2004 Ford F-150
Problems, recalls and owner-reported issues
Visibility is the leading concern among 2,036 owner complaints filed for this model year. This is the highest complaint count among 26 F-150 model years with reports.
Of the 2004 reports, 75 involved a crash and 40 involved a fire. 74 people were injured and 6 people died.
What owners report most often
Recalls and investigations
Fuel system, gasoline, storage, tank assembly, mountingJul 29, 2011
FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.
AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD'S RECALL CAMPAIGN NUMBER IS 11S21
Campaign 11V385000 on NHTSA.gov
Air bags, frontal, driver side, inflator moduleFeb 23, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2004-2006 F-150 PICK UP TRUCKS AS WELL AS CERTAIN MODEL YEAR 2006 LINCOLN MARK LT VEHICLES. IF THE CLOCKSPRING JUMPER WIRE COMES IN CONTACT WITH THE DRIVER SIDE FRONTAL AIR BAG LOWER HORN PLATE, THE WIRE INSULATION MAY BECOME CHAFED, CREATING A POTENTIAL FOR A SHORT CIRCUIT. IF THIS OCCURS THE AIR BAG WARNING LAMP MAY ILLUMINATE INDICATING THAT SERVICE IS REQUIRED.
THE DRIVER SIDE FRONTAL AIR BAG COULD INADVERTENTLY DEPLOY INCREASING THE RISK OF INJURY OR LOSS OF VEHICLE CONTROL IF OCCURRING WHILE IN MOTION.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN/MERCURY DEALER TO HAVE A NEW CLOCKSPRING JUMPER WIRE INSTALLED THAT INCORPORATES A PROTECTIVE MESH COVER. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THIS SAFETY RECALL BEGAN ON SOME VEHICLES IN MARCH 2011. THE RECALL CAMPAIGN ON THE EXPANDED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT MAY 9, 2011. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Campaign 11V107000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Exterior lighting, headlightsOct 25, 2007
CERTAIN SPYDER HEADLAMP REPLACEMENT ASSEMBLIES SOLD FOR USE ON 2004 THROUGH 2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SPYDER WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2007. OWNERS CAN CONTACT SPYDER AT 866-558-4264.
Campaign 07E089000 on NHTSA.gov
Exterior lighting, headlightsSep 25, 2007
CERTAIN HEADLAMP ASSEMBLIES IMPORTED AND SOLD AS AFTERMARKET EQUIPMENT BY SONAR AUTO PARTS FOR USE ON 2004-2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SONAR WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS CAN CONTACT SONAR AT 866-558-4264.
Campaign 07E080000 on NHTSA.gov
Exterior lighting, headlightsSep 14, 2007
CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. FR390-B001L AND FR390-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE THICKNESS IS UNSTABLE INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
EAGLE EYES WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON NOVEMBER 6, 2007. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.
Campaign 07E075000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Vehicle speed controlAug 3, 2007
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
THIS COULD RESULT IN AN UNDERHOOD FIRE.
DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Campaign 07V336000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsJun 12, 2006
CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.
Campaign 06E052000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Fuel system, gasoline, storage, tank assembly, mountingSep 13, 2004
ON CERTAIN TRUCKS EQUIPPED WITH 4.2L, 4.6L AND 5.4L GASOLINE ENGINES, THE FUEL TANK MAY HAVE A DEPRESSION AT THE SEAM BETWEEN THE TOP AND BOTTOM HALVES OF THE TANK. IF A DEPRESSION IS LARGE ENOUGH, FUEL MAY PERMEATE THE FUEL TANK WALL RESULTING IN A FUEL ODOR, ILLUMINATION, OF THE "SERVICE ENGINE SOON" INDICATOR LIGHT, OR A FUEL LEAK.
FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
DEALERS WILL REPLACE THE FUEL TANK. THE RECALL BEGAN SEPTEMBER 17, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V443000 on NHTSA.gov
Fuel system, gasoline, storage, tank assemblyApr 26, 2004
CERTAIN PICKUP TRUCKS MAY HAVE A FUEL TANK WITH LOCALIZED DEPRESSIONS IN THE FUEL TANK WALL AT THE SEAM BETWEEN TOP AND BOTTOM HALVES OF THE TANK. IF A DEPRESSION IS LARGE ENOUGH, FUEL MAY PERMEATE THE FUEL TANK WALL RESULTING IN A FUEL ODOR, OR THE "SERVICE ENGINE SOON" INDICATOR LIGHT IN THE INSTRUMENT CLUSTER MAY ILLUMINATE.
IF LEFT UNCORRECTED, A FUEL LEAK COULD EVENTUALLY DEVELOP.
DEALERS WILL REPLACE THE FUEL TANK ON THESE VEHICLES. OWNER NOTIFICATION BEGAN ON MAY 6, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-248-0186.
Campaign 04V200000 on NHTSA.gov
Representative owner complaints
2,036 reports, newest first.
Visibility, Apr 28, 2009
I HAVE A 2004 F-150. THE WINDOW REGULATOR BROKE AND THE WINDOW WILL NOT GO UP. THIS IS THE SECOND TIME THIS HAS HAPPENED. THE FIRST TIME MY TRUCK WAS PARKED IN A PARKING LOT NOT BEING USED WHILE I WAS IN AFGHANISTAN. IT WAS TAKEN TO THE LOCAL LOUISIANA FORD DEALERSHIP WHERE THEY SAID IT HAPPENED ALL THE TIME. I WAS CHARGED AROUND $400 FOR THE REPAIR. ABOUT 4 MONTHS LATER THE SAME PROBLEM HAPPENED WHILE MY PARENTS WERE DRIVING WITH MY 2 YEAR OLD DAUGHTER IN THE TRUCK. I ONCE AGAIN CONTACTED THE LOCAL OHIO FORD DEALERSHIP AND THE REPAIR COST IS GOING TO BE ABOUT THE SAME AS LAST TIME. I TALKED WITH THE SERVICE MANAGER WHO GAVE ME THE FORD CUSTOMER CARE NUMBER. FORD DOES NOT SEEM TO CARE THAT THIS PROBLEM IS HAPPENING. THEY TOLD ME THAT THERE WAS NOTHING THEY COULD DO OTHER THAN DOCUMENT MY CONCERN. I WAS GIVEN THIS WEBSITE TO FILE A FORMAL COMPLAINT, AND AM AMAZED AT HOW MANY OTHER PEOPLE ARE HAVING THE SAME PROBLEM. I HAVE CONTACTED THE FEDERAL TRADE COMMISSION AND FILED A COMPLAINT WITH THEM AS WELL AS NOTIFYING MY STATE ATTORNEY GENERAL. A ONETIME PROBLEM IS UNDERSTANDABLE BUT FOR THIS TO HAPPEN TWICE TO MY TRUCK AND SEEING HOW MANY OTHER PEOPLE HAVE HAD THE SAME PROBLEM IS PATHETIC. I HOPE THE NHTSA INSPECTORS SEE HOW MANY PEOPLE ARE HAVING THIS PROBLEM AND FORCE FORD TO CORRECT IT. PLEASE HAVE FORD RECALL THIS PART BEFORE SOMEONE GETS HURT, OR A TRUCK BEING STOLEN OVER A FAULTY PIECE OF PLASTIC. THANKS *TR
Visibility, Apr 28, 2009
