2000 Ford F-150
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 1,204 owner complaints filed for this model year. This is the 3rd highest complaint count among 26 F-150 model years with reports.
Of the 2000 reports, 92 involved a crash and 361 involved a fire. 79 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lighting, headlightsAug 1, 2006
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 28, 2006. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.
Campaign 06E067000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Campaign 06E065000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Vehicle speed controlSep 7, 2005
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
A FIRE AT THE SWITCH COULD OCCUR.
BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)
Campaign 05V388000 on NHTSA.gov
Vehicle speed control, cruise controlJan 27, 2005
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
THIS CONDITION COULD LEAD TO A FIRE. FIRES HAVE OCCURRED WHILE THE VEHICLES WERE PARKED WITH THE IGNITION 'OFF.'
AS AN INTERIM REPAIR, OWNERS WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. AS SOON AS REPLACEMENT PARTS ARE AVAILABLE (EARLY APRIL 2005), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A NEW SWITCH FREE OF CHARGE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V388 AND 06V286)
Campaign 05V017000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Equipment, other, labelsSep 21, 2000
VEHICLE DESCRIPTION: BI-FUEL CNG PICKUP TRUCKS AND BI-FUEL CNG VANS, MODIFIED BY CFI CONTROL SYSTEMS, INC., FAIL TO CONFORM TO THE REQUIREMENTS OF FMVSS NO. 303, "FUEL SYSTEM INTEGRITY OF COMPRESSED NATURAL GAS VEHICLES." THE LABEL AFFIXED TO THE FUEL FILLER DOOR BY THE VEHICLE MODIFIER CONTAINS THE INSPECTION DATE AND EXPIRATION DATE OF THE CNG TANK. HOWEVER, IT DOES NOT CONTAIN THE STATEMENT "SEE INSTRUCTIONS ON THE FUEL CONTAINER FOR INSPECTION AND SERVICE LIFE."
THESE VEHICLES DO NOT COMPLY WITH THE REQUIREMENTS.
OWNERS WILL BE PROVIDED A LABEL WITH THE REQUIRED STATEMENT, ALONG WITH INSTRUCTIONS FOR AFFIXING THE LABEL AT THE FUEL FILLER DOOR. OWNER NOTIFICATION BEGAN NOVEMBER 2, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V284000 on NHTSA.gov
Seat beltsAug 18, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
DEALERS WILL INSPECT THE DATE CODE ON CERTAIN SEAT BELT BUCKLES OF YOUR VEHICLE AND REPLACE ALL SEAT BELT BUCKLES THAT FALL WITHIN THE SUSPECT DATE CODE RANGE. OWNER NOTIFICATION BEGAN OCTOBER 26, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V228001 on NHTSA.gov
Representative owner complaints: vehicle speed control
201 reports, newest first. Show all
Vehicle speed control, Service brakes, Aug 14, 2026, fire
Regarding NHTSA Recall Number 05V017000; * Component: Speed control deactivation switch. Available for inspection. * Safety Risk: Spontaneous fire occurred on 07/20/2026 at apx 1am destroying the vehicle, damaging two other vehicles, and nearly burning down our home. *Problem Reproduced: Unknown * Component Inspected: Yes, by HOI claims adjuster. * Any warning lamps/ messages?: I had been dealing with a engine light about 1 year earlier that popped up again about 3 months ago. The codes indicated "Lean bank-Right" and "Lean bank-Left". Facts: On July 20, 2026, at approximately 1:00 AM, my 1997 Ford F-150 spontaneously caught fire while parked in my garage. The vehicle had not been started for well over a week. The fire raged directly under our bedroom for over 40 minutes before the fire department was able to attempt containment, nearly burning our house to the ground. There were also two other vehicles in the garage at the time. We are currently in the early stages of a major Homeowners Insurance (HOI) restoration claim. Fortunately, the fire scene in the garage remains intact as of this date while the HOI conducts their investigations. We have learned that the likely cause is a poorly designed, defective cruise control system—a known Ford issue that has resulted in many spontaneous fires. Despite owning this vehicle since 1999, I never received notice from Ford, and was unaware of the associated manufacturer recall (NHTSA #05V017000).
