2006 Ford F-150
Problems, recalls and owner-reported issues
Service brakes is the leading concern among 589 owner complaints filed for this model year. This is the 6th highest complaint count among 26 F-150 model years with reports.
Of the 2006 reports, 58 involved a crash and 18 involved a fire. 42 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Air bags, frontal, driver side, inflator moduleFeb 23, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2004-2006 F-150 PICK UP TRUCKS AS WELL AS CERTAIN MODEL YEAR 2006 LINCOLN MARK LT VEHICLES. IF THE CLOCKSPRING JUMPER WIRE COMES IN CONTACT WITH THE DRIVER SIDE FRONTAL AIR BAG LOWER HORN PLATE, THE WIRE INSULATION MAY BECOME CHAFED, CREATING A POTENTIAL FOR A SHORT CIRCUIT. IF THIS OCCURS THE AIR BAG WARNING LAMP MAY ILLUMINATE INDICATING THAT SERVICE IS REQUIRED.
THE DRIVER SIDE FRONTAL AIR BAG COULD INADVERTENTLY DEPLOY INCREASING THE RISK OF INJURY OR LOSS OF VEHICLE CONTROL IF OCCURRING WHILE IN MOTION.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN/MERCURY DEALER TO HAVE A NEW CLOCKSPRING JUMPER WIRE INSTALLED THAT INCORPORATES A PROTECTIVE MESH COVER. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THIS SAFETY RECALL BEGAN ON SOME VEHICLES IN MARCH 2011. THE RECALL CAMPAIGN ON THE EXPANDED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT MAY 9, 2011. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Campaign 11V107000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Service brakes, hydraulic, power assist, vacuum, hoses, lines/piping, and fittingsMay 7, 2008
FORD IS RECALLING 605,684 MY 2005-2006 F-150 AND LINCOLN MARK LT VEHICLES EQUIPPED WITH 5.4L 3-VALVE ENGINES. THE BRAKE BOOSTER VACUUM SUPPLY HOSE ATTACHED TO THE INTAKE MANIFOLD FITTING MAY SWELL OVER TIME AND LOSE RETENTION FORCE. THIS CONDITION COULD ALLOW THE HOSE TO BECOME DETACHED FROM THE FITTING DURING AN INTAKE MANIFOLD BACKFIRE. SHOULD THE HOSE DETACH FROM THE INTAKE MANIFOLD, SEVERAL BRAKE APPLICATIONS WITH POWER ASSIST WILL BE AVAILABLE BEFORE THE VACUUM RESERVE IS DEPLETED.
ONCE THE BRAKE BOOSTER VACUUM RESERVE IS DEPLETED, THE DRIVER WILL HAVE FOUNDATION BRAKE FUNCTION, BUT WITH INCREASED BRAKE PEDAL EFFORT. REDUCED VEHICLE BRAKING COULD LEAD TO A CRASH.
DEALERS WILL REPLACE A RUBBER HOSE ON THE BRAKE BOOSTER VACUUM SUPPLY TUBE ASSEMBLY. THE RECALL BEGAN ON JUNE 27, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 08V208000 on NHTSA.gov
Exterior lighting, headlightsOct 25, 2007
CERTAIN SPYDER HEADLAMP REPLACEMENT ASSEMBLIES SOLD FOR USE ON 2004 THROUGH 2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SPYDER WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2007. OWNERS CAN CONTACT SPYDER AT 866-558-4264.
Campaign 07E089000 on NHTSA.gov
Exterior lighting, headlightsSep 25, 2007
CERTAIN HEADLAMP ASSEMBLIES IMPORTED AND SOLD AS AFTERMARKET EQUIPMENT BY SONAR AUTO PARTS FOR USE ON 2004-2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SONAR WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS CAN CONTACT SONAR AT 866-558-4264.
