2005 Ford F-150
Problems, recalls and owner-reported issues
Visibility is the leading concern among 1,121 owner complaints filed for this model year. This is the 4th highest complaint count among 26 F-150 model years with reports.
Of the 2005 reports, 50 involved a crash and 29 involved a fire. 57 people were injured and 2 people died.
What owners report most often
Recalls and investigations
Air bags, frontal, driver side, inflator moduleFeb 23, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2004-2006 F-150 PICK UP TRUCKS AS WELL AS CERTAIN MODEL YEAR 2006 LINCOLN MARK LT VEHICLES. IF THE CLOCKSPRING JUMPER WIRE COMES IN CONTACT WITH THE DRIVER SIDE FRONTAL AIR BAG LOWER HORN PLATE, THE WIRE INSULATION MAY BECOME CHAFED, CREATING A POTENTIAL FOR A SHORT CIRCUIT. IF THIS OCCURS THE AIR BAG WARNING LAMP MAY ILLUMINATE INDICATING THAT SERVICE IS REQUIRED.
THE DRIVER SIDE FRONTAL AIR BAG COULD INADVERTENTLY DEPLOY INCREASING THE RISK OF INJURY OR LOSS OF VEHICLE CONTROL IF OCCURRING WHILE IN MOTION.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN/MERCURY DEALER TO HAVE A NEW CLOCKSPRING JUMPER WIRE INSTALLED THAT INCORPORATES A PROTECTIVE MESH COVER. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THIS SAFETY RECALL BEGAN ON SOME VEHICLES IN MARCH 2011. THE RECALL CAMPAIGN ON THE EXPANDED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT MAY 9, 2011. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Campaign 11V107000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Service brakes, hydraulic, power assist, vacuum, hoses, lines/piping, and fittingsMay 7, 2008
FORD IS RECALLING 605,684 MY 2005-2006 F-150 AND LINCOLN MARK LT VEHICLES EQUIPPED WITH 5.4L 3-VALVE ENGINES. THE BRAKE BOOSTER VACUUM SUPPLY HOSE ATTACHED TO THE INTAKE MANIFOLD FITTING MAY SWELL OVER TIME AND LOSE RETENTION FORCE. THIS CONDITION COULD ALLOW THE HOSE TO BECOME DETACHED FROM THE FITTING DURING AN INTAKE MANIFOLD BACKFIRE. SHOULD THE HOSE DETACH FROM THE INTAKE MANIFOLD, SEVERAL BRAKE APPLICATIONS WITH POWER ASSIST WILL BE AVAILABLE BEFORE THE VACUUM RESERVE IS DEPLETED.
ONCE THE BRAKE BOOSTER VACUUM RESERVE IS DEPLETED, THE DRIVER WILL HAVE FOUNDATION BRAKE FUNCTION, BUT WITH INCREASED BRAKE PEDAL EFFORT. REDUCED VEHICLE BRAKING COULD LEAD TO A CRASH.
DEALERS WILL REPLACE A RUBBER HOSE ON THE BRAKE BOOSTER VACUUM SUPPLY TUBE ASSEMBLY. THE RECALL BEGAN ON JUNE 27, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 08V208000 on NHTSA.gov
Exterior lighting, headlightsOct 25, 2007
CERTAIN SPYDER HEADLAMP REPLACEMENT ASSEMBLIES SOLD FOR USE ON 2004 THROUGH 2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SPYDER WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2007. OWNERS CAN CONTACT SPYDER AT 866-558-4264.
Campaign 07E089000 on NHTSA.gov
Exterior lighting, headlightsSep 25, 2007
CERTAIN HEADLAMP ASSEMBLIES IMPORTED AND SOLD AS AFTERMARKET EQUIPMENT BY SONAR AUTO PARTS FOR USE ON 2004-2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SONAR WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS CAN CONTACT SONAR AT 866-558-4264.
