2002 Ford F-150
Problems, recalls and owner-reported issues
Engine and engine cooling is the leading concern among 955 owner complaints filed for this model year. This is the 5th highest complaint count among 26 F-150 model years with reports.
Of the 2002 reports, 58 involved a crash and 100 involved a fire. 67 people were injured.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lighting, headlightsAug 1, 2006
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 28, 2006. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.
Campaign 06E067000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Campaign 06E065000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Vehicle speed controlSep 7, 2005
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
A FIRE AT THE SWITCH COULD OCCUR.
BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)
Campaign 05V388000 on NHTSA.gov
Representative owner complaints
955 reports, newest first.
Engine and engine cooling, Nov 12, 2009
I GOT IN THE TRUCK AND STARTED IT, THERE WAS A FUNNY NOISE AND A LOUD BANG. I SHUT OFF THE TRUCK AND SAW SMOKE COMING FROM UNDER THE HOOD ON THE PASSENGER SIDE NEAR THE WINDSHIELD. I LOOKED UNDER THE HOOD AND DECIDED IT NEEDED TO GO INTO THE SHOP. I TOOK IT TO THE DEALERSHIP AND WAS TOLD THE SPARK PLUG HAD BLOWN OUT OF THE BLOCK OF THE TRUCK, THEY TRIED TO PUT IT BACK IN BUT THE HEAD HAD BEEN STRIPPED AND THE COIL WAS CRACKED. WE WERE THEN ADVISED THAT THE TRUCK NEEDED A NEW HEAD. *TR
Engine and engine cooling, Nov 9, 2009
02' FORD F150 TRITON V8 5.4 1. LOUD TAPPING NOISE FROM MOTOR. 2. & 3. SPARK PLUG BLOWN OUT OF THE HEAD. SO FAR THIS HAS HAPPENED TWICE. NEW SPARK PLUG, NEW COIL PACK, HEALY-COIL PACK, 4 HRS OF MY TIME WORKING ON THIS P.O.F.S... THERE SHOULD BE A RECALL ON THIS BECAUSE IT SEEMS TO BE HAPPENING ON ALL THE FORD TRUCKS OUT THERE. ONLY FORD. *TR
Vehicle speed control, Nov 9, 2009
MID SEPTEMBER 2009 THE CRUISE CONTROL ON MY FORD F-150 TRUCK FAILED TO COME ON. NOVEMBER 6, 2009 I WENT TO WINCHESTER FORD, WINCHESTER, VA TO SEE IF THE SWITCH WAS UNDER RECALL AND TOLD NO. I WAS SHOWN WHERE THE CRUISE CONTROL SWITCH IS LOCATED AND TOLD THE BEST THING TO DO WAS UNPLUG IT IF I WASN'T GOING TO PAY TO REPLACE IT. I PURCHASED A NEW SWITCH FROM THE PARTS ROOM WHEN LEAVING THE FORD GARAGE. ON SUNDAY, 11/8/2009 I UNPLUGGED THE SWITCH AND FOUND EVERYTHING COVERED IN BRAKE FLUID. I PLUGGED THE SWITCH BACK IN TO STOP ANY FLUID FROM SPRAYING OUT ONTO THE ENGINE. I WILL HAVE TO FIND SOMEONE TO REPLACE THE SWITCH BECAUSE I AM PHYSICALLY UNABLE TO DO THE WORK. *TR
Engine and engine cooling, Nov 7, 2009