2004 FORD F150 WINDOW TRACK FAILURE. THE DRIVER'S SIDE FRONT WINDOW REGULATOR/TRACK BROKE CAUSING THE WINDOW TO FALL INTO THE DOOR. WITHIN 6 MONTHS OF THAT TIME, THE DRIVER'S SIDE BACK WINDOW FAILED IN THE SAME MANNER, LESS THEN 6 MONTHS LATER THE PASSENGER SIDE FRONT DOOR WINDOW FAILED AS THE PREVIOUS 2 WINDOWS AND WITHIN ANOTHER 3 MONTHS, THE PASSENGER SIDE BACK DOOR WINDOW FAILED IN THE SAME MANNER AS THE PRIOR THREE WINDOWS. OBVIOUSLY, THIS IS THE FOURTH WINDOW TRACK THAT HAS FAILED. EACH TIME THE FAILURE HAPPENED WHILE DRIVING. THE ONLY ALTERNATIVE OFFER BY FORD MOTOR CO. WAS TO PAY A DEALERSHIP TO REPLACE THE WINDOW TRACK. *TR
Visibility, Apr 27, 2009
I PURCHASED MY TRUCK USED FROM THE LOCAL FORD DEALERSHIP WHEN IT WAS THREE YEARS OLD, IT WAS A CERTIFIED USED VEHICLE. ROUGHLY ONE YEAR LATER THE DRIVER WINDOW FELL INTO THE DOOR AND WHEN I PRESSED THE SWITCH TO PUT IT BACK UP, I HEARD A GRINDING NOISE COME FROM THE ELECTRIC MOTOR AND THE WINDOW DID NOT BUDGE. IT COST ME ROUGHLY 400.00 DOLLARS FROM FORD TO REPLACE IT. THIS PAST WEEKEND I WAS DRIVING ALONG AND THE REAR PASSENGER WINDOW DID THE SAME. I HAD MY DOG IN THE BACK SEAT OF MY TRUCK AND WHEN THE WINDOW FELL MY DOG WENT STRAIGHT FOR THE WINDOW. LUCKILY I GRABBED HIM BEFORE HE GOT ANY CLOSER TO IT. THANK GOODNESS IT WAS NOT A SMALL CHILD. THIS IS A HUGE SAFETY FACTOR AND FORD SHOULD STAND BEHIND THEIR PRODUCT BETTER AND RECALL THESE PROBLEMS BECAUSE APPARENTLY THIS IS A BIG PROBLEM. IF A CHILD GETS HURT BECAUSE OF THIS PROBLEM THE LAW SUIT WILL COST MUCH MORE THAN IF FORD JUST RECALLS ALL THE PROBLEM. THANKS. *TR
Visibility, Apr 26, 2009
WE HAVE A 2004 F150 WITH 30,000 MILES ON IT. OUR FRONT PASSENGER WINDOW FELL DOWN WHILE WE HAD IT PARKED AT THE AIRPORT FOR 3 DAYS SO NO ONE WAS TOUCHING IT AND IT WAS CLOSED. WE COULD NOT PICK IT UP SO WHEN WE GOT HOME WE GOT THE WINDOW UP. WE CAN NOT ROLL THIS WINDOW DOWN AND HAVE IT UP WITH TAPE. WE WERE TOLD THAT IT IS NOT COVERED AND HAS NOT BEEN RECALLED BUT THERE HAVE BEEN MANY COMPLAINTS ACCORDING TO THE WEBSITE AUTOBEEF.COM. WE HAVE NOT FIXED THIS PROBLEM BECAUSE IT IS GOING TO COST US $400 AND WE DO NOT HAVE THAT KIND OF $ TO FIX SOMETHING FORD IS RESPONSIBLE FOR. *TR
Visibility, Apr 25, 2009