Electrical system, Vehicle speed control, May 8, 2026, fire
The contact owns a 1998 Ford F-150. The contact stated that while The vehicle was park in the son's driveway the neighbor alerted the son that the vehicle on fire. The son rushed to the vehicle and discovered flames coming from the cabin of the vehicle. The Fire Department was called to the scene and extinguished the flames. During the incident the vehicle was destroyed. The cause of the fire was not determined. The local dealer and manufacturer was not contacted regarding the failure. A fire report was take at the scene.. The failure mileage was 190,000.
Vehicle speed control, Aug 8, 2025
The contact owns a 1997 N/A Ford F-150. The contact stated that while servicing the vehicle independently, the contact unplugged the cruise control deactivation sensor and became aware of condensation leaking from the sensor. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 132,000.
Vehicle speed control, Apr 23, 2025, fire
The contact owned a 2000 Ford F-150. The contact stated that her son had parked the vehicle in the residence driveway and had turned off the ignition. The son had exited the vehicle and saw that a fireball had erupted from under the hood. The contact stated that she had reviewed the explosion on her home security camera. The contact stated that the fire department was called and extinguished the flames with water. A fire department report was not filed however it was commented that the origin was most likely an electrical fire. The contact stated that the vehicle was towed to an impound lot and was declared a total loss by her insurance company. The manufacturer was informed of the failure and referred the contact to the NHTSA Safety Hotline. The contact was aware of an open recall for the vehicle, NHTSA Campaign Number: 05V017000 (Vehicle Speed Control), which had a risk of fire. The contact was not the original owner of the vehicle. The failure mileage was approximately 150,000.
Electrical system, Vehicle speed control, Jan 9, 2020
TL* THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT STATED THAT THE CRUISE CONTROL FAILED TO ACTIVATE. THE CONTACT REPLACED THE CRUISE CONTROL START BUTTON HOWEVER WHEN PRESSED IT WOULD ACTIVATE THE HORN INSTEAD OF THE CRUISE CONTROL. IN ADDITION, THE CONTACT MENTIONED THAT THE ODOMETER WOULD INTERMITTENTLY ILLUMINATE TO DISPLAY THE MILEAGE OF THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO A DEALER AND WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 159,000.
Power train, Vehicle speed control, Other or unspecified, Nov 6, 2019
FIRST I PURCHASED THE FORD F-150 2000 YEAR MODEL FROM A CAR DEALERSHIP ON OCT 28, 2019. IMMEDIATELY THERE WAS PROBLEMS KEEPING IT RUNNING. THEY PUT A NEW BATTERY IN IT 2 DAYS LATER THEN WHILE REACHING 50 MPH MY TONS WOULD DROP AND THE TRUCK WOULD NOT ACCELERATE I HAD JUST PUT 51 DOLLARS IN THE TANK, THEN I PUSHED THE GAS TO THE FLOOR MY ROOMS WOULD GO ALL THE WAY TO 3 THEN I WOULD HAVE TO LET OFF THE GAS AND IT SEEMED TO DO A HARD SWITCH IN GEAR. AS THIS CONTINUED THE ENTIRE TRUCK SHOOK TILL I FIGURED OK JUST PUMP THE GAS AND LET OFF BEFORE THE SHAKING GOT TO BAD. NOW THE SHAKING AS GOTTEN WORSE AND THE TRUCK SEEMS TO NOT WANT TO ACCELERATE AT ALL OR DOES A HARD STALL. IT IS SUPPOSED TO HAVE A NEW LOW RANGE MOTOR WITH ONLY 100,000 MILES ON IT AT LEAST THE DEALER TOLD ME THAT, I ALSO VERBALLY MADE AN AGREEMENT WITH THE DEALER THAT IF ANYTHING WAS TO GO WRONG HE WOULD FIX IT, HE AGREED. NOW THAT I HAVE SEEN MY TRUCK HAS 18 RECALLS AND ONE THAT HAS NOT BEEN FIXED, A DUPLICATE TITLE AND HAD 2 LIENS I HONESTLY WANT MY MONEY BACK.IM A SINGLE MOTHER GOING TO COLLEGE AND I'M ALL MY DAUGHTER GOTS. I TOLD THE DEALER I NEEDED A RELIABLE VEHICLE. THE VEHICLE WAS IN MOTION ALL TIMES AND IT DOES IT ON THE HWY AND CITY STREETS.
