2000 Ford F-150
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 1,204 owner complaints filed for this model year. This is the 3rd highest complaint count among 26 F-150 model years with reports.
Of the 2000 reports, 92 involved a crash and 361 involved a fire. 79 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lighting, headlightsAug 1, 2006
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 28, 2006. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.
Campaign 06E067000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Campaign 06E065000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Vehicle speed controlSep 7, 2005
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
A FIRE AT THE SWITCH COULD OCCUR.
BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)
Campaign 05V388000 on NHTSA.gov
Vehicle speed control, cruise controlJan 27, 2005
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
THIS CONDITION COULD LEAD TO A FIRE. FIRES HAVE OCCURRED WHILE THE VEHICLES WERE PARKED WITH THE IGNITION 'OFF.'
AS AN INTERIM REPAIR, OWNERS WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. AS SOON AS REPLACEMENT PARTS ARE AVAILABLE (EARLY APRIL 2005), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A NEW SWITCH FREE OF CHARGE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V388 AND 06V286)
Campaign 05V017000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Equipment, other, labelsSep 21, 2000
VEHICLE DESCRIPTION: BI-FUEL CNG PICKUP TRUCKS AND BI-FUEL CNG VANS, MODIFIED BY CFI CONTROL SYSTEMS, INC., FAIL TO CONFORM TO THE REQUIREMENTS OF FMVSS NO. 303, "FUEL SYSTEM INTEGRITY OF COMPRESSED NATURAL GAS VEHICLES." THE LABEL AFFIXED TO THE FUEL FILLER DOOR BY THE VEHICLE MODIFIER CONTAINS THE INSPECTION DATE AND EXPIRATION DATE OF THE CNG TANK. HOWEVER, IT DOES NOT CONTAIN THE STATEMENT "SEE INSTRUCTIONS ON THE FUEL CONTAINER FOR INSPECTION AND SERVICE LIFE."
THESE VEHICLES DO NOT COMPLY WITH THE REQUIREMENTS.
OWNERS WILL BE PROVIDED A LABEL WITH THE REQUIRED STATEMENT, ALONG WITH INSTRUCTIONS FOR AFFIXING THE LABEL AT THE FUEL FILLER DOOR. OWNER NOTIFICATION BEGAN NOVEMBER 2, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V284000 on NHTSA.gov
Seat beltsAug 18, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
DEALERS WILL INSPECT THE DATE CODE ON CERTAIN SEAT BELT BUCKLES OF YOUR VEHICLE AND REPLACE ALL SEAT BELT BUCKLES THAT FALL WITHIN THE SUSPECT DATE CODE RANGE. OWNER NOTIFICATION BEGAN OCTOBER 26, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V228001 on NHTSA.gov
Representative owner complaints
1,204 reports, newest first.
Engine and engine cooling, Electrical system, Mar 31, 2014, fire
ON MARCH 30, 2014, AT APPROXIMATELY 3:00 P.M. (PST) MY 2000 FORD F-150 UNEXPECTEDLY CAUGHT ON FIRE. THE TRUCK WAS STATIONARY IN MY DRIVEWAY WHEN SUDDENLY BLACK SMOKE AND FIRE COULD BE SEEN COMING OUT OF THE DRIVER SIDE WHEEL WELL. THE FIRE ENGULFED THE DRIVER SIDE OF THE ENGINE COMPARTMENT MELTING ALL THE PLASTIC, WIRING AND THE AIR INTAKE AREA. THE FIRE MELTED EVERYTHING NEAR THE MASTER CYLINDER AND THE CRUISE CONTROL HOUSING. *TR
Electrical system, Mar 4, 2014
ON MY VEHICLE I CAN REMOVE THE KEY, WITH THE VEHICLE STILL RUNNING. I HAD ACTUALLY GOTTEN OUT OF THE VEHICLE WITH THE KEYS THE FIRST TIME I NOTICED IT, AND IT WAS STILL RUNNING. I THEN CLIMBED BACK INSIDE ( KEYS STILL IN MY POCKET) PUT THE CAR IN DRIVE, AND DROVE AROUND THE BLOCK. I HAVE TO BE CAREFUL WHEN I EXIT THAT THE BLACK RING AROUND THE KEY IS TURNED ALL THE WAY COUNTER CLOCKWISE WHEN I EXIT. I CAN ALSO REMOVE THE KEYS WHILE I AM DRIVING DOWN THE ROAD. THEY ACTUALLY FELL OUT ONCE WHILE DRIVING. *TR
