2005 Ford F-150
Problems, recalls and owner-reported issues
Visibility is the leading concern among 1,121 owner complaints filed for this model year. This is the 4th highest complaint count among 26 F-150 model years with reports.
Of the 2005 reports, 50 involved a crash and 29 involved a fire. 57 people were injured and 2 people died.
What owners report most often
Recalls and investigations
Air bags, frontal, driver side, inflator moduleFeb 23, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2004-2006 F-150 PICK UP TRUCKS AS WELL AS CERTAIN MODEL YEAR 2006 LINCOLN MARK LT VEHICLES. IF THE CLOCKSPRING JUMPER WIRE COMES IN CONTACT WITH THE DRIVER SIDE FRONTAL AIR BAG LOWER HORN PLATE, THE WIRE INSULATION MAY BECOME CHAFED, CREATING A POTENTIAL FOR A SHORT CIRCUIT. IF THIS OCCURS THE AIR BAG WARNING LAMP MAY ILLUMINATE INDICATING THAT SERVICE IS REQUIRED.
THE DRIVER SIDE FRONTAL AIR BAG COULD INADVERTENTLY DEPLOY INCREASING THE RISK OF INJURY OR LOSS OF VEHICLE CONTROL IF OCCURRING WHILE IN MOTION.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN/MERCURY DEALER TO HAVE A NEW CLOCKSPRING JUMPER WIRE INSTALLED THAT INCORPORATES A PROTECTIVE MESH COVER. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THIS SAFETY RECALL BEGAN ON SOME VEHICLES IN MARCH 2011. THE RECALL CAMPAIGN ON THE EXPANDED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT MAY 9, 2011. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Campaign 11V107000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Service brakes, hydraulic, power assist, vacuum, hoses, lines/piping, and fittingsMay 7, 2008
FORD IS RECALLING 605,684 MY 2005-2006 F-150 AND LINCOLN MARK LT VEHICLES EQUIPPED WITH 5.4L 3-VALVE ENGINES. THE BRAKE BOOSTER VACUUM SUPPLY HOSE ATTACHED TO THE INTAKE MANIFOLD FITTING MAY SWELL OVER TIME AND LOSE RETENTION FORCE. THIS CONDITION COULD ALLOW THE HOSE TO BECOME DETACHED FROM THE FITTING DURING AN INTAKE MANIFOLD BACKFIRE. SHOULD THE HOSE DETACH FROM THE INTAKE MANIFOLD, SEVERAL BRAKE APPLICATIONS WITH POWER ASSIST WILL BE AVAILABLE BEFORE THE VACUUM RESERVE IS DEPLETED.
ONCE THE BRAKE BOOSTER VACUUM RESERVE IS DEPLETED, THE DRIVER WILL HAVE FOUNDATION BRAKE FUNCTION, BUT WITH INCREASED BRAKE PEDAL EFFORT. REDUCED VEHICLE BRAKING COULD LEAD TO A CRASH.
DEALERS WILL REPLACE A RUBBER HOSE ON THE BRAKE BOOSTER VACUUM SUPPLY TUBE ASSEMBLY. THE RECALL BEGAN ON JUNE 27, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 08V208000 on NHTSA.gov
Exterior lighting, headlightsOct 25, 2007
CERTAIN SPYDER HEADLAMP REPLACEMENT ASSEMBLIES SOLD FOR USE ON 2004 THROUGH 2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SPYDER WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2007. OWNERS CAN CONTACT SPYDER AT 866-558-4264.
Campaign 07E089000 on NHTSA.gov
Exterior lighting, headlightsSep 25, 2007
CERTAIN HEADLAMP ASSEMBLIES IMPORTED AND SOLD AS AFTERMARKET EQUIPMENT BY SONAR AUTO PARTS FOR USE ON 2004-2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SONAR WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS CAN CONTACT SONAR AT 866-558-4264.
Campaign 07E080000 on NHTSA.gov
Exterior lighting, headlightsSep 14, 2007
CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. FR390-B001L AND FR390-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE THICKNESS IS UNSTABLE INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
EAGLE EYES WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON NOVEMBER 6, 2007. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.
