2000 Ford F-150
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 1,204 owner complaints filed for this model year. This is the 3rd highest complaint count among 26 F-150 model years with reports.
Of the 2000 reports, 92 involved a crash and 361 involved a fire. 79 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lighting, headlightsAug 1, 2006
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 28, 2006. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.
Campaign 06E067000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Campaign 06E065000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Vehicle speed controlSep 7, 2005
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
A FIRE AT THE SWITCH COULD OCCUR.
BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)
Campaign 05V388000 on NHTSA.gov
Vehicle speed control, cruise controlJan 27, 2005
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
THIS CONDITION COULD LEAD TO A FIRE. FIRES HAVE OCCURRED WHILE THE VEHICLES WERE PARKED WITH THE IGNITION 'OFF.'
AS AN INTERIM REPAIR, OWNERS WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. AS SOON AS REPLACEMENT PARTS ARE AVAILABLE (EARLY APRIL 2005), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A NEW SWITCH FREE OF CHARGE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V388 AND 06V286)
Campaign 05V017000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Equipment, other, labelsSep 21, 2000
VEHICLE DESCRIPTION: BI-FUEL CNG PICKUP TRUCKS AND BI-FUEL CNG VANS, MODIFIED BY CFI CONTROL SYSTEMS, INC., FAIL TO CONFORM TO THE REQUIREMENTS OF FMVSS NO. 303, "FUEL SYSTEM INTEGRITY OF COMPRESSED NATURAL GAS VEHICLES." THE LABEL AFFIXED TO THE FUEL FILLER DOOR BY THE VEHICLE MODIFIER CONTAINS THE INSPECTION DATE AND EXPIRATION DATE OF THE CNG TANK. HOWEVER, IT DOES NOT CONTAIN THE STATEMENT "SEE INSTRUCTIONS ON THE FUEL CONTAINER FOR INSPECTION AND SERVICE LIFE."
THESE VEHICLES DO NOT COMPLY WITH THE REQUIREMENTS.
OWNERS WILL BE PROVIDED A LABEL WITH THE REQUIRED STATEMENT, ALONG WITH INSTRUCTIONS FOR AFFIXING THE LABEL AT THE FUEL FILLER DOOR. OWNER NOTIFICATION BEGAN NOVEMBER 2, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V284000 on NHTSA.gov
Seat beltsAug 18, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
DEALERS WILL INSPECT THE DATE CODE ON CERTAIN SEAT BELT BUCKLES OF YOUR VEHICLE AND REPLACE ALL SEAT BELT BUCKLES THAT FALL WITHIN THE SUSPECT DATE CODE RANGE. OWNER NOTIFICATION BEGAN OCTOBER 26, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V228001 on NHTSA.gov
Representative owner complaints
