2005 Ford F-150
Problems, recalls and owner-reported issues
Visibility is the leading concern among 1,121 owner complaints filed for this model year. This is the 4th highest complaint count among 26 F-150 model years with reports.
Of the 2005 reports, 50 involved a crash and 29 involved a fire. 57 people were injured and 2 people died.
What owners report most often
Recalls and investigations
Air bags, frontal, driver side, inflator moduleFeb 23, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2004-2006 F-150 PICK UP TRUCKS AS WELL AS CERTAIN MODEL YEAR 2006 LINCOLN MARK LT VEHICLES. IF THE CLOCKSPRING JUMPER WIRE COMES IN CONTACT WITH THE DRIVER SIDE FRONTAL AIR BAG LOWER HORN PLATE, THE WIRE INSULATION MAY BECOME CHAFED, CREATING A POTENTIAL FOR A SHORT CIRCUIT. IF THIS OCCURS THE AIR BAG WARNING LAMP MAY ILLUMINATE INDICATING THAT SERVICE IS REQUIRED.
THE DRIVER SIDE FRONTAL AIR BAG COULD INADVERTENTLY DEPLOY INCREASING THE RISK OF INJURY OR LOSS OF VEHICLE CONTROL IF OCCURRING WHILE IN MOTION.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN/MERCURY DEALER TO HAVE A NEW CLOCKSPRING JUMPER WIRE INSTALLED THAT INCORPORATES A PROTECTIVE MESH COVER. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THIS SAFETY RECALL BEGAN ON SOME VEHICLES IN MARCH 2011. THE RECALL CAMPAIGN ON THE EXPANDED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT MAY 9, 2011. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Campaign 11V107000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Service brakes, hydraulic, power assist, vacuum, hoses, lines/piping, and fittingsMay 7, 2008
FORD IS RECALLING 605,684 MY 2005-2006 F-150 AND LINCOLN MARK LT VEHICLES EQUIPPED WITH 5.4L 3-VALVE ENGINES. THE BRAKE BOOSTER VACUUM SUPPLY HOSE ATTACHED TO THE INTAKE MANIFOLD FITTING MAY SWELL OVER TIME AND LOSE RETENTION FORCE. THIS CONDITION COULD ALLOW THE HOSE TO BECOME DETACHED FROM THE FITTING DURING AN INTAKE MANIFOLD BACKFIRE. SHOULD THE HOSE DETACH FROM THE INTAKE MANIFOLD, SEVERAL BRAKE APPLICATIONS WITH POWER ASSIST WILL BE AVAILABLE BEFORE THE VACUUM RESERVE IS DEPLETED.
ONCE THE BRAKE BOOSTER VACUUM RESERVE IS DEPLETED, THE DRIVER WILL HAVE FOUNDATION BRAKE FUNCTION, BUT WITH INCREASED BRAKE PEDAL EFFORT. REDUCED VEHICLE BRAKING COULD LEAD TO A CRASH.
DEALERS WILL REPLACE A RUBBER HOSE ON THE BRAKE BOOSTER VACUUM SUPPLY TUBE ASSEMBLY. THE RECALL BEGAN ON JUNE 27, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 08V208000 on NHTSA.gov
Exterior lighting, headlightsOct 25, 2007
CERTAIN SPYDER HEADLAMP REPLACEMENT ASSEMBLIES SOLD FOR USE ON 2004 THROUGH 2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SPYDER WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2007. OWNERS CAN CONTACT SPYDER AT 866-558-4264.
Campaign 07E089000 on NHTSA.gov
Exterior lighting, headlightsSep 25, 2007
CERTAIN HEADLAMP ASSEMBLIES IMPORTED AND SOLD AS AFTERMARKET EQUIPMENT BY SONAR AUTO PARTS FOR USE ON 2004-2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SONAR WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS CAN CONTACT SONAR AT 866-558-4264.
Campaign 07E080000 on NHTSA.gov
Exterior lighting, headlightsSep 14, 2007
CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. FR390-B001L AND FR390-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE THICKNESS IS UNSTABLE INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
EAGLE EYES WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON NOVEMBER 6, 2007. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.
