2002 Ford F-150
Problems, recalls and owner-reported issues
Engine and engine cooling is the leading concern among 955 owner complaints filed for this model year. This is the 5th highest complaint count among 26 F-150 model years with reports.
Of the 2002 reports, 58 involved a crash and 100 involved a fire. 67 people were injured.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lighting, headlightsAug 1, 2006
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 28, 2006. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.
Campaign 06E067000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Campaign 06E065000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Vehicle speed controlSep 7, 2005
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
A FIRE AT THE SWITCH COULD OCCUR.
BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)
Campaign 05V388000 on NHTSA.gov
Representative owner complaints
955 reports, newest first.
Seat belts, Mar 12, 2003, crash
CONSUMER WAS REAR ENDED, AND THE FRONT SEAT BELTS FAILED TO RESTRAIN THE DRIVER AND PASSENGER. THE DRIVER HIT HER HEAD ON THE STEERING WHEEL, AND THE PASSENGER HIT HIS HEAD ON THE DASH. AMOUNT OF DAMAGE UNKNOWN. *JB
Air bags, Mar 11, 2003, crash
THE VEHICLE WAS INVOLVED IN A FRONTAL COLLISION AND THE AIR BAGS FAILED TO DEPLOY, CONSUMER WAS INJURED.*JB
Engine and engine cooling, Feb 28, 2003
ENGINE MISFIRES IN COLD WEATHER WHILE DRIVING CAUSING SERIOUS LOSS OF POWER FIRST STARTED AT 341 MILES AND CONTINUES TO DATE.*JB
Tires, Feb 27, 2003
THE SPARE TIRE DISCONNECTED FROM THE VEHICLE. *JB
Other or unspecified, Feb 27, 2003
I AM TRYING TO FIND OUT IF THERE ARE ANY RECALLS OR TECHNICAL SERVICE BULLETINS ON THE FOLLOWING VEHICLE. 2002 FORD F150 SUPERCREW 4 - WHEEL DRIVE. THIS VEHICLE SEEMS NOT TO BE LISTED IN YOUR DATA BASE. *JB
Air bags, Feb 21, 2003, crash
THE VEHICLE WAS INVOLVED IN A FRONTAL COLLISION, AND THE AIR BAGS FAILED TO DEPLOY. *JB *TS
Latches/locks/linkages, Feb 20, 2003
AUTOMATIC DOOR LOCKS PINCH LEAVES ABRASIONS BRUISING ON ARMS
Seat belts, Seats, Feb 17, 2003
BOTH LOCKING PAWLS ON MANUAL SEAT ADJUSTMENT MECHANISM DO NOT LOCK INTO PLACE WHEN SEAT ADJUSTMENT LEVER IS RELEASED. ONE OR THE OTHER PAWL LOCKS INTO PLACE AND A LARGE AMOUNT OF SHIFTING FORCE IS THEN REQUIRED TO MOVE THE SECOND PAWL INTO A POSITION WHERE IT WILL ENGAGE. THIS WOULD ONLY BE A MINOR INCONVENIENCE IF IT WERE NOT FOR THE SEAT BELT CONFIGURATION OF THIS VEHICLE. THIS SEAT BELT ATTACHES NOT TO THE SUB FLOOR OR PILLAR BUT TO THE SEAT ITSELF. IF (AS HAS HAPPENED MANY TIMES TO ME) YOU ARE UNDER WAY AND REPOSITION THE SEAT, YOU MAY NOT REALIZE THE SEAT IS NOT SAFELY LOCKED INTO POSITION. IF YOU WERE THEN INVOLVED IN AN ACCIDENT THE STRAIN ON THE ENGAGED PAWL MIGHT BE BEYOND DESIGN PARAMETERS. WHEN THE UNENGAGED PAWL, TRAVELING TO ITS NEXT LOCKED POSITION UNDER THE FORCES OF THE ACCIDENT, MEET THE MASS OF THE OCCUPANT AND SEAT, THE SHEAR FORCES MAY CAUSE FAILURE OF THE PAWL ALLOWING THE OCCUPANT AND HIS /HER SEAT TO BE UNCONTROLLED DURING AN ACCIDENT. THIS COULD RESULT IN UNNECESSARY INJURY TO THE OCCUPANT. AN AIR BAG SRS COULD EXACERBATE THIS CIRCUMSTANCE CAUSING ESCALATING INJURY(S).
