2005 Ford F-150
Problems, recalls and owner-reported issues
Visibility is the leading concern among 1,121 owner complaints filed for this model year. This is the 4th highest complaint count among 26 F-150 model years with reports.
Of the 2005 reports, 50 involved a crash and 29 involved a fire. 57 people were injured and 2 people died.
What owners report most often
Recalls and investigations
Air bags, frontal, driver side, inflator moduleFeb 23, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2004-2006 F-150 PICK UP TRUCKS AS WELL AS CERTAIN MODEL YEAR 2006 LINCOLN MARK LT VEHICLES. IF THE CLOCKSPRING JUMPER WIRE COMES IN CONTACT WITH THE DRIVER SIDE FRONTAL AIR BAG LOWER HORN PLATE, THE WIRE INSULATION MAY BECOME CHAFED, CREATING A POTENTIAL FOR A SHORT CIRCUIT. IF THIS OCCURS THE AIR BAG WARNING LAMP MAY ILLUMINATE INDICATING THAT SERVICE IS REQUIRED.
THE DRIVER SIDE FRONTAL AIR BAG COULD INADVERTENTLY DEPLOY INCREASING THE RISK OF INJURY OR LOSS OF VEHICLE CONTROL IF OCCURRING WHILE IN MOTION.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN/MERCURY DEALER TO HAVE A NEW CLOCKSPRING JUMPER WIRE INSTALLED THAT INCORPORATES A PROTECTIVE MESH COVER. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THIS SAFETY RECALL BEGAN ON SOME VEHICLES IN MARCH 2011. THE RECALL CAMPAIGN ON THE EXPANDED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT MAY 9, 2011. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Campaign 11V107000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Service brakes, hydraulic, power assist, vacuum, hoses, lines/piping, and fittingsMay 7, 2008
FORD IS RECALLING 605,684 MY 2005-2006 F-150 AND LINCOLN MARK LT VEHICLES EQUIPPED WITH 5.4L 3-VALVE ENGINES. THE BRAKE BOOSTER VACUUM SUPPLY HOSE ATTACHED TO THE INTAKE MANIFOLD FITTING MAY SWELL OVER TIME AND LOSE RETENTION FORCE. THIS CONDITION COULD ALLOW THE HOSE TO BECOME DETACHED FROM THE FITTING DURING AN INTAKE MANIFOLD BACKFIRE. SHOULD THE HOSE DETACH FROM THE INTAKE MANIFOLD, SEVERAL BRAKE APPLICATIONS WITH POWER ASSIST WILL BE AVAILABLE BEFORE THE VACUUM RESERVE IS DEPLETED.
ONCE THE BRAKE BOOSTER VACUUM RESERVE IS DEPLETED, THE DRIVER WILL HAVE FOUNDATION BRAKE FUNCTION, BUT WITH INCREASED BRAKE PEDAL EFFORT. REDUCED VEHICLE BRAKING COULD LEAD TO A CRASH.
DEALERS WILL REPLACE A RUBBER HOSE ON THE BRAKE BOOSTER VACUUM SUPPLY TUBE ASSEMBLY. THE RECALL BEGAN ON JUNE 27, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 08V208000 on NHTSA.gov
Exterior lighting, headlightsOct 25, 2007
CERTAIN SPYDER HEADLAMP REPLACEMENT ASSEMBLIES SOLD FOR USE ON 2004 THROUGH 2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SPYDER WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2007. OWNERS CAN CONTACT SPYDER AT 866-558-4264.
Campaign 07E089000 on NHTSA.gov
Exterior lighting, headlightsSep 25, 2007
CERTAIN HEADLAMP ASSEMBLIES IMPORTED AND SOLD AS AFTERMARKET EQUIPMENT BY SONAR AUTO PARTS FOR USE ON 2004-2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SONAR WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS CAN CONTACT SONAR AT 866-558-4264.
Campaign 07E080000 on NHTSA.gov
Exterior lighting, headlightsSep 14, 2007
CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. FR390-B001L AND FR390-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE THICKNESS IS UNSTABLE INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
EAGLE EYES WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON NOVEMBER 6, 2007. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.
Campaign 07E075000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Interior lightingFeb 6, 2006
CERTAIN PICKUP TRUCKS FAIL TO COMPLY WITH EITHER THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 105, 'HYDRAULIC AND ELECTRIC BRAKE SYSTEMS' OR FMVSS NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' THESE VEHICLES WERE BUILT WITH A SOFTWARE ERROR IN THE INSTRUMENT CLUSTER.
