2005 Ford F-150
Problems, recalls and owner-reported issues
Visibility is the leading concern among 1,121 owner complaints filed for this model year. This is the 4th highest complaint count among 26 F-150 model years with reports.
Of the 2005 reports, 50 involved a crash and 29 involved a fire. 57 people were injured and 2 people died.
What owners report most often
Recalls and investigations
Air bags, frontal, driver side, inflator moduleFeb 23, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2004-2006 F-150 PICK UP TRUCKS AS WELL AS CERTAIN MODEL YEAR 2006 LINCOLN MARK LT VEHICLES. IF THE CLOCKSPRING JUMPER WIRE COMES IN CONTACT WITH THE DRIVER SIDE FRONTAL AIR BAG LOWER HORN PLATE, THE WIRE INSULATION MAY BECOME CHAFED, CREATING A POTENTIAL FOR A SHORT CIRCUIT. IF THIS OCCURS THE AIR BAG WARNING LAMP MAY ILLUMINATE INDICATING THAT SERVICE IS REQUIRED.
THE DRIVER SIDE FRONTAL AIR BAG COULD INADVERTENTLY DEPLOY INCREASING THE RISK OF INJURY OR LOSS OF VEHICLE CONTROL IF OCCURRING WHILE IN MOTION.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN/MERCURY DEALER TO HAVE A NEW CLOCKSPRING JUMPER WIRE INSTALLED THAT INCORPORATES A PROTECTIVE MESH COVER. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THIS SAFETY RECALL BEGAN ON SOME VEHICLES IN MARCH 2011. THE RECALL CAMPAIGN ON THE EXPANDED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT MAY 9, 2011. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Campaign 11V107000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Service brakes, hydraulic, power assist, vacuum, hoses, lines/piping, and fittingsMay 7, 2008
FORD IS RECALLING 605,684 MY 2005-2006 F-150 AND LINCOLN MARK LT VEHICLES EQUIPPED WITH 5.4L 3-VALVE ENGINES. THE BRAKE BOOSTER VACUUM SUPPLY HOSE ATTACHED TO THE INTAKE MANIFOLD FITTING MAY SWELL OVER TIME AND LOSE RETENTION FORCE. THIS CONDITION COULD ALLOW THE HOSE TO BECOME DETACHED FROM THE FITTING DURING AN INTAKE MANIFOLD BACKFIRE. SHOULD THE HOSE DETACH FROM THE INTAKE MANIFOLD, SEVERAL BRAKE APPLICATIONS WITH POWER ASSIST WILL BE AVAILABLE BEFORE THE VACUUM RESERVE IS DEPLETED.
ONCE THE BRAKE BOOSTER VACUUM RESERVE IS DEPLETED, THE DRIVER WILL HAVE FOUNDATION BRAKE FUNCTION, BUT WITH INCREASED BRAKE PEDAL EFFORT. REDUCED VEHICLE BRAKING COULD LEAD TO A CRASH.
DEALERS WILL REPLACE A RUBBER HOSE ON THE BRAKE BOOSTER VACUUM SUPPLY TUBE ASSEMBLY. THE RECALL BEGAN ON JUNE 27, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 08V208000 on NHTSA.gov
Exterior lighting, headlightsOct 25, 2007
CERTAIN SPYDER HEADLAMP REPLACEMENT ASSEMBLIES SOLD FOR USE ON 2004 THROUGH 2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SPYDER WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2007. OWNERS CAN CONTACT SPYDER AT 866-558-4264.
Campaign 07E089000 on NHTSA.gov
Exterior lighting, headlightsSep 25, 2007
CERTAIN HEADLAMP ASSEMBLIES IMPORTED AND SOLD AS AFTERMARKET EQUIPMENT BY SONAR AUTO PARTS FOR USE ON 2004-2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SONAR WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS CAN CONTACT SONAR AT 866-558-4264.
Campaign 07E080000 on NHTSA.gov
Exterior lighting, headlightsSep 14, 2007
CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. FR390-B001L AND FR390-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE THICKNESS IS UNSTABLE INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
EAGLE EYES WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON NOVEMBER 6, 2007. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.
Campaign 07E075000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Interior lightingFeb 6, 2006
CERTAIN PICKUP TRUCKS FAIL TO COMPLY WITH EITHER THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 105, 'HYDRAULIC AND ELECTRIC BRAKE SYSTEMS' OR FMVSS NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' THESE VEHICLES WERE BUILT WITH A SOFTWARE ERROR IN THE INSTRUMENT CLUSTER.
