2006 Ford F-150
Problems, recalls and owner-reported issues
Service brakes is the leading concern among 589 owner complaints filed for this model year. This is the 6th highest complaint count among 26 F-150 model years with reports.
Of the 2006 reports, 58 involved a crash and 18 involved a fire. 42 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Air bags, frontal, driver side, inflator moduleFeb 23, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2004-2006 F-150 PICK UP TRUCKS AS WELL AS CERTAIN MODEL YEAR 2006 LINCOLN MARK LT VEHICLES. IF THE CLOCKSPRING JUMPER WIRE COMES IN CONTACT WITH THE DRIVER SIDE FRONTAL AIR BAG LOWER HORN PLATE, THE WIRE INSULATION MAY BECOME CHAFED, CREATING A POTENTIAL FOR A SHORT CIRCUIT. IF THIS OCCURS THE AIR BAG WARNING LAMP MAY ILLUMINATE INDICATING THAT SERVICE IS REQUIRED.
THE DRIVER SIDE FRONTAL AIR BAG COULD INADVERTENTLY DEPLOY INCREASING THE RISK OF INJURY OR LOSS OF VEHICLE CONTROL IF OCCURRING WHILE IN MOTION.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN/MERCURY DEALER TO HAVE A NEW CLOCKSPRING JUMPER WIRE INSTALLED THAT INCORPORATES A PROTECTIVE MESH COVER. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THIS SAFETY RECALL BEGAN ON SOME VEHICLES IN MARCH 2011. THE RECALL CAMPAIGN ON THE EXPANDED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT MAY 9, 2011. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Campaign 11V107000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Service brakes, hydraulic, power assist, vacuum, hoses, lines/piping, and fittingsMay 7, 2008
FORD IS RECALLING 605,684 MY 2005-2006 F-150 AND LINCOLN MARK LT VEHICLES EQUIPPED WITH 5.4L 3-VALVE ENGINES. THE BRAKE BOOSTER VACUUM SUPPLY HOSE ATTACHED TO THE INTAKE MANIFOLD FITTING MAY SWELL OVER TIME AND LOSE RETENTION FORCE. THIS CONDITION COULD ALLOW THE HOSE TO BECOME DETACHED FROM THE FITTING DURING AN INTAKE MANIFOLD BACKFIRE. SHOULD THE HOSE DETACH FROM THE INTAKE MANIFOLD, SEVERAL BRAKE APPLICATIONS WITH POWER ASSIST WILL BE AVAILABLE BEFORE THE VACUUM RESERVE IS DEPLETED.
ONCE THE BRAKE BOOSTER VACUUM RESERVE IS DEPLETED, THE DRIVER WILL HAVE FOUNDATION BRAKE FUNCTION, BUT WITH INCREASED BRAKE PEDAL EFFORT. REDUCED VEHICLE BRAKING COULD LEAD TO A CRASH.
DEALERS WILL REPLACE A RUBBER HOSE ON THE BRAKE BOOSTER VACUUM SUPPLY TUBE ASSEMBLY. THE RECALL BEGAN ON JUNE 27, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 08V208000 on NHTSA.gov
Exterior lighting, headlightsOct 25, 2007
CERTAIN SPYDER HEADLAMP REPLACEMENT ASSEMBLIES SOLD FOR USE ON 2004 THROUGH 2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SPYDER WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2007. OWNERS CAN CONTACT SPYDER AT 866-558-4264.
Campaign 07E089000 on NHTSA.gov
Exterior lighting, headlightsSep 25, 2007
CERTAIN HEADLAMP ASSEMBLIES IMPORTED AND SOLD AS AFTERMARKET EQUIPMENT BY SONAR AUTO PARTS FOR USE ON 2004-2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SONAR WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS CAN CONTACT SONAR AT 866-558-4264.
Campaign 07E080000 on NHTSA.gov
Exterior lighting, headlightsSep 14, 2007
CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. FR390-B001L AND FR390-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE THICKNESS IS UNSTABLE INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
EAGLE EYES WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON NOVEMBER 6, 2007. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.
