2004 Ford F-150
Problems, recalls and owner-reported issues
Visibility is the leading concern among 2,036 owner complaints filed for this model year. This is the highest complaint count among 26 F-150 model years with reports.
Of the 2004 reports, 75 involved a crash and 40 involved a fire. 74 people were injured and 6 people died.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleFeb 23, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2004-2006 F-150 PICK UP TRUCKS AS WELL AS CERTAIN MODEL YEAR 2006 LINCOLN MARK LT VEHICLES. IF THE CLOCKSPRING JUMPER WIRE COMES IN CONTACT WITH THE DRIVER SIDE FRONTAL AIR BAG LOWER HORN PLATE, THE WIRE INSULATION MAY BECOME CHAFED, CREATING A POTENTIAL FOR A SHORT CIRCUIT. IF THIS OCCURS THE AIR BAG WARNING LAMP MAY ILLUMINATE INDICATING THAT SERVICE IS REQUIRED.
THE DRIVER SIDE FRONTAL AIR BAG COULD INADVERTENTLY DEPLOY INCREASING THE RISK OF INJURY OR LOSS OF VEHICLE CONTROL IF OCCURRING WHILE IN MOTION.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN/MERCURY DEALER TO HAVE A NEW CLOCKSPRING JUMPER WIRE INSTALLED THAT INCORPORATES A PROTECTIVE MESH COVER. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THIS SAFETY RECALL BEGAN ON SOME VEHICLES IN MARCH 2011. THE RECALL CAMPAIGN ON THE EXPANDED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT MAY 9, 2011. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Campaign 11V107000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsOct 25, 2007
CERTAIN SPYDER HEADLAMP REPLACEMENT ASSEMBLIES SOLD FOR USE ON 2004 THROUGH 2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SPYDER WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2007. OWNERS CAN CONTACT SPYDER AT 866-558-4264.
Campaign 07E089000 on NHTSA.gov
Exterior lighting, headlightsSep 25, 2007
CERTAIN HEADLAMP ASSEMBLIES IMPORTED AND SOLD AS AFTERMARKET EQUIPMENT BY SONAR AUTO PARTS FOR USE ON 2004-2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SONAR WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS CAN CONTACT SONAR AT 866-558-4264.
Campaign 07E080000 on NHTSA.gov
Exterior lighting, headlightsSep 14, 2007
CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. FR390-B001L AND FR390-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE THICKNESS IS UNSTABLE INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
EAGLE EYES WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON NOVEMBER 6, 2007. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.
Campaign 07E075000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Vehicle speed controlAug 3, 2007
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
THIS COULD RESULT IN AN UNDERHOOD FIRE.
DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Campaign 07V336000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Fuel system, gasoline, storage, tank assembly, mountingSep 13, 2004
ON CERTAIN TRUCKS EQUIPPED WITH 4.2L, 4.6L AND 5.4L GASOLINE ENGINES, THE FUEL TANK MAY HAVE A DEPRESSION AT THE SEAM BETWEEN THE TOP AND BOTTOM HALVES OF THE TANK. IF A DEPRESSION IS LARGE ENOUGH, FUEL MAY PERMEATE THE FUEL TANK WALL RESULTING IN A FUEL ODOR, ILLUMINATION, OF THE "SERVICE ENGINE SOON" INDICATOR LIGHT, OR A FUEL LEAK.
FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
DEALERS WILL REPLACE THE FUEL TANK. THE RECALL BEGAN SEPTEMBER 17, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V443000 on NHTSA.gov
Fuel system, gasoline, storage, tank assemblyApr 26, 2004
CERTAIN PICKUP TRUCKS MAY HAVE A FUEL TANK WITH LOCALIZED DEPRESSIONS IN THE FUEL TANK WALL AT THE SEAM BETWEEN TOP AND BOTTOM HALVES OF THE TANK. IF A DEPRESSION IS LARGE ENOUGH, FUEL MAY PERMEATE THE FUEL TANK WALL RESULTING IN A FUEL ODOR, OR THE "SERVICE ENGINE SOON" INDICATOR LIGHT IN THE INSTRUMENT CLUSTER MAY ILLUMINATE.