Steering, Dec 31, 2013, crash
I HAVE A COMPLAINT AS FORD WITH THERE SHIFTERS I HAVE ALSO SEEN IT ON SOME OLDER AND NEWER MODELS IS THE TWO BOLTS ON THE BRACKET ON THE END OF THE SHIFTER ROD ON THE STEERING COLUMN COME LOOSE AND OR MISSING BOLT AND THERE FOR HAVE SHIFTING PROBLEMS AS I DID ONE MORNING WITH MY 2000 F 150 WENT TO START THE TRUCK EARLY IN THE MORNING TRUCK WAS I THOUGHT WAS IN PARK ALL THE WAY AS I LEFT IT WENT INSIDE TO GET SOMETHING COME BACK OUT TRUCK WAS AC-CROSS THE STREET ESTIMATED 3100 DOLLARS IN DAMAGE TO MY TRUCK WITH A SIMPLE MISSING BOLT ON THE SHIFTER CAUSED THIS ISSUE AND I FEEL THIS IS A SAFETY CONCERN I FIXED THE PROBLEM MY SELF BUT I SURE THINK IT SHOULD BE RECALLED SO NO ONE ELSE GETS HURT OR KILLED I HAVE PICS TO PROVE THE DAMAGE I CAN EMAIL THEM IF NEEDED. *TR
Fuel system, Gasoline, Oct 29, 2013
TL* THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT STATED THAT WHILE INSPECTING THE VEHICLE, SHE NOTICED THAT THE FUEL TANK STRAPS WERE CORRODED AND THE FUEL TANK WAS LEAKING GASOLINE DUE TO A HOLE ON THE FUEL TANK. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL TANK STRAPS NEEDED TO BE REPLACED AND WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE). HOWEVER, THE CONTACT WAS ADVISED THAT THE REPAIRS FOR THE HOLE IN THE FUEL TANK WERE NOT INCLUDED IN THE RECALL. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT FURTHER REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGES WERE 131,930. UPDATED 12/20/13*CN THE CONSUMER STATED THERE WAS A HOLE IN THE GAS TANK UNDER THE FUEL TANK STRAPS.
Fuel system, Gasoline, Sep 3, 2013
FUEL TANK FELL OFF OF TRUCK WHILE DRIVING DOWN THE ROAD. CAUSING THE FUEL TANK TO HIT THE GROUND AND FUEL TO LEAK OUT OF TANK. FIRE DEPT. HAD TO COME CLEAN UP MESS. HAD TRUCK TOWED TO DEALER FOR SERVICE. FOUND OUT AFTER THAT STRAPS WHERE RECALLED BY FORD. FORD REFUSES TO PAY FOR THE TANK, THE CLEAN UP, OR THE TOW. THEY TOLD ME I HAD BEEN NOTIFIED AND THEY WOULD ONLY PAY FOR THE STRAPS. I FIND IT FUNNY THAT THEY DIDN'T HAVE ANY OF MY INFO BEFORE I GAVE IT TO THEM. SO HOW DID THEY NOTIFY ME. *JB
Electrical system, Jul 22, 2013, fire
TL* THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT STATED THAT THE VEHICLE CAUGHT ON FIRE WHILE PARKED. THE FIRE DEPARTMENT WAS PRESENT TO EXTINGUISH THE FIRE. THE FIRE INITIATED IN THE ENGINE COMPARTMENT AREA. THE MANUFACTURER WAS MADE WARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 161,000.
Fuel system, Gasoline, Jul 20, 2013
TRAVELING AT APPROXIMATELY 25 MPH, THE FUEL TANK STRAPS SNAPPED AND THE FUEL TANK DROPPED TO THE GROUND IN THE VEHICLE. THE DRIVER, UNAWARE OF WHAT HAPPENED, HEARD A NOISE AS SHE WAS APPROACHING A STOP LIGHT. THE NOISE CEASED AFTER STOPPING. THE DRIVER THEN MADE A LEFT TURN WHEN THE LIGHT CHANGED AT WHICH TIME THE NOISE CONTINUED. THE DRIVER PULLED THE VEHICLE INTO THE NEXT AVAILABLE PARKING LOT AND UPON EXITING THE VEHICLE, SMELLED GAS AND FOUND THE FORWARD PART OF THE FUEL TANK ON THE GROUND WITH GASOLINE LEAKING. NO RECALL NOTICE WAS RECEIVED BY THE DRIVER OR THE SPOUSE OF THE DRIVER AT THEIR HOME ADDRESS IN SPITE OF BEING TOLD LATER, AFTER THE INCIDENT, THAT SEVERAL WERE SENT. *TR
Fuel/propulsion system, Jul 15, 2013
TL* THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT TOOK HIS VEHICLE TO THE DEALER TO HAVE NHTSA RECALL CAMPAIGN NUMBER 11V385000 (FUEL SYSTEM, GASOLINE) REPAIRED AND WAS INFORMED THAT THE FUEL TANK HAD CORRODED AND NEEDED TO BE REPLACED AT HIS EXPENSE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 156,816.