I HAVE A 2002 FORD F150 SUPERCREW HARLEY DAVIDSON EDITION WITH A TRITON 5.4 L ENGINE. I PLACED THE TRUCK IN DRIVE AND HEARD A POP AND THEN A CONTINUED RHYTHMIC POPPING. I OPENED THE HOOD AND COULD TELL AIR WAS COMING FROM THE #4 CYLINDER. I TURNED OFF THE ENGINE AND INVESTIGATED FURTHER. THE SPARK PLUG HAD BLOWN COMPLETELY OUT OF THE HEAD AND BROKE THE IGNITION COIL ATTACHED TO THE SPARK PLUG WIRE. SO FAR THIS IS THE ONLY INCIDENT FOR ME BUT AFTER RESEARCHING ONLINE, FOR POSSIBLE REPAIRS SOLUTIONS, I FOUND THAT THIS IS WAY TOO COMMON OF A PROBLEM WITH THESE FORD ENGINES. I AM ONLY GLAD IT HAPPENED WHILE I WAS PULLING OUT OF MY GARAGE. IF THAT HAD HAPPENED AT SPEED ON THE HIGHWAY WITH THE ENGINE TEMPERATURE UP THERE COULD HAVE BEEN A SERIOUS SITUATION. AFTER READING ALL THE PROBLEMS SO MANY OTHERS HAVE HAD, I AM AFRAID OF WHEN THIS COULD HAPPEN AGAIN! *TR
Engine and engine cooling, Nov 5, 2009
2002 FORD F150 5.4L,SPARK PLUG BLEW OUT OF ENGINE WHILE DRIVING, GAS SMELL AND SPARKS IN ENGINE COMPARTMENT. THIS HAS HAPPENED TWICE TO ME, 11-25-08 AT 70K MI WITH ORIGINAL FACTORY PLUGS CLY #3 PASSENGER SIDE AND 11-03-09 AT 82K MI WITH THE REPLACEMENT NGK PLUGS CLY #4 DRIVERS SIDE. THIS SHOULD BE A RECALL VERY HIGH RISK OF UNDER HOOD FIRE. *TR
Vehicle speed control, Oct 21, 2009, fire
TL* THE CONTACT OWNS A 2002 FORD F150. HIS VEHICLE WAS PARKED FOR OVER TWENTY-FOUR HOURS IN THE DRIVE-WAY WHEN THE ENGINE CAUGHT ON FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FLAMES. THE VEHICLE WAS COMPLETELY DESTROYED. THE FAILURE MILEAGE WAS 167,000. UPDATED 12/08/09. *LJ THE CONSUMER DID STATE THAT HE HAD PROBLEMS WITH THE CRUISE CONTROL, DUE TO A SHORT AND HAD NOT USED IT SINCE. THE FIRE DEPARTMENT STATED THE CAUSE OF THE FIRE WAS THE CRUISE CONTROL. UPDATED 12/10/09.*JB
Engine and engine cooling, Oct 14, 2009
TL*THE CONTACT OWNS A 2002 FORD F-150. WHILE THE CONTACT WAS DRIVING 75 MPH SHE SUDDENLY HEARD A LOUD POPPING SOUND IN THE ENGINE AND IMMEDIATELY THE VEHICLE SHUT OFF. A LOCAL MECHANIC STATED THAT THE ENGINE SEIZED AND NEEDED TO BE REPLACED. THERE WERE NO PRIOR WARNINGS AND THE CURRENT AND FAILURE MILEAGES WERE 100000. UPDATED 11/13/09. *LJ UPDATED 11/16/09.*JB
Engine and engine cooling, Oct 12, 2009
I HAVE A 2002 FORD F-150 LIGHTNING, I WAS DRIVING ONE DAY AND THE SPARK PLUG SHOT OUT OF THE ENGINE DUE TO LACK OF THREADS TO HOLD THE SPARK PLUG IN. THE VEHICLE WAS REPAIRED USING A TIME-SERT KIT. *TR
Seat belts, Oct 6, 2009
TL*THE CONTACT OWNS A 2002 FORD F-150. THE SEAT BELTS WILL NOT REMAIN LATCHED INTO THE BUCKLE. THE DRIVER-SIDE SEAT BELT AND BUCKLE WERE REPLACED AT AN EXPENSE OF $53.00. AFTER THE SEAT BELT AND BUCKLE WERE REPLACED, THE FRONT SEAT BELT FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED; HOWEVER, SINCE THE WARRANTY EXPIRED, NO ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS 63,000 AND THE CURRENT MILEAGE WAS 65,000.
