2001 Ford F-150
Problems, recalls and owner-reported issues
Engine and engine cooling is the leading concern among 1,340 owner complaints filed for this model year. This is the 2nd highest complaint count among 26 F-150 model years with reports.
Of the 2001 reports, 94 involved a crash and 262 involved a fire. 90 people were injured and 7 people died.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lighting, headlightsAug 1, 2006
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 28, 2006. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.
Campaign 06E067000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Campaign 06E065000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Vehicle speed controlSep 7, 2005
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
A FIRE AT THE SWITCH COULD OCCUR.
BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)
Campaign 05V388000 on NHTSA.gov
Visibility, windshield wiper/washer, motorAug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V258000 on NHTSA.gov
Seat belts, front, buckle assemblyJul 16, 2001
VEHICLE DESCRIPTION: PASSENGER AND SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND MINIVANS. EQUIPPED WITH SEAT BELTS SUPPLIED BY TRW. IT IS POSSIBLE THAT THE DRIVER'S AND/OR FRONT PASSENGER'S OUTBOARD SEAT BELT BUCKLE MAY NOT FULLY LATCH. FORD CROWN VICTORIA BUILT AT ST. THOMAS ASSEMBLY PLANT FROM 4/17/00 - 5/29/01 MERCURY GRAND MARQUIS BUILT AT ST. THOMAS ASSEMBLY PLANT FROM 4/17/00 - 5/29/01. LINCOLN TOWN CARS BUILT AT WIXOM ASSEMBLY PLANT FROM 3/27/00 - 5/30/01. LINCOLN NAVIGATORS BUILT AT MICHIGAN TRUCK PLANT FROM 4/11/00 - 5/31/01. FORD WINDSTARS BUILT AT OAKVILLE ASSEMBLY PLANT FROM 3/23/00 - 5/30/01. FORD RANGERS BUILT AT TWIN CITIES PLANT FROM 3/28/00 - 5/30/01, AND ALSO AT THE EDISON PLANT FROM 3/13/00 - 5/25/01. FORD F-150 TRUCK BUILT AT NORFOLK PLANT FROM 4/18/00 - 5/25/00; AT ONTARIO PLANT FROM 5/10/00 - 5/28/01; AT KANSAS CITY PLANT FROM 9/11/99 - 5/25/01; AND AT CUAUTITLAN PLANT FROM 5/16/00 - 6/9/01. FORD SUPER DUTY F-250, F-350, F-450, AND F-550 TRUCKS BUILT AT KENTUCKY PLANT FROM 4/17/00 - 5/27/01; AND AT CUAUTITLAN PLANT FROM 5/16/00 - 6/19/01. FORD EXCURSIONS BUILT AT KENTUCKY PLANT FROM 4/17/00 - 10/2/00. FORD EXPEDITIONS BUILT AT MICHIGAN TRUCK PLANT FROM 4/11/00 - 5/31/01.
IN THE EVENT OF A CRASH, THE RESTRAINT SYSTEM MAY NOT PROVIDE ADEQUATE OCCUPANT PROTECTION, INCREASING THE RISK OF PERSONAL INJURY TO THE SEAT OCCUPANT.
DEALERS WILL INSPECT THE FRONT OUTBOARD SEAT BELT BUCKLES AND IF THE BUCKLE FAILS THE INSPECTION PROCESS, IT WILL BE REPLACED. OWNER NOTIFICATION BEGAN JULY 25, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 01V227001 on NHTSA.gov
Service brakes, hydraulic, foundation components, hoses, lines/piping, and fittingsMar 23, 2001
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS. THE LEFT FRONT BRAKE HOSE WAS DAMAGED DURING FINAL ASSEMBLY.
IF THE HOSE IS DAMAGED, BRAKE FLUID COULD LEAK AND STOPPING DISTANCES MAY BE INCREASED.
DEALERS WILL INSTALL A NEW LEFT FRONT BRAKE HOSE ASSEMBLY. OWNER NOTIFICATION BEGAN MARCH 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-248-0186 OR 1-800-392-3673.
Campaign 01V095000 on NHTSA.gov
Air bags, frontalMar 12, 2001
VEHICLE DESCRIPTION: PASSENGER AND SPORT UTILITY VEHICLES. THE INFLATOR CANISTER IN THE DRIVER AIR BAG MODULE MAY HAVE AN INADEQUATE WELD NEAR THE IGNITER.
