2005 Ford F-150
Problems, recalls and owner-reported issues
Visibility is the leading concern among 1,121 owner complaints filed for this model year. This is the 4th highest complaint count among 26 F-150 model years with reports.
Of the 2005 reports, 50 involved a crash and 29 involved a fire. 57 people were injured and 2 people died.
What owners report most often
Recalls and investigations
Air bags, frontal, driver side, inflator moduleFeb 23, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2004-2006 F-150 PICK UP TRUCKS AS WELL AS CERTAIN MODEL YEAR 2006 LINCOLN MARK LT VEHICLES. IF THE CLOCKSPRING JUMPER WIRE COMES IN CONTACT WITH THE DRIVER SIDE FRONTAL AIR BAG LOWER HORN PLATE, THE WIRE INSULATION MAY BECOME CHAFED, CREATING A POTENTIAL FOR A SHORT CIRCUIT. IF THIS OCCURS THE AIR BAG WARNING LAMP MAY ILLUMINATE INDICATING THAT SERVICE IS REQUIRED.
THE DRIVER SIDE FRONTAL AIR BAG COULD INADVERTENTLY DEPLOY INCREASING THE RISK OF INJURY OR LOSS OF VEHICLE CONTROL IF OCCURRING WHILE IN MOTION.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN/MERCURY DEALER TO HAVE A NEW CLOCKSPRING JUMPER WIRE INSTALLED THAT INCORPORATES A PROTECTIVE MESH COVER. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THIS SAFETY RECALL BEGAN ON SOME VEHICLES IN MARCH 2011. THE RECALL CAMPAIGN ON THE EXPANDED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT MAY 9, 2011. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Campaign 11V107000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Service brakes, hydraulic, power assist, vacuum, hoses, lines/piping, and fittingsMay 7, 2008
FORD IS RECALLING 605,684 MY 2005-2006 F-150 AND LINCOLN MARK LT VEHICLES EQUIPPED WITH 5.4L 3-VALVE ENGINES. THE BRAKE BOOSTER VACUUM SUPPLY HOSE ATTACHED TO THE INTAKE MANIFOLD FITTING MAY SWELL OVER TIME AND LOSE RETENTION FORCE. THIS CONDITION COULD ALLOW THE HOSE TO BECOME DETACHED FROM THE FITTING DURING AN INTAKE MANIFOLD BACKFIRE. SHOULD THE HOSE DETACH FROM THE INTAKE MANIFOLD, SEVERAL BRAKE APPLICATIONS WITH POWER ASSIST WILL BE AVAILABLE BEFORE THE VACUUM RESERVE IS DEPLETED.
ONCE THE BRAKE BOOSTER VACUUM RESERVE IS DEPLETED, THE DRIVER WILL HAVE FOUNDATION BRAKE FUNCTION, BUT WITH INCREASED BRAKE PEDAL EFFORT. REDUCED VEHICLE BRAKING COULD LEAD TO A CRASH.
DEALERS WILL REPLACE A RUBBER HOSE ON THE BRAKE BOOSTER VACUUM SUPPLY TUBE ASSEMBLY. THE RECALL BEGAN ON JUNE 27, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 08V208000 on NHTSA.gov
Exterior lighting, headlightsOct 25, 2007
CERTAIN SPYDER HEADLAMP REPLACEMENT ASSEMBLIES SOLD FOR USE ON 2004 THROUGH 2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SPYDER WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2007. OWNERS CAN CONTACT SPYDER AT 866-558-4264.
Campaign 07E089000 on NHTSA.gov
Exterior lighting, headlightsSep 25, 2007
CERTAIN HEADLAMP ASSEMBLIES IMPORTED AND SOLD AS AFTERMARKET EQUIPMENT BY SONAR AUTO PARTS FOR USE ON 2004-2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SONAR WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS CAN CONTACT SONAR AT 866-558-4264.
Campaign 07E080000 on NHTSA.gov
Exterior lighting, headlightsSep 14, 2007
CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. FR390-B001L AND FR390-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE THICKNESS IS UNSTABLE INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
EAGLE EYES WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON NOVEMBER 6, 2007. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.
Campaign 07E075000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Interior lightingFeb 6, 2006
CERTAIN PICKUP TRUCKS FAIL TO COMPLY WITH EITHER THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 105, 'HYDRAULIC AND ELECTRIC BRAKE SYSTEMS' OR FMVSS NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' THESE VEHICLES WERE BUILT WITH A SOFTWARE ERROR IN THE INSTRUMENT CLUSTER.
