2002 Ford F-150
Problems, recalls and owner-reported issues
Engine and engine cooling is the leading concern among 955 owner complaints filed for this model year. This is the 5th highest complaint count among 26 F-150 model years with reports.
Of the 2002 reports, 58 involved a crash and 100 involved a fire. 67 people were injured.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsAug 11, 2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lighting, headlightsAug 1, 2006
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 28, 2006. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.
Campaign 06E067000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Campaign 06E065000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Vehicle speed controlSep 7, 2005
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
A FIRE AT THE SWITCH COULD OCCUR.
BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)
Campaign 05V388000 on NHTSA.gov
Representative owner complaints
955 reports, newest first.
Fuel/propulsion system, Jan 22, 2015
THERE'S A RECALL ALREADY FOR THE FUEL TANK STRAPS IN THE SALT BELT STATES.I LIVE ABOUT 20 MILE FROM TENN.IM SEATING AT MY JOB AND LOOKED OUT THE WINDOW AND MY FUEL TANK STRAP BROKE.THE TANK WAS ABOUT 2 INCH ABOVE THE ROAD.CALL FORD AND THEY SAID ITS NOT COVERED.IM IN THE MOUNTAINS AND WE USE ROAD SALT EVERY YEAR.WHAT MAKES TEN ANY DIFFERENT.THIS COULD HAVE BEEN BAD IT STARTED DRAGGING ON THE ROAD WHILE I WAS DRIVING.WHER THE STRAP RUST.IT CAUSED THE FUEL TANK TO RUST.NOW THE TANK IS LEAKING SAME PLACE THE STRAP RUSTED.HELP. *TR
Seat belts, Jan 17, 2015
THE DRIVER'S SEAT BELT COMES UNBUCKLED FOR NO APPARENT REASON WHILE DRIVING. *TR
Engine, Jan 14, 2015
DRIVING ON THE FREEWAY A SPARK PLUG CAME OUT OF THE ENGINE CAUSING THE VEHICLE TO SHAKE AND LOOSE POWER. THE DEALER AND A SHOP I TOOK THE VEHICLE TO STATED THAT THIS IS A FREQUENT PROBLEM WITH THIS ENGINE. *TR
Electrical system, Jan 12, 2015
THIS IS THE SECOND OCCURRENCE OF THIS NATURE. THE PREVIOUS HAPPENED APPROXIMATELY IN JULY OF 2014. AT THAT TIME THE DEALERSHIP SAID THAT THE KEY WAS THE PROBLEM AND I PAID FOR A NEW KEY AND EVERYTHING HAS BEEN GOOD UNTIL ~ 1/4/15. THIS TIME, THE PATS (ANTI-THEFT) SYSTEM TRIGGERED AND RENDERED THE VEHICLE USELESS. AFTER ~ 45 MINUTES IT EVENTUALLY STARTED AND I DROVE IT TO THE DEALERSHIP. IT WAS THERE FOR 2 DAYS AND THEY COULDN'T GET THE SYSTEM TO TRIGGER. THEREFORE, THEY HAD ME COME PICK UP THE VEHICLE. TWO DAYS LATER, THE VEHICLE RENDERED ITSELF USELESS AGAIN THROUGH THE PATS SYSTEM. THE VEHICLE WOULDN'T START FOR 2 DAYS AS I TRIED TO START IT PERIODICALLY AS I WAS INSTRUCTED BY THE DEALERSHIP. FINALLY IT STARTED ON THE 3RD MORNING. WHEN I ORIGINALLY TOOK THE TRUCK IN THE TWO GUYS AT THE DEALERSHIP SAID THAT THIS IS A COMMON PROBLEM IN THIS YEAR MODEL. IN FACT WHEN I TOLD HIM OF THE ISSUE I WAS HAVING, THE SERVICE MANAGER ASKED IF I HAD A 2002 F150. WE HAD A GOOD LAUGH WHEN I SAID "YES, AND THAT ISN'T A GOOD SIGN THAT YOU KNOW THAT- WITHOUT SEEING MY VEHICLE." HE EXPLAINED THAT THE TILT MECHANISM IN THE STEERING COLUMN DAMAGES THE WIRE THAT RUNS FROM THE KEY TRANSPONDER AREA TO THE SENDING UNIT THAT TELLS THE ENGINE THAT THIS IS THE CORRECT KEY. THIS WAS THE NIGHT THAT THEY KEPT THE TRUCK FOR 2 DAYS. THIS IS A SITUATION WHERE A PERFECT OPERATIONAL VEHICLE IS NOT FUNCTIONING BECAUSE OF A CHAFFED WIRE OR THE WIRE HAS BEEN PULLED FROM ITS SOLDERING POINT. I AM THE OWNER, YET I HAVE THE SAME CHANCE OF STARTING THAT TRUCK AS A CAR THIEF. IT MAKES NO SENSE. THIS DIDN'T SEEM LIKE A SAFETY ISSUE TO ME UNTIL I WAS STRANDED FOR 45 MINUTES IN A PARKING LOT AND IT WAS EXTREMELY COLD. I ENVISIONED SOMEONE TURNING THEIR CAR/TRUCK OFF FOR SOME REASON IN A PLACE WHERE THE TEMP WAS WELL BELOW FREEZING AND FREEZING TO DEATH BECAUSE THIS SYSTEM HAS BEEN TRIGGERED. *TR
Engine, Jan 6, 2015, fire
TL* THE CONTACT OWNS A 2002 FORD F-150. WHILE THE VEHICLE WAS PARKED, SMOKE APPEARED UNDER THE HOOD AND THE VEHICLE CAUGHT FIRE. A POLICE REPORT WAS FILED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 107,000.