IN THE EVENT OF A VEHICLE CRASH, THE DRIVER AIR BAG MAY NOT DEPLOY AS INTENDED, POTENTIALLY RESULTING IN REDUCED OCCUPANT PROTECTION, OR A BURN INJURY.
DEALERS WILL INSTALL A DRIVER AIR BAG MODULE. OWNER NOTIFICATION BEGAN MARCH 19, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 01V082000 on NHTSA.gov
Equipment, other, owners/service/other manualNov 28, 2000
VEHICLE DESCRIPTION: CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE AFFECTED EXPEDITION/NAVIGATOR OWNER GUIDES DO NOT IDENTIFY THE LOCATIONS OF SEATING POSITIONS EQUIPPED WITH TETHER ANCHORAGES, AND DO NOT PROVIDE INSTRUCTIONS FOR SECURING CHILD SEATS TO THESE TETHER ANCHORAGES. THE F150 SC OWNER GUIDES DO NOT PROVIDE THE PROCEDURE FOR SECURING CHILD SEATS TO THE TETHER ANCHORAGES. THE TAURUS/SABLE OWNER GUIDES DO NOT IDENTIFY THE CENTER REAR SEATING POSITION AS HAVING LATCH COMPATIBLE LOWER ANCHORAGES.
IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
OWNERS WILL BE PROVIDED WITH OWNER GUIDE INSERTS REVISED TO PROVIDE THE REQUIRED INFORMATION, AND INSTRUCTIONS FOR AFFIXING THESE INSERTS TO THEIR OWNER GUIDES. CUSTOMERS WILL ALSO BE ADVISED THAT IF THEY PREFER, THEIR DEALER WILL AFFIX THE INSERTS TO THEIR OWNER GUIDES.
Campaign 00V396000 on NHTSA.gov
Seat belts, front, retractorOct 30, 2000
VEHICLE DESCRIPTION: REGULAR CAB PICKUP TRUCKS. THE DRIVER SIDE SEAT BELT RETRACTOR MAY NOT FULLY RETRACT THE BELT.
THIS COULD CAUSE SLACK IN THE SEAT BELT WHEN WORN, INCREASING THE RISK OF PERSONAL INJURY TO THE SEAT OCCUPANT, IN THE EVENT OF A CRASH.
DEALERS WILL REPLACE THE DRIVER'S SIDE SEAT BELT ASSEMBLY.
Campaign 00V348000 on NHTSA.gov
Representative owner complaints
1,340 reports, newest first.
Engine and engine cooling, Fuel/propulsion system, May 27, 2012
I WAS DRIVING HOME AND ALL OF A SUDDEN THERE WAS AN EXPLOSION UNDER THE HOOD AND IT SOUNDED LIKE PART OF THE EXHAUST SYSTEM GAVE WAY. I PULLED OVER AND FOUND OUT THAT A SPARK PLUG HAD BLOWN OUT OF THE HEAD. THE ONLY ONE TO EVER TOUCH THE ENGINE WAS FORD AND THAT THEY HAD REPLACED A SPARK PLUG SEVERAL YEARS AGO. I GOT ON LINE AND FOUND OUT THERE ARE LITERALLY THOUSANDS OF THESE SPARK PLUG EJECTIONS. I WAS WONDERING IF THERE WAS A RECALL ON THE PROBLEM ? THE FACT THAT THE SUPER-HEATED AIR AND MIXTURE FUEL SPRAYING ALL OVER THE UNDERNEATH OF THE HOOD IS A EXTREME DANGER, IT WOULD SEEM THAT WOULD BE A SAFETY RECALL. *TR
Structure, Wheels, Engine, May 19, 2012, fire