APRIL 23 2009 DRIVER WINDOW WENT DOWN WITH OUT WARNING WHILE DRIVING MY 2004 FORD F150 SUPER CAB WITH 8? BED WITH 40000 MILES ON IT. THE WINDOW REGULATORS PLASTIC CABLE RETAINER BROKE RELEASING THE CABLE AND THE WINDOW. WHILE SEARCHING THE INTERNET I FOUND OUT THAT THIS IS A COMMON PROBLEM AND THAT FORD HAS CHANGED THE PART AND PART NUMBER 3 TIMES TRYING TO FIX THE PROBLEM. THIS WAS A GREAT DISTRACTION WHILE DRIVING AND COULD HAVE BEEN A SAFETY ISSUE HAD PETS BEEN ON BOARD OR IF ITEMS HAD BLOWN OUT THE WINDOW. *TR
Visibility, Apr 23, 2009
PASSENGER WINDOW REGULATOR FAILED FOR THE SECOND TIME, WINDOW SLAMMED AND ALMOST CAUSED AN ACCIDENT WHILE DRIVING. DRIVERS ONE REPLACED 5 MONTHS AGO. NOW BEING TOLD THAT THE REAR TWO ARE "GOING OUT" AS WELL AND NEED TO BE REPLACED. DEALERSHIP RECOGNIZES THAT THERE IS A PROBLEM WITH THESE REGULATORS, CALLED FORD CUSTOMER RELATIONSHIP CENTER AND ALL THEY WOULD DO WAS OFFER ME A $750 GIFT CARD IF I AGREE TO BUY A NEW FORD TRUCK IN THE NEXT 30 DAYS. ARE THEY KIDDING!!! I HAVE ALWAYS OWNED FORD TRUCKS, BUT AM GOING TO LOOK AT THE NEW TUNDRA NOW AS I CAN SEE THAT FORD DOES NOT STAND BEHIND THEIR PRODUCTS, SO MUCH FOR BEING BUILT FORD TOUGH..... *TR
Visibility, Apr 22, 2009
I HAVE A 2004 FORD F150 AND I HAVE HAD NOTHING BUT PROBLEMS WITH THE WINDOWS. I HAVE HAD 3 OF MY WINDOW REGULATORS GO OUT ON THIS TRUCK AND ITS ONLY 5 YEARS OLD. I FEEL THIS A MAJOR PROBLEM WITH THESE TRUCKS SINCE I KNOW I AM NOT THE ONLY PERSON WHO HAS HAD THIS SAME PROBLEM. FIRST I HEAR A LOUD BANG IN THE DOOR (EVEN WHEN I'M NOT OPERATING THE WINDOW) AND THEN THE WINDOW DROPS. THIS IS A SAFETY CONCERN SINCE I HAVE CHILDREN, AND FOR SAFETY OF THE TRUCK ITSELF. I'M AFRAID THAT IF IM AT WORK OR SCHOOL THAT THIS WILL HAPPEN AND THE TRUCK WILL BE VANDALIZED OR STOLEN. *TR
Visibility, Apr 21, 2009
FORD LARIAT F150 WHILE VISITING A FRIEND ON APRIL 20TH, 2009 , MY TRUCK WAS PARKED IN DRIVEWAY, WINDOWS ALL UP & DOORS LOCKED. WHEN I GOT READY TO LEAVE, DRIVER WINDOW WAS DOWN AND IT WOULD NOT GO BACK UP. FORD DEALERS ALREADY CLOSED , I DROVE HOME. HAVE SEARCHED SEVERAL SITES TO SEE IF THERE WERE OTHERS WITH THIS PROBLEM OR COMPLAINTS OF THIS. I WAS SHOCKED THERE WERE SO MANY 136 COMPLAINTS HERE SITE #1: HTTP://WWW.CARCOMPLAINTS.COM/FORD/F-150/2004/WINDOWS_WINDSHIELD/WINDOW_DOES_NOT_ROLL_UP.SHTML SITE #2 : :HTTP://WWW.FORDF150.NET/FORUMS/VIEWTOPIC.PHP?T=47037 SITE # 3 : HTTP://WWW.MYCARSTATS.COM/SAFETYSTATION.ASP?CARS=1338942 WHY SO MANY COMPLAINTS BUT YET FORD DOESN'T RECOGNIZED IT. WE