THIS ERROR COULD PREVENT THE ANTILOCK BRAKE SYSTEM (ABS) WARNING LIGHT FROM ILLUMINATING IF THE ABS MODULE EVER BECAME INOPERATIVE.
DEALERS WILL RECALIBRATE THE INSTRUMENT CLUSTER IN THESE VEHICLES. THE RECALL BEGAN ON FEBRUARY 27, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 06V033000 on NHTSA.gov
Tires, tread/beltNov 21, 2005
CERTAIN CONTINENTAL CONTITRAC TR OWL, CONTITRAC TR BSW, GENERAL GRABBER TR BSW, AND CONTITRAC BSW TIRES MANUFACTURED BETWEEN MAY 29 AND JUNE 11, 2005, AND SOLD AS ORIGINAL EQUIPMENT ON CERTAIN FORD TRUCKS AND SOLD AS REPLACEMENT TIRES. THESE TIRES CAN WEAR PREMATURELY WHICH FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 119, NEW PNEUMATIC TIRES FOR VEHICLES OTHER THAN PASSENGER CARS.
AFFECTED TIRES MAY NOT MEET THE ENDURANCE TEST REQUIREMENTS OF THE STANDARD. CONTINUED USE OF THE AFFECTED TIRES CAN RESULT IN TIRE FAILURE WHICH COULD LEAD TO VEHICLE DAMAGE OR MOTOR VEHICLE CRASH.
CONTINENTAL WILL NOTIFY OWNERS AND REPLACE THE TIRES FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 7, 2005. OWNERS MAY CONTACT CONTINENTAL AT 704-588-5895.
Campaign 05T022000 on NHTSA.gov
Representative owner complaints
1,121 reports, newest first.
Visibility, Jun 25, 2009
TL*THE CONTACT OWNS A 2005 FORD F-150. WHILE THE VEHICLE WAS PARKED, THE REAR DRIVER'S SIDE WINDOW FAILED TO OPERATE. THERE WERE NO WARNINGS PRIOR TO THE FAILURE. THE VEHICLE HAS NOT BEEN REPAIRED. THE FRONT DRIVER'S SIDE WINDOW WAS PREVIOUSLY REPAIRED UNDER WARRANTY FOR THE IDENTICAL FAILURE. THE FAILURE MILEAGE WAS 90,000 AND CURRENT MILEAGE WAS 105,000.
Power train, Jun 25, 2009
TL*THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT SHE HEARD A GRINDING NOISE WHILE DRIVING AT ANY SPEED. THE NOISE WAS HEARD INTERMITTENLY. THE DEALER COULD NOT DUPLICATE THE FAILURE. THE VEHICLE LATER LOCKED INTO 4-WHEEL DRIVE WHILE DRIVING LESS THAN 55 MPH. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY FOUND THAT THE SOLENOID AND THE SWITCH FOR THE 4-WHEEL DRIVE WERE DEFECTIVE. THE CONTACT PAID $185 TO HAVE THE VEHICLE REPAIRED. THE DEALER WAS UNSURE IF THE REPAIR WOULD CORRECT THE FAILURE BECAUSE THE ELECTRICAL SWITCH WAS SUSCEPTIBLE TO WATER DAMAGE. THE CURRENT AND FAILURE MILEAGES WERE LESS THAN 37,217. UPDATED 08/11/09.*JB
Visibility, Jun 18, 2009
FORD F-150 LARIAT PASSENGER SIDE POWER WINDOW FAILURE WHILE DRIVING DOWN THE ROAD. *TR
Visibility, Jun 16, 2009