THE TRUCK STARTED ON FIRE WHILE SITTING IN THE DRIVEWAY HOURS AFTER BEING PARKED. BY THE TIME WE REALIZED IT WAS ON FIRE, IT WAS TOTALLY OUT OF CONTROL AND THE TRUCK WELL BEYOND SAVING. IT BURNED SO HOT IT MELTED THE TIRES, THE SIDING OF THE HOUSE AND DESTROYED PART OF A PRIVACY FENCE. WE KEPT WATER ON THE FIRE UNTIL IT WENT OUT ABOUT AN HOUR AND A HALF LATER. THE FIRE STARTED UNDER THE HOOD AND THE WHOLE FRONT OF THE TRUCK IS ALMOST UNRECOGNIZABLE. THE OWNER ( [XXX] ) IS AN AUTO MECHANIC AND HAS BEEN FOR FORTY PLUS YEARS. WE RUN AN AUTO REPAIR BUSINESS. WE HAD HEARD VAGUE THINGS ABOUT FORDS AND FIRES BUT DID NOT LOOK INTO IT UNTIL AFTER THE INCIDENT. WE PURCHASED THE TRUCK THIS WINTER AND NEVER GOT ANY RECALL NOTICES FOR THE CRUISE CONTROL SWITCH PROBLEM. THE PRIOR OWNER SAYS HE DID NOT EITHER. WE HAVE NOT YET CONTACTED FORD BECAUSE OF READING ALL THE HORROR STORIES OF HOW THEY REFUSE RESPONSIBILITY. WE HAD LIABILITY INSURANCE ONLY. THE ANGER IS LETTING UP A BIT AND THE SHOCK HAS WORN OFF AND NOW WE ARE FIGURING OUT THE NEXT STEP. REPORTING THE INCIDENT TO YOU SEEMS TO BE IT. I WILL CONTACT FORD ON MONDAY. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Engine and engine cooling, Apr 20, 2012
PULLED OUT OF SIDE ROAD ONTO MAJOR HIGHWAY AND SUDDENLY A LOUD FLAPPING NOISE FROM ENGINE WAS HEARD. IMMEDIATELY PULLED TO SHOULDER OF ROAD AND TURN VEHICLE OFF AND CALLED FOR ASSISTANCE. WAS TOLD THAT A SPARK PLUG WAS THE CAUSE OF THE PROBLEM AND THAT IT SHOULD BE A EASY FIX, THIS WAS NOT THE CASE BECAUSE THE HEAD HAD TO BE REMOVED TO EXTRACTED TO DAMAGED PLUG. OUR FIX IS COSTING UPWARDS OF $700. *JS
Engine and engine cooling, Apr 11, 2012
TL* THE CONTACT OWNS A 2001 FORD F-150 TRITON. THE VEHICLE WAS TAKEN FOR STATE INSPECTION WHEN THE CONTACT WAS ADVISED THAT THE ENGINE, ENGINE MANIFOLD AND BOLTS WERE CORRODED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE WAS CONFIRMED. THE MANUFACTURER WAS CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 68,000 AND THE CURRENT MILEAGE WAS 71,000. UPDATED 05/21/12 *BF THE CONSUMER WAS INFORMED THE MATERIAL USED WERE DEFECTIVE.
Exterior lighting, Apr 10, 2012
TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED THAT THE HEADLIGHTS STOPPED ILLUMINATING WHENEVER THE TURN SIGNALS WERE ACTIVATED. THE FAILURE OCCURRED WHEN USING BOTH THE LOWBEAM AND HIGHBEAM HEADLIGHTS. THE VEHICLE WAS TAKEN TO THE DEALER, WHERE THE CONTACT WAS INFORMED THAT THE TURN SIGNALS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGES WERE 43,000.
Service brakes, Hydraulic, Apr 2, 2012
TL* THE CONTACT OWNS A 2001 FORD F-150. WHILE DRIVING APPROXIMATELY 20 MPH THE CONTACT DEPRESSED THE BRAKE PEDAL WHEN IT SUDDENLY DROPPED TO THE FLOOR BOARD. THE CONTACT CONTINUED DEPRESSING THE BRAKE PEDAL IN ORDER TO STOP THE VEHICLE. AFTER INSPECTING THE VEHICLE THE CONTACT NOTICED THE BRAKE LINES WERE CORRODED AND FRACTURED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.
