2005 Ford F-150
Problems, recalls and owner-reported issues
Visibility is the leading concern among 1,121 owner complaints filed for this model year. This is the 4th highest complaint count among 26 F-150 model years with reports.
Of the 2005 reports, 50 involved a crash and 29 involved a fire. 57 people were injured and 2 people died.
What owners report most often
Recalls and investigations
Air bags, frontal, driver side, inflator moduleFeb 23, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2004-2006 F-150 PICK UP TRUCKS AS WELL AS CERTAIN MODEL YEAR 2006 LINCOLN MARK LT VEHICLES. IF THE CLOCKSPRING JUMPER WIRE COMES IN CONTACT WITH THE DRIVER SIDE FRONTAL AIR BAG LOWER HORN PLATE, THE WIRE INSULATION MAY BECOME CHAFED, CREATING A POTENTIAL FOR A SHORT CIRCUIT. IF THIS OCCURS THE AIR BAG WARNING LAMP MAY ILLUMINATE INDICATING THAT SERVICE IS REQUIRED.
THE DRIVER SIDE FRONTAL AIR BAG COULD INADVERTENTLY DEPLOY INCREASING THE RISK OF INJURY OR LOSS OF VEHICLE CONTROL IF OCCURRING WHILE IN MOTION.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN/MERCURY DEALER TO HAVE A NEW CLOCKSPRING JUMPER WIRE INSTALLED THAT INCORPORATES A PROTECTIVE MESH COVER. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THIS SAFETY RECALL BEGAN ON SOME VEHICLES IN MARCH 2011. THE RECALL CAMPAIGN ON THE EXPANDED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT MAY 9, 2011. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Campaign 11V107000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Service brakes, hydraulic, power assist, vacuum, hoses, lines/piping, and fittingsMay 7, 2008
FORD IS RECALLING 605,684 MY 2005-2006 F-150 AND LINCOLN MARK LT VEHICLES EQUIPPED WITH 5.4L 3-VALVE ENGINES. THE BRAKE BOOSTER VACUUM SUPPLY HOSE ATTACHED TO THE INTAKE MANIFOLD FITTING MAY SWELL OVER TIME AND LOSE RETENTION FORCE. THIS CONDITION COULD ALLOW THE HOSE TO BECOME DETACHED FROM THE FITTING DURING AN INTAKE MANIFOLD BACKFIRE. SHOULD THE HOSE DETACH FROM THE INTAKE MANIFOLD, SEVERAL BRAKE APPLICATIONS WITH POWER ASSIST WILL BE AVAILABLE BEFORE THE VACUUM RESERVE IS DEPLETED.
ONCE THE BRAKE BOOSTER VACUUM RESERVE IS DEPLETED, THE DRIVER WILL HAVE FOUNDATION BRAKE FUNCTION, BUT WITH INCREASED BRAKE PEDAL EFFORT. REDUCED VEHICLE BRAKING COULD LEAD TO A CRASH.
DEALERS WILL REPLACE A RUBBER HOSE ON THE BRAKE BOOSTER VACUUM SUPPLY TUBE ASSEMBLY. THE RECALL BEGAN ON JUNE 27, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 08V208000 on NHTSA.gov
Exterior lighting, headlightsOct 25, 2007
CERTAIN SPYDER HEADLAMP REPLACEMENT ASSEMBLIES SOLD FOR USE ON 2004 THROUGH 2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SPYDER WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2007. OWNERS CAN CONTACT SPYDER AT 866-558-4264.
Campaign 07E089000 on NHTSA.gov
Exterior lighting, headlightsSep 25, 2007
CERTAIN HEADLAMP ASSEMBLIES IMPORTED AND SOLD AS AFTERMARKET EQUIPMENT BY SONAR AUTO PARTS FOR USE ON 2004-2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SONAR WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS CAN CONTACT SONAR AT 866-558-4264.
Campaign 07E080000 on NHTSA.gov
Exterior lighting, headlightsSep 14, 2007
CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. FR390-B001L AND FR390-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE THICKNESS IS UNSTABLE INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
EAGLE EYES WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON NOVEMBER 6, 2007. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.
Campaign 07E075000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Interior lightingFeb 6, 2006
CERTAIN PICKUP TRUCKS FAIL TO COMPLY WITH EITHER THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 105, 'HYDRAULIC AND ELECTRIC BRAKE SYSTEMS' OR FMVSS NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' THESE VEHICLES WERE BUILT WITH A SOFTWARE ERROR IN THE INSTRUMENT CLUSTER.