Campaign 07E080000 on NHTSA.gov
Exterior lighting, headlightsSep 14, 2007
CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. FR390-B001L AND FR390-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE THICKNESS IS UNSTABLE INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
EAGLE EYES WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON NOVEMBER 6, 2007. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.
Campaign 07E075000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Interior lightingFeb 6, 2006
CERTAIN PICKUP TRUCKS FAIL TO COMPLY WITH EITHER THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 105, 'HYDRAULIC AND ELECTRIC BRAKE SYSTEMS' OR FMVSS NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' THESE VEHICLES WERE BUILT WITH A SOFTWARE ERROR IN THE INSTRUMENT CLUSTER.
THIS ERROR COULD PREVENT THE ANTILOCK BRAKE SYSTEM (ABS) WARNING LIGHT FROM ILLUMINATING IF THE ABS MODULE EVER BECAME INOPERATIVE.
DEALERS WILL RECALIBRATE THE INSTRUMENT CLUSTER IN THESE VEHICLES. THE RECALL BEGAN ON FEBRUARY 27, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 06V033000 on NHTSA.gov
Tires, tread/beltNov 21, 2005
CERTAIN CONTINENTAL CONTITRAC TR OWL, CONTITRAC TR BSW, GENERAL GRABBER TR BSW, AND CONTITRAC BSW TIRES MANUFACTURED BETWEEN MAY 29 AND JUNE 11, 2005, AND SOLD AS ORIGINAL EQUIPMENT ON CERTAIN FORD TRUCKS AND SOLD AS REPLACEMENT TIRES. THESE TIRES CAN WEAR PREMATURELY WHICH FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 119, NEW PNEUMATIC TIRES FOR VEHICLES OTHER THAN PASSENGER CARS.
AFFECTED TIRES MAY NOT MEET THE ENDURANCE TEST REQUIREMENTS OF THE STANDARD. CONTINUED USE OF THE AFFECTED TIRES CAN RESULT IN TIRE FAILURE WHICH COULD LEAD TO VEHICLE DAMAGE OR MOTOR VEHICLE CRASH.
CONTINENTAL WILL NOTIFY OWNERS AND REPLACE THE TIRES FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 7, 2005. OWNERS MAY CONTACT CONTINENTAL AT 704-588-5895.
Campaign 05T022000 on NHTSA.gov
Visibility, windshield wiper/washer, motorNov 9, 2005
ON CERTAIN TRUCKS, PASSENGER CARS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MOTOR MAY HAVE BEEN PRODUCED WITHOUT GREASE BEING APPLIED TO THE OUTPUT SHAFT GEAR.
AFTER A PERIOD OF CONTINUOUS USE ON THE HIGH SPEED SETTING, LACK OF GREASE ON THE OUTPUT SHAFT GEAR MAY CAUSE THE GEAR TO DISTORT OR FRACTURE DURING OPERATION RESULTING IN A LOSS OF WIPER FUNCTION. INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.
DEALERS WILL INSPECT THE WIPER MOTOR FOR THE PRESENCE OF GREASE AND GREASE THE WIPER MOTOR GEARS IF NECESSARY. THE RECALL BEGAN ON NOVEMBER 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673 OR LINCOLN/MERCURY AT 1-800-521-4140.
Campaign 05V520000 on NHTSA.gov
Representative owner complaints
589 reports, newest first.
Visibility, May 24, 2007
DRIVER''S SIDE EXTERIOR MIRROR VIBRATES WHEN GOING DOWN THE ROAD. THIS DISTRACTS THE DRIVER''S VISION AND COULD CAUSE AN ACCIDENT. IT GIVES YOU THE FALSE IMPRESSION THAT THERE IS A VEHICLE MOVING INTO YOUR BLIND SPOT. THIS HAS BEEN REPORTED TO THE DEALER THREE TIMES AND HAS NOT BEEN CORRECTED TO DATE.