HAVE BEEN A LONG TIME FORD OWNER ,BUT THIS PROBLEM MAKES ME THINK I DON'T WANT ANOTHER FORD. HAD OTHER WINDOW PROBLEM WITH REAR SLIDING WINDOW NOT WORKING,BUT ALWAYS WORKED WHEN TOOK IN TO DEALER WHILE UNDER WARRANTY. DOESN'T WORK AT ALL NOW. WINDOWS SEEM TO BE A BIG PROBLEM FOR FORD ON THEIR TRUCKS. WHAT WILL IT TAKE A WINDOW DROPPING DOWN AND SHATTERING AND SOMEONE GETTING HURT FROM IT OR CAUSE A SERIOUS ACCIDENT .ALSO DEFEATS YOUR PURPOSE OF LOCKING IT UP, IF THE WINDOWS ARE GOING KEEP FALLING DOWN. I WILL BE SURPRISED IF I GET ANY KIND OF RESPONSE TO THIS . I FIGURE, LIKE MOST , IT WILL BE LOOKED AT THEN THROWN OUT. WILL HAVE TO TAKE TO THE DEALER IN THE MORNING. I FEEL FORD SHOULD BE RESPONSIBLE FOR THIS ,SINCE IT HAS BEEN GOING ON FOR SEVERAL YEARS WITH THIS YEAR OF TRUCK. *TR
Visibility, Apr 21, 2009
THIS IS THE FOURTH TIME I HAVE HAD TO REPLACE THE WINDOW REGULATOR ON MY TRUCK. ITS A MAJOR PAIN WHEN IT DOES HAPPEN, AND IT NEVER FAILS TO HAPPEN AT THE WORSE TIMES. ALL FOUR TIMES (ONCE FOR EACH OF THE FOUR WINDOWS) IT HAS HAPPENED WHILE I AM JUST DRIVING ALONG AND THE WINDOW JUST FALLS INTO THE DOOR. IT IS REALLY EXPENSIVE TO FIX AT THE DEALER ($400). *TR
Service brakes, Hydraulic, Wheels, Apr 21, 2009
SEVERE VIBRATION WHILE BRAKING FROM ABOVE 40M/HR. DEALER HAD TO REPLACE BOTH FRONT ROTORS AND MACHINED BOTH REAR ROTORS FOR WARPING. ROTOR WORE OFF BEFORE THE ORIGINAL BRAEK PADS. DEALER SAYS ITS TYPICAL BUT I SUSPECT POOR QUALITY AS I AM A CAREFUL DRIVER. *TR
Visibility, Apr 19, 2009
DRIVERS SIDE WINDOW FELL INTO DOOR AFTER A LOUD POP AND CRACKING SOUND. WINDOW WILL NO LONGER ENGAGE WITH POWER SWITCH. *TR
Visibility, Apr 19, 2009
DRIVER SIDE WINDOW MADE A POP WHILE GOING DOWN, THE WINDOW STOPPED ABOUT HALFWAY DOWN AND THEN WOULD NOT GO UP OR DOWN, THE WINDOW MOTOR STILL OPERATES, AND THE WINDOW IS IN THE TRACK. THE OPERATION CABLE THE MOVES THE WINDOW UP AND DOWN BROKE OFF AT ITS CONNECTOR, RESULTING IN THE UNIT NEEDING TO BE REPLACE. THIS IS A FREQUENT COMPLAINT ON THESE VEHICLES. *TR
Visibility, Apr 17, 2009
LOUD POP NOISE FROM DRIVER WINDOW. WINDOW NOT WANTING TO ROLL BACK DOWN. TOOK DOOR PANEL OFF CAN SEE THAT THE CABLE IN THERE IS BROKEN MOTOR STILL SPINS AND GLASS IS ATTACHED TO THE TRACK SYSTEM NEEDS REPLACEMENT CABLES IF POSSIBLE OR NEW REGULATOR SOMEWHERE AROUND THE $300 PRICE RANGE TO FIX. *TR
Visibility, Apr 16, 2009
