2000 Ford F-150
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 1,204 owner complaints filed for this model year. This is the 3rd highest complaint count among 26 F-150 model years with reports.
Of the 2000 reports, 92 involved a crash and 361 involved a fire. 79 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lighting, headlightsAug 1, 2006
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 28, 2006. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.
Campaign 06E067000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Campaign 06E065000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Vehicle speed controlSep 7, 2005
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
A FIRE AT THE SWITCH COULD OCCUR.
BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)
Campaign 05V388000 on NHTSA.gov
Vehicle speed control, cruise controlJan 27, 2005
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
THIS CONDITION COULD LEAD TO A FIRE. FIRES HAVE OCCURRED WHILE THE VEHICLES WERE PARKED WITH THE IGNITION 'OFF.'
AS AN INTERIM REPAIR, OWNERS WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. AS SOON AS REPLACEMENT PARTS ARE AVAILABLE (EARLY APRIL 2005), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A NEW SWITCH FREE OF CHARGE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V388 AND 06V286)
Campaign 05V017000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Equipment, other, labelsSep 21, 2000
VEHICLE DESCRIPTION: BI-FUEL CNG PICKUP TRUCKS AND BI-FUEL CNG VANS, MODIFIED BY CFI CONTROL SYSTEMS, INC., FAIL TO CONFORM TO THE REQUIREMENTS OF FMVSS NO. 303, "FUEL SYSTEM INTEGRITY OF COMPRESSED NATURAL GAS VEHICLES." THE LABEL AFFIXED TO THE FUEL FILLER DOOR BY THE VEHICLE MODIFIER CONTAINS THE INSPECTION DATE AND EXPIRATION DATE OF THE CNG TANK. HOWEVER, IT DOES NOT CONTAIN THE STATEMENT "SEE INSTRUCTIONS ON THE FUEL CONTAINER FOR INSPECTION AND SERVICE LIFE."
THESE VEHICLES DO NOT COMPLY WITH THE REQUIREMENTS.
OWNERS WILL BE PROVIDED A LABEL WITH THE REQUIRED STATEMENT, ALONG WITH INSTRUCTIONS FOR AFFIXING THE LABEL AT THE FUEL FILLER DOOR. OWNER NOTIFICATION BEGAN NOVEMBER 2, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V284000 on NHTSA.gov
Seat beltsAug 18, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
DEALERS WILL INSPECT THE DATE CODE ON CERTAIN SEAT BELT BUCKLES OF YOUR VEHICLE AND REPLACE ALL SEAT BELT BUCKLES THAT FALL WITHIN THE SUSPECT DATE CODE RANGE. OWNER NOTIFICATION BEGAN OCTOBER 26, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V228001 on NHTSA.gov
Representative owner complaints: vehicle speed control
201 reports, newest first. Show all
Vehicle speed control, Mar 4, 2005, fire
WHILE VEHICLE WAS PARKED A FIRE STARTED UNDER THE HOOD. VEHICLE WAS TOTALED. DEALERSHIP WAS NOTIFIED, BUT NOT RESOLVE THE PROBLEM. *AK
Vehicle speed control, Mar 2, 2005, fire
VEHICLE WAS PARKED IN THE DRIVEWAY, AND CONSUMER WAS NOTIFIED BY A PASSERBY THAT THE VEHICLE WAS ON FIRE. THE ENTIRE FRONT HAD BEEN DESTROYED. CONSUMER WAS NOT NOTIFIED OF THE CRUISE CONTROL NHTSA RECALL CAMPAIGN 05V017000. *AK
Vehicle speed control, Mar 2, 2005, fire