Campaign 07E080000 on NHTSA.gov
Exterior lighting, headlightsSep 14, 2007
CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. FR390-B001L AND FR390-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE THICKNESS IS UNSTABLE INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
EAGLE EYES WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON NOVEMBER 6, 2007. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.
Campaign 07E075000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Interior lightingFeb 6, 2006
CERTAIN PICKUP TRUCKS FAIL TO COMPLY WITH EITHER THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 105, 'HYDRAULIC AND ELECTRIC BRAKE SYSTEMS' OR FMVSS NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' THESE VEHICLES WERE BUILT WITH A SOFTWARE ERROR IN THE INSTRUMENT CLUSTER.
THIS ERROR COULD PREVENT THE ANTILOCK BRAKE SYSTEM (ABS) WARNING LIGHT FROM ILLUMINATING IF THE ABS MODULE EVER BECAME INOPERATIVE.
DEALERS WILL RECALIBRATE THE INSTRUMENT CLUSTER IN THESE VEHICLES. THE RECALL BEGAN ON FEBRUARY 27, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 06V033000 on NHTSA.gov
Tires, tread/beltNov 21, 2005
CERTAIN CONTINENTAL CONTITRAC TR OWL, CONTITRAC TR BSW, GENERAL GRABBER TR BSW, AND CONTITRAC BSW TIRES MANUFACTURED BETWEEN MAY 29 AND JUNE 11, 2005, AND SOLD AS ORIGINAL EQUIPMENT ON CERTAIN FORD TRUCKS AND SOLD AS REPLACEMENT TIRES. THESE TIRES CAN WEAR PREMATURELY WHICH FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 119, NEW PNEUMATIC TIRES FOR VEHICLES OTHER THAN PASSENGER CARS.
AFFECTED TIRES MAY NOT MEET THE ENDURANCE TEST REQUIREMENTS OF THE STANDARD. CONTINUED USE OF THE AFFECTED TIRES CAN RESULT IN TIRE FAILURE WHICH COULD LEAD TO VEHICLE DAMAGE OR MOTOR VEHICLE CRASH.
CONTINENTAL WILL NOTIFY OWNERS AND REPLACE THE TIRES FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 7, 2005. OWNERS MAY CONTACT CONTINENTAL AT 704-588-5895.
Campaign 05T022000 on NHTSA.gov
Representative owner complaints: hydraulic
90 reports, newest first. Show all
Service brakes, Hydraulic, Jun 3, 2008
TL*THE CONTACT OWNS A 2005 FORD F150. THE CONTACT NOTICED THAT HIS BRAKE PEDAL WAS SOFT AND SPONGY, MAKING IT DIFFICULT TO BRAKE. THE BRAKE PEDAL WOULD EXTEND TO THE FLOOR WHEN IT WAS DEPRESSED. THE DEALER AND MANUFACTURER STATED THAT THE VEHICLE WAS SUPPOSED TO FUNCTION IN THAT MANNER. THE DEALER WORKED ON THE VEHICLE SEVERAL TIMES, BUT FAILED TO CORRECT THE FAILURE. A FORD REPRESENTATIVE DROVE THE VEHICLE, ACKNOWLEDGED THE FAILURE, AND ORDERED PARTS FOR THE REPAIR. HOWEVER, THE FAILURE STILL PERSISTS. THE CURRENT MILEAGE WAS APPROXIMATELY 25,000 AND FAILURE MILEAGE WAS APPROXIMATELY 4,000.
Service brakes, Hydraulic, May 30, 2008
TL*THE CONTACT OWNS A 2005 FORD F-150. WHILE APPROACHING AN INTERSECTION, THE BRAKE PEDAL WOULD NOT MOVE WHEN IT WAS DEPRESSED AND THE VEHICLE WOULD NOT STOP. FORTUNATELY, AFTER CONTINUALLY APPLYING PRESSURE TO THE BRAKES, THE VEHICLE STOPPED. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND THEY STATED THAT HIS VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 08V208000 (SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM:HOSES, LINES/PIPING, AND FITTINGS). HE WOULD BE RESPONSIBLE FOR THE REPAIR COSTS, WHICH TOTAL $567. THE DEALER REPLACED THE RUBBER HOSE ON THE BRAKE BOOSTER VACUUM SUPPLY TUBE ASSEMBLY. THE CONTACT IS IN THE PROCESS OF NOTIFYING THE MANUFACTURER. THE FAILURE AND CURRENT MILEAGES WERE 54,000. UPDATED 06/16/08 *BF THE INSTALLED A POWER BOOSTER HOSE UNDER THE INTAKE.