Exterior lighting, Interior lighting, May 23, 2007
WAS TRAVELING BACK FROM DECLO IDAHO FROM MY FATHERS PASSING AWAY ,HEADED FOR BOISE IDAHO AT 11:00 PM, JUST PASSED JEROME ABOUT TWO MILES WEST THE HEADLIGHTS AND ALL OTHER LIGHTS, INTERIOR AND EXTERIOR WENT OUT AT 75 MPH ON THE FREEWAY , IN THE VEHICLE I HAD MY SON 8 YEARS OLD , MY WIFE 40 YEARS OLD , MY MOTHER 65 YEARS OLD, AND MYSELF 44 YEARS OLD WE COULD HAVE BEEN KILLED BY A MERGING OR PASSING SEMI, BUT I QUICKLY SWITCHED THE HEADLIGHT SWITCH FROM AUTO TO HEADLAMP AND THE LIGHTS CAME BACK ON, SO I SWITCHED BACK TO AUTO AND WE TRAVELED 8 MILES AND THE LIGHTS WENT OUT AGAIN , SO ,I REPEATED THE SAME THING AGAIN BY TURNING THE SWITCH BACK TO HEADLAMP, AND THE LIGHTS ONCE AGAIN CAME BACK ON. THEN, I SWITCHED IT BACK TO AUTO AGAIN AND THEY STAYED ON FOR ABOUT 8 TO 10 MILES AND WENT OUT AGAIN . I SWITCHED THEM BACK AND LEFT THE SWITCH ON HEADLAMP AND CONTINUED OUR TRIP HOME FROM DECLO NO MORE PROBLEMS WITH SWITCH ON HEADLAMP MOD. ALSO, I HAD FOG LAMPS ON THIS ENTIRE TIME WHICH ENTAILED PULLING THE HEADLIGHT SWITCH OUT TO ENGAGE THE FOG LAMPS. THEN A WHILE LATER LIKE A WEEK I WENT TO WORK AT THE AIRPORT AT NIGHT GRAVES . I GOT TO WORK SHUT DOWN THE VEHICLE AND PUT THE KEYS ON THE FLOOR AS PER PAD TO OPEN VEHICLE, LOCKED VEHICLE BY PAD AND ENTERED THE BUILDING, ABOUT AN HOUR OR SO LATER RECEIVED A CALL FROM HORIZON EMPLOYEE THAT THERE WAS A VEHICLE WITH ITS LIGHTS ON IN THE PARKING LOT WHICH WAS MY VEHICLE. I RETURNED TO THE VEHICLE AND TURNED THE HEADLAMP SWITCH FROM AUTO TO HEADLAMP AND THE LIGHTS WENT OUT WHEN I LOCKED THE VEHICLE THIS TIME , AND THE SAME SCENARIO HAPPENED A COUPLE MORE TIMES . I RETURNED WITH THE VEHICLE TO LITHIA FORD OF BOISE, AND THEY HELD THE VEHICLE OVER NIGHT AND COULD NOT DUPLICATE THE PROBLEM , THEY HAVE DONE THIS A COUPLE TIMES ,AND DAMAGED THE DASHBOARD. *AK
Electrical system, May 9, 2007
TL*THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING AT VARIOUS SPEEDS, THE CONTACT HEARS A THUMPING NOISE. THE DEALER STATED THAT THE SOLENOID NEEDS TO BE REPLACED. THE CURRENT AND FAILURE MILEAGES WERE 43,000.