ON JAUNUARY 28, 2005 I TOOK MY 2000 FORD EXPEDITION TO FAMILY FORD IN MARIETTA, OH TO HAVE THE NECESSARY ITEM DISCONNECTED TO AVOID A FIRE. I HAD HEARD THE CAUTION ON THE NATIONAL NEWS AND TOOK THE CAR IN ALMOST IMMEDIATELY. THE SERVICE DEPARTMENT OF ABOVE DEALERSHIP STATED THEY DISCONNECTED THE CRUISE CONTROL. DURING THE FIRST PART OF FEBRUARY 2005 I RECEIVED THE RECALL LETTER FROM FORD MOTOR COMPANY. I DID NOT ACT ON THE LETTER AS I HAD ALREADY DONE WHAT WAS RECOMMENDED AND PLANNED TO MAKE AN APPOINTMENT FOR A PERMANANT REPAIR WHEN THE PARTS BECAME AVAILABLE. ON 2-24-05 ABOUT 15-20 MINUTES AFTER I HAD PARKED THE CAR IN THE DRIVEWAY FOR THE NIGHT MY HUSBAND, WHO HAD BEEN OUTSIDE, OPENED THE DOOR AND CALLED IN "CALL 911 YOUR CAR IS ON FIRE". HE THEN WENT OUTSIDE AND TRIED TO USE THE FIRE EXTINGUISHER THROUGH THE GRILL TO STEM THE FIRE. THE WILLIAMSTOWN VOLUNTEER FIRE DEPARTMENT RESPONDED QUICKLY AND EFFICIENTLY, PUTTING OUT THE FIRE. IN ADDITION TO THE ENGINE/HOOD, ETC. DISAPPEARING IN THE FIRE, THE BATTERY BLEW UP AND THERE IS LEAD ALL OVER OUR HOUSE, YARD, AS WELL AS ANTI-FREEZE SOAKED INTO THE GRAVEL DRIVEWAY. CERTAINLY AN ENVIRONMENTAL HAZARD TO OUR FAMILY WHICH INCLUDES THREE DOGS. ALSO A PROBLEM FOR THE NEIGHBOR DOGS. FORD MOTOR COMPANY WAS INFORMED AND ON 3-1-05 I WAS GIVEN THE OPTION OF LETTING MY INSURANCE HANDLE IT OR HAVING THE CAR TOWED TO THE NEAREST DEALERSHIP [ANOTHER EXPENSE] AND HAVING THEM EVALUATE IF IT IS A MECHANICAL DEFECT. IF IT IS FORD WOULD GIVE ME TRADE-IN VALUE. OBVIOUSLY I CANNOT REPLACE THE CAR FOR THE TRADE-IN VALUE. FORD MOTOR COMPANY ACCEPTS NO RESPONSIBILITY FOR CLEAN UP OF MY HOUSE AND DRIVEWAY. *AK
Electrical system, Vehicle speed control, Mar 2, 2005, fire
VEHICLE WAS PARKED IN THE DRIVEWAY AND IT CAUGHT ON FIRE. THE FIRE DEPARTMENT WAS NOTIFIED, AND EXTINGUISHED THE FIRE. LATER, OWNER L STATED THAT CRUISE CONTROL WAS NOT WORKING AT THAT TIME, AND THE BRAKE LIGHT FUSE KEPT POPPING. *AK RECALL CAMPAIGN; NHTSA CAMPAIGN ID NUMBER : 05V017000 THE VEHICLE HAD NO BRAKE LIGHTS. *TC
Vehicle speed control, Mar 2, 2005, fire
VEHICLE WOULD SUDDENLY ACCELERATED UNCONTROLLABLY WHILE DRIVING. DRIVER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE. DROVE VEHICLE TO THE DEALER, AND MECHANIC DETERMINED THAT CRUISE CONTROL SWITCH CABLES WERE BURNED, AND NEEDED TO BE REPLACED. *AK *TT
Vehicle speed control, Mar 1, 2005, fire
ON JAN. 25,2005 MY 2000 FORD F150 CAUGHT ON FIRE UNDER THE HOOD IN THE LOCATION OF THE MASTER CYLINDER. THE TRUCK HAD BEEN PARKED FOR APR. 3/4 OF AN HOUR. THE TRUCK WAS INSPECTED BY FORD. IT WAS DETERMINED BY THEM THAT THE CRUISE CONTROL DEACTIVATION SWITCH WAS AT FAULT. FORD ACCEPTED RESPONSIBILITY AND HAS MADE AN UNACCEPTABLE OFFER TO PURCHASE THE TRUCK FROM ME. *JB
Vehicle speed control, Mar 1, 2005, fire
NO EVENTS LEADING UP TO FAILURE. MY FORD F150 WAS PARKED IN MY MOTHER'S CARPORT. FROM INSIDE THE HOUSE I HEARD AN EXPLOSION. I LOOKED OUT THE DOOR TO CARPORT. HOOD ON TRUCK HAD POPPED UP AND FLAMES WERE COMING FROM UNDER THE HOOD, ALREADY TOUCHING THE ROOF OF THE CARPORT. MY MOTHER AND I GOT OUT OF THE HOUSE IMMEDIATELY. I CALLED 911 ON MY CELL PHONE. THE FIRE DEPARTMENT RESPONDED QUICKLY. HOWEVER, THE HOUSE SUSTAINED HEAVY FIRE, SMOKE AND WATER DAMAGE THROUGHOUT AND IS UN-LIVABLE. MY MOTHER'S CAR WAS ALSO BURNED COMPLETELY IN THE FIRE. I RECEIVED MY RECALL NOTICE ON FEBRUARY 18TH, ONE WEEK AFTER THE FIRE.