1,204 reports, newest first.
Air bags, Jan 4, 2001, crash
VEHICLE STRUCK A LARGE DEER AT APPROXIMATELY 50 MPH. UPON IMPACT, BOTH AIR BAGS DID NOT DEPLOY. DEALER / MANUFACTURER NOTIFIED. PLEASE FEEL FREE TO PROVIDE ANY FURTHER DETAILS ON THIS MATTER. *AK
Suspension, Dec 28, 2000
CONSUMER EXPERIENCED SEVERE BOUNCING IN THE FRONT END OF THE VEHICLE INTERMITTENTLY WHILE DRIVING AT HIGHWAY SPEEDS, NO FIX HAS BEEN DONE TO REMEDY THE PROBLEM. NLM
Electrical system, Dec 27, 2000, fire
VEHICLE WAS IN NO START CONDITION. TWO DAYS LATER WHILE VEHICLE NOT DRIVEN, THERE WAS A FIRE IN ENGINE COMPARTMENT. COULD NOT DETERMINE CAUSE. *AK
Air bags, Seat belts, Dec 17, 2000, crash
DRIVING TO WORK ON INTERSTATE. HIT "BLACK ICE" WAS ON RT FAR SIDE, WAS THROWN INTO 2' CONCRETE WALL BARRIER ON FAR LFT SIDE OF INTERSTATE @ 50MPR HEAD-ON. SRS DIDN'T DEPLOY. RCEIVED INJURIES: LEFT SHOULDER/ARM (SEATBELT & THROWN INTO DRIVER'S SIDE DOOR), NECK, UP'R BACK, RT KNEE, LFT LOWER SHIN (LASCARATION, SCRAPES & BRUISES FROM HITTING EMERGENCY BRAKE.) TRANSPORTED TO HOSPITAL. FIRE DEPT NOTED/CONCERNED THAT SRS DIDN'T DEPLOY. "BRAND NEW TRUCK, AIRBAGS DIDN'T WORK..WHY?" PAID $30,000 FOR TRUCK W/SRS & DEFECTIVE. DEFECTIVE SENSOR, NO AIRBAGS INSTALLED, OR AIRBAG MANUFACTURER DEFECT. CONTACTED HILL FORD, WAS TOLD, "SOMETIMES AIRBAGS WORK, SOMETIMES THEY DON'T." I SAID, "SOMETIMES YOU DIE, SOMETIMES YOU DON'T?" NOT ACCEPTING THAT ANSWER FOR A SAFETLY FEATURE. WOULD OF WALKED AWAY FROM HEAD-ON CRASH W/LITTLE TO NO INJURIES. SRS WOULD OF STABALIZED ME & I WOULDN'T OF BEEN THROWN AROUND OR HIT DASH BOARD. WHY DIDN'T SRS OPERATE AT ALL? AMERICAN FAMILY INS BREAKING DOWN TRUCK FOR TOTAL DAMAGE ESTIMATATION. OVER A WK SINCE ACCIDENT..NO ANSWERS, NO TRUCK. FRAME BENT & CAP TWISTED IN ACCIDENT....BUT DO HAVE INJURIES & DEFECTIVE SRS. WHY? *AK
Wheels, Nov 29, 2000, crash
WHILE TRAVELING EASTBOUND ON FREEWAY, LEFT REAR WHEEL FLEW OFF TRUCK, OVER CONCRETE MEDIAN BARRIER INTO WESTBOUND TRAFFIC. AN ACCIDENT SUBSEQUENTLY ENSUED IN WESTBOUND LANES INVOLVING PREGNANT WOMAN. THREE OF THE FIVE STUDS FAILED RESULTING IN WHEEL ASSEMBLY PULLING AWAY FROM REMAINING TWO STUDS AND FLYING OFF THE VEHICLE. THE DEALER REFUSED TO REPAIR THE DAMAGE TO THE TRUCK RESULTING FROM THIS FAILURE EVEN THOUGH THE TRUCK WAS STILL UNDER ORIGINAL WARRANTY, AND EVEN THOUGH NO WORK WAS DONE ON WHEEL OR TIRE OTHER THAN BY MANUFACTURER OR DEALER PRIOR TO SALE. *AK
Tires, Nov 28, 2000
WHILE TRAVELING AT 75 MPH, THE RIGHT FRONT TIRE BLEW, CAUSING THE VEHICLE TO PULL TO THE RIGHT DAMAGING THE BRAKE HOSE. *YH
Visibility, Nov 27, 2000