Engine, Dec 31, 2014
#4 SPARKPLUG EJECTED *JS
Power train, Engine, Fuel/propulsion system, Dec 7, 2014
SPARK PLUG BLEW OUT OF HEAD. *TR
Power train, Engine, Fuel/propulsion system, Nov 22, 2014
FORD F 250 TRITON V10 NO. 2 SPARK PLUG AND COIL BLEW OUT OF THE ENGINE HEAD. APPARENTLY THIS IS A COMMON PROBLEM WITH THIS MODEL AND OTHERS. FORD WILL CHARGE 650.00 TO FIX. *TR
Engine, Nov 22, 2014
FORD F 250 TRITON V10 NO. 2 SPARK PLUG AND COIL BLEW OUT OF THE ENGINE HEAD. APPARENTLY THIS IS A COMMON PROBLEM WITH THIS MODEL AND OTHERS. FORD WILL CHARGE 650.00 TO FIX. *TR
Engine, Nov 15, 2014
2002 F150 HARLEY DAVIDSON EDITION WITH ONLY 75,000 MILES BLEW A SPARK PLUG OUT OF THE HEAD. FORD ADMITS NO CULPABILITY EVEN THOUGH THEY HAVE TSB'S. ESTIMATE TO REPAIR PLUG & CHANGE OUT OTHER 7 SPARK PLUGS WITH 8 NEW COILS WAS $2800. I COULD ALMOST PURCHASE A NEW ENGINE FOR THAT. FOUND A REPUTABLE GARAGE TO DO THE WORK FOR AROUND $900 TOTAL. UNDERSTAND THAT I SHOULD GET USED TO THIS HAPPENING UNTIL ALL 8 SPARK PLUG HOLES HAVE BEEN REPAIRED. FORD MAN FOR 35 YEARS. OWN 3 CURRENTLY. IF DEPENDABILITY IS NO LONGER A PRIORITY FOR FORD DON'T KNOW WHAT I WILL DO. *TR
Exterior lighting, Nov 12, 2014
TL* THE CONTACT OWNS A 2002 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH, THE REAR LIGHTS BECAME INOPERABLE. THE CONTACT BELIEVED THAT THE FAILURE WAS DIRECTLY RELATED TO NHTSA CAMPAIGN NUMBER: 11V352000 (EXTERIOR LIGHTING). THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 71,505.