Engine and engine cooling, Sep 29, 2009
APPARENTLY THE NHTSA MUST NEED MORE COMPLAINTS OR A DEATH TO INVESTIGATE THIS ISSUE. SECOND PENDING FIX 9-23-2009 95,000. AFTER HAVING READ ALL THESE COMPLAINTS AND RELIVING THE SAME PROBLEMS AGAIN THROUGH THIS WEBSITE, AND I'M SURE MANY MORE UNDOCUMENTED COMPLAINTS. I AM NOW ON MY SECOND FIX. FIRST TIME 3 SPARK PLUGS THROUGH THE ENGINE. HAD EXTENDED WARRANTY SO FORD DID A BAND AID FIX ( SURPRISE ) NOW HERE WE ARE A YEAR LATER AND WE NEED SURGERY $4900 JUST TO PUT A NEW HEAD ON ONE SIDE. WHAT IS BEING DONE TO HOLD FORD ACCOUNTABLE FOR A KNOWN DEFECT. THE OPPORTUNITY FOR FIRE AND/OR DEATH IS VERY HIGH AND YET THIS PROBLEM IS NOT IMPORTANT TO ANYONE EXCEPT FOR LETTING FORD GET RICH ON THEIR KNOWN DEFECT. SAD GOV SITE THIS IS JUST A VENT PAGE NEVER TO HANDLED. *TR
Structure, Sep 25, 2009
I HAVE A 2002 FORD F-150. IT STARTED TO LEAK WHEN IT RAINS. THE PROBLEM IS THE BEZEL COVERING THE PLACES WHERE THE GLASS IS ATTACHED TO THE TRUCK - THE BRACKETS WHERE THE SCREWS GO HAVE CRACKED AND THE GROMMETS AROUND THE BOLTS HAVE FAILED. I WANT TO FIX THE ITEM, BUT I HAVE LEARNED THAT THE NECESSARY PART (THE PLASTIC BEZEL FOR THE BACK WINDOW) IS ON NATIONAL BACKORDER, BECAUSE SO MANY OF THEM HAVE FAILED THERE ARE NO MORE AVAILABLE. IT SEEMS TO ME THAT IF SOMETHING IS BREAKING SO MUCH THAT NO ONE HAS THE REPAIR PARTS, THEN THIS SHOULD BE AN ITEM FOR RECALL. *TR
Seat belts, Sep 24, 2009
DRIVER'S SEATBELT SIMPLY DISCONNECTS ITSELF OFTEN WITHOUT EVEN BEING TOUCHED AT ALL, WHILE DRIVING! *TR
Engine and engine cooling, Sep 12, 2009
THE SPARK PLUGS ARE BEING BLOWN OUT OF CYLINDER HEADS ON ALL SIZE TRITON ENGINES. THIS OCCURRED ON MY 2002 FORD F150, AND ON MY FATHER IN-LAWS EXPEDITION. THIS WAS ON A TRITON V-8 AND V-10S. WHEN I TOOK IT TO THE DEALERSHIP IN FT WAYNE INDIANA THEY INFORMED ME THAT THIS IS COMMON ON THESE ENGINES I ALSO SPOKE WITH FORD CUSTOMER CARE AND THEY CLAIM THAT THIS IS COMMON. THEY WONT RECALL IT BECAUSE THEY CLAIM THAT THIS IS NOT A SAFETY ISSUE. I FEEL THAT THIS IS A SAFETY ISSUE BECAUSE IT DOES NOT SHUT OFF THE FUEL SUPPLY TO THAT CYLINDER. NOT TO MENTION IT JUST HAPPENS WITH OUT ANY SORT OF WARNING LUCKILY I WAS ABLE TO LIMP MY TRUCK TO THE CLOSEST FORD DEALERSHIP IN MY AREA. WITH MY FATHER IN -LAWS EXPEDITION HE WAS JUST OUTSIDE OF TOWN ON HIS WAY TO ARKANSAS WHEN HIS BLEW OUT. THE ONLY REMEDY IS A HEALY COIL OR REPLACE THE HEAD, THANKFULLY THE COIL IS REASONABLE IN COST BUT WONT LAST FOREVER. *TR
Engine and engine cooling, Sep 9, 2009, fire
TL*THE CONTACT OWNS A 2002 FORD F-150. THE CONTACT STATED THAT HE WAS ALERTED BY THE FIRE DEPARTMENT THAT HIS VEHICLE WAS ON FIRE. AS A RESULT THE VEHICLE WAS COMPLETELY DESTROYED. THE VEHICLE HAS NOT BEEN INSPECTED BY A TECHNICIAN. THE CURRENT AND FAILURE MILEAGES WERE 140000.