Vehicle speed control, Aug 30, 2017, fire
AROUND 4A.M I SMELLED FROM MY ROOM SOMETHING BURNING I WOKE UP LOOKED OUT THE WINDOW & SAW FIRE COMING OUT OF MY 2000 F-150 PICK UP TRUCK FROM UNDER THE HOOD. WENT OUTSIDE & TOOK THE MATTER IN MY OWN HANDS I QUICKLY GOT THE HOUSE WATER HOSE & TURNED OFF THE FLAMES. THANK GOD FIRE DID NOT REACH ANY FUEL LINES NOBODY WAS INJURED & FIRE DID NOT REACH THE HOUSE. I WAS THINKING OF HOW COULD THIS HAPPEN IF MY TRUCK WAS NOT MOVED FOR 2 DAYS & WAS JUST PARKED IN FRONT OF MY HOME. I WENT AHEAD & DID SOME RESEARCH ON LINE & FOUND OUT THERE WAS A RECALL FOR MY VEHICLE SAFETY RECALL 05S28-SPEED CONTROL DEACTIVATION SWITCH FIRE.
Vehicle speed control, Aug 2, 2017, fire
TL* THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT STATED THAT WHILE AT A FAMILY FUNCTION, THE CONTACT'S RELATIVE MADE THEM AWARE THAT THE VEHICLE WAS IN FLAMES. THE FIRE DEPARTMENT WAS NOTIFIED AND EXTINGUISHED THE FIRE. A POLICE REPORT WAS FILED. THE VEHICLE WAS UNOCCUPIED THEREFORE THERE WERE NO INJURIES SUSTAINED. THE MATT HIKE FORD WAS NOTIFIED AND MADE THE CONTACT AWARE THE VEHICLE WAS INVOLVED NHTSA CAMPAIGN NUMBER: 05V017000 (VEHICLE SPEED CONTROL) HOWEVER THEY WERE NOT NOTIFIED OF THE FAILURE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND INFORMED THE CONTACT THAT DUE TO THE SITUATION THEIR INFORMATION WAS FORWARDED TO THE OFFICE OF THE GENERAL COUNCIL. THE FAILURE MILEAGE WAS APPROXIMATELY 152,000. PARTS DISTRIBUTION DISCONNECT.
Vehicle speed control, Jul 10, 2017, fire
TL* THE CONTACT OWNS A 2000 FORD F-150. WHILE THE VEHICLE WAS TURNED OFF AND UNATTENDED, THE VEHICLE CAUGHT FIRE. THE CONTACT WAS NOT PRESENT. THE FIRE DEPARTMENT WAS CALLED. THE FIRE DEPARTMENT AND A PASSERBY EXTINGUISHED THE FIRE. A FIRE REPORT WAS FILED. THE DEPUTY FIRE MARSHAL DIAGNOSED THAT THE FIRE WAS DUE TO THE SPEED CONTROL SYSTEM IN THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC. THE CONTACT WAS UNSURE IF THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V017000 (VEHICLE SPEED CONTROL). THE APPROXIMATE FAILURE MILEAGE WAS 158,000.