THIS ERROR COULD PREVENT THE ANTILOCK BRAKE SYSTEM (ABS) WARNING LIGHT FROM ILLUMINATING IF THE ABS MODULE EVER BECAME INOPERATIVE.
DEALERS WILL RECALIBRATE THE INSTRUMENT CLUSTER IN THESE VEHICLES. THE RECALL BEGAN ON FEBRUARY 27, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 06V033000 on NHTSA.gov
Tires, tread/beltNov 21, 2005
CERTAIN CONTINENTAL CONTITRAC TR OWL, CONTITRAC TR BSW, GENERAL GRABBER TR BSW, AND CONTITRAC BSW TIRES MANUFACTURED BETWEEN MAY 29 AND JUNE 11, 2005, AND SOLD AS ORIGINAL EQUIPMENT ON CERTAIN FORD TRUCKS AND SOLD AS REPLACEMENT TIRES. THESE TIRES CAN WEAR PREMATURELY WHICH FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 119, NEW PNEUMATIC TIRES FOR VEHICLES OTHER THAN PASSENGER CARS.
AFFECTED TIRES MAY NOT MEET THE ENDURANCE TEST REQUIREMENTS OF THE STANDARD. CONTINUED USE OF THE AFFECTED TIRES CAN RESULT IN TIRE FAILURE WHICH COULD LEAD TO VEHICLE DAMAGE OR MOTOR VEHICLE CRASH.
CONTINENTAL WILL NOTIFY OWNERS AND REPLACE THE TIRES FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 7, 2005. OWNERS MAY CONTACT CONTINENTAL AT 704-588-5895.
Campaign 05T022000 on NHTSA.gov
Representative owner complaints
1,121 reports, newest first.
Air bags, Feb 25, 2011
TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT WOULD ILLUMINATE ON AN INTERMITTENT BASIS. THE VEHICLE WAS INSPECTED BY A DEALER BUT THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS ALSO CONTACTED AND OFFERED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 67,100. UPDATED 03/24/11*LJ UPDATED 05/05/11
Electrical system, Feb 24, 2011
THE TRUCK HAD SEVERAL CRANK-NO START PROBLEMS. IT CONTINUED OVER A PERIOD OF A FEW WEEKS. VEHICLE FINALLY GOT TO THE POINT IT WOULD NOT RESTART. IT WAS A LITTLE HESITANT AT TIMES WHEN RUNNING AND I WAS AFRAID IT WOULD DIE ON ME IN TRAFFIC. WE RAN A DIAGNOSTIC CHECK ON VEHICLE IN BEGINNING AND RETRIEVED CODE FOR THE CAM SENSOR. WE REPLACED AND IT DROVE FINE FOR ONE WEEK. THAT'S THE POINT WHERE IT WOULD NOT START. WE HAD TOWED TO DEALERSHIP AND UPON THEIR DIAGNOSIS HAS DETERMINED THAT THE ENGINE WIRE HARNESS FROM THE FICM TO PCM AND TO THE INJECTORS HAD SHORTS IN IT. I HAVE READ ON A PREVIOUS RECALL # 05V270000, WHERE THE FICM WIRE HAD TO BE REPLACED. I AM NOT SURE IF IT IS RELATED, BUT THE DEALERSHIP HAS GIVEN US A PRICE OF $2600.00 TO REPAIR. I BELIEVE AN ENGINE WIRING HARNESS SHOULD BE DESIGNED TO LAST LONGER THAN 6 YEARS. *TR
Engine and engine cooling, Fuel system, Other, Feb 23, 2011
I OWN A 2005 FORD F-150 WHICH I RECEIVED A LETTER FROM FORD STATING THAT MY FUEL INJECTORS WERE GIVEN A DEFECT ONLY EXTENDED WARRANTY TO 150,000 MILES. I HAVE HAD A FEW INJECTORS REPLACED SINCE THE LETTER BECAUSE OF DEFECT..I.E WHITE SMOKE FROM EXHAUST AND STUTTER OF ENGINE WHILE DRIVING. RIGHT AFTER MY LAST REPLACEMENT OF A FUEL INJECTOR MY CATALYTIC CONVERTER WAS GIVING A BAD ODOR..AFTERWARDS I HAD A DIAGNOSTIC CHECKED AND THE OUTCOME WAS A BAD CONVERTER. AFTER SEVERAL FORUMS I HAVE READ I HAVE NOTICED THAT SEVERAL....SEVERAL.. PEOPLE HAVE CATALYTIC CONVERTER PROBLEMS AFTER THE REPLACEMENT OF FUEL INJECTORS..SOME EVEN HAVING TWO OR THREE REPLACED WITHIN JUST A FEW THOUSAND MILES AND AFTER HAVING ANOTHER FUEL INJECTOR REPLACED. IS THE FUEL INJECTOR PROBLEM A PROBLEM FOR THE CONVERTER..ITS A BIG COINCIDENCE THAT SO MANY HAVE HAD THE SAME PROBLEMS AFTER REPLACING DEFECTIVE FUEL INJECTORS.. *TR
Engine and engine cooling, Feb 23, 2011
TL* THE CONTACT OWNS A 2005 FORD F150. THE CONTACT STATED THAT THE VEHICLE EXHIBITED AN ABNORMAL GRINDING NOISE FROM THE ENGINE WHETHER THE VEHICLE WAS PARKED OR IN MOTION. THE VEHICLE WAS TAKEN TO THE DEALER BUT THE MECHANIC WAS UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 105,000.