MY 2004 FORD F-150 WITH ~15000 MILES HAD THE PASSENGER WINDOW "POP" AND FALL INSIDE THE DOOR. WHILE FIXING I FOUND SEVERAL FORUMS COMPLAINING ABOUT HOW COMMON THIS PROBLEM IS AND INSISTING THAT IT IS UNACCEPTABLE. I AGREE, SO I AM ADDING MY VOICE TO THE LIST OF PEOPLE UNHAPPY WITH THE DEFECT. *TR
Power train, Visibility, Apr 13, 2009
I OWN A 2004 FORD F-150 4 DOOR. I HAVE HAD TO REPLACE ALL FOUR POWER WINDOW REGULATORS. TWO WERE STILL UNDER WARRANTY AND THE OTHER TWO CAME OUT OF MY POCKET. THE DEALERSHIP IS AWARE OF THE PROBLEM BUT NOTHING HAS BEEN DONE TO HELP THE CUSTOMER. ALSO, THE TRANSMISSION HAS A KICKING PROBLEM AT CERTAIN SPEEDS. *TR
Visibility, Apr 13, 2009
ALL FOUR WINDOWS ON OUR TRUCK HAVE HAD A MOTOR PROBLEM, WINDOWS GO DOWN AND DON'T COME DOWN, THE FIRST TWO WERE UNDER WARRANTY AND THE LAST ONE WAS NOT AND IT'S VERY EXPENSIVE AND NOW AS OD 4/13/09 WE HAVE HAD THE FOURTH ONE GO DOWN AND GET STUCK. NOW WE HAVE TO TAKE THE TRUCK IN YET AGAIN AND IT'S NOT UNDER WARRANTY BUT WE ONLY HAVE 45,000 MILES ON IT. *TR
Visibility, Apr 10, 2009
2004 FORD F150, 40K MILES. DRIVING DOWN ROAD, HEAR LOUD POP, THEN THE DRIVERS SIDE WINDOW FELL INTO THE DOOR. LUCKILY GLASS DID NOT SHATTER. DETERMINED THAT WINDOW REGULATOR HAD FAILED CAUSING THE PROBLEM (LOUD POP THEN WINDOW FALLING INTO DOOR). SUBSEQUENT SEARCH OF THIS FAILURE INDICATED IT IS QUITE COMMON. FEDERAL GOVERNMENT SHOULD REQUIRE FORD TO ISSUE A RECALL TO PROACTIVELY REPLACE THESE DEFECTIVE PARTS. COULD CAUSE DRIVER TO SUDDENLY LOSE CONTROL OF VEHICLE. *TR
Visibility, Apr 9, 2009
REPEATED FAILURE OF WINDOW REGULATOR IN LATE MODEL F-150 (2004). I HAVE HEARD MANY OTHER WITH SAME PROBLEM. MY WINDOW FELL DOWN INSIDE THE DOOR WHILE DRIVING, WHICH STARTLED ME ALMOST CAUSING A SERIOUS ACCIDENT. *TR
Engine and engine cooling, Apr 9, 2009
FORD F150 SPARK PLUGS BREAKING. *TR
Visibility, Apr 9, 2009
I BELIEVE THAT THE FORD REGULATOR IS A VERY BIG SAFETY ISSUE. A WINDOW THAT CAN JUST FALL DOWN INTO THE BOTTOM OF THE DOOR WITH NO WARNING. HERE IS WHY I FIND IT A SAFETY ISSUE. I LIVE IN NEBRASKA AND I DEAL WITH SOME PRETTY NASTY WEATHER . MY WIFE AND I ARE EXPECTING OUR FIST CHILD AND IF WE GO SOMEWHERE IN THE MIDDLE OF WINTER AND THE WINDOW FALLS DOWN IN A SNOW STORM THIS COULD CAUSE A THREAT TO MY NEW BORN. I BELIEVE FORD MOTOR COMPANY NEEDS TO STEP UP TO THE PLATE AND GET THIS RESOLVED. I AM IN THE MILITARY AND HAVE SERVER OVER SEAS, I AM NOT A BIG FAN OF PUTTING MY FAMILY IN DANGER. THIS IS A PROBLEM THAT NEEDS TO BE RESOLVED IT COULD BUT MY FAMILY AT RISK. *TR