IF LEFT UNCORRECTED, A FUEL LEAK COULD EVENTUALLY DEVELOP.
DEALERS WILL REPLACE THE FUEL TANK ON THESE VEHICLES. OWNER NOTIFICATION BEGAN ON MAY 6, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-248-0186.
Campaign 04V200000 on NHTSA.gov
Representative owner complaints
2,036 reports, newest first.
Structure, Jul 29, 2019
TL* THE CONTACT OWNS A 2004 FORD F-150. WHILE THE VEHICLE WAS UNDERGOING ROUTINE MAINTENANCE, THE INDEPENDENT MECHANIC DISCOVERED THAT THE FRAME AND CHASSIS OF THE VEHICLE WERE RUSTED AND CORRODED. FLAGSHIP FORD (850 FERN DR, BALDWIN, WI) AND THE MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 138,000.
Engine, Jul 29, 2019
TL* THE CONTACT OWNS A 2004 FORD F-150. WHILE DRIVING APPROXIMATELY 40 MPH, THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE EGR VALVE AND THE FUEL INJECTOR NEEDED TO BE REPLACED. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE CONTACT STATED THAT THE TRANSMISSION AND CHECK ENGINE INDICATORS ILLUMINATED AND WERE REPLACED IN 2018. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 15,000.
Power train, Jul 4, 2019
TAKATA PURCHASE OUR 2004 FORD F150 4X2 SUPERCREW FROM KINGS FORD. WHEN GOING TO TENN. PULL OFF TO GET GAS AND WHEN LEAVING THE GAS STATION MAKING LEFT HAND TURN REAL WHEEL LOCK UP HAD TO BACK UP TO UNLOCK THE REAR WHEEL, CALLED KINGS FORD AND WAS TOLD NOT TO MAKE SHARP TURNS. RETURNED HOME WITH THE REAR END MAKING BANGING NOISES, KING FORD REPAIRED ON AUG 24 2004 REPLACE THE TRACTION LOCK CLUTCH PACK PART#4947 2151 MILES. AFTER THE REPAIR WE NOTICE A WHINING SOUND COMING FROM THE REAR END WAS TOLD TO BRING THE TRUCK BACK, DROPED THE TRUCK OFF ON SEPT 30,2004 AND TO PICK IT BACK UP ON OCT 2, WAS TOLD BY SERVICE REP NO WORK WAS DONE. CALLER SERVICE REP THE FLOWING MONDAY AND WAS TOLD FORD WOULD NOT PAY FOR THE FIX BECAUSE ENGINEERING IS CURRENTLY INVESTIGATION THIS CONDITION AND FOR US TO CALL EVERY MONTH. CALLED FORD MANY TIMES FINELY WAS TOLD TO TAKE OUR TRUCK TO LINCOLN MERCURY GARAGE IN FAIRFIELD, OHIO HAD A PERSON THAT WOULD REBUILD THE REAR AXLE WITH 4205A DIFFERENTIAL CARRIER. ASSEMBLE, FORD DID TAKE CARE OF THIS. AFTER LEAVING THE GARAGE NOTICE A WHINE IN THE REAR TURN AROUND WENT BACK TO THE GARAGE AND WAS TOLD THEY MAY HAVE THE PARTS TO TIGHT AND WILL NEED TO LOOSEN THEN UP. THIS HAS BEEN GOING ON FOR THE LAST 15 YEARS WITH STILL NO FIX WE HAVE NOW 95800 MILES AND WITH ANOTHER FIX FOR $3000.00
Other or unspecified, May 23, 2019
FRAME IS ROTTING HUGE HOLES IN FRAME. VEHICLE HAS LESS THAN 110K MILES
Electrical system, Vehicle speed control, Engine, May 21, 2019
TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED THAT THE VEHICLE STALLED AND THE ACCELERATOR PEDAL HESITATED WHEN DEPRESSED. AS A RESULT, THE VEHICLE MADE AN ABNORMAL PUTTERING SOUND WHILE IN DRIVE. IN ADDITION, THE ELECTRICAL SYSTEM FAILED. THE SPARK PLUGS WERE CHANGED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE SPARK PLUGS SHOULD NOT BE TOUCHED BECAUSE THEY WERE FORD CERTIFIED SPARK PLUGS AND TEAR EASILY. A SPECIAL ONSITE FORD MECHANIC REPAIRED THE SPARK PLUGS. THE ACCELERATOR PEDAL AND STALLING FAILURES WERE NOT REPAIRED. THE MANUFACTURER AND DEALER WERE NOT MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS 233,000.