Seat belts, Jun 20, 2013
APPROX. A MONTH AGO I WAS TRAVELING FROM OUR SHOP IN MY WORK TRUCK[AKA F-150].THE SPEED OUT OF THE CITY WAS 35 MPH ON THE MAIN RD.I EXPERIENCED A SEATBELT DISCONNECT,I RELATCHED IMMEDIATELY WHILE DRIVING.I TRAVELED A LITTLE FURTHER AND ENTERED THE FREEWAY SYSTEM.THE BELT CAME UNLATCHED AGAIN.I FURTHER INSPECTED THE LATCH LATER AFTER WORK,DISCOVERING THAT THE RELEASE BUTTON STAYS DOWN WHEN FASTENING THE BELT INTO IT.SO I TRIED LIGHTLY LUBRICATING THE LATCH,DROVE THE NEXT DAY AND BELT STILL RELEASED SEVERAL TIMES WHEN DRIVING.IF I NORMALLY PUSH THE LATCH INTO THE RECEIVER THE RELEASE STAYS DOWN A BIT AND THE BELT POPS LOOSE WHILE I'M DRIVING.AT VARIOUS TIMES THE LATCH WOULD STAY UP AND HOLD THE BELT AS INTENDED.MOST OF THE TIME THOUGH THAT IS NOT THE CASE AND IT FREQUENTLY RELEASES WHILE I'M DRIVING AT ALL SPEEDS. *TR
Engine, Fuel/propulsion system, Jun 14, 2013
5.4 TRITON V8. TODAY WHILE DRIVING, SPARK PLUG AND COIL BLEW OUT OF #7 CYLINDER HEAD. THIS ALSO OCCURRED SEVERAL MONTHS AGO ON CYLINDER #3. SOUNDED LIKE A SHOTGUN BLAST WHICH STARTLED ME TAKING MY ATTENTION AWAY FROM THE ROAD. GAS ALSO BLOWING OUT OF CYLINDER HOLE, AND LUCKILY NO FIRE STARTED. STRONG SMELL OF GAS WAS PRESENT IN CAB OF TRUCK. NAUSEATED FAMILY MEMBERS RIDING IN TRUCK. UPON INSPECTION FOUND PLUG AND COIL DAMAGED BY FUEL RAIL. ALSO FOUND SPARK PLUG THREADS STRIPPED OUT OF ALUMINUM CYLINDER HEAD. KNOWN TO BE A COMMON PROBLEM WITH FORD 5.4, AND IS ALSO AN ISSUE THAT IS KNOW TO BE IGNORED BY FORD. FORD ESTIMATES REPAIR BETWEEN 500.00 AND 3500.00 FOR A KNOWN MANUFACTURING DEFECT THAT THEY BLAME ON A SPARK PLUG MAINTENANCE ISSUE. *TR
Fuel/propulsion system, Jun 5, 2013
TL* THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT STATED HE RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE) AND THE VEHICLE WAS TAKEN TO A DEALER FOR THE REPAIR. THE CONTACT WAS INFORMED THAT THE FUEL TANK HAD A LEAK AND WOULD NEED TO BE REPLACED BEFORE THE RECALL REPAIR COULD BE PERFORMED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND BOTH FAILURES WERE REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 115,000.