THIS ERROR COULD PREVENT THE ANTILOCK BRAKE SYSTEM (ABS) WARNING LIGHT FROM ILLUMINATING IF THE ABS MODULE EVER BECAME INOPERATIVE.
DEALERS WILL RECALIBRATE THE INSTRUMENT CLUSTER IN THESE VEHICLES. THE RECALL BEGAN ON FEBRUARY 27, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 06V033000 on NHTSA.gov
Tires, tread/beltNov 21, 2005
CERTAIN CONTINENTAL CONTITRAC TR OWL, CONTITRAC TR BSW, GENERAL GRABBER TR BSW, AND CONTITRAC BSW TIRES MANUFACTURED BETWEEN MAY 29 AND JUNE 11, 2005, AND SOLD AS ORIGINAL EQUIPMENT ON CERTAIN FORD TRUCKS AND SOLD AS REPLACEMENT TIRES. THESE TIRES CAN WEAR PREMATURELY WHICH FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 119, NEW PNEUMATIC TIRES FOR VEHICLES OTHER THAN PASSENGER CARS.
AFFECTED TIRES MAY NOT MEET THE ENDURANCE TEST REQUIREMENTS OF THE STANDARD. CONTINUED USE OF THE AFFECTED TIRES CAN RESULT IN TIRE FAILURE WHICH COULD LEAD TO VEHICLE DAMAGE OR MOTOR VEHICLE CRASH.
CONTINENTAL WILL NOTIFY OWNERS AND REPLACE THE TIRES FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 7, 2005. OWNERS MAY CONTACT CONTINENTAL AT 704-588-5895.
Campaign 05T022000 on NHTSA.gov
Representative owner complaints
1,121 reports, newest first.
Visibility, Oct 21, 2008
ANOTHER WINDOW DROPS DOWN INSIDE MY DOOR. THIS IS DEFINITELY DUE TO FAULTY EQUIPMENT. FORD USED CHEAP PLASTIC ON THEIR WINDOW REGULATORS THAT IS NOT SUITABLE FOR THE PURPOSE. *TR
Visibility, Oct 20, 2008
WINDOWS FAILURE,WILL NOT GO UP. *TR
Visibility, Oct 16, 2008
MY WIFE WENT OUT THIS MORNING TO TAKE THE KIDS TO SCHOOL AND THE DRIVERS SIDE WINDOW HAS FALLEN DOWN IN THE DOOR. WE ARE STILL TRYING TO GET A HOLD OF THE NEAREST FORD DEALERSHIP TO GET THIS FIXED. I HAVE READ SEVERAL FORUMS THAT SAY THIS IS A COMMON OCCURRENCE. WHY IS THIS NOT A RECALL? *TR
Fuel system, Gasoline, Oct 14, 2008
WHILE DRIVING INTO TOWN I DECELERATED AND THE ENGINE STALLED. I PUT TRUCK IN NEUTRAL AND REFIRED THE ENGINE. AFTER THAT THE EMISSIONS LIGHT WAS ON. TOOK TRUCK TO MECHANIC AND SAID THE THROTTLE BODY FAILED. MECHANIC REPLACED THROTTLE BODY AND IT COST 450$ PARTS AND LABOR. *TR
Visibility, Oct 13, 2008
2005 FORD 150 4X4 KING RANCH CREW CAB. AT 60K MILES, DRIVER'S WINDOW FELL DOWN INTO DOOR. MECHANISM FAILED. FORD DEALERSHIP IN SANTA FE, NM REPAIRED FOR $350.00. THEY CLAIMED THEY'D NEVER SEEN IT BEFORE BUT SINCE HAVE SEEN NUMEROUS COMPLAINTS OF THIS WINDOW MECHANISM DESIGN FAULT. THIS SHOULD BE A RECALL BY FORD. *TR
Visibility, Oct 8, 2008
