2002 Ford F-150
Problems, recalls and owner-reported issues
Engine and engine cooling is the leading concern among 955 owner complaints filed for this model year. This is the 5th highest complaint count among 26 F-150 model years with reports.
Of the 2002 reports, 58 involved a crash and 100 involved a fire. 67 people were injured.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lighting, headlightsAug 1, 2006
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 28, 2006. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.
Campaign 06E067000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Campaign 06E065000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Vehicle speed controlSep 7, 2005
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
A FIRE AT THE SWITCH COULD OCCUR.
BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)
Campaign 05V388000 on NHTSA.gov
Representative owner complaints
955 reports, newest first.
Electrical system, Jan 17, 2017, fire
TL* THE CONTACT OWNS A 2002 FORD F-150. THE CONTACT STATED THAT THE VEHICLE CAUGHT ON FIRE WHILE PARKED. THE CONTACT EXTINGUISHED THE FIRE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V017000 (VEHICLE SPEED CONTROL). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE THE APPROXIMATE FAILURE MILEAGE WAS 200,000. UPDATED 03/03/17*LJ *CN
Fuel/propulsion system, Dec 27, 2016
IN THE LESS THAN 2 YEARS WE HAVE OWNED THIS TRUCK, IT HAS BLOWN SPARK PLUGS 3 TIMES.
Electrical system, Dec 24, 2016
I HAVE BEEN EXPERIENCING ELECTRICAL PROBLEMS PERIODICALLY OVER THE PAST TWO WITH MY VEHICLE(ORIGINALLY THOUGHT TO BE THE BATTERY), RANGING FROM HIGHLIGHT AND FLASHERS INTERMITTENTLY COMING ON WHEN THE VEHICLE IS LOCKED AND TURNED OFF. THE RADIO AND BLOWER MOTOR HAVING ISSUES AND THE INTERIOR DOME LIGHT COMING ON ANS STAYING ON. I HAVE ALSO NOTICED MORE AND MORE THAT THE WINDSHIELD IS LEAKING ON THE DRIVERS SIDE OF THE VEHICLE. I HAVE ALSO EXPERIENCED THE WIPERS AND HEAD LIGHTS LIGHTS SHUT OFF ONCE WHILST DRIVING ON THE HIGHWAY AT HIGHWAY SPEEDS DURING HEAVY RAIN.. THE MOST RECENT OCCURRENCE WAS ON THE 12/23/2016 AT MY PLACE OF WORK (NTB), ONE OF MY CO WORKERS NOTICED MY HEADLIGHTS FADING IN AND OUT THE RADIO COMING ON AND GOING OFF. WENT OVER TO THE TRUCK TO MAKE SURE IT WAS TURNED OFF AND NOT LEFT ON BY MISTAKE BUT THE ENGINE WAS OFF. SO I BROUGHT THE TRUCK INTO THE WORK SHOP TO HAVE A LOOK OVER THE VEHICLE AND DID SOME DIAGNOSTICS ON IT AND DISCOVERED MULTIPLE DEFECT CODES THAT ALL CONNECT THROUGH THE GEM(GENERAL ELECTRICAL MODULE) ON THE INTERIOR FUSE PANEL. UPON FURTHER INSPECTION I ALSO NOTICED BOTH THE GEM AND FUSE PANEL BOX HAVE GOT WATER INGESTION AND GREEN/BROWN STAINS COMING OUT THE BOTTOM. I HAVE DONE RESEARCH ONLINE ABOUT THESE'S ISSUES AND ITS A COMMON PROBLEM OVER MODELS FROM FORD FROM 98-03. THE FIX IS TO REPLACE THE GEM AND FUSE BOX AND TO RESEAL/REPLACE THE WINDSHIELD. NOW I BELIEVE THAT IS SAFETY ISSUE AND SHOULD BE ADDRESSED BY FORD THEM SELF'S REGARDLESS OF THE AGE OF THE VEHICLES AFFECTED BY THIS. HTTP://WWW.F150FORUM.COM/F12/LEAKY-WINDSHIELD-GEM-MODULE-PROBLEM-TWIST-98192/ HTTP://WWW.F150FORUM.COM/F6/GEM-ANSWER-ALL-MY-ISSUES-43475/
Air bags, Dec 1, 2016, crash, fire
TL* THE CONTACT OWNED A 2002 FORD F-150. WHILE DRIVING APPROXIMATELY 55 MPH, THE DRIVER CRASHED INTO THE REAR OF A TRAILER THAT WAS STALLED IN THE MIDDLE OF AN INTERSECTION. THE INTERIOR OF THE VEHICLE STARTED TO BURN. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT DID NOT KNOW WHETHER A FIRE REPORT WAS FILED. THE DRIVER SUSTAINED INJURIES THAT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS DESTROYED AND TOWED TO A TOW YARD. THE FAILURE MILEAGE WAS NOT PROVIDED.
