2002 Ford F-150
Problems, recalls and owner-reported issues
Engine and engine cooling is the leading concern among 955 owner complaints filed for this model year. This is the 5th highest complaint count among 26 F-150 model years with reports.
Of the 2002 reports, 58 involved a crash and 100 involved a fire. 67 people were injured.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lighting, headlightsAug 1, 2006
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 28, 2006. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.
Campaign 06E067000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Campaign 06E065000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Vehicle speed controlSep 7, 2005
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
A FIRE AT THE SWITCH COULD OCCUR.
BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)
Campaign 05V388000 on NHTSA.gov
Representative owner complaints
955 reports, newest first.
Service brakes, Hydraulic, Aug 25, 2004
CONSUMER COMPLAINED THAT THE BRAKE LIGHT FLASHED WHILE DRIVING. TWO DEALERS WERE NOTIFIED. FIRST DEALER INFORMED CONSUMER THAT THE TERMINAL CONNECTOR TO THE MASTER BRAKE CYLINDER NEEDED TO BE REPLACED. THE SECOND DEALER CLAIMED THAT THE PROBLEM PERTAINED TO A LOOSE TERMINAL CONNECTION TO THE MASTER BRAKE CYLINDER SENSOR. *AK
Service brakes, Hydraulic, Visibility, Aug 20, 2004
CONCERNS WITH BLIND SPOTS ON RIGHT SIDE WHERE THE MIRROR AND HANDGRIP ARE IN A LINE AS WELL AS LOCATION OF THE BRAKE AND GAS PEDALS. *MR THIS SEEMED TO BE A FACTOR IN SEVERAL TRAFFIC INCIDENTS, THE CONSUMER HAD SEVERAL EMERGENCY STOPS SEVERAL TIMES IN WHICH THE CONSUMERS FOOT HAD COME DOWN ON THE BRAKE AND GAS PEDALS AND SEEMED TO ONLY HAPPEN IN EMERGENCY SITUATIONS WHEN THE CONSUMERS FOOT WOULD SHOOT DOWN. *SC *JB
Service brakes, Hydraulic, Parking brake, Seat belts, Structure, Equipment, Aug 20, 2004
VEHICLE HAS A GAP ON DRIVER'S SIDE DOOR OVER THE TOP. THE GAP CAUSES NOISE INSIDE THE CABIN OF THE VEHICLE WHILE DRIVING. IT MAKES IT HARD TO KEEP THE VEHICLE ON THE ROAD. MANUFACTURER WAS CONTACTED WITH NO RESULTS.*AK THE DEALER INSTALLED A RUBBER SEALER AROUND THE GAP BUT THIS SEEMED TO CAUSE MORE NOISE. THE RADIO, CD PLAYER AND TV IN THE REAR OF THE VAN STOPPED WORKING. THE ROTORS WARPED AND CAUSED VIBRATIONS WHEN BRAKING. WATER HAD GOTTEN INTO THE LEFT SIDE PARK LAMP. THE SEAT BELT WARNING CHIME AND LIGHT FAILED INTERMITTENTLY, THE DEALER REPLACED THE MODULE. *NM
Suspension, Service brakes, Hydraulic, Structure, Latches/locks/linkages, Aug 12, 2004
PASSENGER DOOR WOULD OPEN WHILE VEHICLE WAS MOVING. *PH THE CONSUMER ALSO STATED THAT THE VEHICLE VIBRATED WHILE DRIVING. THE CONSUMER MOTHER-IN-LAW FELL WHILE TRYING TO GET INTO THE FRONT PASSENGERS SIDE DOOR OF THE TRUCK. THE BRAKES WOULD LOCK UP INTERMITTENTLY. *NM
Wheels, Aug 10, 2004