2005 FORD F-150 SUPER CREW PICKUP WINDOW REGULATORS BREAK (QUITE COMMONLY), CAUSING THE WINDOW TO NO LONGER HAVE ANY SUPPORT. THE WINDOW THEN CAN FALL ABRUPTLY AT ANY TIME, INCLUDING WHILE DRIVING THE VEHICLE. WHEN THIS HAPPENS, THE DRIVER TENDS TO THINK THAT THE VEHICLE HAS GOTTEN HIT BY SOMETHING LARGE, AND SWERVES TO AVOID IT. THIS CAN RESULT IN DRIVING OFF OF THE ROAD OR INTO ONCOMING TRAFFIC. FORD DENIES THAT THE WINDOW REGULATORS ARE NOT FIT FOR THEIR INTENDED PURPOSE, AND REFUSES TO RELEASE A PROPERLY ENGINEERED PART. A CURSORY EXAMINATION OF THE REGULATOR WILL SHOW THAT IT IS NOT DESIGNED TO HANDLE THE LOADS AND STRESSES THAT EXIST IN THE WINDOW SYSTEM. REPLACING THE PART WITH THE CURRENT DESIGN ONLY STARTS THE CLOCK OVER ON WHEN THE WINDOW WILL FALL AGAIN. AFTER-MARKET REGULATORS ARE NOT AVAILABLE. PLEASE INSIST THAT FORD RECALL THESE FAULTY WINDOW REGULATORS AND REPLACE THEM WITH PROPERLY ENGINEERED UNITS THAT WILL NOT FAIL IN SUCH AN ABRUPT WAY. *TR
Visibility, Oct 7, 2008
THE DRIVER SIDE POWER WINDOW REGULATOR HAS FAILED AND THE WINDOW WILL NOT ROLL UP. IT HAPPENED WHILE I WAS OUT OF TOWN AND IT WAS RAINING. THIS IS A HUGE SAFETY RISK. APPARENTLY, AFTER DOING VERY LITTLE RESEARCH ON THE INTERNET, THERE ARE A LOT OF FOLKS HAVING THE SAME PROBLEMS. NOT ONLY DID THIS LEAVE MY VEHICLE OPEN TO THE ELEMENTS, IT ALSO LEFT IT OPEN TO ANYONE WHO WANTED TO HELP THEMSELVES TO THE VEHICLE OR IT'S CONTENTS. I AM VERY CONCERNED THAT THIS WILL HAPPEN AGAIN. *TR
Visibility, Oct 3, 2008
THE DRIVER SIDE WINDOW OF MY 2005 FORD F-150 SUPER CREW MADE A LOUD POPPING NOISE THEN FELL INTO THE DOOR, ALL WHEN I PRESSED THE BUTTON TO ROLL IT UP. IT HAD BEEN LOCKING UP FOR SEVERAL DAYS ON AND OFF. COST TO REPAIR IS ABOUT $300, SO UNTIL I CAN AFFORD IT, THE WINDOW IS HELD IN PLACE WITH VICE-GRIPS. LOCAL FORD DEALERSHIP TELLS ME THAT HAVEN'T HEARD OF ANY SUCH PROBLEMS WITH THIS MODEL, BUT I HAVE FOUND HUNDREDS OF COMPLAINTS JUST LIKE MINE ON THE INTERNET SIMPLY BY TYPING "2005 FORD F-150 WINDOW PROBLEMS" INTO GOOGLE. *TR
Visibility, Structure, Oct 2, 2008
WAS SITTING IDLE IN A PARKING LOT WHEN SUDDENLY I HEARD A LOUD POP. WHEN I STARTED TO ROLL MY WINDOW DOWN ON MY 2005 FORD F150 SUPER CAB, THE WINDOW DROPPED DOWN AND SOUNDED LIKE BROKEN GLASS. AFTER REMOVING THE PANEL I SAW THE CABLE MESSED UP. THEN AFTER GOOGLING TO FIND AN ANSWER, I DISCOVERED THAT THIS IS THE EXACT PROBLEM THAT DOZENS, PERHAPS HUNDREDS OF OTHERS ARE EXPERIENCING WITH THE POWER WINDOW REGULATOR. THE PLASTIC CLIP BREAKS AND THE CABLE GETS MESSED UP. FORD IS MAKING A KILLING OFF OWNERS BY USING CHEAP, BREAKABLE PARTS. THIS SHOULD BE RECALLED! I HAVE NO MONEY TO REPLACE THIS REGULATOR RIGHT NOW, SO I AM AT THE MERCY OF THE GODS IN HOPE THAT SOMEONE DOESN'T STEAL MY TRUCK, OR IT DOESN'T RAIN, SINCE WITH THIS PART BROKEN THE WINDOW WILL NOT STAY UP. PLEASE PUSH THIS THROUGH FOR A RECALL! *TR