Engine, Nov 22, 2016
VEHICLE IN MOTION, CITY STREET, SPEED AT 35MPH. SUDDEN LOUD BANG, ENGINE STARTED BANGING. SPARK PLUG #4 BLEW OUT OF ENGINE HEAD.
Power train, Nov 22, 2016
VEHICLE IN MOTION ON CITY STREET. LOUD NOISE IN DRIVE POSITION, TRANSMISSION WENT OUT OF GEAR, VEHICLE WOULD NOT GO BACK INTO GEAR.
Seat belts, Nov 18, 2016
PURCHASED USED IN 2004. HAVING SIMILAR ISSUE WITH DRIVER SIDE SEAT BELT IN THAT WHILE TRUCK IS IN MOTION MY SEAT BELT WILL COME UNBUCKLED RANDOMLY. THIS LAST HAPPENED NOV 17TH 2016 AND ALWAYS HAPPENS WHEN DRIVING FOR MORE THAN 25 MINUTES OR SO AND DOES HAPPEN ON A CITY STREET OR HIGHWAY.
Seat belts, Nov 3, 2016
FRONT PASSENGER SEAT BELT RANDOMLY DISENGAGES WHILE IN MOTION. REAR PASSENGER SEAT BELT BUCKLE BROKEN - BLACK "SLEEVE" SLIDES DOWN EXPOSING SPRING MECHANISM INSIDE WHICH IS MISSING SOME PLASTIC PIECES. FRONT PASSENGER HAS BEEN A PROBLEM FOR A COUPE OF YEARS. BACKSEAT IS FAIRLY NEW.
Fuel system, Gasoline, Oct 7, 2016
TL* THE CONTACT OWNS A 2002 FORD F-150. THE CONTACT STATED THAT WHILE PARKED THE VEHICLE LEAKED FUEL CONTINUOUSLY. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 11V3850000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOTIFIED ABOUT THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 149,000. UPDATED 01/10/17*LJ *TR
Fuel/propulsion system, Sep 30, 2016
MY VEHICLE HAD ITS FUEL TANK STRAPS REPLACED UNDER A RECALL. THE CORROSION FROM THE ORIGINAL STRAPS SPREAD TO THE FUEL TANK. NOW, THE CORROSION ON THE FUEL TANK HAS CAUSED THE FUEL TANK TO BEGIN LEAKING UNDER THE REPLACED STRAPS. PERHAPS SOME OF THE ISSUE IS DUE TO THE PROCESS / PROCEDURE USED IN REPLACING THE ORIGINAL FUEL TANK STRAPS. VEHICLE NOW HAS APPROX 207,000 MILES. FUEL LEAK WAS NOTICED WHILE PERFORMING OTHER REGULAR MAINTENANCE.
Engine, Sep 13, 2016
STARTED VEHICLE AND HEARD A REAL LOUD BANG FOLLOWED BY A LOAD CONTINUOUS POPPING SOUND. A SPARK PLUG GOT BLOWN OUT OF THE ENGINE AND IT TOOK THE COP WITH IT SO A FIRE COULD NOT START. WE WERE STRANDED IN BAD WEATHER.
Seat belts, Sep 1, 2016
DRIVERS SIDE SEAT BELT BUCKLE RELEASES RANDOMLY WITHOUT WARNING. AFTER BUCKLING / LATCHING SEATBELT DRIVER CAN PULL HARD ON BELT AND WON'T RELEASE, THEN AFTER DRIVING FOR A RANDOM AMOUNT OF TIME (30 SECONDS TO 3 HOURS) THE SEAT BELT WILL RELEASE WITHOUT WARNING. REPLACED LATCH WITH ALTERNATIVE (2001 YEAR AND DIFFERENT COLOR) 1L7Z 7861203 BAB. I BELIEVE THAT THIS PROBLEM REPRESENTS A SERIOUS SAFETY ISSUE WITH THE CONFIDENCE OF A SEATBELT'S ABILITY TO PERFORM IN AN ACCIDENT DEFECTIVE PART IS AVAILABLE FOR INSPECTION.