THE LEFT FRONT POWER WINDOW REGULATOR BROKE ALLOWING THE WINDOW TO FALL INTO THE DOOR WITH NO POSSIBILITY OF RAISING IT BACK TO A SECURE POSITION. THERE WAS NO ADVANCE WARNING, JUST A LOUD POP BEFORE THE WINDOW DESCENDED OUT OF SIGHT. FORTUNATELY FOR ME IT WAS CLEAR AND HOT (100 DEGREES) SO I DIDN'T HAVE TO CONTEND WITH STORMY WEATHER. THIS IS ONE OF THOSE ITEMS ON A MOTOR VEHICLE THAT SHOULD BE VERY DEPENDABLE, IF FOR NO OTHER REASON, SECURITY. I'M GLAD I WAS DRIVING AND NOT MY WIFE. I HAD THE REGULATOR REPLACED AT A LOCAL REPAIR FACILITY AT A COST OF $290.44. THE OLD PARTS WERE DISCARDED. *TR
Parking brake, Jun 11, 2009
TL*THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING BETWEEN 25-50 MPH, THE VEHICLE BEGAN TO VIBRATE VIOLENTLY. THERE WERE NO WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. THE DRIVER PULLED OVER TO THE SIDE OF THE ROAD AND IMMEDIATELY TURNED OFF AND RESTARTED THE ENGINE. THE VEHICLE RESUMED NORMAL OPERATION. THE FAILURE OCCURRED INTERMITTENTLY DURING THE TRAVEL. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION AND THEY STATED THAT THE EMERGENCY BRAKE HOUSING FAILED. THE CONTACT DISCOVERED A TECHNICAL SERVICE BULLETIN PERTAINING TO THE MALFUNCTION. THE VEHICLE IS IN THE PROCESS OF BEING REPAIRED. THE FAILURE MILEAGE WAS 57,000 AND CURRENT MILEAGE WAS 57,500.
Visibility, Jun 8, 2009
2005 FORD F150 LARIAT SUPERCAB...FRONT DRIVER SIDE WINDOW FELL INTO THE DOOR WHILE DRIVING..BAD WINDOW REGULATOR. *TR
Visibility, Jun 7, 2009
I USED THE POWER BUTTON ON THE DRIVER SIDE DOOR TO LOWER THE WINDOW AND HEARD A POP. THE WINDOW CRASHED DOWN AND LUCKILY DID NOT BREAK. I TRIED TO RAISE THE WINDOW AND HEARD WHAT SOUNDED LIKE WIRES GETTING WOUND UP. FAILURE HAPPENED ONCE. THE DRIVER SIDE WINDOW REGULATOR PLASTIC CRACKED WHICH HOLD THE WIRE TO RAISE AND LOWER THE WINDOW. THE WINDOW REGULATOR NEEDS TO BE REPLACED. *TR
Visibility, Jun 2, 2009
DRIVERS SIDE WINDOW FELL FOR NO REASON ON MY 2005 FORD F-150 XLT 4X4. I TOOK IT TO THE DEALERSHIP AND BOUGHT THE PART (REGULATOR ASSEMBLY). FOR 218.00 AND I AM GOING TO REPLACE IT MYSELF. *TR
Engine and engine cooling, Jun 2, 2009
I HAVE A 2005 FORD F-150 PICK UP WITH A 5.4 LITER TRITON ENGINE. WHILE DRIVING ON THE HIGHWAY THE NUMBER 1 SPARKPLUG WAS SPIT OUT DAMAGING THE HEAD. THE VEHICLE IMMEDIATELY SLOWED DOWN IN THE MIDDLE OF TRAFFIC. FORD SAID THIS IS UNCOMMON, YET THERE ARE THOUSANDS OF COMPLAINTS ALREADY FILED ABOUT THIS PARTICULAR ENGINE THROUGH THE NHTSA. I HAVE TO COMPLETELY REPLACE THE ENGINE. *TR
Air bags, Jun 2, 2009
TL*THE CONTACT OWNS A 2005 FORD F-150. WHILE THE VEHICLE WAS PARKED AND WITH THE CONTACT SEATED IN THE DRIVER'S SEAT, THE DRIVER'S SIDE AIR BAG DEPLOYED WITHOUT IMPACT. THE CONTACT SUFFERED MINOR BURNS ON THE WRIST. A POLICE REPORT WAS FILED AND THE VEHICLE IS CURRENTLY AT THE DEALER. THE CURRENT AND FAILURE MILEAGES WERE 66,000.
