2006 Ford F-150
Problems, recalls and owner-reported issues
Service brakes is the leading concern among 589 owner complaints filed for this model year. This is the 6th highest complaint count among 26 F-150 model years with reports.
Of the 2006 reports, 58 involved a crash and 18 involved a fire. 42 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Air bags, frontal, driver side, inflator moduleFeb 23, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2004-2006 F-150 PICK UP TRUCKS AS WELL AS CERTAIN MODEL YEAR 2006 LINCOLN MARK LT VEHICLES. IF THE CLOCKSPRING JUMPER WIRE COMES IN CONTACT WITH THE DRIVER SIDE FRONTAL AIR BAG LOWER HORN PLATE, THE WIRE INSULATION MAY BECOME CHAFED, CREATING A POTENTIAL FOR A SHORT CIRCUIT. IF THIS OCCURS THE AIR BAG WARNING LAMP MAY ILLUMINATE INDICATING THAT SERVICE IS REQUIRED.
THE DRIVER SIDE FRONTAL AIR BAG COULD INADVERTENTLY DEPLOY INCREASING THE RISK OF INJURY OR LOSS OF VEHICLE CONTROL IF OCCURRING WHILE IN MOTION.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN/MERCURY DEALER TO HAVE A NEW CLOCKSPRING JUMPER WIRE INSTALLED THAT INCORPORATES A PROTECTIVE MESH COVER. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THIS SAFETY RECALL BEGAN ON SOME VEHICLES IN MARCH 2011. THE RECALL CAMPAIGN ON THE EXPANDED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT MAY 9, 2011. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Campaign 11V107000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Service brakes, hydraulic, power assist, vacuum, hoses, lines/piping, and fittingsMay 7, 2008
FORD IS RECALLING 605,684 MY 2005-2006 F-150 AND LINCOLN MARK LT VEHICLES EQUIPPED WITH 5.4L 3-VALVE ENGINES. THE BRAKE BOOSTER VACUUM SUPPLY HOSE ATTACHED TO THE INTAKE MANIFOLD FITTING MAY SWELL OVER TIME AND LOSE RETENTION FORCE. THIS CONDITION COULD ALLOW THE HOSE TO BECOME DETACHED FROM THE FITTING DURING AN INTAKE MANIFOLD BACKFIRE. SHOULD THE HOSE DETACH FROM THE INTAKE MANIFOLD, SEVERAL BRAKE APPLICATIONS WITH POWER ASSIST WILL BE AVAILABLE BEFORE THE VACUUM RESERVE IS DEPLETED.
ONCE THE BRAKE BOOSTER VACUUM RESERVE IS DEPLETED, THE DRIVER WILL HAVE FOUNDATION BRAKE FUNCTION, BUT WITH INCREASED BRAKE PEDAL EFFORT. REDUCED VEHICLE BRAKING COULD LEAD TO A CRASH.
DEALERS WILL REPLACE A RUBBER HOSE ON THE BRAKE BOOSTER VACUUM SUPPLY TUBE ASSEMBLY. THE RECALL BEGAN ON JUNE 27, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 08V208000 on NHTSA.gov
Exterior lighting, headlightsOct 25, 2007
CERTAIN SPYDER HEADLAMP REPLACEMENT ASSEMBLIES SOLD FOR USE ON 2004 THROUGH 2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SPYDER WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2007. OWNERS CAN CONTACT SPYDER AT 866-558-4264.
Campaign 07E089000 on NHTSA.gov
Exterior lighting, headlightsSep 25, 2007
CERTAIN HEADLAMP ASSEMBLIES IMPORTED AND SOLD AS AFTERMARKET EQUIPMENT BY SONAR AUTO PARTS FOR USE ON 2004-2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SONAR WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS CAN CONTACT SONAR AT 866-558-4264.
Campaign 07E080000 on NHTSA.gov
Exterior lighting, headlightsSep 14, 2007
CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. FR390-B001L AND FR390-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE THICKNESS IS UNSTABLE INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
EAGLE EYES WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON NOVEMBER 6, 2007. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.