Campaign 07E075000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Interior lightingFeb 6, 2006
CERTAIN PICKUP TRUCKS FAIL TO COMPLY WITH EITHER THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 105, 'HYDRAULIC AND ELECTRIC BRAKE SYSTEMS' OR FMVSS NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' THESE VEHICLES WERE BUILT WITH A SOFTWARE ERROR IN THE INSTRUMENT CLUSTER.
THIS ERROR COULD PREVENT THE ANTILOCK BRAKE SYSTEM (ABS) WARNING LIGHT FROM ILLUMINATING IF THE ABS MODULE EVER BECAME INOPERATIVE.
DEALERS WILL RECALIBRATE THE INSTRUMENT CLUSTER IN THESE VEHICLES. THE RECALL BEGAN ON FEBRUARY 27, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 06V033000 on NHTSA.gov
Tires, tread/beltNov 21, 2005
CERTAIN CONTINENTAL CONTITRAC TR OWL, CONTITRAC TR BSW, GENERAL GRABBER TR BSW, AND CONTITRAC BSW TIRES MANUFACTURED BETWEEN MAY 29 AND JUNE 11, 2005, AND SOLD AS ORIGINAL EQUIPMENT ON CERTAIN FORD TRUCKS AND SOLD AS REPLACEMENT TIRES. THESE TIRES CAN WEAR PREMATURELY WHICH FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 119, NEW PNEUMATIC TIRES FOR VEHICLES OTHER THAN PASSENGER CARS.
AFFECTED TIRES MAY NOT MEET THE ENDURANCE TEST REQUIREMENTS OF THE STANDARD. CONTINUED USE OF THE AFFECTED TIRES CAN RESULT IN TIRE FAILURE WHICH COULD LEAD TO VEHICLE DAMAGE OR MOTOR VEHICLE CRASH.
CONTINENTAL WILL NOTIFY OWNERS AND REPLACE THE TIRES FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 7, 2005. OWNERS MAY CONTACT CONTINENTAL AT 704-588-5895.
Campaign 05T022000 on NHTSA.gov
Representative owner complaints: engine and engine cooling
114 reports, newest first. Show all
Engine and engine cooling, Nov 21, 2024
The contact owns a 2005 Ford F-150. The contact stated while starting the vehicle, there was an abnormally loud knocking sound coming from the engine. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic where it was diagnosed that the cam phasers had failed and needed to be replaced. The vehicle was not repaired. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The failure mileage was approximately 190,000.
Engine and engine cooling, Structure, Fuel/propulsion system, May 21, 2018
TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING APPROXIMATELY 30 MPH, THE EXHAUST PIPE DETACHED FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND IT WAS DISCOVERED THAT THE ENTIRE SUBFRAME OF THE VEHICLE WAS RUSTED AND CORRODED, INCLUDING THE DAMAGED EXHAUST PIPE. THE EXHAUST PIPE WAS REPAIRED, BUT THE SUBFRAME WAS NOT. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, BUT THE LOCAL DEALER WAS NOT. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 70,000.