Service brakes, Hydraulic, Feb 23, 2011
TL* THE CONTACT OWNS A 2005 FORD F150. WHILE DRIVING APPROXIMATELY 20 MPH, THE CONTACT APPLIED PRESSURE TO THE BRAKE PEDAL BUT THE VEHICLE WOULD NOT RESPOND. THE VEHICLE WAS TAKEN TO THE DEALER YET THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS CONTACTED AND STATED THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 08V208000 (SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM:HOSES, LINES/PIPING, AND FITTINGS) BUT THE CONTACTS VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 105,000.
Vehicle speed control, Feb 23, 2011
TL* THE CONTACT OWNS A 2005 FORD F 150 FX. THE CONTACT WAS DRIVING 45 MPH WHEN THE ELECTRONIC THROTTLE CONTROL LAMP ILLUMINATED AND THE VEHICLE BEGAN TO DECELERATE INDEPENDENTLY. THE CONTACT ATTEMPTED TO ACCELERATE BUT THE VEHICLE WOULD NOT RESPOND. THE VEHICLE THEN STALLED BUT WAS ALE TO BE RESTARTED YET THE FAILURE RECURRED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS CONTACTED AND ADVISED THAT THEY WERE AWARE OF THE FAILURE AND WERE UNABLE TO OFFER ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 74,000.
Air bags, Feb 23, 2011
TL* THE CONTACT OWNS A 2005 FORD F150. THE CONTACT STATED THAT THE AIR BAG LIGHT WOULD ILLUMINATE INTERMITTENTLY WHILE DRIVING ANY SPEED. THE DEALER WAS CONTACTED AND ADVISED THAT THERE WERE NO RECALLS ON THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 105,000.
Engine and engine cooling, Electrical system, Other or unspecified, Feb 4, 2011
WHILE DRIVING VEHICLE AT ANY SPEED FROM 10 MPH TO 70 MPH THE TRUCK WILL GO INTO SAFE MODE (LIMP-HOME MODE) GOING DOWN TO 5 MPH AND LOSING ALL POWER STEERING. WHEN DIAGNOSED IT IS THE THROTTLE BODY CONTROL TO ME THIS IS A SAFETY ISSUE WHAT HAPPENS IF I AM DRIVING 70 MPH ON THE HIGHWAY AND IT GOES INTO SAFETY MODE AND I LOSE ALL POWER STEERING. DOES SOMEONE HAVE TO DIE BEFORE THERE IS A RECALL ON THIS??? IT WILL COST ME AROUND $1000.00 TO FIX PER BRONDES FORD IN TOLEDO OHIO AND I AM TOLD FORD HAS 2 OR 3 VEHICLES A WEEK COME IN FOR THE SAME PROBLEM. TO ME THIS IS NOT STANDARD MAINTENANCE.
