2007 Ford F-150
Problems, recalls and owner-reported issues
Engine is the leading concern among 492 owner complaints filed for this model year. This is the 7th highest complaint count among 26 F-150 model years with reports.
Of the 2007 reports, 40 involved a crash and 13 involved a fire. 38 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Engine and engine coolingOct 8, 2008
ROUSH IS RECALLING 213 MY 2007-2008 FORD F-150 TRUCKS ALTERED TO OPERATE USING LIQUID PROPANE INJECTION. THE HYDRO-CARBON PAPER AFFIXED TO THE INSIDE OF THE AIRBOX LID WITH ADHESIVE MAY BECOME DISLODGED DURING OPERATION.
THIS FAILURE MAY RESULT IN A LOSS OF PERFORMANCE, ILLUMINATION OF THE MALFUNCTION INDICATOR LAMP (MIL) AND, IN EXTREME CASES, A STALLING OF THE VEHICLE DURING OPERATION WITHOUT NOTICE, WHICH COULD RESULT IN A CRASH.
DEALERS WILL REPLACE THE AIRBOX LID WITH A NEW ONE THAT INCLUDES THE HYDRO-CARBON PAPER WHICH HAS BEEN AFFIXED USING AN ADHESIVE PROMOTER AND GREATER PRESSURE AS RECOMMENDED BY THE MANUFACTURER FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 21, 2008. OWNERS MAY CONTACT ROUSH AT 1-866-307-6788.
Campaign 08V523000 on NHTSA.gov
Exterior lighting, headlightsOct 25, 2007
CERTAIN SPYDER HEADLAMP REPLACEMENT ASSEMBLIES SOLD FOR USE ON 2004 THROUGH 2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SPYDER WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2007. OWNERS CAN CONTACT SPYDER AT 866-558-4264.
Campaign 07E089000 on NHTSA.gov
Exterior lighting, headlightsSep 25, 2007
CERTAIN HEADLAMP ASSEMBLIES IMPORTED AND SOLD AS AFTERMARKET EQUIPMENT BY SONAR AUTO PARTS FOR USE ON 2004-2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SONAR WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS CAN CONTACT SONAR AT 866-558-4264.
Campaign 07E080000 on NHTSA.gov
Exterior lighting, headlightsSep 14, 2007
CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. FR390-B001L AND FR390-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE THICKNESS IS UNSTABLE INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
EAGLE EYES WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON NOVEMBER 6, 2007. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.
Campaign 07E075000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Fuel system, gasoline, storage, tank assemblyJun 28, 2007
ON CERTAIN TRUCKS BUILT WITH 26 GALLON FUEL TANKS, THE FUEL TANK MAY HAVE A DEPRESSION AT THE SEAM BETWEEN THE TOP AND BOTTOM HALVES OF THE TANK (NOT VISIBLE FROM OUTSIDE THE FUEL TANK). IF A DEPRESSION IS LARGE ENOUGH, FUEL MAY PERMEATE THE FUEL TANK WALL RESULTING IN A FUEL ODOR, OR A "SERVICE ENGINE SOON" INDICATOR LIGHT.
IF LEFT UNCORRECTED, A FUEL LEAK COULD EVENTUALLY DEVELOP. A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
DEALERS WILL REPLACE THE FUEL TANK FREE OF CHARGE. THE RECALL BEGAN ON JUNE 25, 2007. OWNERS MAY CONTACT FORD AT 1-866-436-7332.
Campaign 07V278000 on NHTSA.gov
Representative owner complaints: engine
148 reports, newest first. Show all
Engine, Fuel/propulsion system, Jan 11, 2018
ENGINE TICKING, FROM PRIOR REPORTS LOOKS TO BE A COMMON ISSUE, ALSO WHEN FILLING UP WITH GAS IT SEEMS TO HAVE BACK PRESSURE AND KEEPS TURNING THE PUMP OFF.