Engine and engine cooling, Power train, Other or unspecified, Jan 11, 2017
CPSC;2005 FORD F-150 TRANSMISSION AND MOTOR WENT OUT AT 89446 MILES. A DIAGNOSTIC WAS PERFORMED. *BF THE CONSUMER STATED AFTER THE TRANSMISSION WAS REPLACED, THE VEHICLES PERFORMANCE WAS NOT INDICATIVE OF HAVING BEEN AT A REPAIR SHOP. THE CONSUMER RETURNED TO THE DEALER AND ANOTHER DIAGNOSTIC WAS PERFORMED. THE CONSUMER WAS THEN INFORMED THE ENGINE NEEDED TO BE REPLACED. IT WAS ALSO DETERMINED THE INITIAL REPAIRS WERE COMPLETED WITH SALVAGED/USED PARTS. *JB
Engine and engine cooling, Electrical system, Oct 9, 2014
2005 FORD F-150. CONSUMER WRITES IN REGARDS TO SPARK PLUGS AND COILS PROBLEM. *SMD THE CONSUMER STATED THE VEHICLE STALLED, UPON ACCELERATION. THE CONSUMER ALSO STATED THE CHECK ENGINE LIGHT ILLUMINATED AND FLASHED WHEN A SPARK PLUS MISFIRED. *JB
Engine and engine cooling, Power train, Sep 25, 2014
FORD DESIGNED THE FACTORY SPARK PLUGS AS A TWO PIECE DESIGN. ONCE THE TRUCK REQUIRES A TUNE UP THE CURRENT SPARK PLUGS BREAK IN HALF AS THEY ARE REMOVED CAUSING AN ADDITION COST FOR EXTRA LABOR AND SPECIAL TOOLS DESIGNED TO REMOVE THESE PLUGS. I TOOK MY TRUCK TO THE FORD DEALER WHO THEN BROKE 6 OUT OF 8 PLUGS UPON REMOVAL AT AN EXTRA COST OF 80 DOLLARS A PIECE. THE TUNE UP WHICH ONLY INCLUDES THE REMOVAL OFF THE OLD AND THE INSTALLATION OF THE NEWLY DESIGNED ONE PIECE SPARK PLUGS ENDED UP COSTING ME 1000 DOLLARS. THESE SPARK PLUGS ALSO BREAK INSIDE THE ENGINE CAUSING A LOSS OF POWER AND POSSIBLE DAMAGE TO THE CATALYTIC CONVERTER. *TR
Engine and engine cooling, Aug 2, 2014
WHEN TAKING MY VEHICLE OUT FOR TEST DRIVE AFTER PUTTING NEW BRAKES ON. WHILE DRIVING AN SPARK PLUG BLEW OUT. WHILE CHECKING ONLINE I FOUND THAT THIS IS A MAJOR PROBLEM. I WAS VERY UPSET TO FIND OUT FROM THE DEALER THAT IT'S GONNA COST $585.70 TO FIX ONE SPARK PLUG AND REPLACE COIL. I ASKED ABOUT REPLACING ALL THE PLUG AND THEY QUOTED $900 TO DO ALL OF THEM. AS A RETIREE OF FORD I THINK THIS IS CRAZY. THEY TELL YOU IN THE MANUAL THAT THE PLUGS ARE GOOD FOR 100,000 MILES. THE MECHANIC SAID THERE IS NO GUARANTEE THAT THIS WON'T HAPPEN AGAIN EVEN IF WE REPLACED ALL THE PLUGS. I'M THINKING OF TRADING MY TRUCK OFF AND AM CONSIDERING ANOTHER BRAND. *TR
Engine and engine cooling, Fuel system, Gasoline, Apr 26, 2014
FORD FUEL PUMP DRIVER CORRODES BADLY CAUSING NO START AND/OR TOTAL FAILURE OF ENGINE POWER. REDUCTION OF POWER OR ENGINE STALLING CAN AND WILL HAPPEN AT HIGHWAY SPEEDS. WHEN ENGINE STALLS DRIVER CAN LOSE POWER STEERING POWER BRAKES AND CONTROL VEHICLE. THIS IS KNOWN BY FORD. FORD ALONG WITH A AFTERMAKET COMPANY HAS REDESIGNED THE PART. THE UPDATED PART HAS STANDOFFS ALONG WITH A PROTECTIVE COATING PREVENTING CORROSION. THE CORROSION OF THE PART HAPPENS FASTER IN THE SALT BELT STATES. I REPLACED MINE AND THE PART HAD A HOLE IN IT LETTING WATER AND PARTS OF METAL INSIDE UNIT. I STILL HAVE PART IF NEEDED. DO AN INTERNET SEARCH AND YOU WILL FIND ALLOT OF EXAMPLES OF THIS ISSUE. THIS ISSUE AFFECTS MILLIONS OF VEHICLES. *TR