Visibility, Apr 7, 2009, crash
I WAS DRIVING AND WENT TO ROLL DOWN MY DRIVER SIDE WINDOW ON THE WAY HOME FROM WORK AND THE WHOLE WINDOW JUST DROPPED INTO MY DOOR NEVER TO BE SEEN AGAIN. TO MY LUCK, IT BEGAN TO RAIN.....BADLY. AS IF GETTING WET WASN'T ENOUGH, EVERY TIME A VEHICLE WOULD PASS ME GOING THE OTHER DIRECTION AT AN INTERSECTION I WOULD GET SPLASHED WITH NASTY ROAD WATER IN MY FACE!!! IT SPRAYED ME SO BAD ONCE WHEN A VEHICLE PASSED ME THAT I HIT THE CURB AND COULD HAVE EASILY HAD A HORRIBLE ACCIDENT OR WORSE, KILLED SOMEONE ON A CURB!!! THIS COST ME OVER $300 TO HAVE THE WHOLE MOTOR ASSEMBLY REPLACED IN THE DOOR AND SOUNDS LIKE IT IS ALL TOO COMMON DUE TO A POORLY DESIGNED PLASTIC TAB THAT BREAKS. WHAT WILL IT TAKE FOR A RECALL ON THIS? SOME POOR PERSONS' CHILD GETTING HIT AT A BUS STOP DURING A RAIN STORM? CAN'T WAIT FOR IT TO HAPPEN AGAIN. *TR
Visibility, Apr 6, 2009
THE DRIVER'S POWER WINDOW IN MY 2004 FORD F-150 SUDDENLY DROPPED DOWN INTO THE DOOR AND WILL NOT CLOSE. THIS HAPPENED WHILE THE TRUCK WAS PARKED IN MY DRIVEWAY. HAD THIS HAPPENED, WHILE ON THE ROAD, IT COULD HAVE WELL CAUSED AN ACCIDENT - ESPECIALLY IN INCLEMENT WEATHER. WHEN USING THE WINDOW CONTROL, THE WINDOW MOTOR RUNS; HOWEVER, THE WINDOW DOESN'T EMERGE FROM THE DOOR. THIS IS A KNOWN AND DANGEROUS DEFECT IN 2004 FORD F-150'S, YET FORD REFUSES TO ISSUE A RECALL. INSTEAD, FORD CHARGES $400 FOR REPAIRS, USING THE SAME DEFECTIVE PARTS! FORD MUST BE HELD ACCOUNTABLE FOR THIS! *TR
Visibility, Apr 6, 2009
I OWN A 2004 FORD F150 AND ON DEC 21, 2008 MY RF WINDOW CAME CRASHING DOWN AND SCARED ME HALF TO DEATH. THE WINDOW WAS ROLLED UP AND JUST FELL INTO THE DOOR MAKING A LOUD NOISE. I WAS AN HOUR AND A HALF AWAY FROM HOME TRAVELING ON A 2 LANE HIGHWAY THAT IS VERY HILLY, CURVY AND USUALLY WINDY. IT IS ONE OF 2 HWYS THAT LEAD IN AND OUT OF A VERY POPULAR OFFROAD AREA CALLED OCOTILLO WELLS. MOST OF THE TRAFFIC ON THAT ROAD CONSISTS OF BIG TRUCKS WITH TRAILERS FULL OF QUADS, MOTORCYCLES, BUGGIES AND FAMILY MEMBERS. I SERIOUSLY ALMOST FLEW OFF THE ROAD BECAUSE I WAS SO SHAKEN FOR THAT MOMENT. IT WAS SO SUDDEN AND LOUD THAT I THOUGHT MY WINDOW HAD BEEN SHOT OUT. PEOPLE DO HUNT IN THE AREA SO NOT A