2006 Ford F-150
Problems, recalls and owner-reported issues
Service brakes is the leading concern among 589 owner complaints filed for this model year. This is the 6th highest complaint count among 26 F-150 model years with reports.
Of the 2006 reports, 58 involved a crash and 18 involved a fire. 42 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Air bags, frontal, driver side, inflator moduleFeb 23, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2004-2006 F-150 PICK UP TRUCKS AS WELL AS CERTAIN MODEL YEAR 2006 LINCOLN MARK LT VEHICLES. IF THE CLOCKSPRING JUMPER WIRE COMES IN CONTACT WITH THE DRIVER SIDE FRONTAL AIR BAG LOWER HORN PLATE, THE WIRE INSULATION MAY BECOME CHAFED, CREATING A POTENTIAL FOR A SHORT CIRCUIT. IF THIS OCCURS THE AIR BAG WARNING LAMP MAY ILLUMINATE INDICATING THAT SERVICE IS REQUIRED.
THE DRIVER SIDE FRONTAL AIR BAG COULD INADVERTENTLY DEPLOY INCREASING THE RISK OF INJURY OR LOSS OF VEHICLE CONTROL IF OCCURRING WHILE IN MOTION.
FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN/MERCURY DEALER TO HAVE A NEW CLOCKSPRING JUMPER WIRE INSTALLED THAT INCORPORATES A PROTECTIVE MESH COVER. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THIS SAFETY RECALL BEGAN ON SOME VEHICLES IN MARCH 2011. THE RECALL CAMPAIGN ON THE EXPANDED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT MAY 9, 2011. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Campaign 11V107000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Service brakes, hydraulic, power assist, vacuum, hoses, lines/piping, and fittingsMay 7, 2008
FORD IS RECALLING 605,684 MY 2005-2006 F-150 AND LINCOLN MARK LT VEHICLES EQUIPPED WITH 5.4L 3-VALVE ENGINES. THE BRAKE BOOSTER VACUUM SUPPLY HOSE ATTACHED TO THE INTAKE MANIFOLD FITTING MAY SWELL OVER TIME AND LOSE RETENTION FORCE. THIS CONDITION COULD ALLOW THE HOSE TO BECOME DETACHED FROM THE FITTING DURING AN INTAKE MANIFOLD BACKFIRE. SHOULD THE HOSE DETACH FROM THE INTAKE MANIFOLD, SEVERAL BRAKE APPLICATIONS WITH POWER ASSIST WILL BE AVAILABLE BEFORE THE VACUUM RESERVE IS DEPLETED.
ONCE THE BRAKE BOOSTER VACUUM RESERVE IS DEPLETED, THE DRIVER WILL HAVE FOUNDATION BRAKE FUNCTION, BUT WITH INCREASED BRAKE PEDAL EFFORT. REDUCED VEHICLE BRAKING COULD LEAD TO A CRASH.
DEALERS WILL REPLACE A RUBBER HOSE ON THE BRAKE BOOSTER VACUUM SUPPLY TUBE ASSEMBLY. THE RECALL BEGAN ON JUNE 27, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 08V208000 on NHTSA.gov
Exterior lighting, headlightsOct 25, 2007
CERTAIN SPYDER HEADLAMP REPLACEMENT ASSEMBLIES SOLD FOR USE ON 2004 THROUGH 2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SPYDER WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2007. OWNERS CAN CONTACT SPYDER AT 866-558-4264.
Campaign 07E089000 on NHTSA.gov
Exterior lighting, headlightsSep 25, 2007
CERTAIN HEADLAMP ASSEMBLIES IMPORTED AND SOLD AS AFTERMARKET EQUIPMENT BY SONAR AUTO PARTS FOR USE ON 2004-2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SONAR WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS CAN CONTACT SONAR AT 866-558-4264.
Campaign 07E080000 on NHTSA.gov
Exterior lighting, headlightsSep 14, 2007
CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. FR390-B001L AND FR390-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE THICKNESS IS UNSTABLE INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
EAGLE EYES WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON NOVEMBER 6, 2007. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.