Visibility, Sep 30, 2008
I HAVE A 2005 F150 FORD FX4 , AND TWO FRONT WINDOWS FELL INTO THE DOOR WITHIN THREE MONTHS. I HAVE BEEN TOLD THIS IS VERY COMMON PROBLEM FOR THIS TRUCK, THAT THE POWER WINDOW REGULATORS ARE FAULTY. WHEN THESE WINDOWS FALL INSIDE THE DOOR I AM LEFT SCARED AND VERY UNSAFE. I HAVE RESEARCHED THIS PROBLEM AND FOUND COMPLAINTS ALL OVER ABOUT THIS SAME PROBLEM. WHAT DOES IT TAKE FOR SOMEONE TO ADDRESS THIS PROBLEM? *TR
Air bags, Sep 30, 2008, crash
TL*THE CONTACT OWNS A 2005 FORD F150. WHILE DRIVING 55 MPH IN THE RAIN, THE VEHICLE HYDROPLANED AND CRASHED HEAD ON INTO A GUARD RAIL. THE AIR BAGS FAILED TO DEPLOY AND THE VEHICLE WAS DESTROYED. A POLICE REPORT WAS FILED. THE VIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 42,000.
Parking brake, Sep 26, 2008
AFTER RELEASING THE PARKING BRAKE, THE CONNECTION OF THE CABLE TO BRAKE ASSEMBLY ON THE DRIVER SIDE REAR WHEEL FAILED. WHEN THE CONNECTION FAILED IT CAUSED ALL OF THE INTERNAL PARTS OF THE PARKING BRAKE ASSEMBLY TO COME LOOSE AND BIND, THUS CAUSING ALL OF THE INTERNAL PARTS TO BECOME DISLODGED. ONCE ALL THE PARTS BECAME DISLODGED THEY STARTED TO RATTLE AND BIND INSIDE THE BRAKE ASSEMBLY. TO CORRECT THE FAILURE, THE ENTIRE PARKING BRAKE ASSEMBLY MUST BE REPLACED, INCLUDING THE DISC/DRUM ASSEMBLY AND BRAKE SHOES FOR THE PARKING BRAKE. *TR
Visibility, Sep 22, 2008
I HAD AN INCIDENT WITH MY 2005 FORD F-150 WINDOW REGULATOR IN WHICH THE PASSENGER SIDE WINDOW JUST DROPPED DOWN INSIDE THE DOOR WHILE THE VEHICLE WAS PARKED IN MARCH OF 2008. BECAUSE IT WAS STILL UNDER WARRANTY, I TOOK IT BACK TO THE DEALER AND THEY REPLACED THE WINDOW REGULATOR. I ASKED THE SERVICE MANAGER WHAT CAUSED THE WINDOW JUST TO DROP DOWN INSIDE THE DOOR WHILE THE VEHICLE WAS PARKED AND HE STATED THAT THEY WERE HAVING PROBLEMS WITH THE WINDOW REGULATORS IN THE '04 AND '05 F-150'S. AT THAT TIME I TOLD HIM THAT I WANTED THE OTHER WINDOW REGULATORS REPLACED. HE ASKED IF I HAD ANY PROBLEMS WITH THE OTHER ONES AND I REPLIED THAT I HAD NOT YET. HE SAID THERE WAS NOTHING THEY COULD DO. I EXPLAINED MY CONCERN BEING THAT THE TRUCK WOULD BE OUT OF WARRANTY IN 3 MONTHS AND THAT I WANTED IT TO BE FIXED WHILE STILL UNDER WARRANTY. HE TOLD ME THAT IF I DID HAVE A PROBLEM AND IT WAS DUE TO FAULTY EQUIPMENT, THEY WOULD REPLACE IT. TWENTY FOUR DAYS AFTER MY WARRANTY EXPIRED THE DRIVER SIDE WINDOW DROPPED DOWN INSIDE THE DOOR WHILE DRIVING ON THE ROAD. I WAS NOT WINDING IT UP OR DOWN, IT JUST DROPPED DOWN INSIDE THE DOOR WITH A LOUD CRASH. IT SCARED THE HECK OUT OF ME AND I ALMOST HIT THE MEDIAN GUARD RAIL. I PULLED OFF THE ROAD TO SEE WHAT HAPPENED. I COULD SEE THE TOP OF THE WINDOW THROUGH THE OPENING AND FIGURED