Campaign 07E075000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Interior lightingFeb 6, 2006
CERTAIN PICKUP TRUCKS FAIL TO COMPLY WITH EITHER THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 105, 'HYDRAULIC AND ELECTRIC BRAKE SYSTEMS' OR FMVSS NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' THESE VEHICLES WERE BUILT WITH A SOFTWARE ERROR IN THE INSTRUMENT CLUSTER.
THIS ERROR COULD PREVENT THE ANTILOCK BRAKE SYSTEM (ABS) WARNING LIGHT FROM ILLUMINATING IF THE ABS MODULE EVER BECAME INOPERATIVE.
DEALERS WILL RECALIBRATE THE INSTRUMENT CLUSTER IN THESE VEHICLES. THE RECALL BEGAN ON FEBRUARY 27, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 06V033000 on NHTSA.gov
Tires, tread/beltNov 21, 2005
CERTAIN CONTINENTAL CONTITRAC TR OWL, CONTITRAC TR BSW, GENERAL GRABBER TR BSW, AND CONTITRAC BSW TIRES MANUFACTURED BETWEEN MAY 29 AND JUNE 11, 2005, AND SOLD AS ORIGINAL EQUIPMENT ON CERTAIN FORD TRUCKS AND SOLD AS REPLACEMENT TIRES. THESE TIRES CAN WEAR PREMATURELY WHICH FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 119, NEW PNEUMATIC TIRES FOR VEHICLES OTHER THAN PASSENGER CARS.
AFFECTED TIRES MAY NOT MEET THE ENDURANCE TEST REQUIREMENTS OF THE STANDARD. CONTINUED USE OF THE AFFECTED TIRES CAN RESULT IN TIRE FAILURE WHICH COULD LEAD TO VEHICLE DAMAGE OR MOTOR VEHICLE CRASH.
CONTINENTAL WILL NOTIFY OWNERS AND REPLACE THE TIRES FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 7, 2005. OWNERS MAY CONTACT CONTINENTAL AT 704-588-5895.
Campaign 05T022000 on NHTSA.gov
Visibility, windshield wiper/washer, motorNov 9, 2005
ON CERTAIN TRUCKS, PASSENGER CARS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MOTOR MAY HAVE BEEN PRODUCED WITHOUT GREASE BEING APPLIED TO THE OUTPUT SHAFT GEAR.
AFTER A PERIOD OF CONTINUOUS USE ON THE HIGH SPEED SETTING, LACK OF GREASE ON THE OUTPUT SHAFT GEAR MAY CAUSE THE GEAR TO DISTORT OR FRACTURE DURING OPERATION RESULTING IN A LOSS OF WIPER FUNCTION. INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.
DEALERS WILL INSPECT THE WIPER MOTOR FOR THE PRESENCE OF GREASE AND GREASE THE WIPER MOTOR GEARS IF NECESSARY. THE RECALL BEGAN ON NOVEMBER 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673 OR LINCOLN/MERCURY AT 1-800-521-4140.
Campaign 05V520000 on NHTSA.gov
Representative owner complaints: power train
47 reports, newest first. Show all
Power train, Electrical system, Engine, Mar 28, 2025
while in drive, accelerating to highway speeds or cruising around 30 mph it will downshift and jump to about 4000 PMS's and not shift up into 3rd gear. It blown 1 engine and I have replaced the transmissions, taken it to a Ford dealership and they weren't able to help me. I've replaced the ECM and anti-theft modal also and the symptoms still persist. i am i in for over 11K for the new engine and transmission, and another $100 on the ECM and anti-theft modal plus the shop charges. The truck has under 190,000 miles before any of this started. I am the 2nd owner an had for less than 3k miles before any of the problems started. Now I see the 2015-2017 F-150s are having the same problems getting recalled. is there anything involving the earlier Triton's engines?