Campaign 07E075000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000 on NHTSA.gov
Exterior lightingJun 29, 2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Campaign 06E060000 on NHTSA.gov
Exterior lighting, headlightsMar 13, 2006
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000 on NHTSA.gov
Interior lightingFeb 6, 2006
CERTAIN PICKUP TRUCKS FAIL TO COMPLY WITH EITHER THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 105, 'HYDRAULIC AND ELECTRIC BRAKE SYSTEMS' OR FMVSS NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' THESE VEHICLES WERE BUILT WITH A SOFTWARE ERROR IN THE INSTRUMENT CLUSTER.
THIS ERROR COULD PREVENT THE ANTILOCK BRAKE SYSTEM (ABS) WARNING LIGHT FROM ILLUMINATING IF THE ABS MODULE EVER BECAME INOPERATIVE.
DEALERS WILL RECALIBRATE THE INSTRUMENT CLUSTER IN THESE VEHICLES. THE RECALL BEGAN ON FEBRUARY 27, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 06V033000 on NHTSA.gov
Tires, tread/beltNov 21, 2005
CERTAIN CONTINENTAL CONTITRAC TR OWL, CONTITRAC TR BSW, GENERAL GRABBER TR BSW, AND CONTITRAC BSW TIRES MANUFACTURED BETWEEN MAY 29 AND JUNE 11, 2005, AND SOLD AS ORIGINAL EQUIPMENT ON CERTAIN FORD TRUCKS AND SOLD AS REPLACEMENT TIRES. THESE TIRES CAN WEAR PREMATURELY WHICH FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 119, NEW PNEUMATIC TIRES FOR VEHICLES OTHER THAN PASSENGER CARS.
AFFECTED TIRES MAY NOT MEET THE ENDURANCE TEST REQUIREMENTS OF THE STANDARD. CONTINUED USE OF THE AFFECTED TIRES CAN RESULT IN TIRE FAILURE WHICH COULD LEAD TO VEHICLE DAMAGE OR MOTOR VEHICLE CRASH.
CONTINENTAL WILL NOTIFY OWNERS AND REPLACE THE TIRES FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 7, 2005. OWNERS MAY CONTACT CONTINENTAL AT 704-588-5895.
Campaign 05T022000 on NHTSA.gov
Visibility, windshield wiper/washer, motorNov 9, 2005
ON CERTAIN TRUCKS, PASSENGER CARS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MOTOR MAY HAVE BEEN PRODUCED WITHOUT GREASE BEING APPLIED TO THE OUTPUT SHAFT GEAR.
AFTER A PERIOD OF CONTINUOUS USE ON THE HIGH SPEED SETTING, LACK OF GREASE ON THE OUTPUT SHAFT GEAR MAY CAUSE THE GEAR TO DISTORT OR FRACTURE DURING OPERATION RESULTING IN A LOSS OF WIPER FUNCTION. INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.
DEALERS WILL INSPECT THE WIPER MOTOR FOR THE PRESENCE OF GREASE AND GREASE THE WIPER MOTOR GEARS IF NECESSARY. THE RECALL BEGAN ON NOVEMBER 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673 OR LINCOLN/MERCURY AT 1-800-521-4140.
Campaign 05V520000 on NHTSA.gov
Representative owner complaints
589 reports, newest first.
Engine, Apr 5, 2016
ON 3 OCCASIONS MY VEHICLE ,OVER 4 MONTHS, HAS HAD A COMPLETE ENGINE FAILURE. THIS OCCURRED MOST RECENTLY WHILE I WAS EXITING THE INTERSTATE .WHEN THE ENGINE SHUTS DOWN SO DOES THE DASH AND BRAKE LIGHTS, IT ALSO STOPS POWER STEERING AND BRAKES. THIS TIME BY REACTING QUICKLY I WAS ABLE TO PUT THE VEHICLE IN NEUTRAL AND RESTART ,AFTER TURNING KEY TO OFF POSITION FIRST.