Vehicle speed control, Service brakes, Engine, Sep 12, 2016, fire
HAD DRIVEN APPROXIMATELY 5 MILES PARKED IN A LOWES PARKING LOT WENT INTO THE STORE FOR ABOUT 45MIN. ONLY TO COME OUT TO MY TRUCK ON FIRE. THE TRUCK WAS COMPLETELY OFF AND NO ONE WAS IN IT, AND THERE ARE ONLY 2 SETS OF KEYS ONE IN MY POCKET AND THE OTHER AT HOME. THE VEHICLE WAS LOCKED. PRIOR TO DRIVING THE 5 MILES IT HAD NOT BEEN DRIVEN IN 2 DAYS. FORD SAYS IT'S NOT THERE PROBLEM AND INSURANCE ONLY WANTS TO GIVE US $3,700.00. MY HUSBAND IS A RETIRED VETERAN AND THIS WHOLE SITUATION HAS CAUSED HIS PTSD TO BE TRIGGERED.
Vehicle speed control, Jun 22, 2016, fire
TL* THE CONTACT OWNS A 2000 FORD F-150. WHILE THE VEHICLE WAS PARKED FOR APPROXIMATELY FIVE HOURS ON THE STREET, THE VEHICLE CAUGHT FIRE AND WAS TOWED. THERE WERE NO WARNING INDICATORS ILLUMINATED PRIOR TO THE FAILURE. THE CONTACT WAS NOT AWARE OF A RECALL, ALTHOUGH NHTSA CAMPAIGN NUMBER: 05V017000 (VEHICLE SPEED CONTROL) WAS FOUND. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, CONFIRMED THE RECALL, AND PROMISED TO GET BACK TO THE CONTACT. THE FAILURE MILEAGE WAS 122,263.
Electrical system, Vehicle speed control, Service brakes, Engine, Nov 13, 2014, fire
CAR WAS PARKED, CAR CAUGHT ON FIRE DO TO RECALL 05S28, PUT OUT MYSELF. WAS NEVER INFORMED ABOUT RECALL BECAUSE I WAS SECOND OWNER. *TR
Electrical system, Vehicle speed control, Engine, Jan 1, 2013, fire
TRUCK WAS PARKED IN DRIVEWAY WHEN IT SUDDENLY CAUGHT ON FIRE UNDER THE HOOD BURNING THROUGH THE HOOD IN A MATTER OF SECONDS. FIREFIGHTERS CALLED TO THE SCENE SAID THEY HAVE NEVER SEEN ANYTHING LIKE IT BEFORE. I BELIEVE THIS FIRE WAS CAUSED BY THE SPEED CONTROL SWITCH, OF WHICH THERE HAVE BEEN AT LEAST TWO RECALLS ON OF WHICH WE WERE NEVER INFORMED ABOUT. *TR
Vehicle speed control, Dec 26, 2012, fire
TL* THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT STATED THAT THE VEHICLE CAUGHT ON FIRE. THE FIRE DEPARTMENT REPORTED TO THE SCENE TO EXTINGUISH THE FIRE. THE FIRE CHIEF ADVISED THE CONTACT THAT THE FIRE WAS CAUSED BY AN ELECTRICAL FAILURE BUT THE CAUSE OF THE FIRE WAS NOT DETERMINED. THE VEHICLE WAS INCLUDED IN AND PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 05V017000 (VEHICLE SPEED CONTROL:CRUISE CONTROL). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE MILEAGE WAS 149,000. *TR
Vehicle speed control, Electronic stability control (ESC), Jan 16, 2012, fire