Suspension, Structure, May 7, 2019
MY 2004 FORD F-150 HAS 61,000 MILES AND NO RUST ON THE OUTSIDE OF THE VEHICLE. I'VE KEPT THE TRUCK WELL MAINTAINED AND IT LOOKS ALMOST NEW. THE FRAME HOWEVER RIGHT WHERE THE REAR LEAF SPRING ATTACHES TO THE FRAME IS RUSTED RIGHT THROUGH. IT IS INCREDIBLE THAT THIS HAS NOT BEEN RECALLED AS OF YET. HOPEFULLY IT WILL BE RECALLED. WHILE DRIVING A PART OF THE EXHAUST HEAT SHIELD FELL ONTO THE DRIVESHAFT. WHEN I WENT TO INSPECT THE UNDERSIDE I FOUND A HOLE IN THE FRAME AND I WAS ABLE TO PUT MY FINGER RIGHT THROUGH IT. *DT CONSUMER STATED ONE IMPORTANT FACT THAT I FORGOT TO ADD TO MY COMPLAINT IS THE SECTION OF THE FRAME THAT RUSTED THROUGH HAS THE EXACT SAME ISSUE IN THE SAME SPOT ON BOTH THE PASSENGER FRAME RAIL AS WELL AS THE DRIVER'S SIDE FRAME RAIL. THE 2004 FORD ESCAPE WAS RECALLED FOR SIMILAR ISSUES THAT YEAR BUT IN THE FRONT OF THE VEHICLE. MY TRUCK HAS ONLY 61,000 MILES ON IT AND FROM FORUMS AND POSTS I'VE READ IT SEEMS TO BE A MAJOR ISSUE FOR THAT YEAR VEHICLE.*JB
Other or unspecified, Apr 13, 2019
PREMATURE FRAME ROT. I TOOK MY TRUCK TO A WELDER AFTER FAILING MY STATE SAFETY INSPECTION BECAUSE OF FRAME ROT. THE WELDER SAID HE HAS WORKED ON HUNDREDS OF FRAMES FOR 2004 F150'S. HE SAID HE STARTED WORKING ON THEM IN 2006. "WORST FRAME EVER," HE SAID. HE COULDN'T BELIEVE THEY WERE NEVER RECALLED BASED ON HOW POORLY THEY WERE DESIGNED.
Other or unspecified, Mar 26, 2019
THE FRAME IS ROTTING ON THE IN SIDE OF THE FRAME
Electrical system, Mar 5, 2019, fire
ELECTRICAL FIRE FRONT PASSENGER SIDE AFTER VEHICLE WAS TURNED OFF WHILE PUMPING GAS.
Structure, Mar 1, 2019
TL* THE CONTACT OWNS A 2004 FORD F-150. WHILE THE VEHICLE WAS BEING SERVICED AT JIM TRENARY FORD (LOCATED AT 255 JOHN DEERE DR, MOSCOW MILLS, MO 63362, (636) 356-9000), THE TECHNICIAN NOTICED THAT THE FRAME WAS SPLIT COMPLETELY IN HALF AND NEEDED TO BE REPLACED. THE TECHNICIAN INFORMED THE CONTACT THAT THE VEHICLE COULD NOT BE DRIVEN. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND DID NOT ASSIST. THE APPROXIMATE FAILURE MILEAGE WAS 200,000.
Other or unspecified, Feb 26, 2019
FRAME OF TRUCK IS COMPLETELY RUSTED ALL THE WAY THRU AT REAR LEAF SPRING ATTACHMENT POINTS. THIS WILL CAUSE A TOTAL FAILURE OF THE REAR SUSPENSION AND DRIVE TRAIN.
