2002 Ford F-150
Problems, recalls and owner-reported issues
Engine and engine cooling is the leading concern among 955 owner complaints filed for this model year. This is the 5th highest complaint count among 26 F-150 model years with reports.
Of the 2002 reports, 58 involved a crash and 100 involved a fire. 67 people were injured.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lighting, headlightsAug 1, 2006
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 28, 2006. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.
Campaign 06E067000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Campaign 06E065000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Vehicle speed controlSep 7, 2005
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
A FIRE AT THE SWITCH COULD OCCUR.
BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)
Campaign 05V388000 on NHTSA.gov
Representative owner complaints
955 reports, newest first.
Electrical system, Apr 1, 2018, crash, fire
WOKE UP AT 1AM ONE 4-1-2018 TO MY FORD F 150 ON FIRE DRIVERS SIDE FRONT UNDER THE HOOD. UNKNOW TO US OUR LOCAL SHERIFF HAD SPOTTED THE FIRE AND ALREADY CALLED THE FIRE DEPARTMENT. TOTAL LOSS. BOUGHT THE TRUCK A FEW MONTHS BACK WITHOUT ANY KNOWLEDGE OF A RECALL ON THE SPEED CONTROL SWITCH. THE VEHICLE WAS SITTING IN OUR DRIVE NEXT TO OUR OTHER CARS FOR 3 HOUR WITH KEYS OUT OF THE IGNITION.
Electrical system, Vehicle speed control, Service brakes, Mar 8, 2018, fire
THE RECALL IE AN INLINE FUSE ON SPEED CONTROL DEACTIVATION SWITCH DID NOT WORK IT JUST CAUGHT ON FIRE AND RUINED MY MASTER CYLINDER AND BRAKE SYSTEM.IT WONT HOLD BRAKE FLUID NOW BECAUSE THE SWITCH MELTED INTO IT.FORD SAYS OH WELL RECALLS BEEN DONE
Seat belts, Feb 14, 2018
TL* THE CONTACT OWNS A 2002 FORD F-150. WHILE DRIVING 50 MPH, THE CONTACT NOTICED THAT THE DRIVER'S SEAT BELT UNBUCKLED RANDOMLY. THE FAILURE ALSO OCCURRED ON THE FRONT PASSENGER SIDE. THE DEALER (SIMI VALLEY FORD, 2440 1ST ST, SIMI VALLEY, CA 93065) STATED THAT THERE WERE NO RECALLS ATTACHED TO THE VIN AND, WITH THE VEHICLE BEING A DIFFERENT YEAR THAN WHAT WAS IN THE RECALL, THE FAILURE WOULD HAVE TO BE PAID OUT OF POCKET AT A COST OF $700. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE THROUGH EMAIL. THE CONTACT WAS AWAITING A RESPONSE FROM THE MANUFACTURER. THE FAILURE MILEAGE WAS 180,000.
Seat belts, Feb 13, 2018
FRONT DRIVER AND PASSENGER SEAT BELT BUCKLES RANDOMLY UNBUCKLE THEMSELVES. WHEN FASTENED, THE BUCKLES SEEMS SECURE. PULL SEVERE TIMES ON THEM AND THEY DO NOT UNBUCKLE. BUT, WHILE DRIVING, THEY UNBUCKLE THEMSELVES PERIODICALLY. THIS HAS BEEN OCCURRING FOR A LONG PERIOD OF TIME.
Other or unspecified, Feb 12, 2018
FUEL TANK STRAPS RUSTED AWAY, AND FUEL TANK STARTING LEAKING AND TANK IS FALLING OUT THIS WEEK., TRUCK HAD BEEN SERVICED AT FORD AND CHECKED FOR RECALLS. CORROSION SEEMS PERVASIVE IN AREA OF FUEL TANK, 4.6L V8 COYOTE SERIES, 2 WD, SHORT BED EXTRA CAB XLT TRIM MILEAGE 197K. TRUCK OTHERWISE IN GOOD CONDITION, WE LIVE IN AGRICULTURAL SOUTH JERSEY.
Seat belts, Feb 5, 2018
ON 2002 FORD F-150 SUPERCREW FRONT PASSENGER SEAT BELT RANDOMLY COMES UNBUCKLED.
Structure, Jan 30, 2018
FRAME HAS RUSTED TO THE EXTENT THAT THE BED HAS DROPPED AND IS ABOUT TO FALL OFF. WHEN I WAS REPLACING THE FUEL TANK, WHICH HAD RUSTED THROUGH, I DISCOVERED THAT THE ENTIRE FRAME HAS HOLES AND CRACKS FROM RUST.I HAVE NOW BEEN HEARING THAT THIS PROBLEM HAS BEEN REPORTED BY MANY, BUT NO ANSWER OR RECALLS FROM FORD. WHY DO THESE TRUCKS RUST SO BADLY. IS THERE NO RECOURSE FOR THOSE OF US WHO HAVE A TRUCK THAT FALLS APART?