Service brakes, Hydraulic, May 20, 2008
TL*THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT ATTEMPTED TO STOP THE VEHICLE, BUT WAS UNSUCCESSFUL. ON MAY 18, 2008, WHILE APPROACHING A STOP SIGN, THE CONTACT DEPRESSED THE BRAKE PEDAL AND THE SPEED REDUCED TO 30 MPH; HOWEVER, THE VEHICLE WOULD NOT STOP AND CONTINUED THROUGH A FOUR LANE HIGHWAY. SHE WAS FINALLY ABLE TO STOP THE VEHICLE. THE DEALER STATED THAT THE POWER BRAKE BOOSTER VACUUM SUPPLY HOSE WAS FALLING OFF, AND THEY REMOVED THE INTAKE AND GLUED IT BACK INTO POSITION. THE DEALER FURTHER STATED THAT NHTSA CAMPAIGN ID NUMBER 08V208000 (SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM:HOSES, LINES/PIPING, AND FITTINGS) DID NOT APPLY TO HER VIN. THE CURRENT AND FAILURE MILEAGES WERE 133,077. UPDATED 06/09/2008. *LJ
Service brakes, Hydraulic, May 15, 2008, crash
I WAS INVOLVED IN AN INJURY CRASH. I HIT THE BRAKES AND THERE WAS NO STOPPING THE TRUCK. I DIDN'T GET THE TRUCK STOPPED UNTIL ABOUT 100-150 FEET PAST THE CRASH SCENE. THERE WERE NO SKID MARKS AT ALL. *TR
Service brakes, Hydraulic, May 1, 2008
FORD F150 BRAKE FAILURE, SUDDEN AND WITHOUT WARNING. OCCURRED WHEN DRIVING TO WORK. I WAS GOING APPROXIMATELY 25 MPH, COULDN'T AT A STOP SIGN, ROLLED THROUGH AND USED MY EMERGENCY BRAKE TO STOP. *TR
Service brakes, Hydraulic, Apr 28, 2008
SUDDEN TOTAL BRAKE FAILURE ON FORD F150 2005. RESULT OF VACUUM LINE POPPING OFF OF REAR INTAKE MANIFOLD. *TR
Service brakes, Hydraulic, Apr 23, 2008
I OWN A 2005 F150 WITH A 5.4 ENGINE. THE TRUCK IS 3 YEARS OLD WITH 49,000 MILES. THE BRAKES FAILED WITHOUT ANY NOTICE OR WARNING. THE DEALER SAYS THAT THE VACUUM HOSE THAT LEADS FROM THE BACK OF THE ENGINE TO THE BRAKE BOOSTER WAS WORN AND NEEDED REPLACING. THE SERVICE MANAGER AT THE DEALERSHIP SAID THERE WERE NO RECALLS ON THE ISSUE AND I WOULD HAVE TO PAY FOR THE WORN PART AND LABOR. AFTER DOING A LITTLE RESEARCH I CONTACTED ANOTHER DEALERSHIP AND THEY SAID THEY HAVE SEEN THE PROBLEM BEFORE AND THAT THERE WERE NO RECALLS ON THE ISSUE. I HAVE A TOUGH TIME UNDERSTANDING HOW THIS TYPE OF BRAKE FAILURE CAN OCCUR ON SUCH A NEW VEHICLE. I HAVE LOOKED OVER EVERYTHING THAT FORD GAVE ME WHEN I PURCHASED THE VEHICLE FROM THEM. NOTHING SAYS THAT THIS PART SHOULD BE REPLACED AT ANY MILEAGE. THEY CONCERN ME WITH FLUID CHANGES, TIRE WEAR, ETC. NOTHING ABOUT A HOSE THAT COULD PUT MY LIFE AND THE LIVES OF MY FAMILY AND OTHERS IN DANGER. THE PART THAT