2006 Ford F-150
Problems, recalls and owner-reported issues
Service brakes is the leading concern among 589 owner complaints filed for this model year. This is the 6th highest complaint count among 26 F-150 model years with reports.
Of the 2006 reports, 58 involved a crash and 18 involved a fire. 42 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Air bags, frontal, driver side, inflator moduleFeb 23, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2004-2006 F-150 PICK UP TRUCKS AS WELL AS CERTAIN MODEL YEAR 2006 LINCOLN MARK LT VEHICLES. IF THE CLOCKSPRING JUMPER WIRE COMES IN CONTACT WITH THE DRIVER SIDE FRONTAL AIR BAG LOWER HORN PLATE, THE WIRE INSULATION MAY BECOME CHAFED, CREATING A POTENTIAL FOR A SHORT CIRCUIT. IF THIS OCCURS THE AIR BAG WARNING LAMP MAY ILLUMINATE INDICATING THAT SERVICE IS REQUIRED.
THE DRIVER SIDE FRONTAL AIR BAG COULD INADVERTENTLY DEPLOY INCREASING THE RISK OF INJURY OR LOSS OF VEHICLE CONTROL IF OCCURRING WHILE IN MOTION.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN/MERCURY DEALER TO HAVE A NEW CLOCKSPRING JUMPER WIRE INSTALLED THAT INCORPORATES A PROTECTIVE MESH COVER. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THIS SAFETY RECALL BEGAN ON SOME VEHICLES IN MARCH 2011. THE RECALL CAMPAIGN ON THE EXPANDED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT MAY 9, 2011. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Campaign 11V107000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Service brakes, hydraulic, power assist, vacuum, hoses, lines/piping, and fittingsMay 7, 2008
FORD IS RECALLING 605,684 MY 2005-2006 F-150 AND LINCOLN MARK LT VEHICLES EQUIPPED WITH 5.4L 3-VALVE ENGINES. THE BRAKE BOOSTER VACUUM SUPPLY HOSE ATTACHED TO THE INTAKE MANIFOLD FITTING MAY SWELL OVER TIME AND LOSE RETENTION FORCE. THIS CONDITION COULD ALLOW THE HOSE TO BECOME DETACHED FROM THE FITTING DURING AN INTAKE MANIFOLD BACKFIRE. SHOULD THE HOSE DETACH FROM THE INTAKE MANIFOLD, SEVERAL BRAKE APPLICATIONS WITH POWER ASSIST WILL BE AVAILABLE BEFORE THE VACUUM RESERVE IS DEPLETED.
ONCE THE BRAKE BOOSTER VACUUM RESERVE IS DEPLETED, THE DRIVER WILL HAVE FOUNDATION BRAKE FUNCTION, BUT WITH INCREASED BRAKE PEDAL EFFORT. REDUCED VEHICLE BRAKING COULD LEAD TO A CRASH.
DEALERS WILL REPLACE A RUBBER HOSE ON THE BRAKE BOOSTER VACUUM SUPPLY TUBE ASSEMBLY. THE RECALL BEGAN ON JUNE 27, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 08V208000 on NHTSA.gov
Exterior lighting, headlightsOct 25, 2007
CERTAIN SPYDER HEADLAMP REPLACEMENT ASSEMBLIES SOLD FOR USE ON 2004 THROUGH 2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SPYDER WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2007. OWNERS CAN CONTACT SPYDER AT 866-558-4264.
Campaign 07E089000 on NHTSA.gov
Exterior lighting, headlightsSep 25, 2007
CERTAIN HEADLAMP ASSEMBLIES IMPORTED AND SOLD AS AFTERMARKET EQUIPMENT BY SONAR AUTO PARTS FOR USE ON 2004-2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SONAR WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS CAN CONTACT SONAR AT 866-558-4264.
Campaign 07E080000 on NHTSA.gov
Exterior lighting, headlightsSep 14, 2007
CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. FR390-B001L AND FR390-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE THICKNESS IS UNSTABLE INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
EAGLE EYES WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON NOVEMBER 6, 2007. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.