Structure, Vehicle speed control, Nov 21, 2017
TWO ISSUES: 1] BOTH REAR DOORS IN THE EXTENDED CAB (SWING COUNTERCLOCKWISE) DOOR LATCHES JAMMED PREVENTING EXITING OR ENTRY. IF EGRESS WAS NEEDED QUICKLY, IT WAS NOT THERE. THE COST TO REPAIR EACH WAS ABOUT $450. (LOCKED UP WHILE DRIVING) 2]SPEED CONTROL DOES NOT WORK - FORD SAYS IT IS A MALFUNCTIONING CONTROL THAT COST ABOUT $500 TO REPLACE. (WHEN VEHICLE IS IN OPERATION)
Vehicle speed control, Nov 14, 2017, fire
GOT HOME FROM WORK PARKED MY VEHICLE IN MY CARPORT AVAILABLE SPACE IN MY APARTMENT. TURN OFF THE TRUCK COMPLETELY, NOTHING LEFT ON OR ANYTHING SUSPICIOUS TO CAUSE A INCIDENT. WHEN TO MY APARTMENT UNIT TOOK A SHOWER AND NOT MORE THAN 20-30MINS WAS ALARMED THAT MY VEHICLE WAS CAUGHT ON FIRE. I IMMEDIATELY RAN OUTSIDE TO THE CARPORT SAW THE ENGINE ON FIRE, TRIED TO STOP IT WITH ANYTHING THAT I COULD FIND (WATER HOLES) OR EXTINGUISHER. MY NEIGHBORS CALLED 911 AS I SAW THE FLAMES GETTING HIGHER AND STRONGER THE FIRE MOVED INTO MY DAUGHTERS VEHICLE WHICH WAS PARKED NEXT TO OUR OTHER CARPORT SPACE AND CAUGHT ON FIRE AS WELL. OVERALL, THERE ARE TWO VEHICLES COMPLETELY DESTROYED. THERE WAS ALSO TWO OTHER VEHICLES INVOLVED THAT HAVE SOME BURNING DAMAGES. AS WELL AS PROPERTY DAMAGES INTO OUR AVAILABLE PARKING SPACES. SOME WINDOWS FROM THE LOWER APARTMENTS WERE CRACKED. MY VEHICLE WAS PARKED INTO MY PARKING PORT, NOT IN MOTION BUT TURNED OFF COMPLETELY.
Seat belts, Nov 11, 2017
ON 2002 FORD F-150 DRIVER AND PASSENGER SEAT BELTS RANDOMLY COME UNBUCKLED AND ANY GIVEN TIME.
Structure, Oct 3, 2017
MY TRUCK FRAME HAS RUSTED THROUGH JUST BEHIND THE RIGHT REAR WHEEL! THIS IS A 2002 FORD F150 SUPERCAB THAT HAS ONLY 75500 MILES ON IT. THE FRAME BROKE JUST AFTER I LEFT THE INTERSTATE AND DROVE TO MY SON'S HOUSE. I INSPECTED THE TRUCK AND SAW THE BREAK IN THE FRAME AS I DESCRIBED. A PICTURE IS ATTACHED. I WAS LUCKY NOT TO HAVE WRECKED ON THE INTERSTATE! WHAT IS GOING ON WITH FORD THAT THE CHASSIS RUSTS THROUGH LIKE THIS!!! WHAT IS GOING ON WITH FORD?
Structure, Other or unspecified, Fuel/propulsion system, Oct 2, 2017
MY FIANCE AND I HAD TO PLACE ARE FULL SIZE SPARE ON THAT CAME WITH TRUCK IT WAS BRAND NEW WE HAD NO CHOICE BC THIS WAS FRIDAY EVENING AND OUT LOCAL TIRE SHOP WAS CLOSED TELL TODAY (MONDAY) YESTERDAY WE DROVE 7 MILE TO COLLINSVILE TO CHANGE BRAKES AFTER WE FINISH WE LOAD OUR 3 KIDS AND BEFAN TO HIDE HOME ANOTHER 3 MILES FROM HOME WE NOTICE THE TRUCK SHAKING THEN WE HEARD LOAD POP AND TAIL OF THE TRUCK LOST CONTROL FOR ABOUT 2 SECOND ONCE WE GOT CONTROL BACK WE PULLED TO SAFETY TO ONLY SEE THE DRIVER SIDE OF THE BED CRACKED TORE AND SHATTERED. EVEN THE HOSE WHERE U FUEL U TRUCK UP AT HAD BEEN DAMAGETTING WHEN WE CONTINUED TO EXAMINE THE TIRE IT WASN'T BLOWN AND IT'S STILL HOLDING AIR. BUT PLZ EXPLAIN TO ME HOW THE ENTIRE CENTER SECTION OF TREAD RIPPED OFF FOR NO REASON AND NOT ONLY PUT MY CHILDREN IN DANGER BUT DAMAGED MY TRUCK TO A SEVERE EXTENT ? IT'S A FULL SIE HERCULES TERRAIN TRAC SIZE 16 HAD NOTHING WRONG WITH IT TELL NOW.
