2004 Ford F-150
Problems, recalls and owner-reported issues
Visibility is the leading concern among 2,036 owner complaints filed for this model year. This is the highest complaint count among 26 F-150 model years with reports.
Of the 2004 reports, 75 involved a crash and 40 involved a fire. 74 people were injured and 6 people died.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleFeb 23, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2004-2006 F-150 PICK UP TRUCKS AS WELL AS CERTAIN MODEL YEAR 2006 LINCOLN MARK LT VEHICLES. IF THE CLOCKSPRING JUMPER WIRE COMES IN CONTACT WITH THE DRIVER SIDE FRONTAL AIR BAG LOWER HORN PLATE, THE WIRE INSULATION MAY BECOME CHAFED, CREATING A POTENTIAL FOR A SHORT CIRCUIT. IF THIS OCCURS THE AIR BAG WARNING LAMP MAY ILLUMINATE INDICATING THAT SERVICE IS REQUIRED.
THE DRIVER SIDE FRONTAL AIR BAG COULD INADVERTENTLY DEPLOY INCREASING THE RISK OF INJURY OR LOSS OF VEHICLE CONTROL IF OCCURRING WHILE IN MOTION.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN/MERCURY DEALER TO HAVE A NEW CLOCKSPRING JUMPER WIRE INSTALLED THAT INCORPORATES A PROTECTIVE MESH COVER. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THIS SAFETY RECALL BEGAN ON SOME VEHICLES IN MARCH 2011. THE RECALL CAMPAIGN ON THE EXPANDED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT MAY 9, 2011. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Campaign 11V107000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsOct 25, 2007
CERTAIN SPYDER HEADLAMP REPLACEMENT ASSEMBLIES SOLD FOR USE ON 2004 THROUGH 2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SPYDER WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2007. OWNERS CAN CONTACT SPYDER AT 866-558-4264.
Campaign 07E089000 on NHTSA.gov
Exterior lighting, headlightsSep 25, 2007
CERTAIN HEADLAMP ASSEMBLIES IMPORTED AND SOLD AS AFTERMARKET EQUIPMENT BY SONAR AUTO PARTS FOR USE ON 2004-2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SONAR WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS CAN CONTACT SONAR AT 866-558-4264.
Campaign 07E080000 on NHTSA.gov
Exterior lighting, headlightsSep 14, 2007
CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. FR390-B001L AND FR390-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE THICKNESS IS UNSTABLE INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
EAGLE EYES WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON NOVEMBER 6, 2007. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.
Campaign 07E075000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Vehicle speed controlAug 3, 2007
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
THIS COULD RESULT IN AN UNDERHOOD FIRE.
DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Campaign 07V336000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Fuel system, gasoline, storage, tank assembly, mountingSep 13, 2004
ON CERTAIN TRUCKS EQUIPPED WITH 4.2L, 4.6L AND 5.4L GASOLINE ENGINES, THE FUEL TANK MAY HAVE A DEPRESSION AT THE SEAM BETWEEN THE TOP AND BOTTOM HALVES OF THE TANK. IF A DEPRESSION IS LARGE ENOUGH, FUEL MAY PERMEATE THE FUEL TANK WALL RESULTING IN A FUEL ODOR, ILLUMINATION, OF THE "SERVICE ENGINE SOON" INDICATOR LIGHT, OR A FUEL LEAK.
FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
DEALERS WILL REPLACE THE FUEL TANK. THE RECALL BEGAN SEPTEMBER 17, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V443000 on NHTSA.gov
Fuel system, gasoline, storage, tank assemblyApr 26, 2004
CERTAIN PICKUP TRUCKS MAY HAVE A FUEL TANK WITH LOCALIZED DEPRESSIONS IN THE FUEL TANK WALL AT THE SEAM BETWEEN TOP AND BOTTOM HALVES OF THE TANK. IF A DEPRESSION IS LARGE ENOUGH, FUEL MAY PERMEATE THE FUEL TANK WALL RESULTING IN A FUEL ODOR, OR THE "SERVICE ENGINE SOON" INDICATOR LIGHT IN THE INSTRUMENT CLUSTER MAY ILLUMINATE.