Other or unspecified, May 28, 2013, fire
MY 2000 FORD F150, BLOWUP, IT EXPLODED TWICE. THE ENTIRE FRONT END IS GONE, THE EXTENDED CAB IS ALL BURNT. THE HOOD IS GONE TOTALLY. WE HADN'T DRIVEN IT SINCE MAY 19 OF 2013. SO IT HAD NOT BEEN RUNNING AT ALL. IT WAS AROUND 80-90, SO WHAT MADE IT BURN AND BLOWUP?? RECALLS, WHICH PART OR PARTS?? MY HOUSE ALSO GOT DAMAGE, THE FRONT OF THE HOUSE NEAR MY TRUCK. I THANK GOD WE WE'RE NOT DRIVING IT, WHICH WE HAD PLANNED TO USE IT THE NEXT DAY!! *TR
Engine, May 20, 2013, fire
THE CAR HAS BEEN PARKED IN A AUXILIARY BUILDING WITH AN APARTMENT FOR 10 DAY, SINCE MAY 9TH. THE PEOPLE LIVING IN THE APARTMENT HEARD A LOAD BANG AROUND 3 AM AND OPEN THEIR FRONT DOOR TO SEEING A MASSIVE FIRE AROUND THE F150. THEY TRIED TO USE A FIRE EXTINGUISHER TO THE FIRE TO NO SUCCESS. THEY WOKE MYSELF UP IN THE MAIN HOUSE ON THE PROPERTY AND WE CALLED 911 AND STARTED SPRAYING THE BUILDING WITH A HOUSE, AS THIS IS A VERY DRY AREA IN SOUTHERN CALIFORNIA. WE OPEN THE FRONT OF THE BUILDING USING A CROWBAR TO SEE A VERY SMOKY AND HOT FIRE AROUND THE F150. WE HEARD SEVERAL MORE LARGE BANGS AND WE ATTEMPTED TO PUT OUT THE FIRE UNTIL THE FIRE DEPARTMENT SHOWED UP. AFTER THE FIRE WAS PUT OUT, IT TOOK ABOUT AN HOUR FOR THE BUILDING TO COOL DOWN. THE ENTIRE BUILDING HAS SMOKE DAMAGE AND THE F150 IS COMPLETELY BURNED OUT, ESPECIALLY ON THE PASSENGER SIDE. THE JEEP PARKED NEXT TO THE F150 FRONT END MELTED BUT DID NOT CATCH ON FIRE. IT APPEARS THAT THE ONLY ITEM EVER ON FIRE WAS THE F150, THE BATTERY COMPLETELY BURNED AWAY AND ITEMS NEXT TO IT ONLY SUFFERED HEAT AND SMOKE DAMAGE. I FEEL VERY FORTUNATE THAT THIS FIRE DID NOT KILL ANYONE OR BURN DOWN THE ENTIRE NEIGHBORHOOD. LET ME STATE AGAIN, THIS CAR WAS NOT MOVED FOR 10 DAYS. *TR
Electrical system, Visibility/wiper, May 13, 2013
IN HEAVY RAIN THE WIPERS AND OTHER ELECTRICAL FUNCTIONS QUIT WHILE DRIVING - CAUSED BY A WINDSHIELD LEAK ONTO THE GEM MODULE AND FUSE BOX. THIS WINDSHIELD LEAK IS A COMMON PROBLEM THAT FORD KNOWS ABOUT ON 1997 THRU 2000 FORD F150 PICKUPS. *TR
Engine, May 6, 2013, fire
TL* THE CONTACT OWNS A 2000 FORD F150. THE CONTACT STATED THAT THE VEHICLE CAUGHT ON FIRE WHILE PARKED. THE FIRE ORIGINATED IN THE ENGINE AREA. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 200,000.
Air bags, May 2, 2013, crash, fire
DRIVER AND PASSENGER AIRBAGS DEPLOYED AFTER A HARD BRAKING, THE TRUCK WAS NOT IN MOTION AT THE TIME OF DEPLOYMENT AT A STOP LIGHT. BOTH AIRBAGS CAUGHT ON FIRE. DRIVER WAS PINNED BY THE AIRBAG CAUSING FOOT TO PRESS ON ACCELERATOR. LOC AND BLUNT TRAUMA TO ABDOMINAL AREA, ABRASIONS/BURNS ON ABDOMEN AND CHEST. *TR
Fuel/propulsion system, Apr 27, 2013
THE STRAPS ON THE FUEL TANK COMPLETELY BROKE OFF AS I WAS DRIVING ON THE TURNPIKE AND THE FUEL TANK FELL DOWN; CAUSING IT TO DRAG ON THE ROAD LEAKING OUT GAS. *TR
Service brakes, Apr 9, 2013
MY ABS LIGHT KEEPS COMING ON AND THEN IT WILL GO OFF. *TR
Electrical system, Mar 19, 2013, fire
TL* THE CONTACT OWNS A 2000 FORD F150. THE CONTACT STATED THAT THE VEHICLE WAS PARKED IN THE DRIVEWAY OVERNIGHT AND CAUGHT ON FIRE. THE FIRE DEPARTMENT WAS NOTIFIED AND EXTINGUISHED THE FIRE. NO ONE WAS INJURED AND THE VEHICLE WAS DESTROYED. THE FIRE DEPARTMENT ADVISED THE CONTACT THAT THE FIRE WAS ELECTRICAL AND A FIRE REPORT WAS FILED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 240,000.