Engine, Oct 23, 2014
ANOTHER SPARK PLUG BLEW OUT OF CYLINDER HEAD TAKING THREADS WITH IT. POSSIBLE FIRE HAZARD AS FUEL SPEWS INTO ENGINE COMPARTMENT WITH LIVE SPARKS CLOSE BY. *TR
Engine, Oct 23, 2014
SPARK PLUG BLEW OUT OF #2 CYLINDER TAKING THREADS WITH IT REQUIRED SPECIAL INSERT FOR NEW PLUG COST $400 POSSIBLE FIRE HAZARD AS FUEL BLOWS INTO ENGINE COMPARTMENT AND SPARK PLUG IS STILL FIRING. *TR
Seat belts, Oct 22, 2014
I ALWAYS LATCH MY SEAT BELT. I HAVE BEEN DOING THIS SINCE 1983. I NEVER DRIVE WITHOUT MY SEAT BELT LATCHED. FOR A COUPLE OF YEARS MY DRIVERS SIDE SEAT BELT HAS BEEN MYSTERIOUSLY BECOMING UNLATCHED WHILE DRIVING DOWN THE ROAD. I THOUGHT I JUST WASN'T PUSHING IT IN FAR ENOUGH SOMETHING I HAVE NEVER BEFORE HAD AN ISSUE WITH IN ANY OTHER VEHICLE. AFTER A FEW MILES OF DRIVING THE SEAT BELT BECOMES UNLATCHED. IT IS VERY NOTICEABLE BECAUSE IT MAKES AN AUDIBLE CLICK AND RECEDES BACK SLIGHTLY RELIEVING ANY TENSION APPLIED TO MY TORSO. FOR A LONG TIME I THOUGHT I WAS CRAZY AND I HAD JUST BEEN IN A HURRY OR SOMETHING. AFTER THE UNCLASPING I REINSERT IT INTO THE RECEIVER THEN I JOSTLE IT AND SEE IF IT UNCLASPING AGAIN. I HAVE NEVER BEEN ABLE TO CAUSE IT TO BECOME UNCLASPED BY JOSTLING IT AND UP TILL TODAY IT WOULD NEVER BECOME UNCLASPED AFTER RESETTING IT. IT HAPPENS AT ALL SPEEDS. THE FREQUENCY HAS INCREASED TO AN ESTIMATED 1/3 OF THE TRIPS THAT THIS HAPPENS. WELL TODAY I EXPERIENCED IT AGAIN AND REINSERTED THE SEAT BELT AND JOSTLED IT AND CONTINUED DRIVING. THIS TIME I DIDN'T GET A MILE BEFORE IT BECAME UNCLASPED AGAIN. AHA! I AM NOT CRAZY. OKAY THAT SOUNDS A LITTLE LIKE I AM BUT I ASSURE YOU I AM NOT. THIS IS A SERIOUS ISSUE AND IT HAS TAKEN ME SEVERAL YEARS TO FINELY PROVE TO MYSELF THAT THE SEAT BELT IS DEFECTIVE. SO BECAUSE THE DRIVER CAN NOT REPRODUCE THE UNCLASPING BY MANUALLY JOSTLING THE SEAT BELT WE TELL OURSELVES THAT IT MAY NOT BE THE SEAT BELT. THIS CAUSES THE DRIVER TO NOT TAKE THE REQUIRED ACTION OF HAVING THE SEAT BELT FIXED. I HAVE BEEN DRIVING WITH MY LIFE AT RISK FOR SEVERAL YEARS NOW. I CALLED THE LOCAL DEALER AND ASKED IF THEY HAVE HEARD OF THE ISSUE IN MY VEHICLE YEAR MAKE AND MODEL AND WAS TOLD THAT THEY HAVE RECEIVED NO OTHER COMPLAINTS. THIS SEAT BELT NEEDS TO BE RECALLED. *TR
Electrical system, Exterior lighting, Oct 12, 2014
HAVE NOTICED THAT THE TURN SIGNALS AND TAILBED BRAKE LIGHTS DO NOT WORK WHEN MOVING THE TILT WHEEL. WILL WORK WHEN STEERING WHEEL IS PLACED IN HIGHEST POSITION. HAVE SEEN RECALL ON RANGER TRUCKS FOR THIS ISSUE. *TR
Seat belts, Oct 2, 2014
TL* THE CONTACT OWNS A 2002 FORD F-150. WHILE DRIVING APPROXIMATELY 15 MPH, THE DRIVER SIDE SEAT BELT UNLATCHED. THE FAILURE OCCURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 210,000.