IF LEFT UNCORRECTED, A FUEL LEAK COULD EVENTUALLY DEVELOP.
DEALERS WILL REPLACE THE FUEL TANK ON THESE VEHICLES. OWNER NOTIFICATION BEGAN ON MAY 6, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-248-0186.
Campaign 04V200000 on NHTSA.gov
Representative owner complaints
2,036 reports, newest first.
Power train, Jun 16, 2022, crash
The contact owns a 2004 Ford F-150. The contact stated while starting his parked vehicle, he found that the vehicle would not start. The contact self-diagnosed and bypassed the starter solenoid using a screwdriver and started the vehicle. The vehicle slipped out of the park and rolled backward. The contact was backed over by the vehicle and had received injuries to his ribs and stomach. He had lacerations and abrasions to his back and chest. The contact was able to get out from under the vehicle and attempted to stop the vehicle which was rolling. The contact jumped into the passenger side and attempted to brake but could not. The contact attempted to push the shift lever into "park" but the gear would not engage. The vehicle rolled and crashed into the rear end of a parked vehicle. The contact's vehicle had damage to the rear bumper and the rear end of the other vehicle had the bumper and trunk crumpled. The police were not called and the contact did not seek medical attention. The contact was able to start the vehicle and drove it to his residence. The contact then examined the undercarriage and determined that the transmission linkage cable had been resting on the doughnut of the exhaust system. The contact stated that the outer cable shell had melted and the metal cable was exposed. The contact diagnosed that the exposed cable had contributed to the vehicle slipping out of gear. The contact had not taken the vehicle to a dealer or an independent mechanic. The vehicle had not been repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 260,000.
Structure, Apr 20, 2022
The truck has had a complete body frame failure. The entire frame is rusted through with large holes. I am unable to put it on a jack to change the tires. It has failed inspections and has not been inspected since 2019. I have a 1992 ford truck that has NO rust issue on the frame. This year is a complete design failure where they used substandard steel or other garbage. It is a safety hazard.
Suspension, Apr 9, 2022
There hasn't been any accidents but the rails underneath of the truck bed are rotting completely off the truck and I feel that would be a safety problem if it collapses and I don't understand why they're so rusty when the rest of the truck is not it this could be a problem!
Suspension, Structure, Mar 11, 2022
Hitch broke off due to ford common frame rot. Frame is rotted from leaf spring shackle and back
Other or unspecified, Feb 5, 2022
Door latch not working. Doors flies open. Frozen or stuck. Doesnt latch all the time very dangerous . Happens parked and while driving
Wheels, Jan 13, 2022
Swollen lug nuts--- had to replace all at my expense
Engine, Feb 19, 2021
THROTTLE BODY CAUSES VEHICLE TO STOP DEAD WHEN SLOWING DOWN ON CITY STREET.
Structure, Nov 18, 2020
TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED THAT WHILE THE VEHICLE WAS AT AN INDEPENDENT MECHANIC FOR ROUTINE MAINTENANCE, THE TECHNICIAN NOTICED THAT THE SUBFRAME WAS SEVERELY RUSTED THROUGH. THE VEHICLE WAS LATER TAKEN TO TONY BETTEN & SONS FORD, INC (3839 PLAINFIELD AVE NE, GRAND RAPIDS, MI 49525) WHERE THE CONTACT WAS INFORMED THAT THE DRIVER'S AND PASSENGER'S SIDE SUBFRAME WERE SEVERELY RUSTED, AND THAT THE SUBFRAME NEEDED TO BE REPLACED. THE SUBFRAME WAS NOT REPLACED NOR WAS THE VEHICLE REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 167,000.
Other or unspecified, Oct 25, 2020
THE TOP OF PASSENGER DASH HAS BECAME A STICKY SURFACE AND THE PAINT WILL RUB OFF. TRUCK ONLY HAS 60K MILES BECAUSE IT'S MY HUSBANDS PRIDE. VEHICLE STAYS IN A GARAGE WITH NO NATURAL LIGHT THAT COULD CAUSE PROBLEM.