FAILED IS LOCATED BEHIND THE ENGINE AND THE ONLY WAY TO SEE IF THE PART WAS WORN IS TO TAKE THE TOP OF THE MOTOR OFF. SO I CAN ASSURE YOU THIS PART IS NEVER INSPECTED UNTIL THE BRAKES FAIL. THE DEALER DID FIX THE TRUCK AT MY EXPENSE STATING THEY COULD DO NOTHING. THEY SAID THEY WOULD ALSO REPORT THE ISSUE TO FORD. I ALSO CALLED THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AND THEY AGREED WITH THE DEALER . NO RECALLS ON THIS ISSUE. I NEED TO SEE THIS ISSUE IS PUT UNDER THE MICROSCOPE. SOMEONE WILL BE KILLED OR SERIOUSLY INJURED IF NOTHING IS DONE ABOUT THIS MANUFACTURING ISSUE. THIS PART SHOULDN'T FAIL UNDER NORMAL DRIVING CONDITIONS AND IF DOES THERE NEEDS TO BE TIME SPENT NOTIFYING THE PUBLIC ABOUT THE ISSUE. NOT SWEEPING IT UNDER THE FLOOR MAT. *TR
Service brakes, Hydraulic, Apr 21, 2008
NORMAL BRAKING CAPABILITY WAS SUDDENLY AND COMPLETELY LOST WITHOUT WARNING WHEN VACUUM ASSIST HOSE SEPARATED FROM FITTING ON THE INTAKE MANIFOLD. VACUUM HOSE SEPARATED APPARENTLY DUE TO SOME SLIGHT BACK-PRESSURE THAT OCCURRED WHEN ENGINE WAS STARTED. ORIGINAL DESIGN DID NOT INCLUDE A CLAMP ON THE HOSE. CORRECTION OF THE PROBLEM REQUIRED REMOVAL OF THE INTAKE MANIFOLD TO GAIN ACCESS TO THE VACUUM FITTING; THE HOSE WAS REPLACED AND CLAMPED. MILEAGE WAS 76,442 AND EXTENDED WARRANTY DID NOT COVER AND IT COST ME $782. IT IS VERY DISCONCERTING TO LEARN THAT NORMAL BRAKING CAPABILITY CAN BE COMPLETELY LOST IN THIS WAY WITHOUT ANY WARNING WHATSOEVER. I BELIEVE THE FORD MOTOR COMPANY MUST BE HELD FULLY RESPONSIBLE TO CORRECT WHAT IS CLEARLY A DESIGN DEFICIENCY THAT HAS HIGH POTENTIAL TO CAUSE A SERIOUS ACCIDENT RESULTING IN PERSONAL INJURY OR EVEN DEATH. I ALSO FEEL THAT THE FORD MOTOR COMPANY SHOULD REIMBURSE ME FOR COST OF REPAIR SINCE THE DEALERSHIP TOLD ME THAT IT KNEW OF THE PROBLEM AND WAS INFORMED TO MODIFY THE VACUUM HOSE ASSEMBLY BECAUSE THEY KNEW THAT THE ORIGINAL COMPOSITION WAS WRONG. *TR
Service brakes, Hydraulic, Apr 17, 2008
MY VEHICLE STALLED WHEN TRYING TO START. WHEN IT DID START, I PRESSED THE BRAKES AND THEY WERE HARD. I PUT MY CAR IN DRIVE AND TRIED TO APPLY MY BRAKES AND THE BRAKES DIDN'T SEEM TO WORK. I LITERALLY HAD TO PUT 2 FEET ON THE BRAKES AND PRESS DOWN WITH ALL OF MY WEIGHT JUST TO STOP MY TRUCK. I BROUGHT IT TO THE DEALERSHIP AND THEY SAID IT WAS MY VACUUM LINE ON MY BRAKES THAT CAME OFF. IT IS GOING TO COST ME $375. THANKFULLY I WASN'T DRIVING FAST WHEN MY BRAKES GAVE OUT. *TR
