000 on NHTSA.gov
Vehicle speed control, cruise controlJan 27, 2005
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
THIS CONDITION COULD LEAD TO A FIRE. FIRES HAVE OCCURRED WHILE THE VEHICLES WERE PARKED WITH THE IGNITION 'OFF.'
AS AN INTERIM REPAIR, OWNERS WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. AS SOON AS REPLACEMENT PARTS ARE AVAILABLE (EARLY APRIL 2005), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A NEW SWITCH FREE OF CHARGE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V388 AND 06V286)
Campaign 05V017000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Equipment, other, labelsSep 21, 2000
VEHICLE DESCRIPTION: BI-FUEL CNG PICKUP TRUCKS AND BI-FUEL CNG VANS, MODIFIED BY CFI CONTROL SYSTEMS, INC., FAIL TO CONFORM TO THE REQUIREMENTS OF FMVSS NO. 303, "FUEL SYSTEM INTEGRITY OF COMPRESSED NATURAL GAS VEHICLES." THE LABEL AFFIXED TO THE FUEL FILLER DOOR BY THE VEHICLE MODIFIER CONTAINS THE INSPECTION DATE AND EXPIRATION DATE OF THE CNG TANK. HOWEVER, IT DOES NOT CONTAIN THE STATEMENT "SEE INSTRUCTIONS ON THE FUEL CONTAINER FOR INSPECTION AND SERVICE LIFE."
THESE VEHICLES DO NOT COMPLY WITH THE REQUIREMENTS.
OWNERS WILL BE PROVIDED A LABEL WITH THE REQUIRED STATEMENT, ALONG WITH INSTRUCTIONS FOR AFFIXING THE LABEL AT THE FUEL FILLER DOOR. OWNER NOTIFICATION BEGAN NOVEMBER 2, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V284000 on NHTSA.gov
Seat beltsAug 18, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
DEALERS WILL INSPECT THE DATE CODE ON CERTAIN SEAT BELT BUCKLES OF YOUR VEHICLE AND REPLACE ALL SEAT BELT BUCKLES THAT FALL WITHIN THE SUSPECT DATE CODE RANGE. OWNER NOTIFICATION BEGAN OCTOBER 26, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V228001 on NHTSA.gov
Representative owner complaints: gasoline
126 reports, newest first. Show all
Fuel system, Gasoline, May 10, 2011
TL*THE CONTACT OWNS A 2000 FORD F-150. WHILE DRIVING APPROXIMATELY 20 MPH, A LOUD NOISE EMITTED FROM OUTSIDE OF THE VEHICLE. THE CONTACT DROVE ONTO THE EMERGENCY LANE AND NOTICED THAT THE FRONT DRIVERS SIDE FUEL TANK STRAP FRACTURED AND CAUSED THE FUEL TANK TO COMPLETELY DETACH FALLING ON THE GROUND. THE VEHICLE WAS TOWED TO A LOCAL INDEPENDENT MECHANIC WHERE BOTH FUEL TANK STRAPS WERE REPLACED. THE FAILURE MILEAGE WAS APPROXIMATELY 56,000.
Fuel system, Gasoline, May 10, 2011
GAS TANK FELL FROM VEHICLE WHILE DRIVING. *TR
Fuel system, Gasoline, May 9, 2011
I HAVE A 2000 FORD F150 AND I HEARD THAT THERE IS BEING AN INVESTIGATION INTO THE GAS TANK STRAPS RUSTING THROUGH AND DROPPING THE TANK. THIS HAPPENED TO MY TRUCK CAUSING THE TANK TO DROP TO THE ROAD AND DRAG, ALSO CAUSING THE TANK TO SPRING A LEAK (NEEDING TO BE REPLACED). THE TANK, STRAPS, VENT TUBE, ETC. WERE REPLACED AT A COST OF NEAR $700.00. I WAS WONDERING WHAT STEPS IF ANY I CAN TAKE TO GET REIMBURSED FOR THIS COST. THANK YOU UPDATED 08/05/11 *BF THE CONSUMER STATED BOTH OF THE STRAPS WERE CORRODED. UPDATED 08/15/11 *TR
Fuel system, Gasoline, May 9, 2011
TL* THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT STATED THAT WHILE REFUELING THE VEHICLE, HE NOTICED THAT THE FUEL TANK WAS HANGING ABNORMALLY BECAUSE THE STRAPS WERE CORRODED AND FRACTURED. THE VEHICLE WAS NOT INSPECTED OR REPAIRED FOR THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE PROBLEM. THE CURRENT MILEAGE WAS 151,788. THE FAILURE MILEAGE WAS APPROXIMATELY 149,000.