Steering, Power train, Structure, Sep 25, 2014
WHILE BACKING INTO MY TRUCK STARTED MAKING A LOAD NOISE, IT WAS OBVIOUS IT WAS IN THE FRONT END. TRYING TO TURN THE STEERING WHEEL, IT WAS STUCK. STOPPED THE TRUCK, LOOKED UNDER THE FRONT OF TRUCK AT STEERING, I NOTICED THAT THERE WAS A HOLE IN THE FRAME, IT WAS THEN THAT I SAW THE STEERING LINK, AGAINST THE RIGHT CV AXLE. THE IDLER ARM HAD SOME HOW RIPPED OFF THE FRAME, LEAVING NA HOLE WHERE THE IDLER ARM WAS, THE FRAME OF THE TRUCK HAD WEAKENED, CAUSING THE METAL TO WEAKEN AND SEPARATE, THANK AGAIN FORD. *TR
Vehicle speed control, Service brakes, Sep 24, 2014, fire
I PARKED THE VEHICLE AND 20 MINUTES LATER DISCOVERED THE VEHICLE ON FIRE. FURTHER INVESTIGATION REVEALED THAT MASTER CYLINDER WAS TOTALLY ENGULFED IN FLAME. THE FIRE DAMAGED THE WIRE HARNESS, AIR FILTER, FUSE BOX AND COMPLETELY MELTED THE CYLINDER. *TR
Engine, Fuel/propulsion system, Sep 23, 2014
WHILE DRIVING MY VEHICLE UNDER VERY NORMAL CIRCUMSTANCES, TRAVELING APPROXIMATELY 30MPH, MY TRUCK BEGAN TO RUN VERY ROUGH AND THERE WERE LOUD POPPING NOISES COMING FROM THE TOP OF THE PASSENGER SIDE VALVE COVER. IT TURNED OUT TO BE A BLOWN-OUT SPARK PLUG AND COIL PACK. *TR
Suspension, Sep 22, 2014
I WAS DRIVING MY 2002 FORD F-150 VIN # ([XXX]) DOWN THE HIGHWAY AT 45MPH WHEN IT STARTED WHEEL HOPPING FROM THE REAR VERY BAD, THERE WAS A SCHOOL BUS STOPPED LETTING CHILDREN OFF & AS I WAS BRAKING IT WAS HOPPING & WAS A NEAR MISS, THIS WAS CLOSE. I PULLED THE TRUCK OFF THE SIDE OF THE ROAD TO INSPECT AS I AM MECHANICALLY INCLINED & RETIRED, FOR THE FIRST 10 YEARS OF MY LIFE I WORKED IN THE AUTOMOBILE FIELD BECAUSE I HAD SCHOOLING FOR IT, ANYWAY I LOOKED UNDER THE TRUCK & SPOTTED THE PROBLEM RIGHT OFF THE BAT, BOTH REAR CENTER LEAF SPRINGS ARE BROKEN BIGGER THAN CRAP. I AM 54 AND A DIE HARD FORD FAN AND HAVE BEEN SINCE THE AGE OF 16, THAT IS ALL I HAVE OWNED & I AM THINKING ABOUT SWITCHING BRANDS BECAUSE THIS IS NOT THE FIRST TIME I HAVE BEEN DISAPPOINTED WITH THIS TRUCK. I AM THE SECOND OWNER, I BOUGHT IT IN 10/2004 WITH 13,000 MILES. IT HAS NEVER HAD ANYTHING OVER 100 POUNDS HAULED IN IT AND I AM THE ONLY ONE WHO HAS DRIVEN IT SINCE I BOUGHT IT. IS THERE ANY RECALLS FOR MY TRUCK ON THIS PROBLEM? CAN FORD MOTOR COMPANY DO ANYTHING FOR ME? THANK YOU [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Seat belts, Sep 16, 2014
DRIVERS SEAT BELT DISCONNECTS ON IT'S OWN, THIS HAPPENS MULTIPLE TIMES DURING THE COURSE OF DRIVING. *TR
Engine, Sep 8, 2014
TL* THE CONTACT OWNS A 2002 FORD F-150. THE CONTACT STATED THAT THE SPARK PLUGS DETACHED FROM THE CYLINDER HEAD AND CAUSED THE VEHICLE NOT TO PERFORM PROPERLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 200,006.
Steering, Power train, Service brakes, Engine, Sep 5, 2014
ENGINE QUITS RUNNING AND WONT RESTART, SO YOU HAVE NO POWER STEERING OR BRAKES. PROBLEM INDICATORS ARE 1. ENGINE WONT RESTART/ OR QUIT RUNNING 2. ODOMETER READS ALL DASHES, NO NUMBERS,3. ANTI THEFT ACTIVATED. THIS IS CAUSED BY THE POWER WIRE IN THE FUSE BOX UNDER THE HOOD CORRODING OFF FOR THE PCM RELAY AND LEAVING THE PCM DEAD. *TR
Other or unspecified, Aug 26, 2014, fire
TL* THE CONTACT OWNS A 2002 FORD F-150. THE CONTACT STATED THAT WHILE PARKED, THE VEHICLE IGNITED INTO FLAMES. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE VEHICLE WAS DESTROYED AND REMAINED AT THE RESIDENCE. THE VIN WAS UNAVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.
Electronic stability control (ESC), Service brakes, Aug 24, 2014
FAILURE OF THE ABS MODULE HAS LED TO A NEAR MISS ACCIDENT THAT WAS AVOIDED VIA STEERING AROUND THE OBSTRUCTION INSTEAD OF BRAKING. THE OBDII MODULE IS THROWING CODE C1185 AS A PART OF THE FAILURE OF THE ABS CONTROLLER.. *TR