Service brakes, Hydraulic, Engine and engine cooling, May 8, 2007
TL*THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING APPROXIMATELY 60 MPH, THE CONTACT'S FOOT BECAME STUCK TO THE ACCELERATOR PEDAL WHEN HE ATTEMPTED TO APPLY THE BRAKE. THE VEHICLE FAILS TO BRAKE PROPERLY UNLESS THE PEDAL IS TOUCHING THE FLOOR. THE DEALER WAS UNABLE TO DETERMINE THE CAUSE OF FAILURE. WHEN TURNING THE STEERING WHEEL, THE CONTACT HEARS A SQUEALING NOISE AND IT BECOMES DIFFICULT TO MANEUVER. THE DEALER REPLACED THE POWER STEERING PUMP, BUT THE SQUEALING NOISE IS STILL AUDIBLE. THE CURRENT MILEAGE IS 37,000 AND FAILURE MILEAGE WAS 9,346. THE CONSUMER STATED THE BRAKE AND GAS PEDAL WERE DESIGNED TOO CLOSE TOGETHER. THE CONSUMER HAS MISTAKENLY HIT THE GAS PEDAL WHEN TRYING TO BRAKE. THE MASTER CYLINDER HAD AN INTERNAL LEAK. THE MUFFLER HAD A LEAK. UPDATED 06/06/07. *JB
Power train, Apr 21, 2007
2006 FORD F-140 TRITION 5.4 LITER FLEX FUEL V-8 ENGINE AND 4 SPEED AUTOMATIC TRANSMISSION HESITATES WHEN ACCELERATING FROM STOP SIGNS OR LIGHTS AND WHEN MERGING WITH HIGHWAY / INTERSTATE TRAFFIC. *TR
Engine and engine cooling, Fuel system, Other, Apr 20, 2007
TL*THE CONTACT OWNS A 2006 FORD F-150. THE ENGINE LIGHT ILLUMINATED AND THE VEHICLE BEGAN TO VIBRATE WHILE IN TRAFFIC. THE VEHICLE WAS TOWED TO DEALER, AMERICAN FORD. THE DEALER REPLACED THE # 6 FUEL INJECTOR. AT 9,670 MILES, THE SAME FAILURE RECURRED, AND THE DEALER REPLACED THE # 5 FUEL INJECTOR. AT 9,735 MILES, THE ENGINE LIGHT ILLUMINATED AGAIN. THE DEALER STATED THAT THE CATALYTIC CONVERTER FAILED BECAUSE OF THE FUEL. THE CURRENT MILEAGE IS 10,765, AND FAILURE MILEAGE WAS 7,462.*AK
Engine and engine cooling, Fuel system, Gasoline, Apr 20, 2007
TWO SEPARATE OCCASIONS I EXPERIENCED A FUEL INJECTOR FAILURE ON MY '06 F-150 WHILE TRAVELING ON I-65 ON 10-10-06 AND ON I-10 ON 10-14-06. I WAS TOLD BY A DEALER IN CULMAN ALABAMA THAT I COULD DRIVE IT ON TO MEMPHIS WITH THE ENGINE LIGHT ON. UPON ARRIVAL IN MEMPHIS DOBBS FORD TOLD ME THERE WAS NOTHING WRONG AND I HAD TO TAKE HIS WORD. ON MY TRIP BACK TO TAMPA THE ENGINE LIGHT CAME ON AGAIN AND I HAD TO TOWED TO AMERICAN FORD IN TALLAHASSEE. THE REPLACED #6 FUEL INJECTOR. LATER, WHILE IN MEMPHIS #5 INJECTOR FAILED AND WAS REPLACED AT LANDERS FORD IN COLLIERVILLE. A FEW DAYS LATER THE ENGINE LIGHT CAME ON AGAIN AND THIS TIME IT WAS THE CATALYTIC CONVERTER, WHICH HAD TO BE REPLACED. *JB