Fuel system, Gasoline, May 9, 2011
A STRAP WHICH HOLDS ON THE GAS TANK ON MY 2000 FORD F150 BROKE WHILE I WAS DRIVING AND DRAGGED APPX. 300 YARDS, CAUSING ABOUT 10 GALLONS TO LEAK OUT ON ROAD. THE LOCAL FIRE DEPT. HAD TO BE DISPATCHED, AND I HAD TO REPLACE THE ENTIRE TANK AND STRAP SYSTEM AT A COST OF OVER $800.00. THE LOCAL FORD DEALER THAT DID THE REPAIR DID NOT MENTION ANYTHING ABOUT A KNOWN PROBLEM. UPDATED 08/04/11 *BF THE CONSUMER STATED THE STRAP FURTHEST TO THE FRONT WAS THE ONLY STRAP THAT BROKE AND CAUSED THE FORWARD PART OF THE TANK TO DRAG. THE BREAK APPEARED TO BE IN THE CENTER OF THE STRAP ON THE BOTTOM FACING THE ROAD. THE ENTIRE METAL PART OF THE STRAP WAS EXTREMELY CORRODED. THE REAR WAS SIMILAR, BUT SEEMED TO HAVE ADDED SUPPORT FROM THE FILL NOZZLE AND CAP ASSEMBLY. ALSO TWO YEARS PRIOR, THE LOWERING SPARE TIRE CABLE WAS CORRODED AND BROKE WHILE DRIVING, WHICH CAUSED THE TIRE TO DROP TO THE GROUND. UPDATED 08/15/11 *TR
Fuel system, Gasoline, May 8, 2011
I WAS DRIVING MY FORD F150 WHEN SUDDENLY I HEARD A SOUND THAT SOUNDED LIKE SOMETHING WAS CAUGHT UNDER THE TRUCK. SLOWLY PULLED OVER AND FOUND THE GAS TANK WAS ON THE GROUND, HELD UP ON ONE END BY A HOSE. GOOD THING I WAS NOT GOING FAST OR ON A BUMPY ROAD. IF THE TANK HAD HIT A BUMP IT WOULD HAVE BEEN CRUSHES AND POSSIBLY EXPLODED. HAD ABOUT A HALF TANK OF GAS. REPAIRS ARE ESTIMATED AT $270 SO FAR. *TR
Fuel system, Gasoline, Apr 9, 2011
VEHICLE IS A 2000 FORD F 150. DAUGHTER FILLED THE TANK ON 4/8/2011. TANK FELL OFF THE VEHICLE WHILE TRAVELING ON A MAJOR HIGHWAY AT SPEED. BOTH SUPPORT STRAPS FAILED BY BREAKING IN HALF. TRUCK WAS SAFELY PULLED TO SIDE OF THE ROAD BUT ENTIRE CONTENTS OF FUEL TANK SPILLED ONTO THE HIGHWAY BERM. TRUCK WAS TOWED TO SERVICE STATION FOR REPAIR. *TR
Fuel system, Gasoline, Apr 8, 2011
S10 APPROPRIATE HANDLING-LETTER TO SECRETARY FROM CONCERNS REGARDING GAS TANK SAFETY. *KB 200 FORD F150. THE CONSUMER STATED THE FUEL LEAK WAS A RESULT OF A TANK STRAP THAT RUSTED. ALSO, THE OTHER STRAP IS SEVERELY CORRODED. UPDATED 01/28/11 UPDATED 03/08/11 UPDATED 04/08/11
Fuel system, Gasoline, Apr 5, 2011
THE GAS TANK FELL OFF OUR TRUCK NO EVENTS LEADING TO THE FAILURE WE REPAIRED THE DAMAGE TO THE TANK AND BOUGHT NEW STRAPS AND PUT THE TANK BACK ON THE TRUCK GAS SPILLED WHEN THIS HAPPENED.. AND MY HUSBAND HD TO GET 6 STITCHES IN HIS FINGER ALSO THE OXYGEN SENSORS KEEP READING BAD CHECK ENGINE LIGHT ON AND WE HAVE CHANGED ALL AIR INTAKE THINGS. *TR
Fuel system, Gasoline, Mar 20, 2011