2000 FORD F150 PICKUP WAS PARKED ON THE STREET AT MY MOTHER IN LAW'S HOUSE. IT HAD BEEN SITTING FOR ABOUT 2 HOURS WHEN WE HEARD THE HORN GOING OFF. WE LOOKED OUTSIDE AND THE FRONT OF THE TRUCK WAS ENGULFED IN FLAMES. THE FIRE GREW SO QUICKLY AND HAD BURNED OUT THE WHOLE CAB BY THE TIME THE FIRE DEPARTMENT GOT IT OUT. IT WAS A TOTAL LOSS, AND HAS PUT OUR FAMILY IN A HORRIBLE SITUATION. THE FIRE STARTED ON THE DRIVER SIDE UNDER THE HOOD. IT LOOKED TO BE ABOVE THE WHEEL AND NEAR THE WINDSHIELD. WHILE THE FIRE WAS BURNING, IT CAUSE THE WINDSHIELD TO EXPLODE, SHOOTING GLASS ALL OVER THE STREET. THE FIRE ALSO DAMAGED ANOTHER VEHICLE PARKED NEARBY. THE TRUCK IS A CHARRED SKELETON AND THE TIRES WERE EVEN MELTED TO THE CONCRETE! THERE IS ABSOLUTELY NOTHING LEFT. I AM GRATEFUL WE WERE NOT IN THE TRUCK OR DRIVING DOWN THE ROAD, BUT THIS IS SO UPSETTING. WE CANNOT AFFORD TO BUY A NEW VEHICLE, WHICH IS WHY WE WERE DRIVING A 13 YEAR OLD TRUCK TO BEGIN WITH. WE DID NOT HAVE THE MONEY FOR ANOTHER CAR PAYMENT. NOW -WE ARE WITHOUT A VEHICLE. *TR
Vehicle speed control, Nov 9, 2011, fire
TL* THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WAS PARKED WITH THE ENGINE TURNED OFF WHEN IT CAUGHT ON FIRE. THE FIRE DEPARTMENT DIAGNOSED THAT FLUID LEAKED INTO THE BRAKE MASTER CYLINDER AND CAUSED THE FIRE. A FIRE REPORT WAS FILED. THE VIN WAS INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 05V388000 (VEHICLE SPEED CONTROL), BUT THE CONTACT DID NOT RECEIVE A RECALL NOTICE IN THE MAIL. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED AND TOLD THE CONTACT THAT THEY WOULD PROCESS AN INVESTIGATION UPON THE GROUNDS THAT THE INSURANCE COMPANY WAS NOT CONTACTED. THE VEHICLE WAS DESTROYED. THE FAILURE AND THE CURRENT MILEAGE WAS 26,000.
Electrical system, Vehicle speed control, Nov 4, 2011
MY TRUCK WAS PARKED ON MY DRIVEWAY, AND HAD NOT BEEN DRIVEN IN ABOUT 2WKS. I DIDN'T EVEN THINK THAT THE BATTERY HAD A CHARGE. MY [XXX] WIFE AND A SALESMAN AND I JUST HAPPENED TO BE STANDING A FEW FEET AWAY HAVING A CONVERSATION, WHEN WE SMELLED WIRES BURNING. I QUICKLY RAISED THE HOOD OF THE TRUCK TO SEE THE PLUG WIRES CONNECTED TO THE BRAKE MASTER CYLINDER SMOKING. AT THAT TIME I OF COURSE DISCONNECTED IT. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Vehicle speed control, Oct 5, 2011, fire
ON TUESDAY OCTOBER 4, 2011 MY TRUCK CAUGHT FIRE WHILE SITTING IN A PARKING LOT AT MY WIFE'S PLACE OF EMPLOYMENT. THE TRUCK WAS NOT RUNNING AND HAD NO MAJOR MECHANICAL ISSUES. THE FIRE STARTED FROM THE ENGINE COMPARTMENT AND DAMAGED THE A MAJORITY OF THE FRONT END OF THE VEHICLE, IT IS TOTALED. I BELIEVE MY FORD TRUCK CAUGHT FIRE DUE TO A FAILURE IN THE CRUISE CONTROL WIRING SYSTEM AND A LEAK IN THE BRAKE FLUID SYSTEM. THERE WAS A RECALL FOR THE WIRING AND MY TRUCK WAS NOT FIXED DUE TO ME BEING THE SECOND OWNER. I WAS NOT AWARE OF THE RECALL UNTIL I SEARCHED THIS MORNING AFTER THE FIRE. *TR