Campaign 07E075000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Interior lightingFeb 6, 2006
CERTAIN PICKUP TRUCKS FAIL TO COMPLY WITH EITHER THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 105, 'HYDRAULIC AND ELECTRIC BRAKE SYSTEMS' OR FMVSS NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' THESE VEHICLES WERE BUILT WITH A SOFTWARE ERROR IN THE INSTRUMENT CLUSTER.
THIS ERROR COULD PREVENT THE ANTILOCK BRAKE SYSTEM (ABS) WARNING LIGHT FROM ILLUMINATING IF THE ABS MODULE EVER BECAME INOPERATIVE.
DEALERS WILL RECALIBRATE THE INSTRUMENT CLUSTER IN THESE VEHICLES. THE RECALL BEGAN ON FEBRUARY 27, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 06V033000 on NHTSA.gov
Tires, tread/beltNov 21, 2005
CERTAIN CONTINENTAL CONTITRAC TR OWL, CONTITRAC TR BSW, GENERAL GRABBER TR BSW, AND CONTITRAC BSW TIRES MANUFACTURED BETWEEN MAY 29 AND JUNE 11, 2005, AND SOLD AS ORIGINAL EQUIPMENT ON CERTAIN FORD TRUCKS AND SOLD AS REPLACEMENT TIRES. THESE TIRES CAN WEAR PREMATURELY WHICH FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 119, NEW PNEUMATIC TIRES FOR VEHICLES OTHER THAN PASSENGER CARS.
AFFECTED TIRES MAY NOT MEET THE ENDURANCE TEST REQUIREMENTS OF THE STANDARD. CONTINUED USE OF THE AFFECTED TIRES CAN RESULT IN TIRE FAILURE WHICH COULD LEAD TO VEHICLE DAMAGE OR MOTOR VEHICLE CRASH.
CONTINENTAL WILL NOTIFY OWNERS AND REPLACE THE TIRES FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 7, 2005. OWNERS MAY CONTACT CONTINENTAL AT 704-588-5895.
Campaign 05T022000 on NHTSA.gov
Visibility, windshield wiper/washer, motorNov 9, 2005
ON CERTAIN TRUCKS, PASSENGER CARS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MOTOR MAY HAVE BEEN PRODUCED WITHOUT GREASE BEING APPLIED TO THE OUTPUT SHAFT GEAR.
AFTER A PERIOD OF CONTINUOUS USE ON THE HIGH SPEED SETTING, LACK OF GREASE ON THE OUTPUT SHAFT GEAR MAY CAUSE THE GEAR TO DISTORT OR FRACTURE DURING OPERATION RESULTING IN A LOSS OF WIPER FUNCTION. INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.
DEALERS WILL INSPECT THE WIPER MOTOR FOR THE PRESENCE OF GREASE AND GREASE THE WIPER MOTOR GEARS IF NECESSARY. THE RECALL BEGAN ON NOVEMBER 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673 OR LINCOLN/MERCURY AT 1-800-521-4140.
Campaign 05V520000 on NHTSA.gov
Representative owner complaints
589 reports, newest first.