THE SMALL SIDE DOOR GLASS (SUPERCAB DOOR) OF PASSENGER SIDE - JUST POPPED AND SHATTERED IN A MILLION PIECES. THE SAFETY GLASS FELL IN AND OUT OF THE VEHICLE AS IT CRUMBLED. THERE WERE CRYSTALIZED PIECES IN THE SMALL PIECES. IT WAS UNBELIEVABLE HOW IT JUST SHATTERED. IT DID NOT APPEAR AS SAFETY GLASS SHOULD. ALSO I CHECKED THE OTHER WINDOW AND THE METAL INSERT THAT IS SUBSET TO THE RUBBERIZED SEAL IS WITHIN 1/8TH AN INCH OF THE GLASS. MY QUESTION/COMMENT/CONCERN/COMPLAINT IS THAT IT APPEARS THAT IN THE NATURAL GIVE AND TAKE OF A VEHICLES TWISTS, ETC. THAT THE GLASS WOULD COME TO REST AS TIMES ON THIS METAL INSERT AND THEREFORE COULD CAUSE A REDUCTION IN THE INTEGRITY OF THE GLASS. I AM IRRITATED BECAUSE OF THE COST AND WILL ARGUE LIKE HELL WITH FORD TO PAY FOR IT, BUT I WOULD LIKE TO KNOW IF OTHER QUERIES HAVE BEEN MADE BY OTHER FORD OWNERS CONCERNING THIS PARTICULAR PROBLEM, AND IF SO, HAS FORD ACCEPTED RESPONSIBILITY FOR THIS ITEM. I AM GOING TO TAKE A DAY OFF TO WORK ON THIS ISSUE EITHER MONDAY OR TUESDAY SO I WOULD APPRECIATE ANY HELP YOU CAN GIVE ME. THE 'WORK' NUMBER IS MY CELL NUMBER. I AM A SCHOOL TEACHER AND THE SYSTEM IS 'LESS THAN GOOD' ABOUT GETTING MESSAGES TO US. PLEASE FEEL FREE TO CONTACT ME ASAP WITH ANY PRUDENT INFORMATION. I WILL CHECK MY EMAIL REGULARLY ALSO. THANK YOU FOR FIELDING THIS COMPLAINT/QUESTION. *AK
Wheels, Nov 16, 2000
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK (DOT NUMBER: DA217PF12D TIRESIZE: LT265/75RX)
Vehicle speed control, Nov 14, 2000
UPON STARTING VEHICLE AND PUTTING INTO GEAR, VEHICLE HAD INSTANT ACCELERATION. RPMS WENT FROM 1000 TO 4500 WITHOUT HITTING THE ACCELERATOR. THIS HAPPENED WHILE FOOT WAS ON THE BRAKE PEDAL *AK *SLC
Power train, Nov 14, 2000
THE TORQUE CONVERTER IN THIS VEHICLE LOCKS UP WITHOUT WARNING. THE PROBLEM IS INTERMITTENT. THE PROBLEM MANIFESTS WHILE CRUISING AND WHILE AT STOP. WHEN PROBLEM HAPPENS AT STOP, THE CAR WILL LURCH FORWARD AND KILL ENGINE. STOPPING DISTANCE IN INCREASED WHEN EVENT OCCURES DURING CRUISE. INCIDENT OCCURRED AT NEAR PEDESTRIANS AND NEARLY CAUSED COLLISION. INCIDENT OCCURED IN PARKING LOT AND CAUSED SLIGHT BUMBER IMPACT WITH STOP POST. FORD WILL NOT FIX PROBLEM BECAUSE NO ERROR CODES ARE GENERATED BY THE EVENT, AND CANNOT BE DUPLICATED BY DEALER. I AM FORMALLY SEEKING APPROPRIATE REMEDY TO HAVE TORQUE CONVERTER REPLACED. I AM BAFFLED BY FORD'S LACK OF CONCERN AND UNWILLINGNESS TO FIX A LOW COST WARRANTIED COMPONENT. I WILL HAVE UNIT REPARIED BY INDEPENDENT MECHANIC IF FORD CONTINUES TO REFUSE. I WILL GLADLY SUBMIT FAILED UNIT TO NHTSA FOR YOUR ANALYSIS. THANKS FOR YOUR SUPPORT.