Service brakes, Hydraulic, Apr 10, 2008, crash
I WAS IN AN ACCIDENT DUE TO BRAKE FAILURE. I WAS TRAVELING AT APPROXIMATELY 25 MPH AND APPROACHING A STOP LIGHT IN MODERATE TRAFFIC. I HAD 80 FT TO THE VEHICLE IN FRONT OF ME AND WHEN I DEPRESSED MY BRAKE PEDAL IT WENT 3/4 OF THE WAY TO THE FLOOR AND WAS VIBRATING AS ANTI LOCK WAS ENGAGED. I RAPIDLY DEPRESSED THE PEDAL AGAIN AND THE SAME OCCURRED. ON THE THIRD ATTEMPT THE BRAKES FINALLY ENGAGED BUT WAS TO LATE TO STOP THE VEHICLE AS I WAS ONLY 2 FEET FROM THE CAR IN FRONT OF ME RESULTING IN A CRASH. MY SPEED WAS REDUCED TO 8-10MPH UPON IMPACT. THE SMALLER CAR IN FRONT OF ME WAS KNOCKED INTO A THIRD CAR STOPPED AT THE LIGHT. DAMAGE OCCURRED TO THE TRUCK AND THE SMALLER CAR AND VERY MINOR DAMAGE TO THE 3RD VEHICLE. THE WEATHER WAS SUNNY AND THE STREETS WERE COMPLETELY DRY. I COULD NOT GET MY VEHICLE STOPPED EVEN WITH NO LOAD OTHER THAN MY PASSENGER WHO IS A WITNESS TO THE INCIDENT. NO INJURIES OCCURRED IN ANY OF THE THREE VEHICLES AND NO AIRBAGS WERE DEPLOYED. I AM SCARED TO DEATH AS I HAVE OWNED THE TRUCK FOR 2 YEARS AND NEVER HAD THIS HAPPEN IN MY LIFE. THE BRAKES WORKED PERFECTLY IMMEDIATELY FOLLOWING THE INCIDENT AND THE TRUCK WAS TAKEN TO THE FORD DEALER WHERE PURCHASED NEW AND ALL SERVICE RECORDS ARE AT THIS DEALER. THEY THOROUGHLY INSPECTED THE ENTIRE SYSTEM AND FOUND NO ISSUES. SYSTEM CHECK ON ALL SENSORS,LINES, ROTORS AND PADS WERE OK. PERFECT WORKING ORDER ? *TR
Service brakes, Hydraulic, Vehicle speed control, Apr 4, 2008, crash
TL*THE CONTACT OWNS A 2005 FORD F150. WHILE SLOWING DOWN TO A COMPLETE STOP, THE VEHICLE RAPIDLY ACCELERATED. THE CONTACT DEPRESSED THE BRAKE PEDAL AGAIN TO MAKE SURE THAT SHE DEPRESSED THE CORRECT PEDAL, AND THE VEHICLE JERKED, CONTINUED TO ACCELERATE, AND THE ENGINE REVVED. THE VEHICLE ONLY STOPPED WHEN THE PASSENGER PLACED THE GEAR INTO PARK. THE CONTACT STRUCK THE PRECEDING VEHICLE AND THE BUMPER SUSTAINED MINOR DAMAGES. THE CONTACTS VEHICLE WAS TOWED TO THE DEALER BECAUSE SHE WAS AFRAID TO DRIVE IT AGAIN. A POLICE REPORT WAS FILED. SHE FILED COMPLAINT NUMBER 0405860938 WITH FORD. SHE WAS INFORMED THAT IT WOULD BE AT LEAST TWO WEEKS BEFORE SHE WOULD HEAR FROM THEIR LEGAL DEPARTMENT. THERE IS CURRENTLY AN OPEN INVESTIGATION NUMBER PE08001 (SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM. SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM:HOSES, LINES/PIPING, AND FITTINGS). THE CURRENT AND FAILURE MILEAGES WERE 34,000. UPDATED 4/29/08 *CN THE DAMAGE WAS MINOR. UPDATED 05/16/08