Air bags, Dec 14, 2018, crash
ON SEPTEMBER 16, 20018 I WAS INVOLVED IN A TRAFFIC COLLUSION. MY VEHICLE WAS IMPACTED ENOUGH FOR A TOTAL LOSS. MY AIRBAGS NEVER DEPLOYED.IN THE ATTACHED POLICE REPORT I AM VEHICLE 2, I WAS HEADING FROM NORTH TO SOUTH ON OWENSMOUTH STREET, VEHICLE 1 WAS TRAVELING FROM WEST TO EAST ON VICTORY. I WAS WAITING AT A RED LIGHT. ANOTHER VEHICLE (VEHICLE 3)WAS WAITING AT THE RED LIGHT NEXT TO ME. WHEN THE LIGHT TURNED GREEN I BEGAN TO DRIVE AND THE VEHICLE 1 TRAVELING EAST ON VICTORY RAN A RED LIGHT AND SLAMMED INTO THE FRONT OF MY VEHICLE. MY AIRBAG NEVER WENT OFF AND I NOW SUFFER FROM EXTREME PAIN IN MY RIGHT RIB, LEFT HIP, MAJOR HEADACHES AND VERY SEVERE NECK PAIN.
Structure, Nov 2, 2018
THE MAIN FRAME RAILS( THAT RUN FROM FRONT BACK) HAVE AN EXTRA CLADDING THAT IS WELDED TO THE MAIN FRAME RAILS. THIS AREA I AM REFERRING TO IS WHERE A CROSS MEMBER( HOLDING THE WEIGHT OF THE REAR ENGINE AND TRANSMISSION) IS WELDED TO THE CLADDING AND THE TWO MAIN FRAME RAILS. THE CLADDING WAS NOT COMPLETELY WELDED SO WATER HAS GOTTEN BETWEEN THE CLADDING AND MAIN FRAME RAILS CAUSING SEVERE CORROSION AND FAILURE OF THAT CONNECTION POINT. EVEN THOUGH IT COULD BE SAID I TAKE EXTREMELY GOOD CARE OF MY VEHICLES THIS AREA SUDDENLY PRESENTED AS A BULGE AND SUBSEQUENT DISCOVERY OF AN EXTREME FAILURE. THIS CONSISTENT FAILURE HAPPENED ON BOTH FRAME RAIL CONNECTION POINTS. I FEEL THAT THIS FAILURE WILL BE OVERLOOKED AS IT WAS WITH ME ....AND COULD CAUSE FRAME FAILURE CAUSING PUBLIC HARM.
Structure, Oct 21, 2018
SAME DEAL AS EVERY OTHER MEMO I READ. MAJOR HIGHLIGHTING POINTS: - PREMATURE FRAME CORROSION AND RUST. - MECHANIC INFORMED ME THAT THE FRAME ON THE REAR HALF. - RUSTED AND CRACKED UNDER BED AND REAR WHEEL WELLS - FRAME WOULD NO LONGER SUPPORT WEIGHT OF VEHICLE - RUST THRU HOLES AND LONGITUDINAL CRACKS FORMED ON THE BOTTOM AND SIDE FRAME SURFACES AT THE STRESS POINT BEFORE THE REAR WHEEL BEND. - EXTREMELY UNUSUAL, TRUCK HAS BEEN GENERALLY BEEN GARAGE KEPT AND MAINTAINED IN GOOD MECHANICAL CONDITION. - THE EXTERIOR BODY DOES NOT EXHIBITS SPOTS OR SURFACE RUST ON VISIBLE BODY PANELS. - NO EVIDENT SIGNS OF RUST OR DEGRADATION OF STRUCTURE. - METICULOUSLY MAINTAINED VEHICLE OTHERWISE. (NEW TRANSMISSION, DRIVE SHAFT, ENGINE RETIMED, SPRAY BED LINER, ETC.) - CATASTROPHIC FAILURE OF THE FRAME STRUCTURE WAS IMMINENT AND THAT THE VEHICLE WAS NO LONGER SAFE TO DRIVE. - CANNOT BE REPAIRED AND IS UNSAFE. - CANNOT PASS A STATE SAFETY INSPECTION. - CANNOT EVEN BE PUT ON A LIFT BECAUSE IT HAS NO STRUCTURAL STRENGTH.
