2005 Ford F-150
Problems, recalls and owner-reported issues
Visibility is the leading concern among 1,121 owner complaints filed for this model year. This is the 4th highest complaint count among 26 F-150 model years with reports.
Of the 2005 reports, 50 involved a crash and 29 involved a fire. 57 people were injured and 2 people died.
What owners report most often
Recalls and investigations
Air bags, frontal, driver side, inflator moduleFeb 23, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2004-2006 F-150 PICK UP TRUCKS AS WELL AS CERTAIN MODEL YEAR 2006 LINCOLN MARK LT VEHICLES. IF THE CLOCKSPRING JUMPER WIRE COMES IN CONTACT WITH THE DRIVER SIDE FRONTAL AIR BAG LOWER HORN PLATE, THE WIRE INSULATION MAY BECOME CHAFED, CREATING A POTENTIAL FOR A SHORT CIRCUIT. IF THIS OCCURS THE AIR BAG WARNING LAMP MAY ILLUMINATE INDICATING THAT SERVICE IS REQUIRED.
THE DRIVER SIDE FRONTAL AIR BAG COULD INADVERTENTLY DEPLOY INCREASING THE RISK OF INJURY OR LOSS OF VEHICLE CONTROL IF OCCURRING WHILE IN MOTION.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN/MERCURY DEALER TO HAVE A NEW CLOCKSPRING JUMPER WIRE INSTALLED THAT INCORPORATES A PROTECTIVE MESH COVER. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THIS SAFETY RECALL BEGAN ON SOME VEHICLES IN MARCH 2011. THE RECALL CAMPAIGN ON THE EXPANDED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT MAY 9, 2011. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Campaign 11V107000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Service brakes, hydraulic, power assist, vacuum, hoses, lines/piping, and fittingsMay 7, 2008
FORD IS RECALLING 605,684 MY 2005-2006 F-150 AND LINCOLN MARK LT VEHICLES EQUIPPED WITH 5.4L 3-VALVE ENGINES. THE BRAKE BOOSTER VACUUM SUPPLY HOSE ATTACHED TO THE INTAKE MANIFOLD FITTING MAY SWELL OVER TIME AND LOSE RETENTION FORCE. THIS CONDITION COULD ALLOW THE HOSE TO BECOME DETACHED FROM THE FITTING DURING AN INTAKE MANIFOLD BACKFIRE. SHOULD THE HOSE DETACH FROM THE INTAKE MANIFOLD, SEVERAL BRAKE APPLICATIONS WITH POWER ASSIST WILL BE AVAILABLE BEFORE THE VACUUM RESERVE IS DEPLETED.
ONCE THE BRAKE BOOSTER VACUUM RESERVE IS DEPLETED, THE DRIVER WILL HAVE FOUNDATION BRAKE FUNCTION, BUT WITH INCREASED BRAKE PEDAL EFFORT. REDUCED VEHICLE BRAKING COULD LEAD TO A CRASH.
DEALERS WILL REPLACE A RUBBER HOSE ON THE BRAKE BOOSTER VACUUM SUPPLY TUBE ASSEMBLY. THE RECALL BEGAN ON JUNE 27, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 08V208000 on NHTSA.gov
Exterior lighting, headlightsOct 25, 2007
CERTAIN SPYDER HEADLAMP REPLACEMENT ASSEMBLIES SOLD FOR USE ON 2004 THROUGH 2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SPYDER WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2007. OWNERS CAN CONTACT SPYDER AT 866-558-4264.
Campaign 07E089000 on NHTSA.gov
Exterior lighting, headlightsSep 25, 2007
CERTAIN HEADLAMP ASSEMBLIES IMPORTED AND SOLD AS AFTERMARKET EQUIPMENT BY SONAR AUTO PARTS FOR USE ON 2004-2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SONAR WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS CAN CONTACT SONAR AT 866-558-4264.
