2000 Ford F-150
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 1,204 owner complaints filed for this model year. This is the 3rd highest complaint count among 26 F-150 model years with reports.
Of the 2000 reports, 92 involved a crash and 361 involved a fire. 79 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lighting, headlightsAug 1, 2006
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 28, 2006. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.
Campaign 06E067000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Campaign 06E065000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Vehicle speed controlSep 7, 2005
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
A FIRE AT THE SWITCH COULD OCCUR.
BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)
Campaign 05V388000 on NHTSA.gov
Vehicle speed control, cruise controlJan 27, 2005
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
THIS CONDITION COULD LEAD TO A FIRE. FIRES HAVE OCCURRED WHILE THE VEHICLES WERE PARKED WITH THE IGNITION 'OFF.'
AS AN INTERIM REPAIR, OWNERS WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. AS SOON AS REPLACEMENT PARTS ARE AVAILABLE (EARLY APRIL 2005), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A NEW SWITCH FREE OF CHARGE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V388 AND 06V286)
Campaign 05V017000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Equipment, other, labelsSep 21, 2000
VEHICLE DESCRIPTION: BI-FUEL CNG PICKUP TRUCKS AND BI-FUEL CNG VANS, MODIFIED BY CFI CONTROL SYSTEMS, INC., FAIL TO CONFORM TO THE REQUIREMENTS OF FMVSS NO. 303, "FUEL SYSTEM INTEGRITY OF COMPRESSED NATURAL GAS VEHICLES." THE LABEL AFFIXED TO THE FUEL FILLER DOOR BY THE VEHICLE MODIFIER CONTAINS THE INSPECTION DATE AND EXPIRATION DATE OF THE CNG TANK. HOWEVER, IT DOES NOT CONTAIN THE STATEMENT "SEE INSTRUCTIONS ON THE FUEL CONTAINER FOR INSPECTION AND SERVICE LIFE."
THESE VEHICLES DO NOT COMPLY WITH THE REQUIREMENTS.
OWNERS WILL BE PROVIDED A LABEL WITH THE REQUIRED STATEMENT, ALONG WITH INSTRUCTIONS FOR AFFIXING THE LABEL AT THE FUEL FILLER DOOR. OWNER NOTIFICATION BEGAN NOVEMBER 2, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V284000 on NHTSA.gov
Seat beltsAug 18, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
DEALERS WILL INSPECT THE DATE CODE ON CERTAIN SEAT BELT BUCKLES OF YOUR VEHICLE AND REPLACE ALL SEAT BELT BUCKLES THAT FALL WITHIN THE SUSPECT DATE CODE RANGE. OWNER NOTIFICATION BEGAN OCTOBER 26, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V228001 on NHTSA.gov
Representative owner complaints
1,204 reports, newest first.
Fuel system, Gasoline, May 18, 2011
JUST TURNED OFF HWY ONTO GRAVEL ROAD. FELT A JOLT AND THOUGHT I HAD A FLAT TIRE. PULLED OVER AND UPON INSPECTION NOTICED THE FUEL TANK STRAPS HAD BROKEN AND I WAS DRAGGING THE FUEL TANK DOWN THE ROAD. DUE TO BEING ON GRAVEL THERE WERE NO SPARKS AND NO FIRE. TANK WAS RUINED AND HAD TO REPLACE THAT ALONG WITH BOTH STRAPS. CHECK ENGINE LIGHT WILL NOT RE-SET SINCE THE INCIDENT AS WELL.
Fuel system, Gasoline, May 16, 2011
TL*THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 50 MPH SHE HEARD A LOUD NOISE. WHEN SHE STOPPED AND INSPECTED THE VEHICLE SHE NOTICED THAT THE TANK HAD DETACHED FROM THE VEHICLE. THE TWO STRAPS WERE BOTH FRACTURED AND RUSTED THROUGH ALONG WITH APPROXIMATELY FIVE GALLONS OF FUEL SPILLED ONTO THE HIGHWAY. THE VEHICLE WAS INSPECTED BY AN INDEPENDENT MECHANIC WHO ADVISED HER THAT BOTH STRAPS AND THE FUEL TANK NEEDED TO BE REPLACED. THE VEHICLE WAS TEMPORARILY REPAIRED BY ADDING TWO STRAPS. THE MANUFACTURER WAS CONTACTED AND ADVISED HER THAT THERE WERE NO RECALLS RELATED TO HER VIN. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 180,000. UPDATED 06/17/11 *BF UPDATED 06/21/11
Engine and engine cooling, May 16, 2011, fire
TL*THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT STATED THAT HE HEARD A LOUD NOISE IN HIS DRIVEWAY, HE WENT OUTSIDE AND THE VEHICLE WAS ENGULFED IN FLAMES. THE CONTACT DID NOT MENTION IF THERE WERE ANY INJURIES. THE POLICE WERE CALLED AND A REPORT WAS FILED. THE VEHICLE WAS NOT INSPECTED BY A DEALER NOR WAS IT REPAIRED. THE MANUFACTURER WAS CONTACTED AND ADVISED HIM THAT THE LEGAL DEPARTMENT WOULD CONTACT HIM. THE FAILURE MILEAGE WAS APPROXIMATELY 175,000.