Service brakes, Hydraulic, Mar 7, 2008
THE POWER BRAKE SYSTEM SUDDENLY SHUT DOWN LEAVING THE VEHICLE UNABLE TO STOP. *TR
Service brakes, Hydraulic, Mar 6, 2008, fire
TL*THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING 50 MPH, THE REAR CALIPERS FROZE. THE WHEELS BEGAN SMOKING AND THE VEHICLE WAS TAKEN TO THE DEALER. THEY STATED THAT THERE WAS A MALFUNCTION WITH THE CALIPERS. THE DEALER ALSO DISCOVERED THAT AN AXLE SEAL WAS LEAKING, WHICH SATURATED THE BRAKE FUSE FOR THE EMERGENCY BRAKE. THE DEALER REPLACED THE SEAL AND CALIPERS AND TURNED DOWN ALL FOUR ROTORS ON THE VEHICLE, BUT DID NOT REPLACE THE BRAKE PADS. THE FAILURE RECURRED AND THE DEALER REPLACED THE REAR CALIPERS, REAR ROTORS, AND BRAKE PADS. THE CONTACT WANTED TO CHARGE HIM FOR THE BRAKE PADS (PARTS, NOT LABOR). THE CURRENT MILEAGE WAS 29,250 AND FAILURE MILEAGE WAS 12,500. UPDATED 4/2/08 *CN UPDATED 04/02/08 *TR
Service brakes, Hydraulic, Feb 18, 2008
I APPROACHED AN INTERSECTION WITH A TRAFFIC SIGNAL...I ATTEMPTED TO STOP MY TRUCK BY APPLYING THE BRAKES...MY TRUCK WENT RIGHT THROUGH THE RED LIGHT AND EVENTUALLY STOPPED AFTER THE INTERSECTION. I HEARD A NOISE RIGHT BEFORE THE TRUCK ACTUALLY STOPPED. I PULLED OFF THE MAIN HIGHWAY AND TRIED APPLYING THE BRAKES AGAIN AND THEY SEEMED TO BE OKAY. I PROCEEDED HOME VERY SLOWLY. *TR
Service brakes, Hydraulic, Feb 13, 2008
RETURNING HOME FROM ERRANDS FRIDAY EVENING, MY HUSBAND NOTICED A BURNING SMELL COMING FROM THE BACK OF MY TRUCK. UPON FURTHER INVESTIGATION, THE RIGHT REAR PASSENGER TIRE RIM WAS VERY HOT AND THERE WAS A STRONG, BURNING ODOR. NOT WANTING TO DUE FURTHER DAMAGE, WE MADE AN IMMEDIATE APPOINTMENT WITH A LOCAL REPAIR SHOP SATURDAY MORNING. THE MECHANIC WAS SURPRISED HE HAD TO REPLACE THE RIGHT REAR PASSENGER CALIPER, BRAKE PADS AND THE RIGHT REAR ROTOR NOW JUST MAKES SPEC AFTER HAVING TO BE RESURFACED. I AM THE PRIMARY DRIVER OF THIS TRUCK AND ALMOST ALWAYS HAVE MY TWO SMALL CHILDREN WITH ME. OBVIOUSLY, THERE IS A PROBLEM HERE THAT SOMEONE NEEDS TO ADDRESS IMMEDIATELY BEFORE THERE ARE ANY INJURIES OR DEATHS. WHAT HAS TO HAPPEN TO GET SOMEONE'S ATTENTION AND HAVE SUCH A SERIOUS SAFETY DEFECT CORRECTED? AND LET ME JUST ADD THAT I ONLY HAVE 23, 500 MILES ON MY TRUCK. *TR
Service brakes, Hydraulic, Feb 12, 2008
