2007 Ford F-150
Problems, recalls and owner-reported issues
Engine is the leading concern among 492 owner complaints filed for this model year. This is the 7th highest complaint count among 26 F-150 model years with reports.
Of the 2007 reports, 40 involved a crash and 13 involved a fire. 38 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Engine and engine coolingOct 8, 2008
ROUSH IS RECALLING 213 MY 2007-2008 FORD F-150 TRUCKS ALTERED TO OPERATE USING LIQUID PROPANE INJECTION. THE HYDRO-CARBON PAPER AFFIXED TO THE INSIDE OF THE AIRBOX LID WITH ADHESIVE MAY BECOME DISLODGED DURING OPERATION.
THIS FAILURE MAY RESULT IN A LOSS OF PERFORMANCE, ILLUMINATION OF THE MALFUNCTION INDICATOR LAMP (MIL) AND, IN EXTREME CASES, A STALLING OF THE VEHICLE DURING OPERATION WITHOUT NOTICE, WHICH COULD RESULT IN A CRASH.
DEALERS WILL REPLACE THE AIRBOX LID WITH A NEW ONE THAT INCLUDES THE HYDRO-CARBON PAPER WHICH HAS BEEN AFFIXED USING AN ADHESIVE PROMOTER AND GREATER PRESSURE AS RECOMMENDED BY THE MANUFACTURER FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 21, 2008. OWNERS MAY CONTACT ROUSH AT 1-866-307-6788.
Campaign 08V523000 on NHTSA.gov
Exterior lighting, headlightsOct 25, 2007
CERTAIN SPYDER HEADLAMP REPLACEMENT ASSEMBLIES SOLD FOR USE ON 2004 THROUGH 2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SPYDER WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2007. OWNERS CAN CONTACT SPYDER AT 866-558-4264.
Campaign 07E089000 on NHTSA.gov
Exterior lighting, headlightsSep 25, 2007
CERTAIN HEADLAMP ASSEMBLIES IMPORTED AND SOLD AS AFTERMARKET EQUIPMENT BY SONAR AUTO PARTS FOR USE ON 2004-2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
SONAR WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS CAN CONTACT SONAR AT 866-558-4264.
Campaign 07E080000 on NHTSA.gov
Exterior lighting, headlightsSep 14, 2007
CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. FR390-B001L AND FR390-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE THICKNESS IS UNSTABLE INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
EAGLE EYES WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON NOVEMBER 6, 2007. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.
Campaign 07E075000 on NHTSA.gov
Equipment, electricalAug 28, 2007
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Campaign 07E066000 on NHTSA.gov
Fuel system, gasoline, storage, tank assemblyJun 28, 2007
ON CERTAIN TRUCKS BUILT WITH 26 GALLON FUEL TANKS, THE FUEL TANK MAY HAVE A DEPRESSION AT THE SEAM BETWEEN THE TOP AND BOTTOM HALVES OF THE TANK (NOT VISIBLE FROM OUTSIDE THE FUEL TANK). IF A DEPRESSION IS LARGE ENOUGH, FUEL MAY PERMEATE THE FUEL TANK WALL RESULTING IN A FUEL ODOR, OR A "SERVICE ENGINE SOON" INDICATOR LIGHT.
IF LEFT UNCORRECTED, A FUEL LEAK COULD EVENTUALLY DEVELOP. A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
DEALERS WILL REPLACE THE FUEL TANK FREE OF CHARGE. THE RECALL BEGAN ON JUNE 25, 2007. OWNERS MAY CONTACT FORD AT 1-866-436-7332.
Campaign 07V278000 on NHTSA.gov
Representative owner complaints
492 reports, newest first.