Engine and engine cooling, Feb 3, 2011
ATTEMPTED TO HAVE SPARK PLUGS CHANGED IN ACCORDANCE WITH VEHICLE MAINTENANCE MANUAL AT 100,000 MILE. WHILE THIS WAS BEING DONE 3 FACTORY INSTALLED MOTORCRAFT SPARK PLUGS BROKE OFF. AS A RESULT I WAS CHARGED A TOTAL OF ALMOST $700 FOR THE REMOVAL OF THESE BROKEN PLUGS. THE DEALERSHIP TECHNICIAN INFORMED ME THAT 100% OF ALL 2004-2007 F150 TRUCKS THAT HAVE THE PLUGS REMOVED AS REQUIRED AT 100,000 MILES HAVE PLUGS THAT BREAK. FORD NOR THE DEALERSHIP WOULD COVER THE COST OF THIS DEFECTIVE PRODUCT AND DEFECTIVE FORD DESIGN. *TR
Structure, Jan 27, 2011
POOR QUALITY PAINT ON MY 2005 FORD F-150. IT HAS BEGUN PEELING AND EXPOSING THE PRIMER. *TR
Wheels, Jan 19, 2011
MY FORD F-150, 2005 MODEL HAS A WHEEL BEARING DEFECT THAT CAUSES BEARING FAILURE AND BRAKE WOBBLE DUE TO THE WEAK BEARINGS THAT'S ON 2004-2009 FORD F-150- 2WD TRUCKS. THE BEARINGS CAN'T BE CHANGED UNLESS YOU PURCHASE THE ENTIRE INSTALLATION (ROTORS, ABS HUB BEARING AND ONE-TIME USE NUT.) FORD KNOWS THAT THE BEARINGS ARE WEAK BUT WILL NOT AUTHORIZE A REPAIR UNLESS YOU USE ORIGINAL EQUIPMENT. FORD PUT OUT A BULLETIN TO USE 4X4 PARTS ON THE 2WD VEHICLE. THE 4X4 PARTS INCLUDES 3 PIECES WHICH INCLUDED A MORE DURABLE AND HARDER BEARING THAN WHAT COMES ON THE 2WD. THERE IS ONLY ONE PLACE IN TEXAS THAT WILL DUE THIS REPAIR (JUST BRAKES.) THE REPAIR IS 300.00 PER SIDE BUT IS A PERMANENT FIX FOR THE WEAK BEARINGS. ALSO EACH PART CAN BE CHANGE INDIVIDUALLY. FORD WILL SELL YOU THE PARTS BUT THEY WILL NOT MAKE THIS REPAIR TO YOUR VEHICLE. THE BEARINGS HAVE A CONSTANT HUMMING NOISE AND THE BIGGEST MISTAKE THAT IS MADE IS THAT. THE NUT IS NOT CHANGE WHEN THE BREAKS ARE BEARINGS ARE REPLACED. BY NOT CHANGING THE NUT THE TORQUE VALUE CAN'T BE REACHED AGAIN. I HAD THIS REPAIR DONE AT JUST BRAKES AND MY TRUCK HASN'T RIDEN THIS WELL IN 2 YRS. FORD NEEDS TO BE REQUESTED TO REIMBURSE ALL OWNERS THAT HAVE HAD THIS PROBLEM. IT IS A VERY DANGEROUS MATTER. *TR
Visibility, Jan 17, 2011
THE CONTACT OWNS A 2005 FORD F-150. THE CONSUMER STATED THE DRIVER'S SIDE WINDOW FELL INTO THE DOOR, THEN THE FRONT PASSENGER SIDE WINDOW FELL INTO THE DOOR A FEW MONTHS LATER. THE DEALER REPLACED THE REGULATOR ASSEMBLY ON THE FRONT DRIVER'S SIDE WINDOW AT NO CHARGE BECAUSE IT WAS STILL UNDER WARRANTY. THE FRONT PASSENGER WINDOW WAS NOT COVERED BECAUSE THE WARRANTY HAD JUST RUN OUT. THE DRIVER'S SIDE REAR WINDOW GLASS FELL INSIDE THE DOOR IN 2010. THE BACK WINDOW QUIT WORKING JUST AFTER THE WARRANTY RAN OUT. WE NEVER GOT IT REPAIRED. EACH REPAIR COST US OVER $300.