I WAS DRIVING DOWN A CITY STREET AND HEAR A LOUD METAL SCRAPING SOUND COMING FROM UNDER MY TRUCK. I IMMEDIATELY PULLED OVER AND STOPPED. WHEN I LOOKED UNDER MY TRUCK MY GAS TANK WAS DRAGGING ON THE GROUND. THE FRONT METAL BRACKET HAD RUSTED THROUGH AND BROKEN. THERE WAS GAS LEAKING FROM THE TANK AND THE FIRE DEPARTMENT RESPONDED. THERE WAS NO FIRE. TO SAY THE LEAST THIS IS OUTRAGEOUS AND TOTALLY UNACCEPTABLE FOR ANY CAR OR TRUCK. I HAVE SEEN MANY OTHER REPORTS ABOUT THIS PROBLEM WITH THIS TRUCK. WHY HASN'T THERE BEEN A RECALL? I WAS LUCKY THERE WASN'T A FIRE. SOMEONE WILL EVENTUALLY BE KILLED BY THIS DEFAULT. *TR
Fuel system, Gasoline, Mar 15, 2011
PULLING INTO A PARKING SPACE, I HEARD A LOUD BANG AND A DRAGGING SOUND. I GOT OUT OF MY VEHICLE TO SEE WHAT I HAD BACKED INTO, BUT COULDN'T SEEN ANYTHING. I WENT TO GET BACK INTO MY VEHICLE AND HEARD SOMEONE SAY, "SOMETHING IS HANGING UNDER YOUR TRUCK". WHEN I GOT OUT AND LOOKED, I SAW THE GAS TANK LAYING ON THE GROUND. UPON INSPECTION, BOTH STRAPS HAD BROKEN AND THE FUEL LINES WERE THE ONLY THING HOLDING IT TO THE TRUCK. THIS OCCURRED ONLY ONCE SO FAR. THE TRUCK IS A 2000 F150 WITH 150,000 MILES ON IT. I REPLACED THE TWO STRAPS AFTER PURCHASING THEM FROM A DEALER. I WAS SHOCKED TO SEE THAT A 24 GALLON TANK WAS HELD UP BY TWO SMALL METAL STRAPS ATTACHED TO THE FRAME BY A BOLT ON ONE SIDE, AND A TWIST LOCK (IF YOU CAN CALL IT THAT) ON THE OTHER. I HOPE FORD HAS FOUND A BETTER WAY TO ATTACH THESE ON THEIR NEWER VEHICLES, ESPECIALLY 4-WHEEL DRIVE. *TR
Fuel system, Gasoline, Mar 8, 2011
TL* THE CONTACT OWNED A 2000 FORD F-150. WHILE DRIVING APPROXIMATELY 5 MPH, THE CONTACT HEARD SOMETHING FALL FROM UNDER THE VEHICLE. THE CONSUMER PULLED OVER AND STOPPED. THE CONTACT EXITED THE VEHICLE AND DISCOVERED THE FUEL TANK WAS DETACHED FROM THE FRAME OF THE VEHICLE AND LAYING ON THE PAVEMENT UNDERNEATH THE VEHICLE STILL ATTACHED TO THE GAS HOSE. THE CONSUMER MANAGED TO RE-ATTACH THE TANK TO THE VEHICLE USING A COAT HANGER. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP WHERE THE CONTACT WAS TOLD THAT THE STRAPS WHICH HELD THE FUEL TANK WERE SEVERELY CORRODED. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 155,140 AND THE CURRENT MILEAGE WAS UNKNOWN. UPDATED 04/25/11 *BF AN INSPECTION REVEALED THE STRAPS HOLDING THE TANK WHICH WAS MADE OUT OF VERY THIN MATERIAL HAD CORRODED AND BROKEN A PART ALLOWING THE FUEL TANK TO FALL OFF. THE CONSUMER HAS SINCE TRADED THE VEHICLE. UPDATED 09/12/11
Fuel system, Gasoline, Mar 2, 2011