Vehicle speed control, Service brakes, Engine, Feb 12, 2015
OVER THE PAST SIX WEEKS, I HAVE ENCOUNTERED THREE EVENTS IN WHICH MY VEHICLE WAS ACCELERATING WHILE I HAD MY FOOT ON THE BRAKE. THE FIRST TIME, THE TRUCK WAS ATTEMPTING TO PULL FORWARD, VIBRATING, AND REVVING THE ENGINE WHILE I WAS STOPPED AT A LIGHT .I THOUGHT IT WAS A FLUKE OR AN ERROR ON MY PART AND DISREGARDED IT. THE SECOND AND THIRD TIME, I WAS TRYING TO SLOW DOWN FOR THE LIGHT WITH VEHICLES AHEAD OF ME. INSTEAD OF STOPPING AS I WAS DEPRESSING THE BRAKE, THE ENGINE BEGAN TO REV AND PULL FORWARD. I DEPRESSED MY BRAKES TO FLOOR AND THE TRUCK STOPPED BUT THE ENGINE CONTINUED TO REV AND ATTEMPT TO PULL FORWARD WITH THE BRAKE ON. FORD COMPANY AND MY DEALERSHIP, OF COURSE, DENIED ANY PROBLEMS EVEN AFTER I CITED SEVERAL CASES IN WHICH THIS OCCURRED WITH OTHER CARS. THEY SAID SOMETIMES SENSORS GO OUT AND THEY SHOULD NOT BE RESPONSIBLE FOR IT BUT WERE HAPPY TO DO A DIAGNOSIS FOR $100. I SEE SEVERAL COMPLAINTS REGARDING THE ELECTRONIC THROTTLE CONTROL SYSTEMS COMPARED TO THE NEW BRAKE OVERRIDE SYSTEMS AND AM TOTALLY UNNERVED THAT FORD WILL NOT TAKE RESPONSIBILITY FOR THIS. I AM CONCERNED ABOUT DRIVING THE TRUCK WITH ONLY 45,000 MILES ON IT. I FEAR THAT ANY MOMENT, MY TRUCK IS GOING TO ACCELERATE INTO ANOTHER VEHICLE WHILE MY FOOT IS ON THE BRAKE. I WILL NEVER BUY A FORD AGAIN--A TOTAL DISREGARD FOR CONSUMER SAFETY. *TR
Engine, Feb 6, 2015
TL*THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 55 MPH, THE VEHICLE DECELERATED AS THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE CAMSHAFT PHASER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000.
Structure, Feb 1, 2015
CAB CORNER RUST OUT ROCK PALL RUST OUT WHEN I PAY 38000 GRAND FOR A TRUCK NEW OFF THE LOT NOW WITH 30000 MILES SHOULD NOT BE THAT MUCH RUST COME TO FIND OUT ON THE BACK OF THE CAB CORNER THERE A GAP WHERE WATER LEAK IN TO THE ROCKER AND THE WATER LAYS IN THERE AND RUST OUT THE BOTTOM OF THE DOOR AND HOW HARD WOULD OF BEEN TO RUN A BEAD OF SEAM SEALER FOR WATER COULD OF GOT DOWN IN THERE. *TR
Engine, Jan 31, 2015
3 OUT OF 8 SPARK PLUGS HAVE BLOWN OUT OF HEAD IH MOTOR. THIS SEEMS TO BE A COMMON PROBLEM AFTER RESEARCHING SEVERAL OTHER MAKES AND MODELS OF ALL FORD VEHICLES. I HAVE SEARCHED FOR RECALL INFORMATION FROM FAULTY DESIGN WITH NO LUCK. *TR
Fuel/propulsion system, Jan 28, 2015
TRUCK WOULDN'T START. HAD TO BE TOWED TO DEALER. PROBLEM WAS CORRODED FUEL PUMP DRIVER MODULE. NEW PART COST $195.07 AND LABOR WAS $285.00. GOING ON LINE TO SEE WHAT WAS DONE, THE LABOR CHARGES SEEM VERY EXCESSIVE! THIS ISSUE LOOKS TO BE VERY WIDESPREAD AND SHOULD BE A RECALL BY FORD. *TR
Air bags, Jan 23, 2015, crash
I WAS STOPPED AT A STOP SIGN AND THE OTHER DRIVER RAN A STOP SIGN AT 55 MPH AND HIT ME ON THE PASSENGER SIDE FRONT FENDER AND MY AIR BAGS NEVER WENT OFF. I HAVE HAD TO GO TO THE HOSPITAL WITH HURT SHOULDER AND BACK AND BRUISED KIDNEYS FRACTURED RIBS AND BRUISED LIVER AND MY ORGANS SWOLLEN AND A DISPLACED HIP. I AM STILL TRYING TO RECOVER FROM THE MAJOR SOFT TISSUE DAMAGE AND THE TRUCK WAS A TOTAL LOSS. *TR
Air bags, Seat belts, Jan 20, 2015, crash
TL* THE CONTACT OWNED A 2007 FORD F-150. WHILE DRIVING APPROXIMATELY 99 MPH, THE VEHICLE STRUCK AN EMBANKMENT AND ROLLED OVER TWO AND A HALF TIMES. THE AIR BAGS DID NOT DEPLOY. THE DRIVER WAS WEARING A SEAT BELT; HOWEVER, HE WAS EJECTED FROM THE VEHICLE THROUGH THE REAR DRIVER SIDE WINDOW. THE DRIVER SUSTAINED FATAL INJURIES. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 64,000. THE VIN WAS UNAVAILABLE.