Power train, Nov 5, 2000
WHILE TRAVELING AT 60 MPH THE SPEEDOMETER DROPPED TO 25 MPH AND THE "LOW RANGE" LIGHT ILLUMINATED. THE VEHICLE NEVER SLOWED AND THE 4 WHEEL DRIVE LOW DID NOT ENGAGE. THE PROBLEM OCCURS SPORADICALLY AT ALL SPEEDS.*AK
Air bags, Nov 3, 2000, crash
VEHICLE INVOLVED IN A FRONTAL COLLISION OF 45 MPH WITH A FORD ESCORT. UPON IMPACT, BOTH AIR BAG DID NOT DEPLOY. DEALER WAS NOTIFIED, AND NO RESPONSE WAS GIVEN. PLEASE FEEL FREE TO PROVIDE ANY FURTHER DETAILS. *AK
Air bags, Oct 30, 2000, crash
CONSUMER WAS INVOLVED IN A 30 MPH FRONTAL COLLISION IN WHICH DRIVER'S AND PASSENGER'S AIR BAGS DID NOT DEPLOY, CAUSE UNKNOWN. PLEASE GIVE ANY FURTHER DETAILS.*AK
Suspension, Oct 26, 2000
VEHICLE EXPERIENCING SEVERE PROBLEM WITH WANDERING ACROSS THE ROAD FROM 30 MPH. MORE VEHICLE ACCELERATES HARDER IT BECOMES TO CONTROL. VEHICLE BEEN IN DEALER SHOP ON FOUR OCCASIONS, AND PROBLEM STILL GOES UNRESOLVED.*AK
Air bags, Oct 26, 2000
WHILE PULLING A TRAILER WITH A PORTABLE TOILET ON A DIRT ROAD AT 10-15 MPH WITH DRIVER ONLY BOTH AIR BAGS DEPLOYED WITHOUT CAUSE. DEALER NOTIFIED. *AK
Service brakes, Hydraulic, Oct 20, 2000, crash
DRIVER'S WAS PULLING INTO A PARKING LOT, TURNED VEHICLE TO PARK AND BRAKES FAILED CAUSING VEHICLE TO HIT CEMENT POLL IN PARKING LOT
Suspension, Oct 17, 2000
SINCE I PURCHASED THE FRONT END WOULD NOT STAY ALIGNED AND THE ENGINE WOULD LOSE POWER THE DEALERSHIP WOULD NOT FIX IT AND FORD MOTOR COMPANY DID NOT CARE I PUT UP WITH THIS FOR A YEAR UNTIL FORD GAVE ME $3,5000 DOWN FOR A NEW VEHICLE AND I NO LONGER HAVE THE VIN INDICATED I TRADED THE LEMON AND THEY RIPPED ME OFF DURING PURCHASE. *AK
Electrical system, Oct 13, 2000, fire
THIS IS THE 3RD TIME I'VE HAD THIS PLOBLEM! I HAVE HAD MY TRUCK INT THE SHOP ON 2 OTHER OCCATIONS FOR THE SAME ELECTRICAL PROBLEM.TODAY MAKES THE 3RD TIME I WENT TO START MY TRUCK & THE STARTER STAYED ENGAGED & ENERGIZED!THE FIRST 2 TIMES THE STARTER QUIT AFTER ABOUT 40 SECONDS ,TODAY (10/12/2000) THE STARTER STAYED ENGAGED UNTILL THE STARTER, WIRING,RELAYS& POSIBLY THE BATTERY ALL BURNED UP! I'VE BEEN TOLD I'M NOT THE ONLY ONE WHO IS HAVING THIS PROBLEM. *AK
Vehicle speed control, Oct 13, 2000
WITH CRUISE CONTROL ON, VEHICLE ACCELERATES UP TO 10-15 MILES FASTER WHEN GOING DOWNHILL. *SLC
Tires, Oct 10, 2000
TIRE STARTED TO SEPERATE ON INTERSTATE DRIVING. ROARING, VIBRATION. WE STOPPED AND REPLACE TIRE WITH SPARE IMMEDIATELY. TIRE HAS BEEN TAKEN TO FOUR GOODRICH DEALERS IN ATHENS AREA, AND WE WERE INFORMED EACH TIME BY ALL THAT THEY WOULD NOT HONOR ANY WARRANTY EVEN THOUGH IT WAS ORIGINAL EQUIPMENT WITH LESS THAN 10,000 MILES ON VEHICLE AT TIME OF INCIDIENT. THEY ALL SAID IT WAS A FORD PROBLEM. FORD ROAD HAZZARD SERVICE CONTACTED 8/15/00 WITH REPORT, AND THEY PROMISED IN AUGUST TO HAVE PURCHASING DEALER CALL US TO REPLACE