Campaign 07E075000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Interior lightingFeb 6, 2006
CERTAIN PICKUP TRUCKS FAIL TO COMPLY WITH EITHER THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 105, 'HYDRAULIC AND ELECTRIC BRAKE SYSTEMS' OR FMVSS NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' THESE VEHICLES WERE BUILT WITH A SOFTWARE ERROR IN THE INSTRUMENT CLUSTER.
THIS ERROR COULD PREVENT THE ANTILOCK BRAKE SYSTEM (ABS) WARNING LIGHT FROM ILLUMINATING IF THE ABS MODULE EVER BECAME INOPERATIVE.
DEALERS WILL RECALIBRATE THE INSTRUMENT CLUSTER IN THESE VEHICLES. THE RECALL BEGAN ON FEBRUARY 27, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 06V033000 on NHTSA.gov
Tires, tread/beltNov 21, 2005
CERTAIN CONTINENTAL CONTITRAC TR OWL, CONTITRAC TR BSW, GENERAL GRABBER TR BSW, AND CONTITRAC BSW TIRES MANUFACTURED BETWEEN MAY 29 AND JUNE 11, 2005, AND SOLD AS ORIGINAL EQUIPMENT ON CERTAIN FORD TRUCKS AND SOLD AS REPLACEMENT TIRES. THESE TIRES CAN WEAR PREMATURELY WHICH FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 119, NEW PNEUMATIC TIRES FOR VEHICLES OTHER THAN PASSENGER CARS.
AFFECTED TIRES MAY NOT MEET THE ENDURANCE TEST REQUIREMENTS OF THE STANDARD. CONTINUED USE OF THE AFFECTED TIRES CAN RESULT IN TIRE FAILURE WHICH COULD LEAD TO VEHICLE DAMAGE OR MOTOR VEHICLE CRASH.
CONTINENTAL WILL NOTIFY OWNERS AND REPLACE THE TIRES FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 7, 2005. OWNERS MAY CONTACT CONTINENTAL AT 704-588-5895.
Campaign 05T022000 on NHTSA.gov
Visibility, windshield wiper/washer, motorNov 9, 2005
ON CERTAIN TRUCKS, PASSENGER CARS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MOTOR MAY HAVE BEEN PRODUCED WITHOUT GREASE BEING APPLIED TO THE OUTPUT SHAFT GEAR.
AFTER A PERIOD OF CONTINUOUS USE ON THE HIGH SPEED SETTING, LACK OF GREASE ON THE OUTPUT SHAFT GEAR MAY CAUSE THE GEAR TO DISTORT OR FRACTURE DURING OPERATION RESULTING IN A LOSS OF WIPER FUNCTION. INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.
DEALERS WILL INSPECT THE WIPER MOTOR FOR THE PRESENCE OF GREASE AND GREASE THE WIPER MOTOR GEARS IF NECESSARY. THE RECALL BEGAN ON NOVEMBER 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673 OR LINCOLN/MERCURY AT 1-800-521-4140.
Campaign 05V520000 on NHTSA.gov
Representative owner complaints: electrical system
61 reports, newest first. Show all
Electrical system, Apr 24, 2025
Odometer Fraud. The contact sold a 2006 Ford F-150. The contact stated that the vehicle was sold with approximately 212,000 miles but later discovered that the buyer had relisted the vehicle for sale with an advertised mileage of 135,713. The vehicle was a private sale. Local authorities had been notified.
Power train, Electrical system, Engine, Mar 28, 2025
while in drive, accelerating to highway speeds or cruising around 30 mph it will downshift and jump to about 4000 PMS's and not shift up into 3rd gear. It blown 1 engine and I have replaced the transmissions, taken it to a Ford dealership and they weren't able to help me. I've replaced the ECM and anti-theft modal also and the symptoms still persist. i am i in for over 11K for the new engine and transmission, and another $100 on the ECM and anti-theft modal plus the shop charges. The truck has under 190,000 miles before any of this started. I am the 2nd owner an had for less than 3k miles before any of the problems started. Now I see the 2015-2017 F-150s are having the same problems getting recalled. is there anything involving the earlier Triton's engines?
Electrical system, May 17, 2022
broken fuses baks air conditioning
Electrical system, Service brakes, Jun 2, 2021
There is a very common problem with the brake light always being on due to a short circuit in the cluster, many owners have reported this problem for several manufacturing years, the brake light is always on even though there is no problem with the brakes. This creates a great hazard because if you do have a brake problem since the light is always on you will never know, and you may be in a fatal vehicle accident. Ford motor company should replace or repair all clusters that have this problem.I just purchased this vehicle with this very common problem. Your inspector can google it and will find this is indeed a very common problem.