THIS ERROR COULD PREVENT THE ANTILOCK BRAKE SYSTEM (ABS) WARNING LIGHT FROM ILLUMINATING IF THE ABS MODULE EVER BECAME INOPERATIVE.
DEALERS WILL RECALIBRATE THE INSTRUMENT CLUSTER IN THESE VEHICLES. THE RECALL BEGAN ON FEBRUARY 27, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 06V033000 on NHTSA.gov
Tires, tread/beltNov 21, 2005
CERTAIN CONTINENTAL CONTITRAC TR OWL, CONTITRAC TR BSW, GENERAL GRABBER TR BSW, AND CONTITRAC BSW TIRES MANUFACTURED BETWEEN MAY 29 AND JUNE 11, 2005, AND SOLD AS ORIGINAL EQUIPMENT ON CERTAIN FORD TRUCKS AND SOLD AS REPLACEMENT TIRES. THESE TIRES CAN WEAR PREMATURELY WHICH FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 119, NEW PNEUMATIC TIRES FOR VEHICLES OTHER THAN PASSENGER CARS.
AFFECTED TIRES MAY NOT MEET THE ENDURANCE TEST REQUIREMENTS OF THE STANDARD. CONTINUED USE OF THE AFFECTED TIRES CAN RESULT IN TIRE FAILURE WHICH COULD LEAD TO VEHICLE DAMAGE OR MOTOR VEHICLE CRASH.
CONTINENTAL WILL NOTIFY OWNERS AND REPLACE THE TIRES FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 7, 2005. OWNERS MAY CONTACT CONTINENTAL AT 704-588-5895.
Campaign 05T022000 on NHTSA.gov
Representative owner complaints: engine and engine cooling
114 reports, newest first. Show all
Engine and engine cooling, Aug 15, 2007
TL*THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WILL SHUT OFF AND THE STEERING WHEEL WILL LOCK WHILE DRIVING. THE FAILURES OCCUR WITHOUT WARNING. THE SERVICE ENGINE LIGHT ILLUMINATED ON THE DASHBOARD AND DISPLAYED THAT THE ENGINE HAS MALFUNCTIONED. THE DEALER REPAIRED THE FAILURE THREE TIMES BY REPLACING THE SPARK PLUGS AND THE CHASSEL BODY. THE SPEED WAS UNKNOWN. THE CURRENT MILEAGE WAS 70,000 AND FAILURE MILEAGE WAS 50,000.
Engine and engine cooling, Aug 14, 2007
EXPERIENCED SUDDEN LOSS OF POWER STEERING AND POWER BRAKES WHILE NORMAL AND ROUTINE DRIVING ON HIGHWAY. NO WARNING OF ANY KIND THAT FAILURE WAS ABOUT TO OCCUR. ENGINE RAN ROUGH, ENGINE LIGHT WARNING CAME ON AFTER BRAKE AND STEERING FAILURE AND THEN ENGINE SHUT OFF. NARROWLY AVOIDED REAR END COLLISION AND DRIVING OFF THE HIGHWAY AND INTO STEEP RAVINE. WAS ABLE TO BRING VEHICLE UNDER CONTROL WITH A LOT OF EFFORT TO STEER AND EMERGENCY BRAKE. COULD HAVE BEEN INJURIES AND/OR FATAL. TOWED VEHICLE TO FORD DEALER. DEALER PERFORMED EEC TEST AND RECEIVED CODES P0171 AND P0174. DEALER FOUND VACUUM HOSE FROM INTAKE MANIFOLD TO EBRAKE BOOSTER BROKEN. DEALER REMOVED INTAKE MANIFOLD, REPLACED VACUUM HOSE AND INTAKE GASKETS, AND REINSTALLED INTAKE MANIFOLD AND CLEARED CODES. I HAVE OLD PARTS. *TR
Engine and engine cooling, Dec 17, 2006