Engine, Sep 7, 2020
WHILE DRIVING ON THE FREEWAY I NOTICE A NOISE AND A LOSE OF POWER PULL OFF AND HAD TRUCK TOWED TO DEALER THEY CALLED ME TOLD ME NEEDED NEW MOTOR I WAS SHOCKED ONLY HAS 154000 MILES ON IT WHAT THE HELL DEALER TOLD ME $9000 TO REPLACE MOTOR WHAT TOLD THEM I WOULD BE THERE TO PICK UP TRUCK WITH TOW TRUCK WELL THEY CALLED ME BACK SAID $7000 STILL WAY TO MUCH BUT I NEED THE TRUCK CANT BUY A NEW ONE SO I HAD TO GET 2 LOANS TO REPLACE MY MOTOR THEN I FIND OUT THE MOTOR IN A 2004 F 150 HAS A MAJOR ISSUES BUT THE DEALER NEVER TOLD ME ANYTHING OF THE SORT SO NOW I HAVE A TRUCK WITH THE SAME MOTOR AS BEFORE THAT COST ME A LARGE AMOUNT OF MONEY I DIDN'T HAVE FORD SHOULD STEP UP AND TAKE CARE OF THE PROBLEM SO NOW I HAVE 2 LOANS TO PAY OFF HOPE TO HELL THIS MOTOR LAST AND THEY WONDER WHY PEOPLE GO POSTAL IF FORD DOSENT RESOLVE THIS I WILL NEVER BUY A FORD PRODUCT AGAIN !!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!
Power train, Other or unspecified, Engine, Jul 20, 2020
F150 STALLS OUT RANDOMLY CAUSING A HAZARD FOR OTHER DRIVERS AND MYSELF. HAPPENS WHILE IN GEAR DRIVING, REVERSE, ETC.
Structure, Apr 20, 2020
THE FRAME IS ROTTED COMPLETELY. IT IS A SAFETY ISSUE THAT WHEN DISCOVERED AND SEARCHED SEEMS TO A HUGE ISSUE. I WAS ADVISED NOT TO DRIVE THE VEHICLE AS IT NOT SAFE TO DRIVE. I BOUGHT THIS TWO DAYS AGO.
Other or unspecified, Mar 22, 2020
THE DOOR LATCH OF THE REAR "SUICIDE" DOOR WILL NOT OPEN. THE LATCH ONLY MOVES BACK AND FORTH, BUT THE LATCH'S CABLE WILL NOT ENGAGE. I CHECKED AND LEARNED OTHER F-150S HAS THE SAME PROBLEM. IS THIS A "RECALL" ISSUE?
Structure, Mar 3, 2020
TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED WHILE ROUTINE MAINTENANCE WAS BEING PERFORMED ON THE VEHICLE, THE CONTACT DISCOVERED THAT THE SUBFRAME WAS EXTREMELY CORRODED. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED NOR REPAIRED. NEITHER THE DEALER NOR THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 167,000.
Suspension, Wheels, Feb 24, 2020
FRONT SPRINGS TO LOW
Electrical system, Structure, Engine, Feb 24, 2020
PAINT CRACKED ,COILS MALFUNCTION,SPRINGS FRONT
Other or unspecified, Jan 20, 2020
DRIVERS DOOR SLUNG OPEN EVENTHOUGH IT APPEARED LATCHED WHEN I TURNED A CURVE. IT WAS 15 DEGREES OUTSIDE AT THE TIME OF INCIDENT. COULD CAUSE AN ACCIDENT .
Visibility/wiper, Dec 12, 2019
IN MID NOVEMBER 2019, I WAS ENTERING MY VEHICLE AND NOTICED THE REAR CENTER GLASS WINDOW COMPLETELY SHATTERED THE MOMENT I OPEN THE TRUCK DOOR FOR NO REASON. NO INDICATION OF AN OBJECT STRIKING OR ANYTHING. THE VEHICLE WAS COMPLETELY STATIONARY IN MY DRIVEWAY. THE TEMPERATURE HAD DROPPED DOWN PAST 20 DEGREES THE DAY THIS HAPPENED. I REPLACED THE ENTIRE REAR WINDOW AND THEN,NOT EVEN A WEEK LATER, THE REAR RIGHT SIDE OF THE WINDOW IS COMPLETELY SHATTERING AND IS ABOUT TO BREAK....THE SAME PROBLEM AGAIN! NOW, I GO OUT TODAY, 12/12/19 TO MY PASSENGER SIDE DOOR WINDOW COMPLETELY SHATTERED FOR NO APPARENT REASON! IN ALL 3 INSTANCES, THE TEMPERATURE DROPPED BELOW 35 DEGREES. I HAVE NO IDEA WHAT'S GOING ON AND IT'S DRIVING ME INSANE TRYING TO FIGURE OUT WHY THE WINDOWS ARE RANDOMLY SHATTERING WHEN THE TEMPERATURE DROPS. NOW I AM ABOUT TO BE OUT I DON'T KNOW HOW MUCH MONEY TO TRY TO REPAIR MY FORD WINDOWS.