Electrical system, Engine, Dec 25, 2020
COMPUTER KEEPS THROWING CODE FOR INTERMITTENT CAM SHAFT POSITION SENSOR CIRCUIT A BANK 1. CAUSE TRUCK TO RUN ON ONLY HALF POWER. POOR MPG. NO HORSEPOWER. HESITATION IN SHIFTING.
Electrical system, Exterior lighting, Other or unspecified, Nov 11, 2020
MY 2006 F150 FORD LARIAT. IT STARTED WITH THE FRONT MAP LIGHT ARE SOME LIGHT NOT SURE WHAT IT'S CALLED. IT WOULD COME ON BY ITSELF JUST SITTING STILL WITH ENGINE OFF. AND NO ONE IN THE TRUCK. IT WOULD DO THIS ALL HOURS OF DAY AND NIGHT. THEN THE DOOR JAR LIGHT CAME ON GOING DOWN THE HWY. AND WOULD NOT GO OFF. WE STOP TO CHECK ALL DOES AND THEY ALL WAS SHUT. IT STAYS ON AND WANT GO OFF. THEN WITH ALL THAT GOING ON ALL MY POWER WINDOWS STOP WORKING. THEY WAS WORKING FINE BUT WHEN THE DIME LIGHT PROBLEM. AND THE DOOR A JAR LIGHT ON WHEN YOU GET IN THE TRUCK AND TURN KEY ON. I HAVE TALK TO PEOPLE THAT OWN A FORD AND MOST ALL FORD'S HAVE HAD THIS PROBLEM. I ALSO HAVE GOOGLED THESE PROBLEMS AND A LOT OF PEOPLE HAVE HAD THE SAME PROBLEMS. BUT IT HASN'T BEEN ANY RECALL ON THESE PROBLEMS. IT REALLY NEEDS TO BE A RECALL FOR THESE PROBLEMS ON FORD'S. IT'S A ELECTRICAL PROBLEM.
Electrical system, Service brakes, Sep 12, 2019
BRAKE LIGHT CONTINUOUSLY ON DUE TO FAULT IN CLUSTER PANEL. SAFETY ISSUE IN NOT KNOWING WHEN THERE ARE BRAKING PROBLEMS.
Electrical system, Exterior lighting, Service brakes, Jun 4, 2019
FORD F-150 FX4 140,000.0 MILES. BRAKE LIGHT HAS BEEN ON FOR SEVERAL YEARS STARTING AROUND 2010 WITH 76,000.0 MILES. THE BRAKES WERE REPLACED AND FLUSHED MULTIPLE TIMES SINCE THE PROBLEM STARTED. REPLACED BRAKE CABLE E-BRAKE SWITCH ETC... EVERYTHING POINTS TO THE CLUSTER AND THERE ARE MULTIPLE WEBSITES THE VERIFY THE SAME EXACT PROBLEM WITH THE BRAKE LIGHT BEGINNING FROM 2004-2010. IN SOME STATES THIS IS AN INDPECTABLE ITEM ADDING ADDITIONAL AND MANDATORY REPAIRS TO BE MADE. THE CLUSTER REPAIR PART COST ANYWHERE FROM $400.00-$600.00 AND WITH LABOR COULD RUN WELL OVER $1000.00 PENDING ON THE MODEL OF THE F-150. MY BOTTOM LINE IS THAT THIS ISSUE HAS GONE WITHOUT A RECALL FROM FORD OR THE NHTSA.