Engine and engine cooling, Mar 19, 2012, fire
TL* THE CONTACT OWNS A 2001 FORD F-150. WHILE PARKED, THE CONTACT NOTICED SMOKE COMING FROM UNDER THE HOOD. AFTER OPENING THE HOOD THE CONTACT NOTICED THAT THE MANIFOLD AND THE WIRING HARNESS WAS ON FIRE. THE CONTACT STATED THAT THE VEHICLE HAD BEEN SHUT OFF AND HAD NOT BEEN DRIVEN PRIOR TO THE FIRE. THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE WITH A FIRE EXTINGUISHER. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTICS OR REPAIRS. THE APPROXIMATE FAILURE MILEAGE WAS 28,000.
Vehicle speed control, Mar 13, 2012
TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT THE ENGINE RPMS WOULD INCREASE EXCESSIVELY IN COLDER WEATHER, USUALLY ABOUT 15 DEGREES. WHEN THE FAILURE WOULD OCCUR, THE VEHICLE WOULD ABNORMALLY ACCELERATE WHILE THE CONTACT WAS DRIVING. THE FAILURE RECURRED FIVES TIMES. THE CONTACT HAD TO SHIFT INTO NEUTRAL IN ORDER TO STOP THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 120,000 AND THE CURRENT MILEAGE WAS 158,000. UPDATED 04/10/12*LJ
Electrical system, Vehicle speed control, Mar 2, 2012, fire
ON OR ABOUT 2004, COMPLAINANT PURCHASED A FORD TRUCK, F-150, SUPERCREW, 4X2, MODEL 2001. COMPLAINANT OWNS AND LIVES IN A HOUSE. SAID HOUSE HAS A GATE CARPORT. BY SEPTEMBER 20, 2011, THE ABOVE REFERENCED VEHICLE HAD BEEN PARKED AND TURNED OFF FOR ABOUT ONE (1) WEEK IN THE GATED CARPORT OF COMPLAINANTS HOUSE. ON SEPTEMBER 20, 2011, SOMETIME BETWEEN 12:00PM AND 1:00PM THE ABOVE REFERENCE VEHICLE BEGAN TO BURN INSIDE THE CARPORT. THE FLAMES AND THE SMOKE FLOWING FROM THE VEHICLE EXPANDED INTO COMPLAINANTS HOUSE CAUSING DAMAGES TO THE STRUCTURE AND A MYRIAD OF MOVABLE OBJECTS LOCATED THEREIN. ACCORDING TO COMPLAINANTS FORENSIC EXPERT, THE VEHICLE BEGAN TO BURN AS A RESULT OF A FAILURE IN THE VEHICLE'S CRUISE CONTROL SWITCH DEACTIVATOR. *TR
Engine and engine cooling, Feb 18, 2012
I'M IN THE LARGE GROWING NUMBER OF OWNERS THAT HAVE HAD A SPARKPLUG BLOW OUT. FORD KNOWS THIS IS A PROBLEM AND HAVE COME UP WITH A SPECIAL TOOL TO HELP IN THE REPAIR OF THIS. IT RETHREADS THE HOLE THEN THEY HAVE AN INSERT THAT GOES IN IT. THE PROBLEM IS THERE'S NOT ENOUGH THREADS TO HOLD THE PLUG. THE THING IS, IF THEY DON'T WANT TO DO A TOTAL RECALL THEN THEY SHOULD AT LEAST COVER THE EXPENSE WHEN IT HAPPENS. I GUESS LIKE EVERYTHING ELSE, IT'S GOING TO TAKE A DEATH OR SERIOUS INJURY BEFORE THEY WILL STEP UP TO THE PLATE AND DO THE RIGHT THING. *TR
Service brakes, Hydraulic, Feb 7, 2012