Campaign 07E080000 on NHTSA.gov
Exterior lighting, headlightsSep 14, 2007
CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. FR390-B001L AND FR390-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE THICKNESS IS UNSTABLE INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
EAGLE EYES WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON NOVEMBER 6, 2007. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.
Campaign 07E075000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Interior lightingFeb 6, 2006
CERTAIN PICKUP TRUCKS FAIL TO COMPLY WITH EITHER THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 105, 'HYDRAULIC AND ELECTRIC BRAKE SYSTEMS' OR FMVSS NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' THESE VEHICLES WERE BUILT WITH A SOFTWARE ERROR IN THE INSTRUMENT CLUSTER.
THIS ERROR COULD PREVENT THE ANTILOCK BRAKE SYSTEM (ABS) WARNING LIGHT FROM ILLUMINATING IF THE ABS MODULE EVER BECAME INOPERATIVE.
DEALERS WILL RECALIBRATE THE INSTRUMENT CLUSTER IN THESE VEHICLES. THE RECALL BEGAN ON FEBRUARY 27, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 06V033000 on NHTSA.gov
Tires, tread/beltNov 21, 2005
CERTAIN CONTINENTAL CONTITRAC TR OWL, CONTITRAC TR BSW, GENERAL GRABBER TR BSW, AND CONTITRAC BSW TIRES MANUFACTURED BETWEEN MAY 29 AND JUNE 11, 2005, AND SOLD AS ORIGINAL EQUIPMENT ON CERTAIN FORD TRUCKS AND SOLD AS REPLACEMENT TIRES. THESE TIRES CAN WEAR PREMATURELY WHICH FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 119, NEW PNEUMATIC TIRES FOR VEHICLES OTHER THAN PASSENGER CARS.
AFFECTED TIRES MAY NOT MEET THE ENDURANCE TEST REQUIREMENTS OF THE STANDARD. CONTINUED USE OF THE AFFECTED TIRES CAN RESULT IN TIRE FAILURE WHICH COULD LEAD TO VEHICLE DAMAGE OR MOTOR VEHICLE CRASH.
CONTINENTAL WILL NOTIFY OWNERS AND REPLACE THE TIRES FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 7, 2005. OWNERS MAY CONTACT CONTINENTAL AT 704-588-5895.
Campaign 05T022000 on NHTSA.gov
Representative owner complaints: visibility
269 reports, newest first. Show all
Visibility, Jan 21, 2009
INTERMITTENT PROBLEM WITH THE PASSENGER SIDE WINDOW SWITCH ON MY 2005 FORD F-150 THEN DRIVING DOWN THE FREEWAY THE WINDOW JUST FELL DOWN INTO THE DOOR. *TR
Visibility, Jan 16, 2009
DRIVER'S SIDE WINDOW FELL DOWN INSIDE DOOR WHILE CAR WAS PARKED. *TR
Visibility, Jan 13, 2009
2005 F150 REGULATOR BROKE AND BROKE WINDOW. I HAVE READ THAT THIS HAPPENS FREQUENTLY. *TR
Visibility, Jan 13, 2009