WHILE DRIVING AT 60 MPH VIBRATION CAME FROM THE FRONT. CONSUMER STOPPED THE VEHICLE, AND FOUND TWO SPOKES OF RIGHT WHEEL BROKE . DEALERSHIP AND MANUFACTURER INDICATED TO THE CONSUMER THAT WARRANTY EXPIRED. *AK
Service brakes, Hydraulic, Aug 3, 2004
WHILE DRIVING AT 35 MPH THERE WAS A LOUD POP FROM THE COMPARTMENT. CONSUMER PROCEEDED TO PULL OF THE HIGHWAY WHEN THE POP NOISE STARTED GETTING WORSE. VEHICLE WAS THEN TOWED TO A DEALERSHIP, WHO INDICATED THAT THE MASTER CYLINDER HEAD NEEDED TO BE REPLACED BECAUSE THE SPARK PLUG SPLIT OFF THE HEAD. *AK
Exterior lighting, Jul 24, 2004
THE 2002 FORD F-150 HEADLIGHT SWITCH BREAKS UPON TURNING ON HEADLIGHTS. IT HAS NOT CAUSED ME TO WRECK, HOWEVER IT IS A PROBLEM WITH TURNING LIGHTS ON AT NIGHT, FOG, OR RAIN. THIS IS THE THIRD TIME THIS HAS HAPPENED. I ORDERED IT FROM PERRY FORD OF POWAY CALIFORNIA, BUT THE HEADLIGHT SWITCH IS ON BACK ORDER. THAT IS TELLING ME THAT ALOT OF PEOPLE NOT JUST MY SELF, ARE HAVING THE SAME PROBLEM. THIS SHOULD BE A SAFETY RECALL.*AK
Air bags, Jul 14, 2004, crash
CONSUMER STATED THAT HER SON WAS DRIVING ON THE HIGHWAY, LOST CONTROL OF VEHICLE, AND HAD TO RUN OFF INTO A DITCH. THE AIR BAG EXPLODED, AND THREW SON OUT INTO THE FIELD. THE PASSENGER'S SEAT BELT WAS WRAPPED AROUND HIS NECK. ALSO, WHEN THE AIR BAG EXPLODED AND THREW SON OUT OF THE VEHICLE THE AIR BAG MODULE WENT WITH HIM AND LANDED WITH HIM. CONSUMER'S SON SUSTAINED CHEMICAL BURNS. CONSUMER STATED THAT SHE NEVER READ ANYWHERE THAT THE AIR BAG MODULE EJECTED FROM THE STEERING WHEN IT DEPLOYED. *AK
Tires, Jul 6, 2004
THE CABLE THAT HOLDS THE SPARE TIRE SHEARED OFF. AS A RESULT THE TIRE SEPARATED FROM THE VEHICLE WHILE DRIVING ON A DIRT ROAD. *AK *NM
Service brakes, Hydraulic, Jun 23, 2004
CONCERNS REGARDING THE FORD F150 2002 GAS AND BRAKE PEDAL. *MR THE CONSUMER WAS ABLE TO CORRECT THE FOOT PLACEMENT AND AVOIDED SERIOUS CONSEQUENCES. IN EMERGENCY SITUATIONS, THE CONSUMERS FOOT SHOT DOWN, PER REFLEX, BUT THE PEDALS DID NOT MATCH THE PLACEMENT OF THE CONSUMERS FOOT WHICH HAD COME DOWN ON BOTH THE GAS AND BRAKE PEDALS. *SC *JB
Tires, Jun 21, 2004
WHILE DRIVING THERE WAS SEVERE VIBRATION IN THE FRONT END OF THE VEHICLE. DEALERSHIP REPLACED ALL FOUR TIRES, BUT NEEDED TO REPLACE THE FRONT DRIVER AND PASSENGER SIDE TIRES AGAIN AT CONSUMER'S EXPENSE. *AK
Steering, Wheels, Jun 14, 2004, crash
THERE WAS NO COTTER PIN INSTALLED ON THE FRONT DRIVER SIDE SPINDLE. AS A RESULT, THE ENTIRE DRIVER SIDE FRONT WHEEL FELL OFF AND THE VEHICLE CRASHED INTO A PARKED CAR. *AK *NM
Latches/locks/linkages, Jun 9, 2004
WHEN USING THE AUTOMATIC DOOR LOCKING MECHANISM THE PART PINCHED THE SKIN OF THE DRIVER'S ARM. *AK
Structure, Jun 4, 2004
CONCERNS OF PLACEMENT OF ACCELERATOR AND BRAKE PEDALS ON 2002 FORD F-150. *MR IT WAS REPORTED THAT DRIVERS WOULD HIT THE ACCELERATOR PEDAL INSTEAD OF THE BRAKE PEDAL. *SC