Engine and engine cooling, Jun 26, 2010
DURING ROUTINE MAINTENANCE SPARK PLUG CHANGE SIX OF THE OEM INSTALLED SPARKPLUGS BROKE OFF IN THE CYLINDER HEAD OF THE ENGINE. FORD DEALER ADMITS TO HAVING PROBLEMS WITH THIS DESIGN ENGINE AND STATES THIS OCCURS OFTEN. FORD DEALER STATED THAT FORD ADMITS AN ISSUE WITH THIS DESIGN SPARKPLUG AND HAS A TSB DETAILING THE PROCEDURE FOR BROKEN PLUG REMOVAL BUT HAS ISSUED NO FORMAL RECALL. DEALER ADVISED THAT FORD ALSO HAS A "SPECIAL TOOL" DESIGNED FOR THIS 5.4 3 VALVE SERIES MOTOR THAT IS ENGINE SPECIFIC TO REMOVE THE BROKEN PIECE OF THE SPARKPLUG BECAUSE THIS HAPPENS SO OFTEN. ALL BUT ONE OF THE BROKEN PLUGS WAS ABLE TO BE REMOVED USING A SPECIALTY TOOL PURCHASED AT AN AUTOMOTIVE PARTS STORE. FORD DEALER WAS UNABLE TO GET THE LAST BROKEN PLUG EXTRACTED FROM CYLINDER HEAD WITH THEIR "SPECIAL TOOL". ENGINE NEEDED TO BE DISSEMBLED AND CYLINDER HEAD REMOVED SO THAT THE BROKEN PIECE COULD BE EXTRACTED. THIS REPAIR COST $1708.00 TO COMPLETE. ALONG WITH $85.00 DIAGNOSTIC FEE TO TELL ME THEY COULD NOT GET THE BROKEN PIECE OUT. THE REPAIR TOOK TWO WEEKS TO HAVE COMPLETED. I FEEL THAT FORD SHOULD ISSUE A RECALL FOR THIS ISSUE AND THEY SHOULD REIMBURSE ME FOR MY COSTS DUE TO THEIR FAULTY DESIGN FLAW. *TR
Engine and engine cooling, Jun 25, 2010
TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE ATTEMPTING TO REPLACE THE SPARK PLUGS IN THE ENGINE, THE CONTACT NOTICED THAT FOUR OF THE SPARK PLUGS WERE WEDGED INTO THE HEAD GASKET AND COULD NOT BE REMOVED. THE VEHICLE WAS NOT DIAGNOSED AND THERE WERE NO PRIOR WARNINGS. THE CURRENT AND FAILURE MILEAGES WAS 46,000. UPDATED 11/08/10 * BF UPDATED 11/10/10*JB
Air bags, Jun 14, 2010
INADVERTENT AIRBAG DEPLOYMENT WHILE STOPPED, NO COLLISION OR INCIDENT ON MY 2006 F-150 TRUCK. *TR
Suspension, Power train, Jun 11, 2010
TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE TRAVELING IN 4-WHEEL DRIVE AT 30-50 MPH THERE WAS AN UNUSUAL CLUNKING NOISE COMING FROM UNDER THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED AND THERE WERE NO PRIOR WARNINGS. THE CURRENT AND FAILURE MILEAGES WERE 54,000. UPDATED 8/2/10 *CN THE CONSUMER STATED THE VEHICLE PULLED SEVERLY TO THE LEFT AND RIGHT. UPDATED 08/09/10*JB
Power train, May 25, 2010
GLAZE ON REAR END CLUTCH CAUSING TRUCK TO DRIVE INCORRECTLY...CONTACTED COMPANY AND THEY HAD A POSSIBLE RESOLUTION THAT DIDN'T WORK....WORRIED THAT THE REAR END WILL LOCK UP WHEN DRIVING CAUSING A WRECK!! *TR
Service brakes, Hydraulic, May 22, 2010
BRAKES FAILED ON PICKUP WHILE DRIVING. REPAIR SHOP DETERMINED MASTER CYLINDER WAS FAULTY. *TR
Engine and engine cooling, Apr 26, 2010