Engine and engine cooling, Vehicle speed control, Feb 25, 2014
WHILE DRIVING HOME TRUCK SHUT OFF ENGINE FAIL SAFE MODE INDICATOR CAME ON ENGINE SHUT OFF ALL FUNCTIONS,BRAKES POWER STEERING. *TR
Engine and engine cooling, Fuel system, Gasoline, Oct 30, 2013
I WAS PULLING OUT INTO TRAFFIC WHEN THE ENGINE WOULDN'T RESPOND. LUCKILY IT WASN'T ON A HIGHWAY THE ON COMING TRAFFIC HAD ENOUGH TIME TO AVOID ME. THERE WAS NO WARNING I THOUGHT THE TRUCK HAD DIED AND WENT TO RESTART BUT THE ENGINE WAS IDLING. I THEN PUT THE TRUCK INTO LOW TRANSFER AND WAS ABLE TO MOVE TO A SAFE PLACE BY IDLING UNTIL A TOW TRUCK COULD REMOVE IT. *TR
Engine and engine cooling, Structure, May 12, 2012
CROSS-REFERENCE FORD TSB 07-13-5: WATER LEAK FROM AC HAS FLOODED THE PASSENGER FLOOR PAN AND ALL ASSOCIATED CARPETING AND PADDING. SIGNIFICANT HEALTH HAZARD EXISTS IN WARM CLIMATES DUE TO THE PROLIFERATION OF RESPIRATORY HAZARDS INCLUDING BUT NOT LIMITED TO LEGIONNAIRE'S DISEASE. THE ITEM SHOULD BE A RECALL FOR THIS REASON. I HAVE LOST USE OF MY TRUCK DUE TO THE INABILITY TO SUFFICIENTLY DRY THE PADDING - I HAVE HAD THE VEHICLE DRYING FOR ONE WEEK IN HOT FLORIDA SUN TO NO AVAIL. *TR
Engine and engine cooling, Apr 30, 2012
#3 SPARK PLUG BLEW OUT WHILE TRAVELING AWAY FROM HOME IN ANOTHER STATE. IN DRIVING TWO MILES BACK TO MY SON'S HOUSE, I HAD TWO EXPLOSIONS FROM EXCESS GASOLINE AND SPARK PLUG FIRING. THE SPARK PLUGS WERE ORIGINAL AND BLEW OUT BECAUSE OF THE FINE THREADS AND ALUMINUM CYLINDER HEADS. THIS IS A DESIGN DEFECT AND SAFETY PROBLEM KNOWN TO FORD. TOWING AND INSERT INSTALLATION BY A FORD DEALER WAS $950. THE ENGINE IS A 4.6 V-8 UPDATED 05/17/12 *BF
Engine and engine cooling, Fuel system, Gasoline, Apr 20, 2012
TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH HE NOTICED THAT THE ENGINE MISFIRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND THE MECHANIC STATED THAT THE REVERSE SPARK PLUGS WELDED THEMSELVES TO THE ENGINE HEAD. THE MECHANIC PERFORMED A TUNE UP AND REPLACED THE SPARK PLUGS. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 94,000. THE VIN WAS UNAVAILABLE. UPDATED 06/05/12*LJ THE CUSTOMER STATED FORD REPLACEDTHE FAULTY FUEL INJECTORS. UPDATED 06/06/12 *JS
Engine and engine cooling, Electrical system, Mar 22, 2012
FORD FACTORY SPARK PLUG BREAKS WITHIN THE HEAD CAUSING POTENTIAL INTERNAL ENGINE DAMAGE. AN EXTREMELY COMMON ISSUE THAT HAS LEAD TO THE INVENTION OF A SPECIAL TOOL USED JUST BECAUSE F THE ISSUE. COMMONLY REACHING HUNDREDS AND EVEN THOUSANDS OF DOLLARS TO REPAIR. FORD HAS CHANGED THEIR TSB FROM CHANGING PLUGS AT 100K MILES TO 60K MILES. HOWEVER BY THE TIME A ISSUE WAS NOTICED MANY OF US OWNERS HAVE OVER THE 60K MILE MARK. *TR