Service brakes, Hydraulic, Apr 18, 2007
2006 FORD F-150 PICKUP CUSTOMER STATES THAT WHEN BRAKE IS APPLIED HIS FOOT ALSO HITS THE GAS CAUSING THE ENGINE TO RACE**NAR**CC UPDATE *TR
Electrical system, Apr 9, 2007
TL*THE CONTACT OWNS A 2006 FORD F-150. THE VEHICLE WAS PURCHASED WITH ONLY 30 MILES. THE CONTACT ASKED THE DEALER PRIOR TO PURCHASING THE VEHICLE IF THERE WERE ANY RELATED RECALLS AND WAS ADVISED THAT THERE WERE NONE. THE CONTACT RECEIVED RECALL NOTICE 06C11 ON APRIL 7, 2007 STATING THAT THE INSTRUMENT CLUSTER CALIBRATION HAD NOT BEEN REPAIRED. THE MANAGER CONFIRMED THAT THEY WERE AWARE OF THE RECALL NOTICE FIVE MONTHS PRIOR TO THE PURCHASE. HOWEVER, WAS NOT ADVISED TO SCHEDULE AN APPOINTMENT FOR THE REPAIRS. ALSO, THE DEALER STATED THAT THE MODULE BEHIND THE DASH WAS FAULTY. THE CONTACT STATED THAT CRUISE CONTROL WAS NEAR THE RELATED RECALL COMPONENT AND COULD CATCH ON FIRE. ON TWO PRIOR OCCASIONS DURING AN OIL CHANGE THE DEALER INDICATED THE INCORRECT MILEAGE. THIS COULD POTENTIALLY AFFECT THE VEHICLE'S WARRANTY, AND INDICATE THAT THE CONTACT HAS EXCEEDED THE ALLOTTED MILEAGE FOR THE NEXT OIL CHANGE. THE CURRENT AND FAILURE MILEAGE WERE 10,500.*AK
Service brakes, Hydraulic, Apr 4, 2007
I CURRENTLY DRIVE A 2006 FORD F-150 WHICH I LEASED NEW IN MARCH OF 2006. SINCE DAY ONE I HAVE COMPLAINED ABOUT THE BRAKES ON THE TRUCK. THE BRAKE PEDAL GOES BELOW THE GAS PEDAL WHEN THE BRAKES ARE APPLIED. MY WIFE CANNOT DRIVE THE TRUCK BECAUSE SHE CONSTANTLY HIT THE BRAKE AND GAS AT THE SAME TIME. I HAVE CHECKED WITH OTHER OWNERS AND THEY HAVE THE SAME PROBLEM. I HAVE ALSO COMPLAINED TO THE DEALERSHIP AND THEY TELL ME THAT THIS IS NORMAL WITH THE NEW FORD TRUCKS. COMPLAINTS TO FORD DIRECT HAVE RESULTED IN NO RESPONSE. I ALSO HAVE THE PROBLEM OF HITTING THE BRAKE AND GAS AT THE SAME TIME UNLESS I PUMP THE BRAKES FIRST, IN A PANIC SITUATION THERE IS NOT TIME TO PUMP THE BRAKES. THIS PROBLEM IS AN ACCIDENT WAITING TO HAPPEN. *AK
Structure, Mar 19, 2007
TL* THE CONTACT WAS A PASSENGER IN A 2006 FORD F-150 EXTENDED CAB. THE CONTACT TRIED TO OPEN THE REAR PASSENGER DOOR AND HER HAND WAS CAUGHT IN AN AREA OF THE DOOR THAT BROKE HER RIGHT INDEX FINGER. FOUR STITCHES WERE REQUIRED DUE TO THE INJURY. THAT AREA OF THE DOOR COULD POTENTIALLY CUT OFF A CHILD'S FINGER. THE DOOR SHOULD HAVE A COVER, ANDWAS CURRENTLY A SAFETY RISK. THE PASSENGER DIDN'T HAVE THE SPECIFICS REGARDING THE VEHICLE. *AK
Service brakes, Hydraulic, Feb 27, 2007