WHEN STARTING MY VEHICLE IN THE PARKING LOT IT SPUTTERED AND DID NOT START THE FIRST TIME. NO PROBLEM THE SECOND TIME. AFTER STARTING THE SECOND TIME I NOTICED THE POWER BRAKES DID NOT WORK. I TURNED THE TRUCK OFF TO TRY TO RESET THE SYSTEM, STILL NO BRAKES. I DROVE HOME VERY CAREFULLY USING MY ENTIRE BODY WEIGHT TO STOP THE VEHICLE AT STOP LIGHTS. THERE WOULD BE NO WAY TO STOP IF I DID NOT HAVE PLENTY OF ROOM IN FRONT OF ME. I TOOK THE TRUCK INTO THE FORD DEALER AND WAS TOLD A HOSE IS LEAKING OR HAS COME LOOSE BEHIND THE INTAKE MANIFOLD. COST APPROX 700.00. I HAVE CONTACTED FORD FOR POTENTIAL PAYMENT. *TR
Suspension, Service brakes, Hydraulic, Feb 10, 2008
I OWN A FORD F-150 PICKUP TRUCK. THE REAR CALIPER IS BROKEN AND THE FRONT STRUTS ARE LEAKING. I ONLY HAVE 34,000 MILES ON THIS VEHICLE. PLEASE E-MAIL ME BACK WITH INFO ABOUT THIS PROBLEM. THANK YOU LIONEL PARENT *TR
Service brakes, Hydraulic, Feb 10, 2008
POWER BRAKE FAILURE AFTER STARTING ENGINE. *TR
Service brakes, Hydraulic, Power train, Jan 28, 2008
BRAKE PROBLEMS SEVERAL TIMES NOW I HAVE HAD TO HAVE CALIPERS, ROTORS, ETC REPLACED. NOW MY REAR END SEEMS TO BE SLIPPING GOING AROUND CORNERS. *TR
Service brakes, Hydraulic, Jan 24, 2008
MY DAUGHTER WAS OPERATING MY 2005 MODEL F150 WHEN THE BRAKES WENT OUT, SHE WAS ABLE TO SWERVE OFF OF THE ROAD TO AVOID AN ACCIDENT UNTIL THE TRUCK CAME TO REST. NO PHYSICAL DAMAGE WAS INCURRED TO HER OR THE VEHICLE. UPON INVESTIGATION, THE BRAKE BOOSTER HAD LOST VACUUM (POWER ASSIST) DUE TO A VACUUM HOSE THAT HAD FALLEN LOOSE FROM THE REAR OF THE INTAKE MANIFOLD. 600.00 REPAIR TO RE-ATTACH VACUUM HOSE AND CLAMP NEVER INSTALLED AT FACTORY. *TR
Service brakes, Hydraulic, Jan 22, 2008
SEVERE FRONT BRAKE SHUDDER STARTING AT 40,000 MILES: TURNED ROTOR, SEVERE BRAKE SHUDDER AT 60,000 MILES: REPLACE L FRONT ROTOR AND BRAKE PAD: SEVERE SHUDDER AT 80,000 MILES: PRESENTLY AT 110,000 MILES AND FORD TELLS ME I NEED TO REPLACE THE ROTORS AND CALIPER TO SOLVE A PROBLEM THAT FORD KNEW ABOUT BEFORE I PURCHASED THE NEW VEHICLE IN AUG 2005 (SERVICE BULLETIN 100117872 JUNE 1 2005). IT WAS NOT RIGHT FOR FORD TO SELL ME A TRUCK WITH BRAKES THAT WERE ALREADY UNDER A SERVICE BULLETIN. *TR
Service brakes, Hydraulic, Jan 18, 2008