Vehicle speed control, Oct 21, 2018
THIS 2004 FORD F 150 THAT I HAVE DRIVEN SINCE NEW AS I AM ABOUT TO MERGE WITH TRAFFIC TO GET ON THE XWAY BEGAN TO REV UP ENGINE . I REMOVE MY FOOT AWAY FROM THE GAS TO SEE THAT THE %$#&* IS GOING ON. PAT THE GAS THINKING " STUCK" STILL REVING UP NOW I AM OVER 60. I USE MY HEELS TO SEE IF MAT OR SOME OBJECT MAY HAVE FALL DOWN. NO ! I PULL OVER IN BETWEEN SOME YELLOW CONE ..WITH ALL THE STRENGTH I COULD PUT ON BRAKES. WITH FOOT STILL ON BRAKE AND ENGINE RPM IN RED I AM THINKING " WHAT THE NEXT THING TO DO " THIS TRUCK IS NOT COMING DOWN TO IDLING . COME TO ME " FOOL PUT IN NEUTRAL ". I DID . STILL RPM IN RED. I AM THINKING " TURN OFF IGNITION" . BUT AT HE SAME TIME THINKING CAN YOU . IT WORKED. I PLACED THE TRUCK IN PARK THEN CRANKED UP AND DROVE OF BUT I CAN NOT WAIT TO HAVE THIS F 150 TAKEN IN. I FLY A TURBO PROP AND AS A STUDENT PILOT I NEVER WISH THIS ON ANY ONE IN AIR OR ON THE GROUND....ACCIDENT WAITING TO HAPPEN !! I AM THINKING BACK SEVERAL DECADES AGO SUCH WAS BIG IN THE NEWS. PERSONAL WITH A 1983 380 SL TOOK ME THROUGH THIS BUT THE ACCELERATION WAS MUCH SLOWER BUT NEVER AT SUCH A FRIGHTING SPEED
Other or unspecified, Oct 15, 2018
TRAILER HITCH RUSTED AWAY AND BROKE TOWING A 26 FT RV TRAILER.TRUCK HAS 140,000 MILES AND IS IN GOOD SHAPE NO BODY RUST.HITCH IS VERY UNSAFE AND COULD HAVE BEEN VERY BAD IF IT BROKE GOING DOWN THE HIGHWAY.I HAVE READ OTHER PEOPLE HAVING THE SAME PROBLEM.I WILL BE CHECKING WITH FORD ABOUT THIS BUT I THINK A RECALL SHOULD BE LOOKED INTO ALSO SEE WWW.CAR COMPLAINS.COM,2005 F150 TRAILER HITCH PROBLEMS
Air bags, Structure, Sep 28, 2018, crash
THIS A.M. AS I ENTERED MY DRIVEWAY, A NEIGHBOR STOPPED ME TO TALK. I STOPPED AND ROLLED DOWN MY WINDOW. HE WENT ON AND ON. SUDDENLY, MY TRUCK ACCELERATED AT FULL THROTTLE TOWARD MY GARAGE 70 FEET AWAY. MY FOOT WAS ON THE BRAKE TO NO AVAIL. I TURNED SLIGHTLY TO THE RIGHT AND HIT THE CORNER OF THE GARAGE. THE AIR BAGS DEPLOYED. MY GLASSES WENT FLYING. I WAS NOT HURT. A TREE HAD SOFTEN THE IMPACT. I WAS SEVERELY SHAKEN. MY BLOOD PRESSURE WAS ELEVATED. FORD MOTOR COMPANY IS NOT HELPFUL. MY INSURANCE COMPANY, GEICO, IS HANDLING THE ISSUE.