Power train, Jan 11, 2015
WHILE DRIVING ON THE FREEWAY AT 75MPH A WARNING LIGHT CAME ON SAYING TRANSMISSION FAULT. THE OVERDRIVE LIGHT WAS FLASHING. THE TRUCK CONTINUED TO DRIVE NORMALLY BUT THE WARNING INDICATORS KEPT GOING ON. THERE WERE NO CODES WHEN IT WAS TAKEN TO THE SHOP ALTHOUGH THE SHOP SAID THEY HAVE A RETAINING CLIP THAT WEARS OUT AND CAUSES ALL THE PARTS TO SHIFT. THIS RESULTED IN HAVING TO REPLACE THE TRANSMISSION. FORD NEEDS TO RECALL THE DEFECTIVE PARTS. MANY OTHER F 150 OWNERS HAVE HAD THE SAME PROBLEM. TRANSMISSION REPLACEMENT COST MORE THAN I BOUGHT THE TRUCK FOR! *TR
Tires, Dec 28, 2014
HANKOOK DYNAPRO AS P235-70-R17S TIRE WITH APPROXIMATELY 60% WEAR (ACCORDING TO FORD DEALERSHIP WHERE VEHICLE WAS PURCHASED AND TIRES REPLACED). DURING NORMAL DRIVING NOTICED ABNORMAL BUMPING THAT APPEARED TO BE ASSOCIATED WITH TIRE OR FRONT END. TOOK VEHICLE TO SHOP TO CHECK BALANCE AND WHEEL ALIGNMENT. TECH FOUND THE ABOVE DESCRIBED TIRE HAD SEPARATED AND THE STEEL BELTING WAS PROTRUDING THROUGH THE TREAD AND TOP OF SIDEWALL. TIRE WAS ABOUT TO FAIL. DRIVER CONTACTED HANKOOK AND FORWARDED A PHOTOGRAPH OF THE TIRE TO THE REPRESENTATIVE. HANKOOK AGREED TO A 40% REFUND OF THE AMOUNT THAT FORD PAID (NOT WHAT I PAID) FOR THE TIRE IF I WOULD RETURN THE TIRE OR A PIECE FROM IT CONTAINING THE DOT NUMBER. FORD TOOK THE TIRE FOR RETURN TO HANKOOK. THREE WEEKS HAVE PASSED AND I HAVE NOT HEARD BACK FROM FORD OR HANKOOK. *TR
Power train, Dec 23, 2014
STARTED TO ACCELERATE OUT OF A PARKING LOT AND HEARD A LOUD THUMPING SO I PULLED OVER GOT OUT LOOKED AT THE DRIVESHAFT SEEN IT HAD SLID BACK. A BIT OUT OF THE TRANSMISSION ALSO OUT OF THE CARRIER BEARING. *TR
Power train, Dec 17, 2014
GEAR SLIPPED OUT OF PARK AS I WAS EXITING VEHICLE. I HAD NOT YET CLOSED THE DOOR AND THE TRUCK BEGAN TO MOVE DOWN THE DRIVEWAY. I WAS CAUGHT BY THE DOOR AND DRAGGED ALONG UNTIL THE DOOR THREW ME TO THE GROUND, INJURING MY BACK. THE TRUCK CAME TO REST ON BOTH OF MY LEGS. I WAS ABLE TO PULL OUT MY LEFT LEG EASILY RESULTING IN JUST A FEW CUTS, SCRAPES AND PARTIAL BLACK AND BLUE SPOTS. WOUNDS ALL HEELED THEMSELVES. HOWEVER MY RIGHT WAS THOROUGHLY PINNED AND I HAD TO PULL LONG AND HARD TO REMOVE IT FROM UNDER THE TIRE RESULTING IN LOST FLESH AT MY ANKLE BONE TO RIGHT BELOW MY KNEE AND ABOUT 4 TO 5 INCHES WIDE. *TR
Engine, Dec 5, 2014