MY 2006 FORD F-150 HAD A SPARK PLUG BROKE OFF AND NOW THE ONLY WAY TO FIX THIS IS TO REMOVE THE HEAD APPROX 3000.00 TO CORRECT. FORD SAYS THEY ARE AWARE OF THE PROBLEM BUT THEY REFUSE TO DO ANYTHING ABOUT IT. THE VEHICLE ONLY HAS 45,000 MILES AND THE TRUCK IS NOW NON DRIVABLE. WHY AREN'T THEY BEING HELD ACCOUNTABLE FOR SOMETHING WHEN THEY KNOW IT IS A PROBLEM WITH THIS STYLE VEHICLE. *TR
Fuel system, Gasoline, Apr 16, 2010
GAS POURS OUT OF THE FILLER NECK AFTER EVERY FILL UP. I DO NOT CLICK EXTRA TO "TOP IT OFF" AND STILL GAS POURS OUT OF THE NECK WHEN I REMOVE THE PUMP FROM THE FILLER NECK. *TR
Visibility, Apr 11, 2010
BOTH DRIVER AND PASSENGER SIDE REVIEW MIRRORS ARE NOT STATIONARY. THEY ARE LOOSE AND PIVOT WHEN CLOSING A DOOR. DRIVER'S SIDE ALSO VIBRATES WHILE DRIVING MAKING IT DIFFICULT TO SEE OUT OF. THIS HAS BEEN REPORTED TO FORD DEALERSHIP WHERE THEY STATED "IT IS JUST A POOR DESIGN WITH A 'BREAK-AWAY FEATURE' THAT APPEARS TO HAVE BEEN 'OVERWORN' BY PREVIOUS OWNER, POSSIBLY DUE TO USE OF THINNER GASKETS IN MIRROR ASSEMBLY". WHEN ASKED ABOUT LONGEVITY AND ANTICIPATED LIFESPAN OF MIRRORS PRIOR TO FAILURE DUE TO WEAR, THEY STATED IT WAS NOT A WEAR-PART, HOWEVER, THEY ALSO DENIED IT BEING DEFECTIVE AND QUOTED ME $1200 FOR PARTS AND LABOR TO REPLACE. WARRANTY WOULD NOT COVER SINCE THE DEFECT WAS MECHANICAL AND NOT ELECTRICAL. THE DEALERSHIP ALSO STATED THE MIRRORS THAT WOULD BE INSTALLED WOULD BE EXACTLY THE SAME AND THERE WAS NO GUARANTEE THIS WOULD NOT HAPPEN AGAIN. I WAS UNABLE TO GET A CORRECTIVE ACTION OR REASONING WHY MY PARTICULAR MIRRORS ARE NOT SATISFACTORY, BUT I HAVE HEARD THIS IS NOT A NEW PROBLEM FOR THIS VEHICLE. LOOKING AT BOTH OF MY MIRRORS, IT IS OBVIOUS THEY SHOULD HAVE SOME SORT OF LOCKING MECHANISM (SNAP-IN-PLACE DESIGN) LIKE MOST VEHICLES. THERE HAS NOT BEEN ANY ACCIDENT INVOLVED WITH THIS SAFETY ISSUE. THIS IS TO DOCUMENT A KNOWN PROBLEM FOR AWARENESS PURPOSES AND TO POTENTIALLY RECEIVE A CORRECTIVE ACTION FOR MY FAULTY MIRRORS. THIS ISSUE HAS BEEN ON-GOING, AND AN ARBITRARY INCIDENT DATE HAS BEEN ASSIGNED. *TR
Fuel system, Gasoline, Power train, Other or unspecified, Mar 31, 2010
SPARK PLUGS FAIL AND ENGINE STOPS. PLUGS CAN'T BE REPLACED;LONG SHAFT SEIZES TO HEAD WALLS. SCHEDULED MAINTENANCE ITEM FOR 100,000 MILES.DANGEROUS DESIGN OF PLUGS FOR ALL FORD F-150 5.4 V-8 ; AS LOSS OF STEERING,BRAKES WITH ENGINE FAILURE.
Power train, Mar 26, 2010
TL* THE CONTACT OWNS A 2006 FORD F-150 EQUIPPED WITH 4 WHEEL DRIVE. THE CONTACT STATED THAT THE REAR DIFFERIENTIAL WAS NOT FUNCTIONING CORRECTLY AND THE REAR WHEELS FELT AS IF THEY WERE SLIDING FROM THE REAR OF THE VEHICLE. ALSO, THE REAR OF THE VEHICLE SEEMED TO HAVE NO TRACTION. HE HAD THE REAR DIFFERENTIAL REPLACED. THE CONTACT'S MAJOR CONCERN WAS THAT ONE COULD LOSE CONTROL OF THE ENTIRE VEHICLE IF THE REAR FUNCTIONED IN THIS MANNER. THE FAILURE MILEAGE WAS APPROXIMATELY 38,000. THE CURRENT MILEAGE WAS APPROXIMATELY 40,000.