TL* - THE CONTACT OWNS A 2006 F150 FORD. THE CONTACT STATED THAT WHEN BACKING UP, AND APPLYING THE BRAKES IT WAS EASY TO PRESS THE GAS PEDAL AT THE SAME TIME. THIS HAPPENED THREE TIMES. ON ONE OCCASION HE WAS BACKING UP IN THE DRIVEWAY WHEN HE BUMPED THE GARAGE AND DID SOME DAMAGE TO THE GARAGE. THE CONTACT STATED THAT THE VEHICLE ONLY HAD 5600 MILES ON IT. THIS ONLY HAPPENED WHILE IN REVERSE. THIS OCCURRED WHEN THE CONTACT WAS WEARING WORK BOOTS. THE ACCELERATOR PEDAL AND THE BRAKE PEDAL ARE TOO CLOSE TOGETHER. *AK UPDATED 03/19/07. *JB
Service brakes, Hydraulic, Feb 11, 2007, crash
WHILE PULLING INTO A PARKING SPOT AT A LOCAL GAS STATION(5 - 8 MPH), I APPLIED THE BRAKE TO STOP AND IT WENT ALL THE WAY TO THE FLOOR. THE TRUCK JUMPED THE SIDEWALK AND CRASHED INTO THE BUILDING. AFTER PICKING THE TRUCK UP THE NEXT DAY, THE BRAKES WORKED FINE AND EVERYBODY THINKS I'M NUTS! CURRENTLY HAVING TRUCK ACCESSED BY DIFFERENT SOURCES. *JB
Structure, Jan 18, 2007
I HAVE HAD MY TRUCK SERVICED BY THE DEALERSHIP THREE TIMES SINCE I PURCHASED IT IN JULY 2006. THE BED VIBRATES EXCESSIVELY WHEN TRAVELING ABOVE 45 MPH, ALMOST AS IF IT IS LOOSE. THERE IS ALSO A NOTICEABLE GROANING FROM THE REAR WHEN THE TRUCK GOES IN AND OUT OF GEAR. THE SERVICE MANAGER VERIFIED THE PROBLEM BUT DOES NOT KNOW HOW TO FIX IT. *NM
Vehicle speed control, Jan 16, 2007, fire
TL* - ON DECEMBER 20, 2006, THE CONTACT RECEIVED A CALL FROM THE POLICE DEPARTMENT STATING HIS 1995 FORD F150 AND THE CAR PORT WERE ON FIRE AT HIS RESIDENCE. THE VEHICLE CAUGHT FIRE UNDER THE HOOD. THE CONTACT STATED THAT THE VEHICLE HAD BEEN PARKED FOR TWO MONTHS. A WITNESS STATED THAT THE VEHICLE SOUNDED AS IF IT WERE TRYING TO START ON ITS OWN. THE WITNESS LOOKED INTO THE VEHICLE AND CONFIRMED THAT NO ONE WAS IN IT AND CALLED 911. THERE WERE NO INJURIES. THE VEHICLE WAS DESTROYED. THERE WERE NO RECENT REPAIRS TO THE VEHICLE. THE VEHICLE HAD APPROXIMATELY 210,000 MILES ON IT. THE FIRE DEPARTMENT STATED THE CAUSE OF THE FIRE TO BE A FAULTY SPEED CONTROL DEACTIVATION SWITCH. THE CONTACT HAS PICTURES, A FIRE DEPARTMENT REPORT AND THE VEHICLE STORED. *NM UPDATED 03/19/07. *JB
Suspension, Tires, Jan 4, 2007
MY NEW F150 HAS A TERRIBLE SHUDDER IN THE STEERING WHEEL FOR THE FIRST 10 MILES AFTER THE CAR IS STARTED. IF IT IS COLD OUT, IT IS VERY DIFFICULT TO CONTROL THE VEHICLE ABOVE 50 MPH. FORD HAS REPLACED THE TIRES, BUT THEY REPLACED THEM WITH THE SAME PIRELLIS AND IT DID NOT HELP. *JB