WHILE RETURNING HOME, TOWING 25' PONTOON BOAT, APPROACHING DRIVEWAY WHEN BRAKE PEDAL WENT TO FLOOR, NO BRAKES. FORTUNATELY I WAS ABLE TO MANEUVER THE VEHICLE INTO MY YARD AND STOP WITH PARKING BRAKE. ROOT CAUSE WAS FOUND TO BE BRAKE LINE ABOVE DRIVER'S SIDE REAR WHEEL HAD RUSTED THROUGH AT FITTING CAUSING LOSS OF BRAKE FLUID. UPON CLOSE INSPECTION, MANY BRAKE LINES, TRANSMISSION COOLING LINES, GAS TANK STRAPS (THE LATTER SUBSEQUENTLY REPLACED PER FORD RECALL) ARE DETERIORATING DUE TO EXCESSIVE RUST. ALTHOUGH THIS VEHICLE IS 11 YEARS OLD, IT ONLY HAS 58,867 ORIGINAL, DOCUMENTED MILES, AND HAS NOT BEEN EXPOSED TO EXCESS ROAD SALT (MID-ATLANTIC REGION). I HAVE HAD TO REPLACE BRAKE ROTORS, CALIPERS, BRAKE SHIELDS, EGR TUBE, EXHAUST SYSTEM FROM MUFFLER BACK, AND PARKING BRAKE ASSEMBLY ALL DUE TO EXCESSIVE, AND WHAT I CONSIDER, PREMATURE RUST. IF THAT WERE NOT BAD ENOUGH, YESTERDAY I LOOK UNDER THE TRUCK AND SEE A PUDDLE OF TRANSMISSION FLUID. ONE OF THE TRANSMISSION COOLING LINES BETWEEN THE TRANSMISSION AND THE UPPER RADIATOR HAS RUSTED THROUGH, AND ONCE AGAIN I WILL BE RESPONSIBLE FOR THE REPAIRS. I HAVE OWNED MANY FORD PRODUCTS IN MY 44 YEARS OF DRIVING BUT HAVE NEVER EXPERIENCED ANYTHING OF THIS MAGNITUDE WITH A VEHICLE OF SUCH LOW MILEAGE. BRAKE LINES RUSTING OUT SHOULD BE CONSIDERED A SIGNIFICANT SAFETY CONCERN. IF I HAD LOST BRAKES WHILE TRAVELING ON THE HIGHWAY TOWING A 3000 LB BOAT AND TRAILER IT COULD HAVE BEEN DISASTROUS. I FEEL THE GAS TANK STRAP RECALL IS A START, BUT FAR FROM ADDRESSING THE OVERALL ISSUE OF UNDERCARRIAGE DETERIORATION WITH THIS YEAR/MODEL VEHICLE. *TR
Engine and engine cooling, Electrical system, Feb 6, 2012
SPARK PLUG BLEW OUT OF ENGINE CAUSING FAILURE. ENGINE. *TR FIRE
Engine and engine cooling, Feb 1, 2012
ATTEMPTED TO START A 2001 FORD F-150 SUPER CREW THAT HAS A 5.4LITER ENGINE AND ONLY 80,500 AND HEARD A BANG. ENGINE STARTED BUT MADE A LOT OF NOISE. I SHUT DOWN THE ENGINE AND CHECKED UNDER HOOD. ON THE RIGHT SIDE OF ENGINE FOUND A PLUG WIRE AND COIL DESTROYED WHICH INDICATED A SPARK PLUG EXPLODED OUT OF THE CYLINDER HEAD. REPAIR SHOP SAID DO NOT DRIVE IT AS FUEL WILL SPRAY ON HOT MANIFOLD AND WILL CAUSE A FIRE. THEY SAID I WAS LUCKY ENGINE WAS NOT HOT. THESE WERE THE FACTORY INSTALLED PLUGS AS ORIGINAL WINDOW STICKER SAYS 100K MILE TUNE-UPS. ESTIMATE OF REPAIR IS $4,000. FORD ACCRONIM APPLIES HERE "FOUND ON ROAD DEAD OR, FIX OR REPAIR DAILY." UPON INTERNET SEARCH THIS APPEARS TO BE A COMMON OCCURANCE AND NEITHER FORD OR NHITSA ARE DOING ANYTHING ABOUT IT. FORD HAS EVEN PUT OUT A TSB07-15-2 AUTHORIZING A SPECIFIC TOOL AND REPAIR PROCEDURE FOR ALUMINUM HEADS FOR THE 5.4 1997 TO 2004 FSERIES. FORD KNOWS IT IS AN ENGINEERING DEFECT AND NHITSA KNOWS IT IS A FIRE HAZARD AS SOME VEHICLES HAVE CAUGHT ON FIRE. *TR
Engine and engine cooling, Jan 18, 2012