I WAS DRIVING MY FORD F150 PICK UP TRUCK AND HEARD SOMETHING LIKE I DROPPED AN EXHAUST PIPE. LUCKILY I WAS DRIVING SLOWLY ABOUT 20-25 MPH. I STOPPED AND GOT OUT TO SEE WHAT HAD HAPPENED. MY GAS TANK THAT I HAD JUST FILLED THE OTHER DAY FELL OFF. BOTH STRAPS BROKE AND I WAS DRAGGING THE TANK ON THE GROUND. I HAD IT TOWED TO MY HOUSE FOR REPAIR. AFTER NOTICING THAT THE FUEL FILL PIPE HAD RUSTED OFF NEAR THE TANK AND BOTH STRAPS HAD FAILED. I DECIDED IT WAS TO MUCH FOR MYSELF TO REPAIR. I BELIEVE I NEED A NEW GAS TANK AND NEW STRAPS. FUEL WAS THROWN UP UNDER MY TRUCK. I CONTACTED FORD BUT THEY WERE OF LITTLE HELP. PROBABLY NOT GOING TO BUY ANOTHER ONE. A TEN YEAR OLD TRUCK THIS SHOULDN'T HAPPEN TO! THERE WAS NO FIRE BUT I'M REALLY GLAD I DIDN'T HAVE MY GRANDSON IN THE TRUCK OR THAT I WAS DRIVING DOWN THE HIGHWAY! *TR
Fuel system, Gasoline, Feb 22, 2011
REAR FUEL TANK STRAP RUSTED THROUGH ON 2000 FORD F-150.*TR
Fuel system, Gasoline, Feb 22, 2011
TL*THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE FUEL TANK FELL TO THE GROUND AND BEGAN LEAKING FUEL; FIRE SPARKS BEGAN TO ERUPT. THE CONTACT PULLED OVER AND THE VEHICLE WAS TOWED TO A REPAIR SHOP WHERE THE CONTACT WAS INFORMED THAT THE FUEL TANK STRAPS HAD RUSTED WHICH CAUSED THE TANK TO FALL. THE CONTACT CALLED THE MANUFACTURER WHO OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 195,000.
Fuel system, Gasoline, Feb 15, 2011
DRIVING DOWN THE ROAD AT APPROX 45 MPH WHEN THE FRONT END OF THE GAS TANK FELL ON THE ROAD. WHEN TRUCK WAS PLACED ON TOW TRUCK IT WAS OBVIOUS THE STRAPS HAD BROKEN HOLDING THE GAS TANK ONTO THE TRUCK. DUE TO THE GAS TANK FALLING TO THE GROUND OTHER PARTS WERE DAMAGED AS WELL.
Fuel system, Gasoline, Feb 13, 2011
APPROXIMATELY (5:45 PM) ON MON.,1- 24-11. I WAS COMING HOME HAD FUELED UP MY TRUCK (THEN AT 3/4S FULL) FOR WEEK WHEN I NOTICED A SCRAPING/DRAGGING SOUND COMING FROM REAR OF THE TRUCK JUST AFTER CROSSING A DOUBLE RR-TRACK ON A PAVED TWO LANE ROAD. NOWHERE TO PULL OVER AFTER A WET SNOWFALL ON NARROW SHOULDER, I PUT ON 4-WAYS AND CREPT TO THE NEAREST DRIVEWAY AT A DRUGSTORE. I EXITED TRUCK TO CHECK OUT THE NOISE, TO MY SHOCK I SAW MY FORWARD END OF FUEL TANK WAS ON THE GROUND AND SPILLING FUEL. I CALLED 911, POLICE AND FIRE (EQUIPPED TO STABILIZE THE FUEL SPILL) AND A TOW COMPANY WERE SENT TO ASSIST. A REPORT WAS MADE BY THE LOCAL POLICE. THE TRUCK WAS THEN TAKEN BY MY REQUEST TO THE FORD DEALERSHIP WHERE IT HAD BEEN PURCHASED NEW. NEXT DAY: THE DEALERSHIP QUOTED AN ASTRONOMICAL PRICE FOR