Vehicle speed control, Feb 22, 2005, crash
1) PRIOR TO THE ACCIDENT, WE HAD NO UNUSAL PROBLEMS WITH THE VEHICLE. FEBRUARY 1, 2005 THE CRUISE CONTROL WAS DISCONNECTED PER FORD RECALL. ) FEBRUARY 12, 2005 THE 2000 FORD EXPEDITION WAS TAKEN TO A CAR WASH. WHEN IT REACHED THE END OF THE WASH CYCLE, THE ATTENDANT GOT IN THE VEHICLE TO PULL IT FORWARD AND THE VEHICLE SUDDENLY ACCELERATED (6000 RPM) AND TRAVELLED OFF THE CAR WASH LOT AND OVER A 5 LANE HIGHWAY BEFORE HITTING AN EMBANKMENT AND STOPPING. ) THE VEHICLE WAS TOTALLED BY THE INSURANCE ADJUSTOR REPRESENTING OUR INSURANCE. OMPANY. BOTH OUR INSURANCE COMPANY AND FORD WAS MADE AWARE OF THE PROBLEM THAT OCCURRED. THE INSURANCE COMPANY IS DEALING WITH THE CAR WASH BUT FORD DID NOT WANT TO INSPECT THE VEHICLE TO EITHER PROVE OR DISPROVE IT WAS A MANUFACTURING ERROR. OUR BELIEF IS THAT IT IS A PROBLEM WITH THE VEHICLE THAT IS RELATED TO MANUFACTURING AND THAT FORD SHOULD BE HELD RESPONSIBLE FOR WHAT HAPPENED ON FEBRUARY 12TH TO OUR VEHICLE. LIVES WERE IN DANGER.*AK
Vehicle speed control, Feb 16, 2005, fire
WHILE VEHICLE WAS PARKED IT CAUGHT ON FIRE DUE TO AN ELECTRICAL SHORT WITHIN THE CRUISE CONTROL SWITCH. MANUFACTURER WAS CONTACTED BY OWNER.*AK
Vehicle speed control, Feb 15, 2005, fire
VEHICLE WAS PARKED WHEN ALL OF A SUDDEN IT CAUGHT ON FIRE DUE TO AN ELECTRICAL SHORT IN THE CRUISE CONTROL SWITCH. MANUFACTURER WAS CONTACTED BY CONSUMER.*AK
Vehicle speed control, Feb 14, 2005, fire
MY HUSBAND AND I BOUGHT A 2000 FORD F-150. ON FEB 4, 2005 AFTER MY HUSBAND HAD BEEN HOME FOR ABOUT 20 MINS HE NOTICED HIS HORN WAS BLOWING NON-STOP. HE WENT OUTSIDE TO THE TRUCK AND OPENED HIS DOOR AND BLACK SMOKE ROLLED OUT THE CAB OF THE TRUCK. HE POPED THE HOOD AND FLAMES FROM THE FRONT DRIVER SIDE CAME OUT. HE CALLED THE FIRE DEPT BUT THERE WAS NO HOPE. WE HAD ONLY HAD THE TRUCK FOR ABOUT 6 MONTHS AND NOW THERE IS NOTHING LEFT OF THE TRUCK EXCEPT THE BED. *AK
Vehicle speed control, Feb 9, 2005, fire
NHTSA RECALL CAMPAIGN 05V017000 CONCERNING CRUISE CONTROL. VEHICLE WAS PARKED IN THE DRIVEWAY. CONSUMER WAS HOME WHEN HE WAS NOTIFIED THAT THE VEHICLE WAS ON FIRE. CONSUMER WAS UNABLE TO PUT THE FIRE OUT. THE FIRE DEPARTMENT ARRIVED AND EXTINGUISHED THE FIRE. *AK
Vehicle speed control, Feb 8, 2005, crash
WHILE DRIVING THE THROTTLE STUCK WHICH RESULTED IN AN ACCIDENT. CONSUMER PUT HIS FOOT OF THE BRAKE TO CHANGE GEARS AND THE MOTOR ACCELERATED TO A HIGH RATE OF SPEED. HE THEN HIT A POLE.*AK