I HAD STOPPED AT A LOCAL SHOP ON MY WAY BACK TO WORK AND WHEN I WENT TO START MY PICKUP TO RETURN THE ENGINE WOULD NOT TURN OVER. ON THE THIRD ATTEMPT, IT FINALLY STARTED, BUT SMELLED LIKE A MOTOR BURNING UP. I WAS PROCEEDING UP A HILL AND WAS APPROACHING A STOP SIGN. WHEN I PRESSED ON THE BRAKES, THERE WERE NO BRAKES. I COULD NOT STOP THE TRUCK AT THE STOP SIGN. I COASTED THROUGH THE STOP SIGN AT APPROXIMATELY 10MPH AND I PULLED RIGHT INTO A PARKING LOT. NO MATTER HOW HARD I PRESSED THE BRAKE PEDAL I COULDN'T GET THE TRUCK TO STOP COMPLETELY SO I PUT THE TRANSMISSION INTO PARK. I THEN PROCEEDED TO CALL FOR HELP. WHEN THE MECHANIC ARRIVED, HE FOUND THAT THE VACUUM HOSE HAD COME UNATTACHED. AFTER SPEAKING WITH A FORD MECHANIC OVER THE PHONE, HE STATED THAT THE MECHANIC HAD SINCE SEVERAL TRUCKS IN THE SAME MAKE AND MODEL AS MINE THAT ALSO HAD THIS SAME PROBLEM OCCUR. AT THIS TIME, MY TRUCK IS IN THE PROCESS OF BEING FIXED BY THE MECHANIC WHO TOLD US OF THIS PROBLEM. *NM
Engine and engine cooling, Power train, May 15, 2006
BAD VIBRATION FROM REAR OF TRUCK 55-60 MPH INTERMITTENT. FORD STATE IT IS AFTERMARKET TIRES. HAD TRUCK IN 2 TIMES WITH FACTORY TIRES AND 3 TIMES WITH NEW TIRES FOR SAME VIBRATION. PINION ANGLE CHANGED TWICE ON TRUCK CAUSING MORE VIBRATIONS THAT FORD WON'T FIX. NOW TRUCK IS LEAKING ENGINE OIL FROM REAR MAIN. I AM AFRAID TO TAKE TRUCK ON LONG TRIPS FOR FEAR OF DRIVELINE FAILURE. NUMEROUS COMPLAINTS ON WEB OF SAME PROBLEM. WHY IS FORD NOT MADE TO FIX THIS ISSUE?TRUCK HAS 6,200 MILES ON IT AND ALMOST A YEAR OLD. THIS COULD BE A BIG SAFETY CONCERN IF DRIVELINE FAILURE OCCURS AT HIGHWAY SPEEDS. I HAVE BEEN AN AUTO MECHANIC FOR 18 YEARS AT DEALERSHIPS AND I KNOW A TIRE VIBRATION FROM A DRIVELINE VIBRATION. *JB
Engine and engine cooling, Fuel system, Gasoline, Mar 17, 2006
DT*: THE CONTACT STATED WHILE THE HEATER IS ENGAGED GAS FUMES ARE DETECTED IN THE VEHICLE. IN AN ATTEMPT TO REMEDY THE PROBLEM THE DEALER REPLACED THE FUEL INJECTORS, SPARK PLUGS, STARTER, FLY WHEEL, TRANSFER CASE, AND CATALYTIC CONVERTER WITH NO SUCCESS.
Engine and engine cooling, Feb 9, 2006, fire
DT*: THE CONTACT STATED THERE WERE NOISES THAT RESEMBLED THE SOUND OF BREAKING GLASS. AFTER FINDING THE SOURCE OF THE NOISE IT WAS DISCOVERED THE VEHICLE HAD CAUGHT ON FIRE. THE VEHICLE HAD BEEN PARKED SINCE THE PREVIOUS DAY. THE FIRE SPREAD TO THE CONTACT'S OTHER VEHICLE AND HOME. THE FIRE MARSHAL FILED A REPORT. THE FIRE STARTED IN THE ENGINE COMPARTMENT AND COMPLETELY MELTED. THE VEHICLE IS STILL BEING INSPECTED. THERE WERE NO PREVIOUS PROBLEMS WITH THE VEHICLE.