Seat belts, Mar 7, 2016
TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT WAS UNABLE TO LATCH THE FRONT DRIVER'S SEAT BELT. WHEN DRIVING ALONE, THE CONTACT WOULD LATCH HIS SEAT BELT INTO THE PASSENGER SIDE BUCKLE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 135,000.
Steering, Mar 2, 2016
THE STEERING WHEEL FREEZES UP IN COLD WEATHER. MY MECHANIC DIAGNOSED A FAILED LOWER STEERING COLUMN THAT IS EXPOSED TO ROADWAY SPLASH AND CORROSION. THIS IS ALSO A TELESCOPING SECTION OF THE STEERING COLUMN DESIGNED TO PROTECT THE DRIVER IN CASE OF FRONTAL CRASH. SO OVERNITE IT FREEZES UP AND SLOWLY LOOSENS. WHILE DRIVING BECOMES STIF AND RESULTS IN DIFFICULT STEERING. 45,000 MILES ON ODOMETER.
Steering, Mar 1, 2016
DROVE F-150 NORMALLY DURING WEEK. ON WEEKEND MORNING WHILE PULLING OUT OF DRIVEWAY STEERING WHEEL SUDDENLY AND SPORADICALLY BEGAN RESISTING EFFORT TO TURN CAUSING TRUCK TO SWAY UNPREDICTABLY DURING TURNS. RESISTING DRIVER INPUT. WAS TOO DANGEROUS TO DRIVE. AFTER REVIEWING BLOGS ONLINE I REALIZED A LOT OF OTHER PEOPLE WHO DRIVE THIS ERA F-150 HAVE THE SAME PROBLEM. IT TURNS OUT THE LOWER STEERING COLUMN SHAFT CONTAINING THE U-JOINTS USES DEFECTIVE MATERIALS OR HAS BAD DESIGN. THE U-JOINTS ARE BINDING UP DURING DRIVING CAUSING THE DRIVER TO LOSE PARTIAL CONTROL OVER DIRECTION OF VEHICLE. TEMPORARY FIX MAY BE TO SPRAY WITH ANTI-CORROSIVE SPRAY, THEN LUBRICATING SPRAY, WHICH I DID. THIS LASTS ONLY A SHORT TIME SO THE LOWER SHAFT WITH U-JOINTS MUST BE REPLACED. FORD KNOWS OF THE DEFECT FOR THIS ERA F-150 AND HAS REDESIGNED THIS LOWER SHAFT TO ELIMINATE THE BINDING. THIS NEW DESIGN IS WHAT THEY SELL YOU AS A REPLACEMENT, NOT THE ORIGINAL DESIGN. IF YOU TRY TO BUY ONE ONLINE IT COSTS AT LEAST $245 FOR THE O.E.M. PART. IF YOU BUY ONE OF THE 2 AFTERMARKET KNOCKOFFS IT'LL SET YOU BACK APPROX $125. THE AFTERMARKET SHAFT ADVERTISING TOUTS THE FACT THAT IT HAS A DESIGN THAT WILL NOT BIND LIKE THE ORIGINAL FORD SHAFT DOES. THIS TRUCK HAD APPROX 69,700 MILES ON IT WHEN THE SHAFT BEGAN BINDING UP.
Engine, Jan 30, 2016
I HAVE A 2006 F-150 V8 4.6 THE HEATER COIL IN THE TRUCK HAS FAILED. AND THE WATER PUMP ALSO
Visibility/wiper, Dec 22, 2015
TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE REAR PASSENGER AND DRIVER WINDOWS WERE LEAKING DURING INCLEMENT WEATHER. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 110,000.