Structure, Sep 7, 2017
TL* THE CONTACT OWNS A 2002 FORD F-150. WHILE DRIVING APPROXIMATELY 5 MPH, THE CABLE THAT HELD THE SPARE TIRE UNDERNEATH THE VEHICLE RUSTED AND DETACHED, CAUSING THE SPARE TIRE TO DROP FROM THE VEHICLE. THE CONTACT STOPPED THE VEHICLE AND PICKED UP THE TIRE. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000. ......UPDATED 11/21/17 *BF
Engine, Aug 23, 2017
SPARK BLOW BLOW FROM THE HEAD NO. 6 I THE MECHANIC FIX IT AND THAT HAPPENED YESTERDAY I CANNOT REMEMBER THE HOPPING IN VEGAS I CAN REMEMBER ' THE
Tires, Aug 21, 2017
TL* THE CONTACT OWNS A 2002 FORD F-150 EQUIPPED WITH CAPITOL PRECISION TRAC II TIRES, SIZE: 265/70/R16 (NA). WHILE DRIVING 65 MPH, THE REAR PASSENGER TIRE EXPERIENCED A BLOWOUT. THE CONTACT STATED THAT THE BLOWOUT CAUSED DAMAGE TO THE FENDER WELL. THE TIRE WAS NOT REPLACED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE TIRE FAILURE MILEAGE WAS 18,000, AND THE VEHICLE FAILURE MILEAGE WAS 165,000. THE VIN WAS NOT AVAILABLE.
Seat belts, Aug 11, 2017
WHILE DRIVING OR SITTING AT A LIGHT, ETC, THE DRIVER SIDE SEAT BELT WILL DISENGAGE WITHOUT WARNING.
Engine, Jul 17, 2017
TL* THE CONTACT OWNS A 2002 FORD F-150. THE CONTACT STATED THAT THE SPARK PLUG EJECTED OUT OF THE ENGINE COMPARTMENT WHILE DRIVING APPROXIMATELY 65 MPH. THE VEHICLE WAS TOWED FROM THE CONTACT'S RESIDENCE. MCMAGHN FORD DIAGNOSED THAT THE ENGINE WOULD NEED TO HAVE A NEW CYLINDER HEAD. THE MANUFACTURER WAS NOTIFIED, BUT DID NOT OFFER FURTHER ASSISTANCE. THE FAILURE MILEAGE WAS 120,000.
Seat belts, Jun 16, 2017
BOTH FRONT SEATBELTS (DRIVER AND PASSENGER) RANDOMLY DISENGAGE EITHER WHILE DRIVING OR SITTING MOTIONLESS. VERY UNSAFE!
Fuel/propulsion system, May 27, 2017
MY 2002 F150 TRUCK DROPPED THE FUEL TANK ON 5/26/2017. MIRACULOUSLY, MY WIFE AND DAUGHTER WEREN'T KILLED. MY WIFE AND DAUGHTER WERE USING THE TRUCK, HELPING A FRIEND MOVE. LUCKILY, THEY JUST LEFT MCDONALDS RESTAURANT WHEN IT BROKE. THEY WERE ON A SIDE STREET AND WERE FORCED TO STAY WHERE THEY WERE. THE EASTPOINT FIRE-DEPARTMENT WERE CALLED ON SCENE DUE TO GASOLINE LEAKING OUT OF THE TANK INTO THE STREET. THEY STAYED WITH THE VEHICLE UNTIL AAA WAS CALLED. THEY TOWED THE TRUCK ON A FLATBED TRUCK AND DELIVERED IT TO MY GUYS AUTO REPAIR, GRATIOT, ROSEVILLE, MI. MY TRUCK HAD A RECALL ON IT FOR SAFETY STRAPS, WHICH WERE THE CAUSE BY BREAKING. I TRIED TO GET IT FIXED AT DORIAN FORD, CLINTON TWP.,MI. 2 YEARS PRIOR, BUT WAS GIVEN A 'RUNAROUND' BY DORIAN FORD, TELLING ME TO BRING IT IN FOR REPAIR IN 2 MONTHS TIME. I FORGOT WHEN THE 2 MONTHS WERE UP AND DORIAN FORD DIDN'T TRY TO CONTACT ME. I AM FORCED NOW TO PAY OVER 1500 DOLLARS TO REPAIR MY TRUCK, WHICH I AM THE ORIGINAL OWNER. I AM GRATEFUL BEYOND BELIEF THAT MY FAMILY OR I WEREN'T KILLED. PLEASE ADVISE ME ON WHAT I CAN DO IN LIGHT OF EVERYTHING IE...COMPENSATION FOR SAID REPAIR, ETC. THANK-YOU.