Vehicle speed control, Feb 4, 2005, fire
CRUISE CONTROL ON 2000 MODEL FORD F-150 QUIT OPERATING. FOUND BRAKE FLUID LEAKING AROUND SPEED CONTROL TERMINATION SWITCH CONNECTED TO BRAKE FLUID RESERVOIR. WAS ROTATING TIRES ON SAID PICKUP WHEN I NOTICED LARGE AMOUNT OF SMOKE AND SMALL FIRE COMING FROM UNDER HOOD. PULLED FUSE FROM UNDER DASH TO SPEED CONTROL AND STOPPED SMOKE AND FIRE. LOOKED AT SWITCH THAT WAS LEAKING FLUID AND NOTICED WIRES HAD BEEN MELTED. PLASTIC (POLY) BRAKE FLUID RESERVOIR WAS ALSO DAMAGED BUT DID NOT LEAK FLUID. BOUGHT NEW SWITCH FROM FORD DEALERSHIP AND SCREWED IN FLUID BLOCK AND REPAIRED WIRING WITH NEW TERMINAL CONNECTORS THAT CAME WITH SWITCH. I STILL HAVE OLD MELTED SWITCH AND DAMAGED BRAKE FLUID RESERVOIR. *JB
Electrical system, Vehicle speed control, Feb 3, 2005, fire
THE CONSUMER PARKED THE VEHICLE AT 10:30 AM, AROUND 11:00 THE CONSUMER WAS TOLD THAT THERE WAS A FIRE. FIRE WAS COMING FROM THE ENGINE COMPARTMENT. NO PROBLEMS WITH THE VEHICLE. THE VEHICLE HAD CRUISE CONTROL AND IT WAS USED ONE TIME WHEN THE VEHICLE WAS FIRST BOUGHT 9 MONTHS AGO. NO STRUCTURE DAMAGE. WILL SEND PHOTOS TO BRUCE YORK. VEHICLE WAS INSURED BY CLAREDON INSURANCE. 305-260-5700.
Vehicle speed control, Jan 31, 2005, fire
WHILE PARKED CRUISE CONTROL FAILED AND VEHICLE CAUGHT ON FIRE. *AK
Vehicle speed control, Jan 31, 2005, fire
VEHICLE CAUGHT ON FIRE UNEXPECTEDLY WHILE IT WAS PARKED. RESULTS SHOWED THAT THERE WAS A SHORT WITHIN CRUISE CONTROL WIRE. MANUFACTURER WAS CONTACTED BY OWNER.*AK
Vehicle speed control, Jan 27, 2005, fire
VEHICLE WAS PARKED WHEN ALL OF A SUDDEN THE ENGINE CAUGHT ON FIRE DUE TO SPEED CONTROL SWITCH HAD AN ELECTRICAL SHORT. MANUFACTURER WAS CONTACTED BY OWNER.*AK
Vehicle speed control, Jan 27, 2005, fire
MY TRUCK LOST IT'S CRUISE CONTROL AND ABS LIGHT CAME ON. BEFORE I COULD GET IT LOOKED AT MY F150 FORD CAUGHT ON FIRE IN MY DRIVEWAY.*AK
Electrical system, Vehicle speed control, Jan 24, 2005, fire
THE VEHICLE CAUGHT ON FIRE WHILE PARKED IN THE GARAGE. THE CONSUMER WAS ALERTED TO THE FIRE BY THE CHILD WHO HEARD THE HORN BLOWING. THE FIRE DEPARTMENT WAS IMMEDIATELY CONTACTED AND EXTINGUISHED THE FIRE. THE FIRE ORIGINATED FROM UNDER THE HOOD ON THE DRIVER'S SIDE. THE INSURANCE COMPANY WAS GOING TO INSPECT THE VEHICLE TO DETERMINE WHAT CAUSED THE FIRE. A FIRE REPORT WAS FILED. *AK IT WAS DETERMINED PER INSPECTION THAT THE FIRE ORIGINATED FROM THE CRUISE CONTROL. *SC