Campaign 07E075000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Interior lightingFeb 6, 2006
CERTAIN PICKUP TRUCKS FAIL TO COMPLY WITH EITHER THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 105, 'HYDRAULIC AND ELECTRIC BRAKE SYSTEMS' OR FMVSS NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' THESE VEHICLES WERE BUILT WITH A SOFTWARE ERROR IN THE INSTRUMENT CLUSTER.
THIS ERROR COULD PREVENT THE ANTILOCK BRAKE SYSTEM (ABS) WARNING LIGHT FROM ILLUMINATING IF THE ABS MODULE EVER BECAME INOPERATIVE.
DEALERS WILL RECALIBRATE THE INSTRUMENT CLUSTER IN THESE VEHICLES. THE RECALL BEGAN ON FEBRUARY 27, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 06V033000 on NHTSA.gov
Tires, tread/beltNov 21, 2005
CERTAIN CONTINENTAL CONTITRAC TR OWL, CONTITRAC TR BSW, GENERAL GRABBER TR BSW, AND CONTITRAC BSW TIRES MANUFACTURED BETWEEN MAY 29 AND JUNE 11, 2005, AND SOLD AS ORIGINAL EQUIPMENT ON CERTAIN FORD TRUCKS AND SOLD AS REPLACEMENT TIRES. THESE TIRES CAN WEAR PREMATURELY WHICH FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 119, NEW PNEUMATIC TIRES FOR VEHICLES OTHER THAN PASSENGER CARS.
AFFECTED TIRES MAY NOT MEET THE ENDURANCE TEST REQUIREMENTS OF THE STANDARD. CONTINUED USE OF THE AFFECTED TIRES CAN RESULT IN TIRE FAILURE WHICH COULD LEAD TO VEHICLE DAMAGE OR MOTOR VEHICLE CRASH.
CONTINENTAL WILL NOTIFY OWNERS AND REPLACE THE TIRES FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 7, 2005. OWNERS MAY CONTACT CONTINENTAL AT 704-588-5895.
Campaign 05T022000 on NHTSA.gov
Representative owner complaints
1,121 reports, newest first.
Visibility, Jan 30, 2010
I WAS DRIVING MY 2005 F-150 TRUCK WITH 37,500 MILES ON IT, WHEN I HEARD A RATTLING NOISE COMING FROM MY DRIVERS SIDE WINDOW. IT SOUNDED AS THOUGH THE WINDOW WAS NOT ALL THE WAY UP. I THEN PUSHED THE BUTTON TO WIND THE WINDOW UP AND THEN THE WHOLE WINDOW JUST FELL BACK INTO THE DOOR WITH A LOUD CRASH. I DROVE HOME AND OPENED THE DOOR PANEL TO SEE IF THE WINDOW WAS BROKEN AND IT WAS NOT. I CALLED A FORD DEALERSHIP AND HE SAID IT WAS A COMMON PROBLEM WITH THE WINDOW REGULATOR AND THAT THERE WAS A REDESIGN. I ASKED IF THERE WAS A RECALL ON IT AND THEY SAID THAT FORD DOESN'T CONSIDER IT A SAFETY ISSUE AND THEREFORE A RECALL IS NOT REQUIRED. I SAID THAT I WAS DRIVING DOWN THE ROAD AT 60 MPH AND MY WINDOW FALLS OUT WITH A LOUD BANG DISTRACTING ME AND BEING 35 DEGREES AND RAINING OUT AND THAT IS NOT A SAFETY ISSUE. HE THEN SAID FORD DOESN'T SEE IT THAT WAY. I HAD TO PAY $333 TO FIX A PROBLEM THAT FORD KNOWS ABOUT. *TR
Air bags, Jan 28, 2010
TL*THE CONTACT OWNS A 2005 FORD F150. WHILE DRIVING 2 MPH, THE AIR BAGS DEPLOYED WHILE DRIVING THROUGH A TRAFFIC LIGHT. THE CONTACT WAS ABLE TO SAFELY DRIVE THE VEHICLE HOME. THE DEALER WAS UNABLE TO TELL THE CONTACT WHAT CAUSED THE AIR BAGS TO DEPLOY. A COMPLAINT WAS FILED WITH CONSUMER AFFAIRS. THE FAILURE MILEAGE WAS 92,000. PCO CONTACTED CONSUMER: UNK IF ABL WAS ILLUMINATED AT TIME. DRIVER RECEIVED MINOR BURISES ON ARM. DEALER COULD NOT FIND DAMAGE/FAULT CODES. REPAIR NOT MADE TO DATE. 20100414.PCO
Vehicle speed control, Jan 28, 2010
TL*THE CONTACT OWNS A 2005 FORD F150. THE CONTACT EXPERIENCED RAPID ACCELERATION WHENEVER HE CAME TO A COMPLETE STOP. HE HAD TO USE BOTH FEET ON THE BRAKE PEDAL AND SHIFT INTO NEUTRAL GEAR TO SLOW THE VEHICLE DOWN. THE DEALER STATED THAT THERE WERE NO PROBLEMS WITH THE VEHICLE. THE FORD MANUFACTURER WAS NOTIFIED AND THEY STATED THAT THERE WAS NOTHING WRONG WITH THE VEHICLE. THE FAILURE MILEAGE WAS 53,000.