Visibility, Jun 1, 2009
ROLLED DOWN FRONT DRIVER WINDOW OF '05 F150 AND THE WINDOW REGULATOR FAILED WHEN IT WAS ALL THE WAY DOWN. I'VE SEEN SEVERAL COMPLAINTS ON THIS. *TR
Visibility, May 28, 2009
LEAVING WORK I WENT TO PUT DOWN MY DRIVERS SIDE WINDOW. I HEARD A LOUD "POP" AND THE WINDOW GLASS FELL TO THE BOTTOM OF THE DOOR. IMMEDIATELY TOOK IT TO THE LOCAL FORD DEALER AND HE KNEW WHAT IT WAS FROM MY DESCRIPTION AND ADVISED OF A $90 DIAGNOSIS CHARGE. TWO DAYS LATER AND 400 DOLLARS LESS IN MY POCKET, THEY HAD TO REPLACE THE WINDOW REGULATOR ASSEMBLY. APPARENTLY FROM ALL OF THE COMPLAINTS, IT IS A KNOWN PROBLEM AND FORD SHOULD BE HELD RESPONSIBLE AND THE NHTSA SHOULD ALSO TAKE ACTION AGAINST FORD AND DEMAND A RECALL. *TR
Visibility, May 28, 2009
HEARD A LOUD POP SOUND AND MY DRIVER'S SIDE WINDOW FELL. BASED ON MY RESEARCH ON THE INTERNET SEEMS TO BE HAPPENING TO A LOT OF FORD F-150 OWNERS. THIS COULD HAVE BEEN VERY DANGEROUS AS THE SOUND IS VERY LOUD AND COULD EASILY DISTRACT A DRIVER. *TR
Visibility, May 27, 2009
2005 FORD F-150 FX4 - DRIVERSIDE WINDOW/DOOR, HEARD A LOUD POP IN THE DOOR AND THE WINDOW (IN THE UP POSITION) DROPPED TO THE BOTTOM OF THE DOOR. THIS OCCURRED WHILE TRAVELING ON INTERSTATE 235 IN IOWA AT AN APPROXIMATE SPEED OF 70 MPH. THIS INCIDENT COULD HAVE VERY EASILY CAUSED A FATAL ACCIDENT. *TR
Visibility, May 24, 2009
REAR DRIVER SIDE WINDOW FELL DOWN INTO THE DOOR WHILE I WAS DRIVING DOWN THE ROAD. *TR
Visibility, May 21, 2009
FORD F150 2005 DOOR WINDOWS ONE WINDOW FAILED AT 30,000 MILES AND TWO OTHER WINDOWS FAIL AT 70,000 MILES AT THE COST OF 300.00 EACH. THERE HAS TO BE A RECALL ON DOOR WINDOWS BREAKING DOWN. *TR
Engine and engine cooling, May 19, 2009
SPARK PLUGS CANNOT BE CHANGED BECAUSE OF DESIGN OF CYLINDER HEAD. THIS IS A SPARK PLUG BREAKAGE INSIDE THE HEAD. THIS IS A COMMON OCCURRENCE ON 5.4 LITER FORD MOTORS AS REPORTED ON FORUMS AND THROUGH WORD OF MOUTH. 1998 TO 2008 MOTORS ARE NOTORIOUS LEADING CONSUMERS TO EITHER PAY HUGE REPAIR BILLS OR TRADE BEFORE THEY WISH TO TRADE. ALSO, SOMEONE WISHING TO CHANGE HIS PLUGS FOR PROPER EMISSIONS OR PROPER MAINTENANCE IS JUST SCREWED. SCARED TO DEATH TO HAVE THEM CHANGED EVEN AT A DEALERSHIP. FORD MECHANICS EVEN HAVE TROUBLE.THIS IS NO FEW VEHICLES. THIS IS WIDESPREAD.