Fuel system, Gasoline, Sep 8, 2009
TRUCK STOPPED AND IDLING AT STOP SIGN FOLLOWED BY LOUD BANG AND THUMPING NOISE. SHUT OFF TRUCK, AND LOOKED UNDER HOOD TO FIND SPARK PLUG HAD BLOWN OUT OF CYLINDER HEAD ALONG WITH COIL. THE SMELL OF FUEL WAS EVIDENT FROM THE OPEN HOLE IN THE CYLINDER HEAD. LUCKY THERE WAS NO FIRE WHEN THE PLUG WAS DISCHARGED. FORD WILL NOT DO ANYTHING TO REMEDY THE PROBLEM EVEN THOUGH THIS IS VERY COMMON IN THESE VEHICLES EVEN WITH THE ORIGINAL SPARK PLUGS. I WAS TOLD THAT THIS WAS MY MISTAKE FOR OVERTIGHTENING THE PLUGS. I HAVE NEVER CHANGED THE PLUGS NOR DOES FORD RECOMMEND THIS UNTIL 100,000 MILES. I BELIEVE THAT THE ISSUE IS WIDESPREAD ENOUGH TO WARRANT A RECALL, BUT THIS HAS NOT HAPPENED YET. AVERAGE PEOPLE CANNOT AFFORD THE $1,000 - $3,500 REPAIR THAT IS NECESSARY TO FIX THIS PROBLEM NOR SHOULD THEY BE REQUIRED TO WHEN IT IS A PROBLEM THAT FORD HAS KNOWN ABOUT AND REFUSED TO FIX. FORD IS PROVIDING AN INFERIOR PRODUCT AND WILL NOT TAKE RESPONSIBILITY FOR IT. *TR
Engine and engine cooling, Aug 31, 2009
MY 2002 FORD F-150 HAS IN THE PAST TWO MONTHS EXPERIENCED THREE BLOWN/EJECTED SPARK PLUGS CAUSING THE DAMAGE AND NECESSARY REPLACEMENT OF "COILS". THIS POSED A POSSIBLE SAFETY HAZARD, AND I AM VERY UNHAPPY AT THE TIME AND COST I HAVE INCURRED SINCE THE INITIAL ONSET OF THIS PROBLEM, THAT APPARENTLY FORD HAS BEEN AWARE OF ALL OF THIS TIME. *TR
Engine and engine cooling, Aug 31, 2009
EVENT.. I WAS DRIVING WEST BOUND ON THE 215 FREEWAY IN LAS VEGAS, NV. EXITING DURANGO ROAD. I SAT AT THE INTERSECTION WAITING FOR THE SIGNAL LIGHT TO TURN GREEN. WHEN THE LIGHT TURNED GREEN, MOVING FORWARD, I WAS MAKING A LEFT HAND TURN GOING (10MPH) SOUTH BOUND ON DURANGO ROAD, JUST AT THAT TIME I HERD A LOUD POP NOISE. AS I WAS PULLING OVER, MY TRUCK (F150) WAS RUNNING ROUGH, I STOPPED, PUT IT IN PARK , SHUT THE ENGINE OFF, OPENED THE HOOD AND THERE SAT A COIL PACK INCLUDING THE SPARK PLUG ON TOP OF THE MOTOR. AFTER EVALUATING THE INCIDENT MORE, I NOTICE THAT THE COIL PACK AND SPARK PLUG CAME FROM THE PASSENGER SIDE ENGINE HEAD #THREE (3) CYLINDER. MY TRUCK HAS THE ORIGINAL MOTORCRAFT SPARK PLUGS IN IT SINCE 2002. NOT SURE WHY THE SPARK PLUG WOULD JUST POP-OUT. NICE JOB FORD!! FORD MANUFACTURES THE MOTOR (TRITON 5.4L) AND THE MOTORCRAFT SPARK PLUGS? SEEMS VERY SIMPLE WHOSE RESPONSIBILITY THIS IS. REPAIR COST''THE REPAIR SHOP IS ESTIMATING $2,500.00 HEAD REPAIR OR NEW ENGINE AT APPROXIMATELY $6,500.00 INC. LABOR. QUESTIIONS.. HOW IS THE CONSUMER GOING TO KNOW PRIOR