Engine, Aug 30, 2016
#3SPARK PLUG BLEW OUT OF RIGHT CYLINDER HEAD . SINCE THE INJECTOR WAS STILL PUMPING FUEL INTO THE OPEN CHAMBER THIS COULD HAVE CAUSED AN ENGINE FIRE INOW HAVE FOUND THIS TO BE SOMEWHAT OF A PROBLEM WITH THE 4.6 LITRE ENGINE DUE TO THE ALUMINUM HEADS.
Seat belts, Aug 14, 2016
DRIVER SEAT BELT LOCKED. UNABLE TO BUCKLE AT ALL. WHEN I PULL THE BELT WILL NOT RELEASE.
Engine, Jun 18, 2016
THE SPARK PLUG ON THE PASSENGER SIDE OF MY VEHICLE EXPLODED OUT OF THE HEAD AS SOON AS I STARTED THE VEHICLE BREAKING THE COIL PACK IN THE PROCESS. I PURCHASED THE VEHICLE USED A YEAR AGO AND SINCE THE PLUG BLEW OUT ON ME I DISCOVERED THAT THIS IS NOT THE FIRST TIME THIS HAS HAPPENED TO MY TRUCK SO IT IS AN ONGOING PROBLEM.
Engine, May 27, 2016
WHILE PULLING UP TO A STOP LIGHT MY TRUCK STARTED POPPING AND SHAKING. I PULLED OVER AND OPENED THE HOOD TO FIND OUT A SPARK PLUG HAD BLOWN OUT OF THE MOTOR. IT EXPLODED WITH SUCH FORCE IT BROKE THE COIL OVER HOUSING ON THE HEAD. I HAVE CALLED FORD AND THEY SAY THEY DON'T KNOW OF ANY ISSUES OF THIS. IT IS ALL OVER THE INTERNET ABOUT IT. THEY ARE IN COURT RIGHT NOW OVER THE 2005 AND UP VEHICLES HAVING THE SAME ISSUE. I AM THE ORIGINAL OWNER AND HAVE NEVER HAD TO REPLACE THE PLUGS SO THEY ARE STRAIGHT FROM THE FACTORY, AND THE TRUCK HAS ONLY 123,000 MILES ON IT. IT IS NOW GOING TO COST ME OVER $400.00 TO FIX THIS ONE PLUG WITH NO GUARANTEE IT WON'T HAPPEN TO ANY OTHER PLUGS. I'M RETIRED ON SOCIAL SECURITY AND CANNOT AFFORD A NEW TRUCK PAYMENT, OR CONTINUE TO FIX THEIR DEFECTS.
Air bags, May 27, 2016, crash
TL* THE CONTACT OWNS A 2002 FORD F-150. THE CONTACT STATED THAT AFTER BEING INVOLVED IN A CRASH, THE DRIVER SIDE AIR BAG DEPLOYED AND STARTED EMITTING SPARKS. THE CONTACT DID NOT SUSTAIN ANY INJURIES AND A POLICE REPORT WAS FILED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 160,000.
Electrical system, Structure, Fuel/propulsion system, May 3, 2016
VEHICLE CAB ROCKER PANELS RUSTING OFF REAR WINDOW LEAKING CRUISE CONTROL NOT WORKING VEHICLE RUSTING AND BEEN IN AREA WITH NO SALT ON ROADS
Fuel system, Gasoline, Apr 14, 2016
TL* THE CONTACT OWNS A 2002 FORD F-150. WHILE WALKING PAST THE VEHICLE, THE CONTACT NOTICED A STRONG ODOR OF FUEL. THE CONTACT DISCOVERED THAT THE FUEL TANK STRAPS WERE CORRODED AND CREATED A HOLE IN THE FUEL TANK, WHICH CAUSED FUEL TO LEAK FROM THE TANK. THE CONTACT WAS INFORMED BY THE DEALER THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE) BUT THE REMEDY COULD NOT BE PERFORMED AT THE TIME DUE TO THE CORROSION OF THE FUEL TANK. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 202,000. THE VIN WAS NOT AVAILABLE. UPDATED 05/31/2016*LJ
Electrical system, Engine, Apr 13, 2016, fire
VEHICLE CAUGHT FIRE AFTER BEING PARKED FOR 5 HOURS. ALMOST BURNT MY BUILDING DOWN.