Visibility, May 19, 2009
DRIVER-SIDE WINDOW FELL INTO THE DOOR AFTER CLOSING THE DOOR. *TR
Visibility, May 18, 2009
I HEARD A LOUD CRACK AND THEN MY DRIVERS SIDE WINDOW FELL! I SEARCHED THE WEB AND FOUND SO MANY PEOPLE WITH THE SAME PROBLEM, DO SOMETHING! FORD SHOULD PUT OUT A RECALL ON THIS PROBLEM. I'VE FOUND THERE WAS SEVERAL F150 OWNERS ALL HAVE HAD THIS PROBLEM. BAD DESIGN ON THESE REGULATORS BAD WINDOW REGULATOR ON THIS TRUCK IN UNDER 72,000 MILES. FORD NEEDS TO REFUND OR RECALL ALL OF THESE TRUCKS. IT IS A VERY COMMON PROBLEM; THESE REGULATORS ARE DEFECTIVE FROM THE FACTORY! *TR
Engine and engine cooling, May 17, 2009
SUDDEN ENGINE SURGES OCCURRING AT ANY TIME WEATHER MOVING OR STOPPED AT RED LIGHT OR WHILE SLOWING DOWN TO STOP. *TR
Engine and engine cooling, May 12, 2009
REGARDING: 2005 FORD F 150 TRUCK PURCHASED NEW FROM DEALER, HAS BEEN HAVING PROBLEMS WITH STALLING. IT HAS STALLED IN REVERSE AND WHILE DRIVING ON FREEWAY. IT IS VERY DANGEROUS. I ALMOST GOT INTO AN ACCIDENT TODAY ON THE FREEWAY, WHICH IS WHY I AM TAKING THE TIME TO LOOK INTO THIS MATTER. I ALSO KNOW A FEW PEOPLE WITH THE SAME PROBLEM AND HAVE ALSO SEEN MANY POSTINGS ONLINE FOR THIS ISSUE. MANY PEOPLE HAVE BEEN INJURED IN ACCIDENTS AND MANY TRUCKS HAVE CAUGHT ON FIRE. ALL HAVE STARTED WITH THESE SAME PROBLEMS. FORD RECOGNIZED THIS PROBLEM UNTIL THE MADE YEAR OF 2004. I DO BELIEVE IT ALSO A PROBLEM WITH 2005, AND MAYBE WITH OTHER YEARS. THIS REALLY NEEDS TO BE CHECKED INTO. I HAVE HAD MY TRUCK LOOKED AT BY A MECHANIC, AND HE IS NOT SURE OF THE PROBLEM. I SEE A LOT OF PROBLEMS WITH FORD AND FUEL INJECTORS AND CRUISE CONTROL WITH MY YEAR OF TRUCK, BUT NO RECALLS. THIS IS A SERIOUS MATTER AND I WOULD APPRECIATE THAT IT BE HANDLED RESPONSIBLY. *TR
Seat belts, May 11, 2009
2005 FORD F150 HAS A PROBLEM WITH THE DRIVER'S SIDE SEAT BELT. CONSUMER STATES THAT FORD DEALERSHIP REFUSED TO CORRECT THE PROBLEM. *NJ
Air bags, May 11, 2009, crash
TL*THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING 35 MPH IN FAIR WEATHER CONDITIONS, THE CONTACT CRASHED INTO THE REAR OF ANOTHER VEHICLE. THE AIR BAG LIGHT ILLUMINATED ON THE INSTRUMENT PANEL, BUT THE AIR BAGS FAILED TO DEPLOY. THERE WERE NO INJURIES; HOWEVER, THE CONTACT WAS CONCERNED ABOUT THE AIR BAGS NOT DEPLOYING. THE CURRENT AND FAILURE MILEAGES WERE 32,684. UPDATED 05/13/09 *BF THE CONSUMER STATED IT WAS A MINOR FENDER BENDER AND THE POLICE WERE NOT CALLED. UPDATED 05/20/09. *JB UPDATED 06/17/09 *BF UPDATED 06/17/09.*JB UPDATED 06/24/09. *LJ
Structure, May 5, 2009
2005 FORD F150 (22K) HAS SEVERAL AREAS WHERE PAINT IS BLISTERING. *TR
Visibility, May 4, 2009
FORD F150 PICKUP. THE PASSENGER-SIDE SIMPLY WINDOW DROPPED TO THE BOTTOM OF THE DOOR AS I WAS DRIVING. THE DEALER SAYS IT IS CAUSED BY A FAILED WINDOW REGULATOR. THIS IS THE SECOND TIME IT HAPPENED ON THIS VEHICLE; ALSO HAD A SINGLE FAILURE ON MY 2004 FORD EXPEDITION, THE REAR WINDOW WHERE MY (THEN) 4-YEAR OLD DAUGHTER SAT. IT DROPPED CLEAR TO THE BOTTOM OF THE DOOR AND SHE COULD HAVE EASILY CRAWLED OUT. SEEMS LIKE THIS IS QUITE A DANGEROUS DEFECT--THE NOISE ALONE SURE STARTLED ME! FORD APPARENTLY HAS HUGE NUMBERS OF COMPLAINTS ON THIS DEFECTIVE PART. *TR