DRIVING ON A POSTED 40 MPH COUNTY ROAD APPROACHING A STOP SIGN. THE VEHICLE MADE A LOUD NOISE FROM THE ENGINE COMPARTMENT AND LOST 80% POWER. TOOK IT TO A LOCAL MECHANIC AND THEY EXPLAINED THAT THE SPARK PLUG(S) WERE BAD AND THE TUNE UP WOULD BE $500-$800 DEPENDING ON "IF" ONE OR ALL OF THEM BROKE DURING REMOVAL. ONE HAD ALREADY BLOWN OUT DURING AFOREMENTIONED INCIDENT. I UNDERSTAND THAT THIS WAS A PROBLEM FOR A LOT OF FORD VEHICLES DURING THE YEARS 2004 THRU 2008. I BELIEVE THIS SHOULD HAVE BEEN A RECALL REPAIR. THANK YOU. *TR
Structure, Engine, Nov 4, 2014
WATER LEAKING FROM INTAKE MANIFOLD COOLANT CROSSOVER LINE. CROSSOVER IS AN ALUMINUM PIPE THAT CONNECTS TO THE PLASTIC INTAKE MANIFOLD. WHEN MANIFOLD STARTED LEAKING COOLANT, 1 & 2 SPARK PLUG HOLES FILLED WITH WATER CAUSING SPARK PLUGS TO SHORT OUT AND STALL THE ENGINE AT LOW SPEED. PER FORD THE ONLY REPAIR IS REPLACEMENT OF THE COMPLETE INTAKE MANIFOLD AT A COST OF OVER $1200.00. THIS IS A COMMON PROBLEM WITH THIS ENGINE. I HAVE SEEN MANY COMPLAINTS ON F-150 FORUMS VIA THE INTERNET OF PEOPLE HAVING THE SAME PROBLEM. MY TRUCK HAS ONLY 105000 MILES ON IT. *TR
Engine, Nov 3, 2014
ON OCTOBER 31 2014 WHILE VISITING FAMILY AFTER 350 MILE DRIVE MY 2007 FORD F-150 XLT SUPER CAB 4X4 4.6L MOTOR MADE A NOISE SIMILAR TO AN EXPLOSION THAT WAS FELT IN THE CAB BY ALL PASSENGERS. RIGHT AFTER THE EXPLOSION THE TRUCK LOST POWER AND SOUNDED LIKE AN EXHAUST PIPE HAD FALLEN OFF THE MOTOR. THERE WAS A STRONG SMELL OF GAS AND EXHAUST BUT TRUCK WAS DRIVABLE. BROUGHT TRUCK TO DEALERSHIP AND WAS TOLD THAT 2 SPARK PLUGS HAS BLOWN OUT AND ONE OF THE TWO HAD TAKEN THE THREADS WITH IT. ADVISED ME THAT THIS WAS VERY RARE AND I HAD TO OPTIONS TO FIX. ONE WAS TO RE-THREAD AND REPLACE ALL SPARK PLUGS FOR $899. SECOND WAS TO REPLACE HEAD AT $2100. TOLD DEALERSHIP TO DO THE LESSER OPTION. HAD TO LEAVE TRUCK THERE AND OBTAIN A ONE WAY RENTAL FOR 5 PEOPLE AT $300. HAVE NOW FOUND OUT THAT ITS NOT RARE AND MAY NOT BE FIXED EVEN AFTER THE REPAIR. I AM GLAD THAT THIS HAPPENED ON A SURFACE ROAD AT LOW SPEED AND NOT ON THE HWY. *TR
Steering, Oct 27, 2014
I HAD THE PUMP, RACK AND PINION REPLACED AND THE SENSOR. AFTER ALL THIS WAS REPLACED SOME TIME LATER THE STEERING GOT TIGHT . I TOOK IT BACK THE MECHANIC THOUGHT I HAD ANOTHER PROBLEM. HE SPRAYED A LUBRICANT ON BOTH UNIVERSALS ON THE STEERING SHAFT. WHEN IT GETS TIGHT AGAIN I WILL GO AND SATURATE THESE TWO UNIVERSALS WITH A SPRAY LUBRICANT. *TR
Engine, Oct 19, 2014