Fuel system, Gasoline, Jan 27, 2010
FUEL INJECTIONS. I TOOK MY TRUCK IN FOR A WHISTLING PROBLEM. THEY PUT IT ON THE COMPUTER AND TOLD ME EVERYTHING LOOKED GREAT. NO PROBLEMS . TWO DAYS LATER THE TRUCK WAS IN THE DEALERSHIP BECACUSE OF A SMOKING PROBLEM AND THEY REPLACED FUEL INJECTOR #8. A COVERED SERVICE. FORD WAS AWARE OF THE PROBLEM BUT DID NOT SEND RECALL NOTICES. ONE WEEK LATER THE CHECK ENGINE LIGHT CAME ON, THE TRUCK WENT INTO THE SHOP AND THEY REPLACE FUEL INJECTOR # 1 AND #5. NOW I FIND OUT THAT FORD WILL NOT REPLACE ALL THE FUEL INJECTIONS AT ONCE. ONLY WHEN THERE IS A PROBLEM. I ASKED THEM WHY THE COMPUTER SAID EVERYTHING WAS OK AND THEN ENDED UP WITH THE FUEL INJECTOR PROBLEMS. THEY DIDNT HAVE AN ANSWER. FURTHER MORE THE OTHER FUEL INJECTORS CAN GO OUT AT ANY GIVEN TIME. HOPE IM NOT IN THE MOUNTAINS WHEN THAT HAPPENS.*CW
Electrical system, Visibility, Jan 27, 2010
I HAVE A 2005 FORD F150 TRUCK. THE END OF DECEMBER 2009 THE DRIVER'S SIDE WINDOW FELL DOWN. IT STARTED WITH THE ELECTRIC WINDOW BUTTON STICKING AND ENDED UP ALL OF A SUDDEN FALLING DOWN. THE FORD MECHANICS SAID THIS IS NOT UNUSUAL AND COULD HAPPEN TO ALL 4 WINDOWS. THIS IS NOT A COVERED SERVICE FOR REPAIR.*CW
Visibility, Jan 18, 2010
WINDOW REGULATOR ON 2005 F-150 GOT IN MY TRUCK, CLOSED THE DOOR, AND THE WINDOW FELL INTO THE DOOR. READING ONLINE THIS SEEMS TO BE A HUGE ISSUE. IT IS VERY DANGEROUS AND COSTLY. *TR
Visibility, Jan 18, 2010
THE DRIVER WINDOW REGULATOR FAILED ON MY FORD F150 TRUCK. THE WINDOW FELL TO THE BOTTOM OF THE DOOR WITH NO WARNING. REPLACED REGULATOR. *TR
Fuel system, Gasoline, Jan 15, 2010
MY 2005 F-150 LARIAT FORD PICKUP TRUCK SUDDENLY BEGAN TO SURGE AS I WAS PULLING INTO MY DRIVEWAY. WHITE SMOKE WAS BILLOWING OUT THE TAIL PIPE. I WAS ABLE TO COMPLETE PARKING OF THE VEHICLE. I TURNED OFF THE ENGINE AND THEN TRIED RESTARTING BUT IT WOULD NOT START. I CALLED A NEARBY FORD DEALER AND THEY DISPATCHED A WRECKER TO BRING THE TRUCK TO THE FORD DEALER GARAGE LOCATED A FEW MILES AWAY. ONCE THE TRUCK WAS LOOKED AT THE DEALER CALLED TO INFORM ME THAT A FUEL INJECTOR HAD GONE BAD AND THAT FORD WAS AWARE OF THE PROBLEM AND HAD EXTENDED THE WARRANTY ON THIS MODEL YEAR OF PICKUP TRUCK TO 111,000 MILES. THE TRUCK WAS OUT OF THE 35,000 MILES WARRANTY. FORD SAID THERE WOULD BE NO CHARGE TO REPAIR THE INJECTOR. I'M WONDERING WHY THERE WAS NO RECALL BY FORD SINCE THEY ADMIT THEY ARE AWARE OF THE PROBLEM. SHOULD THE INJECTOR HAVE FAILED WHILE DRIVING AT A HIGHER SPEED THERE COULD HAVE BEEN AN ACCIDENT AND POSSIBLE LOSS OF LIFE. *TR