Electrical system, Exterior lighting, Vehicle speed control, Apr 2, 2019
INTERIOR LIGHTS DO NOT LIGHT UP ON OPENING THE DOOR. ADDITIONALLY, UPON STARTING THE ENGINE, THE ELECTRICAL PANEL BLINKS, FIZZLES, DEMANDS RESET, WHICH DOESN'T RESET, AND EVENTUALLY CORRECTS ITSELF SOMETIMES AFTER 15 MINUTES OF BLINKING. ADDITIONALLY, THE HIGH BEAMS IMPLEMENT AND THEN YOU CANNOT MAKE THE HIGH BEAMS TURN OFF. MAY ALL BE RELATED BUT, SEEMS LIKE 3 SEPARATE ISSUES, ALL SEEM TO BE RELATED TO THE ELECTRICAL PANEL. BLINKING BEGINS WHILE STATIONARY UPON STARTING TRUCK AND CONTINUES WHILE IN MOTION, INDICATES PROBLEM WITH EVERYTHING ELECTRICAL INCLUDING SPEEDOMETER AND STATES AUTO LOCKS FAIL, ALONG WITH BLINKING FAILURE OF ALL SYSTEMS STATING RESET BUT PUSHING RESET DOES NOT APPEAR TO FIX ANYTHING.....ONLY TIME FIXES IT.
Electrical system, Engine, Fuel/propulsion system, Dec 25, 2018
MOTOR IS MISSING AND THE CODES ARE P0345, P0349 AND P0171
Electrical system, Exterior lighting, Other or unspecified, Sep 7, 2018
TAKATA RECALL. FOR THREE YEARS OF ELECTRICAL ISSUES, BEEPING ELECTRICAL DASH PANEL AND LIGHTS IN TRUCK HARDLY EVER WORK. THE TRUCKS DEPENDABILITY AT MOMENT ISN'T GREAT DUE TO THESE ISSUES. CAN'T AFFORD A NEW TRUCK AT TIME BEING .. THIS TRUCK TRANSPORTS MY TODDLERS AROUND. THIS TYPICALLY HAPPENS WHEN TURNING ON CAR AND OPENING DOORS WE NEVER SEE LIGHTS ON. IT DOES HAPPEN ALSO WHEN DRIVING AT RANDOM TIMES. NOT SURE IF IT HAS ANYTHING TO DO WITH STOPPING OR TURNING. WILL HAPPEN AT ANY RATE OF SPEED.
Electrical system, Exterior lighting, Nov 8, 2017
SMART JUNCTION BOX FAILED. CAUSING INTERIOR, DASH AND BACK LIGHTS NOT TO LIGHT AND INCLUDING THE HORN NOT TO WORK. WHEN TRYING TO REPLACE THE FUSE IT WOULD BLOW THE FUSE AND SMOKE. IT IS IN THE SHOP NOW TO HAVE THE SMART JUNCTION BOX REPLACED. FUSES STARTED BLOWING. AT FIRST IT WAS THE RADIO AND THE FUSE WAS REPLACED THEN THE OTHERS STARTED TO BLOW.
Electrical system, Structure, Engine, Oct 23, 2017, fire
MY TRUCK CAUGHT ON FIRE YESTERDAY. DUE TO A HEAT SHIELD MISSING OVER PASSENGER SIDE CATALYTIC CONVERTER CAUSED THE PLASTIC GROMMETS THAT HOLD THE SOUND BARRIER MATERIAL ON THE FLOORBOARD TO DROP AND HANG ON TOP OF THE CATALYTIC CONVERTER UNTIL THE MATERIAL CAUGHT ON FIRE. MY INSURANCE COMPANY IS STILL INVESTIGATING HOW THE CATALYTIC CONVERTER HEAT SHIELD WAS MISSING. LESS THAN A MONTH AFTER I BOUGHT THE TRUCK AND IT WAS USED, THEY HAD TO DO SERVICE WORK ON IT BECAUSE I PURCHASED THE TRUCK WITH A BROKEN FRONT COIL SPRING AND THE TRANSMISSION DIPSTICK TUBE HAD ROTTED. EVEN THOUGH THE TRUCK WAS MISSING A HEAT SHIELD, I BELIEVE THERE SHOULD BE ANY KIND OF FLAMMABLE MATERIAL NEAR THE CATALYTIC CONVERTER JUST IN CASE A HEAT SHIELD HAPPENS TO ROT AND FALL OFF OR FOR ANY REASON THE HEAT SHIELD IS MISSING .THE FIRE TRAVELED THROUGH THE MATERIAL ALMOST TO THE TOP OF MY ENGINE. AFTER I GOT THE FLAMES OUT IT WAS STILL SMOLDERING AND SMOLDERED UP INTO A SPACE I COULD NOT REACH TO NOR SEE. I ALSO BELIEVE A FIRE RETARDANT SYSTEM SHOULD BE CREATED TO DOUSE FLAMES IN A SECTION OF AN ENGINE COMPARTMENT THAT CANNOT BE REACHED AND WOULD PROBABLY SAVE COUNTLESS LIVES PROPERTY AND INVESTED MONEY INTO VEHICLE AND OTHER THINGS THAT A VEHICLE ON FIRE COULD DESTROY.