I DROVE AWAY FROM AN ATM WENT TO PUT WINDOW UP HERE LOUD RINGING NOISE AND WINDOW WOULD NOT GO ALL THE WAY UP. THEN A FEW MINUTES LATER I HEARD A LOUD POPPING NOISE AND NOTICE WINDOW HAD FALLEN INTO DOOR AND. WOULD NOT RETURN TO THE CLOSED POSITION. THE NOISE WAS LOUD ENOUGH TO CAUSE GRANDSON SITTING IN CAR SEAT IN BACK OF VEHICLE TO START CRYING. IF THERE WOULD HAVE BEEN FOUL WEATHER THE INSIDE OF VEHICLE WOULD HAVE GOTTEN SOAKED AS WELL AS A HAZARD OF GRANDSON GETTING INJURED FROM POSSIBILITY OF SOMETHING ENTERING VEHICLE THROUGH OPEN WINDOW OPENING. *TR
Visibility, Jan 8, 2009
WITHIN THE LAST FOUR MONTHS (SHORTLY AFTER THE 3 YEAR WARRANTY EXPIRATION) THREE OF FOUR POWER WINDOW REGULATORS HAVE FAILED IN MY F-150. THE DEALER INDICATES THAT THIS IS ONE OF THE MOST COMMON REPAIR ACTIONS FOR F-150'S. THIS IS CLEARLY A WELL DOCUMENTED AND COMPLAINED ABOUT PRODUCT DEFICIENCY THAT IS ALSO A MAJOR SAFETY HAZARD BECAUSE WHEN THE FAILURES OCCUR THE WINDOW DROPS INTO THE DOOR PANEL. MY MOST RECENT FAILURE WHICH OCCURRED LAST WEEK WAS DURING A SERIOUS RAIN STORM WITH MY CHILD SITTING AT THE REAR PASSENGER WINDOW WHEN IT FAILED AND FELL INTO THE DOOR PANEL. *TR
Visibility, Jan 6, 2009
DRIVING DOWN THE ROAD AT ABOUT 30 MPH I HEARD WIND BLOWING INTO MY 2005 FORD F-150 AND NOTICED THAT THE RIGHT REAR WINDOW HAD FELL DOWN ABOUT HALF WAY I TRIED TO ROLL UP THE WINDOW WITH NO SUCCESS. I HAD TO TAPE THE WINDOW SO THAT IT WOULD STAY IN THE UP POSITION. THE TRUCK ONLY HAS ABOUT 30,000 MILES AND THIS IS THE SECOND WINDOW I HAVE HAD TO REPAIR. THIS WAS VERY TROUBLING TO ME THAT MY WINDOW COULD JUST FALL DOWN WITH NO ONE PUSHING THE BUTTON OR ANYTHING. I WONDERED WHAT IF MY TRUCK WAS JUST PARKED IN A PARKING LOT AND THIS OCCURRED SOMEONE COULD EASILY STEAL EVERYTHING IN MY VEHICLE. I LOOKED ON THE INTERNET TO SEE IF ANYONE ELSE WAS HAVING THIS PROBLEM AND FOUND THOUSANDS OF PEOPLE HAVE HAD THE SAME PROBLEM. THE WINDOW REGULATORS ON THE 2004 AND 2005 F-150'S ARE FAULTY AND DANGEROUS. AND IT IS TIME THAT SOMEONE MAKE FORD TAKE RESPONSIBILITY FOR THEIR FAULTY EQUIPMENT. *TR
Visibility, Dec 18, 2008
WINDOW REGULATOR FAILURE ON MY 2005 F150. 2 FAILURES IN THE LAST 8 MONTHS. PAID FORD 332.00 DOLLARS TO FIX, EACH. *TR
Visibility, Dec 18, 2008
TL*THE CONTACT OWNS A 2005 FORD F150 PURCHASED BRAND NEW IN 2005. THE FRONT WINDSHIELD COMPLETELY LOST ITS SEAL. WHILE DRIVING AT SPEEDS OF LESS THAN 30 MPH, HE HEARD FIVE LOUD BANGING NOISES IN FRONT OF THE WINDSHIELD. THE DEALER STATED THAT THE INSTALLATION OF THE WINDSHIELD WAS NOT FORD MANUFACTURED AND WOULD NOT ASSIST WITH THE REPAIR COSTS. THE VEHICLE WAS PURCHASED BRAND NEW FROM A FORD DEALER AND HAS NOT HAD ANY REPAIRS TO THE WINDSHIELD. THE FAILURE AND CURRENT MILEAGES WERE LESS THAN 47,197.