Engine and engine cooling, Fuel system, Gasoline, Jan 10, 2006
DT*: THE CONTACT STATED WHILE SITTING INSIDE THE VEHICLE THERE WAS AN ODOR OF GASOLINE. THE VEHICLE WAS INSPECTED BY THE LOCAL DEALERSHIP, AND THEY REPLACED 7 FUEL INJECTORS, 8 SPARK PLUGS, AND ORDERED A FUEL RAIL. THESE ATTEMPTS TO SOLVE THE PROBLEM HAVE BEEN UNSUCCESSFUL. *AK UPDATED 01/25/06. *JB
Engine and engine cooling, Oct 23, 2005
TWO WEEKS AFTER PURCHASING MY F150 I NOTICED A TICKING SOUND COMING FROM UNDER THE HOOD WHILE DRIVING DOWN THE HIGHWAY AT APPROXIMATELY 55 MPH AND WITH THE A/C ON AND THE FAN IN LOW. I DROVE FOR ANOTHER WEEK TO DETERMINE WHAT THE NOISE WAS AND FOUND THAT IT IS APPARENTLY A RELAY THAT IS BEING CYCLED WHEN THE A/C COMPRESSOR TURNS ON. THE SWITCH WILL CYCLE ANYWHERE FROM ONCE EVERY TEN SECONDS AT 55 MPH AND ABOVE WITH THE FAN IN 1 OR 2 TO ONCE EVERY THIRTY SECONDS. THE SWITCH SELDOM CYCLES WHILE THE VEHICLE IS AT IDLE BUT CAN BE HEARD TO CYCLE WHEN THE A/C IS SWITCHED ON OR OFF AT IDLE OR WHILE THE VEHICLE IS IN MOTION. THERE IS NO APPARENT AFFECT ON THE A/C SYSTEM OPERATION. THE TICKING IS VERY LOUD AND ANNOYING. THIS IS NOT NORMAL FOR A NEW VEHICLE. I TOOK THE VEHICLE TO MY DEALER AND THEY DID SEVERAL THINGS, FIRST THEY RECHARGED THE A/C SYSTEM AND TRIED TO RETURN THE TRUCK TO ME. I DROVE IT DOWN THE STREET, NOTED THE TICKING STILL THERE AND TOOK IT BACK. I SPOKE WITH THE SERVICE MANAGER WHO TOLD ME THAT THE TICKING IS "NORMAL" ON THESE TRUCKS. I PRESSED THE ISSUE AND HE MADE SOME ADJUSTMENTS AND ULTIMATELY CHANGED THE SWITCH/RELAY THAT IS CYCLING. THIS, HOWEVER IS THE WRONG SOLUTION, OBVIOUSLY THE SWITCH WORKS, WHAT IS NOT WORKING IS WHAT IS CAUSING IT TO CYCLE SO FREQUENTLY (AS OFTEN AS ONCE EVERY TEN SECONDS). AFTER A FULL DAY AT THE DEALERSHIP, I TOOK THE TRUCK AND HAVEN'T HAD THE TIME TO TAKE IT TO ANOTHER DEALER TO SEE IF THEY HAD ANOTHER SOLUTION. *NM
Engine and engine cooling, Sep 5, 2005
WHEN I START THE TRUCK IT MAKES A TICKING SOUND AND WHEN I HAVE THE A/C ON IT MAKES THE TICKING SOUND EVERY FEW SECONDS. I TOOK IT TO THE DEALERSHIP 2 TIMES SO FAR AND THEY SAY THAT IT'S NORMAL SOUNDS FROM THE A/C COMPRESSOR BUT I'M NOT SURE THAT IT IS NORMAL BECAUSE WHEN THE TRUCK IS STARTED WITH THE AIR OFF IT DOES THIS. ALSO WHEN BRAKING, THE STEERING WHEEL SHAKES STRONGLY AND UNCONTROLLABLY. THIS IS EVERYTIME YOU BRAKE AND AT ANY SPEED UNTIL COMING TO A COMPLETE STOP. *JB
Engine and engine cooling, Aug 4, 2005
ENGINE KNOCKS. *JB
Engine and engine cooling, Jun 27, 2005
2004 F-150 SUPER CREW STALLED AFTER DECELERATING AND AT LOW SPEED TURNING LEFT THROUGH ONCOMING TRAFFIC. WAS ABLE TO ROLL THROUGH INTERSECTION WITHOUT POWER STEERING AND RE-START ENGINE AFTER COMING TO A STOP AND SHIFTING TO PARK. THIS IS THE SECOND TIME THE VEHICLE HAS STALLED AT A LOW SPEED OR TURNING.