Fuel system, Gasoline, Mar 23, 2010
SUBJ: BROKEN GAS TANK AT SEAMS ON MY 2006 FORD F150 TRUCK I HAVE A MAJOR PROBLEM WITH MY 2006 FORD F150 FUEL TANK LEAKING AT THE MANUFACTURES PLASTIC WELDED SEAMS. I BOUGHT MY LAST 3 TRUCKS FROM NORTH COUNTY FORD, IN VISTA, CALIFORNIA. MY 3RD TRUCK WAS A BRAND NEW 2006 FORD F150, AND ALL 3 TRUCKS I BOUGHT FROM NORTH COUNTY FORD, I PAID EXTENDED WARRANTY ON EACH ONE OF THEM, AND THAT WAS OVER $9,000, AND I NEVER USED 1 PENNY OF IT, I NEVER NEEDED ANY WARRANTY OR EXTENDED WARRANTY WORK UNTIL NOW, FOR THE FAULTY LEAKY PLASTIC GAS FUEL TANK UNDER MY TRUCK. I COULD NOT FIGURE OUT WHY MY GAS GAUGE SAID LOW FUEL, WHEN I HAD JUST PUT FUEL IN THE TRUCK THE SAME DAY. WHEN I STARTED MY TRUCK, I SMELLED GAS, SO I GOT OUT OF THE TRUCK, AND COULD SEE IT COMING OUT OF THE FUEL TANK AREA. I WENT TO THE GAS STATION WITH THE LOW FUEL LIGHT ON, BECAUSE I WANTED TO GET HOME BEFORE SOMETHING BAD HAPPENED, AND I PUT MORE FUEL IN THE TRUCK, AND JUST GOING ONLY 15 MILES THE GAS DISAPPEARED AND THE LOW FUEL LIGHT CAME ON AGAIN, BUT I DID GET IT HOME. I JACKED UP THE TRUCK AND STARTED IT, AND CLIMBED UNDERNEATH, AND WAS SURPRISED TO SEE THAT IT WAS A PLASTIC BLACK FUEL TANK, NOT STEEL OR METAL. I WAS JUST LIKE A CHEAP SWIMMING POOL THAT YOU WOULD PUT TWO OF THEM TOGETHER, AND YOU WOULD SEAL IT IN THE MIDDLE TO MAKE A TANK. BUT THE SEAL IS NOW BROKE, AND IM TRYING TO PUT SOME PLASTIC SEAL ON IT, BUT EVERYTHING I READ ON THE INTERNET, TOLD ME FORD WAS ALREADY AWARE OF THIS PROBLEM, BECAUSE I PUT AN AD UP ON CRAIGSLIST UNDER THE AUTOMOTIVE SECTION, ASKING MECHANICS FOR HELP ON WHY THIS WOULD HAPPEN TO SUCH A NEW TRUCK. ITS NOT LIKE I RAN OVER SOMETHING, AS THAT WOULD OF MADE A HOLE IN THE TANK, AND I COULD UNDERSTAND THAT BEING MY FAULT, BUT THE SEAMS COMING APART, AND THE GAS JUST GOING ALL OVER THE GROUND. THIS IS AN EXTREME FIRE HAZARD, AND DONT BE SURPRISED IF THIS THING CATCHES ON FIRE ON ME, HOPEFULLY NOT?