Structure, Dec 3, 2019
2004 F150 FX4. CONSUMER WRITES IN REGARDS TO DAMAGED FRAME. *LD *JS
Structure, Nov 27, 2019
THIS VEHICLE IS OTHERWISE IN GOOD CONDITION WITH VERY LITTLE BODY RUST LIMITED TO THE BACK CORNER OF THE PASSENGER CABIN. HOWEVER THE LEFT FRAME RAIL STARTING 14 INCHES AHEAD OF THE FRONT ATTACHMENT POINT OF THE LEAF SPRING. THE RUST HOLE EXTENDS THE WIDTH OF THE FRAME RAIL FOR A DISTANCE OF 17 INCHES. ONE FINGER SIZE HOLE WAS OBSERVED. THE FRAME BOTTOM STEEL WAS EASILY STRIPPED AWAY WITH TWO FINGERS AND A THUMB TO THE LENGTH AND WIDTH DESCRIBED. THE REMAINDER OF THE FRAME HAS EXTENSIVE SURFACE RUST BUT NO HOLE AND OTHERWISE FAIR CONDITION. THE LICENSED STATE VEHICLE INSPECTION SHOP FAILED THE VEHICLE DUE TO THE FRAME RUST AT THIS LOCATION. OTHERWISE, WITH SOME MINOR MECHANICAL ISSUES, THE TRUCK IS IN GOOD CONDITION AND COULD BE SAFELY USED FOR A NUMBER OF MORE YEARS. ONLINE THIS RUST PROBLEM AT THIS POINT HAS A LARGE NUMBER OF COMPLAINTS IN FORD F-150 TRUCKS IN 2004 AND 2005. OBVIOUSLY THERE WAS A MANUFACTURING ISSUE FRAME FORMING TO CAUSE THIS RUST THROUGH IN SO MANY TRUCKS AT THIS FRAME LOCATION AND NOT ELSEWHERE.
Electrical system, Nov 8, 2019
BOUGHT VEHICLE FROM INDIVIDUAL HE STATED MILEAGE ON ODOMETER 125K AND 2008 WENT TO GET INSURANCE AND IT'S A 2004 AND MILEAGE WAS 240K PLUS
Air bags, Oct 15, 2019, crash
TL* THE CONTACT OWNED A 2004 FORD F-150. WHILE THE CONTACT'S FIANCE WAS DRIVING 35 MPH, A DEER RAN INTO THE ROAD AND CAUSED THE DRIVER TO SWERVE AND CRASH INTO A TREE. THE AIR BAGS DID NOT DEPLOY. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE DRIVER SUSTAINED A BROKEN LEFT WRIST AND STRUCK HIS HEAD ON THE WINDSHIELD. THE DRIVER RECEIVED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO AN IMPOUND LOT AND DEEMED DESTROYED. THE CONTACT CALLED CONWAY FORD (LOCATED AT 2393 CHURCH ST, CONWAY, SC 29526, (843) 365-5596) AND INFORMED THEM OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WERE UNKNOWN. *LN*JB * PM CONSUMER STATED OWNER OF THE VEHICLE WAS HER DAD'S WHICH WAS PURCHASED IN 2000. *JB
Other or unspecified, Sep 23, 2019