Power train, Structure, Engine, Mar 4, 2024
Rotted and bent frame realized after purchase on February 22 at nj car and driver (Cadillacs Plus) for $3500.00 Continues to stall and feels like it’s going to crack in two. Stalled a few times while driving and had to put it in neutral to start back up
Power train, Jun 8, 2021
The shift cable for the automatic transmission was routed next to the exhaust manifold on the engine. The shift cable gets hot and burns into from the heat off the exhaust manifold. I purchased the 2006 Ford F150 used. I had mechanic replace one shift cable with a new shift cable. The new shift cable burned into has I was backing in my driveway. I did research on the internet for trucks in that year range and it included other trucks 2007 and 2008 F150 having the same issue. You can find a ton of utube videos . ShowIng mechanics finding solutions to prevent the shift cables from burning into. I contacted Ford motor company about it. Ford wanted me to take the truck to a dealership and let them diagnosed the problem. The dealership wanted me to pay them a 150 dollars to look at it. I was not going to pay them for something that I already knew the answer too. So it is a manufacturing flaw with the way Ford put the shift cable on 2006 F150 and other F150's in that year range. I hope you research the issue and get back to me soon. Sincerely Yours [XXX] Ph [XXX] [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Power train, Dec 2, 2020
MY 2006 FORD F 150 HAS 125,000 MILES. I WENT TO PUT MY TRUCK IN REVERSE TO BACK UP OUT OF MY DRIVEWAY AND IT MADE A NOISE. APPARENTLY REVERS BAND IN THE TRANSMISSION WENT. I NO LONGER CAN PUT MY VEHICLE IN REVERSE TO BACK UP. VERY FRUSTRATED BECAUSE THE VEHICLE IS VERY WELL MAINTAINED AND IT BROKE FOR NO REASON.
Power train, Other or unspecified, Apr 29, 2019
I WAS PULLING IN MY DRIVEWAY I BACK OUT TO BACK IN BACK IN TO UNLOAD MY FOURWHEELER AN THE TRUCK WOULDN'T MOVE, I TAPPED THE FUEL A COUPLE TIMES AN SOUND LIKE THE TRANSMISSION WENT OUT, I JUST BOUGHT THE TRUCK IN FEBRUARY
Power train, Mar 23, 2018
THE MECHANIC SAID I NEED TO REPLACE MY TRANSMISSION, IT IS AN AUTOMATIC 4.6L MOTOR AND DOES NOT GET 4RD OR 4TH GEAR. MY VEHICLE WAS IN MOTION AND WHEN IT REACHED 40MPH IT WOULD NOT GO I HAD TO SWITCH TO 2ND GEAR.
Power train, Nov 17, 2017
TRANSMISSION HAS A DELAY SHIFTING OR KIND OF GET STOCK THE TRANSMISSION WAS REPLACED AT 80000 MILES AND DOING IT AGAIN
Power train, Jun 5, 2015
TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE STEERING WHEEL BECAME TIGHT AND LOOSENED UP AT RANDOM TIMES WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE DRIVESHAFT WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 160,000.