Electrical system, Visibility, May 13, 2004
WINDSHIELD SEAL LEAKED (RAIN) ALONG ROOFLINE CAUSING MULTIPLE ELECTRICAL PROBLEMS. VEHICLE HAS MULTIPLE SYSTEM WARNING LIGHTS VISIBLE ON DASH. SHORT CIRCUIT SOUNDS COMING FROM BEHIND DASHBOARD. WARNING LIGHTS, BLOWER MOTOR AND HEAD LIGHTS OPERATE WITHOUT KEY IN THE IGNITION CAUSING BATTERY TO BE DRAINED. WIPERS CUT OFF WITHOUT WARNING. DOOR WINDOWS STOP WORKING WITHOUT WARNING. VEHICLE SHIFTS INTO FOUR-WHEEL DRIVE WITHOUT WARNING. ENGINE RACES WHILE PARKED (REVS TO 4000 RPM AND RETURNS TO NORMAL). SALES MAN INFORMED THAT FORD WILL NOT COVER THE PROBLEM BECAUSE THE TRUCK IS OUT OF WARRANTY AND TO BRING TRUCK TO DEALER (5/3/04). TRUCK WOULD NOT START UNTIL 5/8/04. SEAL TO WINDSHIELD SEPARATED FROM VEHICLE ON LEFT SIDE WHILE DRIVING TO DEALERSHIP (5/10/04). THE TRUCK NOW HAS EXCESSIVE WIND NOISE. TRUCK WILL NO LONGER START (5/11/04). I CALLED FORDS CUSTOMER AND REQUESTED THAT A REPRESENTATIVE FROM FORD INSPECT THE TRUCK. CUSTOMER SERVICE ASKED THAT THE TRUCK BE TOWED TO A FORD DEALER. TRUCK WAS TOWED TO LOCAL DEALER. DEALER DID NOT WANT TO HELP ME CONTACT FORD AFTER I INFORMED THEM THAT THE TRUCK HAS A DEFECTIVE WINDSHIELD SEAL. DEALERSHIP INFORMS ME ON 5/13/04 THAT THE ZONE SUPERVISOR FROM FORD SAID THAT THERE WAS NOTHING THAT COULD BE DONE ABOUT THE PROBLEM. IN ADDITION, DEALER REFUSES TO PUT STATEMENT IN WRITING. THE DEALER ALSO INFORMED ME THAT FOR A FEE, THEY COULD SEAL THE WINDSHIELD AND DIAGNOSIS THE PROBLEM BUT THE DEALERSHIP WHERE THE TRUCK WAS PURCHASED FROM SHOULD DO THE REPAIRS. *AK
Electrical system, May 10, 2004
IGNITION COIL MISFIRING, VEHICLE EXHIBITED OCCASIONAL MISS FIRE. UPON COLD START AFTER SITTING FOR SEVERAL DAYS PLUME OF BLUE SMOKE FROM TAIL PIPE WAS NOTICED. DEALER COULD NOT DUPLICATE EVENT BUT DETERMINED #1 IGNITION COIL WAS FIRING AT REDUCED CAPACITY. UNIT WAS REPLACED AND INCIDENT OF BLUE SMOKE AT COLD START HAS BEEN REDUCED. *LA
Power train, May 10, 2004
I WAS DRIVING DOWN SR 33 IN POLK CITY WHEN IT SEEMED AS IF MY CAR WAS SLOWING DOWN. I HAD THE PEDAL DEPRESSED BUT THE TRUCK CONTINUED TO SLOW DOWN. I HAD TO PULL OFF TO THE SIDE OF THE ROAD. WHEN THE SPEEDOMETER FELL BACK DOWN TO ZERO I ATTEMPTED TO TAKE OFF AGAIN. ONCE AGAIN, THE TRUCK WOULD GET TO 50 AND THEN NOT SHIFT TO THE NEXT GEAR. THIS WAS THE FIRST AND ONLY SIGNS SOMETHING WAS WRONG. I ASSUMED IT WAS A PROBLEM WITH THE TRANSMISSION. I DROVE TO WORK (15 MILES) IN SECOND GEAR, CALLED A TOW TRUCK AND HAD IT TOWED TO LAKELAND FORD. I WAS TOLD THE OVERDRIVE CLUTCH BURNED UP AND THE DIRECT DRIVE PAK BURNED UP. THE FORD DEALERSHIP WANTED $2,326.09 TO FIX A 2002 VEHICLE THAT IS NOT EVEN TWO YEARS OLD AND HAS 44,176 MILES ON IT. MOST OF THE MILES ON THIS VEHICLE WERE HIGHWAY MILES ALWAYS DRIVEN WITH OVERDRIVE ON AND ONLY WAS SOMETHING TOWED. THIS VEHICLE HAS THE TOWING PACKAGE IN IT SO THIS PROBLEM SHOULD NOT HAVE HAPPENED. MY WARRANTY WAS 3 YEARS/36,000 MILES. TRUCK IS NOW AT AAMCO WITH TRANSMISSION BEING REBUILT. *LA