IT WAS THE PROBLEM WITH THIS WINDOW REGULATOR. WHEN I CALLED THE DEALERSHIP, THEY STATED THAT BECAUSE THE TRUCK WAS OUT OF WARRANTY, THERE WAS NOTHING THEY COULD DO. I EXPLAINED THAT THIS IS FAULTY EQUIPMENT AND THEY TOLD ME TO TAKE IT UP WITH FORD. I HAVE WRITTEN FORD CUSTOMER SERVICE ON TEN DIFFERENT OCCASIONS AND ONLY EVER RECEIVED ONE RESPONSE. THEY ASKED WHAT I WANTED DONE AND I REPLIED THAT I JUST WANTED IT REPLACED. IT HAS BEEN ALMOST 2 MONTHS NOW AND I HAVE RECEIVED NO OTHER RESPONSES FROM FORD AND MY WINDOW IS STILL NOT FIXED. I HAVE HAD TO DRIVE IN RAIN AND 110 DEGREE TEMPERATURES WITHOUT A DRIVER'S SIDE WINDOW. WINDOW REGULATOR PROBLEM. *TR
Air bags, Sep 19, 2008
TL*THE CONTACT OWNS A 2005 FORD F-150. WHEN THE CONTACT STARTED THE VEHICLE, THE AIR BAGS SUDDENLY DEPLOYED. THE DEALER COULD NOT EXPLAIN WHAT CAUSED THE FAILURE. THE MANUFACTURER STATED THAT THERE WERE NO COMPLAINTS RELATING TO THE FAILURE. THE REPAIRS WERE COMPLETED THROUGH THE INSURANCE COMPANY. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 75,000.
Visibility, Sep 13, 2008
NORMAL DRIVING WITH WINDOWS UP, HEARD LOUD BANG AND WE THOUGHT SOMEONE HAD HIT OR THROWN SOMETHING AT OUR PICKUP. THEN I NOTICED DRIVER SIDE FRONT WINDOW SLOWLY SLIDING DOWN AND FINALLY FALLING INTO DOOR. PICKUP IS FOR ALL INTENTS UNSAFE. CAN NOT PUT UP WINDOW. I SEE ON OTHER WEBSITES AND THIS ONE THAT THIS IS A VERY COMMON PROBLEM, AND FORD SHOULD BE MADE TO FIX THIS WITH A SAFETY RECALL. THIS HAPPENED 2 MONTHS AFTER WARRANTY WAS UP WITH LESS THAN 15,000 MILES ON VEHICLE. TOTALLY UNACCEPTABLE. *TR
Visibility, Sep 3, 2008
2005 FORD F150 LARIAT SUPERCREW 4 DOOR TRUCK-FAILED POWER WINDOW REGULATOR ON PASSENGER SIDE DOOR. POWER WINDOW SWITCH WAS BEING USED TO RAISE WINDOW AND THE GLASS FELL INTO THE DOOR PANEL MAKING A LOUD BANG. THE NOISE WAS LOUD AND I BELIEVED THE GLASS HAD BROKEN DUE TO THE NOISE. THE WINDOW WOULD NO LONGER OPERATE. THE TRUCK IS ONLY USED FOR PLEASURE DRIVING ON OCCASION. THE WINDOWS ARE SELDOM OPERATED AS AIR-CONDITIONING IS TYPICALLY USED. , THE DEALERSHIP SERVICE DEPARTMENT IS SCHEDULED TO REPAIR THIS SECOND FAILURE IN LESS THAN ONE MONTH. PROBLEM IS NOT UNIQUE TO MY TRUCK. I HAVE FILED COMPLAINT WITH FORD. *TR
Visibility, Sep 3, 2008
2005 FORD F150 LARIAT SUPERCREW 4 DOOR TRUCK-FAILED POWER WINDOW REGULATOR ON DRIVER SIDE DOOR. POWER WINDOW SWITCH WAS BEING USED TO RAISE WINDOW AND THE GLASS FELL INTO THE DOOR PANEL MAKING A LOUD BANG. THE NOISE WAS LOUD AND I BELIEVED THE GLASS HAD BROKEN DUE TO THE NOISE. THE WINDOW WOULD NO LONGER OPERATE. THE FAILURE WAS A TOTAL SHOCK. THE TRUCK IS ONLY USED FOR PLEASURE DRIVING ON OCCASION. THE WINDOWS ARE SELDOM OPERATED AS AIR-CONDITIONING IS TYPICALLY USED. , THE DEALERSHIP SERVICE DEPARTMENT REPAIRED REGULATOR AT A TOTAL COST OF $259.50 AND THE PROBLEM IS NOT UNIQUE TO MY TRUCK AND INDICATED I SHOULD PASS MY COMPLAINT ON TO FORD. *TR