Service brakes, Hydraulic, Air bags, Equipment, Mar 18, 2010, crash
MY SON WAS KILLED IN HIS 2006 FORD 150 PICKUP TRUCK DRIVING 45 MILES AN HOUR. HIS TRUCK APPARENTLY LEFT THE ROAD WITH NO SIGNS OF BRAKES BEING APPLIED, FLIPPED SEVERAL TIMES. THE AIRBAGS NEVER DEPLOYED. HIS INSURANCE COMPANY WAS THREATENING ME TO RELEASE THE TRUCK FROM STORAGE WHICH I DID. I HAVE SINCE REGAINED MY SENSES ENOUGH TO SEARCH THE WEB AND SEE THAT THERE WERE MANY RECALLS ON THE BRAKE LINES OF THIS MAKE TRUCK. *TR
Steering, Mar 8, 2010
LOSS OF POWER STEERING. *TR
Tires, Mar 5, 2010
TL*THE CONTACT OWNS A 2006 FORD F150. THE VEHICLE WAS EQUIPPED WITH CONTINENTAL CONTI TRAC TIRES, AND TIRE SIZE P255-65-R17. THE CONTACT WAS DRIVING APPROXIMATELY 45 MPH. SUDDENLY, THERE WAS A SEVERE VIBRATION. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER. THE TECHNICIAN STATED THE TIRES MET THE TREAD REQUIREMENTS. THE CONTACT OBSERVED AT A LATER DATE THAT ALL FOUR TIRES EXHIBITED EXCESSIVE TREAD SEPARATION. THE MANUFACTURER WAS NOTIFIED AND OFFERED A DISCOUNT PRICE ON A SET OF TIRES. THE TIRES WERE REPLACED. THE FAILURE MILEAGE WAS UNKNOWN. THE DOT NUMBER A3K345MW4605. UPDATED 4/30/10 *CN THE TIRES HAD A VIBRATION FROM BEGINNING. THE CONSUMER STATED THE TREAD SEPARATED AS WELL AS THE BELTS ON TWO TIRES. UPDATED 05/17/10
Vehicle speed control, Mar 4, 2010
WHILE BRAKING THE MOTOR SURGED CAUSING ME TO HAVE TO SWERVE TO AVOID HITTING ANOTHER CAR. EVEN WITH MY FOOT ON THE BRAKE THE TRUCK DID NOT FULLY RESPOND. *TR
Visibility, Mar 2, 2010
INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). POWER WINDOWS FOR THE F-150 NOT WORKING PROPERLY. I HAVE MANY FRIENDS WHO OWN THIS TYPE OF TRUCK AND THEY ARE COMPLAINING OF THE SAME THING. AND THE AVERAGE FIX IT PRICE IS $500. [XXX] *TR
Service brakes, Hydraulic, Feb 26, 2010
WE HAVE A CORRODED ABS BRAKE WIRE ON OUR 2006 FORD F150 TRUCK. THE ABS LIGHT CAME ON AND STAYED ON. WE TOOK IT TO OUR DEALER AND WAS TOLD IT WAS NOT COVERED UNDER OUR EXTENDED WARRANTY DUE TO CORROSION. I CALLED FORD ESP AND WAS TOLD THE SAME THING (DOES NOT STATE THIS IN COVERAGES). WHEN I ASKED ABOUT ANY COVERED PART NOT BEING COVERED IF IT HAS ANY CORROSION ON IT, I WAS TOLD IT DOES NOT COVER CORROSION. I LIVE IN NORTHERN OHIO AND THIS IS IMPOSSIBLE IF THE VEHICLE IS MORE THE A FEW YEARS OLD. WE BELIEVE THAT THIS IS A BRAKE SAFETY ISSUE AND THIS WIRE SHOULD NOT HAVE CORRODED THIS SOON. *TR
Engine and engine cooling, Feb 21, 2010
MY 2006 F-150 WITH THE 4.6L MOTOR EJECTED A SPARK PLUG FROM THE CYLINDER WITHOUT WARNING. I WENT TO CRANK THE VEHICLE ON 2/19/10, AND THERE WAS A HORRENDOUS KNOCKING OR TAPPING SOUND. I WAS ON MY WAY OUT OF TOWN, SO I DID NOT HAVE TIME TO DO A THOROUGH CHECK OF WHAT COULD BE WRONG. I SHUT THE VEHICLE OFF AND LEFT IT SITTING UNTIL I RETURNED ON 2/21/2010. UPON LOOKING, I NOTICED THAT THE SECOND CYLINDER IN FROM THE FIREWALL ON THE PASSENGER SIDE HAD EJECTED THE PLUG FROM THE CYLINDER WELL. WHEN I WENT TO TRY TO PUT THE PLUG BACK IN, IT WOULD NOT TIGHTEN. I JIGGLED THE PLUG AND RATCHET EXTENSION AND NOTICED THAT THE THREADED AREA TO ACCEPT THE PLUG WAS MUCH LARGER THAN THE STOCK PLUG. I UNDERSTAND THAT FORD HAS USED MANY EXCUSES AS TO WHY THIS HAPPENS, BUT I ASSURE YOU THAT I HAVE PURCHASED NO NEW PARTS. THIS VEHICLE IS NOW UNUSABLE, AND IS MY PRIMARY TRANSPORTATION TO AND FROM WORK. THERE IS OBVIOUSLY AN ISSUE WITH THESE MOTORS AND EJECTING PLUGS, SO MY QUESTION IS WHY HAS FORD NOT STEPPED UP TO ADDRESS THIS ISSUE? *TR
Service brakes, Hydraulic, Feb 18, 2010
TL*THE CONTACT HAS A 2006 FORD F-150. THE CONTACT STATED THAT IF THE VEHICLE DROVE 10 MPH OVER A BUMPY ROAD OR A POTHOLE THE BRAKES DID NOT ENGAGE FOR ABOUT 2 OR THREE SECONDS. ON EVEN SURFACES THE BRAKES PERFORMED NORMALLY. THE FAILURE MILEAGE WAS 31,000. THE CURRENT MILEAGE WAS 36,080.