Visibility, Dec 17, 2008
TL*THE CONTACT OWNS A 2005 FORD F-150. THE CONSUMER STATED THE REAR WINDOW STOPPED WORKING. THEN THE DRIVERS SIDE FRONT WINDOW FELL INSIDE THE DOOR. THE DEALER REPLACED THE SLIDER WINDOW MOTOR ON THE REAR WINDOW AND THE REGULATOR ASSEMBLY IN THE DRIVERS SIDE FRONT DOOR. THE PASSENGER REAR WINDOW GLASS THEN FELL INSIDE THE DOOR. UPDATED 01/07/09. *L'S THE CONSUMER ALSO STATED THE WINDSHIELD WIPERS STOPPED WORKING. UPDATED 01/0/09. *JB
Visibility, Dec 14, 2008
PASSENGER SIDE ELECTRIC WINDOW ON OUR 2005 FORD F-150 SUPERCAB SIMPLY FELL DOWN WHILE MY WIFE WAS WORKING. WE RARELY USE THE PASSENGER WINDOW AT ALL. I HAVE READ A PLETHORA OF SUCH OCCURRENCES ON WWW.CARCOMPLAINTS.COM. I FEEL THIS IS A SAFETY ISSUE. THE WINDOWS CAN FALL AT ANY TIME - EVEN WHEN THE VEHICLE IS PARKED. IMAGINE BEING BROKEN DOWN IN A VERY FRIGID PLACE AND TRYING TO STAY WARM AND BANG - A WINDOW SIMPLY FALLS DOWN. THIS SHOULD WARRANT AN IMMEDIATE RECALL. THE PARTS THAT FAIL ARE CHEAP PLASTIC CLIPS USED TO GUIDE CABLES WITH A LOT OF TORQUE/TENSION ON THEM. THANK YOU VERY MUCH. RONNIE PIERCE *TR
Visibility, Dec 8, 2008
I HAVE CHANGED THE WINDOW CONTROL SWITCH, WINDOW MOTOR AND NOW HAVE TO CHANGE THE WINDOW REGULATOR FOR THE SAME WINDOW. THE CHEAP PLASTIC PIECE BROKE. THAT IS ON ONE WINDOW, NOT COUNTING THE OTHER THREE WINDOWS THAT HAVE HAD PARTS REPLACED ALREADY. *TR
Visibility, Dec 4, 2008
BROKEN POWER WINDOW. *TR
Visibility, Dec 1, 2008
AT 47,296 MILES THE RIGHT REAR WINDOW OF MY FORD F150 CREW CAB FELL DOWN INTO THE DOOR AND WOULD NO LONGER OPERATE. I PAID 416.00 TO REPAIR AT A FORD DEALERSHIP. AT 48312 THE LEFT REAR WINDOW HAS FALLEN INSIDE THE DOOR AND WILL NOT OPERATE. I WILL BE FACING ANOTHER 400+ IN REPAIRS. *TR
Visibility, Nov 18, 2008
MY PASSENGER WINDOW FELL DOWN INSIDE THE DOOR FRAME. THIS IS THE SECOND TIME THIS HAS HAPPENED. THE FIRST TIME I WAS GOING DOWN THE HIGHWAY AND THE DRIVERS WINDOW FELL DOWN IN THE DOOR. IT WAS POURING OUT AN I COULDN'T SEE WHERE I WAS GOING WITH THE RAIN BLOWING INSIDE. I PUSHED THE WINDOW UP BUTTON AND NOTHING HAPPENED. I TOOK IT TO THE DEALER AND IT WAS 240.00 TO GET FIXED. IM LUCKY IT WASN'T RAINING THIS TIME. I HOPE FORD MOTOR IS LOOKING AT THIS ISSUE. THIS IS A REAL SAFETY CONCERN WHILE DRIVING IN BAD WEATHER, JUST TO HAVE THE WINDOW FALL DOWN WITH NO WARNING!! THANKS. *TR
Visibility, Nov 16, 2008