Vehicle speed control, Jan 3, 2007
TL* - THE CONTACT STATED THAT WHILE THE 2006 FORD F-150WAS IN PARK HADTO DEPRESS THE BRAKE PEDAL TO SWITCH THE TRANSMISSION TO A DRIVE GEAR. ONCE HE HAD THE VEHICLE IN GEAR WITHOUT FOOT ON THE ACCELERATION PEDAL THE VEHICLE WILL ACCELERATE UNEXPECTEDLY. THE CONTACT STATED THAT THE VEHICLE WILL ACCELERATE FOR A FEW SECONDS AND THEN RELEASE ITSELF. IT ACCELERATED WHEN VEHICLE WAS IN DRIVE OR REVERSE GEAR. ONE TIME WHEN THE CONTACT WAS ON THE HIGHWAY IN CRUISE CONTROL AT 70 MPH ON AN EXIT RAMP, WHEN HE PRESSED THE BRAKE PEDAL TO RELEASE THE CRUISE CONTROL AND SUDDENLY THE VEHICLE ACCELERATED FOR ABOUT 3 SECONDS. CONTACT TOOK THE VEHICLE TO THE DEALERSHIP ON 11/01/06 AND THEY PUT A BOX THAT CONTACT STATED WORKED LIKE A BLACK BOX ON THE PLANE TO DIAGNOSE VEHICLE FAILURE. THE CONTACT HAD THE BOX ON FOR 6 WEEKS AND THE DEALERSHIP WASN'T ABLE TO DIAGNOSE THE FAILURE. *AK UPDATED 1/30/2007 - *NM
Tires, Jan 2, 2007
HAD A GENERAL AMERI-TECH GO FLAT (613 MILES ON IT) COULD FIND NO HOLES OR LEAK EXCEPT FROM TIRE/RIM SEAL. FORD DEALER CLAIMED IT HAD A NAIL HOLE IN SIDE WALL AND I HAD TO PAY FOR A NEW TIRE MYSELF. AGAIN I ATTEMPTED TO AIR TIRE BACK UP BUT IT WAS LEAKING FROM TIRE AT RIM. *JB
Exterior lighting, Dec 26, 2006
ALL FORD LIGHT TRUCKS, SUVS, AND CARS MANUFACTURED SINCE 1987 ALL THE WAY UNTIL 2006 NEED TO HAVE THE HEADLIGHTS ADJUSTED. I HAVE BEEN DRIVING FOR 24 YEARS AND I HAVE SEEN THESE VEHICLES SWITCH FROM HIGH TO LOW BEAMS AND THE LIGHTS ARE STILL TOO BRIGHT. THIS IS DANGEROUS BECAUSE IT BLINDS INCOMING TRAFFIC DRIVERS. THIS IS ALSO TRUE WHEN FORD PRODUCTS ARE DRIVEN BEHIND OTHER VEHICLE. THIS IS FAR TOO DANGEROUS AND THE PROBLEM NEEDS TO BE INVESTIGATED. *NM
Service brakes, Hydraulic, Dec 19, 2006, crash
TL* - THE CONTACT WAS DRIVING AT 8 - 10 MILES PER HOUR, AND APPLIED THE BRAKES. THE CAR ACCELERATED AND CRASHED INTO A WALL AND WAS BADLY DMAGED ON THE PASSENGER SIDE. THE CONTACT STATES THAT THIS HAS HAPPENED BEFORE. WE WILL BE CONTACTING THE CALLER FOR MORE INFORMATION.
Steering, Dec 11, 2006
DT*: THE CONTACT STATED WHILE DRIVING 50 MPH, THE VEHICLE SHOOK VIOLENTLY, AND PULLED TO BOTH THE LEFT AND RIGHT. EXCESSIVE FORCE WAS REQUIRED TO KEEP THE VEHICLE MOVING STRAIGHT. THE VEHICLE WAS TAKEN TO A SERVICE DEALER ON 3 DIFFERENT OCCASIONS, WHERE THE DEALER WAS UNABLE TO DETERMINE THE PROBLEM.