Engine and engine cooling, Electrical system, Feb 11, 2003
SPARK PLUG SELF LAUNCHING FROM FORD F150 5.4 L ENGINE
Suspension, Feb 5, 2003
REAR WHEELS HAVE ENOUGH PLAY IN THEM THAT THERE IS A NOTICEABLE CLUNK WHEN TURNING. TOOK THE TRUCK TO THE DEALER AND THE END PLAY OF THE AXLES ARE .020. FORD MANUFACTURER SAID UP TO .030 IS TOLERABLE AND I WILL HAVE TO LIVE WITH THE CLUNKING SOUND. I DID NOT PAY $30,000 FOR A TRUCK TO LISTEN TO A CLUNKING SOUND!
Steering, Dec 31, 2002, crash
CONSUMER COMPLAINED ABOUT THE PITMAN ARM ON THE VEHICLE. ALSO STATED THAT WHILE DRIVING THE VEHICLE THE PITMAN ARM FELL OFF WHICH IT CAUSED COMPLETELY LOST OF STEERING AND THE CONSUMER HIT ANOTHER VEHICLE ON THE HIGHWAY WAS CONTACTED AND HAS AGREED THAT THERE WAS NO BOLT PUT INTO THE PART THAT FELL OFF BUT THERE STILL NOT DOING NOTHING ABOUT IT. TS PHOTOS ATTACHED. *TT
Equipment, Dec 27, 2002
CONSUMER CALLED COMPLAINING ABOUT HAVING PROBLEMS WITH THE CHAISE ON THE VEHICLE. ALSO STATED THAT DEALER WAS CONTACTED AND HAS AGREE THAT THERE IS A PROBLEM WITH THE VEHICLE BUT WONT TAKE IT IN UNTIL AFTER JANUARY THE 2ND. TS
Power train, Dec 24, 2002
WHILE AT HIGH SPEED VEHICLE VIBRATES AND PULLS TO THE RIGHT. CONSUMER TOOK TO THE DEALER AND THEY REPLACED THE DRIVESHAFT. PROBLEM WAS STILL PRESENT. TS THE WHEELS AND TIRES WERE ALSO CHANGED BUT TO NO AVAIL. *JG
Steering, Dec 2, 2002
VERY SERIOUS FAILURE!!! WHILE BACKING UP A STEEP HILL IN 4WD. THE TRUCK'S PITMAN ARM CAME COMPLETELY OFF OF THE SPLINED SHAFT THAT COMES OUT OF THE STEERING BOX. SO, THERE WAS NO LONGER ANY CONNECTION BETWEEN THE STEERING WHEEL AND THE FRONT WHEELS. THE RETAINING NUT AND LOCK WASHER CAME OFF, TOO, AND WERE RECOVERED. THE LOCK WASHER IS OF THE HELICAL SPRING TYPE, AND HAS A BLACK OXIDE FINISH. BECAUSE OF THIS FINISH, IT IS EASY TO DEDUCE FROM THE WEAR MARKS ON THE WASHER. THAT THE RETAINING NUT WAS NOT TORQUED AT THE FACTORY. LUCKILY THIS FAILURE OCCURRED AT ALMOST ZERO SPEED IN A DRIVEWAY. CLEARLY, HAD IT OCCURRED AT FREEWAY SPEED (WHICH IS WHERE THE TRUCK WOULD HAVE BEEN 2 MILES LATER), THE RESULTS COULD HAVE BEEN CATASTROPHIC. THE OWNER OF THIS CAR, WOODY PORTER, IS MY FATHER-IN-LAW. I WAS DRIVING IT AT THE TIME OF THE FAILURE, AND FILLED OUT THIS FORM FOR HIM WITH HIS PERMISSION. IF YOU HAVE ANY QUESTIONS, YOU MY CONTACT ME, JOHN GUNTHER, AT 650-802-8384. THANKS. DT