Other or unspecified, May 15, 2011
REAR GAS TANK STRAP RUSTED OUT AND BROKE. THE TANK DID SEPARATE FROM THE TRUCK BUT DROPPED DOWN ABOUT 4 INCHES.
Fuel system, Other, May 15, 2011
I OWN A 2000 FORD F 150 THAT I BOUGHT USED BACK IN FEBRUARY. WE GOT IT HOME AND CHECKED IT OUT AND FOUND THE BROKEN STRAP. WE HAVE ONE FUEL TANK STRAP THAT IS RUSTED AND BROKE. THE OTHER ONE IS RUSTED BUT NOT BROKE AS OF NOW. *TR
Fuel system, Gasoline, May 15, 2011
2000 F-150 FORD. LOST BRAKE FLUID DUE TO RUSTED HOLE IN BRAKE LINE NEAR REAR WHEEL ON DRIVER SIDE.WHILE CRAWLING UNDER THE TRUCK I DISCOVERED THE GAS TANK FRONT STRAP RUSTED INTO. THE TANK HAD DROPPED DOWN. THE REAR STRAP WAS RUSTY BUT HOLDING. HAD TO HAVE FRONT STRAP REPLACED. REAR STRAP WAS SANDED AND PRIMERED BECAUSE THE NEW REAR STRAP I PURCHASED DID NOT FIT. HAD NEW BRAKE LINE AND TANK STRAP INSTALLED. *TR
Fuel system, Gasoline, May 14, 2011
STRAPS HOLDING THE GAS TANK UP ON MY 2000 FORD F150 RUSTED AND ENDED UP ON THE GROUND AS I WAS PULLING OUT OF MY DRIVEWAY. ONE STRAP WASN'T EVEN ON THE TRUCK AFTER FURTHER LOOKING AT IT. *TR
Structure, May 14, 2011
BROKEN FUEL TANK STRAP. LOOKED AT MY TRUCK FUEL TANK HANGING LOW. LOOKED UNDERSIDE FRONT FUEL TANK STRAP GONE. I HAD ABOUT 20 GALLONS IN TANK, OR 3/4 FULL. I WAS ABOUT TO HEAD TO FAMILY'S HOUSE 25 MILES AWAY WHEN NOTICED,. THIS WAS ON A SATURDAY MORNING. WENT TO FORD DEALER, THEY HAD BOTH STRAPS IN STOCK. REPLACED BOTH STRAPS. TOOK ABOUT 30 MINUTES TO REPLACE. *TR
Fuel system, Gasoline, May 13, 2011
S10 APPROPRIATE HANDLING - EMAIL FROM RE GAS TANKS FALLING FROM MOVING VEHICLES. *KB 2000 FORD F150. THE CONSUMER STATED THE FUEL LEAK WAS A RESULT OF A TANK STRAP THAT RUSTED. ALSO, ANOTHER STRAP IS SEVERELY CORRODED. *JB
Fuel system, Gasoline, May 13, 2011
TL* THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT STATED THAT THE FUEL TANK STRAP WAS CORRODED AND FRACTURED FROM THE VEHICLE. THE FUEL TANK STRUCK THE TOP PORTION OF THE FUEL TANK SHIELD AND WAS CAUSING FRICTION TO THE SHIELD. THE CONTACT WAS CONCERNED THAT THE FUEL TANK WOULD BEAR A HOLE IN THE FUEL TANK AND CAUSE FUEL TO LEAK. THE VEHICLE WAS NOT INSPECTED OR REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CURRENT MILEAGE WAS APPROXIMATELY 271,000 AND THE FAILURE MILEAGE WAS APPROXIMATELY 240,000.