2005 FORD F150 WINDOW REGULATOR FAILURE. *TR
Visibility, Nov 12, 2008
MY 2005 FORD F150 JUST DROPPED THE DRIVER SIDE WINDOW DOWN INTO THE DOOR DUE TO THE POORLY DESIGNED FAULTY WINDOW REGULATOR. FROM SEARCHING THE WEB THIS IS A WELL KNOWN DEFECT THAT IS ABUNDANT IN F150'S. THIS IS A SAFETY HAZARD AS THIS HAPPENED IN RUSH HOUR TRAFFIC AND I THOUGHT I HAD BEEN SHOT AT AND DROVE OFF THE ROAD INTO A DITCH AND BANGED MY SHOULDER. THIS IS WELL KNOWN TO BE AN ISSUE AND IS A MAJOR SAFETY HAZARD. THIS NEEDS TO BE RECALLED BEFORE SOMEONE GETS KILLED! *TR
Visibility, Nov 10, 2008
THIS HAS HAPPENED TWO TIMES NOW. WHILE DRIVING, I HEAR LOUD POP OR BANG AND THEN THE WINDOW WILL FALL INTO THE DOOR. THIS HAS HAPPENED ON THE PASSENGER SIDE AND DRIVERS SIDE. THIS NEARLY CAUSED AN ACCIDENT BECAUSE I THOUGHT SOMEONE WAS SHOOTING AT ME. IT STARTLED ME QUITE BADLY. FORD SHOULD BE REQUIRED TO ISSUE A RECALL ON THESE WINDOW REGULATORS. PARTS ARE AVAILABLE TO REPAIR, BUT THE REPAIR DOES NOT PERMANENTLY FIX THE PROBLEM. THIS IS DANGEROUS BECAUSE MOST PEOPLE COVER THE WINDOW WITH PLASTIC WHILE WAITING FOR THE REPAIR. IF THEY CAN'T AFFORD THE REPAIR THEY MAY DRIVE AROUND FOR WEEKS OR MONTHS WITH A PLASTIC WINDOW THAT COMPLETELY BLOCKS VISIBILITY. *TR
Visibility, Oct 28, 2008
TL*THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING APPROXIMATELY 40 MPH ON NORMAL ROAD CONDITIONS, THE FRONT PASSENGER SIDE POWER WINDOW RELEASED IN A DOWNWARD POSITION WITHOUT ASSISTANCE. THE INCIDENT OCCURRED WITHOUT WARNING. THE CONTACT IS IN THE PROCESS OF TAKING THE VEHICLE TO AN AUTHORIZED DEALER FOR REPAIR. HE WAS CONCERNED OF THE SAFETY RISK INVOLVED. THE VIN WAS UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE 28,000.
Visibility, Oct 28, 2008
TL*THE CONTACT OWNS A 2005 FORD F150. THE CONTACT STATED THAT THE WINDOW REGULATORS FAILED AND CAUSED THE WINDOW TO SPONTANEOUSLY FALL INTO THE DOOR. HE TOOK THE VEHICLE TO THE DEALER AND THEY STATED THAT THE REGULATOR NEEDED TO BE REPLACED AT THE COST OF $300. IN ADDITION, THE TECHNICIAN REPLACED THE FAILED COMPONENT WITH A NEW REGULATOR OF THE SAME DESIGN. THE VEHICLE IS CURRENTLY BEING REPAIRED. THE CONTACT CALLED THE MANUFACTURER AND THEY ACKNOWLEDGED THE FAILURE; HOWEVER, THEY WOULD NOT ASSUME RESPONSIBILITY SINCE THERE WAS NO RECALL. THE FAILURE MILEAGE WAS 38,000 AND CURRENT MILEAGE WAS 46,000.