Seat belts, May 14, 2017
PASSENGER SEATBELT RELEASES WITHOUT WARNING. THIS HAPPENS WHILE THE VEHICLE IS MOVING AT DIFFERENT SPEEDS ON CITY STREETS OR HIGHWAYS EVERY PASSENGER THAT RIDES IN MY VEHICLE HAS THE SAME PROBLEM
Engine, Mar 23, 2017
TAKATA RECALL MY SPARK PLUG BLOW OUT ON # 6 HEADER TODAY ON 3/23/2017 ON MY WAY TO WORK AT 4:00 AM ON ROUT 390 IN PA
Engine, Mar 22, 2017
BLEW SPARK PLUG OUT OF HEAD.
Fuel/propulsion system, Mar 15, 2017
FUEL TANK STRAPS BROKE WHILE DRIVING STRAIGHT ON CITY STREETS PUTTING A HOLE IN THE TANK AND SPILLING OUT FUEL WHILE DRIVING. FORD HAD A RECALL ON THE SAME YEAR & MODEL OF VEHICLE, HOWEVER OURS WAS NOT RECALLED.
Steering, Vehicle speed control, Feb 19, 2017
SEED CONTRAL.
Exterior lighting, Jan 31, 2017
TRUCK WAS PURCHASED AS USED IN OCT, 2016, SO WE HAVE NO KNOWLEDGE OF PREVIOUS DRIVER'S HABITS OR PROBLEMS. EVERYTHING SEEMED TO WORK FINE. PRIMARY DRIVER IS 5 FEET TALL AND MOVED THE STEERING WHEEL DOWN TO MAKE A MORE COMFORTABLE DRIVING POSITION. LATE DEC, 2016, EARLY JAN, 2017 WHILE PARKED, WE DISCOVERED THE BRAKE LIGHTS AND ONE TURN SIGNAL LIGHT NO LONGER WORKED..THE HIGH MOUNT BRAKE LIGHT WAS A BAD BULB, BUT WHEN A CHECK OF FUSES AND BULBS FOR THE OTHER LIGHTS WERE FOUND TO BE OK, WE DECIDED THE BRAKE LIGHT SWITCH WAS BAD. WRONG ! MORE RESEARCH POINTED THE PROBLEM TO THE MULTI FUNCTION/COMBINATION SWITCH OR ITS CONNECTIONS, ACTUAL PROBLEM WAS THE CONNECTIONS ON THE MFS. NUMEROUS REFERRALS TO THIS PROBLEM FOR MANY FORD YEAR MODELS ARE POSTED ON THE INTERNET AS WELL AS SEVERAL VIDEOS ON YOUTUBE.COM. INSPECTION REVEALED THAT SEVERAL WIRES GOING TO THE MFS HAD PULLED OUT OF THE CONNECTOR WHEN THE STEERING WHEEL WAS LOWERED. CONNECTOR WAS DAMAGED BY THIS ACTION. WIRE CABLE GOING TO THE MFS IS FIXED SOLID TO THE STEERING COLUMN, AND THERE IS NOT ENOUGH SLACK IN THE WIRES TO ALLOW THE STEERING WHEEL TO BE LOWERED ALL THE WAY WITHOUT CAUSING THE PULLED WIRES AND DAMAGED CONNECTOR. PROBLEM WAS REPAIRED BY AN INDEPENDENT REPAIR SHOP AT OWNERS EXPENSE SINCE THE TRUCK WAS HAZARDOUS, UNSAFE, AND ILLEGAL TO DRIVE WITH NO BRAKE LIGHTS AND PARTIAL TURN SIGNALS. DRIVING WITHOUT THESE LIGHTS, ESPECIALLY IN NE OHIO IN THE WINTER SNOW STORMS - I DON'T THINK SO !! COST OF REPAIRS:SEE FORWARDED INVOICE. IT APPEARS THE PROBLEM WAS BUILT INTO THE TRUCK FROM THE BEGINNING AND FORD SHOULD BE RESPONSIBLE FOR THE REPAIRS AS WELL AS RECALLING ALL VEHICLES WITH THIS PROBLEM. IT SHOULD BE NOTED THAT THE REPLACEMENT FORD CABLE PART XL1Z-14A320-AA COMES WITH LONGER LEADS TO AVOID THE PROBLEM, SO FORD IS CERTAINLY AWARE OF THIS FAILURE BUT HAS DONE NOTHING ABOUT IT !!