Electrical system, Air bags, Structure, Dec 12, 2016
TL* THE CONTACT OWNS A 2006 FORD F-150. AFTER TAKING THE VEHICLE TO A DRIVE THRU CAR WASH SERVICE, WATER ENTERED THE PASSENGER SIDE. THE INTERIOR OF THE PASSENGER SIDE BECAME WET AND THE AIR BAG WARNING INDICATOR ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 98,000.
Electrical system, Jul 14, 2016
TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING 15 MPH, THE VEHICLE MADE A LOUD POPPING NOISE AND THE INSTRUMENT PANEL BECAME INOPERABLE. IN ADDITION, THE REAR WINDOWS AND POWER LOCKS FAILED TO OPERATE AND THE VEHICLE STALLED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS 150,000.
Electrical system, Service brakes, Jun 3, 2016
AFTER COUNTLESS HOURS SPENT DIAGNOSING A DASH BRAKE LITE WARNING. THESE VEHICLES FACTORY DEFECT IS THE ELECTRONICS BOARD OR SPEEDOMETER CLUSTER. COUNTLESS PEOPLE ARE DRIVING WITH A BRAKE LIGHT ON WITH NOTHING POSSIBLY WRONG.WHEN SOMETHING DOES GO WRONG THEY MAY NOT HAVE A CLUE UNTIL THE VEHICLE HAS NO BRAKES.
Electrical system, Nov 2, 2015
WHILE DRIVING INSTRUMENT PANAL SHUTS DOWN, RADIO SHUTS OFF, AIRBAG INDICATOR COMES ON, WINDOWS DON'T WORK, IF SHUT OFF LASTS MORE THAN 5 MINUTES SEAT BELT CHIME GOES OFF, TWICE WORD TEST CAME ON IN MILEAGE INDICATOR WINDOW. SOMETIMES GOES ON AND OFF WHILE TURNING OR HITTING BRAKES, OTHER TIMES JUST WHILE DRIVING.
Electrical system, Engine, Fuel/propulsion system, Sep 25, 2015
SPARK PLUGS ON THE 5.3 LITER ENGINE WHEN REPLACED BREAK--IN RETURN THE BOOK SAID PULL ENGINE AND PULL HEADS TO REPLACE SPARK PLUGS. THE LAW SUIT FILLED FORD ADMITS TO BAD DECISION ON SPARK PLUGS AND WILL REIMBURSE SOME OF THE COST. THE COST IS VERY HIGH--THE BOOK AND FORD'S SHOP SAID THE ENGINE NEEDS TO BE PULLED TO PULL THE HEADS TO REPLACE THE SPARK PLUGS. THERE WAS NEVER ANY SOFTWARE UPDATES, AND NOW THE VEHICLE REQUIRES THEM. THE ERROR IN THE CLUSTER SOFTWARE RECALL WAS SUPPOSE TO BE REPAIRED AND I READ FROM THE EXPERTS ALL SOFTWARE SHOULD HAVE BEEN UPGRADED WITH THE CLUSTER ERROR. THERE ARE 42 P.M. FORD AND NHSTA KNEW OR KNOWS ABOUT ON MY VEHICLE AND NOTHING HAS BEEN DONE, I AM A 100% DAV AND MY VEHICLE HAS BEEN BROKEN DOWN. THE 2006 HARLEY DAVIDSON F-150 THAT COST SO MUCH WITH IT'S ON BOARD COMPUTER SYSTEM DOES NOT WORK. I HAVE READ MANY COMPLAINTS ABOUT THE F-150 ENGINE CUTTING OUT, I PULLED OUT TO PASS ON A TWO LANE ROAD AND ALMOST GOT KILLED WHEN MINE CUT OUT SO BAD. A TWO CYLINDER WOULD HAVE DONE BETTER THAN THAT V-8.