THE TIRE. FOLLOWING UP WITH ORIGINAL PURCHASE DEALER SERVICE CENTER IN COMMERCE, WAS INFORMED BY SHOP MANAGER THEY KNEW NOTHING ABOUT A CLAIM, THEY WOULD NOT RESOLVE OR REPLACE TIRE , IT WAS A GOODRICH TIRE ISSUE TO REPLACE IT. CALLED FORD CONSUMER LINE AGAIN, GIVEN PROMISE THAT SOMEONE WOULD CALL US BACK, STILL WAITING ON THAT CALL. CALLED GOODRICH, CORPORATE CONSUMER LINE, AND WAS TOLD A GOODRICH DEALER, ANY THAT WE COULD DRIVE TO, WOULD REPLACE THE TIRE. UPON DRIVING AROUND ATHENS, GA. WITH TIRE AND VEHICLE LAST WEEK, NO GOODRICH DEALER WAS WILLING TO CALL GOODRICH CORPORATE TO SEE IF THEY COULD GET A REPLACEMENT AND AUTHORIZATION FOR SAME. ALL GOODRICH DEALERS HAVE TOLD US TO CALL FORD TO REPLACE A NEW TIRE UNDER WARRANTY IF VEHICLE IS STILLUNDER WARRANTY. WE STILL DO NOT HAVE A TIRE. WE HAVE BEEN TOLD BY FORD CONSUMER LINE, BY ROAD HAZARD HOTLINE, NOW THAT GOODRICH TIRES ARE NOT PART OF ANY RECALL AND THEY WILL NOT REPLACE ANY TIRE FOR FREE EVEN THOUGH THE FORD WARRANTY, AND ORIG EQUIPMENT BOOKLET IN NEW VEHICHLE GLOVEBOX STATES THEY ARE LIABLE FOR WARRANTY REPLACEMENT ON A NEW VEHICLE WITH ORIGINAL EQUIPMENT TIRES. FORD NOW STATES THAT IT IS A GOODRICH ISSUE. (TIRESIZE: 23570R16)( DOT NUMBER: TIRE SIZE: 23570R16 )
Tires, Oct 5, 2000
FIRESTONE TIRE EXPERIENCED TREAD SEPARATION, CAUSING DAMAGE TO THE LEFT FRONT WHEEL ASSEMBLY, ROTOR, DISC BRAKE, AND THE OUTER AXLE. *SLC
Fuel system, Gasoline, Oct 3, 2000
MY CONCERN IS NOT WITH MY FORD MINI VAN...HOWEVER, IT IS WITH THE COURT SYSTEM THAT SUPPRESSES FULL DISCLOSURE OF LIABILITY CLAIMS. THIS IS AN EXAMPLE OF A DENIAL OF INFORMATION TO THE PUBLIC THAT RESULTED IN 100 PLUS FATALITIES, FIRESTONE/FORD AND OVER 200 FATALS WITH GM TRUCKS AND OUTER GAS TANKS... SOUNDS LIKE A SEVERE LEGAL GLITCH OUT THERE AND SAME SHOULD BE CLOSED, LESS PUBLIC CONFIDENCE IS ERODED IN YOUR OFFICE AND THE COURTS...*AK
Tires, Oct 2, 2000
WHILE DRIVING ALONG ALL OF A SUDDEN VEHICLE STARTED PULLING TO THE LEFT. WAS TAKEN BACK TO FORD, WHERE A TIRE PROBLEM WAS FOUND. CORD SEPARATED FROM THE TIRE ON THE DRIVER'S FRONT SIDE. ORIGINAL TIRE EQUIPMENT ON A 2000, FORD, F350. TIRE MILEAGE ABOUT 13,000. TIRE SIZE P265R7516. FIRESTONE REPLACED THE TIRE FREE OF CHARGE. DOT # VNW81XL449. TIRE SIZE 265/75R16 *AK
Air bags, Sep 28, 2000, crash
WHEN TRUCK WAS INVOLVED IN A FRONT END CRASH WHILE TRAVELING AT 50 MPH, THERE WAS NO DEPLOYMENT OF DRIVER'S OR PASSENGER'S FRONT AIR BAGS. NOT SURE IF THE TRUCK WAS REPAIRABLE. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK
Service brakes, Hydraulic, Sep 27, 2000, crash
VEHICLE EXPERIENCING INTERMITTENT LOSS OF BRAKES, WHEN APPLIED AT A LOW SPEED OF 25 MPH OR LESS, AND THEN REENGAGED. DEALER NOTIFIED, AND INFORMED THAT WAS THE WAY SYSTEM WAS DESIGNED TO OPERATE. *AK BRAKES FAILURE RESULTING IN ACCIDENT. *YH