Power train, Jan 8, 2011
I HAVE A 05 FORD F150 AND MY DIFFERENTIAL HAS GONE OUT AND NEEDS TO BE REBUILT I HAD THIS ISSUE WHILE UNDER WARRANTY BUT FORD ALWAYS FOUND EXCUSES AND NOW THAT ITS OUT OF WARRANTY I STARTED TO RESEARCH AND I HAVE FOUND ALOT OF COMPLAINTS WHERE PEOPLE COMPLAIN OF LOUD NOISE AND VIBRATIONS AT THE ABOVE SPEEDS OF 45MPH. *LN
Power train, Jan 6, 2011
TRUCK WOULD IDLE EXTREMELY BAD, WHEN YOU CUT IT OFF IT WOULDN'T START. THIS STARTED HAPPENING ON FRIDAY, DECEMBER 31, 2010. I TOOK THE TRUCK TO FIRESTONE AND THEY RUN A DIAGNOSTIC TEST WHICH AT THE TIME DID NOT SHOW THE THROTTLE BODY PROBLEM BECAUSE THE "CHECK ENGINE" LIGHT WAS NOT ON AT THE TIME. HOWEVER, FIRESTONE REPLACED THE FUEL FILTER, DID A TUNE UP AND REPLACED THE BATTERY AND REMOVED THE GAS TANK TO CLEAN IT BUT THIS STILL DID NOT RESOLVE THE PROBLEM AND THIS COST ME $369. THE TRUCK WAS THEN TAKEN TO A FORD DEALERSHIP AND ON THE WAY THERE THE "CHECK ENGINE" LIGHT DID COME ON. THE DEALERSHIP ADVISED US AFTER THE DIAGNOSTIC TEST THAT WE NEEDED A THROTTLE BODY AND ELECTRONIC EGR VALVE WHICH WILL COST $1330.00. *TR
Engine and engine cooling, Jan 6, 2011
2005 F150 JUST DIES WITHOUT ANY WARNING. DRIVING DOWN THE HWY AND JUST DIES. IT HAPPENS FREQUENTLY, JUST DIES, IT ALWAYS TAKES A FEW TRIES TO GET IT RESTARTED. WE WERE TOLD THAT THE THROTTLE BODY NEEDS TO BE REPLACED. WE KNOW AT LEAST 4 OTHER FAMILYS THAT ALSO HAVE 2005 F150'S AND THEY HAVE EXPERIENCED THE SAME PROBLEM. MY CO-WORKER HAS HERS IN THE FORD SHOP RIGHT NOW AND THEY ARE CHARGING 1300.00 TO FIX IT. IT SEEMS TO ME THAT WITH ALL OF THE COMPLAINTS THIS SHOULD BE A SAFETY RECALL AND REPLACED BY FORD CO. *TR
Power train, Jan 2, 2011
ON CERTAIN MODEL FORD VEHICLES USING THEIR 5.4 LITER ENGINE (WHICH INCLUDES FORD/LINCOLN MODELS) THE SPARK PLUGS ARE OF A 3 PART DESIGN WHICH WILL SEPARATE AND SHOOT OUT OF THE TOP OF THE ENGINE WHILE RUNNING CAUSING SERIOUS INJURY OR EVEN DEATH AND EXTENSIVE DAMAGE TO THE ENGINE. FORD IS AWARE OF THIS PROBLEM AS I HAVE BEEN TOLD BY SEVERAL SERVICE MANAGERS BUT FORD REFUSES TO DO ANYTHING ABOUT IT BECAUSE FOR EVERY VEHICLE REPAIR IS A 1500.00 REPAIR BILL FOR THE DEALER/FORD. FOR PEOPLE WHOM DON'T HAVE 1500.00 TO REPLACE SPARK PLUGS WHICH SHOULD BE A 50.00 REPAIR, THEY REMAIN AT RISK. *TR
Fuel system, Gasoline, Dec 28, 2010
TL* THE CONTACT OWNS 2005 FORD F150. THE CONTACT STATED THAT THE VEHICLE WAS EMITTING AN OVERPOWERING ODOR OF GASOLINE FUEL. THE ODOR WAS MOST PROMINENT WHEN THE VEHICLE WAS AT A COMPLETE STOP. THE VEHICLE WAS TAKEN TO THE DEALER YET THE VEHICLE WAS NOT REPAIRED. THE CONTACT ALSO CONTACTED THE MANUFACTURER AND WAS ADVISED TO TAKE THE VEHICLE BACK TO THE DEALER. NO FURTHER ASSISTANCE WAS OFFERED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE FAILURE AND CURRENT MILEAGES WAS 87,240.