Engine, Dec 7, 2017
I BOUGHT A 2007 FORD F15 FX4 TRUCK A YEARS AGO, AND TOOK IT TO FORD TO ASKED THEM ABOUT THE TICKING NOISE COMING FROM ENGINE. THEY TOLD ME THAT IT WAS NORMAL ON THE 5.4 TRITON. ABOUT A WEEK AGO THE TICKING GOT LOUDER AND I LOOKED UP PROBLEMS ONLINE, AND FOUND THAT THERE IS A DESIGN FLAW IN THE ENGINE THAT CAUSES CAM PHASERS TO FAIL, AND OIL PRESSURE DROPS TO ZERO. FORD KNOWS ABOUT THE PROBLEM, BUT WHEN I CALLED THEY TOLD ME THAT I NEED TO REPLACE THE ENGINE, AND THAT IT WOULD BE ON ME. I LOOKED ON SEVERAL FORD FORUMS AND FOUND THAT THERE ARE 1000'S OF PEOPLE TALKING ABOUT THIS. IS IT GOING TO TAKE SOMEONE GETTING KILLED BEFORE FORD OWNS UP TO THERE PROBLEMS! THEY ARE IGNORING THE ISSUE AND HAVING THE CONSUMER PAY AYWHERE FROM 3500- 8000 DOLLARS TO REPAIR THIS ISSUE. ALSO, THE ENGINE HAS VERY BAD POWER LOSS AND SHAKES VIGOURESLY WHEN WARM AND PULLING UP TO STOP OR REVERSE.
Power train, Structure, Engine, Sep 20, 2017
O/D OFF LIGHT , TRANSMISSION FAULT ON INFORMATION DISPLAY INTERMITTENT LIGHT AND TONE! TRUCK WOULD NOT START, PCM FAILURE $3500 DOLLARS IN REPAIR, AT FORD DEALER STILL NOT FIXED!
Engine, Sep 19, 2017
BLOWN OUT SPARK PLUG #3 CYLINDER, REPAIR LASTED LESS THAN 3 WEEKS AND FAILED ON STATE HIGHER 41 IN CALIFORNIA WITCH CAUSE MAJOR LOSS OF POWER GOING UPHILL AND STALLED IN THE MIDDLE OF TRAFFIC WITH MY WIFE AND CHILD IN THE VEHICLE. THE INCIDENT LEFT US WITH NO CHOICE BUT TO WALK ACROSS HEAVY TRAFFIC TO THE SIDE OF THE HIGHWAY AND LEAVE THE VEHICLE IN THE ROAD WAY
Engine, Sep 6, 2017
I BOUGHT TRUCK ABOUT 2 YEARS AGO TOOK TO FORD TO HAVE TRANNY FLUSH ON IT ASKED THEM ABOUT THE TICKING NOISE COMING FROM ENGINE THEY TOLD ME THAT IT WAS NORMAL ON THE 5.4 TRITON ABOUT A WEEK AGO THE TICKING GOT LOUDER AND LOOKED UP PROBLEMS AND FOUND THAT THERE IS A DESIGN FLAW IN ENGINE THAT CAUSES CAM PHASERS FAIL ND OIL PRESSURE DROPS TO ZERO FORD KNOWS ABOUT PROBLEM BUT WHN YOU CALL THEY TELL YOU THAT YOU NEED TO REPLACE THE ENGINE WELL LOOKED UP FORUMS AND PEOPLE WHO HAVE REPLACED THE MOTOR HAD SAME PROBLEMS WITH IT LATER ON YESTERDAY I WAS DRIVING TAKING MY 2 DAUGHTERS TO SCHOOL WHEN ALL OF A SUDDEN THE ENGINE SHUT OFF I LOST BRAKES AND STEERING. THE TRUCK BEHIND ME HAD TO LOCK UP ITS BRAKES TO KEEP FROM HITTING ME AND MY KIDS SO I AM WRITING YOU TO SEE IF YOU CAN LOOK INTO THIS MY KIDS WERE SO SCARED THE TRUCK SLOWED INSTANTLY WHEN THE ENGINE FAILED I HAD MY FRIEND TOW IT BACK TO MY HOUSE WHERE I CHECKED THE CAM SENSORS AND CHANGED THEM AND DID NOT START STILL DOES NOT START NOW THERE ARE 1000'S OF PEOPLE ON FORUMS TALKING ABOUT THIS IS IT GOING TO TAKE SOMEONE GETTING KILLED BEFORE FORD OWNS UP TO THERE PROBLEMS THEY ARE IGNORING AND HAVING THE CONSUMER PAY AYWHERE FROM 3500- 8000 DOLLARS TO REPAIR THIS I FIRST ASKED WHEN I BOUGHT TRUCK WITH 81,000 MILES ON IT
Engine, May 24, 2017