Vehicle speed control, Jan 15, 2010
TL*THE CONTACT OWNS A 2005 F-150 CREW CAB. WHILE DRIVING 50 MPH THE VEHICLE ACCELERATED PAST ANOTHER VEHICLE. THE VEHICLE STARTED TO SPUTTER AND LOST POWER CAUSING THE CONTACT TO APPLY THE BRAKES TO AVOID A CRASH. THE VEHICLE NEARLY ACCELERATED INTO TRAFFIC WHICH COULD HAVE CAUSED A CRASH. THE CONTACT STATED THAT THIS IS A MANUFACTURERS DEFECT. THE FAILURE MILEAGE WAS 100,000.
Engine and engine cooling, Jan 11, 2010
COIL ON PLUG KEEPS MISS FIRING . THEY WERE CHANGED TWICE. FORD WANTS TO DO A VALVE JOB TO FIX THE PROBLEM . THE TRUCK HAS ONLY 57000 MILES ON IT. *TR
Electrical system, Jan 11, 2010
I WAS DRIVING @ 45MPH WHEN ENGINE SUDDENLY STALLED OUT AND LOST ALL POWER, RPMS, AND POWER STEERING. CHECK ENGINE LIGHTS CAME ON, ALONG WITH "CHECK GAUGES" MESSAGE. PULLED OVER, TURNED OFF TRUCK, THEN STARTED UP AND EVERYTHING WAS FINE AGAIN. THIS IS THE SECOND TIME THIS HAS HAPPENED. SINCE EVERYTHING IS WORKING AGAIN, IT WONT GIVE A DIAGNOSTIC CODE, SO PROBLEM CANNOT BE FIXED. I HAVE READ ALOT ONLINE OF THIS HAPPENING TO OTHERS, BUT FORD SEEMS OBLIVIOUS TO THE FACT. SOME SAY IT COULD BE A THROTTLE POSITIONING SENSOR. *TR
Visibility, Jan 11, 2010
YOUR SITE SHOWS A HIGH NUMBER OF COMPLAINTS ON THE VEHICLE I OWN, A 2005 FORD F-150, IN WHICH PEOPLE ARE STARTLED WHEN A SIDE WINDOW ON THIS VEHICLE "POPS" LOUD ENOUGH TO BE A GUNSHOT, THEN FALLS INTO THE DOORFRAME. IN READING THEIR COMPLAINTS YOU CAN SEE HOW LUCKY SOME OF THEM WHERE TO AVOID AN ACCIDENT. MUCH LESS HAVING TO PAY ~$400. TO HAVE IT REPAIRED BY FORD. THIS CLEARLY IS A DESIGN FLAW THAT SHOULD BE CORRECTED AND PAID FOR BY FORD MOTOR CO. MY QUESTION TO YOU IS, WHY HAVEN'T YOU INVESTIGATED THIS MATTER YET??? *TR
Service brakes, Hydraulic, Jan 7, 2010
HAD TO REPLACE WHEEL BEARING, PADS AND ROTORS AT 33000 MILES. 5000 MILES LATER CALIPER FROZE LOCKING BRAKES. ANOTHER BRAKE JOB HAD TO BE DONE. *TR
Power train, Jan 7, 2010
FOUR WHEEL DRIVE DOES NOT ENGAGE. NO INDICATOR LAMPS. FORD HAD TO REPLACE 4X4 MOTOR. 34,000 MILES BUT 38 MONTHS SO WAS NOT COVERED UNDER WARRANTY. *TR
Power train, Jan 7, 2010