Vehicle speed control, Jul 22, 2011, fire
TL* THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT STATED THAT THE VEHICLE CAUGHT ON FIRE WITHOUT WARNING. A FIRE REPORT WAS NOT FILED FOR THE INCIDENT AND THE CAUSE OF THE FIRE WAS UNKNOWN. NEITHER THE DEALER NOR MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 160,000. UPDATED 8/29/11 *CN THE CONSUMER BELIEVED THE CRUISE CONTROL DEACTIVATION SWITCH WAS TO BLAME FOR THE FIRE. UPDATED 09/09/11 THE MASTER CYLINDER WAS REPLACED AND THE BRAKE SYSTEM WAS BLEW. THE WIRING TO THE CRUISE CONTROL DEACTIVATION SWITCH WAS REPLACED AS WELL AS THE SPEED CONTROL CABLE. THE TURN SIGNALS, FUSE AND JUNCTION BOX WAS REPLACED. UPDATED 09/21/11
Vehicle speed control, Jul 13, 2011, fire
TL* THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT STATED WITNESSES NOTICED THE VEHICLE WAS ENGULFED IN FLAMES WHILE IT WAS PARKED. THE FIRE DEPARTMENT WAS CALLED AND EXTINGUISH THE FIRE. A REPORT WAS FILED AND THE FIRE DEPARTMENT STATED THE FIRE WAS CAUSED BY A MECHANICAL FAILURE. THE VEHICLE THAT WAS PARKED NEXT TO THE CONTACTS VEHICLE ALSO SUSTAINED DAMAGE. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE MILEAGE WAS 168,000. UPDATED 09/02/11*LJ UPDATED 09/16/11*JB
Vehicle speed control, Jun 28, 2011, fire
VEHICLE WAS PARKED AND IGNITION WAS OFF FOR APPROXIMATELY TWO HOURS AFTER NORMAL DRIVING CONDITIONS. VEHICLE ENGINE COMPARTMENT CAUGHT FIRE WHILE VEHICLE WAS PARKED AND UNATTENDED IN OWNER'S DRIVEWAY. *TR
Vehicle speed control, Jun 1, 2011, fire
TL*THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT STATED WHILE THE VEHICLE WAS PARKED, IT CAUGHT FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FLAMES. NO ONE WAS INJURED. THE INSURANCE AGENCY PERFORMED AN INVESTIGATION TO DETERMINE WHAT CAUSED THE FIRE. THE INVESTIGATION INDICATED THAT THE CRUISE CONTROL SWITCH CAUSED THE FIRE TO OCCUR. THE FAILURE MILEAGE WAS 125,000. UPDATED 07/15/11
Vehicle speed control, May 13, 2011, fire
2000 FORD F-150 TRUCK SPONTANEOUSLY COMBUSTED AT APPROXIMATELY 2AM ON MAY 12, 2011. TRUCK HAD BEEN PARKED SINCE 9AM THE PRECEDING DAY. FIRE INVESTIGATOR BELIEVES IT TO BE THE CRUISE CONTROL DEACTIVATION SWITCH PENDING FURTHER INVESTIGATION. *TR
Vehicle speed control, Feb 2, 2011, fire