FILED A CLAIM WITH THE STATE OF CALIFORNIA BUREAU OF AUTOMOTIVE REPAIR ON 4-3-17, COMPLAINT # OC 2017005088, AGAINST FOUR ENTITIES INCLUDING: EL CAJON, CA FORD DEALER, CERTIFIED CAR CLINIC, FORD AUTOMOTIVE INC., AND DREW/PENSKE FORD REGARDING MY 2007 5.4 TRITON FORD F-150 TRUCK PLATINUM SPARK PLUG DEFECT. I WAS TOLD BY THE BAR THAT MY COMPLAINT WOULD BE FILED WITH YOUR AGENCY. I WOULD LIKE TO VERIFY IN WRITING THAT YOUR AGENCY HAS RECEIVED THE STATE OF CALIFORNIA BAR COMPLAINT.
Engine, May 23, 2017
I NEED REPLACE SPARKS PLUS NO VARY LIKE DO THEY SAID FORD F150 5.4 POSIBLE LOOS PICE INSIDE MOTOR
Engine, May 22, 2017
TL* THE CONTACT OWNS A 2007 FORD F-150. WHILE DRIVING APPROXIMATELY 40 MPH, THE ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE ENGINE SPARK PLUGS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.
Engine, May 3, 2017
PICKED UP MY SON FROM SCHOOL AND WHILE DRIVING DOWN THE HIGHWAY AT 55MPH I HEARD A LOUD NOISE AND IT GOT REALLY LOUD . MY SPARK PLUG JUST BLEW OUT FOR NO REASON.
Suspension, Engine, May 2, 2017
TL* THE CONTACT OWNS A 2007 FORD F-150. WHILE DRIVING 45 MPH, THE VEHICLE DECELERATED AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE SPARK PLUGS AND THE COIL SPRINGS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE MANUFACTURER ADVISED THE CONTACT TO CALL NHTSA TO CHECK FOR ANY OPEN RECALLS. THE FAILURE MILEAGE WAS 88,000.
Engine, Feb 22, 2017
SPARK PLUG BLEW OUT OF HEAD.
Engine, Jan 29, 2017
A SPARK PLUG BACKED OUT. STRIPPED THE THREADS IN THE HEAD. THIS HAPPENED WHILE DRIVING THE TRUCK. *TR
Engine, Nov 2, 2016
TL* THE CONTACT OWNS A 2007 FORD F-150. WHILE DRIVING APPROXIMATELY 20 MPH, THERE WAS A KNOCKING NOISE COMING FROM THE ENGINE AND THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE NUMBER THREE SPARK PLUG DETACHED AND NEEDED TO BE REPLACED THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 102,890. UPDATED 08/09/17*LJ *CN
Engine, Oct 31, 2016
CRACKED OR WARPED EXHAUST MANIFOLD. I'VE HAD IT LOOKED AT BY TWO AUTO MECHANICS AND HAVE READ ONLINE WITH THIS WIDESPREAD PROBLEM.
Engine, Sep 9, 2016
WHILE DRIVING MY TRUCK SUDDENLY LOST POWER AND SHIFTED INTO "LIMP HOME MODE" WHILE THE WRENCH AND CHECK ENGINE LIGHT CAME ON. THIS HAPPENED TO ME A FEW YEAR BACK AS WELL SO I IMMEDIATELY ASSUMED IT WAS THE THROTTLE BODY OR SENSOR GOING BAD. I BROUGHT INTO THE FORD DEALERSHIP WHO CONFIRMED TO ME IT WAS THE THROTTLE BODY THAT WENT OUT. THIS IS NOW THE 3 THROTTLE BODY THAT MY TRUCK HAD HAD (9 YEARS OLD AND 130,000 MILES). AFTER DOING RESEARCH I SAW WHERE FORD HAD THIS SAME ISSUE WITH OTHER MODEL VEHICLES AND INSTEAD OF RECALLING EXTENDED WARRANTIES TO COVER THE COST OF REPLACEMENT. THIS IS EXTREMELY DANGEROUS AS IF IT OCCURS WHEN MERGING INTO TRAFFIC YOU LOSE ALL ABILITY TO ACCELERATE. I THINK FORD HAS A MAJOR ISSUE HERE THAT IT IS REFUSING TO ADDRESS.