Vehicle speed control, Aug 26, 2008
TL*THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING 5 MPH, THE ACCELERATOR PEDAL BECAME STUCK TO THE BOTTOM OF THE FLOOR. THE CONTACT STOPPED THE VEHICLE AND PLACED IT INTO PARK. HE ALSO NOTICED THAT THE RPM'S WERE AT 5,000 WHILE THE VEHICLE WAS STILL IN PARK. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY STATED THAT THERE WERE NO DEFECTS OR FAILURES. THE CURRENT AND FAILURE MILEAGES WERE 17,000. UPDATED 09/24/08. *LJ THE CONSUMER STATED WHILE PULLING OUT OF A PARKING LOT WHEN THE INCIDENT HAPPENED. UPDATED 09/30/08. *JB
Visibility, Aug 25, 2008
IN OCTOBER OF 2007 DURING NORMAL OPERATION OF THE VEHICLE THE RIGHT HAND PASSENGER WINDOW SUDDENLY FELL INTO THE DOOR RENDERING THE WINDOW INOPERABLE. IN DECEMBER OF 2007 THE 2ND FAILURE OF A WINDOW REGULATOR ASSEMBLY OCCURRED ON THE RIGHT HAND REAR PASSENGER WINDOW WHILE AGAIN OPERATING THE VEHICLE UNDER NORMAL DRIVING CONDITIONS. THE WINDOW, AGAIN, FELL INTO THE DOOR AND COULD NOT BE RETRIEVED. THE 3RD FAILURE OF THE WINDOW REGULATOR ASSEMBLY OCCURRED DURING AUGUST OF 2008. THIS TIME THE DRIVER'S WINDOW FELL INTO THE DOOR DURING NORMAL OPERATION OF THE VEHICLE AND WAS UNABLE TO BE RETRIEVED. ACCORDING TO THE DEALER, THE WINDOW REGULATOR ASSEMBLY WAS AT FAULT IN EACH INSTANCE. THE FIRST TWO INCIDENTS WERE COVERED UNDER THE FACTORY WARRANTY, THE THIRD INCIDENT OCCURRED (37,618 MILES) AFTER EXPIRATION OF THE FACTORY WARRANTY. EACH TIME THE VEHICLE WAS BROUGHT IN FOR REPAIRS, THE SERVICE DEPARTMENT INDICATED THAT THE FAILURE OF THE WINDOW REGULATOR HAS BEEN A FREQUENT PROBLEM SEEN WITH THIS MAKE AND MODEL. WHEN THIS FAILURE OCCURS, THE VEHICLE IS BASICALLY RENDERED INOPERABLE DUE TO INCLEMENT WEATHER, SECURITY, ETC. I AM ANTICIPATING THE FAILURE OF THE REMAINING WINDOW (LEFT HAND PASSENGER) TO OCCUR AT ANY UNKNOWN MOMENT. ALL ASSEMBLIES WERE REPLACED WITH AN IMPROVED VERSION OF THE PART, ACCORDING TO THE DEALER. NO ASSEMBLIES WERE ALLOWED TO BE REPLACED PRIOR TO ACTUAL FAILURE OF THE REGULATOR UNLESS I WAS WILLING TO PAY FULL PRICE FOR REPLACEMENT CHARGES. I BELIEVE FORD SHOULD RECALL ALL VEHICLES THAT HAVE BEEN MANUFACTURED WITH THIS DEFECTIVE REGULATOR AND REPLACE IT AT NO CHARGE WITH THE IMPROVED PART. *TR
Engine and engine cooling, Fuel system, Gasoline, Aug 22, 2008