I HAVE A 2001 FORD PICKUP WITH 116,000 MILES THAT I HAVE BABIED SINCE I PURCHASED IT JUST THIS WEEK I HAD A SPARK PLUG BLOW OUT OF THE HEAD, JUST SO HAPPENED I WAS 45 MILES AWAY FROM HOME, SO A WRECKER CHARGE WAS DUE, TOOK MY TRUCK TO MY USUAL REPAIR SHOP BUT THEY SAID THEY COULDN'T FIX THE PROBLEM. SO I THEN HAD TO FIND SOMEONE ELSE, ANOTHE WRECKER CHARGE. FORD MUST KNOW FROM ALL THE COMPLAINTS THAT THIS IS A BIG PROBLEM AND VERY COSTLY. FORD SHOULD RECALL ALL VEHICLES WITH ALUMINUM HEADS AND INSTALL A STEEL SLEEVE IN ALL SPARK PLUGS TO TAKE CARE OF THIS PROBLEM, THEY ARE SAVING TONS OF MONEY WITH THIS TYPE OF FAULTY ENGINE. I HAD CONSIDERED BUYING A NEW FORD PICKUP, BUT THIS JUST MIGHT HAVE CHANGED MY MIND. THE PRICE OF VEHICLES THESE DAYS, MANY PEOPLE LIKE MYSELF HAVE TO DRIVE THEIR VEHICLES SERVERAL YEARS, WE CAN'T AFFORD A NEW VEHICLE WITH THE PRICE OF GAS. THE POOR MIDDLE CLASS IS ALMOST A THING OF THE PAST, IF YOU'RE NOT MAKING 100,000 A YEAR YOU'RE HARD PRESSED TO KEEP YOUR HEAD ABOVE WATER. SOMEONE NEEDS TO STOP THE THINGS THAT RAGAN STARTED WITH HIS TRICKLE DOWN POLICIES AND FIX THE PROBLEM. KEEP THE REPUBLICANS OUT OF OFFICE AND LET SOME GOOD PEOPLE WORK FOR THE MIDDLE CLASS FOR ONCE.
Engine and engine cooling, Jan 13, 2012
SPARK PLUG BLOW OUT CAUSED EXCESSIVE DAMAGE TO ENGINE. ENGINE HAD TO BE REPLACED AT A COST OF $6200.00. THIS IS A KNOWN PROBLEM FOR 1999 TO 2005 ENGINES. *TR
Electrical system, Jan 5, 2012, fire
MY F150 BLOWER MOTOR UNIT JUST SHORTED OUT AND CAUGHT FIRE WHILE I WAS ON THE FREEWAY. I AM JUST SO DISGUSTED AS I ALREADY GOT PAST BLOWING OUT SPARKPLUGS ON THIS TRUCK AS I HAD TO REMOVE THE HEAD AND RE THREAD IT SO THEY WOULD BE SAFE AND NOW THIS. HOW DOES FORD CONTINUE TO GET A AWAY WITH PRODUCING VEHICLES THAT ARE DANGEROUS TO THE PUBLIC? I LOVED MY TRUCK BUT WILL PROBABLY HAVE TO MOVE TO A SAFER VEHICLE NOW. *TR
Engine and engine cooling, Jan 5, 2012
I WAS GETTING ON THE INTERSTATE THIS AM AND HEARD A NOISE, THE TRUCK LOST POWER AND STARTED RUNNING EXTREMELY ROUGH. I TURNED AROUND AND BARELY MADE IT HOME (ONLY A FEW MILES). WHEN I RAISED THE HOOD, A SPARK PLUG WAS LAYING ON TOP OF THE ENGINE. THE COIL PACK WAS ALSO BROKEN WHEN THE SPARK PLUG BLEW OUT. THERE WAS A VERY STRONG SMELL OF GAS. I RESEARCHED THE INTERNET AND FOUND THAT THIS IS A MAJOR PROBLEM WITH FORD ENGINES BUILT FROM 1997 - 2003. IF I HAD BEEN IN A CENTER OR LEFT LANE, BEING RUSH HOUR TRAFFIC, THIS COULD HAVE CAUSED A MAJOR WRECK. THIS PROBLEM SHOULD NOT BE IGNORED AND SHOULD BECOME A RECALL FOR FORD. *TR
Fuel system, Gasoline, Jan 2, 2012