Steering, Dec 21, 2015
LAST WEEK I STARTED NOTICING MY STEERING STARTING TO GET STIFF AND THE WHEEL DOES NOT RECENTER AFTER A STEER TO THE LEFT OR RIGHT. IVE HAD TO DO SOME QUICK MUSCLING TO RECENTER THE WHEEL. I'VE JUST FINISHED RESEARCHING SOME OTHER FORD FORUMS FOR THIS VEHICLE AND MANY OWNERS HAVE REPORTED THE SAME ISSUE WITH THE U JOINTS ON THE STEERING COLUMN RUSTING OR SEIZING. I WILL TRY SPRAYING SOME ANTI SEIZE ON THE U JOINTS TOMMOROW UNTIL I CAN GET IT TO A GARAGE.MY TRUCK HAS APPROXIMATELY 103,000 MILES ON IT . THIS IS DANGEROUS AND WITH THE AMOUNT OF COMPLAINTS ON THIS IT SHOULD BE RECALLED BY FORD TO CORRECT.
Steering, Other or unspecified, Nov 30, 2015
LAST WEEK TRUCK SUDDENLY BECAME VERY HARD TO TURN GOING AROUND CORNERS. STEERING WHEEL LOCKED UP AND I ALMOST WENT OVER AN EMBANKMENT. HIT OR MISS SO I NEVER KNOW WHEN IT WILL GO OUT. THANKFULLY DID NOT HAVE MY 2 YOUNG CHILDREN! A WEEK LATER (11/29/15), TRUCK SUDDENLY STARTS TO VIOLENTLY SHAKE IF I GO OVER 50 MPH! SCARED THE DICKENS OUT OF ME! HOPING TO LIMP IT TO A DEALERSHIP AND TRADE IT IN. NOT SAFE FOR ME TO DRIVE. I HAVE PUT 20K MILES ON IT IN 2 YEARS AND HAS BEEN REGULARLY SERVICED. WHAT GIVES?!?
Steering, Nov 29, 2015
MY STEERING STARTED TO BIND WHILE DRIVING . COULD NOT MAKE FULL RIGHT OR LEFT TURNS. VERY UNSAFE. THE TRUCK HAS LEFT THAN 30,000 MILES. RARELY DRIVEN.
Electrical system, Nov 2, 2015
WHILE DRIVING INSTRUMENT PANAL SHUTS DOWN, RADIO SHUTS OFF, AIRBAG INDICATOR COMES ON, WINDOWS DON'T WORK, IF SHUT OFF LASTS MORE THAN 5 MINUTES SEAT BELT CHIME GOES OFF, TWICE WORD TEST CAME ON IN MILEAGE INDICATOR WINDOW. SOMETIMES GOES ON AND OFF WHILE TURNING OR HITTING BRAKES, OTHER TIMES JUST WHILE DRIVING.
Engine, Oct 20, 2015
CYLINDER #4 BLEW THE SPARK PLUG OUT, STRIPPING THE THREADS AS IT WENT. THIS IS THE 2ND CYLINDER TO DO THIS IN 6 MONTHS. WHILE DRIVING AT 45 MPH.
Steering, Oct 13, 2015
WHILE MY VEHICLE WAS IN THE SHOP FOR A FOUR WHEEL ALIGNMENT THE MECHANIC NOTED THAT THE U-JOINT IN INTERMEDIATE STEERING SHAFT IS GOING BAD AND THEREFORE THE REASON THERE IS SOME PLAY IN THE STEERING WHEEL. COST TO REPAIR IS GOING TO BE APPROXIMATELY $700
Service brakes, Hydraulic, Oct 7, 2015
TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE BRAKE PEDAL EXCESSIVELY ABNORMALLY TRAVELED TO THE FLOORBOARD. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS INFORMED THAT THE VEHICLE WAS FUNCTIONING AS DESIGNED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 200. UPDATED 1/12/2016 *CN THE CONSUMER STATED WHEN HE ATTEMPTED TO BRAKE, HIS FOOT ALSO HIT THE ACCELERATOR PEDAL. THE CONSUMER STATED THE BRAKE AND ACCELERATOR WERE TOO CLOSE TOGETHER. UPDATED 05/04/16
Steering, Wheels, Oct 5, 2015
TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING 35 MPH AND COMING TO A COMPLETE STOP, THE REAR DRIVER SIDE TIRE SEPARATED AND ROLLED INTO TRAFFIC. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE REAR ROTOR AND STUDS FAILED AND NEEDED TO BE TIGHTENED. THE CONTACT ALSO STATED THAT HE HAD TO ALSO REPLACE THE STEERING RACK AND PINION DUE TO THE FAILURE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 136,000.