TO THE SPARK PLUG POPPING OUT, TO SECURE IT? WHY ARE THE SPARK PLUGS POPPING OUT? NOT ENOUGH THREADS? HOW DO THE EXECUTIVES AT FORD SLEEP AT NIGHT KNOWING THAT THIS PROBLEM COULD TAKE SOMEONE'S LIFE AT ANY TIME? PERSONAL COMMENT.. WHEN THE SPARK PLUG OR THE COIL PACK WAS EJECTED FROM THE ENGINE HEAD, THIS COULD HAVE HIT THE FUEL RAIL AND STARTED A TREMENDOUS FIRE, LIKE A LOT OF PEOPLE IN THE US WE DON'T ALWAYS CARRY A FIRE EXTINGUISHER BECAUSE AN '!@#$% SPARK PLUG IS GOING TO POP OUT OF THE ENGINE HEAD AND START THE TRUCK ON FIRE. THIS IS RIDICULOUS!!!! FORD MOTOR COMPANY NEEDS TO OWN UP TO THERE MISTAKES BEFORE SOMEBODY LOOSES THERE LIFE. I AM NOT THE SUING TYPE OF PERSON, BUT IF ONE OF MY KIDS LOOSES THERE LIFE DRIVING MY TRUCK BECAUSE OF A SPARK PLUG PROBLEM AND FORD MOTOR COMPANY DID NOT TELL ME ABOUT IT, I AM AFRAID TO TELL YOU WHAT I WOULD DO. THIS IS NOT A THREAT JUST REALITY. *TR
Engine and engine cooling, Aug 18, 2009
THERE WAS NO EVENTS LEADING UP TO OUR PROBLEM WITH OUR PICK UP TRUCK. I STARTED THE TRUCK AND HEARD A LOUD BANG AND THEN THE TRUCK SOUNDED LIKE IT WAS MISSING. WE FOUND OUT THAT THE 3RD SPARK PLUG ON THE PASSENGER SIDE OF THE MOTOR BLEW OUT. IT HASN'T BEEN FIXED YET IT HAPPENED YESTERDAY 8/17/09. *TR
Vehicle speed control, Aug 10, 2009, fire
TL*THE CONTACT OWNS A 2002 FORD F-150. WHILE THE VEHICLE WAS PARKED, THE CONTACT NOTICED SMOKE UNDERNEATH THE HOOD. SHE OPENED THE HOOD AND NOTICED FLAMES. SHE EXTINGUISHED THE FLAMES AND STATED THAT THE FIRE ORIGINATED NEAR THE CRUISE CONTROL WIRES. THE MANUFACTURER STATED THAT IT WOULD TAKE FIFTEEN DAYS FOR THEM TO REACH A DECISION REGARDING HOW TO HANDLE THE ISSUE. THE FAILURE AND CURRENT MILEAGES WERE 95,000.
Engine and engine cooling, Jul 22, 2009
BLEW TWO SPARK PLUGS OUT OF THE HEAD ON TWO SEPARATE INCIDENTS ABOUT 3 MONTHS APART. HAD PLUG HOLE RETHREADED AND IT BLEW OUT AGAIN ABOUT THREE MONTHS LATER. HAD SLEEVE PUT INTO THE HEAD TODAY. HOPE THAT HOLDS IT BUT DOUBTFUL. *TR
Engine and engine cooling, Fuel system, Gasoline, Jul 15, 2009
I OWN A 2002 FORD F150 WITH THE TRITON 5.4L V-8. I HAVE HAD SPARK PLUGS EJECT FROM 3 DIFFERENT CYLINDERS NOW AND FORD CLAIMS IT IS NOT A RECALL ISSUE. THIS PROBLEM HAS BEEN NOTED ON MANY OF THE FORD VEHICLES WITH THE TRITON 5.4 V-8. WHEN THE SPARK PLUG IS EJECTED FUEL VAPOR CAN LEAK INTO THE ENGINE COMPARTMENT AND POSSIBLY CAUSE A FIRE. I HAVE NOT HAD THAT PROBLEM BUT I AM FRUSTRATED WITH FORD'S UNWILLINGNESS TO COVER A KNOWN PROBLEM WITH THEIR DESIGN. *TR