COOL WET MORNING (65F) BUT NOT RAINING AT THE TIME. DROVE DOWN HILL TO STOP SIGN AT 35MPH. AFTER SLOWING TO ABOUT 5MPH, TRUCK SUDDENLY SURGED DESPITE BRAKING HARD ENOUGH TO ENGAGE ANTILOCK BRAKES DRAGGING THE TRUCK INTO THE INTERSECTION. LESS THAN A MILE LATER, STILL GOING DOWN HILL AT 25MPH SLOWED FOR ANOTHER STOP SIGN. ENGINE SURGED AGAIN TO 3000RPM. DRAG INTO INTERSECTION WAS AVOIDED BY SHIFTING TO NEUTRAL. SURGE DROPPED SPONTANEOUSLY WITHIN 10 SECONDS. *TR
Steering, Oct 15, 2014
NOTED POWER STEERING FLUID LEAKAGE OVER PERIOD OF TIME. EVENTUALLY FLUID COMPLETELY LEAKED OUT. FORD GARAGE TOLD ME THAT STEERING RACK AND HOSES NEEDED REPLACED DUE TO EXTENSIVE CORROSION FROM SLURRY USED ON ROADS IN OHIO. WAS TOLD NO PREVENTIVE MEASURES WOULD HAVE AVOIDED THE PROBLEM WHICH WAS INEVITABLE. REPAIR COSTS WERE 1900 DOLLARS. COMPLAINT IS THAT I CONTEND THAT INFERIOR MATERIALS WERE USED FOR LINES. THIS IS A 7 Y/O VEHICLE AND SHOULD NOT HAVE CORRODED IN VITAL AREA SUCH AS STEERING. COULD HAVE HAD SERIOUS CONSEQUENCES UNDER HIGH SPEED DRIVING. WOULD SUSPECT THAT UNREPORTED INCIDENTS HAVE OCCURRED. *TR
Fuel/propulsion system, Oct 13, 2014
THE FUEL PUMP DRIVER MODULE DESIGN IS TERRIBLE ON THESE TRUCKS. LUCK FOR MY FAMILY WE WERE IN TOWN GOING SLOW WHEN THIS UNIT SHORTED OUT. IF WE WOULD HAVE BEEN AT HIGHWAY SPEEDS WHO KNOWS WHAT COULD HAVE HAPPENED. THIS COULD HAVE BEEN A VERY GRAVE AND DANGEROUS SITUATION. FROM READING ON THE INTERNET THERE IS A SERIOUS PROBLEM WITH THIS PART. *TR
Engine, Oct 2, 2014
BLEW #2 SPARK PLUG AND COIL OUT OF HEAD. *TR
Air bags, Sep 28, 2014, crash
SON WAS IN AN ACCIDENT, ON THE FREEWAY, TRUCK WAS HIT FRONTEND MAJOR DAMAGE FRONTEND WAS "V" SHAPE IN ACCIDENT TO INCLUDE BOTH SIDES AND THROWN APPROX: 200+ ONE OF THE AIRBAG SENSORS IN LOCATED AT RADIATOR AIRBAGS DID NOT DEPLOY, FORD SAID THERE WAS A WARNING PRIOR TO ACCIDENT WHICH IS NOT TRUE IF THERE WAS A FLASHING FAULT LIGHT GOING OFF I ASSURED THEM I WOULD OF HAVE TAKEN VEHICLE TO DEALERSHIP ASAP. *TR
Air bags, Sep 28, 2014
ON 9-26-14 THE AIRBAG LIGHT CAME ON THEN WENT OFF AFTER 10-15 MINUTES. I DROVE THE VEHICLE APPROXIMATELY 10 MILES ON 9-26. AT 1PM ON 9-27 I STARTED THE TRUCK AND WITHIN 5-10 SECONDS THE AIRBAG EXPLODED. THE VEHICLE WAS STILL IN PARK AS I WAS OPENING MAIL BEFORE LEAVING. I WAS NOT SERIOUSLY INJURED BUT HAD A SORE RIGHT SHOULDER MOST OF THE DAY. FORD IS TELLING ME I HAVE TO PAY FOR A NEW AIRBAG AS THEY ARE ONLY GUARANTEED FOR 5 YEARS. MY TRUCK HAS NEVER BEEN IN AN ACCIDENT, PURCHASED IT NEW IN 2007 AND IT JUST TURNED 41000. THIS IS A MAJOR HAZARD AS I HAD NO WARNING OF DEPLOYMENT, ONLY MY AIRBAG LIGHT WENT ON. I TOLD FORD OF I HAD TO PAY FOR THE AIRBAG THEN I WANTED ALL PARTS REMOVED. FORD IS GOING TO CALL ME ON 9-29-30. *TR