REPLACEMENT OF DAMAGED PARTS & LABOR (1600-2000). AFTER RESEARCH HAD THE TRUCK TOWED TO ANOTHER FACILITY FOR THE REPAIRS WHICH WERE COMPLETED THE SAME WEEK BY THAT THU. EVENING. I DO HAVE THE DEFECTIVE PARTS IN MY POSSESSION (FUEL TANK STRAPS). THIS WAS OUT OF POCKET (EXCEPT FOR THE ORIGINAL TOW; INSURANCE REIMBURSED 50.) HAD TO BARROW AND REFUEL A VEHICLE AS WELL TO GET TO WORK. DUE TO SOME FORD MOTOR CO. CONNECTIONS THROUGH MY BUSINESS CLIENTS I HAVE RECEIVED A PHONE CALL FROM THEIR CORPORATE OFFICES FOR WHICH I HAD A 30 MIN. CONVERSATION WITH A REP. WHO NEEDED A WEEK TO RESEARCH MY VERBAL COMPLAINT. THIS PERSON DID TRY TO CALL ME BACK ON THU.2-10-11 BUT I WAS NOT AVAILABLE (DUE TO MY WORK HOURS). IN THE FIRST PHONE CALL I SPOKE OF MY KNOWLEDGE OF FORD RECEIVING A LETTER FROM (ODI) BACK IN 9-24-10. IF THEY KNEW WHY WASN'T THIS PROBLEM CHECKED IF MY TRUCK HAD BEEN IN & OUT OF A FORD SERVICE FACILITY THE LAST 3 MO.'S OF 2010. I MADE IT KNOWN THAT I WOULD BE FILING A COMPLAINT WITH YOUR ADMINISTRATION AND I WOULD BE WARNING EVERYONE I KNOW FOR FEAR THAT THIS COULD HAPPEN TO OTHERS. I ALSO TOLD THEM THAT I HOPED THAT FORD MOTOR CO. WOULD ISSUE A RECALL. *TR UPDATED 08/01/11 *BF UPDATED 08/02/11
Fuel system, Gasoline, Jan 18, 2011
AFTER I FILLED UP WITH GAS, I SMELLED GAS. AFTER THIS HAPPENED A COUPLE OF TIMES, I NOTICED GAS DRIPPING FROM THE TANK. UPON INSPECTION, I NOTICED THAT THE LEAK WAS NEAR THE FILLER NECK, BUT THE ROOT CAUSE WAS THAT ONE OF THE TANK STRAPS WAS COMPLETELY RUSTED AWAY, THE OTHER IS SEVERELY CORRODED; THE LEAK AT THE NECK IS BECAUSE THE WEIGHT OF THE TANK IS BEING SUPPORTED BY THE NECK. I SEE THAT SEVERAL DOZEN CASES HAVE OCCURRED WHERE THE TANK HAS FALLEN OUT OF THE TRUCKS GOING DOWN THE ROAD, AND THE "CRACK STAFF" AT NHTSA HAS BEEN "STUDYING" THIS SINCE SEPTEMBER TO SEE IF THIS IS A "SAFETY CONCERN", BUT THEY ARE EITHER TOO INEPT, TOO CORRUPT, OR TOO LAZY TO DO THEIR JOBS. THIS IS THE SAME LACK OF CONCERN FOR AMERICAN CONSUMERS THAT ALLOWED PEOPLE TO DIE FROM THE TOYOTA SUDDEN ACCELERATION ISSUE. TAKE YOU R TIME GUYS, YOU ARE ONLY PLAYING ROULETTE WITH HUMAN LIVES!!!!! I WILL QUOTE [XXX] "SHAME ON NHTSA FOR NOT DOING YOUR JOB." I HOPE THE NEW CHAIRS OF ENERGY AND COMMERCE AND OVERSIGHT AND REFORM HAVE MORE RESPECT FOR HUMAN LIFE THAN THE LAST ONES. IF SO, NHTSA MAY BE COMPELLED TO DO ITS JOB! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Fuel system, Gasoline, Jan 17, 2011
GAS TANK STRAPES RUSTED, CAUSING THE GAS TANK TO FALL FROM TRUCK.