Power train, May 28, 2015
TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT WAS UNABLE TO SHIFT THE GEAR INTO DRIVE OR REVERSE, ONLY NEUTRAL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE CLUTCHES AND BANDS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 28,854. UPDATED 7/16/15*CN THE CONSUMER STATED THE TAIL SHAFT HOUSING HAD A HAIRLINE FRACTURE/CRACK WITH. THE REPAIRMAN BELIEVED THE PART WAS DEFECTIVE. THERE WAS NO WEAR ON THE INSIDE OF THE TRANSMISSION, BEARING OR SEALS. UPDATED 08/04/15*JB
Steering, Power train, Electrical system, Feb 5, 2015
FORD'S IWE SOLENOID HAS A TENDENCY TO MALFUNCTION DUE TO A POOR DESIGN. TSB 06-8-15 WAS ISSUED TO REPLACE THESE SOLENOIDS, BUT ONLY IF THERE WAS A PROBLEM AND ONLY IF IT WAS GIVING A PROBLEM. MY VEHICLE WAS IN STORAGE FOR 5 YEARS AND AFTER IT WAS BROUGHT OUT AND TO NY, THE WATER LEAKED ON THE SOLENOID DUE TO THE INADEQUATE DESIGN, CAUSING THE IWE'S TO MALFUNCTION. I STILL DON'T KNOW WHAT EXACTLY IT DID BUT DRIVING THE CAR DOWN THE ROAD, IT CAUSED ME TO FEEL LIKE I WAS DRIVING OVER SMALL SPEED BUMPS WITH THE FRONT DRIVERS SIDE TIRE. I'M AFRAID THAT IF THIS FAILED AT A HIGH RATE OF SPEED IT COULD CAUSE THE IWE TO ENGAGE AND POSSIBLY LOCK UP ONE OF THE FRONT TIRES. *TR
Power train, Jan 5, 2015
TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING APPROXIMATELY 25 MPH, THE TRANSMISSION CHANGED FROM TWO WHEEL DRIVE TO FOUR WHEEL DRIVE INDEPENDENTLY. THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 72,000. UPDATED 3/4/15*CN THE CONSUMER STATED THE CAUSE OF THE FAILURE WAS A FAULTY SOLENOID. UPDATED 10/15/2015 *JS
Power train, Oct 14, 2014
TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE MAKING A TURN AT AN UNKNOWN SPEED, THE VEHICLE BEGAN TO SHAKE VIOLENTLY. THE DEALER STATED THAT THE REAR DIFFERENTIAL FLUID NEEDED TO BE REFILLED. THE FLUID WAS REPLENISHED, BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN STATED THAT THE REAR DIFFERENTIAL NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 110,678.
Power train, Oct 7, 2014
TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT UPON TRAVELING OVER APPROXIMATELY 40 MPH ATTEMPTING TO ACCELERATE, THE VEHICLE HESITATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO DIAGNOSED THAT THE SPARK PLUGS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 92,000.
Power train, Jun 16, 2014
MY TRUCK WAS NOT INVOLVED IN AN ACCIDENT. I HAVE 74,000 MILES ON MY TRUCK AND THE TRANSMISSION IS STARTING TO SLIP. WITH THIS LOW MILEAGE THIS SHOULD NOT BE HAPPENING. *TR
Power train, Jul 9, 2013
WENT TO BACK UP AND NO REVERSE. *TR
Power train, Jun 10, 2013
TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE VEHICLE SHIFTED OUT OF GEAR WHILE AT A STOP AND THEN LUNGED FORWARD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO STATED THAT THE TRANSMISSION HAD DEVELOPED A PLANETARY NOISE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE WAS REPORTED TO THE MANUFACTURER. THE FAILURE MILEAGE WAS 24,000. THE CURRENT MILEAGE WAS 35,800.