Engine, Jul 7, 2016
WHEN MY TRUCK IS AT OPERATING TEMP. AND COMING TO A STOP IT SOUNDS LIKE A DIESEL, IT FIRST STARTS BY KNOCKING AND TICKING THEN IT SHUTS DOWN.. THIS IS A SERIOUS PROBLEM FOR WHEN YOUR PULLING ANYTHING WITH THE TRUCK ALWAYS IT WANTS TO DIE, OF COURSE UNLESS YOUR GOOD AND CAN THROW IT INTO NEUTRAL AND REV THE MOTOR TO 2000 RPM'S WITH KILLING ANYONE. YOU START LOSING STEERING AND BRAKES WHEN THE MOTORS RPM'S GET VERY LOW.
Air bags, Engine, Fuel/propulsion system, Jul 4, 2016
TAKATA RECALL.ENGINE HAS VERY BAD POWER LOSS AND SHAKES VIGOURESLY WHEN WARM AND PULLING UP TO STOP OR REVERSE.
Structure, Engine, Jun 25, 2016
2007 FORD F-150 XLT WITH 5.4L TRITON V8,ENGINE BEGAN SHAKING VIOLENTLY WHILE AT STOP LIGHT, THEN HESITATED CONSISTENTLY WHILE ACCELERATING 40-50MPH, NO WARNING LIGHTS OR INDICATORS ON IN TRUCK. FORD DEALERSHIP REPLACED COIL I BELIEVE, JUST PURCHASED THE TRUCK USED AND DIDN'T GET ANY DOCUMENTATION WHEN THEY FIXED IT.
Electrical system, Engine, Jun 22, 2016
TL* THE CONTACT OWNS A 2007 FORD F-150. WHILE DRIVING APPROXIMATELY 15 MPH, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED AND THE VEHICLE STARTED TO LOSE ACCELERATION AND POWER. THE CONTACT HAD TO PULL INTO A FUEL STATION. THE MECHANIC AT THE STATION DETERMINED THAT THE IGNITION COIL AND A SPARK PLUG FAILED AND NEEDED TO BE CHANGED. THE VEHICLE WAS REPAIRED. THE FAILURE RECURRED THREE OTHER TIMES AND WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS INVALID. THE APPROXIMATE FAILURE MILEAGE WAS 116,000.
Engine, Jun 16, 2016
WHEN AT A RED LIGHT OR STOP SIGN THE TRUCK SURGES THE RPM GAGE IS OUT OF CONTROL ALMOST SURGING ME INTO ONCOMING TRAFFIC THIS IS THE SECOND TIME THIS HAS HAPPEN IT ALSO HAPPENED IN 2015, TOOK IT TO THE SHOP AND IT COST ME 385.00 AND NOW A YESR LATER ITS HAPPENING AGAIN.