Service brakes, Hydraulic, Feb 18, 2010
TL*THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHENEVER THE VEHICLE WAS DRIVEN APPROXIMATELY 15 MPH OVER A BUMP THE BRAKES FAILED TO ENGAGE. THE FAILURE MILEAGE WAS 31000. THE CURRENT MILEAGE WAS 36080.
Engine and engine cooling, Power train, Feb 17, 2010
I PURCHASED A FORD F-150 IN 2006. I AM AT MY 100,000 MAINTENANCE AND THE SPARK PLUGS HAVE TO BE CHANGED. I SPOKE WITH A REPRESENTATIVE AT THE FORD REPAIR SHOP WHO TOLD ME THAT I WOULD HAVE TO BRING MY TRUCK IN 24 HOURS EARLY TO SOAK THE PLUGS BECAUSE THEY WILL BREAK IN THE MOTOR AND I WILL HAVE TO PAY TO HAVE THEM REMOVED. I FOLLOWED THERE INSTRUCTIONS ON MONDAY MORNING AND TOOK THE TRUCK TO THEM. THEY CALLED AND INFORMED ME THAT THEY WOULD HAVE TO TAKE THE HEAD OFF MY MOTOR TO REMOVE THE PLUGS AT A CONSIDERABLE EXPENSE TO ME. IT DOES NOT SEEM FAIR TO ME THAT IF FORD MECHANICS PUT FORD PLUGS INTO THERE FORD TRUCKS AND WHEN THERE FORD MECHANICS TRY TO REMOVE THE FORD PLUGS FROM THE FORD VEHICLE THEY BREAK AND I HAVE TO PAY FOR THE DAMAGES. *TR
Power train, Feb 11, 2010
WHILE DRIVING MY 2006 FORD F150, THE GEAR SHIFT CABLE MELTED DUE TO CONTACT WITH THE MANIFOLD. THIS CAUSE THE TRUCK TO STOP. I COULD NOT START THE TRUCK AGAIN. THIS HAPPENED WHEN I BACKED OUT OF MY DRIVEWAY. THE TRUCK WAS TAKEN TO THE FORD DEALER BY FLATBED. *TR
Other or unspecified, Feb 8, 2010
BLACK PAINT, CHIPPING FROM UNDER THE GAS DOOR.
Engine and engine cooling, Feb 5, 2010
I'M AN OWNER OF A 2006 FORD F-150 5.4 ENGINE. I HAVE HAD 3 ENGINE FAILURES WITH THIS TRUCK THE FIRST ONE WAS AN INJECTOR. SECOND WAS A TIMING SOLENOID. THIRD WAS A COIL. I HAD OVER 100,000 KMS. I HAD MY PLUGS CHANGED. THE MECHANIC ENDED UP BREAKING OFF 6 PLUGS IN THE ENGINE. THIS IS A VERY EXPENSIVE REPAIR, IT SHOULD ONLY BE REGULAR MAINTENANCE. I HAVE DONE A GREAT DEAL OF RESEARCH AND HAVE FOUND IT IS A VERY WIDESPREAD PROBLEM. I FEEL OWNERS SHOULD BE COMPENSATED. ANY ADVICE I CAN RECEIVE WOULD BE HELPFUL THANKS IN ADVANCE. *TR