Wheels, Other or unspecified, Apr 7, 2016
TAKATA RECALL. WHILE I WAS DRIVING I NOTICED A LOUD POP AND MY TRUCK STARTED VIBRATING AND SPUN ME SIDEWAYS GOING DOWN THE HIGHWAY. I HAD FOUGHT IT UNTIL I WAS ABLE TO GET IT UNDER CONTROL AND COME TO A STOP. (I WAS LUCKY ENOUGH THAT NOBODY ELSE WAS HEADING IN MY DIRECTION BECAUSE THE TRUCK TOOK UP BOTH SIDES OF THE ROAD). I GOT OUT AND LOOKED TO SEE WHAT HAD HAPPENED AND SEEN MY ALUMINUM FORD FACTORY RIM HAD BUSTED INTO PIECES. TAKATA RECALL. A PROBLEM THAT I AM HAVING AS OF RIGHT NOW IS SPARK PLUGS KEEP FLYING OUT AND DESTROYING MY COIL PACKS. THIS IS THE THIRD TIME IT HAS DONE THIS.
Electrical system, Apr 1, 2016
LOUD NOISE SPARK PLUG BLOW OUT AND CAUSED SPARKS WHEN OPENED THE HOOD. AFRAID IT WAS GOING TO CATCH FIRE SO HAD IT TOWED. ACCORDING TO MECHANIC IS A FORD ISSUE ONGOING BUT NO RECALL NOR WILL FORD PAY FOR IT. 91120 MILES ON TRUCK WELL MAINTAINED.
Engine, Feb 20, 2016
ABOUT 6MONTHS AGO, CRUISING ABOUT 60MPH; HEARD A "POP", LOST ENGINE POWER, ENGINE LIGHT ON,...PULLED OVER AND DISCOVERED #3 CYLINDER MISSING THE SPARK PLUG AND THE COP BROKEN. HAD IT TOWED HOME (APPROX 25MILES); WENT ONLINE AND DISCOVERED IT'S A SYSTEMIC PROBLEM WITH MANY OTHER FORD V8-V10 1997-2003 MOTORS.
Engine, Feb 12, 2016
SPARK PLUG EJECTED OUT OF MOTOR WHEN I WAS PULLING OUT OF A DRIVEWAY ONTO A CITY STREET.
Vehicle speed control, Jan 10, 2016
IN 12-14 AND 1-10-2016 THE BUTTERFLY IN THE THROTTLE BODY STUCK AND VEHICLE WOULDN'T SLOW DOWN. 1ST INCIDENT -10F, CAME FROM WARM GARAGE, INTERSTATE, CRUISE CONTROL IN USE, IN ABOUT 15 MINUTES OF DRIVING EVENTUALLY SPEED GOT TO 85MPH ON ITS OWN, CRUISE SHUT OFF AND VEHICLE MAINTAINED 85 MPH, ONCE STOPPED THROTTLE AND CRUISE CABLE WERE CHECKED AND FREE, BUTTERFLY WAS STUCK PARTIALLY OPEN WHEN MANUALLY MOVED AND BROKE FREE, PROBLEM WENT AWAY; 2ND DATE -5F CAME FROM WARM GARAGE, INTERSTATE, CRUISE ON, 20 MINUTES INTO TRIP, SIMILAR RESULTS, WEATHER CLEAR LOW HUMIDITY, VEHICLE WOULD NOT SLOW DOWN, CRUISE SHUT OFF, NO-LOAD ENGINE SPEED OVER 5000 RPM, VEHICLE SPEED 65MPH ON LEVEL WITH NO THROTTLE INPUT, CABLES WHEN CHECKED WERE FREE, BRAKES WOULD BARELY SLOW VEHICLE, ENGINE OPERATED NORMALLY ONCE BUTTERFLY WAS BROKE FREE BUT PROBLEM REOCCURRED ABOUT 30 MINUTES LATER. FORD F150 XLT 4.6L AUTOMATIC SUPERCREW, NO PROBLEM NOTED WHEN WEATHER IS WARMER