FAR FETCHED CONCLUSION. I GOT HOME SAFELY AND HAD THE WINDOW REPAIRED THE NEXT DAY. YESTERDAY, APRIL 5, 2009 IT HAPPENED AGAIN. I WAS WITH MY PREGNANT WIFE AND 2 DOGS ON OUR WAY HOME. THIS TIME IT WAS THE RR WINDOW. IT CAME CRASHING DOWN IN THE SAME MANNER AND SCARED US HALF TO DEATH, AGAIN. THIS TIME ONE OF MY DOGS NEARLY JUMPED IN MY LAP MAKING IT DIFFICULT TO DRIVE. THE REMAINDER OF THE RIDE CONSISTED OF MY WIFE TRYING TO KEEP ONE OF MY DOGS FROM ALMOST FALLING OUT THE WINDOW. NOTHING LIKE WIND IN THE FACE FOR SOME DOGS!!! MY TRUCK IS IN THE SHOP AGAIN TODAY WITH THIS SAME REPAIR/SAFETY ISSUE. I'M WRITING THIS BECAUSE I HAVE READ NUMEROUS ACCOUNTS ON THE INTERNET REGARDING THIS SAME ISSUE. I'M VERY FRUSTRATED THAT THIS PROBLEM CAN ACTUALLY CAUSE SOMEONE TO LOSE CONTROL OF THEIR VEHICLE AND CRASH. I KNOW THIS FIRST HAND BECAUSE IT HAS HAPPENED TO ME TWICE SINCE DEC 21, 2008. I STILL HAVE 2 MORE WINDOWS THAT HAVE NOT BROKEN AND HAVE NO IDEA WHEN THEY WILL COME CRASHING DOWN. WILL MY FAMILY AND I BE STATISTICS BECAUSE OF AND REALLY CHEAP PART??? OR WILL I KILL SOMEONE'S FAMILY??? I AM ALSO NOT PLEASED WITH THE FACT THAT THEY ARE CHARGING ALL OF US ALMOST $400 PER WINDOW TO FIX THE PROBLEM. FORD SHOULD BE FIXING THIS PROBLEM. *TR A VERY CONCERNED, JEFF SHORES
Visibility, Apr 6, 2009
TL*THE CONTACT OWNS A 2004 FORD F-150. WHILE DRIVING LESS THAN 55 MPH, THE CONTACT HEARD A LOUD POPPING SOUND FROM THE REAR OF THE VEHICLE. SHE THOUGHT SOMETHING STRUCK THE WINDOW, BUT MINUTES LATER, THE ENTIRE REAR PASSENGER SIDE WINDOW COLLAPSED INTO THE WINDOW ASSEMBLY UNIT AND THE DOOR. THE DEALER REPLACED THE WINDOW REGULATOR. PREVIOUSLY, THE SAME FAILURE OCCURRED WITH THE FRONT DRIVER'S SIDE WINDOW. THE WINDOW REGULATOR WAS REPLACED AT THAT TIME AS WELL. BOTH REPAIRS COST $450 EACH. THERE WERE NO RECALLS FOR THE FAILURE. THE CURRENT AND FAILURE MILEAGES WERE LESS THAN 64,500. UPDATED 12/8/09 *CN UPDATED 12/09/09.*JB
Engine and engine cooling, Apr 2, 2009
TL*THE CONTACT OWNS A 2004 FORD F-150. WHEN THE CONTACT INSPECTED THE VEHICLE, HE NOTICED THAT A SPARK PLUG WAS LOOSE AND CREATED A HOLE ON TOP OF THE CYLINDER. THE SPARK PLUG WAS DEFECTIVE AND CAUSED ALL THE OTHER SPARK PLUGS TO COME OUT OF PLACE. THE MANUFACTURER STATED THAT THEY WOULD NOT ASSIST WITH THE REPAIR. THE VEHICLE WILL NOT BE REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 90,000.