Electrical system, Engine, Fuel/propulsion system, Sep 25, 2015
SPARK PLUGS ON THE 5.3 LITER ENGINE WHEN REPLACED BREAK--IN RETURN THE BOOK SAID PULL ENGINE AND PULL HEADS TO REPLACE SPARK PLUGS. THE LAW SUIT FILLED FORD ADMITS TO BAD DECISION ON SPARK PLUGS AND WILL REIMBURSE SOME OF THE COST. THE COST IS VERY HIGH--THE BOOK AND FORD'S SHOP SAID THE ENGINE NEEDS TO BE PULLED TO PULL THE HEADS TO REPLACE THE SPARK PLUGS. THERE WAS NEVER ANY SOFTWARE UPDATES, AND NOW THE VEHICLE REQUIRES THEM. THE ERROR IN THE CLUSTER SOFTWARE RECALL WAS SUPPOSE TO BE REPAIRED AND I READ FROM THE EXPERTS ALL SOFTWARE SHOULD HAVE BEEN UPGRADED WITH THE CLUSTER ERROR. THERE ARE 42 P.M. FORD AND NHSTA KNEW OR KNOWS ABOUT ON MY VEHICLE AND NOTHING HAS BEEN DONE, I AM A 100% DAV AND MY VEHICLE HAS BEEN BROKEN DOWN. THE 2006 HARLEY DAVIDSON F-150 THAT COST SO MUCH WITH IT'S ON BOARD COMPUTER SYSTEM DOES NOT WORK. I HAVE READ MANY COMPLAINTS ABOUT THE F-150 ENGINE CUTTING OUT, I PULLED OUT TO PASS ON A TWO LANE ROAD AND ALMOST GOT KILLED WHEN MINE CUT OUT SO BAD. A TWO CYLINDER WOULD HAVE DONE BETTER THAN THAT V-8.
Wheels, Sep 21, 2015
FACTORY WELDS ON WHEELS FAILED CAUSING RAPID LOSS OF TIRE PRESSURE. THIS HAS HAPPENED TWO DIFFERENT TIMES ON TWO DIFFERENT WHEELS.
Engine, Sep 5, 2015
ORIGINALLY FACTORY INSTALLED SPARKPLUG BLOWS OUT OF THE ENGINE HEAD TRAVELING AT APPROXIMATELY 35 MPH. THIS WAS DISCLOSED AFTER TAKING VEHICLE TO A FORD DEALERSHIP FOR DIAGNOSTICS AS THERE WAS A LOUD NOISE WHILE ENGINE RUNNING AND LOSS OF POWER. REPAIR COST WAS $617. DISCUSSION WITH DEALER DISCLOSES THAT THIS A WELL KNOW PROBLEM BY FORD MANAGEMENT, A TBS HAS BEEN ISSUED. FURTHER FORD HAS DENIED ANY RESPONSIBILITY AND WILL NOT PROVIDE ANY MONETARY ASSISTANCE. THIS IS A FORD CREATED DESIGN ENGINEERING DEFECT THAT FORD JUST IGNORES AND LET'S THE CUSTOMER PAY FOR ITS MISTAKE. CUSTOMER IS SUBJECT TO COST OF REPAIR THAT IS FAR FROM NORMAL WEAR AND TEAR, A SAFETY CONCERN OF FIRE IN ENGINE COMPARTMENT FROM RAW FUEL BLOWN OUT OF THE HOLE VACATED BY SPARKPLUG, A RELIABILITY ISSUE AND A SAFETY CONCERN FROM SUDDEN LOSS OF POWER. THIS PROBLEM SHOULD BE COVERED BY A FEDERAL MANDATED RECALL SINCE FORD IS MAKING THIS A CONSUMER PROBLEM IGNORING THE FACT THAT IT IS A ENGINEERING, DESIGN OR MANUFACTURING PROBLEM FOR WHICH IT REFUSES TO ACCEPT RESPONSIBILITY. IN ADDITION THE TRADE IN VALUE OF THIS VEHICLE WILL BE REDUCED BY THE FORD DEALERSHIP THAT IS AWARE OF THE PROBLEM EVAN FOR THE CUSTOMER THAT DID NOT ENCOUNTER A SPARKPLUG BLOWOUT AND AT PRIVATE SALE IF PROSPECTIVE BUYER CHECKS ON VEHICLE VIA ANY INTERNET AUTOMOTIVE SITE. AGAIN FORD LETS CONSUMER ABSORB COST OF DEFECT IT CREATED.