Steering, Suspension, Sep 28, 2018
MY VEHICLE HAS DEVELOPED WHAT I WOULD REFER TO AS A DEATH WOBBLE. AT SPEEDS FROM 40 TO 55 MPG THE FRONT OF THE TRICK SHAKES AS THOUGH IT'S GOING TO RATTLE APART. THIS IS CLEARLY A FORD ISSUE AND IS NOW GETTING A GOOD SHARE OF ATTENTION ON YOU TUBE. THERE ARE A LOT OF US OUT THERE WHO HAVE INHERITATED THIS FROM FORD WHO IS IN CONSTANT DENIAL OF IT'S REFUSAL TO ADDRESS AND TAKE CORRECTIVE ACTION TO REPAIR THE BUCKLEING OF THE FRONT END. HOW MANY MORE ACCIDENTS NEED TO HAPPEN OR FORD'S DILIGENCE ON PREVENTITIVE MEASURES MAY JUST SAVE LIVES AND CUSTOMERS. PLEASE HELP IN RESOLVING THIS MANUFACTURING ISSUE.
Structure, Sep 5, 2018
THE TRUCK WAS TAKEN INTO MECHANIC. THE MECHANIC PUT IT UP, AND SAW THAT ENTIRE FRAME WAS RUSTED. IT IS NOT FIXABLE. CONTACTED JOHN LANCE FORD, WHERE IT WAS PURCHASED. THEY ADVISED TO TAKE TRUCK TO NEAREST FORD DEALER. WE TOOK IT TO FORD IN PORT CLINTON, OHIO. THE SERVICE MANAGER TOOK PICTURES AND SENT IT TO CORPORATE OFFICE. IT HAS BEEN LONGER THAN 6 WEEKS, AND HAVE NOT HEARD BACK.
Service brakes, Aug 22, 2018
BRAKE MASTER CYLINDER LOST FLUID. LEAK WAS INTO THE BRAKE VACUUM BOOSTER. COULD CAUSE LOSS OF BRAKES IF IT OCCURRED WHILE DRIVING.
Other or unspecified, Aug 5, 2018
THE FRAME IS TOTALLY RUSTED THROUGH.
Service brakes, Aug 3, 2018
BRAKE PEDAL FADES TO FLOOR REPLACED ABS SAME PROBLEM. NOTICED A LOT OF F150 HAVING BRAKE PROBLEMS. FORD SHOULD STEP UP SAY WE HAVE A PROBLEM. FORDMAN BUT GETTING PISSED OFF. MAY TRY TOYOTA.
Structure, Jun 27, 2018
TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT LOOKED UNDERNEATH THE VEHICLE AND NOTICED THAT THE ENTIRE BOTTOM OF THE FRAME WAS RUSTED. THE DEALER (LIBERTY FORD, 9311 LIBERTY RD, RANDALLSTOWN, MD 21133, 410-504-2897) WAS CONTACTED AND STATED THAT THE FRAMES WERE ABSOLUTE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 78,000.
Power train, Jun 22, 2018
MY 2004 F-150 SHIFT CABLE BROKE AS I ATTEMPTED TO PUT IT IN PARK. THIS RENDERED THE VEHICLE UNABLE TO BE PUT IN PARK AND IT ROLLED BACKWARDS. THE REASON IT BROKE WAS BECAUSE OF IT RESTING AGAINST THE BOTTOM OF THE EXHAUST MANIFOLD WHERE IT JOINS TO THE WYE PIPE ON THE DRIVER SIDE. IT BURNT THE CABLE CAUSING IT TO BREAK. THE NEXT MODEL YEAR IN 2005 THIS WAS CHANGED AS FORD REDESIGNED AND RELOCATED IT TO EXIT IN A COMPLETELY SPOT. THE HOLE THAT IT EXITS THRU IN 2004 IS PLUGGED OFF IN THE 2005 MODEL. IT WOULD SEEM THAT THIS WAS DONE DUE TO MULTIPLE INSTANCES OF WARRANTY CLAIMS AND POSSIBLE LAWSUITS ARRISING FROM THIS DANGEROUS DESIGN.
Service brakes, Jun 6, 2018
WHEN DRIVING ABS LIGHT COMES ON AND THE BRAKES WON'T WORK PROPERLY