Electrical system, Sep 4, 2015
TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING AT 45 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE FAILED TO RESTART AND WAS TOWED TO A MECHANIC WHERE IT WAS DISCOVERED THAT THE IGNITION SWITCH NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. AFTER THE VEHICLE WAS REPAIRED, THE FAILURE CONTINUED WITH A TICKING NOISE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNAVAILABLE.
Electrical system, Air bags, Seat belts, Aug 23, 2015
IN JUNE 2015, THE AIR BAG LIGHT IN MY FORD F150 ILLUMINATED, INDICATING A PROBLEM. I TOOK MY VEHICLE TO A FORD DEALERSHIP. THEY TOLD ME THAT THE DEPLOYABLE RESTRAINT SYSTEM, SPECIFICALLY THE PRETENSIONER, HAD MALFUNCTIONED AND POSSIBLY WOULD FAIL TO FUNCTION AS INTENDED IN THE EVENT OF A CRASH. THE SERVICE TECHNICIAN INDICATED THAT THE RESTRAINT SYSTEM IS CONNECTED TO MY AIR BAGS, WHICH MIGHT FAIL TO WORK IN A CRASH, INCREASING THE RISK OF INJURY. AFTER PAYING THE DIAGNOSTIC FEE, I WAS GIVEN A REPAIR ESTIMATE OF AN ADDITIONAL $392.21. NOT WANTING TO RISK INJURY IN THE EVENT OF A CRASH, I HAD THE PRETENSIONER REPLACED. THE BUCKLE PRETENSIONER IS A CRITICAL SAFETY DEVICE THAT SHOULD NEVER FAIL UNDER NORMAL USE. MY VEHICLE HAS NEVER BEEN IN AN ACCIDENT. IT IS MY UNDERSTANDING THAT SOME PRETENSIONERS HAVE FAILED DUE TO SIMPLE SEAT POSITION ADJUSTMENTS, WHICH, TO ME, IS EVIDENCE OF A POOR DESIGN. FORD HAS RECENTLY RECALLED MANY 2013 ' 2014 VEHICLES FOR POORLY MADE PRETENSIONERS, RECOGNIZING THE SAFETY ISSUE SURROUNDING THEM. I REQUESTED THAT FORD REIMBURSE ME FOR THE COST OF THE PRETENSIONER BUCKLE; HOWEVER, FORD DENIED THIS REQUEST. I HAVE THE ORIGINAL PRETENSIONER AND ALL RECEIPTS AVAILABLE.
Electrical system, Equipment adaptive/mobility, Engine, Aug 11, 2015
MORNING OF JULY 23,2015, I WAS DRIVING ABOUT 25 MPR SPEED WHEN NUMBER THREE SPARK PLUG BLOW OUT OF THE CYLANDERHEAD ON MY F-150 TRITON V8. TOOK IT TO THE LOCAL MACHANIC SHOP WALTON'S. THREE HOURS LATER, WALTON'S HAD TO REPLACE AND RESLEEVE NUMBER THREE CYLANDERHEAD AND REPLACED ELECTRICAL SPARKPLUG WIRE, PLUS REPLACED ALL EIGHT SPARK PLUGS. ALL AT A COST OF $543.00. NOT ONLY THIS HAPPENED TO ME BUT WALTON'S STATED THAT I WAS THE 10TH PERSON THIS WEEK THIS HAS HAPPENED TOO. I PRESENTED THE PART TO MY LOCAL FORD DEALERSHIP WHERE WE BOUGHT THE TRUCK (HALL'S FORD MOTOR COMPANY) BRAND NEW IN 2006 AND PAID CASH TO THE SUM OF $30,000.00. I ASKED THEM IF THEY KNOW OF THIS PROBLEM WITH TRITON V8'S. THEY STATED THEY DID BUT NO KNOW RECALLS AND THEY TOO HAD SEVERAL REPAIRS COME IN FOR THE SAME THING IN THE PASS WEEK. THEY ALSO STATED THAT THE FORD MOTOR COMPANY WAS AWARE OF THIS MATTER BUT NEVER LET THERE CUSTOMERS KNOW ABOUT THIS PROBLEM YET BECAUSE THERE WAS NO RECALL ON FILE TO LET THEM KNOW. THIS THING WHERE THE SPARK PLUGS COME FLYING OUT OF AN ENGINE CAN BE VERY HAZARDS, IT COULD CAUSE A CRASH OR EVEN GIVE A PERSON A HEART ATTACK BECAUSE THE TRUCK SOUNDS LIKE WORLD WAR III GOING OFF UNDER THE HOOD AND IT MAY EVEN START A FIRE. THIS MATTER NEEDS TO BE TAKEN CARE OF BY FORD.