Electrical system, Vehicle speed control, Engine, Jan 1, 2013, fire
TRUCK WAS PARKED IN DRIVEWAY WHEN IT SUDDENLY CAUGHT ON FIRE UNDER THE HOOD BURNING THROUGH THE HOOD IN A MATTER OF SECONDS. FIREFIGHTERS CALLED TO THE SCENE SAID THEY HAVE NEVER SEEN ANYTHING LIKE IT BEFORE. I BELIEVE THIS FIRE WAS CAUSED BY THE SPEED CONTROL SWITCH, OF WHICH THERE HAVE BEEN AT LEAST TWO RECALLS ON OF WHICH WE WERE NEVER INFORMED ABOUT. *TR
Vehicle speed control, Dec 26, 2012, fire
TL* THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT STATED THAT THE VEHICLE CAUGHT ON FIRE. THE FIRE DEPARTMENT REPORTED TO THE SCENE TO EXTINGUISH THE FIRE. THE FIRE CHIEF ADVISED THE CONTACT THAT THE FIRE WAS CAUSED BY AN ELECTRICAL FAILURE BUT THE CAUSE OF THE FIRE WAS NOT DETERMINED. THE VEHICLE WAS INCLUDED IN AND PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 05V017000 (VEHICLE SPEED CONTROL:CRUISE CONTROL). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE MILEAGE WAS 149,000. *TR
Fuel/propulsion system, Dec 16, 2012
REAR FUEL TANK STRAP CORRODED THROUGH AND BROKEN, APPROXIMATELY 6 INCHES OF DRIVER SIDE MISSING. REAR OF TANK WAS BEING SUPPORTED BY FILL AND VENT TUBES ONLY. FRONT STRAP WAS INTACT BUT CORRODED. *TR
Fuel/propulsion system, Nov 18, 2012
I HAD AN APPOINTMENT AT DONLEY FORD IN ASHLAND, OHIO MON., 11-11-12 AT 6 PM., TO HAVE THE FUEL TANK STRAPS REPLACED ON MY F-150 PER THE RECALL. WHEN THE TECHNICIAN REMOVED THE STRAPS, THE TANK STARTED LEAKING. WHEN CONTACTING FORD, THEY DENY ANY RESPONSIBILITY FOR THIS PROBLEM. A QUICK SEARCH ON THE INTERNET SHOWS THAT MANY OTHERS HAVE HAD THE SAME EXPERIENCE. MY TRUCK WAS PREVIOUSLY OWNED MY BROTHER AND HAS BEEN TAKEN WELL CARE OFF. THE TECHNICIAN EVEN COMMENTED ON ITS CONDITION. THE TANK IS IN PERFECT CONDITION EXCEPT SOME RUSTING WHERE THE STRAPS WERE. AFTER SEARCHING THE INTERNET, I AM SURE THAT YOU HAVE HEARD THIS COMPLAINT BEFORE. I AM SIMPLY ADDING ONE MORE. NOT ONLY IS THERE A POTENTIAL FOR THE STRAPS TO BREAK, ALLOWING THE TANK TO FALL, THEY ALSO CORRODE THE TANK, CAUSING IT TO LEAK FUEL. *TR
Electrical system, Engine, Nov 5, 2012, fire
TL* THE CONTACT OWNS A 2007 FORD F-150. WHILE PARKED, THE CONTACT NOTICED FLAMES COMING FROM THE GRILL OF THE VEHICLE AND FROM UNDER THE HOOD. THE FIRE DEPARTMENT WAS CALLED TO THE SCENE AND A FIRE REPORT WAS FILED. THE CAUSE OF THE FIRE WAS UNDETERMINED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE MILEAGE WAS 140,000. ..UPDATED 01/16/2013 *BF UPDATED 1/28/2013 *JS
Fuel/propulsion system, Sep 18, 2012
TL* THE CONTACT OWNS A 2000 FORD F150. THE CONTACT STATED THAT WHILE DRIVING 20 MPH, THE FUEL TANK DETACHED FROM THE VEHICLE. THE CONTACT STATED THAT HE PULLED OVER AND NOTICED THAT GASOLINE WAS LEAKING FROM A HOLE IN THE FUEL TANK. THE VEHICLE WAS TOWED TO THE DEALER FOR INSPECTION WHERE THEY STATED THAT THE FUEL TANK STRAPS WERE FRACTURED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND STATED THAT SHE SHOULD HAVE RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING). THE FAILURE MILEAGE WAS 130,000.