Electrical system, Sep 4, 2015
TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING AT 45 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE FAILED TO RESTART AND WAS TOWED TO A MECHANIC WHERE IT WAS DISCOVERED THAT THE IGNITION SWITCH NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. AFTER THE VEHICLE WAS REPAIRED, THE FAILURE CONTINUED WITH A TICKING NOISE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNAVAILABLE.
Electrical system, Air bags, Seat belts, Aug 23, 2015
IN JUNE 2015, THE AIR BAG LIGHT IN MY FORD F150 ILLUMINATED, INDICATING A PROBLEM. I TOOK MY VEHICLE TO A FORD DEALERSHIP. THEY TOLD ME THAT THE DEPLOYABLE RESTRAINT SYSTEM, SPECIFICALLY THE PRETENSIONER, HAD MALFUNCTIONED AND POSSIBLY WOULD FAIL TO FUNCTION AS INTENDED IN THE EVENT OF A CRASH. THE SERVICE TECHNICIAN INDICATED THAT THE RESTRAINT SYSTEM IS CONNECTED TO MY AIR BAGS, WHICH MIGHT FAIL TO WORK IN A CRASH, INCREASING THE RISK OF INJURY. AFTER PAYING THE DIAGNOSTIC FEE, I WAS GIVEN A REPAIR ESTIMATE OF AN ADDITIONAL $392.21. NOT WANTING TO RISK INJURY IN THE EVENT OF A CRASH, I HAD THE PRETENSIONER REPLACED. THE BUCKLE PRETENSIONER IS A CRITICAL SAFETY DEVICE THAT SHOULD NEVER FAIL UNDER NORMAL USE. MY VEHICLE HAS NEVER BEEN IN AN ACCIDENT. IT IS MY UNDERSTANDING THAT SOME PRETENSIONERS HAVE FAILED DUE TO SIMPLE SEAT POSITION ADJUSTMENTS, WHICH, TO ME, IS EVIDENCE OF A POOR DESIGN. FORD HAS RECENTLY RECALLED MANY 2013 ' 2014 VEHICLES FOR POORLY MADE PRETENSIONERS, RECOGNIZING THE SAFETY ISSUE SURROUNDING THEM. I REQUESTED THAT FORD REIMBURSE ME FOR THE COST OF THE PRETENSIONER BUCKLE; HOWEVER, FORD DENIED THIS REQUEST. I HAVE THE ORIGINAL PRETENSIONER AND ALL RECEIPTS AVAILABLE.