Engine and engine cooling, Jul 4, 2009
MY 2002 FORD F150 TRUCK, WITH THE 5.4 LITER ENGINE, HAS HAD 2 FAILURES ON 2 DIFFERENT OCCASIONS IN THE SPACE OF 8 MONTHS. EACH TIME I WAS JUST DRIVING DOWN THE HIGHWAY AND A SPARK PLUG WAS BLOWN OUT OF THE HEAD, ALONG WITH THE COIL. (PLUG #3 THE FIRST TIME AND #7 THE LAST TIME.) THIS FAILURE CAUSED AN IMMEDIATE LOSS OF POWER. LUCKILY THE TRAFFIC WAS LIGHT EACH TIME, BEING LATE AT NIGHT, SO I WAS ABLE TO PULL SAFELY TO THE SIDE OF THE ROAD TO DETERMINE THE PROBLEM, WHEREAS IF THE TRAFFIC HAD BEEN HEAVY, IT COULD HAVE CAUSED A MAJOR ACCIDENT BECAUSE OF THE IMMEDIATE POWER LOSS TO THE ENGINE, AND/OR A FIRE DUE TO IT PROXIMITY TO THE INJECTORS. THE DEFECTS WERE REPAIRED AT THE LOCAL FORD DEALERSHIP WHERE THE TRUCK WAS PURCHASED USING A THREADED INSERT INTO THE OLD HEAD AND A NEW COIL. TOTAL COST FOR BOTH REPAIRS WAS APPROXIMATELY $600, AT MY EXPENSE. I HAVE EMAILED FORD MOTOR COMPANY AND THEY RESPONDED SAYING THAT BECAUSE THE VEHICLE WAS OUT OF WARRANTY AND THERE WERE NO RECALLS OR CUSTOMER SATISFACTION PROGRAMS IT WOULD NOT BE FIXED BY FORD. I PURCHASED THIS VEHICLE NEW AND IT HAS BEEN METICULOUSLY MAINTAINED. I HAVE SEARCHED THE INTERNET AND HAVE FOUND THAT THERE ARE THOUSANDS OF THESE ENGINES WITH THIS PROBLEM. IT IS OBVIOUS FORD KNOWS OF THIS DEFECT IN THE HEADS AND REFUSES TO DEAL WITH IT. IF NOT BY RECALL, IT IS OBVIOUSLY A FACTORY DEFECT AND SHOULD BE DEALT WITH BY FORD AS THE INCIDENTS OCCUR. THIS IS A DANGEROUS SITUATION THAT SHOULD BE LOOKED INTO BECAUSE OF THE IMMEDIATE LOSS OF ENGINE POWER AND POSSIBILITY OF FIRE. *TR
Visibility, May 30, 2009
DRIVER SIDE WINDOW LEAKS/ HAS LEAKED WATER DURING LIGHT RAIN STORMS FAILURE IS SQUEALS AS DRIVING AT 50 MPH PRONE TO LEAK AND FUSE BOX IS RIGHT BELOW WINDOW NEW WINDOW SEAL WILL NEED TO BE INSTALLED AND YES OLD PART WILL BE AVAILABLE. *TR
Engine and engine cooling, May 25, 2009
DRIVING ALONG A RIVER ROAD AT 35 MILES PER HOUR, AFTER A SHORT HIGHWAY DRIVE OF ABOUT 70MPH, A SPARK PLUG BLEW OUT OF THE #3 CYLINDER. WE WERE GOING CAMPING WITH OUR 2 YOUNG BOYS, SO DECIDED TO DRIVE THE TRUCK HOME. DURING THE DRIVE THE SMELL OF GASOLINE VAPOR WAS OVERPOWERING. WE HAD ONLY A 45 MILE DRIVE TO HOME. ON GETTING THE TRUCK HOME I POPPED THE HOOD AND TO MY HORROR THE EJECTED PLUG WAS STILL FIRING ON TOP OF THE VALVE COVER. THIS IS AN EXTREME FIRE HAZARD! *TR
Service brakes, Hydraulic, Vehicle speed control, May 22, 2009
ABS AND BRAKE LIGHTS HAS CONTINUED TO BE ON AND CRUISE CONTROL HAS STOPPED WORKING. *TR