Engine and engine cooling, Fuel system, Other, Dec 28, 2010
SPARK PLUGS BREAKING OFF IN ENGINE HEAD BECAUSE OF POOR DESIGN. JUST HAPPENED TO ME AND AFTER LOOKING AROUND THE INTERNET IT HAS HAPPENED TO A LOT OF PEOPLE AND NOW THE SERVICE DEPARTMENT OF MY LOCAL FORD DEALERSHIP SAYS IT COMMON AND NOW THEY ARE CHARGING ME BECUASE THEY BROKE IT AND ITS COMMON. *TR
Power train, Equipment, Dec 28, 2010
ORIGINAL FLYWHEEL BROKEN. TOLD WILL COST $1K TO $1,4K TO REPLACE THAT AND STARTER B/C FLYWHEEL 'PROBABLY' DAMAGED STARTER. TRUCK WON'T START SOMETIMES, AND GRINDS WHEN I TRY TO START IT. WAS STRANDED 2 TIMES AND HAD TO BE TOWED. *TR
Visibility, Dec 28, 2010
POWER WINDOW REGULATOR FAILED AND NOW I HAVE DUCT TAPE ON MY WINDOW B/C I CAN'T AFFORD THE REPAIR. *TR
Visibility, Dec 27, 2010
WEBASTO - HOLLANDIA 700 SERIES SUNROOF BLEW OFF TRUCK GOING 70 MILES PER HOUR. THE VEHICLE IS A 2005 FORD F-150 KING RANCH SUPER CREW. ON 12/26/2010 - WHILE TRAVELING WITH MY WIFE AND CHILD FROM JACKSONVILLE, FL. TO ATLANTA, GA.AND ON I-10 WEST, 5 MILES FROM I-75 NORTH WHEN MY SUNROOF SUDDENLY RIPPED OFF THE TOP OF MY TRUCK. THE SUNSHADE WAS ALSO RIPPED OUT INSTANTANEOUSLY. FORTUNATELY THE CAR BEHIND ME WAS FAR ENOUGH BACK TO SWERVE AND AVOID BE HIT BY THE GLASS PANEL AND SUNSHADE. I RECOVERED THE GLASS PANEL AND SUNSHADE. *TR
Engine and engine cooling, Dec 21, 2010
TL*THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING. THE FAILURE WAS INTERMITTENT. THE CONTACT CALLED THE MANUFACTURER WHO STATED THAT SOMEONE WOULD INSPECT THE VEHICLE. THERE WERE NO WARNING LIGHTS PRIOR TO THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 71,000 AND THE FAILURE MILEAGE WAS UNKNOWN.
Visibility, Dec 10, 2010
WE OWNED A 2005 F150 VEHICLE. WE PURCHASE THE VEHICLE 2004 AND THE DRIVERS SIDE WINDOW'S REGULATED FAILED A LOUD SOUND WAS HEARD AND THE WINDOW CAME DOWN BY ITSELF. TODAY 12/10/2010 THE PASSENGER SIDE FRONT WINDOW DID THE SAME THING. WE ARE NOW OUT OF WARRANTY AND WITH NO MONEY TO PAY FOR THE WINDOW. THERE HAS BEING SO MANY COMPLAINS IN THE INTERNET ABOUT THIS PARTICULAR ISSUE THAT IF THE RESEARCH IS DONE YOU WILL FIND THIS IS A DEFECT SINCE BEFORE THE 2005 WERE MADE. I DON'T BELIEVE THAT THE CONSUMER HAS TO PAY FOR A MANUFACTURE DEFECT OF THIS KIND. *TR
Electrical system, Dec 3, 2010
TL*THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING 5 MPH, THE ENGINE FAIL SAFE LIGHT ILLUMINATED AND THE VEHICLE SUDDENLY STOPPED ON A RAILROAD TRACK. THE CONTACT STATED THAT THE FAILURE ALSMOST CAUSED A CRASH. THE VEHICLE WOULD NOT MOVE ALTHOUGH THE ENGINE WAS STILL RUNNING. THE FAILURE COULD NOT BE DIAGNOSED BY THE DEALER. THE FAILURE MILEAGE WAS APPROXIMATELY 46,000.
Air bags, Dec 1, 2010
TL*THE CONTACT OWNS A 2005 FORD F150. WHILE ATTEMPTING TO START THE VEHICLE, THE AIR BAG DEPLOYED WITHOUT WARNING. THE DEALER WAS CONTACTED, BUT OFFERED NO ASSISTANCE. THE MANUFACTURER WAS NOTIFIED, BUT OFFERED NO ASSISTANCE AS WELL. THE VEHICLE WAS NOT REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 76,000. UPDATED 01/11/11*LJ