I TOOK MY TRUCK IN TO GET THE STEERING SHAFT REPLACED AND WHEN THE LIFTED UP ON THE HOIST THEY NOTICED THAT THE FRAME IN THE FRONT HAD A SPLIT IN IT UP IN THE FRONT PART OF THE FRAME ON THE DRIVER SIDE OF THE VEHICLE AND THAT THE FRAME WAS VERY RUSTY. I THEN TOOK IT TO ANOTHER PERSON TO HAVE IT LOOKED OVER TO SEE IF THERE WAS ANY WAY TO WELD THE FRAME TO FIX THE SPLIT. UPON HIS INSPECTION, HE FOUND THAT THE ENTIRE FRAME IN THE REAR AND THE MAJORITY OF THE REST OF THE FRAME WASN'T STABLE ENOUGH TO HANDLE A WELD SINCE THE FRAME IS RUSTED SO BAD THE WELD WOULDN'T HOLD. I THEN CALLED AND TALKED TO FORD DIRECTLY AND THEY TOLD ME THAT I HAD TO BRING IT INTO AN AUTHORIZED SERVICE CENTER TO HAVE IT INSPECTED. WHICH I DID AND THEY ALSO DEEMED THE FRAME BEYOND REPAIR. I THEN CALLED FORD BACK AND THEY TOLD ME THAT THERE WAS NOTHING THAT THEY COULD DO FOR ME SINCE THE VEHICLE WAS PAST 7 YEARS. SO, NOW I HAVE AN UN-USEABLE UN-SELLABLE VEHICLE. UPON SOME RESEARCH, I FOUND THAT THAT GENERATION OF FORD VEHICLES HAS HAD SEVERAL HUNDRED THOUSAND VEHICLE RECALLS FOR THE SAME ISSUES FRAME DETERIORATION AND OR FAULTY FRAME OR CHASSIS IN MULTIPLE MODELS. UPON FURTHER RESEARCH, I HAVE FOUND THAT THIS SEEMS TO BE A COMMON PROBLEM FOR THAT GENERATION FORD F150'S AS WELL HOWEVER THERE IS NO RECALL FOR THAT VEHICLE. MY TRUCK ONLY HAS 128,000 ORIGINAL MILES ON IT AND THE MOTOR ITS SELF PROBABLY WOULD LAST ANOTHER 150,000 MILES OR MORE. IF I HAD NOT TAKEN THE VEHICLE IN FOR SERVICE FOR ANY ISSUES THEN I WOULDN'T HAVE KNOWN THAT THERE WAS A FRAME ISSUE AND IF I WOULD HAVE BEEN IN AN ACCIDENT MY FRAME WOULD HAVE BUCKLED NO DOUBT ABOUT IT SINCE THAT IS EXACTLY WHAT EVERYONE HAS TOLD ME. I HAVE A FAMILY OF 5 AND IM SURE THAT IF WE WERE IN A SERIOUS RECK IT WOULD NOT HAVE BEEN GOOD. THIS IS UNACCEPTABLE FOR SUCH A MAJOR MANUFACTURER TO TURN THEIR CHEEK AND ON TOP OF IT MY FAMILY AND THEIR LIVES.
Power train, Sep 17, 2019
TRANSMISSION OVERDRIVE FAILED AT 130K MILES CAUSING TRANSMISSION TO BE REPLACED.
Engine, Sep 12, 2019
2004 FORD F-150 ENGINE IS BAD. THE 5.4 LITER ENGINE. I BOUGHT THIS VEHICLE USED 3 YEARS AGO AND NOW THE ENGINE IS RUINED. MY HUSBAND RESEARCHED AND ALSO CONSULTED WITH SEVERAL MECHANICS AND FOUND THAT THESE ENGINES WERE KNOWN FOR THE CAM PHASERS GOING BAD SO FORD STOPPED PUTTING THIS ENGINE IN THE VEHICLES IN 2007. THE LAST TIME I DROVE THIS VEHICLE AA I WAS MAKING A RIGHT TURN, THE TRUCK CUT OFF ON ME IN THE MIDDLE OF THE ROAD WHICH IS VERY DANGEROUS. WE OWE $8,000 ON THIS FORD WHICH IS NOW NO FOOD. SITS IN OUR YARD. WE WANT ACTION. FORD NEEDS TO STAND BEHIND THEIR PRODUCT.