2005 FORD F-150 5.4 LITER ENGINE; ALL SERVICE WORK WAS PERFORMED AT THE RECOMMENDED SERVICE INTERVALS ON THIS VEHICLE. AT 102,000 MILES, I TOOK THE VEHICLE TO THE DEALERSHIP TO HAVE SPARK PLUGS REPLACED. (FORD RECOMMENDED 100,000 MILE TUNE-UP) THE FIRST THREE SPARK PLUGS ATTEMPTED TO BE REMOVED BY THREE DIFFERENT TECHNICIANS BROKE OFF EVEN WHEN FOLLOWING THE FORD TSB PROCEEDURE. THIS TUNE UP WILL COST ME ALMOST $2,000 DUE TO THE DEFECTIVE SPARK PLUG DESIGN. FORD WILL NOT HELP WITH THE REPAIR. *TR
Visibility, Aug 22, 2008
WINDOW REGULATOR-EARLY FAILURE-FORD WOULD DO NOTHING. AFTER READING MANY BLOGS-IT'S A REAL BIG PROBLEM. FORD IS CHARGING 350-OR SO TO REPAIR OVER AND OVER AGAIN,MANY PEOPLE HAVE HAD 4-6 REPAIRS ON THE SAME VEHICLE WITH 40,00 MILES ON THEM, FORD REFUSES TO STAND BEHIND. *TR
Visibility, Aug 15, 2008
FAILURE OF WINDOW MOTOR REGULATOR ON DRIVERS SIDE VEHICLE IS ONLY 3 YEARS OLD. *TR
Steering, Suspension, Aug 15, 2008
TL*THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING 45-55 MPH, THE VEHICLE EXPERIENCES MODERATE TO SEVERE SHAKING. THE ROAD CONDITIONS ARE NOT A FACTOR. THE SHAKING IS SO SEVERE THAT THE CONTACT HAS TO STOP THE VEHICLE. THE BRAKES, BRAKE PADS, AND ROTORS WERE CHANGED, BUT THAT HAS NOT REMEDIED THE FAILURE. THE WINDSHIELD WIPERS ALSO RAISED AWAY FROM THE WINDSHIELD WHEN THE SHAKING OCCURRED. WHEN THE CONTACT SHUT OFF THE ENGINE AND RESTARTED THE VEHICLE, THE SHAKING STOPPED. ALL FOUR OF THE TIRES WERE REPLACED. THE DEALER DISASSEMBLED AND REBUILT THE EMERGENCY BRAKE, WHICH WAS DRAGGING AND WORE OUT THE LINING. THE APPROXIMATE FAILURE AND CURRENT MILEAGES WERE 45,000. UPDATED 09/10/08. *LJ THE CONSUMER STATED THE PROBLEM WAS INTERMITTENT. UPDATED 09/12/08. *JB
Visibility, Latches/locks/linkages, Aug 13, 2008
WINDOW CONTROLLER FAILS WITH A LOUD BANGING NOISE. THE NOISE IS SO DISTRACTING THAT IT CAUSES A POSSIBLE ACCIDENT SITUATION. I WAS PULLING A TRAILER AT THE TIME AND THE SWERVING CAUSED FISH TAILING. THERE ARE THOUSANDS OF DOCUMENTED FAILURES OF THE FORD WINDOW CONTROLLER IN 2005 VEHICLES AND FORD WON'T RECALL WITHOUT NHTSA REQUIRING IT. *TR
Electrical system, Aug 12, 2008
TL*THE CONTACT OWNS A 2005 FORD F150. WHEN THE CONTACT ACTIVATED THE HEADLIGHTS, THE INSTRUMENT PANEL LIGHTS WOULD DIM. AS A RESULT, THE GAUGES BECAME DIFFICULT TO SEE. SHE TOOK THE VEHICLE TO THE DEALER ON THREE DIFFERENT OCCASIONS AND WAS INFORMED THAT THE ISSUE WAS A SAFETY FEATURE IN ORDER TO PREVENT GLARE ON THE DRIVER'S EYES AT NIGHT. THE DEALER DID NOTHING TO REPAIR THE VEHICLE DURING THE FIRST VISIT. DURING THE SECOND AND THIRD VISITS, THE DEALER OFFERED NO REMEDY. THE MANUFACTURER STATED THAT SHE DID NOT HAVE A LEGITIMATE COMPLAINT AND REFERRED HER TO THE SERVICE MANAGER AT THE DEALER. THE CURRENT MILEAGE WAS 11,382 AND FAILURE MILEAGE WAS APPROXIMATELY 6,000.