Engine and engine cooling, Power train, Sep 28, 2014
NOTICED LEAKAGE UNDER FRONT LEFT TIRE. ALL TRANSMISSION FLUID HAD LEAKED OUT. TRANSMISSION OIL LINE RUSTED THROUGH. HAD PREVIOUS LEAKAGE WHICH I REPAIRED WITH A PIECE OF HIGH PRESSURE LINE. CHECKED METAL LINES OF TRANSMISSION OIL COOLING SYSTEM AND FOUND NUMEROUS AREAS RUSTED OUT AND READY TO BURST. HAD TRUCK TOWED TO DEALER TO REPLACE COOLING SYSTEM LINES. WAS TOLD CORROSION IS A COMMON PROBLEM WITH THE LINES ON F150. CAN'T UNDERSTAND WHY IF THIS IS A COMMON PROBLEM FORD DOES NOT NOTIFY OWNERS ABOUT POSSIBLE PREVENTIVE ACTION TO DEAL WITH THE CORROSION OR USE NON-CORROSION MATERIALS FOR PRESSURE LINES. *TR
Steering, Sep 22, 2014
I WAS JUST LEAVING A BUSINESS. AS I WAS PULLING OUT OF THE PARKING LOT MY STEERING HAD GOTTEN VERY STIFF AND WOULD NOT GO BACK TO CENTER AFTER TURNING A CORNER. IT WAS A LITTLE SCARY BECAUSE I HAD 50 MILES TO DRIVE AND GET BACK HOME. OUT OF THE BLUE THIS HAPPENED. I HAVE HAD NO PROBLEM BEFORE THIS!!! *TR
Suspension, Sep 17, 2014
TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT NOTICED THAT THE FRONT PASSENGER COIL SPRING FRACTURED. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 109,000.
Steering, Sep 16, 2014
WHILE TRAVELING FROM NYS TO NJ, I NOTICED THAT IT BECAME HARDER TO STEER THE TRUCK AS THE TRIP PROGRESSED. WHILE ON 80E IN NJ IT BECAME SO SEVERE THAT TO CHANGE LANES AND TAKE AN OFF RAMP TOOK ALL THE STRENGTH I COULD MUSTER. I KNEW IT WASN'T MY POWER STEERING PUMP BECAUSE I CONTINUED TO LOSE RANGE OF STEERING MOTION IN THE STEERING WHEEL. I LIMPED THE TRUCK TO A GAS STATION IN DENVILLE NJ. FLUID LEVEL WAS OK, BELT WAS GOOD AND TURNING PROPERLY ON THE PS PULLEY. I NOTICED THE TWO UNIVERSAL JOINTS ON THE STEERING SHAFT LOOKED CORRODED SO ON A HUNCH I POURED SOME MOTOR OIL ON BOTH U-JOINTS. THAT FIXED THE PROBLEM AND GOT ME OUT OF A VERY DANGEROUS SITUATION. SOMEBODY IS GOING TO GET KILLED BECAUSE THEIR STEERING IS GOING TO LOCK UP DUE TO THOSE U-JOINTS AND THEY WON'T BE ABLE TO STEER OUT OF A BAD SITUATION. *TR