Engine and engine cooling, Apr 11, 2005
FORD F150 2005 , AFTER ABOUT 100 TO 150 MILES ON TRUCK DRIVING ON A ROAD WITH SLIGHT HILLS NOTICED VIBRATION , AT OR ABOUT 2100 TO 2400 RPMS IN ANY GEAR FLAT OR HILLY SURFACE AND AT ANY SPEED AS LONG AS 2100 TO 2400 RPMS ARE REACHED , TRUCK VIBRATES THROUGH OUT THE TRUCK , CONTACTED DEALERSHIP WHERE PURCHASED 3 TIMES FIRST WAS TOLD TO BRING TRUCK BACK IN FOR FURTHER TESTING , SECOND TIME DRIVABLE TECH WENT FOR RIDE NOTICED VIBRATION , THIRD TIME SERVICE MANAGER DROVE TRUCK NOTICED VIBRATION , CONTACTED FORD , FORD STATES ISSUE IS NORMAL FOR TRUCK NOT GOING TO DO ANYTHING , BUT HAS TSB FOR ISSUE 05-15 , SO I AM TO ASSUME THAT FORD IS NOW PRODUCING TRUCKS THAT VIBRATE AT SET RPMS . THE TRUCK NOW HAS ABOUT 650 MILES ON IT AND THE VIBRATION IS GETTING WORSE BUT FORD OR THE DEALERSHIP WILL NOT DO ANYTHING TO FIX THE ISSUE.*AK
Engine and engine cooling, Mar 19, 2005
A WEEK AFTER I HAD PICKED UP MY NEW 2005 FORD F150 LARIAT THE 5.4L ENGINE STARTED KNOCKING AND SPUTTERING. AFTER TAKING IT BACK TO THE DEALER THEY DETERMINED THAT THE PROBLEM WAS RELATED TO FAULTY SPROCKETS ON THE CAM SHAFTS (BULLETIN SSM-18342). I BROUGHT IT IN FOR SERVICE AND A WEEK AFTER GETTING IT BACK THE KNOCKING AND SPUTTERING IS STILL THERE AND GETTING WORSE. NOW I'M GOING BACK TO THE DEALER INSISTING THE ENGINE BE REPLACED. I DON'T EXPECT A LOT OF COOPERATION.*AK
Engine and engine cooling, Jan 24, 2005
THE COMPLAINANT PURCHASED A TRUCK FOR HIS BUSINESS AT THE COLORADO RIVER FORD DEALERSHIP IN BULLHEAD CITY AZ. THE DEALERSHIP OBTAINED THE TRUCK FROM CALIFORNIA AND HAD SAME DELIVERED TO BULLHEAD CITY. THE COMPLAINANT PICKED UP THE TRUCK AT THE DEALERSHIP AND IMMEDIATELY NOTED A PRONOUNCED ENGINE KNOCK. CALLING THE SERVICE DEPARTMENTS ATTENTION TO THIS PROBLEM THEY TOLD THE COMPLAINANT THAT THE NOISE WAS NORMAL. THE COMPLAINANT THEN MADE THEM START UP TWO SIMILAR TRUCKS ON THE LOT THAT DID NOT MANIFEST THE SAME KNOCK. THE COMPLAINANT REQUESTED A NEW TRUCK FROM THE DEALERSHIP THAT REFUSED TO HONOR THE REQUEST. THE COMPLAINANT HAD THE DEALERSHIP CONTACT THE MANUFACTURER IN DETROIT WHO ADVISED THAT THIS PROBLEM IS KNOWN TO ACCRUE IN SOME 2004/2005 MODELS AND THAT TO CORRECT SAME A NEW PART HAD TO BE ORDERED WHICH THE DEALERSHIP COULD NOT REPLACE AS THEY LACKED THE PROPER TOOLS TO DO SO. THE DEALERSHIP THEN DISMANTLED THE ENGINE. THE COMPLAINANT AGAIN ADVISED THE DEALERSHIP THAT HE WOULD NOT ACCEPT THIS DEFECTIVE TRUCK, AS HE HAD PURCHASED A NEW TRUCK TO BE IN PROPER WORKING CONDITION AND THE DEALERSHIP WAS NOW ATTEMPTING TO COMPEL THE COMPLAINANT TO ACCEPT A TRUCK THAT WAS DEFECTIVE FROM THE FACTORY. TO DATE THE TRUCK REMAINS AT THE DEALERSHIP. THE COMPLAINANT REFUSES TO ACCEPT THIS DEFECTIVE (FROM THE FACTORY) TRUCK AND THE DEALERSHIP REFUSES TO GIVE HIM ANOTHER NEW TRUCK IN LIEU OF THE DEFECTIVE ONE. YOUR ASSISTANCE IN THIS MATTER WILL BE GREATLY APPRECIATED, CONSTANTINE "CHUCK" BENTAS. *NM