Wheels, Dec 4, 2006
DURING ADVERSE WEATHER CONDITIONS (WINTER ICE AND SNOW, COLD TEMPS) MY WHEELS HAD ICE FREEZE IN THEM CREATING AN IMPOSSIBLE STEERING SITUATION. THE DESIGN OF THESE WHEELS ALLOWS THEM TO HOLD ABOUT AN INCH OF WATER ABOUT 3 INCHES IN LENGTH, WHEN THIS FREEZES THE RESULT IS AN OUT OF BALANCE WHEEL, ( IN THIS CASE 4 OUT OF BALANCE WHEELS) MAKING THEM WOBBLE (VIBRATE) UNCONTROLLABLY ON ICY ROADS. THIS CAUSED ME TO EXPERIENCE A TERRIFYING DRIVE FOR THE 17 MILES TO TOWN. I BELIEVE THIS COULD CAUSE AN ACCIDENT WITH A LESS EXPERIENCED DRIVER. *JB
Visibility, Equipment, Nov 29, 2006
MY 2006 FORD F-150 SUPER CAB PICKUP, 2X4, V-8 ENGINE, HAS A MAJOR PROBLEM WITH THE OUTSIDE MIRRORS FALLING TOWARDS THE GROUND CAUSING ME NOT TO BE ABLE TO PICK UP MOVING TRAFFIC WHILE DRIVING DOWN THE HIGHWAY...I HAVE TAKEN THE TRUCK TO THREE DIFFERENT FORD DEALERSHIPS AND THEY REFUSE TO GIVE ME A TRADE-IN ON A TRUCK WITH POWER MIRRORS...I HAVE HAD (3) NEW SETS OF MIRRORS INSTALLED ON THIS TRUCK ALREADY SINCE I PURCHASED THE TRUCK IN JANUARY 2006....I HAVE HAD A RESTRICTION PUT ON MY DRIVERS LICENSE STATING THAT I MUST HAVE A RIGHT HAND MIRROR ON ALL VEHICLES I DRIVE DUE TO HAVING AMBLYOPIA IN MY RIGHT EYE....CAN'T SEE ANYTHING WHEN MY MIRRORS POINT DOWN TOWARDS THE GROUND...SHOULDN'T' HAVE TO TAKE A BEATING ON THE TRADE-IN SINCE I BOUGHT THE TRUCK IN GOOD FAITH BELIEVING THAT FORD WOULD STAND BEHIND ITS WARRANTY...THEY ARE NOT REIMBURSING ME FOR THE TIME OR GAS TO TAKE THE TRUCK IN FOR REPAIRS AND I BELIEVE THREE SETS OF MIRRORS ARE ENOUGH....I WANT THIS TO BE DOCUMENTED IN CASE THAT I HAVE A MINOR OR MAJOR ACCIDENT THAT IS INVOLVING A LIFE BECAUSE I COULDN'T SEE OUT OF MY MIRROR WHILE CHANGING A LANE..... *NM
Service brakes, Hydraulic, Vehicle speed control, Nov 7, 2006, crash
I WAS INVOLVED IN AN ACCIDENT WHICH WAS CAUSED BY HITTING THE BRAKE PEDAL AND THE ACCELERATOR AT THE SAME TIME. I THOUGHT I WAS HITTING THE BRAKE WHEN AND HIT THE GAS AT THE SAME TIME CAUSING MY VEHICLE TO REAR END COLLIDE WITH THE VEHICLE IN FRONT OF ME. SINCE I HAVE BEEN DRIVING THE VEHICLE THIS HAS HAPPENED SEVERAL TIMES, THE GAS PEDAL IS TOO CLOSE IN HEIGHT TO THE BRAKE PEDAL. *NM
Suspension, Oct 26, 2006
DT*: THE CONTACT STATED AT VARIOUS SPEEDS, THERE WAS A WHINING NOISE UNDER THE DRIVER SIDE FLOOR BOARD. THE NOISE SOUNDED AS THOUGH IT WAS COMING FROM THE SUSPENSION. THE DEALERSHIP WAS UNABLE TO DETERMINE THE PROBLEM.