Engine and engine cooling, Electrical system, Mar 5, 2012, fire
TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED, A LOUD POP NOISE WAS HEARD AND THE VEHICLE ERUPTED INTO FLAMES. THE VEHICLE CAUSED EXTENSIVE DAMAGE TO A COMMERCIAL BUILDING IN WHICH IT WAS PARKED NEAR. THE POLICE WERE CONTACTED AND A POLICE REPORT WAS FILED. THE FIRE DEPARTMENT DID NOT DETERMINE THE CAUSE OF THE FIRE. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 78,000. UPDATED 03/28/12 *BF UPDATED 03/30/12
Engine and engine cooling, Electrical system, Feb 9, 2012
2005 FORD F150. CONSUMER STATES ENGINE SHUTS OFF AND VEHICLE CONTINUES TO GO INTO "FAIL SAFE MODE" *TGW THE CONSUMER STATED THERE WERE TIMES WHEN THE VEHICLE WOULD RE-START, AND OTHER TIMES IT WOULDN'T. THE CONSUMER STATED SEVERAL COMPONENTS SUCH AS THE FUEL FILTER, CATALYTIC CONVERTER, FUEL PUMP MODULE, THROTTLE BODY, AND CRANKSHAFT POSITION SENSOR WERE REPLACED TO TRY AND RECTIFY THE PROBLEM. THE ENGINE BEGAN TO MISFIRE AND THE CHECK ENGINE LIGHT ILLUMINATED. THE CONSUMER STATED IT WAS FINALLY DETERMINED, THE CASING ON THE CRANKSHAFT POSITION SENSOR WIRE HAD RUBBED THROUGH AND WAS SHORTING OUT ON THE AC LINE RUNNING ALONG THE RIGHT FENDER WELL. THE CONSUMER STATED AT SOME POINT WHEN HIS VEHICLE WAS BEING SERVICED AT THE DEALER, A COVER WAS REMOVED FROM THE FAR LEFT WIRING HARNESS AT THE PCM, WHICH PERMITTED WATER TO RUN DOWN THE INSIDE OF THE WIRING HARNESS AND SHORTED OUT THE CONNECTOR. JB
Engine and engine cooling, Power train, Dec 14, 2011
YES MY 4X4 IS NOT WORKING AND I HAVE READ OVER 300 POST EASY ABOUT THE SAME PROBLEM PEOPLE ARE HAVING. THOUSANDS OF PEOPLE ARE HAVING THE SAME PROBLEM I HAVE HAD WITH MY TRUCK. OBVIOUSLY IF THERE ARE THAT MANY PEOPLE WITH THE SAME YEAR OF TRUCK AND SAME PROBLEM WHY ISN'T FORD DOING A RECALL? THEY SAY THE PROBLEM IS THE IWE, SOLENOID, THE PROBLEM WHY IT HAPPENS IN THE FIRST PLACE IS THERE ISN'T A RAIN COVER OVER THE SOLENOID UNDERNEATH THE HOOD. I DO BELIEVE THAT THIS IS A HUGE SAFETY HAZARD AND ALMOST CAUSED ME TO BE IN AN ACCIDENT ABOUT THREE WEEKS AGO BECAUSE MY FOUR WHEEL DRIVE WENT OUT! FORD PLEASE DO A RECALL BEFORE SOMEONE GETS HURT OR EVEN DIE! I DO BELIEVE THAT FORD SHOULD BE RESPONSIBLE FOR THIS ISSUE AND HAVE A RECALL TO GET THESE VEHICLES FIXED. *TR
Engine and engine cooling, Fuel system, Gasoline, Dec 6, 2011