NOT A NEW COMPLAINT, JUST WANTED TO SAY THANKS. FORD MOTOR COMPANY HAS REIMBURSED ME FOR 100% OF MY EXPENSES RELATED TO THE GAS TANK STRAP FAILURE. THANK YOU, AND THANK FORD MOTOR COMPANY. I COULD NOT FIND ANOTHER WAY TO EDIT MY PREVIOUS COMPLAINT. ODI # 10402810. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Fuel system, Gasoline, Dec 30, 2011
TL* THE CONTACT OWNS A 2001 FORD F150. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 11V385000 ( FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING) AND TOOK THE VEHICLE TO THE DEALER FOR REPAIRS. WHILE THE VEHICLE WAS BEING SERVICED, THE FUEL TANK WAS FRACTURED AND BEGAN LEAKING GASOLINE. NEITHER THE DEALER NOR THE MANUFACTURER OFFERED ANY ASSISTANCE WITH THE FAILURE SINCE THE RECALL DID NOT INCLUDE REPAIRING THE FUEL TANK. THE CURRENT AND THE FAILURE MILEAGES WERE 129,400. UPDATED 02/03/12*LJ THE TANK WAS REPLACED FREE OF CHARGE ON JAN 17, 2011 AND THE PROBLEM HAS BEEN RESOLVED. UPDATED 02/10/12
Service brakes, Hydraulic, Dec 20, 2011
I HAVE A 2001 FORD F-150 THAT I WAS USING TO DROP MY SON OFF AT HIS FRIEND'S HOUSE. ON THE WAY HOME MY BRAKE PEDAL WENT TO THE FLOOR, I WAS TRAVELING AT ABOUT 35 MPH AND I WAS NOT ABLE TO STOP AT THE INTERSECTION LIKE I WAS SUPPOSED TO. I DID MANAGE TO DRIVE HOME WITH LITTLE TO NO BRAKES. WHEN I GOT HOME I LOOKED IN THE BRAKE FLUID WELL AND THERE WAS NO FLUID IN THERE. I LOOKED AT THE GROUND ON THE DRIVERS SIDE NEAR THE REAR TIRE AND I SAW FLUID DRIPPING ON THE GROUND. I GOT UNDER THE TRUCK AND WAS SURPRISED TO SEE A LOT OF BRAKE FLUID ON THE SIDE OF GAS TANK AND DRIPPING FROM THE FRAME. THIS IS A VERY UNUSUAL AND DANGEROUS SITUATION. NEEDLESS TO SAY, I NO LONGER HAVE THE USE OF MY VEHICLE. I RECENTLY TOOK THE TRUCK IN FOR RECALL SERVICE TO HAVE THE GAS TANK SUPPORT STRAPS REPLACED, IS POSSIBLE THAT THE BRAKE LINE WAS COMPROMISED DURING THE RECALL WORK? I HAVE OWNED MANY VEHICLES AND THIS IS THE FIRST TIME I HAVE SEEN SOMETHING LIKE THIS. I CONTACTED FORD ABOUT THIS UNUSUAL INCIDENT AND THEY STATED THAT BECAUSE MY TRUCK IS NO LONGER UNDER WARRANTY THAT I SHOULD TAKE IT TO A DEALER AND HAVE IT REPAIRED. THE LARGER ISSUE IS THAT SOMETHING LIKE THIS SHOULD NEVER HAPPEN, WARRANTY OR NO. WHAT IF I HAD BEEN TRAVELING AT A FASTER RATE OF SPEED OR ENTERING A BUSY INTERSECTION OR A NERVOUS DRIVER. THIS INCIDENT COULD HAVE ENDED VERY BADLY. THE BRAKE LINES SHOULD NOT RUPTURE. MY CONCERN IS WHETHER THESE WAS AN ISOLATED INCIDENT, OR HAVE OTHER BRAKE LINES RUPTURED CAUSING ACCIDENTS AND HAVE NOT BEEN REPORTED. *TR
Engine and engine cooling, Fuel system, Gasoline, Vehicle speed control, Dec 16, 2011, crash