Power train, Mar 25, 2013
TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH WITH THE CRUISE CONTROL ACTIVATED, THE ENGINE RPMS INCREASED AND THE VEHICLE WOULD NOT ACCELERATE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS. THE TECHNICIAN ADVISED THE CONTACT THAT THE TRANSMISSION WOULD HAVE TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 64,000. *TR
Steering, Power train, Wheels, Jan 22, 2013
MY 2006 FORD F150 HAS THE POSITRACTION REAR END. ITS WENT OUT AROUND 25000 TO 30000 MILES, WHILE THE TRUCK WAS STILL UNDER WARRANTY AND THE DEALER FIXED IT NO CHARGE. NOW THE TRUCK HAS A LITTLE OVER 62000 MILES AND THE REAR END HAS GONE OUT AGAIN. ALMOST EXACTLY THE SAME AMOUNT OF MILES ON THE REAR END. WARRANTY WAS UP AT 60000 MILES SO ITS NO LONGER COVERED. I THINK THIS SHOULD BE LOOKED INTO AS A RECALL BECAUSE THIS IS THE SECOND TIME ITS HAPPENED ON THE SAME TRUCK. *TR
Power train, Vehicle speed control, May 21, 2012
TRANSMISSION SHIFT CABLE OUTER SHEATH WAS MELTED ON EXHAUST SYSTEM. CABLE HAD UNKNOWINGLY COME LOOSE OF A RETAINING CLIP AND WAS THEN ALLOWED TO CONTACT HOT EXHAUST MANIFOLD. MELTED THE OUTER PLASTIC OF SHIFT CABLE CAUSING THE SHIFT SELECTOR TO BECOME INOPERABLE. SHIFT SELECTOR COULD BE PLACED IN PARK BUT TRANSMISSION WOULD NOT BE IN PARK; IF I HAD NOT REALIZED THERE WAS A PROBLEM I COULD HAVE BELIEVED THE TRANSMISSION WAS IN PARK WHEN IT WAS NOT AND THE TRUCK COULD HAVE ROLLED FREELY. TRUCK IS A WELL MAINTAINED 2006 FORD F150 CREW CAB 4X4 WITH THE COLUMN SHIFTER. *TT
Power train, Mar 5, 2012, crash
TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED, THE VEHICLE DRIFTED BACKWARD AND CRASHED INTO ANOTHER VEHICLE. THE CRASH CAUSED NO INJURIES AND A POLICE REPORT WAS FILED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION OR REPAIRS. THE MANUFACTURER WAS NOT CONTACTED AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 96,000 AND THE CURRENT MILEAGE WAS 96,500.
Engine and engine cooling, Power train, Feb 10, 2012
THE NUMBER 3 SPARK PLUG WAS BLOWN OUT OF THE CYLINDER HEAD. THIS IS THE SECOND OCCURRENCE OF THE SAME SPARK PLUG. THE FIRST INCIDENT OCCURRED ON 10/21/2011 AT 82781 MILES. THE FIRST REPAIR WAS COMPLETED BY MIKE NAUGHTON FORD IN AURORA CO. THE MECHANIC INSTALLED A SLEEVE INTO THE CYLINDER HEAD TO REINSTALL A NEW SPARK PLUG. THE MECHANIC EXPLAINED THAT THIS IS A KNOWN PROBLEM BECAUSE THE CYLINDER HEAD ONLY HAS 3-4 THREADS FOR THE SPARK PLUG TO SCREW INTO. *TR
Suspension, Power train, Feb 2, 2012
I HAD TO REPLACE ALL OF THE GEARS AND THE INSIDE AND OUTSIDE BEARINGS AND SEALS IN THE REAR END - ON A TRUCK THAT HAD 87,000 MILES. EVERY DEALERSHIP I'VE SPOKEN TO HAS TALKED ABOUT THE CHEAP BEARINGS IN THE FRONT AND REAR END ON THESE FORD F-150'S. 18,000 MILES AGO I HAD TO FIX THE FRONT END. *KB
Service brakes, Hydraulic, Power train, Vehicle speed control, Nov 15, 2011
ON 3 SEPARATE OCCASIONS WHEN BRAKES WERE APPLIED THE VEHICLE ACTUALLY SPED-UP AND WAS ONLY BROUGHT TO A STOP THROUGH HEAVY PRESSURE TO THE BRAKE PEDAL. *TR
Power train, Nov 2, 2011
TRANSMISSION JUMPS IN HIGH GEAR WHEN OVERDRIVE IS ACTIVE. *TR
Suspension, Power train, Sep 6, 2011
2006 FORD F-150. CONSUMER WRITES IN REGARDS TO REAR END OVERHAUL BEARINGS REPAIR *TGW THE CONSUMER STATED THE REAR PINION SEALS WERE REPLACED TWO YEARS AGO. THE CONSUMER BELIEVED THERE WAS SOMETHING WRONG WITH THE QUALITY OF WORK OR THERE WAS A MANUFACTURING DEFECT. THE DEALER AND FORD HAVE AGREED TO CUT THE BILL IN HALF TO $650. *JB