NORMAL BRAKING CAPABILITY WAS SUDDENLY AND COMPLETELY LOST WITHOUT WARNING WHEN VACUUM ASSIST HOSE SEPARATED FROM FITTING ON THE INTAKE MANIFOLD. VACUUM HOSE SEPARATED APPARENTLY DUE TO SOME SLIGHT BACK-PRESSURE THAT OCCURRED WHEN ENGINE WAS STARTED. ORIGINAL DESIGN DID NOT INCLUDE A CLAMP ON THE HOSE. CORRECTION OF THE PROBLEM REQUIRED REMOVAL OF THE INTAKE MANIFOLD TO GAIN ACCESS TO THE VACUUM FITTING; THE HOSE WAS REPLACED AND CLAMPED. MILEAGE WAS 23,442 BUT VEHICLE WAS OUT OF WARRANTY DUE TO AGE OF 39 MONTHS. DEALER DID A "GOODWILL - AFTER WARRANTY" REPAIR FOR WHICH I WAS REQUIRED TO PAY 20% OR A MINIMUM OF $100. IT IS VERY DISCONCERTING TO LEARN THAT NORMAL BRAKING CAPABILITY CAN BE COMPLETELY LOST IN THIS WAY WITHOUT ANY WARNING WHATSOEVER. I BELIEVE THE FORD MOTOR COMPANY MUST BE HELD FULLY RESPONSIBLE TO CORRECT WHAT IS CLEARLY A DESIGN DEFICIENCY THAT HAS HIGH POTENTIAL TO CAUSE A SERIOUS ACCIDENT RESULTING IN PERSONAL INJURY OR EVEN DEATH. *TR
Service brakes, Hydraulic, Dec 28, 2007
TL*THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING 10 MPH, THE CONTACT DEPRESSED THE BRAKE PEDAL, BUT IT WOULD NOT MOVE. AS A RESULT, THE VEHICLE WOULD NOT STOP AND RAN A RED LIGHT. THE PARKING BRAKE WAS APPLIED AND THE VEHICLE FINALLY STOPPED. THE VEHICLE WAS DRIVEN TO THE DEALER AND THEY STATED THAT THE VACUUM HOSE DETACHED FROM THE MANIFOLD. THE HOSE TUBING WAS REPLACED. THE VIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 36,900.
Service brakes, Hydraulic, Dec 17, 2007
MY HUSBAND HAS TAKEN OUR 2005 FORD F-150 TO THE DEALER WE PURCHASED IT FROM TWICE CONCERNING BRAKES AND ROTORS. THE FIRST TIME WAS AROUND 7,400 MILES. THEY TURNED THE ROTORS AND SAID ALL WAS FINE. AT AROUND 18,000 MILE HE AGAIN HAD TO GO BACK DUE TO A BAD VIBRATION. THEY TURNED THE ROTORS YET AGAIN INSTEAD OF REPLACING THEM. WE HAD NEW TIRES PUT ON OUR TRUCK YESTERDAY AND WE WERE INFORMED THE BRAKES AND ROTORS ARE NEARLY SHOT. THIS IS AT ONLY 28,000 MILES. THIS HAS TO BE DUE TO A DEFECT IN THE WORKMANSHIP. I KNOW OF NO OTHER VEHICLE I HAVE DRIVEN THAT HAS HAD THESE PROBLEMS EARLY ON. *TR
Service brakes, Hydraulic, Dec 13, 2007
TL*THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING 10-15 MPH, THE BRAKE PEDAL FELT VERY STIFF WHEN IT WAS DEPRESSED. THE CONTACT HAD TO DEPRESS THE BRAKE PEDAL WITH EXCESSIVE PRESSURE IN ORDER TO STOP THE VEHICLE. WHEN THE VEHICLE FINALLY CAME TO A STOP, IT WAS IN THE MIDDLE OF AN INTERSECTION. THE VEHICLE WAS PUSHED BACK TO THE DRIVEWAY. THERE WERE NO WARNING INDICATORS AND THE ROAD CONDITIONS WERE DRY. THE VEHICLE WAS NOT INSPECTED BY A DEALER. THE CURRENT AND FAILURE MILEAGES WERE 49,173.