MY 2000 FORD F-150 WAS IN FRONT OF MY DOCTOR'S OFFICE WHILE I WAS INSIDE FOR A DR. APPT. MONDAY, JANUARY 31, 2011. WHILE WAITING, THE RECEPTIONIST TOLD ME SHE THOUGHT MY TRUCK WAS ON FIRE. SMOKE WAS BILLOWING OUT FROM UNDER THE HOOD, BUT NO FLAMES WERE SEEN. THE FIRE DEPT. WAS CALLED, AND ONE OF THE FIREMEN TOLD ME THE ORIGIN OF THE FIRE WAS FROM THE CRUISE CONTROL SWITCH ON THE FRONT OF THE BRAKE MASTER CYLINDER. HE TOLD ME HE WAS AWARE OF A FORD RECALL ON THAT PART. I WAS NEVER MAILED ANY RECALL NOTICES!! THE FIRE MELTED THE CRUISE CONTROL SWITCH/WIRING, MELTED THE PLASTIC BRAKE FLUID RESERVOIR, AND ALSO DAMAGED THE MASTER CYLINDER. I HAD IT TOWED TO THE NEAREST DEALERSHIP. THIS IS MY FAMILY'S ONLY MEANS OF TRANSPORTATION, SO I ASKED FOR A LOANER OR RENTAL CAR WHILE MY TRUCK WAS BEING REPAIRED. THEY ARE REFUSING TO PAY FOR THE COST OF A REPLACEMENT VEHICLE AND ALSO, THEY ARE REFUSING TO REPAIR ANY ?RELATED DAMAGES? (BRAKE MASTER CYLINDER AND BRAKE FLUID RESERVOIR) AS A RESULT OF THE FIRE CAUSED BY THEIR DEFECTIVE PART. THEY SAID THEY WOULD ONLY MAKE REPAIRS ON THE RECALL PART BUT NOT REPAIRS TO RELATED DAMAGES? (BRAKE MASTER CYLINDER AND BRAKE FLUID RESERVOIR) CAUSED BYTHE FIRE. WHY AM I EXPECTED TO PAY FOR EXPENSES INCURRED BECAUSE OF A DEFECTIVE PART THAT WAS RECALLED BY FORD? THE RECALL IS A PAINFULLY OBVIOUS ADMISSION OF NEGLIGENCE THEY NEED TO TAKE RESPONSIBILITY FOR THE DAMAGES CAUSED TO MY TRUCK, AS WELL AS THE INCONVENIENCE AND HARDSHIP OF NOT HAVING A MODE OF TRANSPORTATION FOR MY FAMILY. WE ARE NOW A ONE INCOME FAMILY, (I LOST MY JOB 2 MONTHS AGO WHILE IN THE HOSPITAL) AND WE DO NOT HAVE MONEY TO PAY FOR THESE EXPENSES. LET ALONE OUR MONTHLY BILLS! I NEED IMMEDIATE RESOLUTION AND I AM NOT GETTING ANY COOPERATION OR ASSISTANCE FROM FORD'S CUSTOMER RELATIONSHIP SERVICES DEPARTMENT. THIS IS NOT ACCEPTABLE AND I WILL NOT ACCEPT THEIR LACK OF CONCERN OR ATTENTION TO MY URGENT SITUATION. *TR
Vehicle speed control, Feb 1, 2011, fire
TL*THE CONTACT OWNS A 2000 FORD F-150. WHILE THE VEHICLE WAS PARKED THE CONTACT STATED THAT THERE WAS SMOKE COMING FROM UNDERNEATH THE HOOD. WHEN THE CONTACT OPENED THE HOOD HE NOTICED THAT THE CRUISE CONTROL WIRING AND THE MASTER CYLINDER WERE ON FIRE. THE CONTACT STATED A FLAME BURNED THE TOP OF HIS HOOD. THE CONTACT EXTINGUISHED THE FIRE. THE FIRE DEPARTMENT WAS NOT CALLED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE THE TECHNICIAN STATED THAT THE MASTER CYLINDER AND THE CRUISE CONTROL NEEDED TO BE REPLACED. THE MECHANIC ALSO CONFIRMED THAT THE FIRE WAS CAUSED BY A FAULTY CRUISE CONTROL . THE VEHICLE WAS TOWED TO THE DEALER; HOWEVER, IT WAS NOT REPAIRED. THERE WAS A RECALL ON THE YEAR, MAKE AND MODEL OF THE VEHICLE BUT HIS VIN WAS NOT INCLUDED IN THE RECALL. THE APPROXIMATE FAILURE MILEAGE WAS 220,000.