Fuel system, Gasoline, May 13, 2011
TL* THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT STATED THAT WHILE INSPECTING THE VEHICLE, HE NOTICED THAT THE FUEL TANK STRAP WAS SEVERELY CORRODED. HE PURCHASED A NEW ONE AND REPLACED IT HIMSELF. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CURRENT MILEAGE WAS APPROXIMATELY 113,000 AND THE FAILURE MILEAGE WAS APPROXIMATELY 90,000. UPDATED 06/13/11*JB
Vehicle speed control, May 13, 2011, fire
2000 FORD F-150 TRUCK SPONTANEOUSLY COMBUSTED AT APPROXIMATELY 2AM ON MAY 12, 2011. TRUCK HAD BEEN PARKED SINCE 9AM THE PRECEDING DAY. FIRE INVESTIGATOR BELIEVES IT TO BE THE CRUISE CONTROL DEACTIVATION SWITCH PENDING FURTHER INVESTIGATION. *TR
Fuel system, Gasoline, May 12, 2011
2000 FORD F-150 GAS TANK STRAPS BROKE. *TR
Service brakes, Hydraulic, May 12, 2011, fire
TL* THE CONTACT OWNS A 2000 FORD F150. THE CONTACT WAS DRIVING APPROXIMATELY 5 MPH WHEN SMOKE WAS EMITTED FROM UNDER THE HOOD. THE CONTACT AND THE DRIVER EXITED THE VEHICLE AND THEN NOTICED FLAMES COMING FROM UNDER THE HOOD. THE DRIVER WAS ABLE TO EXTINGUISH THE FIRE WITH A FIRE EXTINGUISHER AND THE FIRE DEPARTMENT DID NOT REPORT TO THE SCENE. THE VEHICLE WAS TOWED TO AN AUTO SHOP WHERE THE TECHNICIANS STATED THERE WAS AN ELECTRICAL SHORTAGE IN THE MASTER CYLINDER THAT CAUSED THE FIRE. THE INSURANCE COMPANY STATED THAT AN INSPECTOR WOULD INVESTIGATE THE VEHICLE TO DETERMINE IF THE VEHICLE COULD BE REPAIRED OR WOULD BE DEEMED AS DESTROYED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.
Fuel system, Gasoline, May 11, 2011
TL* THE CONTACT OWNS A 2000 FORD F150. WHILE DRIVING APPROXIMATELY 55 MPH, THE CONTACT STATED THAT THE FUEL TANK DETACHED FROM THE VEHICLE. THE FIRE DEPARTMENT WAS DISPATCHED SINCE THE TANK WAS LEAKING FUEL. A POLICE REPORT WAS AVAILABLE. THE DEALER WAS CONTACT BUT DID NOT PROVIDE ANY ASSISTANCE SINCE THERE WERE NO RECALLS FOR THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE AND THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 100,000. THE VIN WAS UNAVAILABLE. UPDATED 06/24/11 *BF UPDATED 1/24/2012 *LN *TR
Fuel system, Gasoline, May 10, 2011
WHILE DRIVING MY 2000 FORD F150 PICKUP, HEARD CRASHING SOUND AND HEAVY SCRAPING. WAS ABLE TO PULL OVER TO SIDE OF ROAD AND FOUND THAT THE GAS TANK HAD DROPPED FROM BELOW THE VEHICLE CAUSING A GOUGE IN THE GAS TANK WHICH WAS DUMPING THE GAS ONTO THE ROAD. THIS HAPPENED APRIL 7, 2011. FORTUNATELY I WAS ALONE IN THE CAR AND THERE WERE NO INJURIES. BUT THERE COULD HAVE BEEN!!! *TR
Fuel system, Gasoline, May 10, 2011
TL*THE CONTACT OWNS A 2000 FORD F-150. WHILE DRIVING APPROXIMATELY 15 MPH, THE CONTACT HEARD A LOUD NOISE WHEN HE NOTICED THAT THE FUEL TANK HAD SEPARATED FROM THE VEHICLE. THE VEHICLE WAS TOWED TO A PRIVATE MECHANIC WHERE THEY REINSTALLED THE DETACHED FUEL TANK AND REPLACED THE HOSE AND FILLER TUBE. THE DEALER ADVISED THE CONTACT TO BRING THE VEHICLE IN FOR INSPECTION. THE MANUFACTURER WAS NOT ADVISED OF THE FAILURE. THE CURRENT MILEAGE WAS 175,000. THE APPROXIMATE FAILURE MILEAGE WAS 150,000. THE VIN WAS UNAVAILABLE.
Fuel system, Gasoline, May 10, 2011
TL*THE CONTACT OWNS A 2000 FORD F150. THE CONTACT STATED THE FRONT FUEL TANK STRAP WAS COVERED WITH RUST THE REAR STRAP HAD ALSO FAILED. THE DEALER STATED THEY WILL REPAIR THE STRAPS FOR $60.00. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 110,000.
Fuel system, Gasoline, May 10, 2011
TL*THE CONTACT OWNS A 2000 FORD F-150. WHILE DRIVING APPROXIMATELY 20 MPH, A LOUD NOISE EMITTED FROM OUTSIDE OF THE VEHICLE. THE CONTACT DROVE ONTO THE EMERGENCY LANE AND NOTICED THAT THE FRONT DRIVERS SIDE FUEL TANK STRAP FRACTURED AND CAUSED THE FUEL TANK TO COMPLETELY DETACH FALLING ON THE GROUND. THE VEHICLE WAS TOWED TO A LOCAL INDEPENDENT MECHANIC WHERE BOTH FUEL TANK STRAPS WERE REPLACED. THE FAILURE MILEAGE WAS APPROXIMATELY 56,000.