Power train, Nov 29, 2002, crash
WAS DRIVING DOWN THE ROAD THE STEERING WHEEL JERKED TO THE RIGHT COULD NOT GAIN CONTROL BACK. THERE IS ONE SKID MARK 35 FEET LONG HIT AN ELECTRIC POLE WHEN CAME TO REST THE BACK PASSENGER TIRE HAD BROKE OFF AT THE AXEL. DT
Engine and engine cooling, Nov 19, 2002, crash
WHILE DRIVING THE VEHICLE IN REVERSE, TO PARK THE VEHICLE SUFFERED SUDDEN ACCELERATION WHEN SHIFTED FROM DRIVER INTO REVERSE VEHICLE COLLIDED WITH ANOTHER CAR CAUSING DAMAGE TO HIS VEHICLE AND OTHER CAR. DEALER HAS BEEN NOTIFIED. PLEASE PROVIDE FURRTHER INFORMATION. TS
Steering, Nov 18, 2002
CONSUMER STATES THAT WHILE DRIVING AT 65MPH AND WITHOUT WARNING THE STEERING WHEEL WILL PULL TO THE RIGHT AND IT WILL BE HARD FOR THE CONSUMER TO CONTROL THE VEHICLE. DEALER NOTIFIED TS
Power train, Nov 13, 2002
WHILE DRIVING THE VEHICLE, THE TRANSMISSION BOLT CAME LOOSE AND THE FLUID WENT OUT, CAUSING PULL OUT ROAD. DEALER HAS BEEN NOTIFIED. PLEASE PROVIDE FURTHER INFORMATION:: MR
Electrical system, Nov 5, 2002
THE REAR DOOR LOCKS WILL NOT OPEN UNLESS THE LOCK IS MANUALLY UNLOCKED. THE FRONT DOORS WILL UNLOCK AND OPEN BY USING THE INSIDE DOOR HANDLE. THE REAR DOORS WILL NOT DO THIS. YOU MUST FIRST UNLOCK THE REAR DOOR MANUALLY (FOR WITH THE POWER LOCKS), THEN OPEN THE DOOR WITH THE INSIDE DOOR HANDLE. I FEEL THAT THIS CONDITION IS A SAFETY ISSUE BECAUSE IF THERE IS AN INSTANCE WHERE SOMEONE IS RIDING IN THE REAR SEAT AND THE PERSON MUST EXIT THE VEHICLE IN A HURRY, THEY MAY BECOME DISORIENTED AND FORGET TO FIRST UNLOCK THE REAR DOOR MANUALLY. THEY WILL GET PANICKY THEN UNTIL THEY REALIZE, IF THEY DO, WHAT IS HAPPENING. THIS IS ESPECIALLY TRUE IN THE CASE OF OLDER CHILDREN WHO ARE OLD ENOUGH TO OPERATE A CAR DOOR BY THEMSELVES.**** DIMS 11 IVOQ ENTRY POSTED AFTER 12/12/02 CUT-OVER TO ARTEMIS****769311. *AK *JB
Vehicle speed control, Oct 29, 2002
CONSUMER STATES SINCE 05/02, WHEN ACCELERATING GAS PEDAL STICKS INTERMITTENLY. CONSUMER HAS TO SHIFT INTO NEUTRAL AND PUMP PEDAL FOR IT TO RELEASE. TS
Tires, Oct 28, 2002
WHILE DRIVING THE REAR PASSENGER TIRE EXPERIENCED TREAD SEPARATION. FRONT GENERLAL TIRE HAD A SMALL SLIT VERTICALLY IN THE TREAD. PASSENGER BACK TIRE HAD A TWO INCH CHUNK MISSING AND A SLIT LIKE A V ON THE INSIDE OF TIRE. GENERAL , GRABBER AW TIRES-SIZE#255/70R16. *SCC ...*AK