Vehicle speed control, Jan 24, 2005, fire
THE VEHICLE WAS PARKED IN THE DRIVEWAY FOR ABOUT 4 HOURS WHEN THE OWNER LOOKED OUT THE WINDOW AND SAW FLAMES COMING FROM THE ENGINE COMPARTMENT. SHE DIDN'T USE THE CRUISE CONTROL, SO SHE WASN'T SURE IF IT QUIT WORKING OR NOT. #2 AND #14 FUSES WERE BLOWN AND #13 WAS NOT BLOWN. THE OWNER STATED THAT SHE SAW THE WIRES FOR THE SPEED CONTROL DEACTIVATION SWITCH CONNECTOR ARCING IMMEDIATELY AFTER THE FIRE WAS EXTINGUISHED. PICTURES FORWARDED TO BRUCE YORK. *JB *TC
Vehicle speed control, Jan 12, 2005, fire
F-150 CAUGHT FIRE AFTER BEING PARKED FOR 1 1/2HOURS. DID DAMAGE TO OUR CAR PARKED NEXT TO IT AND OUR HOUSE. THERE WAS NO WARNING OF ANY DANGER WITH THE VEHICLE OR ANYTHING WRONG WITH IT. IT IS OUR UNDERSTANDING THAT CRUISE CONTROLS ON THE F-150'S ARE A PROBLEM, AND WHY HAVE THEY NOT BEEN RECALLED TO PREVENT DAMAGE AND INJURY? IS THERE ANY SIGNIFICANT SIMILAR PROBLEMS EXPERIENCED BY OTHERS?*AK
Vehicle speed control, Jan 6, 2005, fire
WHILE THE VEHICLE WAS PARKED IT CAUGHT ON FIRE. CONSUMER EXTINGUISHED THE FIRE WITH A FIRE EXTINGUISHER. THEN, VEHICLE WAS TOWED TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT THE SPEED CONTROL MODULE NEEDED TO BE REPLACED. *AK
Electrical system, Vehicle speed control, Jan 6, 2005, fire
HUSBAND DROVE TO WORK 7 MILES, PARKED VEHICLE AT 7:20 AM, THEN AT 10:30 AM RECEIVED A CALL, TELLING HIM THAT VEHICLE WAS ON FIRE. SOMEONE PUT THE FIRE OUT WITH AN EXTINGUISHER. VEHICLE WAS NOT TOTALED. PRIOR TO FIRE THERE WERE NO PROBLEMS WITH VEHICLE. BOUGHT VEHICLE USED. TRIED TO USE CRUISE CONTROL, BUT COULD NOT GET IT TO WORK. NOT SURE IF WORKING OR NOT. VEHICLE WAS INSURED BY NATIONWIDE. ADJUSTER GEORGE ALEXANDER 888-593-2432, EXTENSION 13, POLICY NUMBER 7709P499619. NATIONWIDE MAY HAVE DONE AN INVESTIGATION. HAVE COPIES OF WORK ORDERS TO REPAIR THE VEHICLE, AND WILL FAX THEM TO BRUCE YORK.*AK *TC
Electrical system, Vehicle speed control, Jan 6, 2005, fire
HUSBAND PARKED TRUCK ABOUT 12:00 AM AND AT ABOUT 3:00 PM HE SAW WHITE SMOKE COMING FROM HOOD AREA ON THE DRIVER'S SIDE. THEN , VEHICLE BURST INTO FLAMES. THREE DAYS PRIOR TO THE FIRE, CRUISE CONTROL STOPPED WORKING. NO OTHER PROBLEMS WITH THE VEHICLE. WILL SEND PICTURES TO BRUCE YORK. *AK