Fuel system, Gasoline, May 10, 2011
GAS TANK FELL FROM VEHICLE WHILE DRIVING. *TR
Fuel system, Gasoline, May 9, 2011
I HAVE A 2000 FORD F150 AND I HEARD THAT THERE IS BEING AN INVESTIGATION INTO THE GAS TANK STRAPS RUSTING THROUGH AND DROPPING THE TANK. THIS HAPPENED TO MY TRUCK CAUSING THE TANK TO DROP TO THE ROAD AND DRAG, ALSO CAUSING THE TANK TO SPRING A LEAK (NEEDING TO BE REPLACED). THE TANK, STRAPS, VENT TUBE, ETC. WERE REPLACED AT A COST OF NEAR $700.00. I WAS WONDERING WHAT STEPS IF ANY I CAN TAKE TO GET REIMBURSED FOR THIS COST. THANK YOU UPDATED 08/05/11 *BF THE CONSUMER STATED BOTH OF THE STRAPS WERE CORRODED. UPDATED 08/15/11 *TR
Fuel system, Gasoline, May 9, 2011
TL* THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT STATED THAT WHILE REFUELING THE VEHICLE, HE NOTICED THAT THE FUEL TANK WAS HANGING ABNORMALLY BECAUSE THE STRAPS WERE CORRODED AND FRACTURED. THE VEHICLE WAS NOT INSPECTED OR REPAIRED FOR THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE PROBLEM. THE CURRENT MILEAGE WAS 151,788. THE FAILURE MILEAGE WAS APPROXIMATELY 149,000.
Fuel system, Gasoline, May 9, 2011
A STRAP WHICH HOLDS ON THE GAS TANK ON MY 2000 FORD F150 BROKE WHILE I WAS DRIVING AND DRAGGED APPX. 300 YARDS, CAUSING ABOUT 10 GALLONS TO LEAK OUT ON ROAD. THE LOCAL FIRE DEPT. HAD TO BE DISPATCHED, AND I HAD TO REPLACE THE ENTIRE TANK AND STRAP SYSTEM AT A COST OF OVER $800.00. THE LOCAL FORD DEALER THAT DID THE REPAIR DID NOT MENTION ANYTHING ABOUT A KNOWN PROBLEM. UPDATED 08/04/11 *BF THE CONSUMER STATED THE STRAP FURTHEST TO THE FRONT WAS THE ONLY STRAP THAT BROKE AND CAUSED THE FORWARD PART OF THE TANK TO DRAG. THE BREAK APPEARED TO BE IN THE CENTER OF THE STRAP ON THE BOTTOM FACING THE ROAD. THE ENTIRE METAL PART OF THE STRAP WAS EXTREMELY CORRODED. THE REAR WAS SIMILAR, BUT SEEMED TO HAVE ADDED SUPPORT FROM THE FILL NOZZLE AND CAP ASSEMBLY. ALSO TWO YEARS PRIOR, THE LOWERING SPARE TIRE CABLE WAS CORRODED AND BROKE WHILE DRIVING, WHICH CAUSED THE TIRE TO DROP TO THE GROUND. UPDATED 08/15/11 *TR
Fuel system, Gasoline, May 8, 2011
I WAS DRIVING MY FORD F150 WHEN SUDDENLY I HEARD A SOUND THAT SOUNDED LIKE SOMETHING WAS CAUGHT UNDER THE TRUCK. SLOWLY PULLED OVER AND FOUND THE GAS TANK WAS ON THE GROUND, HELD UP ON ONE END BY A HOSE. GOOD THING I WAS NOT GOING FAST OR ON A BUMPY ROAD. IF THE TANK HAD HIT A BUMP IT WOULD HAVE BEEN CRUSHES AND POSSIBLY EXPLODED. HAD ABOUT A HALF TANK OF GAS. REPAIRS ARE ESTIMATED AT $270 SO FAR. *TR
Engine and engine cooling, Apr 14, 2011, fire
TL* THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WAS PARKED IN A RESIDENTIAL GARAGE WHEN THE VEHICLE ERUPTED IN FLAMES FROM THE ENGINE COMPARTMENT. THE FIRE DEPARTMENT WAS CALLED TO EXTINGUISH THE FIRE AND A FIRE REPORT WAS FILED. THE VEHICLE AS WELL AS THE RESIDENTIAL GARAGE WAS DESTROYED. THE MANUFACTURER HAD NOT BEEN NOTIFIED OF THE FAILURE. THE CURRENT AND FAILURE MILEAGE WAS APPROXIMATELY 69,200.