FRONT WHEELS DO NOT ENGAGE INTO 4-WHEEL DRIVE. INDICATOR LAMPS DISPLAY THAT SYSTEM IS ENGAGED AND FUNCTIONING PROPERLY CAUSING A FALSE SINCE OF SECURITY WHEN TRAVELING ON SNOW COVERED ROADS. MECHANIC REPLACED PART # 7LIZ-3C247-A (ACTUATOR). A COUPLE OF MECHANICS SAID IT WAS A POOR DESIGN AND THIS VACUUM SYSTEM WAS PRONE TO WATER AND DIRT AND WOULD EVENTUALLY HAVE TO BE REPLACED AGAIN. *TR
Engine and engine cooling, Jan 5, 2010
WHILE TRAVELING THROUGH A TUNNEL AT APPROX.55 MPH THE ENGINE ON MY 2005 F-150 WITH A 5.4 LITER ENGINE QUIT RUNNING AT FULL SPEED AND WENT INTO WHAT FORD CALLS LIMP MODE. LUCKILY THERE WAS NO OTHER VEHICLE BEHIND ME OR I WOULD NOT BE HERE TO WRITE THIS. THE TRUCK HAS SINCE THIS INCIDENT QUIT RUNNING ALL TOGETHER SEVERAL DIFFERENT TIMES. I TOOK THE VEHICLE BACK TO WHERE IT WAS PURCHASED AND WAS CHARGED $75 TO DIAGNOSE THE PROBLEM. THEY SAID THAT THE THROTTLE BODY WAS NOT FUNCTIONING PROPERLY AND IT WOULD COST $450 TO REPLACE. FORD KNOWS OF THIS PROBLEM AND WILL DO NOTHING TO REPAIR THE DEFECTIVE PARTS ON THEIR OWN. THE DEALER THAT IS DOING THE REPAIRS SAID THAT THERE ARE 397 OF THESE PARTS ON BACK ORDER, THAT SHOULD TELL THEM SOMETHING! THIS COULD BE A LIFE THREATENING DEFECT THAT THE FORD MOTOR CO. WILL NOT TAKE RESPONSIBILITY FOR. *TR
Fuel system, Gasoline, Jan 3, 2010
DRIVING HOME @ (HIGHWAY SPEED 55+) FROM A FAMILY GATHERING. SERVICE ENGINE LIGHT ILLUMINATED. ENGINE LOST POWER. I TRIED TO ACCELERATE. NO THROTTLE RESPONSE. ENGINE STALLED. HAD TO FIND PLACE TO PULL OVER WITH NO POWER STEERING. RETURNED GEAR SELECTOR TO P. TURNED IGNITION TO OFF POSITION. RESTARTED AND COMPLETED TRIP. 50+ MILES. THIS EVENT HAS OCCURRED TWO TIMES. I HAVE BEEN VERY LUCKY THAT I HAD A PLACE TO PULL OVER AND RESTART THE VEHICLE. IF I HAD BEEN ENTERING OR DRIVING IN HIGH SPEED TRAFFIC THIS FAILURE COULD HAVE CAUSED A MAJOR ACCIDENT. I READ DISCUSSIONS ON 2005 F150 WEB SITE THAT RELATE TO THIS TYPE FAILURE. SCANNED FOR ENGINE CODES. TPS FAULT CODE. REPLACE THROTTLE BODY. I WILL RETAIN OLD PARTS. *TR
Visibility, Dec 31, 2009
I WAS DRIVING DOWN THE ROAD IN MY 2005 FORD F-150 WHEN I HEARD A LOUD POP, IT WAS MY DRIVERS SIDE WINDOW THAT JUST GAVE OUT ON ITS OWN. NOW THIS SAME PROBLEM HAS HAPPENED TO MY PASSENGER SIDE WINDOW NEARLY 3 MONTHS AGO. IT A HAZARD FOR THE SIMPLE FACT THAT I DRIVING ON THE ROAD AND IT SPOOOKED THE '!@#$% OUT OF ME CAUSING ME TO SWERVE ON THE OTHER LANES. PLEASE HAVE THIS PART RECALLED IMMEDIATELY. IT HAS HAPPENED TO ME TWICE AND MY OLDER BROTHER ALSO HAS A F-150 AND HIM TOO HAS HAD THIS PROBLEM!!! *TR