THE PROBLEM STARTED IN 2010, IT NOW HAS HAPPEN THREE TIMES THIS YEAR MY 2005 FORD F-150 SUPERCAB HAS WITHOUT ANY WARNING, EITHER LOST ALL POWER OR THE ENGINE WAS REDUCED TO IDLE RPM AT HIGHWAY SPEEDS. A TOTAL OF FIVE TIMES THIS HAS HAPPEN SINCE I BOUGHT THE TRUCK. ITS HAPPEN IN ALL TYPS OF DRIVING, HIGHWAY SPEEDS, CITY DRIVING, ACCELERATION AND AT A STEADY SPEED. I HAVE HAD TO MANEUVER ACROSS BUSY FREEWAY LANES WHILE COASTING. IN THREE OF THE INCIDENTS IN WHICH THE ENGINE STALLED, I HAD TO ACCOMPLISH THIS WITHOUT POWER STEERING OR BRAKES. IN ANOTHER INCIDENT, THE ENGINE WAS IDLING SO P/S AND P/B WERE FUNCTIONING, BUT THERE WAS NO RESPONSE TO THROTTLE INPUTS FOR ACCELERATION. THE CHECK ENGINE AND "WRENCH" WARNING LIGHTS WERE ILLUMINATED ON THE DASHBOARD. AFTER TURNING OFF THE IGNITION SWITCH, THE VEHICLE RE-STARTED AND I WAS ABLE TO CONTINUE, THE WRENCH LIGHT WENT OFF AFTER RESTART, BUT THE CHECK ENGINE LIGHT REMAINED ILLUMINATED UNTIL I HAVE IT RESET. I BEEN VERY FORTUNATE THAT I HAVE NOT BEEN IN AN ACCIDENT. THIS PROBLEM IS INTERMITTENT AND COMES WITH ABSOLUTELY NO WARNING, IT IS CLEARLY A SAFETY ISSUE. I NOW WILL NOT LET MY FAMILY DRIVE THE TRUCK. *TR
Engine and engine cooling, Dec 1, 2011
TL* THE CONTACT OWNS A 2005 FORD F150. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, A LOUD NOISE WAS EMITTED FROM THE ENGINE COMPARTMENT. THE CONTACT MENTIONED THAT THE FAILURE RECURRED TWICE. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE SPARK PLUGS WERE NOT TORQUED CORRECTLY, CAUSING THE SPARK PLUGS TO BE SPEWED FROM THE ENGINE BLOCK. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 87,000 AND THE CURRENT MILEAGE WAS 120,000.
Engine and engine cooling, Fuel system, Gasoline, Nov 14, 2011
STARTING WITH A SERVICE ON 2/19/2008 THE TRUCK HAD BEEN IDLING REALLY ROUGH AND MAKING A TICKING SOUND WHEN STARTED. AT THAT TIME THE FORD SERVICE DEPARTMENT STATED THAT THE NOISE WENT AWAY WITH FACTORY OIL AND FILTER. THIS PROBLEM HAS PERSISTED UP TO AND INCLUDING WHEN WE TOOK IT IN LAST WEEK WHERE WE WERE TOLD THAT THIS COULD BE FIXED WITH THICKER OIL, AND TO RETURN WHEN IT IS TIME FOR OUR NEXT SERVICE. THE SECOND ISSUE HAS PERSISTED SINCE MID 2010, IT IS A FOUL FUEL SMELL COMING INSIDE THE CAB, THROUGH THE AC VENTS WHEN THE TRUCK IS STARTED IN THE MORNING AND WHEN IDLING. WE HAVE BEEN TOLD OVER AND OVER AGING THAT NOTHING CAN BE FOUND AND THEY CANNOT SMELL IT. WE WERE ALSO TOLD THAT THEY DROVE THE TRUCK AROUND DURING A SERVICE ON 8/17/2011 TO SEE IF THEY COULD SMELL IT, YET OUR MILES IN AND MILES OUT ON OUR SERVICE RECORDS BOTH STATE 47,771. NOT SURE HOW THEY DROVE IT WITHOUT CHANGING THE MILES. OUR TRUCK BARELY HAS 50,000 MILES ON IT, IT IS SERVICED REGULARLY YET IT IDLES HORRIBLY, SMELLS OF FUEL AND GETS 7MPG. SOMETHING HAS TO BE WRONG! *TR
Engine and engine cooling, Nov 10, 2011
WHILE DRIVING TO WORK #5 SPARKPLUG BLEW OUT OF THE BLOCK. WITH THE ENGINE STILL RUNNING FUMES OR GAS VAPORS FROM THE SPARKPLUG HOLE AND THE SPARK FROM THE COIL PACK CAN CAUSE THE ENGINE TO CATCH FIRE OR EVEN EXPLODE!!!! CAUSING BODILY INJURY OR DEATH TO THE OCCUPANT OF THE VEHICLE. *TR