ATTEMPTING TO PARK VEHICLE IN PARKING STALL WITH FOOT ON BRAKE STOPPING THE VEHICLE. THE VEHICLE, FOR NO APPARENT REASON, ABRUPTLY ACCELERATED FORWARD STRIKNIG THE VEHICLE ON THE OTHER SIDE OF THE PARKING STALL. THE RESULTING CRASH CAUSED DAMAGE TO THE FRONT OF THE 2011 GMC SPORT UTILITY VEHICLE AND TO THE FRONT OF THE 2001 FORD F-150. THIS IS THE SECOND TIME AN INCIDENT SIMILAR TO THIS HAS OCCURRED. THE FIRST TIME WAS IN AUGUST 2011. THE FIRST TIME THE VEHICLE DEMONSTRATED A SIMILAR PHENOMENA OCCURRED WHEN THE OWNER WAS PARKING THE VEHICLE IN A PARKING STALL. THE VEHICLE WAS STOPPED IN THE PARKING STALL, THE DRIVER'S FOOT ON THE BRAKE AND THE VEHICLE ABRUPTLY ACCELERATED, FOR NO APPARENT REASON, OVER A CONCRETE PARKING BLOCK. THE VEHICLE CONTINUED INTO THE STREET AS THE DRIVER CONTINUED TO APPLY THE BRAKE, ATTEMPTING TO STOP THE FORD F-150. THE DRIVER WAS UNABLE TO AVOID STRIKING A VEHICLE AFTER ENTERING THE STREET. *TR
Power train, Dec 12, 2011
WHILE DRIVING ON HIGHWAY AT HIGHWAY SPEEDS AND WHEN THROTTLE IS APPLIED AT FULL CAPACITY, THROTTLE PEDAL STICKS FOR UP TO THIRTY (30) SECONDS BEFORE SELF RELEASING. ENGINE RPM REACHES NEAR MAXIMUM AND VEHICLE SPEED INCREASES UNTIL VEHICLE IS PLACED IN 'NEUTRAL' AND THROTTLE SELF RELEASES. PROBLEM HAS ONLY OCCURRED WHILE ON HIGHWAY AND CAN NOT BE DUPLICATED WHILE STATIONARY OR IN 'PARK.' PROBLEM WAS DUPLICATED BY DRIVER TWO TIMES WHILE ENTERING HIGHWAY ON RAMP AT APPROXIMATE SPEED OF 60MPH. PROBLEM OCCURRED TWO TIMES WITHIN FIVE (5) MINUTES. *TR
Visibility, Seat belts, Dec 2, 2011
TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT THE FRONT DRIVER'S SEAT BELT WOULD NOT ATTACH INTO ITS BUCKLE. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE CONTACT ALSO STATED THAT THE REAR WINDSHIELD WAS LEAKING. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES AND INFORMED THE CONTACT THAT THERE WERE NO RECALLS ADDRESSING THE FAILURES. THE FAILURE MILEAGE WAS 115,000.
Electrical system, Nov 29, 2011
TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT THE WIRING HARNESS AND COIL PLUG WAS CAUSING THE VEHICLE TO STALL AND DRIVE HARD. THE CONTACT TOOK THE VEHICLE TO THE DEALER TO HAVE THE WIRING HARNESS AND COIL PLUG REPLACED BUT THE REPAIR DID NOT REMEDY THE ISSUE. THE CONTACT TOOK THE VEHICLE BACK TO THE DEALER BUT THE DEALER COULD NOT PROPERLY DIAGNOSE THE VEHICLE. THE FAILURE MILEAGE WAS 68,000.
Fuel system, Gasoline, Nov 28, 2011
A PLASTIC COVER OVER THE REAR PART (TOWARDS THE AXLE) OF THE GAS TANK HAS CAUSED A RUST HOLE IN THE TANK. THE PIECE IS HELD ON WITH 2 STRIPS OF DOUBLE SIDED ADHESIVE AND ATTACHES TO TWO CLIPS ON THE TANK. THE RUST DAMAGE IS UNDER THE ADHESIVE STRIP ON THE BOTTOM CAUSING A VERY SLOW LEAK. I'M NOT SURE WHAT THE FUNCTION IS FOR THIS PLASTIC PIECE AND I CAN'T IMAGINE THAT MY VEHICLE IS THE ONLY ONE AFFECTED BY THIS DESIGN FLAW? *KB