Engine, Jun 9, 2016
I BOUGHT THIS TRUCK IN 2015 HAD 120,000 MILES ON IT NOW PROBLEMS AFTER 5,000 MILES I NOTICED A KNOCKING IN THE ENGINE AND THE WHOLE TRUCK WILL BEGIN TO SHAKE AFTER A FEW MILES DOWN THE ROAD. THIS STARTED AT 125,000 MILES. I WOULD HAVE TO TURN THE TRUCK OFF AND TURN IT BACK ON, WHILE AT A STOP LIGHT. JUST RECENTLY MY WIFE AND I TOOK A TRIP OUT OF STATE WHILE ON THE HIGHWAY THE ENGINE STARED TO KNOCK AND TRUCK BEGAN TO SHAKE. I HAD TO PULL OVER TURN THE TRUCK OFF AND TURN IT BACK ON. HAVE TO DO THIS THREE TIMES ON OUR TRIP, NOT A HAPPY TRIP IN THE TRUCK. AFTER OUR TRIP THE I CALLED FORD MOTOR COMPANY AND TOLD THEM WHAT WAS HAPPENING WITH THE TRUCK THEY TOLD ME IT WAS NOT THERE PROBLEM AND WOULD NOT PAY TO HAVE IT FIXED. I TOOK MY TRUCK TO AN INDEPENDENT MECHANIC WHO TOLD ME THAT IT WAS THE CAM SENSOR OR CAM PHASOR. TO HAVE IT REPLACED WOULD COST ME $4,000. I TOOK THE TRUCK TO A FORD DEALERSHIP THAT TOLD ME THE SAME THING THE MECHANIC SAID AND THAT THEY WOULD CHARGE ME $2,000 TO REPLACE. THEY ALSO INFORMED THE THAT MOST OF THE 2007 F150 THAT COME ARE HAVING THE SAME PROBLEM. I HAVE LET IT SIT IN MY GARAGE TILL FORD DOES A RECALL. I AM NOT PAYING FOR THERE MISTAKE FOR SHODDY WORK.
Engine, May 13, 2016
TL* THE CONTACT OWNS A 2007 FORD F-150. WHILE DRIVING 40 MPH, THE CONTACT FELT A VIBRATION FROM THE ENGINE COMPARTMENT. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 99,000.
Engine, Apr 4, 2016
TL* THE CONTACT OWNS A 2007 FORD F-150. WHILE DRIVING AT VARIOUS SPEEDS, AN UNKNOWN SOUND WAS HEARD FROM THE ENGINE AND THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE FAILURE OCCURRED CONSTANTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE CAMSHAFT FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. SOMETIME AFTER THE REPAIRS, WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE STARTED TO VIBRATE SEVERELY. THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO ANOTHER INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE ENGINE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 115,000.
Engine, Feb 25, 2016
SPARK PLUG BLEW OUT. MECHANIC REPLACED IT FOR $350 THEN IT BLEW OUT AGAIN 2 DAYS LATER. PROBLEM WITH FORD SPARK PLUG TEARING THREADS OUT AND NOT BEING ABLE TO REPLACE SPARK PLUG WITHOUT REPLACING ENTIRE ENGINE. MY SON WAS ON HIS WAY BACK TO COLLEGE (5HR DRIVE) WHEN THE SPARK PLUG BLEW. IT SOUNDED LIKE A SHOTGUN! HAD IT TOWED TO MECHANIC AND THEY REPLACED SPARK PLUG AND 2 DAYS LATER SAME ONE BLEW AGAIN WHILE DRIVING TO WORK. TOWED A SECOND TIME AND MECHANIC IS SEARCHING FOR WAYS TO RESOLVE. HE SAYS WE MAY HAVE TO REPLACE ENTIRE ENGINE BECAUSE OF THREADS BEING STRIPED WHEN IT BLEW OUT. FORD MECHANIC HAS LOOKED AT AND DOES NOT HAVE ANY SOLUTIONS. IN RESEARCHING ONLINE I HAVE DISCOVERED THAT THIS COULD HAVE POTENTIALLY BEEN VERY DANGEROUS. OTHERS WITH SAME PROBLEM HAVE HAD ENGINE FIRE WHEN SPARKPLUG BLEW. WE WERE IN PROCESS OF SELLING VEHICLE SO NOW WE ARE SOL! WE DON'T HAVE $4000 TO REPLACE ENGINE AND OUR FAMILY NEEDS A 2ND CAR. NEVER AGAIN WILL I BUY A FORD. THEY DO NOT STAND BEHIND THEIR PRODUCT!
Engine, Jan 11, 2016
TL* THE CONTACT OWNS A 2007 F-150. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 35 MPH AND COMING TO A STOP LIGHT, THE VEHICLE STALLED AND THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE ENGINE FAILED AND THE MOTOR NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 123,000.