Power train, May 7, 2004
TRUCK IS A F-150 WITH A 3.55 LIMITED SLIP AXLE. THERE IS A VERY NOTICEABLE WHINE COMING FROM THE REAR DIFFERENTAIL. NOISE STARTS AT 40 MPH BUT IS MOST NOTICEABLE AT 60 MPH. NOISE IS WITH SLIGHT ACCELERATION, IF I TAKE MY FOOT OFF THE GAS IT STOPS. I HAVE HAD THE TRUCK TO THE DEALER THREE DIFFERENT TIMES. THEY HAVE REPLACED THE BEARINGS, DRIVE SHAFT AND GEARS BUT IT HASN'T HELPED. THIS IS A WIDESPREAD KNOWN PROBLEM BUT THEY DON'T SEEM TO HAVE A FIX FOR THE PROBLEM. I WOULD NEVER BE ABLE TO SELL THIS TRUCK WITH THIS PROBLEM.*AK
Service brakes, Hydraulic, Apr 7, 2004
WHILE DRIVING 55 MPH CONSUMER APPLIED THE BRAKES, FOR A BUMP ON THE HIGHWAY. A CLICKING NOISE WAS HEARD COMING FROM UNDERNEATH THE DASHBOARD. ABS BRAKING SYSTEM DISENGAGED. CAUSING LOSS OF BRAKING POWER. CONSUMER RELEASED THE BRAKE PEDAL. THEN REAPPLIED THE BRAKES IN ORDER TO STOP. CONSUMER HAD THE VEHICLE TOWED TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT THE ABS MODULAR NEEDED TO BE REPLACED. *AK
Steering, Apr 6, 2004
2002 F-150 SUPER CAB, MAKES A POP RIGHT WHEN STEERING WHEEL IS TURNED IN EITHER DIRECTION, STANDING STILL (VEHICLE RUNNING OR NOT) AND MOVING, ALSO GETTING A VIBRATION AT HIGHWAY SPEEDS. PERSONAL INVESTIGATION WAS TO CHECK THE LUGNUTS FOR TIGHTNESS, ALL OK, THEN REMOVED BEARING COVER OFF FRONT WHEELS, FOUND NO LOCKING MECHANISM ON RIGHT FRONT WHEEL BEARING NUT. GOING TO DEALER TOMORROW (4/7/2004) VEHICLE HAS 26,500 MILES. OWNED SINCE NEW, FRONT WHEELS HAVE NEVER BEEN REMOVED. NOTICED SEVERAL "POPPING" COMPLAINTS ON THIS VEHICLE - WONDER IF THEY HAVE LOCKING MECHANISMS ON THEIR BEARING NUTS? *LA
Electrical system, Apr 1, 2004
SPARKPLUGS BLEW OUT OF THE HEAD AT 65 MPH ON SVT LIGHTNING. SERVICE MANAGER INDICATED FORD IS AWARE OF THIS HAPPENING BUT THEY ARE NOT ISSUING A RECALL. HE STATED THEY PUT OUT A "WHAT TO DO" IF A VEHICLE COMES IN WITH THIS PROBLEM. UNFORTUNATELY, THAT DOES NOT HELP US CONSUMERS WHO HAVE TO FORK THE BILL.*AK
Suspension, Mar 29, 2004
BROKEN FRONT COIL SPRING. *AK
Power train, Mar 9, 2004
TRANSMISSION PROBLEMS: CLUTCH DOES NOT DISENGAGE PROPERLY. DEALER REPLACED CLUTCH ASSEMBLY AT CONSUMER'S EXPENSE. *AK
Power train, Mar 9, 2004
TRANSMISSION PROBLEMS: CLUTCH DID NOT DISENGAGE PROPERLY. DRIVER HAD TO CHANGE GEARS REPEATEDLY IN ORDER TO SHIFT. THIS PRODUCED DANGEROUS DRIVING PROBLEMS. DEALER REPLACED THE MASTER CYLINDER RELAY AT CONSUMER'S EXPENSE. *AK
Power train, Feb 26, 2004
VIBRATION IN DRIVETRAIN AT HIGHWAY SPEED (BETWEEN 65 -75 MPH). ONLY HAPPENS WHEN TRUCK IS UNDER POWER. AS SOON AS YOU REMOVE YOUR FOOT FROM THE PEDAL, THE VIBRATION GOES AWAY. DRIVE SHAFT WAS REPLACED OVER 6 MONTHS AGO, BUT THAT DID NOT FIX THE ISSUE.*AK