Visibility, Dec 31, 2009
WINDSHIELD WIPER MOTOR FAILURE. MY WINDSHIELD WIPERS CEASED TO WORK DURING A SNOW STORM. FORTUNATELY I WAS ABLE TO RETURN HOME WITHOUT ANY INCIDENTS. I WAS ABLE TO CHECK THE FUSE AND SUBSEQUENTLY REMOVED AND TESTED THE MOTOR AT WHICH TIME I FOUND THAT THE MOTOR IS SEIZED. I SUBSEQUENTLY FOUND THAT THERE IS A SAFETY RECALL FOR A SIMILAR PROBLEM ON THE NEXT MODEL YEAR OF MY VEHICLE. RECALL NUMBER 05V520000 COVERS 2006 F-150'S I HAVE A 2005 FORD F-150. *TR
Service brakes, Hydraulic, Dec 30, 2009
LOSS OF BRAKES, BRAKING WHILE GOING DOWNHILL, LOSS OF BRAKES, ABS NOT WORKING THEN WORKING. *TR
Power train, Dec 30, 2009
TRANSMISSION FAILED WHILE DRIVING. LEAVING ME STRANDED ON THE HIGHWAY. FRONT BEARING WENT OUT ,ROOT CAUSE OF FAILURE ACCORDING TO AAMCO MECHANIC. TRUCK ONLY HAS 49,000 MILES. TRUCK HAS ALWAYS HAD A VIBRATION . LANCE CUNNINGHAM FORD ALWAYS POINTED TO TIRES, DRIVE SHAFT. I BELIEVE THAT THE TRUE PROBLEM HAS NOW CAME TO LIGHT. UNFORTUNATELY THE ORIGINAL WARRANTY WAS FOR 3 YEARS OR 36,000 MILES. *TR
Visibility, Dec 24, 2009
TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING IN A RAINSTORM AT 65 MPH THE DRIVER-SIDE WINDOW COLLAPSED. WHEN THE FAILURE OCCURRED, HE HEARD A LOUD BANG. HE PULLED OVER AND THEN TOOK THE VEHICLE TO A LOCAL REPAIR FACILITY. A TECHNICIAN STATED THAT THE WINDOW REGULATOR FAILED. HE CALLED THE MANUFACTURER AND WAS REFERRED TO NHTSA. THE VEHICLE HAD NOT BEEN REPAIRED TO-DATE. THE CURRENT MILEAGE WAS 53,547. THE FAILURE MILEAGE WAS APPROXIMATELY 53,520.
Visibility, Dec 24, 2009
WINDOW REGULATOR ON 2005 FORD F150. DRIVING IA A RAINSTORM AND DRIVERS SIDE WINDOW FELL WITH NO WARNING. ALMOST CRASHED ON THE INTERSTATE. *TR
Visibility, Dec 22, 2009
TL* THE CONTACT OWNS A 2005 FORD F-150. THE PASSENGER AND DRIVER SIDE WINDOW HAD FALLEN INSIDE OF THE DOOR WITHOUT WARNING. HE SPECULATED THAT THE PLASTIC CLIP FOR THE WINDOW CABLES HAVE FRACTURED. HE HAS NOT CONTACTED THE DEALER OR MANUFACTURER. THE FAILURE AND CURRENT MILEAGES WERE 55,000.
Visibility, Dec 18, 2009
WINDOW REGULATOR FAILED WHILE DRIVING. LOUD CRASH IN DRIVER SIDE DOOR AND THEN WINDOW DROPS TO FULL OPEN POSITION. WAS POURING DOWN RAIN AND SUDDENLY BEING HIT BY WALL OF RAIN AND LOUD CRASH I ALMOST LOST CONTROL OF THE VEHICLE ON THE INTERSTATE. I DID RESEARCH AFTER GETTING HOME AND THIS IS A WELL KNOW ISSUE AND IS THE MOST COMMON FIX FOR 2004-2008 F-150S, ALL MODELS. *TR