Electrical system, Equipment adaptive/mobility, Engine, Aug 11, 2015
MORNING OF JULY 23,2015, I WAS DRIVING ABOUT 25 MPR SPEED WHEN NUMBER THREE SPARK PLUG BLOW OUT OF THE CYLANDERHEAD ON MY F-150 TRITON V8. TOOK IT TO THE LOCAL MACHANIC SHOP WALTON'S. THREE HOURS LATER, WALTON'S HAD TO REPLACE AND RESLEEVE NUMBER THREE CYLANDERHEAD AND REPLACED ELECTRICAL SPARKPLUG WIRE, PLUS REPLACED ALL EIGHT SPARK PLUGS. ALL AT A COST OF $543.00. NOT ONLY THIS HAPPENED TO ME BUT WALTON'S STATED THAT I WAS THE 10TH PERSON THIS WEEK THIS HAS HAPPENED TOO. I PRESENTED THE PART TO MY LOCAL FORD DEALERSHIP WHERE WE BOUGHT THE TRUCK (HALL'S FORD MOTOR COMPANY) BRAND NEW IN 2006 AND PAID CASH TO THE SUM OF $30,000.00. I ASKED THEM IF THEY KNOW OF THIS PROBLEM WITH TRITON V8'S. THEY STATED THEY DID BUT NO KNOW RECALLS AND THEY TOO HAD SEVERAL REPAIRS COME IN FOR THE SAME THING IN THE PASS WEEK. THEY ALSO STATED THAT THE FORD MOTOR COMPANY WAS AWARE OF THIS MATTER BUT NEVER LET THERE CUSTOMERS KNOW ABOUT THIS PROBLEM YET BECAUSE THERE WAS NO RECALL ON FILE TO LET THEM KNOW. THIS THING WHERE THE SPARK PLUGS COME FLYING OUT OF AN ENGINE CAN BE VERY HAZARDS, IT COULD CAUSE A CRASH OR EVEN GIVE A PERSON A HEART ATTACK BECAUSE THE TRUCK SOUNDS LIKE WORLD WAR III GOING OFF UNDER THE HOOD AND IT MAY EVEN START A FIRE. THIS MATTER NEEDS TO BE TAKEN CARE OF BY FORD.
Electrical system, Engine, Jul 13, 2015
TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR ROUTINE MAINTENANCE. WHILE AT THE INDEPENDENT MECHANIC, THE CONTACT WAS NOTIFIED THAT SEVEN OF THE EIGHT SPARK PLUGS IN THE VEHICLE WERE FRACTURED AND NEEDED TO BE REPLACED. THE CONTACT STATED THAT ONE OF THE FRACTURED SPARK PLUGS REMAINED IN THE CYLINDER HEAD. THE MECHANIC STATED THAT THE CYLINDER HEAD HAD TO BE REMOVED FROM THE ENGINE TO REMOVE THE FRACTURED SPARK PLUG. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE; HOWEVER, THE CONTACT WAS NOT OFFERED A REMEDY FOR THE FAILURE. THE FAILURE MILEAGE WAS 84,000.
Service brakes, Jun 22, 2015
TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING AT 20 MPH, THE BRAKES AUTO ENGAGED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 80,000. UPDATED 09/03/15*LJ UPDATED 10/26/2017*CN
Power train, Jun 5, 2015
TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE STEERING WHEEL BECAME TIGHT AND LOOSENED UP AT RANDOM TIMES WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE DRIVESHAFT WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 160,000.
Power train, May 28, 2015
TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT WAS UNABLE TO SHIFT THE GEAR INTO DRIVE OR REVERSE, ONLY NEUTRAL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE CLUTCHES AND BANDS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 28,854. UPDATED 7/16/15*CN THE CONSUMER STATED THE TAIL SHAFT HOUSING HAD A HAIRLINE FRACTURE/CRACK WITH. THE REPAIRMAN BELIEVED THE PART WAS DEFECTIVE. THERE WAS NO WEAR ON THE INSIDE OF THE TRANSMISSION, BEARING OR SEALS. UPDATED 08/04/15*JB
Structure, Fuel/propulsion system, Mar 23, 2015
WHILE IN PASSING LANE OF THREE LANE WEST BOUND ROUTE 3 ENGINE SHUT DOWN, HAD TO NEGOTIATE TWO LANES OF HIGHWAY TRAFFIC TO GET TO SHOULDER WHILE COASTING. VEHICLE TOWED TO REPAIR SHOP. FUEL PUMP CONTROL MODULE FAILURE. MODULE CORRODED, HOLES THRU BACK OF MODULE WHERE IT MOUNTS TO FRAME. *TR