Visibility, Oct 21, 2008
ANOTHER WINDOW DROPS DOWN INSIDE MY DOOR. THIS IS DEFINITELY DUE TO FAULTY EQUIPMENT. FORD USED CHEAP PLASTIC ON THEIR WINDOW REGULATORS THAT IS NOT SUITABLE FOR THE PURPOSE. *TR
Visibility, Oct 20, 2008
WINDOWS FAILURE,WILL NOT GO UP. *TR
Visibility, Oct 16, 2008
MY WIFE WENT OUT THIS MORNING TO TAKE THE KIDS TO SCHOOL AND THE DRIVERS SIDE WINDOW HAS FALLEN DOWN IN THE DOOR. WE ARE STILL TRYING TO GET A HOLD OF THE NEAREST FORD DEALERSHIP TO GET THIS FIXED. I HAVE READ SEVERAL FORUMS THAT SAY THIS IS A COMMON OCCURRENCE. WHY IS THIS NOT A RECALL? *TR
Visibility, Oct 13, 2008
2005 FORD 150 4X4 KING RANCH CREW CAB. AT 60K MILES, DRIVER'S WINDOW FELL DOWN INTO DOOR. MECHANISM FAILED. FORD DEALERSHIP IN SANTA FE, NM REPAIRED FOR $350.00. THEY CLAIMED THEY'D NEVER SEEN IT BEFORE BUT SINCE HAVE SEEN NUMEROUS COMPLAINTS OF THIS WINDOW MECHANISM DESIGN FAULT. THIS SHOULD BE A RECALL BY FORD. *TR
Visibility, Oct 8, 2008
2005 FORD F-150 SUPER CREW PICKUP WINDOW REGULATORS BREAK (QUITE COMMONLY), CAUSING THE WINDOW TO NO LONGER HAVE ANY SUPPORT. THE WINDOW THEN CAN FALL ABRUPTLY AT ANY TIME, INCLUDING WHILE DRIVING THE VEHICLE. WHEN THIS HAPPENS, THE DRIVER TENDS TO THINK THAT THE VEHICLE HAS GOTTEN HIT BY SOMETHING LARGE, AND SWERVES TO AVOID IT. THIS CAN RESULT IN DRIVING OFF OF THE ROAD OR INTO ONCOMING TRAFFIC. FORD DENIES THAT THE WINDOW REGULATORS ARE NOT FIT FOR THEIR INTENDED PURPOSE, AND REFUSES TO RELEASE A PROPERLY ENGINEERED PART. A CURSORY EXAMINATION OF THE REGULATOR WILL SHOW THAT IT IS NOT DESIGNED TO HANDLE THE LOADS AND STRESSES THAT EXIST IN THE WINDOW SYSTEM. REPLACING THE PART WITH THE CURRENT DESIGN ONLY STARTS THE CLOCK OVER ON WHEN THE WINDOW WILL FALL AGAIN. AFTER-MARKET REGULATORS ARE NOT AVAILABLE. PLEASE INSIST THAT FORD RECALL THESE FAULTY WINDOW REGULATORS AND REPLACE THEM WITH PROPERLY ENGINEERED UNITS THAT WILL NOT FAIL IN SUCH AN ABRUPT WAY. *TR
Visibility, Oct 7, 2008
THE DRIVER SIDE POWER WINDOW REGULATOR HAS FAILED AND THE WINDOW WILL NOT ROLL UP. IT HAPPENED WHILE I WAS OUT OF TOWN AND IT WAS RAINING. THIS IS A HUGE SAFETY RISK. APPARENTLY, AFTER DOING VERY LITTLE RESEARCH ON THE INTERNET, THERE ARE A LOT OF FOLKS HAVING THE SAME PROBLEMS. NOT ONLY DID THIS LEAVE MY VEHICLE OPEN TO THE ELEMENTS, IT ALSO LEFT IT OPEN TO ANYONE WHO WANTED TO HELP THEMSELVES TO THE VEHICLE OR IT'S CONTENTS. I AM VERY CONCERNED THAT THIS WILL HAPPEN AGAIN. *TR