Electrical system, Engine, Jul 13, 2015
TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR ROUTINE MAINTENANCE. WHILE AT THE INDEPENDENT MECHANIC, THE CONTACT WAS NOTIFIED THAT SEVEN OF THE EIGHT SPARK PLUGS IN THE VEHICLE WERE FRACTURED AND NEEDED TO BE REPLACED. THE CONTACT STATED THAT ONE OF THE FRACTURED SPARK PLUGS REMAINED IN THE CYLINDER HEAD. THE MECHANIC STATED THAT THE CYLINDER HEAD HAD TO BE REMOVED FROM THE ENGINE TO REMOVE THE FRACTURED SPARK PLUG. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE; HOWEVER, THE CONTACT WAS NOT OFFERED A REMEDY FOR THE FAILURE. THE FAILURE MILEAGE WAS 84,000.
Steering, Power train, Electrical system, Feb 5, 2015
FORD'S IWE SOLENOID HAS A TENDENCY TO MALFUNCTION DUE TO A POOR DESIGN. TSB 06-8-15 WAS ISSUED TO REPLACE THESE SOLENOIDS, BUT ONLY IF THERE WAS A PROBLEM AND ONLY IF IT WAS GIVING A PROBLEM. MY VEHICLE WAS IN STORAGE FOR 5 YEARS AND AFTER IT WAS BROUGHT OUT AND TO NY, THE WATER LEAKED ON THE SOLENOID DUE TO THE INADEQUATE DESIGN, CAUSING THE IWE'S TO MALFUNCTION. I STILL DON'T KNOW WHAT EXACTLY IT DID BUT DRIVING THE CAR DOWN THE ROAD, IT CAUSED ME TO FEEL LIKE I WAS DRIVING OVER SMALL SPEED BUMPS WITH THE FRONT DRIVERS SIDE TIRE. I'M AFRAID THAT IF THIS FAILED AT A HIGH RATE OF SPEED IT COULD CAUSE THE IWE TO ENGAGE AND POSSIBLY LOCK UP ONE OF THE FRONT TIRES. *TR
Electrical system, Jan 31, 2015
VEHICLE STARTED LOSING POWER AND UNABLE TO RUN CORRECTLY. TOOK TO GARAGE AND FUEL PUMP DRIVE MODULE WAS RUSTED WITH CIRCUITS BEING EXPOSED TO THE SALT AND MOISTURE ELEMENTS WHERE THERE WAS A LARGE HOLE IN BACK OF UNIT. NEW ONE WAS INSTALLED WITH SPACERS TO HELP PREVENT SALT AND MOISTURE FROM COLLECTING WHERE BACK OF MODULE MOUNTS ONTO AXLE BRACKET. VEHICLE RAN BETTER BUT ALSO HAD TO INSTALL NEW COIL DUE TO A CYLINDER MISSING. RUNS OK WITH WORK THAT WAS PERFORMED. MODULE SHOULD NOT HAVE BEEN INSTALLED AGAINST THE BRACKET SO SALT AND MOISTURE COULD COLLECT AND RUST IT SO BADLY AND CAUSE IT TO FAIL. FORD SHOULD PAY FOR THIS REPAIR DUE TO THE WAY IN WHICH THE MODULE WAS INSTALLED SO IT WOULD RUST SO BADLY. *TR
Electrical system, Vehicle speed control, Jan 21, 2015
TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING APPROXIMATELY 45 MPH, THE VEHICLE FAILED TO ACCELERATE AND THE SERVICE VEHICLE WARNING INDICATOR ILLUMINATED CONTINUOUSLY. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN DIAGNOSED THAT A SENSOR WAS FAULTY. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 89,069. UPDATED 04/10/15*LJ UPDATED 11/5/2015*JS