Fuel system, Gasoline, Jan 11, 2011
TL*THE CONTACT OWNS A 2000 FORD F150. THE CONTACT NOTICED THAT THE FILLER NECK WAS LEAKING GASOLINE SIMILAR TO NHTSA CAMPAIGN ID NUMBER: 06E056000 ( FUEL SYSTEM, GASOLINE). THE FUEL TANK STRAP WAS ALSO CORRODED WHICH ADDED TO THE FAILURE. THE DEALER OR MANUFACTURER HAD NOT BEEN NOTIFIED NOR WAS THE VEHICLE DIAGNOSED OR REPAIRED. THE CURRENT MILEAGE WAS APPROXIMATELY 210,000. THE FAILURE MILEAGE WAS APPROXIMATELY 202,000. THE VIN WAS UNAVAILABLE.
Fuel system, Gasoline, Dec 21, 2010
FILLED UP WITH FUEL. DROVE APPROX. 2 MILES AND FUEL TANK FELL OFF DUE TO RUSTED TANK STRAPS. DEALER REPLACED STRAPS AND BROKEN FUEL VAPOR VALVE. VEHICLE HAD 62260 MILES AT THE TIME. I HAVE PARTS OF BOTH STRAPS. *TR UPDATED 08/01/11 *BF UPDATED 08/01/11
Fuel system, Gasoline, Oct 4, 2010
TL* THE CONTACT OWNS A 2000 FORD F-150. WHILE TRAVELING 55 MPH, THE CONTACT NOTICED A DRAGGING NOISE COMING FROM THE REAR OF THE VEHICLE. AFTER EXAMINING THE VEHICLE, THE CONTACT DISCOVERED THAT THE FRONT END OF THE FUEL TANK WAS DRAGGING ONTO THE PAVEMENT. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHERE THE CONTACT WAS INFORMED THAT THE FUEL TANK WOULD NEED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE CURRENT AND FAILURE MILEAGE WAS 213,000. UPDATEDD 09/07/11
Fuel system, Gasoline, Sep 27, 2010
TL* THE CONTACT OWNS A 2000 FORD F150. THE CONTACT WAS DRIVING 60 MPH WHEN THE FUEL TANK STRAPS FRACTURED AND CAUSED THE FUEL TANK TO FALL TO THE GROUND, SPEWING GASOLINE ONTO THE HIGHWAY. THE FIRE DEPARTMENT WAS CALLED TO CLEAN THE FUEL FROM THE HIGHWAY. THE VEHICLE WAS TOWED TO A NEARBY LOT WHERE THE CONTACT WAS AWAITING FOR REPAIRS. THE DEALER AND THE MANUFACTURER WERE NOT YET CONTACTED. THE FAILURE MILEAGE WAS 70,000.
Fuel system, Gasoline, Sep 24, 2010
2000 FORD F150 - BOTH STRAPS THAT HOLD FUEL TANK RUSTED IN HALF AND THE FUEL TANK FELL WHILE DRIVING DOWN THE ROAD. THE FRONT OF THE TANK WAS DRAGGING THE PAVEMENT. THE TRUCK OTHERWISE HAS NO RUST. MAJOR SAFETY CONCERN!!!!!!!! *TR
Fuel system, Gasoline, Sep 23, 2010
ACCELERATED FROM INTERSECTION; HEARD NOISE; THOUGHT WAS EXHAUST PIPE DROPPED AND WAS BEING DRAGGED; SMELLED FUEL; STOPPED AND SAW THAT FUEL TANK HAD FALLEN ONTO THE ROAD; TANK MORE THAN 3/4 FULL HAD SPLIT AND WAS LEAKING FUEL; CALLED 911 FOR FIRE DEPARTMENT AND POLICE; FIRE DEPARTMENT LIFTED TANK AND FUEL GUSHED OUT; FIRE DEPARTMENT USED A WEDGE OF WOOD TO PLUG TANK AS GOOD AS POSSIBLE THOUGH TANK WAS NEARLY EMPTY BY THAT TIME; TOW TRUCK ARRIVED; TOWED TRUCK TO DEALER; CLEANED UP MORE ABOUT 19 GALLONS OF FUEL; WILL DISCUSS REPAIRS WITH DEALER TOMORROW; ASSUMPTION IS THAT A NEW TANK, STRAPS AND POSSIBLE FUEL LINE WILL BE NEEDED. DO NOT BELIEVE POLICE MADE A REPORT SINCE NO ACCIDENT OR INJURIES OCCURRED. UPDATED 12/08/10 *TR