Engine and engine cooling, Nov 8, 2011
AUTO RAN GREAT,FUEL MILEAGE REAL GOOD,THEN SPARKPLUG BLEW OUT WITHOUT ANY ADVANCE INDICATION OF A PROBLEM. *TR
Engine and engine cooling, Oct 22, 2011
VEHICLE MISFIRED ON ACCELERATION ON HIGHWAY. WAS AWARE OF SPARK PLUG EJECTIONS W/ MY PARTICULAR YEAR AND MODEL AFTER GOING THROUGH CAMSHAFT PHASER REPAIRS. (2005 F-150 W/ 5.4L TRITON ENGINE). MECHANIC SUGGESTED REPLACING ALL FACTORY SPARK PLUGS W/ NEW DESIGNED SPARK PLUG KIT TO ELIMINATE EJECTION PROBLEM. I DID SO AT A COST OF $831.52. COSTS TO DATE $4729.25 WITHIN THE LAST 2 MONTHS ON A 2005 VEHICLE. UNACCEPTABLE. RESEARCHED ON INTERNET AND FOUND THIS TO BE A VERY WELL KNOWN PROBLEM. NO MENTION OF IT FROM THE DEALER UPON PURCHASE. FORD HAS TURNED THEIR BACK ON THIS (AND THE CAMSHAFT PHASER DEFECT). I AM A SMALL CONTRACTOR WHOSE LIVELIHOOD DEPENDS ON THIS VEHICLE. THE PURCHASE PRICE OF $35,890.00 PLUS TAX AND LICENSE WAS A HUGE INVESTMENT FOR ME (I PAID CASH AND DRAINED MY SAVINGS SO I WOULD NOT HAVE MONTHLY PAYMENT). SO THESE ADDITIONAL COSTS TO AN ALMOST NEW VEHICLE HAVE DRAINED MY ACCOUNT AGAIN. *TR
Engine and engine cooling, Oct 22, 2011
CAMSHAFT PHASERS FAILED SO ENGINE WOULD NOT IDLE, CAUSING A VERY DANGEROUS SITUATION AT STOP SIGNS HAVING TO CONSTANTLY REV ENGINE TO KEEP RUNNING. REPAIR COST $3,897.73. THROUGH INTERNET INVESTIGATION HAVE FOUND MY PARTICULAR YEAR AND ENGINE (5.4L TRITON) HAS A HISTORY OF THIS FAILURE. TOLD THAT A NON-MOTORCRAFT OIL FILTER CAN RELEASE DEBRIS THAT CLOGS A LUBRIVATION PORT IN THE CAM PHASERS WHICH IN TURN DESTROYS THEM. NO INFO. OF THIS SORT WAS EVER RELAYED TO ME ON PURCHASE OF VEHICLE. I HAVE NO REASON TO BELIEVE I HAVE EVER USED ANYTHING BUT A MOTORCRAFT OIL FILTER. A 2005 VEHICLE W/ A $3900.00 MECHANICAL REPAIR IS UNACCEPTABLE. HAVE CONTACTED FORD UNTIL I HAVE EXHAUSTED MY ATTEMPTS. THEY FINALLY TOLD ME THIS WAS THE END OF OUR COMMUNICATIONS. *TR
Engine and engine cooling, Oct 7, 2011
TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE STOPPED, THE CONTACT HEARD A TICKING SOUND COMING FROM THE ENGINE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING WHERE THE TECHNICIAN STATED THAT THE CAM PHASER AND THE TENTIONERS WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 39,000.
Engine and engine cooling, Fuel system, Gasoline, Vehicle speed control, Sep 25, 2011
TRUCK CONTINUES ACCELERATING AFTER FOOT IS REMOVED FROM ACCELERATOR PEDAL. ALMOST IMPOSSIBLE TO STOP WITH BRAKE PEDAL. HAD TO TAKE OUT OF GEAR TO STOP TRUCK. RESTARTED TRUCK AND IT OPERATES PROPERLY. IT HAS HAPPENED THREE MORE TIMES SINCE THIS ORIGINAL OCCURRENCE. FORD DEALER COULD FIND NO PROBLEM IN 2007. AM TAKING IT BACK AGAIN AS IT HAS HAPPENED TWICE IN THE PAST YEAR. *TR