Steering, Oct 25, 2002
WHILE DRIVING THE VEHICLE CONSUMER STATES CANT CONTROL THE STEERING WHEEL, WHEN MAKE LEFT OR RIGHT. DEALER HAS BEEN NOTIFIED. PLEASE PROVIDE FURTHER INFORMATION. TS
Tires, Oct 24, 2002
APPROXIMATELY ON MONTH AND 1800 MILES AFTER PURCHASING THE VEHICLE. THE RIGHT FRONT TREAD SEPARATED FROM THE SIDEWALL. I TOOK THE TIRE TO THE DEALER AND WAS TOLD THEY WOULD REPLACE THE TIRE WITH ONE JUST LIKE IT BUT IT HAD TO BE ORDERED AND WOULD BE IN A DAY OR TWO. FOUR DAYS LATER THE TIRE WAS STILL NOT IN BUT THEY TOOK ONE OFF ANOTHER VEHICLE AND PUT IT ON MINE. TWO WEEKS LATER THE SAME WHEEL, WITH THE NEW TIRE, WENT FLAT AGAIN. THIS TIME THE DEALER TOLD ME TO TAKE IT TO THE TIRE SHOP AND HAVE IT CHECKED OUT. I DID SO AND WAS TOLD THE WHEEL HAD A LEAKING VALVE STEM, WAS FIXED FREE OF CHARGE AND SO FAR IS STILL UP. ON 10-23 THE RIGHT REAR TIRE ON MY TRUCK WENT FLAT. IT AS ALL THE REST ARE ALSO GENERAL GRABBERS. THE ONLY THING I CAN SEE THAT COULD BE THE CAUSE OF THE REAR TIRE FLAT IS A ROCK STUCK BETWEEN THE TREAD, THOUGH I HAVEN'T CHECKED TO SEE IF IT PUNCTURED THE TIRE OR NOT. I'M TAKING THE TRUCK TO THE DEALER THE NEXT DAY OR TWO TO LET THEM INSPECT IT. I HAVE DONE SOME RESEARCH ON THE GRABBER AW AND DISCOVERED THAT THERE IS A RECALL ON THE 17" VERSION. THE DEALER AND FORD HAVE FLATLY REFUSED TO REPLACE THE TIRES WITH A TRUSTWORTHY AND SAFER TIRE. IN LIGHT OF ALL THE PROBLEMS FORD HAS HAD WITH TIRES IT APPEARS TO ME THEY WOULD BE A LITTLE MORE CAREFUL WITH THE QUALITY OF TIRES THEY PUT ON THE VEHICLES THEY MANUFACTURE. THESE TIRES ARE UNSAFE AND DANGEROUS, AND ALTHOUGH COVERED UNDER FORD'S WARRANTY, COULD BE DISASTROUS SHOULD ANOTHER ONE OF THEM SEPARATE. I WOULD APPRECIATE ANY HELP OR GUIDANCE YOU COULD PROVIDE FOR ME. SINCERELY [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Wheels, Oct 18, 2002
CONSUMER STATES AFTER ROTATING THE TIRES THE LUG NUT STUD BROKE EASILY WHEN TIGHTENING IT. THE DEALER WAS INFORMED. PLEASE PROVIDE MORE INFORMATION. MR
Tires, Oct 8, 2002
CONSUMER STATES THAT WHILE DRIVING AND WITHOUT WARNING THE LEFT REAR INSIDE TIRE TREAD SEPARATED AND BLEW OUT, SIZE LT22575R16. MR DOT # VD1L 1X1 (THIS VEHICLE IS AN AMBULANCE). *YH